Lenovo 41X8111 User's Manual
Contents
1. 16 Locating components 3 Trademarks 16 Identifying parts on the system board 4 Lenovo 2005 2007 Portions IBM Corp 2005 ili iv Hardware Replacement Guide Overview This guide is intended to be used by customers who are replacing Customer Replaceable Units CRUs In this document CRUs will be referred to as parts This guide does not include procedures for all parts It is expected that cables switches and certain mechanical parts can be replaced by trained service personnel without the need for step by step procedures This guide contains instructions for replacing the following parts Note Use only the parts provided by Lenovo e Memory module e PCI adapter card e Keyboard e Mouse Safety information Do not open your computer or attempt any repair before reading the Important safety information in the Safety and Warranty Guide that was included with your computer To obtain a copy of the Safety and Warranty Guide go to the World Wide Web at http www lenovo com support Additional information resources If you have Internet access the most up to date information for your computer is available from the World Wide Web You can find the following information e CRU removal and installation instructions e CRU removal and installation videos e Publications e Troubleshooting information e Parts information e Downloads and drivers e Links to other useful s2. wa IE Co AA E7 HI dm Microprocessor fan connector 11 Microprocessor and heat sink 12 Memory connector 1 Memory connector 2 Clear CMOS Recovery jumper l Power connector Diskette drive connector IDE connector 1 IDE connector 2 Battery i Lam LQ efe wfo Se rej Ki ayo N Front panel connector SATA IDE connectors 2 Front USB connectors 2 Serial COM connector PCI adapter connectors Front audio connector PCI Express x16 graphics adapter connector PCI Express x1 adapter connector System fan connector 12v power connector The following illustration shows the locations of parts on the system board for some computer models Bee NOGECEE 1 J L lata FG 115 mes Ta N i Microprocessor and heat sink Microprocessor fan connector Memorv connector 1 Memorv connector 2 Power connector Diskette drive connector IDE connector SATA IDE connectors 2 Front panel connector
3. 1 Ensure that all components have been reassembled correctly and that no tools or loose screws are left inside your computer 2 Reposition any cables that might impede the replacement of the cover 12 Hardware Replacement Guide 3 Position the computer cover on the chassis so that the rail guides on the bottom of the cover engage the rails and push the cover to the closed position Install the two screws that secure the computer cover 4 Install any locking devices such as a padlock as necessary 5 Reconnect the external cables and power cords to the computer See the connectors on the rear of your computer on page 2 6 To update the configuration see Using the Setup Utility in the User Guide that was included with your computer Note In most areas of the world Lenovo reguires the return of the defective CRU Information about this will come with the CRU or will come a few days after the CRU arrives Chapter 2 Replacing hardware 13 14 Hardware Replacement Guide Appendix Notices Lenovo may not offer the products services or features discussed in this document in all countries Consult your local Lenovo representative for information on the products and services currently available in your area Any reference to a Lenovo product program or service is not intended to state or imply that only that Lenovo product program or service may be used Any functionally egui
4. Disconnect the failing kevboard cable from the computer 5 Connect the new kevboard to the appropriate connector on the computer 6 Go to Completing the parts replacement on page 12 Replacing a mouse Attention Do not open your computer or attempt any repair before reading the Important safety information in the Safety and Warranty Guide that was included with your computer To obtain copies of the Safety and Warranty Guide go to http www lenovo com support This section provides instructions on how to replace a mouse 1 Remove any media diskettes CDs or tapes from the drives shut down your operating system and turn off all attached devices 2 Unplug all power cords from electrical outlets Chapter 2 Replacing hardware 11 3 Locate the mouse connector Note Your mouse might be connected to a standard mouse connector E or a USB connector BA in the front or rear of your computer See or 4 Disconnect the failing mouse cable from the computer 5 Connect the new mouse to the appropriate connector on the computer 6 Go to Completing the parts replacement Completing the parts replacement After working with parts you need to replace the computer cover and reconnect any cables including telephone lines and power cords Also depending on the part that was replaced you might need to confirm the updated information in the Setup Utility program
5. Clear CMOS Recoverv jumper Pie Le Gal eed La i II LQ wo oo uti rei KI Fe e dej Lan mom a Front USB connectors 2 Serial COM connector Front audio connector PCI adapter connectors 2 PCI Express x1 adapter connector Battery PCI Express x16 graphics adapter connector System fan connector 12v power connector Chapter 1 Locations 5 6 Hardware Replacement Guide Chapter 2 Replacing hardware Attention Do not open your computer or attempt any repair before reading the Important safety information in the Safety and Warranty Guide that was included with your computer To obtain copies of the Safety and Warranty Guide go to http www lenovo com support Note Use only the parts provided by Lenovo Removing the cover Important AN Turn off the computer and wait 3 to 5 minutes to let the computer cool before opening the computer cover To remove the computer cover do the following 1 Shut down vour operating svstem remove anv media diskettes CDs or tapes from the drives and turn off all attached devices and the computer 2 Unplug all power cords from electrical outlets 3 Disconnect all cables attached to the computer This includes power cords input output I O cables and any other cables that are connected to the computer Lenovo 2005 2007 Portions IBM Corp 2005 7 4 Remove the two screws at the rear of the left side cover and slide the cov
