Land Pride Conference Phone Fertilizer Spreaders User's Manual
Contents
1. Driveline Grease all knuckle points daily This includes the zerks and tubes of the driveline shaft 12 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 6 27 08 Land Pride Table of Contents Section 5 Specifications and Capacities FS500 FS700 amp FS1000 Broadcast Spreaders FS500 FS700 FS1000 Capacity pounds Overall Dimensions Loading Height 5 85 cu ft 350 Ibs 9 38 cu ft 563 Ibs 11 22 cu ft 673 lbs 46 8 x 46 Weight 3 Point Attachment Category 1 Category 1 Category 1 Net Spreadable Granular Width 23 54 23 54 23 54 PTO Attachment Type Transmission Ratio Min Tractor HP 1 3 8 1 1 1 3 8 1 1 1 3 8 1 1 Range of Spreading Possibility Ibs acre Note All measurements in British Standard Units are approximate as translated from metric equivalents 13613 T MA IN _ i UP TO APPROX 54 Specification Drawing Figure 6 1 6 27 08 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 13 Table of Contents Land Pride Section 6 Features and Benefits FS500 FS700 amp FS1000 Broadcast Spreaders Hopper capacity FS500 350 lbs FS700 563 Ibs FS1000 673 Ibs to meet specific customer needs Spreading capacity Highly productive at 44 to 890 Ibs per acre Spin type broadcast2. A A PA A AA AA SSA a A A A ES CO CA AA O A A EA A a jo jo lo fo fo les we jo jo lo fo _ fo ws l es m9 SS a a O A PP A a PS jo jo lo lo lo tt fs fT A A A EA A A 6 27 08 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 11 Table of Contents Section 4 Maintenance Land Pride General Maintenance Prior to operation thoroughly lubricate fertilizer spreader Check for proper operation of mechanisms by running the machine at no load for a few feet Adjust the distributing assembly for spreading the quantity desired and recheck for adjustment accuracy All the parts must be cleaned accurately with water after every use for a long life and for the efficiency of the implement Proper servicing and adjustment can increase the life of any implement With careful and systematic inspection you can avoid costly maintenance time and repair A CAUTION Be sure to wear proper protective clothing when servicing or lubricating your Fertilizer Spreader Refer to chemical manufacturers labels for specific clothing requirements Lubrication Lu brication Multi purpose Multi purpose Multi purpose Intervals at which Legen d spray lube A grease lube oil lube lubrication is required Gearbox Type of Lubrication Use a Lithium Base gun grease Grade 2 Note Grease should be rated for gearbox application Quantity Grease until visible at purge hole Seasonally
3. For even spreading and productive coverage up to 54 ft 14 Gauge one piece steel Seamless for accurate and consistent emptying hopper Heavy duty all steel frame Supports the weight when full Tow hook Handles up to 1200 pounds 540 RPM shielded PTO For added safety Plated spinner vanes Protects from corrosive material to enhance longevity Plastic agitator wheel Standard equipment and is useful when spreading powder type materials that tend to with steel arm bridge Stainless steel orifice doors Protects from corrosive material enabling doors to operate smoothly Plated adjustment levers Protects from corrosive material to enhance longevity Vinyl cap available Optional vinyl cap with elastic and buckle keeps wind and rain out and material in Cat 1 3 point hitch For attachment to a wide range of tractors 14 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 6 27 08 Land Pride Table of Contents Section 7 Appendix Torque Values Chart Bolt Head Identification Bolt Head Identification 8 8 Inches Grade 2 Grade 5 Grade 8 Metric Class 5 8 Class 8 8 Class 10 9 ae N m ft lb N m ft lb mmxpitch N m felb N m ft lb N m ft lb ezo fra pe fo le h mexos Je b le k kbr 1 4 28 a 13 io cm 11 11 5 16 18 i 11 24 5 16 24 13 z gt 21 gt 29 ee per o fe p e m 72 58 E 31 22 s A 62 7 16 14 43 32 95 70 93
