Keys Fitness ALL800 User's Manual
Contents
1. CUSTOMIZING PROGRAMS in P1 and P2 Mode Each pre set program Fat Burn Cardio Warm up can be customized in the P1 or P2 mode After making the program selection the CAL DIST window will read OP The OP refers to original program and is preset The pro gram name you select will display in the diode light above the program name Press the MODE button once more and the CAL DIST window will read P1 The P1 mode is now accessed You can now program the Time Speed and Incline in P1 mode which will be saved for future workouts 1 The TIME window will blink Use the SPEED or arrows to select your workout time Press ENTER PROGRAM 2 The SPEED window will then blink Use the same or arrows to select the speed for your workout Press ENTER PROGRAM 3 The INCLINE window will then blink Use the INCLINE or arrows to set your workout incline Press ENTER PROGRAM To start press the START STOP button To access P2 mode press the MODE for desired pro gram then press the MODE button again once for OP twice for P1 three times for P2 Follow the above steps 1 3 to customize P2 settings TO CHANGE A PREVIOUSLY PROGRAMMED P1 P2 or user program Once you have programmed the P1 or P2 modes you will need to use the PAUSE button to change the program you previously entered For instance to change to a new setting in P1 FAT BURN press the MODE button to access FAT BURN then twice to access P1 Then press the2. PAUSE button to get the TIME window to flash Follow the directions above to continue to change the program INCLINE SPEED FAT BURN CARDIO WARM UP 7 lance INCLINE SPEED TIME INCLINE TIME CAL DIST SPEED WV MmSPEED SERED TTT tll GC T NTER INCLINE FAT BURN CARDIO WARM UF GC MODE Caution Belore starting a ae lt is recommen ded that you consult you POWER START STOP PAUSE FITHESS Program Profiles SPEED SPEED E INCLINE 12 INCLINE 10 9 8 7 6 5 4 3 2 1 1234567 8 9 10 1234567 8 9 10 The Fat Burn Program is designed to vary the treadmill The Cardio Program is designed elevation while maintaining a to vaty the treadmill Speed while constant walking belt speed maintaining a constant Elevation ia SPEED 11 10 INCLINE 9 8 7 6 5 4 3 2 1 1234567 8 9 10 The Warm Up Program is designed to gradually increase the treadmill Speed and Elevation in the first segment warm up and gradually decrease the treadmill Speed and Elevation in the last segment cool down This is also known as a Plateau program Belt Adjustment and Tension WARNING Do not over tighten rollers This will cause premature roller bearing failure Belt adjustment and tension performs two functions adjustment for ten sion and centering Your new treadmill comes pre adjusted from the facto ry for tension and centering Please follow the procedures below if the belt shif
3. muscles and raising body temperature Begin each workout with 5 to 10 minutes of stretching and light exercise to warm up The photos on this page show several forms of basic stretching you may perform before your workouts In order to achieve an adequate warm up perform each stretch three times TOE TOUCH STRETCH Stand bending your knees slightly and slowly bend forward from your hips Allow your back and shoulders to relax as you reach down toward your toes as far as possible Hold for 15 counts then relax This will stretch your hamstrings back of knees and back HAMSTRING STRETCH DN Sit with one leg extended Bring the sole of the opposite foot toward you and rest it against the inner thigh of your extended leg Reach toward your toes as far as possible Hold for 15 counts then relax This will stretch your hamstrings lower back and groin CALF ACHILLES STRETCH With one leg in front of the other reach forward and place your hands against a wall d Keep your back leg straight and your back foot flat on the floor Bend your front leg lean forward and move your hips toward the wall Hold for 15 counts then relax To cause further stretching of the Achilles tendon bend your back leg as well This will stretch your calves Achilles tendons and ankles QUADRICEPS STRETCH With one hand against a wall for balance reach back and grasp one foot with your other hand Bring your heel as close to your butt
