Kenwood TK-190 User's Manual
Contents
1. KNB 16 17A 17B 35 00 KSC 19M 220 volt regular rate single unit desk charger for KNB 16 17A 17B 35 00 KSC 24 110 volt Rapid rate single unit dual chemistry charger for KNB 14 15 16 17A 17B 20N 21N 22N 59 00 KSC 24E 220 volt Rapid rate single unit dual chemistry charger for KNB 14 15 16 17A 17B 20N 21N 22N 59 00 KVC 3 Regular rate DC vehicular charger adapter for the KSC 15 19 30 chargers not included 60 00 KVC 4 Rapid rate DC vehicular charger adapter for the KSC 16 24 25 chargers not included 80 00 KVC 5A4 Vehicular D C Charger for 80 90 Series Portables Note Compatible with the KNB 16 17A 17B 21N 22N 22NC 340 00 CARRYING ACCESSORIES KBH 10 Spring action belt clip 8 00 KBH 8DS5 Swivel belt loop with D Ring 25 00 KLH 6SW Leather swivel belt loop detachable swivel D Ring back for a leather case 21 00 KLH 78B Heavy duty leather carrying case for TK 190 290 390 42 00 KLH 88 Cordura Nylon carrying case for TK 190 290 390 25 00 KLH 137ST Firemen s Heavy Duty Leather Shoulder Strap for KLH 78B 35 00 MICROPHONE AND SPEAKERS KCT 302 2 5mm Audio Accessory Adapter for KEP 3 4 Intrinsically Safe Approved Accessory 61 00 KEP 12 3 5mm earphone kit for KMC 25 26 Speaker Mics Black only Intrinsically Safe Approved Accessory 50 00 KEP 32 Earphone kit w 2 5mm plug for KCT 30 30 Cable black Intrinsically Safe Approved Accessory 49 00 KEP 42 Earphone kit w 2 5mm plug for KCT 30 48 Cable bla2. Kenwood NiCd chargers or earlier model leather cases 60 00 KNB 22N7 2100 mAh NiMH more than 13 hours life 5 5 90 requires KSC 24 charger Note Not compatible with Kenwood NiCd chargers or earlier model leather cases 70 00 KNB 22NC7 8 2100 mAh NiMH battery requires KSC 24 charger Intrinsically Safe Option must order L 979 117 00 KBP 43 AA Alkaline Refillable Battery Pack for TK 190 290 390 280 380 12 AA Alkaline 9V Battery cells not incl 41 00 Land Mobile Radio Division Price Guide Heavy duty Spring action Belt Clip Channel Selector Mechanical stop and dressing plate included Antenna amp Battery not included MIL STD 810 C D E Internal Noise Canceling Microphone Operator Selectable Tone Code OST Recessed Emergency Function Key Companded Audio Programmable MIL SPEC Speak Mics 16 Channel Capacity Wide Band Coverage 7 Character Invert Display Priority Scan Programable Power Per Channel 5 Programmable Keys TK 190 Low Band Portable Radio Page 1 of 4 Kenwood USA Corporation July 07 BATTERIES AND CHARGERS CONT D KMB 16 Six Unit Charger Adapter for the KSC 20 24 25 rapid rate chargers not included 165 00 KMB 23 Six Unit Charger Adapter for the KSC 32 25 24 amp 16 rapid rate chargers chargers not included Small footprint 13 Wx7 8 Hx11 7 D 2 tiered rows hold 3 KSC units each 182 00 KSC 19 Regular rate single unit desk charger for
3. Kenwood USA Corporation July 07 MODEL DESCRIPTION LIST TK 190K VHF Low Band 29 7 37 0 MHz 6W 16 Channels 642 00 TK 190K2 VHF Low Band 35 0 50 0 MHz 6W 16 Channels 642 00 Important Notice Regarding the TK 190 Model Radios If this transceiver is programmed for more than one channel the transmit frequencies must be within a 500 kHz range The physical condition of the antenna may affect the radio s performance If the original KRA 21 antenna is worn bent or damaged immediately have your Kenwood authorized dealer replace the antenna with a new properly adjusted KRA 21 antenna Failure to follow these instructions may cause poor performance damage to your transceiver and may also place excess transmitter energy on the metal portions of your radio which could make the transceiver uncomfortable to handle when transmitting When transmitting if your hand feels uncomfortable contact your Kenwood dealer for a transceiver inspection and possible antenna replacement ANTENNAS KRA 211 Tunable VHF Low Band helical antenna 29 7 50MHz Note Antenna band width is 1 MHz 40 00 BATTERIES AND CHARGERS KNB 17A 1500 mAh 7 2 VDC 4 5W NiCd battery 67 00 KNB 17BK2 Intrinsically Safe Battery 1500 mAH 7 2 VDC 4 5W NiCd battery Intrinsically Safe Option must order L 835 100 00 KNB 21N7 1600 mAh NiMH more than 10 hours life 5 5 90 requires KSC 24 charger Note Not compatible with
