Karcher K 6.50 MB User's Manual
Contents
1. Profi RM 555 ULTRA Automotive Cleaner pp Profi RM 565 ULTRA House Garden Cleaner Profi RM 570 ULTRA Boat Cleaner pp Profi RM 575 ULTRA Detergent tablets are also available from some stores Karcher Clean Tabs 10 tablets per box 10 Tablets dissolved in clean water provide 5 litres of cleaning detergent OPERATING YOUR PRESSURE WASHER If you have followed all the instructions so far you are now ready to have fun cleaning the KARCHER way e Turn on the supply water and press the Spray Gun lever No 12 until the water flows freely and removes all air locks from the hoses e You may now attach the bayonet fit Spray Lance No 16 or required accessory to the Spray Gun All accessories are bayonet fit simply push in and twist until they click into position Once water is flowing through the machine you may now switch on your Karcher Pressure Washer using the Power Switch No 4 You can regulate the working pressure on the spray by turning the nozzle end of the Spray Lance No 16 in a or direction e The working pressure can be read from the pressure gauge No 15 on the Spray Gun WHEN USING YOUR KARCHER PRESSURE WASHER ON THE HIGH PRESSURE SETTING THE RECOMMENDED WORKING DISTANCE BETWEEN THE NOZZLE AND THE OBJECT OR SURFACE TO BE CLEANED IS 30 CM IT CAN BE CLOSER IF REQUIRED FOR PATIOS OR MASONERY When cleaning painted surfaces ensure tha2. 7 PROBLEM CHECKLIST The machine you have chosen is of the highest quality Correctly stored away from frost it should operate without problems If a problem does arise please check the following chart as a solution may be at hand PROBLEM Machine refuses to start Pump stops Strong pressure fluctuations Machine does not reach operating pressure No detergent suction POSSIBLE CAUSE Plug not connected Defective socket Fuse blown Defective extension cable Wrong mains voltage Fuse blown Overheating due to poor water Supply Nozzle partly blocked Inadequate mains water Nozzle blocked worn out Inadequate mains water Inlet hose squeezed Water filter clogged 3 1 item15 Inlet hose blocked Wrong pressure Blocked filter in detergent tank CORRECTION Connect plug Try another socket Change the fuse Try without extension cable Check mains voltage corresponds to specifications of machine Change fuse and check size of extension cable Check inlet water flow rate hose should fill a 10 litre bucket in one minute Clean dirt from nozzle hole with needle and rinse from the front Check inlet water flow rate Clean replace nozzle Check inlet water flow rate Straighten out hose Clean filter Check hose for leaks or blockages Set Spray Lance at the minimum working pressure Unblock filter Clean ventilation hole in cover of Detergent Tank In the unlikely event that you need to ret
3. PRESSURE WASHER IF IT HAS NOT BEEN COMPLETELY EMPTIED OF WATER AFTER USE ALWAYS STORE INA FROST FREE AREA 6 ACCESSORIES A wide range of popular accessories are available from your local store selling Karcher Pressure Washers 4 763 228 Dirt Blaster Rotary Jet A rapidly rotating pencil jet used to remove loose paint stubborn algae and moss from hard surfaces 4 760 269 Triple Nozzle Lance An integral fan jet pencil jet and low pressure chemical jet in one unit allows optimal nozzle selection 4 760 212 Underbody Lance Extended lance with angled end and upward firing jet for cleaning under cars gutters etc 6 903 276 Car Wash Brush Simple bayonet fitting attaches the brush to the hand gun used in conjunction with RM555 4 762 065 Rotary Wash Brush Ideal for car bodywork and windows as the water forces the brush to rotate enhancing cleaning power 4 760 262 Extension Lance To add length to the standard lance 2 637 729 Drain Kit 7 5 m Hose 2 637 767 Drain Kit 15 m Hose A flexible hose with backwards firing high pressure jet to create turbulence and dislodge blockages 2 637 728 Sandblaster Used to remove paint rust and cement from metallic and stone surfaces by using a combination of high pres sure water and sand 4 760 265 Flexi Lance A lance which can be angled to any degree to clean hard to reach areas such as wheel arches etc 2 637 755 Floor Cleaning Lance An extended lance fitted with t
4. Mains Fuse c ccococcccnncnonnnnnnnnnnnnnnnnnnnnnnnnnnnninennnneninininos 13 AMP Safety class os 1 IPX5 Water Connection Supply Temperature Max pp 60 C Supply Rate MIM messen 10 litres per minute Supply Pressure Max pp 6 bar 0 6 MPa Supply Hose Length pp 7 5 metres Diameter 1 2 inch Suction Height from open tank at Water Temperature 20 1 metre Performance Data Pump Pressure Max at bypass 140 bar 14 MPa Operating Pressure pp 130 bar 13 MPa Flow 530 1 h 8 8 litres per minute Detergent 0 3 litres per minute Recoil Force of Spray Gun at Max Pressure 19 Optimum Working Distance on High Pressure 30 cm Hand transmitted vibration ISO 5349 0 8 m s Sound pressure level L EN 60704 1 75 dB A Sound power level L 2000 14 EC 93 dB A Dimensions A aiaa 497 mm WHT sitiar ai 360 mm HON ys coria dto 925 mm 21 Kg Circuit Diagramm id if C1 Running capacitor ih F1 Temperature fuse M1 Motor l a se 2 S1 Appliance switch ae S2 Pressure operated switch a H C1 10 ASSEMBLY EU Declaration of Conformity We hereby declare that the equipment described belo