4. replaced under this warranty will become the property of Keys Keys reserves the right to change manufacturers of any part to cover any existing warranty To obtain warranty service you must contact a Keys authorized service technician or Keys Fitness at our phone numbers located in this manual Any parts determined to be defective must be returned to Keys to obtain warranty service You must prepay any shipping charges export taxes custom duties and taxes or any other charges associated with transportation of the parts or Product In addition you are responsible for insuring any parts or Product shipped or returned You assume the risk of loss during shipment You must present Keys with proof of purchase documents including the date of purchase Any evidence of alteration erasing or forgery of proof of purchase documents will be cause to void this Limited Warranty This warranty does not extend to any product not purchased from Keys or from an authorized Keys reseller This Limited Warranty does not extend to any Product that has been damaged or rendered defective a as a result of accident misuse or abuse b by the use of parts not manufactured or sold by Keys c by modification of the Product or normal wear and tear d operation on incorrect power supplies or e as a result of service by anyone other than Keys or an authorized Keys warranty service provider Product on which the serial number has been defaced or removed is not eligible for
5. treadmill WARNING To prevent electrical shock be sure the power to the treadmill is OFF and the unit unplugged from the wall electrical outlet before attempting any cleaning or maintenance AFTER EACH WORKOUT Wipe off the console and other treadmill surfaces with a clean water dampened soft cloth to remove excess perspiration USE NO CHEMICALS WEEKLY Use of a treadmill mat is recommended for ease of cleaning Dirt from your shoes contacts the belt and eventually makes it to underneath the treadmill Vacuum underneath treadmill once a week DECK LUBRICATION The walking belt has been pre lubricated at the factory However it is recommended that the walking board be checked periodically for lubrication to ensure optimal treadmill performance Every 30 days or 30 hours of operation lift the sides of the walking belt and feel the top surface of the walking board as far under as you can reach If you feel signs of silicone no further lubrication is required If it feels dry to the touch follow the instructions below KEYS recommends Lube N Walk for cleaning and lubricating the treadmill belt and deck Ask your retailer or call KEYS at 888 340 0482 You may also use silicone such as Napa 8300 available at most stores TO APPLY LUBRICANT TO THE WALKING BOARD 1 Position the walking belt so that the seam is located on top and in the center of the center of the walk ing board 2 Insert the spray nozzle into the spray head of the lub
6. warranty service Should any Product be submitted for warranty service be found ineligible therefore an estimate of repair cost will furnished and the repair will be made if requested by you upon Keys receipt of payment or acceptable arrangements for payment EXCEPT AS EXPRESSLY SET FORTH IN THIS WARRANTY KEYS MAKES NO OTHER WARRANTIES EXPRESSED OR IMPLIED INCLUDING ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE KEYS EXPRESSLY DISCLAIMS ALL WARRANTIES NOT STATED IN THIS LIMITED WARRANTY ANY IMPLIED WARRANTIES THAT MAY BE IMPOSED BY LAW ARE LIMITED TO THE TERMS OF THIS LIMITED WARRANTY NEITHER KEYS NOR ANY OF ITS AFFILIATES SHALL BE RESPONSIBLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS OR THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU This Limited Warranty gives you specific legal rights and you may also have other rights that may vary from state to state This is the only express warranty applicable to Keys branded products Keys neither assumes nor authorizes anyone to assume for it any other express warranty PLEASE SEND IN THE ATTACHED WARRANTY CARD WITHIN TEN 10 DAYS OF PURCHASE TO REGISTER YOUR TREADMILL WITH KEYS FITNESS PRODUCTS LP MADE IN THE USA Thank you for your business PLEASE MAIL WARRANTY CARD TO KEYS FITNESS PRODUCTS PO BOX 551239 DALLAS TX
7. with pre existing health problems The manufacturer or distributor assumes no responsibility for personal injury or property damage sustained by or through the use of this product WARNING To reduce the risk of electrical shock burns fire or other possible injuries to the user it is important to review this manual and the following precautions before operation SAFETY PRECAUTIONS AND TIPS It is the owner s responsibility to ensure that all users of this treadmill have read the Owner s Manual and are familiar with warnings and safety precautions This treadmill has a user maximum capacity of 250 pounds The treadmill should only be used on a level surface and is intended for indoor use only The tread mill should not be placed in a garage patio or near water and should never be used while you are wet KEYS recommends a treadmill mat be placed under the treadmill to protect floor or carpet and for easier cleaning Follow safety information in regards to plugging in your treadmill Keep the power cord away from the incline wheels and do not run the power cord underneath your treadmill Do not operate the treadmill with a damaged or frayed power cord Wear comfortable good quality walking or running shoes and appropriate clothing Do not use the treadmill with bare feet sandals socks or stockings Always straddle the belt and allow it to start moving before stepping onto the belt Hold on to handrails
