Lifetime 125 User's Manual
Contents
1. Kit w hardware 5 pack Five 30 x 14 Shelves with hardware 6426 60 Shed Extension Kit w 2 windows Extend your shed five feet for the ultimate storage building To purchase shed accessories visit us at www buylifetime com Or call 1 800 424 3865 Congratulations on your Lifetime Outdoor Shed purchase By following the instructions below your new Lifetime shed should provide you with years of service and enjoyment Cleaning and Care The polyethylene walls and shelves are stain and solvent resistant To clean use a mild soap and a soft bristled brush Abrasive cleaning materials may scratch the plastic and are not recommended Repair scratches or rust spots on the metal by Sanding the affected area lightly using a rust preventative spray primer and finally spraying with a high gloss spray enamel paint Avoid placing a direct heat source on or near surfaces unless using a heat barrier For warranty details or to register your product visit www lifetime com or call 801 776 1532 112. Strips AM Center Gutter Connector FD and two Gutter Channels AB Refer to the Owner s Manual that came with your shed when assembling other truss frames AM AM FB Cm gy Crn l i a j e a AB P Finger Tighten Hardware Do not overtighten the Cap Nut If the end of the Bolt breaks through the plastic cap call our Customer Service Department at the number on Page One Exposed threads on the end of the Bolt may cause serious injuries t 4 ao 7 Lg H hy Ay j y i f F g i AA S A KY i yy i af fy tg i A HN 7 os Z A iy A H 1 rA Z A rf Z 1 D K pej A y I G yi PA A y By GY H l YY H g A A iy Sy 4 ae Oy 7i i I nf F A A yf P R ff j 4 i 1 Of 1 AM Opt 2 11 Attach a Gutter Channel AB Truss Support Strips AM fit inside Gutter Channel AB Attach Truss Channel AD to Gutter Channel AB at each end Tighten All Hardware Opt 2 12 Attach Truss Assembly to two Wall Support Channels AC Do not completely tighten the Cap Nut FC until after truss is secured to the wall Use Second Holes from the end Opt 2 13 Replace the two Wall Panels that were previously removed Add the two new Wall Panels that came with this kit Note As new panel slides into place be sure that screw bosses along the sides interlock properly with the adjoining Wall Panels 1 Set Wall Panel Tabs into Floor Panel Slots 2 Slide Wall Panel to the left
3. ees TPES YA y i ways Eee a f i a ae a7 lit B BEFA d a A y E Opt 2 3 Tip the Wall Panel inward Note To remove a Wall Panel slide it to the left when looking at it from inside the shed until it lifts out Opt 2 4 Use a long flat screwdriver to gently pry the bottom corner of the Wall Panel so that it has room to slide on the inside of other Wall Panels Slide the Wall Panel to the left and then remove the panel Note As you remove the Wall Panels have one person support the Truss assembly so that it does not fall over Opt 2 5 Remove the Truss assembly and set it aside for later WY j A A as See PZS STOLE Ha VURA LOER Lf i SOQ Ke VL Opt 2 6 With at least on person on each side of the shed tip the back section of the shed forward to about a 45 degree angle and slide the back section away from the shed Opt 2 7 Fit together the two Inner Floor Panel extensions AJ Opt 2 8 Connect the Inner Floor Panel extensions AJ to the other Inner Floor Panels on the main section of the shed Ss as oi Opt 2 9 With at least on person on each side of the shed tip the back section of the shed forward to about a 45 degree angle and slide it forward to re connect it to the rest of the shed Opt 2 10 Fit two Truss Support Strips AM together Bolt Truss Support
4. of your shed Before beginning expansion of your shed be sure that your site can accomodate the new size Option 2 Add Extension Kit to an Existing Shed Save all hardware for re assembly ATTENTION If your existing shed is anchored to the ground remove all anchoring hardware before following these steps Opt 2 1 Remove the four Lower Roof Panels and two Center Roof Caps leave Skylights in place that are highlighted below CFSE OK Ps x ZAPO LLLA ees LOS bie of ate LMLIO EE SSS Sok LT OS AA PELL Se LEI RI LE SLI C SRM edie LT ory pe v Ce BREE TS LILI SOL BES Sz LEE Sia eee eg Vd xX IR X XD SON Wt i OAN SS j N Ss 4e S X ee ET i SS SOX SONS X x Note Your shed may be shorter than shown above Skip the very back Roof Panels slightly more nar row than the middle Roof Panels and then remove the next two Roof Panels from each side of the shed along with the connected Roof Caps Repeat Steps 2 2 through 2 4 for both sides of the shed Opt 2 2 Remove all screws from the highlighted Wall Panel that connect it to adjoing Wall Panels and to the Wall Support can Pane SS Remove this panel RA Sany TPES A iil is i s ey re ay ce i i j l LEED SD TA ICL fh os ERRAK MELA EEE KAN