5. Seyi KARCHER K 6 50 MB 650 MB PLEASE READ THIS LEAFLET CAREFULLY BEFORE OPERATING YOUR MACHINE THANK YOU FOR PURCHASING A KARCHER PRESSURE WASHER PLEASE READ THIS LEAFLET CAREFULLY BEFORE OPERATING YOUR MACHINE WHAT IS A PRESSURE WASHER A Pressure Washer is essentially a powerful electric motor driving a set of pistons that force water through a small nozzle thus creating a pressurised jet of water This provides the cleaning power behind the Karcher Pressure Washer A Karcher Pressure Washer can be usedfor an endless list of applications around the home and garden It provides an efficient economical and labour saving way of cleaning with excellent results All Karcher domestic pressure washers are designed to run from a suitable cold water supply although some models will accept a water inlet temperature of between 40 C and 60 C Environmental Comment Save water with high pressure The Karcher Pressure Washer is environmentally friendly enabling you to reduce your water consumption compared to a normal garden hose A definite advantage with a metered water supply OR with the added benefit of suction mode water can be drawn from an open container such as a water butt INDEX 10 APPLICATIONS SAFETY INSTRUCTIONS GETTING STARTED Contents Water Connection Electrical Connection Suction Mode Detergent OPERATING YOUR PRESSURE WASHER High Pressure Operation Low P
6. ached to the Mains Electric Lead No 5 into an earthed socket it is recommended that an RCD plug socket is used If using an Extension Cable make sure it is completely unwound from the cable drum and is the correct diameter 3 4 Suction Mode an added benefit of the Karcher Pressure Washer If you are drawing water from a static water supply such as a water butt disconnect the water connection hosepipe with coupling No 9 from the machine and replace with a suction hose and filter Part No 4 440 238 that can be purchased as an accessory Disconnect the Spray Lance from the Spray Gun Allow the pressure washer to operate without the Spray Lance fitted until water flows from the Spray Gun without bubbles Re connect the Spray Lance to the Spray Gun Dirt in the drawn water could damage your Pressure Washer To avoid this risk please use a suitable filter Part No 4 730 059 3 5 Detergent Only cleaning agents recommended by Karcher UK Ltd should be used Unsuitable detergents could damage your Pressure Washer and the object being cleaned Recommended Detergents 1 The following cleaning agent may be used undiluted But further dilution is practical but trial before application Universal Cleaner pp Profi RM 555 ASF The following cleaning agents are available as concentrate and must be diluted with 9 parts of water 1 9 before use Universal
7. d this physical agitation removes all trace of traffic film Finally revert to the high pressure operation with the Spray Lance and complete the wash down 4 4 End Of Operation ALWAYS REMEMBER TO RINSE YOUR PRESSURE WASHER AFTER USING DETERGENT BY FILLING THE DETERGENT CONTAINER WITH CLEAN WATER AND RUN THE PUMP FOR APPROXIMATELY ONE MINUTE In the event of a break of 5 minutes in the operation of your Karcher Pressure Washer always switch off the pump to avoid damage due to overheating Switch off the pressure washer by the Power Switch No 4 and unplug the Mains Electric Lead No 5 from the socket e Close the water inlet tap and disconnect the hosepipe e Squeeze the lever to remove all pressure from the machine Release the lever and then secure the trigger with the Safety Locking Device to prevent accidental opening 4 5 STORAGE The Spray Gun No 12 the Wash Brush No 17 and the Spray Lance No 16 can be stored with the Pressure Washer The Mains Electric Lead No 5 can be wound up over the Mains Lead Storage No 6 5 IMPORTANT CARE AND MAINTENANCE To ensure prolonged life and trouble free use of your Karcher Pressure Washer we strongly recommend that you always adopt the following procedures Water e Before use always check the inlet filter for dirt or debris Visually check to see if the nozzle is blocked by dirt or grit if so remove the dirt from the noz
