KitchenAid KAWE660W User's Manual
Contents
1. Comments HOT e White and colorfast e Gives best cleaning for 130 F 54 C or above cottons heavy oily soils e Heavy soils Helps prevent greying e Diapers and yellowing e Less fading and bleeding of dye e Safe for fabric finishes WARM 100 F 38 C e Normal soiled permanent press and synthetic items e Dark or non colorfast colors e Washable woolens e Moderate soils Knits COLD 70 100 F 21 1 37 8 C Lightly soiled fabrics e Some non colorfast colors e Some normally soiled items with extra detergent e Less effective cleaning than hot or warm water e Dissolve powdered detergent in warm water before adding to washer or use a liquid detergent Pretreat spots stains and heavy oily soils e Use longest wash time in cycle selected Water can be too cold for effective washing During cold weather water may be too cold to dissolve detergent properly If your tap water is less than 70 F 21 1 C use a warm wash setting and follow instructions for a cold wash IMPORTANT Cold rinses can be used for all loads as they save energy and help keep wrinkles from setting into fabrics Use warm wash water and cold rinse water for PERMANENT PRESS and KNITS DELICATES Cycles to minimize wrinkling Energy Saving Tips 1 Use hot water only when necessary heavy or greasy soils whites etc Use cold water for light soils2. Replace house fuses or correct house wiring Correct house plumbing Repairs when washer is used in other than normal home use Damage resulting from accident alteration misuse abuse improper installation or installation not in accordance with local electrical or plumbing codes D Any labor costs during the E limited warranties Replacement parts or repair labor costs for units operated outside the United States Pickup and delivery This product is designed to be repaired in the home KITCHENAID DOES NOT ASSUME ANY RESPONSIBILITY FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES Some states do not allow the exclusion or limitation of incidental or consequential damages so this exclusion or limitation may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from State to state If you need service first see the Service and Assistance section of this book After checking Service and Assistance additional help can be found by calling our service assistance telephone number 1 800 422 1230 from anywhere in the U S Part No 3353725 Rev A 1990 KitchenAid KitchenAid St Joseph Michigan U S A 49085 TM Trademark of KitchenAid Printed in U S A
3. 2 Full loads make the best use of water heating energy If proper sorting results in less than full loads adjust the water level to the size of the load 3 Avoid rewashing e Use recommended amount of detergent based on soil level load size and water hardness See loading information on page 9 Do not overload the washer See page 11 for loading suggestions Use the cycles and wash times recommended for the wash load fabric type and soil level Sort the wash load correctly See Sorting page 9 Load Preparation For best results the following steps should be taken to prepare your clothes for washing e Make sure all pockets are empty Tissues and other paper left in pockets can leave lint throughout the wash load Turn pockets inside out e Turn cuffs down and brush away lint and dirt e Remove pins buckles and other sharp objects and close zippers snaps and hooks This will help avoid scratching the basket damaging the agitator and snagging other load items e Remove unwashable trim and ornaments e Tie strings and sashes so they won t tangle e Mend tears loose hems and seams e Treat spots and stains See the Stain Removal Tips section on pages 22 24 Turn synthetic knits inside out This will help avoid pilling Some knits are stretched during manufacturing and may shrink slightly during laundering Sorting Always sort carefully for best washing results Sort by f
4. EXTRA WASH OFF PRE WASH OFF SPIN KNITS DELICATES NORMAL OFF Knits Delicates C ycie Delicate items and washable knits are washed and spun gently on this cycle Nylon hosiery should be washed in a net laundry bag to avoid tangling Cycle Sequence is as follows FILL to Selected Level v WASH 6 Minutes Low Speed v DRAIN No Agitation v SPIN Medium Speed v FILL for Deep Rinse v RINSE Low Speed v DRAIN No Agitation v SPIN Medium Speed 2 Spray Rinses 15 Use of Clothes Washer Dispensers Liquid Bleach Dispenser The bleach dispenser is located near the lower right edge of the washer tub opening Always measure bleach never use more than 1 cup for a full load Use less bleach with lower water level settings e Follow directions on bottle for safe use e Use a cup with a pouring spout to avoid spilling TO USE 1 Add detergent and load to basket 2 Pour measured bleach carefully into dispenser DO NOT let bleach splash drip or run down into the washer basket Undiluted bleach will damage any fabric it touches 3 Start the washer Bleach will be diluted automatically during the wash part of the cycle For more information on the use of chlorine bleach see page 19 Fabric Softener Dispenser TO USE 1 Add detergent and load to basket 2 Add liquid fabric softener to the dispenser following the instructions recommended on the bottle Avoid
5. KitchenAid Extra Capacity Clothes Washer Model KAWE6G60W USE and CARE GUIDE Table of Contents Important Safety Instructions 06 3 You Are Responsible FOr 4 Ownership Registration ceceeeeeeeeeeee 4 Clothes Washer Features 0 eeeee 5 Operating the Clothes Washer 6 Water Hardness ae enn bo eleecke ands 6 Water Temperature cee cceeeceeeeeeeeee ees 7 Energy Saving Tips cceeeeceeeeeeeeeeeeeeeees 8 Load Preparation 2 2 2 0 cece eceeceeee tees eecene 8 SORIA PE E A deceens 9 LOAGING i reaa e ee ete eee 9 Add Soap or Detergent a c 9 Tips on Detergent Use eee 10 Add Sorted Wash Load seeen 10 LOADING TIPS inoeooo ai aai gia 10 Load Sizes and Water Levels 11 Loading Suggestions n 11 Make Selections 0 ccceeceeeeeenteeeeeeeeees 12 Select a Water Level scair onii 12 Select Water Temperatures aeeie 12 Select a Wash Cycle iseeneses 12 Self Clean Lint Filter a e 12 Pre Wash Cycle cee ead a 13 Extra Wash Cycle sn aigar eus aagana 13 Regular Heavy Cycle aiieieo 14 Permanent Press Cycle iaaii 14 Knits Delicates Cycle eoii aai 15 Use of Clothes Washer Dispensers 16 Liquid Bleach Dispenser o e 16 Fabric Softener Dispenser 5 16 Caring for the Clothes Washer 17 Common Washing Problems ANG GaUSeS siirdati tare sidonia Rie 18 19 Laundry Aids inre n a e 19 21 Stain Re