4. FS1000 Fertilizer Spreaders 309 500M 1 Important Safety Information Table of Contents Land Pride These are common practices that may or may not be applicable to the products described in this manual Use Safety Lights and Devices A Slow moving tractors self propelled equipment and towed implements can create a hazard when driven on public roads They are difficult to see especially at night A Flashing warning lights and turn signals are recommended whenever driving on public roads Use lights and devices provided with implement Transport Machinery Safely A Comply with state and local laws A Maximum transport speed for implement is 20 mph DO NOT EXCEED Never travel at a speed which does not allow adequate control of steering and stopping Some rough terrains require a slower speed A Sudden breaking can cause a towed load to swerve and upset oO ike Reduce speed if towed load is not equipped with breaks A Use the following maximum speed tow load weight ratios as a guideline A 20 mph when weight is less than or equal to the weight of tractor A 10 mph when weight is double the weight of tractor A IMPORTANT Do not tow a load that is more than double the weight of tractor ilus ilus pa z ZININNS ZININNS Use A Safety Chain A A safety chain will help control drawn machinery should it separate from the tractor drawbar A Use a chain w
5. amp FS1000 Fertilizer Spreaders 309 500M 9 Table of Contents Land Pride Section 3 Adjustments Spreading Chart for Fertilizer and Seed TRACTO SPRED QUANTITY SPREAD IN LBS ACRE AT VARIOUS GATE SETTINGS RSPEED WIDTH 1 2 3 4 5 6 7 8 8 5 MPH FEET LARGE GRANULAR FERTIL IZER a GRANULAR 5 E VE FINE GRANULAR FERTIL IZER feas Jee Jeso Jeso 1286 1954 1622 1682 ci 23 fa ea 20 as oe 677 761 816 SULPHATE 75 07 fer ne ast sor 547 IOMA CO CCAA CC EC AT E GI o fo Jo o Ja 2 ess fas clover fo fo Jp o Je e jo pa o fo Jo o oe m e fer o o b o 6e fir fee Fescue amp Ryegrass 10 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 6 27 08 Land Pride Table of Contents Section 3 Adjustments TRACTO SPRED QUANTITY SPREAD IN LBS ACRE AT VARIOUS GATE SETTINGS RSPEED WIDTH 1 2 3 4 5 6 7 8 8 5 MPH FEET o jo Jo Jo Ja 17 s33 lee o Jo jo Jo f s ws 250 less Rod Clover o jo jo jo j tom 20m las 60 jo jo jo fo 22 es lie lam A a i Soe A O A O SA A A PE o jo Jo Jo so 131 fsm tesco o jo Jo Jo Ja es fosas 45 we E o Jo Jo Jo jis 7 fis ss amp Bermuda o Jo jo Jo Js es fiws 3s CE o Jo jo Jo j3 ws ess jo jo fo fo tts A A A A A A A E a A O A CO O CA NA A A O EA A ESS A aS eS Ss jo CC CE me i AA O AO O A jo jo fo fo fo as les ws he A E ass PA A A A A
6. 7 16 20 49 36 105 78 130 97 eis fee fao fros rs fiae ros pros 77 tas fios 165 120 145 105 200 150 12 210 155 E 115 1215 160 9 16 18 Ae Z 235 170 165 315 230 5e 11 fiso o7 205 150 f285 210 150 110 325 240 310 230 405 300 3 4 10 235 170 510 375 350 260 485 355 3 4 16 260 190 570 420 440 325 610 450 165 230 e50 480 ooo ees 250 185 905 670 re 560 1050 780 340 250 1230 910 610 1150 845 370 275 1350 995 a O 1120 2100 1550 355 M30 X 2 gt a as 890 1960 1440 M36 X 3 5 1730 1270 2650 1950 3660 2700 1 1 4 7 1120 2460 1820 M36 X 2 1880 1380 2960 2190 4100 3220 2010 1 1 4 12 1240 2730 655 1 in tpi nominal thread diameter in inches threads per 1 3 8 12 a 745 1670 2710 2 N m newton meters 11 2 6 1180 870 1950 4290 3160 3 ft Ib foot pounds 1 1 2 12 1330 980 2190 4820 3560 4mm x pitch nominal thread diameter in millimeters x Torque tolerance 0 15 of torquing values Unless otherwise specified use torque values listed above 6 27 08 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 15 Table of Contents Land Pride Section 7 Appendix Notes 16 S500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 6 27 08 Warranty Land Pride warrants to the original purchaser that this Land Pride product will be free from defects in material and
7. Contents Section 1 Assembly and Set up Tractor Requirements Optional Equipment Assemblies The frame is designed for mounting on 3 point hitch tractor Agitator category 1 or 2 Assembly The Fertilizer is disassembled when it gets the dealer Refer to Figure 1 1 for assembly Assemble the agitator as shown in Figure 1 2 Vs Agitator Assembly Hook Up Assembly 18283 Adjust the 3 point hitch so that the distributer disc is horizontal and about 27 1 2 31 1 2 70 80 cm above Fi 1 1 i igure ground level Refer to Figure 1 3 Spreader Hook Up 1 Figure 1 3 14827 6 27 08 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 7 Table of Contents Section 2 Operation Land Pride Transporting The Fertilizer Spreader is equipped with a towing hook for trailers Maximum towing weight is 1200 pounds A CAUTION Never transport your Fertilizer Spreader at speeds in excess of 20 miles per hour Driveline Installation A DANGER Tractor PTO shield must be in place at all times during operation 1 Slide driveline end with extended safety cone over splined shaft of the gearbox and secure with attaching device 2 Slide driveline over the tractor s splined PTO shaft and secure with locking device of driveline 3 Driveline should now be moved back and forth to insure that it is secure on the PTO shaft of the tractor and spreader gearbox 4 Should the driveline require shortening Fi