8. e object to be cleaned release the Safety Locking Device on the Spray Gun and squeeze the lever to apply the detergent to the working area To rinse the detergent away increase the nozzle setting towards setting No detergent will be drawn in with high working pressure Spray with the required jet spray setting until no trace of detergent can be found We recommend the following cleaning method Step 1 Remove loose dirt by washing over the surface to be cleaned with the high pressure jet Step 2 Spray on the detergent and leave for 1 4 minutes so assisting the easy removal of fine dirt and associated greasy adhesions Step 3 Finally spray off the loosened dirt with the high pressure spray 4 3 Low Pressure Operation with Brush When cleaning surfaces with a grease contamination typically car paintwork that always has a greasy traffic film Covering adopt the following procedure Washing loose dirt away with the clean water high pressure spray e Apply the detergent in low pressure mode by setting the bayonet fit spray lance No 16 to its lowest setting Leave for 2 4 minutes for the detergent to have maximum effect Remove the bayonet fit spray lance and fit the Wash Brush No 17 to the Spray Gun No 12 The Wash Brush is suitable for use with a water inlet temperature into the Pressure Washer of maximum 40 C e With or without the pressure washer switched on brush down the surface being cleane
9. e the appliance if third persons are within the reach of the appliance unless such persons wear protective clothes A Warning High pressure jets may be dangerous if they are used improperly The jet must not be directed at people animals active electrical equipment or the appliance itself IN Never direct the jet at yourself or third persons to clean clothes or shoes IN Never use the appliance to spray objects containing hazardous substances e g asbestos A Warning Vehicle tyres tyre valves may be damaged and burst by the high pressure jet A first sign is the discoloration of the tyre Damaged vehicle tyres tyre valves are hazardous Always perform the cleaning with a minimum distance of 30 cm A Cleaning operations during which oil saturated waste water is generated such as engine cleaning and underbody cleaning may only be performed in cleaning locations that are equipped with an oil separator Alt you clean varnished surfaces please respect a minimum distance of 30 cm to avoid damages A Never take in solvent containing liquids or undiluted acids and solvents These include for example benzene paint thinner or heating oil The spray is highly inflammable explosive and toxic Do not use acetone undiluted acids and solvents as they affect the materials used on the appliance required wear appropriate protective clothes and glasses to protect yourself from return spray Never leave the appliance unatt
10. ended as long as it turned on 3 GETTING STARTED 3 1 Contents Upon opening the carton if you do not have all the items as detailed please contact the Customer Helpline Assembly 40 Da Assembly see Page 21 44 Transport Bracket High Pressure Hose Reel High Pressure Outlet Power Switch On Off Mains Electric Lead with Plug Mains Lead Storage Support Leg Inlet Water Connection with Strainer Hosepipe Connector OANODABRWNDY 10 Detergent Dosing Valve and Suction Tube with Filter 11 Detergent Tank 12 Spray Gun 13 Safety Lock Device 14 High Pressure Hose 15 Pressure Gauge 16 Spray Lance with Pressure Regulator 17 Wash Brush Please follow these instructions carefully for troublefree cleaning Use the diagram on Page 8 for reference purposes 3 2 Water Connection e The minimum length of supply hosepipe advised for maximum user convenience is 7 5 metres with a diameter of 12 5 mm 1 2 to allow free flow of inlet water to the machine so avoiding backpressure and any associated potential damage to your machine e Attach your supply hosepipe with its connector to the coupling on the machine No 9 and the other end should be connected to a suitable water supply 3 3 Electrical Connection e Ensure the Power Switch No 4 is in the OFF position before connecting the factory fitted Plug att
11. hree shrouded high pressure nozzles to provide a wide area of cleaning power without any splash back 4 440 238 Suction Hose and Filter Used to provide a water supply to the unit where a mains water supply is not available by placing the kit into a water butt 6 541 040 Trolley Eliminates the need to carry the pressure washer when the unit has no built in mobility 6 964 006 Foam Nozzle A bayonet fit accessory that generates a low pressure detergent foam This allows longer detergent contact time on the surface to be cleaned 2 637 214 Water Pump Kit 9 300 051 25 Kg Grit 6 291 080 RM 555 5 litre 6 291 079 RM 555 6 x 1 litre 6 Spare Parts In the event that your Karcher Pressure Washer requires replacement parts please refer to the diagram below AND identify the particular model of your machine by reference to the data plate on the underside Please write email or fax Karcher see page 19 with any parts order you wish to place A premium rate Help line Number is available for telephone enquires of any type A a fe 6 388 216 0 4 063 681 0 6 362 740 0 N 1 6 388 216 6 U 4 071 120 0 fh 5 731 609 0 y 5 071 115 0 6 903 276 0 gt G 6 414 252 0 Sa 6 389 870 0 A SI SET 6 435 196 0 i 6 435 197 0 6 390 463 0 4 775 390 0 se 6 362 498 0 5 332 464 0 4 A