6. c Select a wash cycle See pages 12 15 for a description of selection options Step 4 Close washer lid The washer will not spin if the lid is left open Step 5 Start the washer See page 12 for instructions on Cycle Control Selector use Water Hardness Many complaints of poor washing results can be traced to wash water temperature and hardness Water Hardness Water with a high mineral content is called hard water Water deposits and stains in the wash tub are examples of problems caused by hard water To check water hardness e City water ask the water company They can tell you the mineral content in grains per gallon or parts per million e Well water check with your Cooperative Extension Service Office If your water is hard e Consider installing a water softener e Consider installing an iron filter if the iron content is high e Use more detergent See table on page 9 for recommended amourts e Do not use soap use detergent e Soften wash and rinse water with a packaged non precipitating water conditioner SOFT WATER 0 to 4 grains per gallon or O to 68 parts per million MEDIUM HARD WATER 5 to 8 grains per gallon or 85 to 136 parts per million HARD WATER 9 to 12 grains per gallon or 153 to 205 parts per million VERY HARD WATER More than 12 grains per gallon or more than 205 parts per million Water Temperature Water Temperature Guide Wash Water Temperature
7. Some pre soak products and regular detergents contain enzymes Enzymes help break down protein type stains such as blood baby formula meat juice and vegetable protein stains such as grass and tomatoes Dissolve enzyme laundry products in warm water to help prevent spot fading of colored items 20 Fabric Softeners Fabric softeners help make fabrics soft and also help reduce static electricity and fabric wrinkling Follow package directions carefully e Always dilute fabric softeners with 1 2 to 1 cup 125 to 250 mL of warm water Undiluted fabric softener can stain fabrics e Use only in deep rinse Do not mix with any other laundry products This includes detergent packaged water conditioners and bleaches Mixing may cause greasy stains Stains from fabric softeners can be removed by weiting the stain and rubbing it with liquid detergent or a bar of soap Re wash the stained item e Use correct amount Too much fabric softener can make some items nonabsorbent like diapers and towels If this happens either use less fabric softener or don t use it every time e Use the fabric softener dispenser See page 16 for use information Packaged Water Conditioners If your water is hard laundry results will be better if you use a non precipitating water conditioner Non precipitating water conditioners soften water by tying up hardness minerals so they will not be deposited on clothes resulting in yellow
8. acetone or rubbing alcohol Sponge stain continuously until all bleeding stops Let dry Repeat if necessary Wash If stain remains bleach if safe for fabric India and other indelible inks are almost impossible to completely remove Avoid use of acetone on acetate triacetate or modacrylics for example stuffed toys and synthetic furs iron or Rust For colored or non colorfast items apply lemon juice and salt Place in the sun to dry Rinse thoroughly Repeat if necessary For white or colorfast items a liquid rust remover available at grocery stores may be effective Test first on inside seam or hem ACAUTION When using rust remover follow package directions carefully Some rust removers can harm the washer s top and basket finish 23 Lipstick Apply non flammable dry cleaning solvent or pre wash soil and stain remover Blot with absorbent material Repeat if necessary Rinse If stain still remains rub with liquid detergent Wash Meat Juice Egg Scrape off excess egg with dull side of tableknife Soak in cold or warm water with enzyme pre soak at least 30 minutes Treat grease stains with a non flammable dry cleaning solvent Wash Mildew Wash in hottest water safe for fabric If stain remains soak in warm water and an alil fabric bleach for 15 to 30 minutes Re wash Old mildew stains are almost impossible to remove Mildew fungus destroys or weakens fabrics An alternative to bleach
9. Chicago IL 60606 e MACAP will in turn inform us of your action When requesting assistance please provide Model Number Serial Number Date of Purchase and a complete description of the problem This information is needed in order to better respond to your request 29 KitchenAid Washer Warranty LENGTH KITCHENAID KITCHENAID OF WARRANTY WILL PAY FOR WILL NOT PAY FOR ONE YEAR FULL WARRANTY FROM DATE OF PURCHASE SECOND YEAR LIMITED WARRANTY FROM DATE OF PURCHASE SECOND THROUGH FIFTH YEAR LIMITED WARRANTY FROM DATE OF PURCHASE SECOND THROUGH TENTH YEAR LIMITED WARRANTY FROM DATE OF PURCHASE Replacement parts and repair labor costs to correct defects in materials or workmanship Service must be provided by an authorized KitchenAid servicing outlet Replacement parts to correct defects in materials or workmanship Replacement parts for the cabinet assembly should it rust through due to defects in materials or workmanship For solid state touch control models replacement parts for the solid state controls if defective in materials or workmanship Replacement parts for any part of the gearcase assembly to correct defects in materials or workmanship Replacement parts for the washer outer tub should it fail to contain water due to defects in materials or workmanship A Service calls to Correct the installation of the washer Instruct you how to use the washer