4. ck Intrinsically Safe Approved Accessory 52 00 KMC 25A2 6 MIL SPEC Noise canceling Speaker mic For TK 190 low band use Intrinsically Safe Approved Accessory 92 00 KHS 11BE2 2 wire palm mic w earphone universal connector Beige Intrinsically Safe Approved Accessory SEE Note A 149 00 KHS 11BL2 2 wire palm mic w earphone universal connector Black Intrinsically Safe Approved Accessory 149 00 KHS 12BE2 3 wire mini lapel mic w earphone universal connector Beige Intrinsically Safe Approved Accessory SEE Note A 175 00 KHS 12BL2 3 wire mini lapel mic w earphone universal connector Black Intrinsically Safe Approved Accessory 175 00 KHS 142 Lt Wt Single muff headset w boom mic amp In line PTT universal connector Black Intrinsically Safe Approved Accessory 120 00 Page 2 of 4 Kenwood USA Corporation July 07 MICROPHONE AND SPEAKERS CONT D KHS 15 BH2 Hvy duty noise reduction behind the headset w noise cancelling boom mic amp in line PTT black NRR24 db Intrinsically Safe Approved Accessory SEE Note B 400 00 KHS 15 OH2 black NRR24 db Intrinsically Safe Approved Accessory SEE Note B 350 00 Note A Beige colored 2 wire amp 3 wire mic models Allow min 4 weeks delivery time Note B Heavy duty headsets Allow min 4 weeks delivery time DIGITAL MODULE CIM 1000 G Star or MDC1200 ANI Board PTT ANI emergency amp man down Intrinsically Safe Approved Accesso
5. e receive and transmit performance A KLH 6SW swivel loop and KLH 78 90 carrying case can help facilitate this orientation IMPORTANT INSTRUCTIONS 2 Important Note Regarding Intrinsically Safe Certification Using an Intrinsically Safe battery on a radio does not constitute an Intrinsically Safe I S radio All Kenwood I S radios must be certified at Kenwood by inspection logging amp proper labeling The appropriate I S labor code must be specified on all I S radio orders and the proper model I S battery must be used with the radio Kenwood I S batteries can be purchased separately for existing Kenwood certified I S radios Intentionally or inadvertently representing a Kenwood radio as I S without proper Kenwood certification can result in serious safety and or legal liability issues for your company For intrinsically safe models TK 190 280 380 290 390 480 481 Meets Intrinsically Safe Classes I II amp III Div 1 Groups C D E F G hazardous locations and Non Incentive Class I Div 2 Groups C D hazardous locations 3 AA refillable packs DO NOT meet any of the MIL STD environmental standards nor are they water resistant or Intrinsically Safe approved Actual battery life is dependent on battery condition type quality temperature and use habits Alkalines exhibit non linear voltage vs current drain characteristics therefore radio transmit power will lower and decrease during transmit and as the battery is drained Nominal L
6. ife hrs 5 5 90 duty cycle battery save off scan off See chart below Transmit Power 1W 2W 4 5W Nominal Battery Life hrs 18 11 5 4 4 KVC 5A amp KVC 6A has the following features Accommodates Speaker Microphones of KMC 25 26 for KVC 5 and KMC 17 21 for KVC 6 with retainer brackets Rapid Charge LED red on when portable radio is properly seated and battery is in rapid charge mode Trickle Charge LED green on when the battery is fully charged and the charger is in the trickly charge mode repeat enable LED yellow on when the Automatic Enable switch is on and the portable is removed it goes off when portable is inserted and Automatic Repeat Enable Switch activates the vehicular repeater units e g Pyramid Communications brand SVR units Note These units are ONLY charger units They are NOT vehicular adapters with RF P A AF P A antenna connector speaker amp mobile hand mic a k a console vehicular console convert a com jerk amp run 5 Retain the screws included with the metal belt clip included with radio These are required to attach the KBH 8 or KBH 8DS Screws also available from Parts Dept Part N99 2004 05 6 KMC 25 is not compatible with the TK 190 due to the effects of RF on it at low band frequencies the KMC 25A is the compatible model The KMC 26 Speaker microphone with antenna connector CANNOT be used due to the inadequate ground plane properties on a speaker microphone at l