12. nsulation of the supply cable is not damaged e Only earthed sockets should be used e If you are using an extension cable it must be completely unwound from the cable drum and be the correct diameter 10 metre length of cable should have a cross section of 1 5 mm 30 metre length of cable should have a cross section of 2 5 mm Safety Assurance As an added precaution your pressure washer is fitted with a safety locking device on the Spray Gun AFTER USE ALWAYS REMOVE THE PLUG FROM THE SOCKET BEFORE CLEANING YOUR PRESSURE WASHER 2 SAFETY INSTRUCTIONS UN Never use defect connection or extension lines If the connection line is damaged it must be replaced with a special connection line that is available from the manufacturer or his customer service IN Please make sure that the connection or extension lines are not damaged by being ran over pulled or dragged Protect the connection lines from heat oil and sharp edges IN Never touch the mains plug and the socket with wet hands The connection between connection line and extension line must not lie in the water A All current carrying components within the working area must be jet proof A The appliance may only be connected to an electrical connection that was performed by an electrician according to IEC 60364 A Only connect the appliance to alternating current The voltage must comply with the voltage specified on the typeplate UN To avoid elect
13. ressure Operation Without Brush Low Pressure Operation With Brush End Of Operation Storage IMPORTANT CARE AND MAINTENANCE ACCESSORIES SPARE PARTS PROBLEM CHECKLIST TROUBLESHOOTING HELP LINE TECHNICAL DATA ASSEMBLY APPLICATIONS The main applications for this product are DOMESTIC cleaning tasks Cars motorbikes caravans boats and bicycles Patio s fences garden walls pathways driveways and house facades particularly useful for cleaning block driveways Removal of algae and moss from roofs brickwork and guttering Garden tools and machinery furniture and barbecues Hygienic cleaning of animal pens and their surroundings With the addition of Karcher accessories the list continues Clearing blocked drains and pipes Removal of old paint and rust from garden furniture and gates Spraying insecticide onto trees plants and lawns 2 SAFETY INSTRUCTIONS BEFORE STARTING UP YOUR PRESSURE WASHER PLEASE CHECK YOU HAVE THE FOLLOWING We recommend you purchase these items from a reputable store e RCD plug and socket that will interrupt electrical supply in an emergency Atypical garden hose minimum length 7 5 metres with suitable hose connection Hoselock Gardena type to match the coupling on the machine hose and connector not supplied e The mains voltage and supply indicated on the Rating Plate of the machine corresponds with that of the power source e The i
14. ric accidents we recommend to use sockets with a series connected residual current operated device rated breaking current max 30 mA A Warning Inappropriate extension lines may be dangerous If you work outside only use extension lines that are approved and specifically labelled and provide of a sufficient conductor cross section See page 5 A The plug and the coupling of an extension line must be waterproof A Always unwind the extension line completely from the cable drum A The operation of the device in hazardous locations is not admissible A Please comply with the corresponding safety instructions if you use the appliance in danger areas e g filling stations Do not turn on the appliance if the power supply line or important components of the appliance such as safety components high pressure hoses spray jet are damaged A Warning High pressure hoses fittings and couplings are of importance for the appliance safety Only use high pressure hoses fittings and couplings recommended by the manufacturer The appliance is not intended for use by young children or infirm persons without supervision Young children should be supervised to ensure that they do not play with the appliance The operator must use the appliance properly He must take the local conditions into consideration and must pay attention to third persons in particular children while working with the appliance A Warning Do not us