6. verify the applicable data for their specific environment Television output notice The following notice applies to models that have the factory installed television output feature This product incorporates copyright protection technology that is protected by method claims of certain U S patents and other intellectual property rights owned by Macrovision Corporation and other rights owners Use of this copyright protection technology must be authorized by Macrovision Corporation and is intended for home and other limited viewing uses only unless otherwise authorized by Macrovision Corporation Reverse engineering or disassembly is prohibited Trademarks Lenovo and the Lenovo logo are trademarks of Lenovo in the United States other countries or both IBM is a trademark of the International Business Machines Corporation in the United States other countries or both Other company product or service names may be trademarks or service marks of others 16 Hardware Replacement Guide lenovo Part Number 41X8111 Printed in USA 1P P N 41X8111
7. cations where malfunction may result in injury or death to persons The information contained in this document does not affect or change Lenovo product specifications or warranties Nothing in this document shall operate as an express or implied license or indemnity under the intellectual property rights of Lenovo or third parties All information contained in this document was obtained in specific environments and is presented as an illustration The result obtained in other operating environments may vary Lenovo may use or distribute any of the information you supply in any way it believes appropriate without incurring any obligation to you Any references in this publication to non Lenovo Web sites are provided for convenience only and do not in any manner serve as an endorsement of those Web sites The materials at those Web sites are not part of the materials for this Lenovo product and use of those Web sites is at your own risk Any performance data contained herein was determined in a controlled environment Therefore the result obtained in other operating environments may Lenovo 2005 2007 Portions IBM Corp 2005 15 vary significantly Some measurements may have been made on development level systems and there is no guarantee that these measurements will be the same on generally available systems Furthermore some measurements may have been estimated through extrapolation Actual results may vary Users of this document should
8. er to the rear to remove Replacing a memory module Attention Do not open your computer or attempt any repair before reading the Important safety information in the Safety and Warranty Guide that was included with your computer To obtain copies of the Safety and Warranty Guide go to http www lenovo com support This section provides instructions on how to replace a memory module Note Your computer has support for two memory modules 1 Remove the computer cover Seef Removing the cover on page 7 8 Hardware Replacement Guide 2 Remove the memory module being replaced by opening the retaining clips as shown 3 Position the replacement memory module over the memory connector Make sure that the notch Bi on the memory module aligns correctly with the connector key J on the system board Push the memory module straight down into the memory connector until the retaining clips close 4 Go to Completing the parts replacement on page 12 Replacing a PCI adapter Attention Do not open your computer or attempt any repair before reading the Important safety information in the Safety and Warranty Guide that was included with your computer To obtain copies of the Safety and Warranty Guide go to http www lenovo com support Chapter 2 Replacing hardware 9 This section provides instructions on how to re
9. lenovo Hardware Replacement Guide Lenovo 3000 J Series Types 7387 7388 7389 7393 7394 7395 lenovo Lenovo 3000 J Series Second Edition February 2007 Copyright Lenovo 2005 2007 Portions O Copyright International Business Machines Corporation 2005 All rights reserved U S GOVERNMENT USERS RESTRICTED RIGHTS Our products and or services are provided with RESTRICTED RIGHTS Use duplication or disclosure by the Government is subject to the GSA ADP Schedule contract with Lenovo Group Limited if any or the standard terms of this commercial license or if the agency is unable to accept this Program under these terms then we provide this Program under the provisions set forth in Commercial Computer Software Restricted Rights at FAR 52 227 19 when applicable or under Rights in Data General FAR 52 227 14 Alternate III Contents Overview v Chapter 2 Replacing hardware 7 Safety information MA V Removing the cover Z Additional information resources Me Replacing a memory module e e ei O Tools required l V Replacing a PCI adapter LP fe EL ea ZA Handling static sensitive devices V Replacing a keyboard a Replacing amouse ia s Ze 4 Il Chapter 1 Locations 1 Completing the parts replacement aos s a v Locating the connectors on the front of your computer col Appendix Notices 15 Locating the connectors on the rear of your computer 2 Television output notice