10. agitator IMPORTANT Bulky synthetic items often float on top of the water Stop the washer from time to time to press air from item being washed e Two rinses may be necessary e Do not overload Some items may be too large for the washer Towels Some towels particularly those made of a blend of synthetic fibers and natural fibers polyester and cotton blends may shed more lint than other towels When towels are laundered the lint screen in your dryer may get full faster Be sure to remove the lint from the dryer lint screen when you launder new towels Tinted Dyed or Non Colorfast Items For tinting or dyeing in the washer follow package directions and information on page 21 for best results To wash non colorfast items follow care label directions to reduce the amount of dye transfer Wash separately Clean the washer according to instructions on page 17 27 Washable Knits Knits are comfortable to wear because they stretch and give However this stretchy factor means they will be less stable than a woven fabric when washed When manufactured some knit fabrics may be stretched When the garment is washed the fabric can return to its original size This is the nature of knits when they are washed either by hand or washer Knits made of synthetic fibers such as polyester acrylic and nylons are more likely to keep their original size than those made of cotton or rayon Knit garments made o
11. be placed in the washer Failure to follow these guidelines may result in damage to the washer basket finish To clean washer exterior wipe with a soft damp cloth To clean washer interior put chlorine bleach and detergent in the washer Run through a complete cycle using hot water Service or performance problems caused by the use of any product not manufactured by KitchenAid are the responsibility of the manufacturer of that product Winterizing Because a small amount of water stays in the washer pump after draining freezing can cause a lot of damage If your washer is stored or moved during the cold weather follow this procedure 1 Shut off both water faucets Disconnect and drain water inlet hoses 2 Pour 1 quart of R V type antifreeze in the basket 3 Set the washer to the spin portion of the REGULAR HEAVY Cycle and turn the washer on Allow the washer to run about 30 seconds to mix the antifreeze and water then push the Cycle Control Selector in stopping the washer To Use the Washer Again The winterizing procedure mixes antifreeze into the water pump to protect against freezing and damage Before the washer is used again the antifreeze must be removed from the pump by following these steps 1 Flush the water pipes and hoses 2 Connect hoses to the washer 3 Turn on the water faucets 4 Run the washer through a complete REGULAR HEAVY Cycle without clothing using one cup of de
12. dripping or spilling any fabric softener on the load because fabrics can stain 3 Add warm water to fill dispenser until liquid reaches the opening 4 Diluted fabric softener will be added to the load when the washer fills for the rinse part of the cycle IMPORTANT Do not stop the washer before the final rinse Staining can occur 5 Clean dispenser after each use with warm water To remove the dispenser grasp the top of the dispenser with both hands Squeeze and push upward with thumbs to remove Clean by holding under water faucet Replace after cleaning IMPORTANT Do not add detergent to dispensers The dispensers can clog For more information on the use of fabric softeners see page 20 Caring for the Clothes Washer When not washing keep both water faucets off This takes the pressure off the water inlet valve and hoses For maximum use Satisfaction and longer washer life follow these guidelines e Wet or damp laundry should not be stored in your washer for an extended period of time e Do not use vinegar or other acids in your washer e Do not place urine soaked clothing in the washer without appropriate amounts of water and detergent e Clothing may be soaked in your washer as long as sufficient amounts of detergent have been added to the water If chlorine bleach is needed for soaking it may be used as long as detergent is present in the water e Sharp or heavy objects should never
13. safe for fabric Heavy stain Place face down on towel and treat with a paste of ammonia and all fabric bleach Let stand for 30 minutes Wash in hottest water safe for fabric Fabric Softener Wet the stain and rub with liquid detergent or bar of soap Re wash the stained item Fat Grease or Oil Try any of the following treatments 1 Use pretreatment stain remover Follow label directions Wash in hottest water safe for fabric 2 Use talcum powder to absorb as much grease as possible Sponge with a non flammable dry cleaning solvent Wash 3 Treat with liquid detergent or rub a detergent paste on the stain Wash using hottest water safe for fabric Fruit stains Do not use soap on fruit stains It will set stains Fresh stains Soak immediately in cool water Wash If stains remain cover area with a paste made of all fabric bleach a few drops of hot water and a few drops of ammonia Wait 15 to 30 minutes Wash Old stains Sponge with white vinegar Rinse Repeat procedure for fresh stains Grass or Green Vegetables Soak in warm or cold water or sponge with denatured alcohol Wash in water temperature and bleach safe for the fabric For colored fabrics check colorfastness before applying alcohol On acetate fabrics sponge with a non flammable dry cleaning solvent If stains remain bleach with 3 hydrogen peroxide Rinse Re wash Ink or Ballpoint Pen Ink Spray stain with an aerosol hair spray
14. temperature setting Remove from dryer while slightly damp 25 Flame Retardant Finishes Some items may be treated to improve their resistance to burning if exposed to flame Such items wiil be clearly labeled To help keep flame retardant qualities through continuous use and washing wash according to the manufacturer s instructions Glass Fiber Materials Do not wash glass fiber materials in your washer Some fibers can remain in the washer These glass particles could stick to fabric washed in the next load and cause skin irritation Napped Items e Corduroy e Velveteen 1 Use hot or warm water depending on colorfastness 2 Turn inside out before washing 3 Restore fluffiness in your dryer If line dried place on hangers to dry and brush up nap Permanent Press Fabrics Permanent press is a special finish applied to fabrics It helps the garment stay smooth and wrinkle free if it is washed correctly When the finish is heated as in hot water or in the dryer it softens and becomes pliable It will give up wrinkles at this time Permanent press items should not be crushed while warm in spin or when dryer stops Wrinkles will be put back in Your KitchenAid washer has a special cool down cycle for permanent press to help prevent setting in wrinkles 1 Wash frequently Permanent press garments stay so fresh looking that people tend to postpone laundering Once they become soiled and stained they a