8. observe your distribution width and pattern density Typically the pattern won t be as dense on the outer edges As you make your turn for an adjacent pass adjust your travel path to achieve uniform overlap and pattern density You may need to close and open the distribution gate at the beginning and ending of each pass Your hopper should empty out just as you complete coverage of your one acre plot If not make the necessary adjustments until you are absolutely confident that you have achieved the proper final calibration Once you have achieved final calibration load the spreader hopper with the appropriate amount of material to be spread Do not overload hopper with more weight than is specified for your individual model If the tractor front end becomes too light for proper steering add tractor weights to the front end Proceed with spreading operations looking back often to ensure a uniform distribution pattern and to make sure there are no interruptions to hopper flow With a little practice you should become a very good applicator Once you are done spreading disengage the PTO park the tractor set the brake shut off the tractor and remove the keys When finished always clean out the spreader to prevent rust and corrosion 8 FS500 FS700 8 FS1000 Fertilizer Spreaders 309 500M 6 27 08 Land Pride Table of Contents Section 3 Adjustments Adjustments How to adjust the Spreader Vanes 0 wi To ensure even distri
9. workmanship beginning on the date of purchase by the end user according to the following schedule when used as intended and under normal service and conditions for personal use Overall Unit One year Parts and Labor Gearbox and Driveline One year Parts and Labor This Warranty is limited to the replacement of any defective part by Land Pride and the installation by the dealer of any such replacement part and does not cover common wear items such as blades belts tines etc Land Pride reserves the right to inspect any equipment or parts which are claimed to have been defective in material or workmanship This Warranty does not apply to any part or product which in Land Pride s judgment shall have been misused or damaged by accident or lack of normal maintenance or care or which has been repaired or altered in a way which adversely affects its performance or reliability or which has been used for a purpose for which the product is not designed Misuse also specifically includes failure to properly maintain oil levels grease points and driveline shafts Claims under this Warranty must be made to the dealer which originally sold the product and all warranty adjustments must be made through such dealer Land Pride reserves the right to make changes in materials or design of the product at any time without notice This Warranty shall not be interpreted to render Land Pride liable for damages of any kind direct consequential or continge
10. TOXIC CHEMICAL HAZARD WEAR RUBBER CLOVES DO NOT INGEST CHEMICAL Do rot llow chomioal or seul to touch sdn Some con be absarbad lrouph the 818 541C Danger Toxic Chemical Hazard Wear rubber gloves ond proc gear af all limes FAILURE TO FOLLOW THESE INSTRUCTIONS WILL RESULT IN SERIOUS INJURY OR DEATH NOTICE e Verify PTO shaft does not bottom out in horizontal position a DO NOT operate without 4 inner tube engagement DO NOT operate at high driveline angles 818 5420 818 542C Notice PTO To prevent serious injury or death Keep away from discharge area and rotating paddles during operation Kesp others away Disconnect ond lockout power source BEFORE adjusting or servicing DO NOT point discharge towards people animals or buildings when operating Kaap hands fest hair ond clothing away from moving parts 818 539C Danger Thrown Object Rotating Paddles Hazard 4 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 6 27 08 Land Pride Table of Contents Important Safety Information A DANGER GUARD MISSING DO NOT OPERATE A DANGER 818 540C ENA Danger Guard Missing GUARD MISSING DO NOT OPERATE ROTATING DRIVELINE CONTACT CAN CAUSE DEATH KEEP AWAY DO NOT OPERATE WITHOUT 81 8 552C e All driveline guards tractor and equipment shields in place a Drivelines securely attached at both Danger R