8. 75355 OR REGISTER ONLINE AT www keysfitness com KEYS FITNESS TREADMILL WARRANTY REGISTRATION TELEPHONE RaT ast LILI FICO ooo ooo ooo ADDRESS APT NO HWW OULU LILI CITY STATE ZIP OOOOOOCOOOOLOOOOOO UU DATE OF PURCHASE MODEL NO SERIAL NO MILO OUI OO DUI Name of store or company where Where did you learn about treadmills f How important are each feature Other Comments purchased TV__ Radio ___ Friend___ Least Unique Features In Store Display Salesperson __ Horsepower How do you plan to use the treadmill Warranty Walk__ Run____ Both____ Print ad flyer Internet Price Look Design Folding Feature Who will use the treadmill Why did you purchase a treadmill Male Female Both Dr s Orders Loose Weight KEYS FITNESS respects the rights of your privacy Our How many family members In home convenience company will not sell or distribute to others the information Improve Cardiovascular Fitness above This information is used to track our product Safety from outdoors a quality and to contact you in the event of a product safety AGE 15 24 25 34 concern It may be used to offer you future Keys products 35 44 45 54 Other only through the mail Please check here if wish not to 09 64 OD F __ receive any additional information on Keys products C
9. NCE WINDOW SPEED WINDOW INCLINE SPEED TIME INCLINE TIME CAL DIST SPEED SPEED BEERS H IIl ECD INCLINE FAT BURN CARDIO WARM UP y Caution Before starting any exercise program it le recommended that you coneult your physician For your safety plassa reed the manual carefully before using the treadmill rower MADE IN UL Program and Operating Instructions QUICK START MANUAL MODE 4 gt gt Plug into a surge protector outlet Attach the Red Safety Key on to the treadmill console Stand on the treadmill and straddle belt Attach safety key clip to your clothes Press POWER button There will be an eight 8 second delay after pressing the POWER button before data can be entered The TIME window will flash Press START STOP button Belt will begin to move after 4 seconds Step on belt slowly after the belt starts moving Speed or incline may be adjusted by using the appropriate increase or decrease button To end your workout press START STOP button Belt will gradually slow to zero To pause your workout press PAUSE To re start after pausing Press the PAUSE button WARNING THE TREADMILL BELT WILL RESUME AT THE SPEED THE TREADMILL WAS MOVING BEFORE PAUS ING Countdown Time Preset Speed and or Incline Time Speed and Incline may be preset prior to get ting started After pressing the POWER button the time window will blink Use the SPEED o
10. ale FITNESS ALLIANCE 800 TREADMILL OWNER S MANUAL Model Name ALL800 Serial Number Purchase Date Write down for future reference Keys Technical Service 888 340 0482 KEYS Fitness Products LP P O Box 551239 Dallas TX 75239 1239 Part 15 0131 keysfitness AJ Table of Contents Information Page Table of Contents 2 Specification Sheet 3 Important Safety Information 4 Before You Start 5 Warm Up Exercises 6 Assembly Moving Instructions 7 Power Requirements Console Functions and Descriptions 9 Program and Operating Instructions 10 amp 11 Program Descriptions and Profiles 12 Belt Adjustments and Tension 13 Change to MPH or Km H 14 Maintenance Instructions 15 Troubleshooting Guide 16 Error Messages 17 Calibration Sequence 18 Parts and Diagrams 19 Warranty Registration Mail In Form 20 Specification Sheet Horsepower Continuous 2 0hp Display Type 4 Window LCD Electronics Push Button Pre Set Programs 3 Semi Custom Programs 6 Power Incline 0 12 Roller Diameter 1 9 Cushioned Deck Yes Speed Range 0 10mph Belt Size 18 x 51 Side Hand Rails Yes Foot Print 29 X02 Folded Foot Print 2 x20 Warranty Motor 10 Years Warranty Parts 2 Years Warranty Labor 1 Year Warranty Frame Lifetime Important Safety Information WARNING Before using this treadmill or starting any exercise program consult your physician This is especially important for persons over the age of 35 and or persons