15. abric and construction e Sturdy cottons such as jeans towels work clothes e Knits such as sweaters and double Knit clothing e Delicate items such as lingerie and fine washables Sort by color Always wash synthetics and light colored permanent press as a separate load as they will easily pick up color from non colorfast garments Separate heavily soiled items Even if a garment would normally be washed with lightly soiled items if it is heavily soiled it should be washed separately This will help other lightly soiled load items to become more thoroughly cleaned Separate lint givers from lint takers Lint givers are laundry items that have a high cotton content chenille bath towels sweatshirts and lint takers are high in synthetic content permanent press knit sweaters or tend to collect lint corduroy When possible turn lint givers inside out Loading When loading your washer be sure to follow the proper sequence a add soap or detergent b add sorted wash load c make selections start washing Add Soap or Detergent If soap or detergent is added directly on top of clothing stains may result especially with liquid detergents The following chart shows the correct amount of soap or detergent to use based on the type of detergent and the level of water hardness in your wash water Extra Capacity Washer highest water level only Powdered Detergents concentrated low suds phosph
16. ate normal suds phosphate concentrated low suds non phosphate normal suds non phosphate Liquid Detergents 0 4 gr 1 2 C lc 1 2 3 4 C hi 1 4 1 2 C IMPORTANT in areas where phosphate detergents are not allowed e Use increased amounts of liquid detergent based on the level of water hardness and amount of soil in the wash load e Use a non precipitating water conditioner in the wash and deep rinse e install a mechanical water softener if water is very hard and soap not a synthetic detergent is used WATER HARDNESS IN GRAINS 4 10 gr 10 20 gr 20 gr 3 4 1 C 1 174C 11 2 C lic 1 172 1 3 4 C 2c Ic 1 174 1 172 1 374 2 c l 1 3 13 4 C 2c 1 2 3 4 C lc 1 v4c Tips on Detergent Use e Measure your detergent carefully Use the correct amount based on level of water hardness and the amount of wash load soil e Using too little detergent is a common cause of laundry problems You need enough detergent to hold the soil as it drains away with the wash water e Detergent package directions are usually based on moderate water hardness 4 to 6 grains lightly soiled items normal mixed loads e Follow package directions carefully but use more detergent for hard water cooler wash water full loads heavily soiled items Do not judge the amount of detergent to use by the amount of suds in the wash basket Some detergents will generate less suds than others e If too ma
17. ately removed from washer after cycle is completed improper rinse temperature e poor permanent press finishes e cycle selection is incorrect based on fabric type Yellow Areas Built Up Body Oils e water temperature too low not enough detergent Laundry Aids The following pages list some AWARNING common laundry aid products and techniques for best washing results Follow all package directions carefully Chlorine Bleach e Use bleach only in the wash so Personal Injury and Fire Hazard Keep stain removal products out of the reach of children preferably in a locked cabinet To help avoid the danger of a that it can be removed in the fire or explosion a ra NEVER store flammable e Follow directions on care labels Do not use chlorine bleach on wool silk spandex acetates or some flame retardant fabrics e Do not use chlorine bleach in water high in iron Yellow stains or spotting may result e Always measure bleach and follow until they have been package directions Never use completely rinsed and air more than 1 cup for a full load dried Undiluted bleach will damage any fabric The damage appears as rips holes or tears and may not show up until several washings solvents or liquids near your washer NEVER put dry cleaning solvents or fluids directly into your washer NEVER put items treated with solvents in your washer e The fumes from these substances can create a fire
18. d the washer as full as with other loads Large sheets require more space in the wash basket for movement and proper cleaning Load Sizes and Water Levels Do not overload the washer For best cleaning results the load must be able to move freely in the washer Too big a load or too little water can Cause wear or tearing of load items Large Extra smali Approximate fill with load Loading Suggestions Large Water Level Smaller load sizes should be washed in lower water levels Mixed Load 3 double sheets 4 pillowcases 8 T shirts 6 pair shorts 2 shirts 2 blouses 8 handkerchiefs Permanent Press 2 double or 1 king size sheet 1 tablecloth 1 dress 1 blouse 2 slacks 2 pillowcases Heavy Work Clothes 3 pair pants 3 shirts 4 pair jeans 1 coverall 1 overall Knits 3 slacks 3 blouses 6 shirts 4 tops 4 dresses Towels 10 bath towels 10 hand towels 14 wash cloths 1 bathmat Delicates 3 camisoles 1 quilted robe 4 slips 4 panties 2 bras 2 nighties 1 baby s dress Make Selections AWARNING To reduce the risk of fire electric shock or injury to persons read the Important Safety Instructions on page 3 before operating your washer Select a Water Level To set the correct water level turn the Water Level Selector to the level that describes the size of your wash load The water level can be set to wash any load between EXTRA SMALL a few small items and LARGE a full load To chang
19. e the water level after the washer has started to fill turn the selector to the desired water level Select Water Temperatures Choose a wash temperature top and a rinse temperature bottom by turning the Temperature Selector to the desired temperature combination Refer to the Water Temperature Guide page 7 for recommended water temperatures Select a Wash Cycle To select a wash cycle push the Cycle Control Selector in and turn to the right Stop at the NORMAL setting in the wash cycle of your choice For garments with lower soil levels that may require less washing time the REGULAR HEAVY and PERMANENT PRESS Cycles also offer a LIGHT setting Start the washer by pulling the Cycle Control Selector out WATER LEVEL SMALL MEDIUM coLD EXTRA SMALL Water level selector Each cycle has been designed for different kinds of fabrics When a cycle has been chosen and the knob is pulled out the washer fills before the agitation and timing Starts After agitation begins the washer automatically times each part of the selected cycle until it ends and the washer shuts off You may hear the sound of water spraying during the spin of some cycles as cold water is sprayed on the spinning load to help with rinsing To stop the washer at any time push the Cycle Control Selector in To restart the washer pull the Cycle Control Selector out IMPORTANT If you are using a fabric softener do not stop the washer befo