7. ow band frequencies the TK 190 does not have an RF pin on its accessory connector 7 Important Note regarding KNB 21N 22N 22NC NiMH batteries will exhibit reduced capacity while exposed to temperatures below 14 F 10 C and become virtually unusable below 4 F or 20 C NiMH batteries are commonly used in extreme low temperature environments ex northern latitudes refrigerated warehousing etc by keeping the portable next to the body under the users coats Prolonged exposure to extreme cold should be avoided for proper radio operation NiMH batteries capacity life is slightly lower than NiCd NiCd 70 at 500 cycles vs NiMH 1600 mAh 60 at 500 cycles 8 Meets Intrinsically Safe requirements of Classes I II III Division 1 Groups C D E F G amp Non Incendive Class I Division 2 Gropus C D hazardous locations The KNB 22NC is labeled KNB 22NC is an authorized alternate to KNB 17B and therefore the KNB 22NC can be sold into existing portable fleets using KNB 17BK and not compromise the portables I S certification The KNB 22NC does NOT require re adjustment of the Low Battery Warning settings Portables previously inspected amp readjusted by Kenwood Tuning Dept or the dealership for KNB 17B Low Battery Warning should be re adjusted for the Low Battery Warning factory default setting per the service manual Page 4 of 4
8. ry Factory Install Only Order L 1038 or 1039 125 00 CIM CABLE Serial Program Cable 59 00 CIM 1000 programs via Windows Hyper terminal Windows Ver 3 1 or later or any ProComm version board must be installed in a powered radio for programming The radio programmer does NOT program the CIM 1000 CIM CABLE is a DB 9 PC connector with 3 short lead with clips and may require a PC serial extension cable KCT 56MS Emergency Man Down Internal Tilt Switch Intrinsically Safe Must be Kenwood installed for I S Order L 1059 for install 21 00 KCT 56MS FleetSync Emergency Man Down Internal Tilt Switch Intrinsically Safe Must be Kenwood installed for I S Order L 1060 for install 21 00 SERVICE RELATED ACCESSORIES KPG 36AM Programming interface cable N A KCT 53UM USB Adapter for KPG xxAM DB9F Programming Interface Cables DB9M to USB Type A connector 81 67 KPG 59DK Program Software for TK 190 6110 Version 2 00 N A Call Kenwood Parts at 800 367 7514 to order the following E30 3325 05 Portable to Portable Cloning cable For TK 290 390 480 481 Only INSTALLATION TUNING CHARGES L 836 Assemble KMB 16 with six KSC 20 s 24 s 15 00 L 961 Assemble KMB 23 with six KSC 32K s Rapid Rate 120 Volt version only 17 00 L 835 Configure TK 190 290 390 for Intrinsically Safe Must Order KNB 17BK Note Please see end of this pricepages section for a list of Intrinsically Safe Accessories for
9. this radio 70 00 L 979 Configure TK 190 290 390 KNB 22NC for Intrinsically Safe Must Order KNB 22NC 70 00 L 837 Install KNB 17A 17BK battery 0 00 L 870 Simultaneous transpond and alert feature up grade for 90 series mobiles amp portables 50 00 L 1038 TK 190 290 390 CIM 1000 MDC1200 ENCODER INSTALLATION 75 00 L 1039 TK 190 290 390 CIM 1000 GE STAR ENCODER INSTALLATION 75 00 L 1059 Install KCT 56MS w CIM 1000K 9 00 L 1060 Install KCT 56MS for FleetSync 9 00 L 911 TK 190 TK 6110 Programming with basic TX RX check 25 00 L 914 Cut KRA 21 Low Band Antenna 10 00 Page 3 of 4 Kenwood USA Corporation July 07 1 KRA 21 Antenna Caution the TK 190 antenna must be cut per the antennas cutting chart and instructions Failure to do so will result in a poorly matched antenna poor performance and most probably excessive and damage in the transmitters final power amplifier circuit The antenna bandwidth is only 1 MHz The KRA 21 low band antenna can be between 6 to 12 inches long dependent on frequency cut It is recommended that a KLH 6SW leather swivel belt loop with a KLH 78 or KLH 90 carrying case be used to provide the greatest comfort freedom of movement especially when entering or exiting vehicles and for better transmit and receive performance When using a KMC 25A speaker microphone tilting the radio slightly to provide a minimum 4 spacing between the wearers body and the tip of the KRA 21 antenna will optimiz
Download Pdf Manuals
Related Search