Lanier CP- 341 User's Manual
Contents
1. Routes of Exposure Inhalation dermal contact incidental ingestion Inhalation Excessive inhalation may cause irritation of the nose throat and respiratory tract Eye Contact Not an irritant Dermal Contact Not an irritant not a sensitizer Ingestion None currently known Chronic effects Carcinogenicity See Section 11 Toxicological Information Reproductive Developmental None identified Target Organs Prolonged breathing of high concentrations may cause adverse effects on the respiratory system Signs and Symptoms of Exposure Prolonged exposure to dusts of this product may irritate the respiratory system Medical Conditions Aggravated by Exposure to this Product Respiratory disorders such as asthma may be aggravated by prolonged exposure to high concentrations of this product Section 4 First Aid Measures Remove to fresh air immediately Get medical In case of contact immediately flush eyes with Inhalation attention if needed Eye Contact water for 15 minutes Get medical attention if needed Dilute stomach contents with several glasses of water Get medical attention Skin Contact Wash with soap and water If irritation occurs or is persistent seek medical attention Section 5 Fire Fighting Measures Suitable extinguishing media CO dry chemical foam or water Ignition temperature gt 350 C Extinguishing media which may not be used for safety reasons none Ingestion This material will burn in case of fire The d2. avoid none Materials to avoid none Stability Stable Hazardous decomposition products CO and CO2 and other decomposition products when burned Section 11 Toxicological Information Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respiratory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation should be avoided May cause temporary eye discomfort Health Hazards of Long Term exposure Chronic A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level 1mg m the most relevant level to potential human exposures A very slight degree of fibrosis was noted in 25 of the animals at the middle exposure level 4mg m while a slight degree of fibrosis was observed at the highest exposure level 16mg m in all animals These findings are attributed to Lung Overloading a generic response to excessive amount of any dust retained in the lungs for a prolonged interval The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment Carbon Black is listed on the IARC Monograph and the Massachusetts Substance List The IARC has evaluated the evidence for the carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans This product contain
3. care has been taken in the preparation of this information Lanier Worldwide Inc extends no warranties makes no representations and assumes no responsibility as to the accuracy or suitability of such information for application to users intended purposes ao for consequences of its use All materials may present unknown hazards and should be used with caution Although certain hazards are described herein we do not guarantee that these are the only hazards that exist Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals
4. LANiER Lanier Worldwide Inc 2300 Parklake Dr N E Atlanta GA 30345 2979 Emergency Telephone 800 526 4371 MATERIAL SAFETY DATA SHEET Section 1 Chemical Product and Company Information Identity 5415 Toner MSDS No CP 341 Product ID 480 0047 Issued 12 01 00 Supersedes None Synonyms Date 12 01 00 amp Common Black Toner for Prepared by EH amp S Department 770 496 9500 Names Lanier 5415 Approved by Larry Choskey Manager CEH amp S European Contact Lanier Worldwide Inc Uses Lanier 5415 Digital Copier Walter Fricke Manager Safety amp Environment Chemical Im Taubental D 41468 Neuss Germany Formula Mixture 49 2131 387 177 Section 2 Composition Information on Ingredients PERCENT CAS No EXPOSURE LIMITS SOURCE Polyester resin gt 90 Trade secret Not listed N a Carbon black 1 5 1333 86 4 3 5mg m 3 5mg m OSHA PEL ACGIH TWA Polyolefin wax 1 5 Trade secret Not listed N a Organic pigment 1 5 Trade secret Not listed N a PEL as the product 15mg n total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification Emergency Overview Product is stable nonflammable powder If used as intended the product does not present an acute or chronic health hazard Physical Hazards This product is not classified as flammable or combustible It will burn in case of fire Avoid contact with strong oxidizers such as chromate bromate and nitrates
5. ecomposition products are CO COz and No Avoid inhalation of smoke Special protective equipment for fire fighters none UEL n a LEL n a MATERIAL SAFETY DATA SHEET Page 2 of CP 341 Section 6 Accidental Release Measures Spill leak Procedures If spilled sweep up using an approved toner vacuum with a 0 5 micron filter or smaller such as the Atrix AAA Toner Vacuum or 3M Toner Vacuum Use of a vacuum cleaner not rated for toner particles could result in a fire or personal injury Remove residue with soap and cold water Miscellaneous Keep product out of sewers and watercourses Personal protection Avoid inhalation of dust Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of workday Special Storage Avoid direct sunlight Keep out of reach of children Store in a cool dry place Section 8 Exposure Control and Personal Protection Information Respiratory Protection none required under normal use Hand Protection none required under normal use Eye Protection none required under normal use Skin Protection none required under normal use Section 9 Physical and Chemical Properties CHARACTERISTICS Appearance Black Melting point 110 C 150 C Form Powder Vapor pressure n a Odor Odorless Vapor density n a Solubility in Water Negligible Evaporation rate n a Specific gravity 1 1 1 5 Boiling point n a Section 10 Stability and Reactivity Conditions to
6. isted as chemicals known to the State of California to cause cancer or reproductive system effects Controlled Products Regulations Canada This product has been classified in accordance with the hazard criteria of the CPR Other State Regulations Carbon black is listed in the New Jersey Right to Know List Pennsylvania Hazardous Substance List and Massachusetts Substance List U S Canada Label Statements LOW HAZARD FOR RECOMMENDED HANDLING Minimize dust generation and accumulation Use with adequate ventilation EU Information Label Information According to Directives 67 548 EEC amp 88 379 EEC Symbol amp Indication Not required Risk Phrase Not required Safety Advise Phrase Not required EEC Directive 76 548 EEC 79 831 EEC 92 32 EEC All chemical substances in this product comply with all applicable rules or order under EEC Directive The Subject of Specific Provisions in Relation to Protection of Man or the Environment Directive 76 769 EEC Not required National requirement No specific regulations or restrictions Section 16 Miscellaneous Information National Fire Protection Association NFPA Rating FLAMMABILITY 0 HEALTH 0 REACTIVITY 0 Hazardous Materials Information System Rating HMIS FLAMMABILITY red 0 ACUTE EFFECTS blue 0 REACTIVITY yellow 0 Judgment as to the suitability of information contained herein for user s purposes is the responsibility of the purchaser Therefore although reasonable
7. s no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 Section 12 Environmental Ecological Information None Section 13 Disposal Consideration Used Toner should be disposed of under conditions that meet all federal state and local environmental regulations Disposal regulations vary from locality to locality therefore consult your local Lanier office or the EPA to determine the proper method for disposal Do not incinerate loose or spilled Toner Section 14 Transportation Information None This is not a hazardous product Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals MATERIAL SAFETY DATA SHEET Page 3 of CP 341 Section 15 Regulatory Information US Canada Information OSHA Hazard Communication Standard 29CFR 1910 1200 Not regulated Toxic Substance Control Act TSCA All chemical substances in this product comply with all applicable rules or orders under TSCA RCRA 40 CFR 261 Product or components not listed CERCLA SARA Information Not regulated NTP Annual Report on Carcinogens Not listed as an NTP carcinogen IARC See section 11 California Proposition 65 Neither toner or any of the components are l
Download Pdf Manuals
Related Search