20. el in the washer If it isn t e The washer may seem to be draining during wash and rinse cycles Water can siphon out See Installation Instructions 2 If the problem is not due to one of the above items Call KitchenAid Consumer Relations TOLL FREE 1 800 422 1230 and talk with one of our trained consultants The consultant can instruct you in how to obtain satisfactory operation from your appliance or if service is necessary recommend a qualified service company in your area e If you prefer write to Consumer Relations Department KitchenAid P O Box 558 St Joseph MI 49085 0558 Please include a daytime phone number in your correspondence 3 If you need service e Call your dealer or the repair service he recommends e All service should be handled locally by the dealer from whom you purchased the unit or an authorized KitchenAid servicer e If you are unable to obtain the name of a local authorized KitchenAid servicer call our service assistance number see Step 2 4 If you are not satisfied with the action taken e Contact the Major Appliance Consumer Action Panel MACAP MACAP is a group of independent consumer experts that voices consumer views at the highest levels of the major appliance industry e Contact MACAP only when the dealer authorized servicer or KitchenAid have failed to resolve your problem Major Appliance Consumer Action Panel 20 North Wacker Drive
21. ey are fresh 2 Before treating any stain find out e What kind of stain it is What kind of fabric it is and how colorfast it is check label How old the stain is Washing and drying can set some stains 3 Heat hot or warm wash or dryer can make some stains permanent Pre treat such stains or soils before washing 4 When bleach is recommended use a bleach that is safe for the fabric See comments on bleach use page 19 5 Test stain remover on an inside seam or hidden corner of the item to see if color is removed 6 Put the stained area face down on a paper towel or white cloth Apply the stain remover to the back of the stain This can force the stain off the fabric instead of through it 7 Ameat tenderizer or enzyme pre soak will help break down some protein stains so they will be easier to remove 8 Use dry cleaning solvents in a well ventilated room 9 Stubborn stains may require more than one treatment Do not machine dry between washings or stain may become set The following items are often used in stain removal and may be kept on hand e Ammonia Alcohol denatured or rubbing e A bar of soap e Bleach e Meat tenderizer e Non flammable dry cleaning solvent e Pre wash soil and stain removers liquid spray powder enzyme pre soak products Pay attention to warnings and cautions on the product labels 22 Alcoholic Beverage These stains turn brown with age so trea
22. f a blend of synthetic fiber and a cellulosic fiber such as cotton or rayon at least 50 synthetic fiber in blend also hold their size better than those of cotton or rayon 1 Select cycle wash temperature and time depending upon fiber content construction of garment amount of soil and colorfastness 2 Follow garment manufacturer s recommendations on the care label or hang tag 3 To prevent snagging close zippers fasten hooks and eyes and turn wrong side out 4 Sort properly White synthetic fiber items pick up color readily from other items 5 Wash small loads to reduce pilling and lint generation on items 28 For Service or Assistance Follow These Steps 1 If your washer should fail to operate review the following list before calling your dealer You could save the cost of a service call If your washer does not fill Is the power supply cord plugged into a live circuit with the proper voltage e Are both water faucets open e Has a fuse blown or is the circuit breaker open e Are the water supply hoses kinked If your washer does not spin e Is the lid closed e Is the power supply cord plugged into a live circuit with the proper voltage e Has a fuse blown or is the circuit breaker open If your washer stops during a cycle e Remember the washer pauses briefly between each portion of every cycle The pauses are normal Make sure the drain hose is higher than the water lev
23. g for Special Items Most items have care labels with laundering instructions Always follow label directions when they are available General laundering instructions for some special washables are included in this section Blankets and Woolens e Electric Blankets check manufacturer s recommendations e Woolen Blankets e Washable Woolen Garments 1 Measure blanket or trace outline of garment before washing 2 If binding is extremely soiled brush with a concentrated solution of soap or detergent 3 Add detergent or mild soap and water conditioner to basket Fill and agitate briefly to dissolve detergent 4 Stop washer unfold blanket Load in washer evenly around agitator Soak 10 to 15 minutes 5 Start washer Set control to drain and spin Spin about 1 minute See washer instructions 6 Fill washer for deep rinse If you wish to use a fabric softener to increase fluffiness or reduce static electricity add it during the deep rinse Allow the washer to rinse drain and spin 7 Lay item on flat surface and block by gently stretching to original measurement Woolens tend to shrink more the first time they are washed This is normal For best results follow the care label drying instructions To dry on line choose a breezy day and hang blanket in shade over two lines Pin binding edges together over line and straighten edges When blanket is partially dry change position and straighten again When dr