11. d tear only manufacturer defects for the periods specified Keys warrants that the Product you have purchased for non commercial personal family or household use from Keys or from an authorized Keys reseller is free from defects in materials or workmanship under normal use during the warranty period Your sales receipt showing the date of purchase of the Product is your proof of the date of purchase This warranty only extends to you the original purchaser It is not transferable to anyone who subsequently purchases the Product from you It excludes expendable parts This Limited Warranty becomes VALID ONLY if the treadmill is assembled installed by a Keys Fitness authorized dealer technician unless otherwise authorized by Keys Fitness in writing if anyone other than a Keys Fitness authorized dealer technician assembles a Keys Fitness treadmill the warranty will be void unless accompanied by written authorization by Keys Fitness Select models do not require assembly and the original purchaser During the warranty period Keys will at no additional charge repair or replace at Keys option the part or product if it becomes defective malfunctions or otherwise fails to conform with this Limited Warranty under normal non commercial personal family or household use In repairing the Product Keys may replace defective parts or at the option of Keys serviceable used parts that are equivalent to new parts in performance All exchanged parts and Products
12. e direction Plug the power cord back into the surge protector and run the treadmill at 2 5 mph You should now walk on the belt to determine if the belt is still slipping Repeat the above procedure until the walking belt is not slipping The tension should be just tight enough not to slip Turning the hex key counter clockwise brings the rear rollers and belt towards you Q Turning the hex key clockwise pushes the rear roller and belt away form you Change Miles per hour to Kilometers per hour Your treadmill will operate in British Units miles per hour or International Units kilometers per hour All treadmills are calibrated at the factory for British Units miles per hour To change the display to read in kilometers follow the steps described here 1 Turn power OFF on the console Do not unplug treadmill Attach the magnet safety key to the con sole 2 Activate the calibration mode switch by inserting the eraser end of a pencil into the opening in the backside of the console see diagram below 3 Depressing the calibration mode switch ONCE CL11 should appear in the TIME window 4 Pressing the SPEED button will activate your choice 5 To accept the setting press the POWER button Maintenance Instructions WARNING Before performing any maintenance to your treadmill always unplug the power cord from the surge protectot CLEANING Routine cleaning of your Keys Fitness treadmill will extend the life of your
13. en press the switch back in 2 Check the house electrical breaker box and the circuit breaker for the room where the treadmill is located If it has tripped reset or have an electrician replace the breaker in home 3 If the treadmill still will not operate please call Keys Technical Service at 888 340 0482 Treadmill walking belt slows during use 1 Check to make sure the treadmill is securely plugged into an UL listed surge protector rated at 15 amps with a 14 cauge cord of five feet or less and the surge protector is securely plugged into the outlet 2 If treadmill still will not operate please call Keys Technical Service at 888 340 0482 Treadmill walking belt slips or is not centered on rear roller 1 Refer to Belt Adjustment and Tension section on page 13 2 Need help Call Keys Technical Service at 888 340 0482 gt Error Messages Treadmill Error Messages Your treadmill is equipped with a software package that enables error messages to be displayed when there is a problem The following error codes will be displayed in the console display win dows Safety Interlock Error Messages SI 1 Safety key missing replace and try again SI 2 Over voltage protection trip Notify Keys Fitness Technical Service SI 3 Tilt Switch Trip Notify Keys Fitness Technical Service Other Error Messages E11 Lack of speed feedback data from belt motor Attempt re calibration See Calibration Seque
14. ill be flashing in the Speed window pressing the Speed button will toggle options Choose MPH KPH press Enter 7 CL22 8 10 or 12 13 16 or 20 in KPH mode will be displayed in the Speed window pressing the Speed button will toggle options Choose 10 or 16 for KPH mode press Enter 8 CL23 FFF UUU or HHH will be displayed in the Speed window pressing the Speed button will toggle options Choose FFF press Enter 9 CL24 111 or 222 will be displayed in the Speed window pressing the Speed button will toggle options Choose 111 press Enter 10 CL25 AL1 or AL2 will be displayed in the Speed window pressing the Speed button will toggle options Choose AL2 press Enter 11 CL26 OPA or OPI will be displayed in the Speed window pressing the Speed button will tog gle options Choose OPA press Enter 12 CL27 Blank nothing a b c or d will be displayed in the Incline window pressing the Speed button will toggle options Choose Blank press Enter 13 CAL DIST window will display E Press Enter 55 will display in CAL DIST window 14 Press Start Stop 15 At this time make sure you are not standing on the walking belt as the machine will automatically initiate belt movement and run through a complete calibration and diagnostic routine Press Enter belt will begin to move unit will begin self calibration 16 When Speed and Incline calibration has fin