10. or USB connectors H H al od faqa laqa Lv m o poj Kari ej IT gt Ethernet connector USB connectors Microphone connector Audio line out connector Audio line in connector PCI Express x1 adapter or PCI Express x16 adapter connector some models PCI Express x1 adapter or PCI Express x16 adapter connector some models PCI adapter connectors Locating components The following illustration will help you locate the various components in your computer Microprocessor and heat sink H PCI adapter connectors A Memory modules g PCI adapter PCI Express x1 adapter or PCI Express Power supply assembly x16 graphics adapter connector some models PCI Express x16 graphics adapter or PCI Express x1 adapter connector some models Chapter 1 Locations 3 Identifying parts on the system board The system board sometimes called the planar or motherboard is the main circuit board in your computer It provides basic computer functions and supports a variety of devices The following illustration shows the locations of parts on the system board for some computer models BIS BNOBBBBMDB 4 Hardware Replacement Guide a
11. ources of information e Support phone list To access this information point your browser to http www lenovo com support Tools required To replace some parts in your computer you might need a flat blade or Phillips screwdriver Additional tools might be needed for certain parts Handling static sensitive devices Static electricity although harmless to you can seriously damage computer components and parts Lenovo 2005 2007 Portions IBM Corp 2005 V vi When replacing a part do not open the static protective package containing the new part until the defective part has been removed from the computer and you are ready to install the new part When you handle parts and other computer components take these precautions to avoid static electricity damage Limit your movement Movement can cause static electricity to build up around you Always handle parts and other computer components carefully Handle adapters memory modules system boards and microprocessors by the edges Never touch any exposed circuitry Prevent others from touching the parts and other computer components Before you replace a new part touch the static protective package containing the part to a metal expansion slot cover or other unpainted metal surface on the computer for at least two seconds This reduces static electricity in the package and your body When possible remove the new part from the static protective packaging and in
12. place a PCI adapter 1 Remove the computer cover Seef Removing the cover on page 7 2 Remove the screw securing the adapter in the connector 3 Remove the adapter being replaced N Zp BE V 4 a 4 Remove the new adapter from its static protective package 5 Install the new adapter into the appropriate slot on the system board 6 Install the screw to secure the new adapter 7 Go tof Completing the parts replacement on page 12 10 Hardware Replacement Guide Replacing a keyboard Attention Do not open your computer or attempt any repair before reading the Important safety information in the Safety and Warranty Guide that was included with your computer To obtain copies of the Safety and Warranty Guide go to http www lenovo com support This section provides instructions on how to replace a keyboard 1 Remove any media diskettes CDs or tapes from the drives shut down your operating system and turn off all attached devices 2 Unplug all power cords from electrical outlets 3 Locate the keyboard connector Note Your keyboard might be connected to a standard keyboard connector or a USB connector BA Depending on where your keyboard is connected see Locating the connectors on the rear of your computer pag or Locating the connectors on the front of your computer on G if 4
13. stall it directly in the computer without setting the part down When this is not possible place the static protective package that the part came in ona smooth level surface and place the part on it Do not place the part on the computer cover or other metal surface Hardware Replacement Guide Chapter 1 Locations This chapter provides illustrations to help locate the various connectors controls and components of the computer To remove the computer cover see Removing the cover on page 7 Locating the connectors on the front of your computer The following illustration shows the location of connectors on the front of the computer mmm LLL LLL LULL UU Headphone connector USB connector Es Microphone connector 4 USB connector Lenovo 2005 2007 Portions IBM Corp 2005 1 Locating the connectors on the rear of your computer The following illustration shows the location of connectors on the rear of the computer A ET gp sise o Bi adi 10 tiri m7 8 3 12 S El mi Fa 16 pet SN QOEBGO NG 2 Hardware Replacement Guide Power connector Voltage selection switch some models Mouse connector Keyboard connector Serial connector Parallel connector VGA monitor connect
14. valent product program or service that does not infringe any Lenovo intellectual property right may be used instead However it is the user s responsibility to evaluate and verify the operation of any other product program Or service Lenovo may have patents or pending patent applications covering subject matter described in this document The furnishing of this document does not give you any license to these patents You can send license inguiries in writing to Lenovo United States Inc 500 Park Offices Drive Hwy 54 Research Triangle Park NC 27709 U S A Attention Lenovo Director of Licensing LENOVO GROUP LTD PROVIDES THIS PUBLICATION AS IS WITHOUT WARRANTY OF ANY KIND EITHER EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF NON INFRINGEMENT MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE Some jurisdictions do not allow disclaimer of express or implied warranties in certain transactions therefore this statement may not apply to you This information could include technical inaccuracies or typographical errors Changes are periodically made to the information herein these changes will be incorporated in new editions of the publication Lenovo may make improvements and or changes in the product s and or the program s described in this publication at any time without notice The products described in this document are not intended for use in implantation or other life support appli
Download Pdf Manuals
Related Search