24. hazard or explosion later e if you do not use your bleach Soap or detergent is used to help dispenser e Loosen and remove soil from items 1 Let the washer fill and begin in the load agitating the load and detergent e Hold soil and lint in the water so 2 Dilute measured bleach in they can be drained away with 1 quart of water the water 3 Pour diluted bleach around if too little soap or detergent is used soil and lint can settle back on the clothes agitator not directly on the load 19 All Fabric Bleach Powdered or liquid ail fabric bleach may be used on all types of fabrics Use according to package directions with detergent Do not use all fabric bleach in the bleach dispenser because it may clog Bluing Dry bluing beads or flakes may be added to the basket before adding soap or detergent Liquid or tablet bluing should be mixed with 1 quart of warm water and added to the deep rinse Follow package directions carefully Ammonia Ammonia helps detergent work better by helping to cut grease and heavy soil AWARNING Personal Injury Hazard Never use chlorine bleach with ammonia or acids such as vinegar or rust remover Hazardous fumes can be formed Pretreatment Products Always follow the manufacturer s instructions with any pretreatment product Aerosol applications remove oily soils on both cotton and polyester fabrics better than pump or squirt applications Enzyme Laundry Products
25. is to treat with salt and lemon juice and dry in direct sunlight Rinse and re wash Mustard Treat immediately Scrape off excess mustard Sponge with a non flammable dry cleaning solvent or a pre wash soil and stain remover Rinse Work liquid detergent and a few drops of vinegar into stain Rinse If stain remains apply 3 hydrogen peroxide Rinse and wash Paint Water base Treat stains while still wet These paints cannot be removed after they have dried Rinse in warm water to flush out paint Sponge with a non flammable dry cleaning solvent and then wash Oil base Scrape off fresh paint Sponge with a non flammable dry cleaning solvent or treat stain with recommended thinner While stain is wet with solvent rub liquid detergent into it Wash with hottest water Safe for fabric 24 Perspiration Remove stains before ironing Perspiration stains may weaken fabric Wash or sponge stains thoroughly with detergent and warm water If perspiration has changed the color of the fabric use one of the following treatments Fresh stains Apply ammonia to stains Rinse Launder to remove ammonia odor Old stains Apply white vinegar to stains Rinse Launder to remove vinegar odor Scorch Severe scorch cannot be removed Wet stain with 3 hydrogen peroxide Cover with a dry cloth and press with an iron as hot as is safe for fabric Rinse well Wash or wet with lemon juice and spread in the sun to dry Wash Carin
26. ll automatically stop in a few seconds If the hot water system has not been used for a period of 2 weeks or more hydrogen gas may build up in water heater and hot water pipes Hydrogen gas is explosive If the hot water system has not been used for such a time period turn on all hot water faucets and let the water flow from each for several minutes before using the washing machine This will allow gases to escape Do not smoke or use an open flame during this procedure Do not install or perform any servicing unless you are qualified Improper installation repair or servicing can result in personal injury or fire hazard SAVE THESE INSTRUCTIONS You Are Responsible For YOU ARE RESPONSIBLE FOR MAKING SURE THAT YOUR WASHER e s installed by a qualified installer Is properly maintained e Is properly installed and leveled on a floor that can support the weight e Is located in an area where the temperature will not fall below freezing e Is properly connected to the right water supply and drain e Is used only for its intended function e ls not run where there may be explosive fumes eis not used by children or anyone unable to operate it properly ALWAYS unplug the power supply cord or turn off electrical power before attempting to service the washer DO NOT machine wash glass fiber materials Small particles can stick to fabrics washed in subsequent loads and cause skin irritation ALWAYS read and follow instr
27. moval TIPS c cceceeeecceeeeeees 22 24 Caring for Special Items o n 25 28 For Service or ASSIStANCE eeen 29 KitchenAid Washer Warranty BACK COVER 1990 KitchenAid Important Safety Instructions AWARNING To reduce the risk of fire electric shock or injury to persons when using the washer follow basic precautions including the following Read all instructions before using the washer Your washer should be installed in an area protected from weather Your washer should be connected to a properly grounded 3 prong outlet and the correct electrical supply See the Installation Instructions for complete information Never wash articles in the washer that have been spotted cleaned washed or soaked in gasoline wax paint or other flammable fluids The fumes can create a fire hazard or explosion Never add these materials to your washer and never use them near your washer Always hand launder and air dry fabrics treated with flammable fluids Never allow children to play on or in the washer Close supervision is necessary when this or any appliance is used near children Before your washer is removed from service or discarded always remove the lid to prevent accidental entrapment Do not tamper with controls Do not reach into the washer basket while it is filling with water while the agitator is moving or while the basket is spinning If the lid is opened while the basket is spinning the basket wi
28. nutes High Speed v DRAIN No Agitation v SPIN Medium Speed v WASHER STOPS Select Wash Cycle Special stains may need special treatment See Stain Removal Tips pages 22 24 Regular Heavy C yele This cycle is used for heavily soiled items and fabrics of sturdy construction such as work clothes denim jeans and coveralls Cycle Sequence is as follows FILL to Selected Level v WASH Normal 10 Minutes High Speed OR Light 6 Minutes High Speed v DRAIN No Agitation v SPIN Medium to High Speed v FILL for Deep Rinse v RINSE High Speed v DRAIN No Agitation v SPIN Medium to High Speed 2 Spray Rinses SMALL WATER LEVEL WASH RINSE WARM MEDIUM Permanent Press Cycle This cycle features a COOL DOWN rinse that occurs before the total wash time has elapsed The cool down rinse helps to keep wrinkles from setting into synthetic fabrics and clothes with a permanent press finish Cycle Sequence is as follows FILL to Selected Level v WASH 4 Minutes High Speed v WASH 4 Minutes Low Speed v PARTIAL DRAIN Pause v REFILL COOL DOWN v WASH 2 Minutes High Speed v DRAIN No Agitation v SPIN Medium Speed v FILL for Deep Rinse v RINSE High Speed v DRAIN No Agitation v SPIN Low to Medium to High Speed 2 Spray Rinses NORMAL setting features both High and Low Speed washes LIGHT setting features Low Speed wash only