15. ished press Power button twice display should blank and treadmill should be ready for use To avoid possible damage to the treadmill and the possibility of injury do not operate the treadmill until the problem is corrected Call Keys Technical Service at 888 340 0482 Parts amp Diagrams Please review the following drawing below to familiarize yourself with the listed parts This man ual covers several treadmills so the one pictured below may not be identical to your particular model OS ooN aca BW NY e 10 11 12 13 Left Side Extrusion Rail Right Side Extrusion Rail Treadmill Belt Front Roller Assembly Rear Roller Treadmill Deck End Cap L R Elevation Motor actuator Pan Motor Base Pan Center Base Pan End Base Small Fan Motor Poly V Belt Motor Hood Cover Top gt Part 05 0036 05 0036 04 0025 24 0218 09 0013 03 0011 06 0008 12 0022 06 0018 06 0019 06 0020 06 0080 12 0023 04 0004 06 0105 Alliance 800 Treadmill manfactured by KEYS FITNESS PRODUCTS LP LIMITED WARRANTY PLEASE CONSULT YOUR PHYSICIAN BEFORE USING THIS PRODUCT This Limited Warranty applies in the United States Canada and Mexico to products manufactured or distributed by Keys Fitness Products LP Keys under the ALLIANCE brand name The warranty period to the original purchaser is lifetime on the frame 10 years on the motor 2 years on parts and 1 year labor This warranty does not cover wear an
16. nce section for detailed information E22 Under Speed condition detected from the belt motor Attempt re calibration See Calibration Sequence section for detailed information E33 Over Speed condition detected from the belt motor Attempt re calibration See Calibration Sequence section for detailed information To avoid possible damage to the treadmill and the possibility of injury do not operate the treadmill until the problem is corrected Call Keys Technical Service at 888 340 0482 Calibration Sequence our treadmill is equipped with a software package that will perform a calibration sequence unique to your specific model number Please perform the following steps to calibrate the KEYS ALLIANCE 800 TREADMILL 1 Unplug power cord from outlet strip 2 Attach Safety Key to console 3 Plug power cord into outlet strip 4 Initiate calibration sequence Locate hole on the back of the console and insert the eraser end of a pencil through the hole and press the calibration switch twice As show on page 14 5 CL21 should appear in the Time window if not continue to press the calibration switch until CL21 appears Note During the calibration sequence the Time window will display which step you are at in the process C21 C22 C23 and so on The CAL DIST window will display which key should be entered next For example E for Enter P for Power or SS for Start Stop 6 CL21 MPH or KPH w
17. ocks as possible Hold for 15 counts then relax This will stretch your quadriceps and hip muscles a INNER THIGH STRETCH Sit with the soles of your feet together and your knees outward Pull your feet toward your groin area as far as possible Hold for 15 counts then relax This gt iP will stretch your quadriceps and hip muscles Assembly Moving Instructions Assembly This KEYS treadmill is shipped in one piece and fully assembled After opening the box remove any packing materials from the treadmill Do not throw away any packing materials until the unit is working properly Place the base on a clean level surface Make sure the electrical cord will easily reach an electrical outlet Moving CAUTION TO AVOID THE RISK OF INJURY NEVER ATTEMPT TO MOVE THE TREADMILL WHILE IT IS IN THE UNFOLDED OPERATING POSITON TO REDUCE THE POSSIBILITY OF INJURY WHILE LIFTING BEND YOUR LEGS AND KEEP YOUR BACK STRAIGHT AS YOU RAISE THE TREADMILL LIFT USING YOUR LEGS NOT YOUR BACK IN ORDER TO RAISE OR LOWER THE TREADMILL SAFELY YOU MUST BE ABLE TO LIFT 45 POUNDS 20KG IT IS SUGGESTED YOU ALWAYS USE THE AID OF A SECOND PERSON WHEN MOVING THE TREADMILL With the treadmill in the folded locked position safety latch is engaged grasp the handrails and place one foot on the base as shown in the photo below Next with a firm grasp on handrails place one foot on the center of the base crossbar and carefully tilt the treadmill back until i
