Moffat turbofan 300 User's Manual
Contents
1. TECHNICAL SPECIFICATIONS TURBOFAN 300 Electio Specification Information Model No DEL300CX Power 3P N E 400 415 volt 50 Hz 95kW heating 90kW motors 5kW Connections 1 4 BSP water and 1 2 BSP copper drain located at rear of oven Dimensions Width 2515mm Depth 2180mm includes canopy 1830mm no canopy Height 2700mm includes canopy Weight 1300kg Installation Information Client to provide the following connections Oven requires direct wiring from switchboard Water connection 1 4 BSP Drainage connection 1 2 required from drain pipe Oven supply does not include canopies and flues as required by relevant authorities Bends or offsets in the flue restrict gas velocity and must be allowed for when designing the flue height and diameter which will be dependent on the building and local conditions A flue connection is required and is not included in the contract Exhaust flue 200mm in diam canopy models 100mm non canopy models Clearance 50mm clearance is required at back and sides of unit 2695mm clearance required back to front of oven with door open Minimum 2900mm ceiling height Floor A concrete or tile surface is preferred The floor area is to be flat to within 3mm over whole floor area Access Oven is supplied partially assembled to be fully erected on site Largest piece if unassembled 2140mm H x 1680mm W x 750mm D In line with policy to continually develop and improve its products M2. ied t AT REAR OF OVEN SIDE ELEVATION 2140 high x 1680 wide x 750 long OVEN FLUES 7 Fan duct from extraction fan in oven SUPPLY WATER FLOW JETS canopy to be taksn to atmosphere 200mm diameter SUPPLY WATER S N CONNECTION SSSH Flues from aven to atmosphere RACK LIFT MOTOR 0 37KW Nol inehided In contract GEARBOX 20 1 ms ote RAGI DRIVE MOTOR SEK Bands or offsets in the tlue restrict gas velocity and must be allowed for BCA FAN when designing the flue height and TORQUE LIMITER diameter which will be depandent on UE LIMITE the building and local conditions RACK LIFT MICROSWITCH RACK STOP PROXIMITY i ELECTRICAL REQUIREMENTS SWITCH 3 Phase Earth and Neutral 400 415V 50Hz gt FAN MOTOR 037kW i A The approximate total kilowatt loading is Motors 3 92kW lt S Heating Elements 90kW ELECTRICAL ENTRY POINTS CLEARANCE EXTRACTION FAN SECTION OVERPRESSURE 50mm clearance ts required at back PEI aa a VENT SS and sides ACTION y AND OVERPRESSURE FLUE CONNECTION EEA Repellers sk EQUIPMENT ACCESS DOOR FOR BAKE DOOR ARC PERFORMANCE 2 9957 3 03 03 1 gt 8 1 2003 REV CHANGE DATE f NOTES DATE 8 1 2003 FINISH NATURAL TOLERANCE 0 5mm USED ON DEL300MX DEL300Cx CHANGE No 9957 DATE 3 03 03 1ST ANGLE PROJ KAOLE umrrep mme SPEC DETAILS DEL300Mx DEL300CX revno 2 pwen B25260 WS Z lt O sa aW
3. offat reserves the right to change specifications and design without notice Australia New Zealand Moffat Pty Limited Moffat Limited Free Call 1800 023 953 CIl ZL Free Call 0800 663 328 email vsales moffat com au aner silat email sales moffat co nz www moffat com au duinn aia ae www moffat co nz DEL300CX 0403V1 DEL300CX 0403V1 UU NUI SUALE IF IN VUUS I ASK New Zealand Moffat Limited Free Call 0800 663 328 email sales moffat co nz www moffat co nz FLUES Flues from oven to atmosphere not VENT CONTROL HANDLE included in contract SHOWN IN SHUT POSITION MANUAL OPTION ONLY z FLOOR 3 A concrete or tiie surface is prefered ELECTRICAL ENTRY POINTS The floor area is to be flat to within Imm over the whole oven area WATER SUPPLY TO STEAM GENERATOR Pressure 1 0 5 5bar 15 80psi Connection 4 BSP Mains water will not require regulating Water volume can be varied by altering jet size ELECTRICAL GEAR PLATE EQUIPMENT ACCESS DOOR DOOR CATCH MICROSWITCH INTERNAL DOOR SAFETY RELEASE LEVER DRAINAGE Client to provide drain pipe from steam generator to suitable receptacle or pipe te drain 2700 MAXIMUM ASSEMBLED HEIGHT 2300 MIN CEILING HEIGHT 1920 DOOR HEIGHT FROM FLOOR 1820 MAX RACK HEIGHT ACCESS INTO BAKERY Oven can be dispatched fully assembled to dimensions shown or in subassemblies t ii lents bak DRAIN WATER CONNECTION ee NANA poset nikasonit
4. re lt Z an O sa a In line with policy to continually develop and improve its products Moffat reserves the right to change specifications and design without notice Free Call 1800 023 953 email vsales moffat com au Moffat Pty Limited www moffat com au Australia
Download Pdf Manuals
Related Search