29. ny suds are generated by the recommended amount of your detergent try a low suds detergent Do not reduce the amount of your current detergent to less than the recommended amount as clothes may not become clean 10 Add Sorted Wash Load Add the wash load before starting the wash cycle When clothes are added to the washer after the tub is full of water the washer may tend to become overloaded IMPORTANT Do not overload Overloading or packing can e cause poor cleaning e increase wrinkling cause excessive lint e wear out items faster example pilling e tear clothing Refer to page 11 for loading suggestions Loading Tips Load by the amount of space items take up e Drop items in loosely filling to the top of the basket Do not wrap around agitator because damage to clothing may result e Load evenly to maintain washer basket balance during washing and spinning An off balance load can cause the washer to vibrate during a spin cycle e Mix large and small items in each load for ease of load movement through the wash water This will help give the best cleaning with wrinkle free results If the washer is loaded correctly items will go below the water surface and reappear later e To reduce wrinkling permanent press and synthetic knits should have more room to move in the water than items such as towels and jeans e When washing very large items such as king or queen size sheets do not loa
30. or brown stains and washer parts Follow package directions for the correct use Tints and Dyes Use tints and dyes in the washer according to instructions on the package When you are finisned with the tinting process put chlorine bleach and detergent in the washer Run through a complete cycle using hot water to remove excess dye or tint If staining occurs on subsequent loads repeat the above process IMPORTANT Washer parts such as the agitator washer lid etc may pick up dye color Parts may be permanently discolored Disinfectants You may want to use a disinfectant when Someone has an infection or a contagious illness e Someone other than your family uses the washer e You use cold water for washing To disinfect a load e Select a disinfectant safe for the fabrics and colors in the load Read and follow the package label carefully e Note any cautions e Measure disinfectant carefully and according to instructions e Do not use any disinfectant other than liquid chlorine bleach in the bleach dispenser To disinfect the washer e Set the controls for a hot wash with a low water level e Pour cup liquid chlorine bleach into the basket e Run the washer through a complete cycle Starch Starch adds crispness and body to fabrics It is available in spray or powder form Follow the package directions carefully 21 Stain Removal Tips 1 Most stains are easier to remove when th
31. re difficult to wash clean 2 Remove stains as soon as possible Pretreat stains or heavy soils with a liquid detergent a 26 paste made from your regular detergent or a special pretreatment product 3 Sort properly Always wash whites in a separate load to prevent color pick up from other garments 4 Wash small loads Crowding in the washer can cause wrinkling 5 Select wash time and water temperature according to amount of soil 6 Use a cold rinse 7 Add a diluted fabric softener in deep rinse to reduce the static electricity that attracts lint and makes garments cling 8 Follow instructions on the garment s label for proper use of bleach 9 Tumble dry for best results and remove load as soon as tumbling stops to help prevent setting in wrinkles Pillows and Stuffed Toys e Feather e Polyester if manufacturer suggests machine washing e Foam 1 Be sure pillow covers are securely stitched 2 Partially fill washer with water add detergent agitate until detergent is dissolved 3 Place two pillows in washer on opposite sides of agitator to balance load 4 Allow washer to completely fill and continue through cycle 5 Stop the washer occasionally to press air from item being washed IMPORTANT Washing feather pillows is not recommended unless they are dryer dried 6 Dry foam rubber items without heat air dry cycle AWARNING Fire Hazard Do not dry foam rubber items on hea
32. re the final rinse Staining can occur Self Clean Lint Filter As load items are being washed lint particles from the wash water automatically collect on the SELF CLEAN LINT FILTER located between the basket and tub As the washer drains collected lint is carried away with the wash and rinse water If the washer drains into a tub remove any lint collected in the drain or strainer WASH RINSE WARM COLD Temperature selector EXTRA WASH NORMAL OFF LIGHT PRE WASH OFF SPIN REGULAR HEAVY RINSE SPIN SPIN gt OFF NORMAL NORMAL OFF LIGHT SPIN PERMANENT PRESS KNITS DELICATES Cycle contro selector Pre Wash Cycle Extra Wash Cycle Heavily soiled items that require Heavily soiled items that require maximum soil removal or stained maximum soil removal may be run items that need extra care may through the EXTRA WASH Cycle need to be pre washed for best Double the recommended cleaning amount of detergent when using A brief period of pre washing this cycle helps loosen soils and remove stains Cycle Sequence is as follows Anag NE PREWASH FILL To Selected Level Cycle use enough detergent for v one wash Add detergent again when setting the washer for one of WASH F Minutes HighSpeed the other wash cycles M PARTIAL DRAIN Pause v Cycle Sequence is as follows Washer Automatically Advances to the FILL to Selected Level REGULAR HEAVY CYCLE v PRE WASH 4 Mi