15. t the paint is sound and there are no signs or rusting or blistering It is your responsibility to check the suitability of the surface to be cleaned Karcher UK Ltd cannot be held responsible for any damaged caused 4 1 High Pressure Operation Switch on the pressure washer No 4 Ensure the Spray Lance with the Pressure Regulator No 16 is attached securely to the Spray Gun No 12 and the nozzle is set to the required setting Aim the lance towards the object to be cleaned making sure the recommended working distance is used for reference see Page 11 Release the Safety Lock Device No 13 on the Spray Gun and squeeze the lever The pressurised water jet alone is capable of fulfiling most cleaning tasks around the garden or on building work but detergent and wash brush are advantageous when cleaning vehicles or other paint finishes 4 2 Low Oressure Operation without Brush Fill the Detergent Tank No 11 with the selected detergent ensuring it is the correct concentration See Page 10 or read recommended dosage on label or Dilute the detergent to the required concentration before filling the Detergent Tank The correct dilution is dependent on the degree of soiling of surface and is best determined by experience Set the Spray Lance No 16 to the lowest working pressure setting Set the Detergent Dosing Valve No 10 to the desired dosage Switch on the pressure washer No 4 Aim the nozzle towards th
16. urn your machine to your supplier please ensure that this is returned complete with hose gun and all accessories Note Inrush currents cause short time voltage drops Under unfavourable power supply conditions other equipment may be affected If the system impedance of the power supply is lt 0 15 Ohms disturbances are unlikely to occur 8 HELP LINE Karcher UK Limited operate a help line allowing customers to discuss any problems experienced with our products The help line operates during normal business hours if you have diffi culty getting through please understand that there are peak periods during the day when our consultants are unable to take all calls coming in In these circumstances we would ask that you try to contact us again later in the day The help line number is 0906 6800632 calls at this number are charged at 25p per minute From 8 30am to 5 00pm Monday Friday It helps us if you have the model number and data plate details to hand before making your call as there are very many different models of Karcher Pressure Washers in use Alternatively you may write or e mail to the address below Karcher UK Limited Karcher House Beaumont Road Banbury Oxon OX16 1TB FAX 01295 752030 E mail retail_inquiries karcheruk co uk 9 TECHNICAL DATA Power Connection Voltage 220 240 V AC y AP 1 50 Hz Connected Load una 2 5 KW
17. w conforms to the relevant fundamental safety and health requirements of the appropriate EU Directives both in its basic design and construction as well as in the version marketed by us This declaration will cease to be valid if any modifications are made to the machine without our express approval Product High pressure cleaner Model 1 138 xxx Relevant EU Directives EU Machinery Directive 89 392 EEC 91 368 EEC 93 44 EEC 93 68 EEC 98 37 EC EU Low Voltage Equipment Directive 73 23 EEC 93 68 EEC EU Directive on Electromagnetic Compatibility 89 336 EEC 91 263 EEC 92 31 EEC 93 68 EEC EU Directive on Noise 2000 14 EC Harmonised standards applied DIN EN 55014 1 2000 A1 2001 DIN EN 55014 2 1997 DIN EN 60335 1 DIN 60335 2 79 DIN EN 61000 3 2 2000 DIN EN 61000 3 3 1995 A1 2001 Conformity assessment procedure followed Annex V Sound power level Measured 91 dB A Guaranteed 93 dB A Appropriate internal measures have been taken to ensure that series production units conform at all times to the requirements of current EU Directives and relevant standards The signatories are empowered to represent and act on behalf of the company management Alfred K rcher GmbH 8 Co KG Cleaning Systems Alfred Karcher Str 28 40 P O Box 160 D 71349 Winnenden J Tel 49 71 95 140 WEST Fax 49 71 95 22 12 Jenner S_Reiser 5 957 566 11 02 Notes KARCHER www karcher com
18. zle hole with a needle and rinse with water from the front Failure to do this will seriously damage your machine and invalidate the warranty Connect the water supply hose and without the lance attached squeeze the Spray Gun lever to run water through your pressure washer until the water flow is constant Then plug in to the electric supply Unless drawing water from an open water source such as a water butt always have a minimum of 10 metres 25 feet of uncoiled hose between the water tap and your machine The internal diameter of the feed water hose should be 12 mm 1 23 Water Regulations require the use of a back flow preventer valve at the tap end of the supply hose Only use a full flow connector to connect the hose to the machine Electricity If using an electrical extension lead it must be rated at a minimum of 13 amps Always fully uncoil any extension lead when used Chemicals Use of chemicals other than those recommended by Karcher could cause significant damage which may not be covered by your warranty After using chemicals always run fresh water through your machine The high pressure hose of your Karcher Pressure Washer should not be mistreated It is designed to withstand high pressure operation so vehicles should NOT run over it nor should it be pulled across sharp or abrasive edges These actions may weaken the hose and cause ballooning IMPORTANT REMEMBER FROST WILL DAMAGE YOUR KARCHER
Download Pdf Manuals
Related Search