11. Table of Contents Fertilizer Spreaders FS500 FS700 amp FS1000 15594 309 500M Operator s Manual Read the Operator s manual entirely A When you see this symbol the subsequent instructions and warnings are serious follow without exception Your life and the lives of others depend on it Copyright 2008 Printed 6 27 08 Cover photo may show optional equipment not supplied with standard unit Land Pride Table of Contents Important Safety Information 1 Section 3 Adjustments ooo oooooooo 9 Be Aware of Signal Words o oo ooooo oo 1 Adjustments aa c eee eee eee 9 Introduction an a ad 6 How to adjust the Spreader Vanes 9 Application 6 0 ee ee 6 mews adusi me Delivery RA eee 3 Using This Manual 6 Spreading Chart for Fertilizer and Seed 10 Terminology cee eee eee eee 6 Section 4 Maintenance oo oocoomoo 12 DefinitiONS o o ooooooooooooooo o 6 General Maintenance oo ooooooooo 12 Owner Assistance 000 0c eee eee eee 6 Lubrication 0 0 eee eee 12 Further Assistance 00000 c eee eee 6 Gearbox raro a ii 12 Section 1 Assembly and Set up ai e o o Be Pore 7 Driveline a Bayes O OS Rite Si ee eats 12 Tractor Requirements 00000 ee eeee 7 Section 5 Specifications and Capacities 13 Assembly E A 7 Section 6 Features and Benefits 14 Op
12. bution on either side of the fertilizer a A spreader of differing specific gravities the vanes can be l I adjusted to the different holes on the distributor disc le When all vanes are placed in hole 1 the distribution to the left of the tractor driver is increased If inserted into hole 4 distribution to the right of the driver increases Refer to Figure 3 1 The fertilizer adjustment depends upon the type of material being used and the operator s experience Delivery Adjustments 13611 Figure 3 3 1 Total width spreading of the fertilizer A 2 Spreading to the left side driver B Refer to Figure 3 2 Remove knob 3 move down lever 1 to full extent and close the other lock device at the same time This is done by bringing lever 2 to the 1 position 3 Spreading to the right side of driver C Refer to Figure 3 2 Remove knob 3 move down lever 2 to full extent and close the other lock device at the same time This is done by bringing lever Spreader Vanes 1 to the 1 position Figure 3 1 How to adjust the Delivery The fertilizer delivery is controlled by properly opening the orifices in the hopper bottom through the lock devices op erated by two levers 1 and 2 Refer to Figure 3 2 Distrubution Gate Settings 14826 Figure 3 4 Lever Adjustments 13610 Figure 3 2 The position of the adjustment levers follows and is shown in Figure 3 3 6 27 08 FS500 FS700
13. ching A Keep hands feet and clothing away from power driven parts A Wear snug fitting clothing to avoid entanglement with moving parts A Watch out for wires trees etc when raising implement Make sure all persons are clear of working area A Turning tractor too tight may cause implement to ride up on wheels This could result in injury or equipment damage 6 27 08 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 3 Table of Contents Important Safety Information Land Pride Safety Labels 1 Your fertilizer spreader comes equipped with all safety labels in place They were designed to help you safely operate your spreader Read and follow their directions Keep all safety labels clean and legible 3 Replace all damaged or missing labels To order new labels go to your Land Pride dealer 4 Some new equipment installed during repair requires safety labels to be affixed to the replaced component as specified by Land Pride When ordering new components make sure N the correct safety labels are included in the request To order new labels go to your Land Pride dealer 5 Refer to this section for proper label placement To install new labels a Clean the area the label is to be placed b Spray soapy water on the surface where the label is to be placed c Peel backing from label Press firmly onto the surface Squeeze out air bubbles with the edge of a credit card