18. r arrows to select your workout time then press the ENTER PROGRAM button The SPEED win dow will now be flashing Using the same or arrows select the speed for your workout then press ENTER PROGRAM Now the INCLINE window will be flashing Use the INCLINE or arrows to set your workout incline then press ENTER PROGRAM To start press the START STOP button SPEED TIME INCLINE 4 ee _ _ _ i mar rm eee INCLINE CAL DIST SPEED SPEED SEES alil Iil INCLINE FAT BURN CARDIO WARM UP Caution Before starting any exercise program it is recommended that you consult your physician For your safety please read manual carefully before using the treadmill Program and Operating Instructions PROGRAM MODE Plug treadmill into a surge protector outlet Attach the Red Safety Key on to the treadmill console Stand on the treadmill and straddle belt Attach safety key clip to your clothes Press POWER button There will be an eight 8 second delay before data can be entered The TIME window will flash There are three 3 pre set and six 6 semi custom pre set programs on the ALL800 The treadmill includes FAT BURN CARDIO and WARM UP programs To select the program press the MODE button until desired program is illuminated on console Press START STOP button Belt will begin to move after 4 seconds Step on belt slowly after the belt starts moving
19. ricant can 3 While lifting the side of the walking belt position the spray nozzle between the walking belt and the board approximately 6 from the front of the treadmill Apply the silicone spray to the walking board moving from the front of the treadmill to the rear Repeat this on the other side of the belt Spray approximately 4 seconds on each side 4 Allow the silicone to set for one minute before using the treadmill WARNING Do not over lubricate the walking board Excess lubricant should be wiped off with a clean towel Troubleshooting Guide Treadmill will not start 1 Is the Safety Key inserted into the treadmill Console 2 Make sure the power cord is plugged into a surge protector the surge protector is plugged into a properly grounded outlet and the surge protector is turned on Refer to Power Requirements on page 8 3 Check the circuit breaker located on the front of the treadmill If the switch protrudes it has tripped Wait five minutes and then press the switch back in 4 Check the house electrical breaker box and the circuit breaker for the room where the treadmill is located If it has tripped reset or have an electrician replace the breaker in home 5 Have an electrician check for inadequate voltage at the outlet Treadmill loses power during use 1 Check the circuit breaker located on the front of the treadmill If the switch protrudes it has tripped Wait five minutes and th
20. t please read the Owner s Manual and become familiar with the operation of your new Remember to take the time to perform the stretching exercises provided to avoid injury Do not stand on the walking belt while pressing the Power button or Start Stop button Always adjust the speed of the treadmill in small increments as this treadmill is capable of high If you are taking medication consult your physician to see if the medication will affect your exercise If you have heart problems you are not active and or ate over the age of 35 years do not use the pre set treadmill programs or start an exercise program without first contacting and receiving approval To avoid the risk of electrical shock always keep the console dry Do not spill liquids on the console KEYS recommends a sealed water bottle for beverages consumed while using the treadmill Please review the following drawing below to familiarize yourself with the listed parts This manual covers several treadmills so the one pictured below may not be identical to your par SAFELY LATCH 4 REAR ROLLER ADJUSTMENT BOLTS Warm Up Exercises EXERCISE GUIDELINES WARNING Before beginning this or any exercise program you should consult your physician This is especially important for individuals over the age of 35 or individuals with pre existing health problems Warming up prepares the body for the exercise by increasing circulation supplying more oxygen to the
21. t rolls freely on the wheels Using extreme caution move the treadmill to the desired location To set the treadmill down place one foot on the center of the base crossbar and carefully lower treadmill onto base in resting position Do not attempt to move the treadmill over an uneven or rough surface Power Requitements IMPROPER CONNECTION OF THE EQUIPMENT GROUNDING CONNECTOR CAN RESULT IN A RISK OF AN ELECTRIC SHOCK CHECK WITH A QUALIFIED ELEC TRICIAN OR SERVICE MAN IF YOU ARE IN DOUBT AS TO WHETHER THE PROD UCT IS PROPERLY GROUNDED DO NOT MODIFY THE PLUG PROVIDED WITH THE PRODUCT IF IT WILL NOT FIT THE OUTLET HAVE A PROPER OUTLET INSTALLED BY A QUALIFIED ELECTRICIAN This treadmill can be seriously damaged by sudden voltage changes in your home s electrical power Voltage spikes surges and noise interference can result from weather conditions or from other appliances being turned on or off To reduce the possibility of treadmill damage always use a surge protector not included with your treadmill Surge protectors can be purchased at most hardware stores The manufacturer recommends a single out let surge protector with UL 1449 rating as a Transient Voltage Surge Suppressor TVSS with UL sup pressed voltage rating of 400V or less and an electrical rating of 120VAC 15 amps This treadmill must be grounded to reduce the risk of electrical shock Grounding provides a path of least resistance for electric current should the