5. until the Wall Panel locks into place 3 Use a Rubber Mallet to nudge the panel into position Be careful not to damage the edge of the wall panel Opt 2 14 Replace the Truss assembly that was previously removed Add the new Truss assembly from steps 2 9 to 2 11 10 Opt 2 15 Replace the four Lower Roof Panels that were previously removed Add the two new Lower Roof Panels that came with this kit 3 FSS LAL IPIK GAT Pee AII ODA a AR EO EE oL De CL A AOA 2 T T OEA LLLI II a SRA LK fe S79 LES A LISD See LZZ 0 Lh C Z ey Yi ogy Oe CAGE Lon A hel Ps aig j pe Only use a hand screwdriver for the Skylights 2 a Attach Skylight with 10 Washers LA and 10 x 5 8 Screws LB Opt 2 17 Install both Center Roof Caps with Skylights onto the shed li gt Attach Roof Cap AA to Truss on both sides with 1 4 x 5 8 Screws SS Enhance your Lifetime Outdoor Shed by purchasing the following Shed Accessories Model 0111 Window Shutters Two decorative window shutters 0112 Shed Lights 2 pack Two battery powered Touch Lights 0113 16 Pegboard Strips w hardware Two sixteen inch Pegboard Strips with hooks Great for hanging large items such as rakes shovels or other tools 0114 10 Shelf Kit w hardware 5 pack Five 30 x 10 Shelves with hardware 0115 14 Shelf
6. 4 05 2007 LIFETIME jf VISIT THE LIFETIME WEB SITE WWW LIFETIME COM Do Not Contact the Store For Assistance including missing or broken Call Customer Service at 1 800 225 3865 30 Shed Extension Kit for 11 Shee ss ON VAN N W4 RN ASSEMBLY INSTRUCTIONS AND OWNER a Ze LESES Aa Pa lt gt oe o gt PCIE OIC OO Cigtatatete tatoo So y JZ CP r gt Lgtatetetetet sil ole AA N LE eS OT vi ae Eo E OEN i P RO tree d E es ry ot ee ey ee a 5 Save this instruction in the event you must contact the manufacturer for replacement parts INSTRUCTION 1026972 A MINIMUM OF TWO ADULTS ARE REQUIRED FOR ASSEMBLY amp BEFORE BEGINNING ASSEMBLY sro Identify and inventory all parts using the checklist boxes on the Parts List Keep the hardware bags and their contents separate If any parts are missing call our Customer service Department AN SAFETY INSTRUCTIONS A N Failure to follow these safety instructions may result in serious injury or property damage Proper and complete assembly use and supervision is essential for proper operation and to reduce the risk of accident or injury A high probability of serious injury exists if this display is not installed maintained or operated properly If using a ladder during assembly use extreme caution Follow all warnings and cautions on the ladder ca
7. refully e 2 people are required for assembly e Misuse could result in system failure If technical assistance is required contact the manufacturer Most injuries are caused by misuse and or failure to follow instructions PARTS LIST AA 1020443 Center Roof Cap AB 1019503 Gutter Channel AC 1007977 Wall Support Channel AD 1007988 Truss Channel AE 1007996 Inner Roof Panel AF 1007997 Wall Panel AG 1009232 Skylight AJ 1008000 Inner Floor Panel AK 1008001 Roof Support Strip AM 1020423 Truss Support Strip Shed Parts Box 1019238 Skylight Hardware Bag 1011616 1 LA BW01200 10 1 Fender Washer LB 1010132 10 x 5 8 Pan Head Screw 7 Truss Extension Hardware Bag 1016014 1 FA 1009117 Floor Bracket 2 FB 300072 1 x 1 1 2 Hex Bolt 11 FC BNO00300 1 4 Cap Nut 1 FD 1012933 Center Gutter Connector 1 Shed Screw Hardware Bag 1011615 SS BS07500 1 x 5 8 Screw 60 OBNOFRPNONFNN Tools and Materials Required for Assembly Not Included 7 16 Wrenches 2 3 8 Wrenches 2 2 Phillips screwdriver or Electric drill with phillips head HARDWARE IS NOT ACTUAL SIZE unless otherwise indicated AF If you are Extending an New Shed 1 To obtain instructions for extending a new shed contact our Customer Service Department To extend a never assembled shed Call Customer Service for Instructions 1 800 225 3865 Site Selection a This extension kit adds another 30 to the length
Download Pdf Manuals
Related Search