14. e or level of hazard seriousness The signal words are A DANGER Indicates an imminently hazardous situation which if not avoided will result in death or serious injury This signal word is limited to the most extreme situations typically for machine components that for functional purposes cannot be guarded WARNING Indicates a potentially hazardous situation which if not avoided could result in death or serious injury and includes hazards that are exposed when guards are removed It may also be used to alert against unsafe practices A CAUTION Indicates a potentially hazardous situation which if not avoided may result in minor or moderate injury It may also be used to alert against unsafe practices ATTENTION BECOME ALERT YOUR SAFETY IS INVOLVED This is the safety alert symbol It means Keep Riders Off Machinery A Riders obstruct the operator s view They can be struck by foreign objects or thrown from the machine A Never allow children to operate equipment For Your Protection A Thoroughly read and understand the Safety Label section read all instructions noted on them Shutdown and Storage A Lower machine to ground turn off engine and remove the key A Detach and store implements in a area where children normally do not play Secure implement by using blocks and supports 6 27 08 FS500 FS700 amp
15. gure 3 3 ae ae 2 INNER DRIVELINE M a fp Pn D M INNER SHAFT INNER SHIELD IMPLEMENT END UNIVERSAL JOINT SHIELD OUTER DRIVELINE Ne za TRACTOR END SA E OUTER SHAFT 13588 Shortening the PTO Shafts Figure 3 3 a Raise the tractor 3 point hitch so the input shaft of the gearbox is in line with the PTO shaft on the tractor Shut tractor engine off leaving the spresder in position of shortest distance between shafts refer to A dimension Securely block spreader in position b Pull driveline apart as shown in Figure 3 3 Reattach outer yoke sections to tractor and gearbox Pull on each driveline section to be sure the yokes are locked into place c Hold driveline sections parallel to each other to determine if too long Each section should end approximately 1 B dimension short of reaching universal joint shield on opposite section If too long measure 1 B dimension back from universal joint shield and mark on opposite section Do this for both sections d Cut off shield where marked X dimension Cut shaft the same amount X dimension e Repeat the procedure to the other driveline half Remove all burrs and cuttings f Apply multi purpose grease to inside of outer female driveline section Assemble driveline and install on tractor and spreader Pull on each driveline section to be sure yokes lock into place Make certain driveline shieldi
16. ications of salt and sand for snow and ice control See Features and Benefits Section 6 for additional information Using This Manual This Operator s Manual is designed to help familiarize you with safety assembly operation adjustments troubleshooting and maintenance Read this manual and follow the recommendations to help ensure safe and efficient operation The information contained within this manual was current at the time of printing Some parts may change slightly to assure you of the best performance To order a new Operator s or Parts Manual contact your authorized dealer Manuals can also be downloaded free of charge from our website at www landpride com or printed from the Land Pride Service amp Support Center by your dealer Terminology Right or Left as used in this manual is determined by facing the direction the machine will operate while in use unless otherwise stated Definitions NOTE A special point of information that the operator must be aware of before continuing IMPORTANT A special point of information related to its preceding topic Land Pride s intention is that this information should be read and noted before continuing Owner Assistance The Warranty Registration card should be filled out by the dealer at the time of purchase This information is necessary to provide you with quality customer service If customer service or repair parts are required c