22. treadmill malfunction This treadmill comes with an electri cal cord with an equipment grounding conductor and a grounding plug Always plug the power cord into a sutge protector and plug the surge protector into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances This product is for use on a nominal 120 volt circuit and has a grounding plug that looks like the plug illustrated in the drawing below GROUNDED OUTLET BOX TREADMILL POWER CORD GROUNDING PLUG GROUNDING PLUG GROUNDING PIN GROUNDING PIN GROUNDED OUTLET SURGE PROTECTOR lt gt Console Functions and Descriptions There are four display windows on the control panel to provide feedback information TIME WINDOW TIME Indicates elapsed time after pressing start in minutes and seconds 0 99 minutes 0 59 seconds INTERVAL TIME Indicates countdown in seconds to the next interval starting at 5 seconds and counting to 0 seconds SPEED WINDOW SPEED Indicates MPH miles per hour or KMH kilometer per hour in 1 increments CALORIE DISTANCE WINDOW DISTANCE Indicates Miles or Kilometers traveled in 01 increments up to 9 99 and 1 increments starting at 10 0 CALORIE Indicates estimated calories used based on 150 Ib person at the indicated speed incline and time INCLINE WINDOW INCLINE Indicates incline in percent of grade 0 12 in 5 increments INCLINE WINDOW TIME WINDOW CALORIE DISTA
23. ts to the left or right while walking WALKING BELT IS SHIFTING TO THE LEFT Diagram 1 First turn treadmill on to run at 1 mph Using the hex key provided turn the left rear roller adjustment bolt turn in the clockwise direction Next run the treadmill at 2 5 mph You should see the belt start to correct itself by moving back towards the center Repeat the above procedure until the walking belt is centered It may be necessary to set walking belt tension once you have completed this procedure if the belt feels like it is slipping while walking Refer below to the Walking Belt Slipping instructions WALKING BELT IS SHIFTING TO THE RIGHT Diagram 2 First turn the treadmill on to run at 1 mph Using the hex key provided turn the right rear roller adjustment bolt 1 4 turn in the clockwise direction Next run the treadmill at 2 5 mph You should see the belt start to correct if itself moving back towards the center Repeat the above procedure until the a walking belt is centered It may be necessary to set walking belt tension 2 once you have completed this procedure if the belt feels like it is slipping while walking Refer below to the Walking Belt Slipping instructions WALKING BELT IS SLIPPING DURING USE Diagram 3 o First unplug the power cord from the surge protector Using the hex key provided turn both left and right rear roller adjustment bolts the same dis tance usually a 1 4 turn in the clockwis
24. when adjusting speed incline or other controls Always examine your treadmill before using to ensure all parts are in working order Allow the belt to fully stop before dismounting Pets should never be allowed near or on the treadmill Do not leave children unsupervised near or on the treadmill Never operate the treadmill where oxygen is being administered or where aerosol products are being used Never insert any object or body parts into any opening For safety and to prevent damage to your treadmill no more than one person should use the tread mill at a time Always unplug the treadmill before cleaning and or servicing Service to your treadmill should only be performed by an authorized service representative unless authorized and or instructed by the manufacturer Failure to follow these instructions will void the treadmill warranty Never leave the treadmill unattended while it is running lt gt Before You Start was designed to meet your needs for cardiovascular exercise treadmill speeds heart rate from your physician ticular model READING RACK CONSOLE ELECTRONIG DISPLAY WATER BOTTLE HOLDER WATER BOTTLE NOT INCLUDED UPRIGHTS SIDE HAND RAILS FRONT HAND RAIL MOTOR COVER FITHESS Thank you for purchasing the KEYS ALLIANCE 800 treadmill This quality product you have chosen Before you star
Download Pdf Manuals
Related Search