33. t immediately Sponge or soak fresh stains with cold water Wash If stains remain soak 15 minutes in a solution of lukewarm water liquid detergent and a few drops of white vinegar Rinse and re wash Blood Rinse immediately or soak in cold water with enzyme pre soak for 30 minutes or longer Rinse Rub detergent into any remaining stains Rinse If stains remain put a few drops of 3 hydrogen peroxide on stain for 3 5 minutes Rinse thoroughly Wash Chocolate or Coffee Sponge immediately with a non flammable dry cleaning solvent or apply a pre wash soil and stain remover Wash If stain remains apply a liquid detergent to stain or soak in warm water with an enzyme pre soak Re wash Chewing Gum Use ice to make gum hard Scrape off what you can Sponge with a non flammable dry cleaning solvent Let dry Wash Crayon and Candie Wax Scrape off excess wax with dull knife Sponge with a non flammable dry cleaning solvent Wash If stain remains soak in an enzyme pre soak or all fabric bleach Wash Cream Milk or Ice Cream Sponge with a non flammable dry cleaning solvent or a pre wash soil and stain remover Wash Repeat if necessary If stains remain apply a few drops of liquid detergent and a few drops of ammonia Blot and rinse If stains remain soak in an enzyme pre soak Wash Deodorants and Antiperspirants Light stain Treat with liquid detergent or your regular laundry detergent Wash in hottest water
34. t setting of dryer Use air setting or line dry Drying in a heated dryer can damage items or be a FIRE HAZARD Kes estrada a Plastic and Rubber Items e Shower Curtains e Table Cloths Baby Panties Treat as delicate items Wash in warm water Wash small items in a mesh bag Dry without heat Quilts and Bedspreads Treat quilted items as delicate items e Wash one quilt or bedspread at a time Distribute evenly around agitator e if dried on a line shake occasionally for best results dry in a dryer e Do not wash cotton filled comforters unless they are quilted or stitched cotton batting when only tucked tends to slip and become lumpy e Do not overload Some items may be too large for the washer Scatter Rugs 1 Check label to be sure rug is washable and colorfast 2 Snake or vacuum well 3 Pre wash or soak rug if it is badly soiled 4 Wash more than one small rug at a time If you wash only one small rug add bath towels to balance the load A larger rug should be distributed around the agitator to balance the load Remember for good washing results the rug should move freely during agitation Snowsuits Vests Jackets Etc e Nylon e Polyester Base Follow the care label instructions to select the proper water temperature and cycle Pre soak items before washing if badly soiled Wash only one jacket or snowsuit at a time Load item in washer evenly around the
35. tergent Common Washing Problems and Causes Problem Cause Brown or Yellow Stains e chlorine staining e iron in water heater or pipes iron and manganese in water e rust spots in washer basket see page 17 for tips on washer care Dye Transfer e improper sorting load left in washer Gray Whites or Dingy Colors e improper sorting e water temperature too low e not enough detergent e using soap in water that is too hard Greasy Looking Spots Lint H e undiluted fabric softener e fabric softener in wash water e not enough detergent improper sorting e paper or tissue in pockets e pilling being mistaken for lint overloading e not enough detergent e clogged lint filter Load Too Wet After Spin cold rinses e lid is opened before spinning is completed Shrinking e fabric type some knits stretch during manufacturing and laundering returns fabric to original size e care label directions not followed Snags Rips Holes misuse of chlorine bleach e sharp articles not removed from pockets etc e overloading items damaged before washing e fasteners not fastened Stiff Rough Fabrics usually Cottons e using soap in water that is too hard use detergent if you live in a hard water area e not enough detergent e line drying Twisting Tangling e overloading e improper loading Wrinkling e overloading e load not immedi
36. uctions on packages of detergent and laundry aids especially warnings and precautions See the Installation Instructions for complete information Ownership Registration Please fill out and mail your Ownership Registration Card packed with the product The card will enable us to contact you in the unlikely event of a product safety notification and assist us in complying with the provisions of the Consumer Product Safety Act Return of the card is not necessary to validate your warranty You must provide proof of purchase or installation date for in warranty service For your own records write down the following information in the space provided below If your washer ever requires service the service technician may need this information Model Number Serial Number Date Purchased Date Installed Dealer s Name Address Phone Model and serial numbers are located on a plate underneath the lid near the hinge Clothes Washer Features Temperature selector Water level selector Cycle control selector Liquid bleach Model and serial 2s LISPENSEr number plate under lid Fabric softener dispenser Agitator Basket Self clean lint filter not shown Tub Operating the Clothes Washer Step 1 Add measured detergent See page 10 for information on detergent use Step 2 Add sorted load See page 9 for sorting information Step 3 Make selections a Select a water level b Select water temperatures
37. y brush up nap with wire or nylon brush e Cotton Rayon and Synthetic Blankets Wash as recommended for permanent press fabrics Curtains Draperies and Slip Covers Be sure fabric is washable shrink resistant and colorfast before washing Select water temperature and cycle according to type of fabric e Shake or vacuum to remove loose dirt Pre wash or soak if badly soiled e Wash small loads Crowding will cause wrinkling Dry in dryer or on the line Replace slipcovers on furniture while still slightly damp They will dry to fit tightly IMPORTANT Sun damaged curtains and draperies will tear whether hand or machine washed Diapers and Baby Clothes Rinse immediately Soak diapers in a solution of lukewarm water and a small amount of detergent until you are ready to wash them e Treat spots and stains before washing e Spin excess water from diapers before washing e Wash diapers following the Water Temperature Guide for white cottons on page 7 e Wash small items in a mesh bag IMPORTANT You may wish to use bleach or a special soaking product for soaking diapers Do not use liquid fabric softener every time Overuse of fabric softener reduces the absorbency of diapers Elastics e Elastics pick up oil from the body Since oil damages elastics wash often to help reduce the damage e Use warm enough water and sufficient detergent to remove oils Dry at lowest dryer
Download Pdf Manuals
Related Search