17. ith the strength rating equal to or greater than the gross weight of the towed machinery A Attach the chain to the tractor drawbar support or other specified anchor location Allow only enough slack in the chain to permit turning A Do not use safety chain for towing Practice Safe Maintenance A Understand procedure before doing work Use proper tools and equipment refer to Operator s Manual for additional information A Work in a clean dry area A Lower the implement to the ground put tractor in park turn off engine and remove key before performing maintenance A Allow implement to cool completely A Do not grease or oil implement while it is in operation A Inspect all parts Make sure parts are in good condition amp installed properly A Remove buildup of grease oil or debris A Remove all tools and unused parts from implement before operation ke by ZO 2 FS500 FS700 amp FS1000 Fertilizer Soreaders 309 500M 6 27 08 Land Pride Important Safety Information Table of Contents These are common practices that may or may not be applicable to the products described in this manual Prepare for Emergencies A Be prepared if a fire starts A Keep a first aid kit and fire extinguisher handy A Keep emergency numbers for doctor ambulance hospital and fire department near phone T Wear Protective Equipment A Protective clothi
18. ng and equipment should be worn A Wear clothing and equipment appropriate for the job Avoid loose fitting clothing A Prolonged exposure to loud noise can cause hearing impairment or hearing loss Wear suitable hearing protection such as earmuffs or earplugs A Operating equipment safely requires the full attention of the operator Avoid wearing radio headphones while operating machinery Avoid High Pressure Fluids Hazard A Escaping fluid under pressure can penetrate the skin causing serious injury A Avoid the hazard by relieving pressure before disconnecting hydraulic lines A Use a piece of paper or cardboard NOT BODY PARTS to check for suspected leaks A Wear protective gloves and safety glasses or goggles when working with hydraulic systems A If an accident occurs see a doctor immediately Any fluid injected into the skin must be surgically removed within a few hours or gangrene may result WT Safety at All Times Thoroughly read and understand the instructions given in this manual before operation Refer to the Safety Label section read all instructions noted on them A Operator should be familiar with all functions of the unit A Operate implement from the driver s seat only A Do not leave tractor or implement unattended with engine running A Dismounting from a moving tractor could cause serious injury or death A Do not stand between the tractor and implement during hit
19. ng is in place and in good condition Operating Instructions By now you should have properly installed your Land Pride Fertilizer Spreader on your tractor Based on the type of material and pounds per acre you intend to broadcast you should have referred to the spreading chart in the operator s manual to determine the proper tractor ground speed distribution gate opening and spread pattern setting for your spreader This process of taking prescribed fertilizer or seed label rates and making the necessary spreader setting adjustments is called initial calibration When setting your spreader up for initial calibration following the chemical or seed supplier s label directions and using the manufacturer s application rate setting charts is absolutely essential and required Once you have achieved your initial calibration it is time to make final calibration adjustments Measure off an area where chemicals or seed are to be applied An acre is preferred Measure out exactly enough product to cover an acre at the manufacturer s prescribed rate and put it in the hopper You should have already determined the appropriate ground speed that will allow you to meet the application rate and also maintain 540 rpm PTO speed Start the tractor and travel to the one acre plot you have measured off Maintaining proper ground and engine speed engage the PTO and open the distribution gate just as you move onto the plot Look back often to
20. nt to property Furthermore Land Pride shall not be liable for damages resulting from any cause beyond its reasonable control This Warranty does not extend to loss of crops any expense or loss for labor supplies rental machinery or for any other reason No other warranty of any kind whatsoever express or implied is made with respect to this sale and all implied warranties of merchantability and fitness for a particular purpose which exceed the obligations set forth in this written warranty are hereby disclaimed and excluded from this sale This Warranty is not valid unless registered with Land Pride within 30 days from the date of purchase by the end user Corporate Office RO Box 5060 Salina Kansas 67402 5060 USA www landpride com
21. ontact a Land Pride dealer A dealer has trained personnel repair parts and equipment needed to service the implement The parts on your Fertilizer Spreader have been specially designed and should only be replaced with genuine Land Pride parts Therefore should your Fertilizer Spreader require replacement parts go to your Land Pride Dealer Serial Number Plate For prompt service always use the serial number and model number when ordering parts from your Land Pride dealer Be sure to include your serial and model numbers in correspondence also Refer to Figure 1 for the location of your serial number plate Serial Number Plate Location Figure 1 15594 Further Assistance Your dealer wants you to be satisfied with your new Fertilizer Spreader If for any reason you do not understand any part of this manual or are not satisfied with the service received the following actions are suggested 2 Discuss the matter with your dealership service manager making sure he is aware of any problems you may have and that he has had the opportunity to assist you 3 Ifyou are still not satisfied seek out the owner or general manager of the dealership explain the problem and request assistance 4 For further assistance write to Land Pride Service Department P O Box 5060 Salina KS 67402 5060 E mail address lpservicedept landpride com 6 FS500 FS700 amp FS1000 Fertilizer Soreaders 309 500M 6 27 08 Land Pride Table of
22. otating Driveline ends e Driveline guards that turn freely on Driveline 818 552 6 27 08 FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 5 Table of Contents Introduction Land Pride Land Pride welcomes you to the growing family of new product owners This Fertilizer Spreader has been designed with care and built by skilled workers using quality materials Proper assembly maintenance and safe operating practices will help you get years of satisfactory use from this Fertilizer Spreader Application The Land Pride FS500 FS700 and FS1000 are rotary spin type broadcast spreaders designed for Category 1 three point hitch mounting They are capable of spreading seed sand salt top dressings and prilled granular fertilizer lime and iron at delivery rates ranging from 43 890 lbs per acre Each of these models offers specific hopper capacities with the FS500 at 350lbs 5 85cu ft the FS700 at 563lbs 9 38cu ft and the FS1000 at 673lbs 11 22cu ft An internally mounted agitator helps keep material in the hopper from bridging This ensures a continuous hopper flow and uniform delivery rate from the adjustable pattern rotary spreader The spread rate capability and range of hopper capacities make the Land Pride Fertilizer Spreaders well suited for applications on farms golf courses park systems athletic fields and large campuses They also work well for smaller municipal or commercial appl
23. tional Equipment Assemblies 7 Agitator A EN 7 Section 7 Appendix ooocococoooconcocmm 15 HOOKS UD acota td ap loa 7 A SAM ei ha tot Es T tek sh 16 Section 2 Operation 00ceceeeeeeees 8 DE ee ee ee ae 17 Transporting eee er aa a a eee 8 Driveline Installation ooo o o oooo 8 Operating Instructions o ooooooo o 8 Copyright 2008 All rights Reserved Land Pride provides this publication as is without warranty of any kind either expressed or implied While every precaution has been taken in the preparation of this manual Land Pride assumes no responsibility for errors or omissions Neither is any liability assumed for damages resulting from the use of the information contained herein Land Pride reserves the right to revise and improve its products as it sees fit This publication describes the state of this product at the time of its publication and may not reflect the product in the future Land Pride is a registered trademark All other brands and product names are trademarks or registered trademarks of their respective holders Printed in the United States of America FS500 FS700 amp FS1000 Fertilizer Spreaders 309 500M 6 27 08 Land Pride Important Safety Information Table of Contents These are common practices that may or may not be applicable to the products described in this manual Be Aware of Signal Words A signal word designates a degre
Download Pdf Manuals
Related Search