Jumpking Orbunder JK14EN2A-05 User's Manual
Contents
1. 23 Do not intentionally rebound off the netting 24 Do not hang from kick cut or climb on the netting 25 The trampoline frame and the enclosure frame are made of metal They are not grounded and they will conduct electricity Therefore an electrocution hazard exists Lights electric heaters extension cords and household electrical appliances are not per mitted in or on the trampoline or enclosure 26 The trampoline is a rebounding device that Zi 28 propels the user to unaccustomed heights and into a variety of body movements Rebounding off the trampoline striking the frame or springs or improperly landing on the bed may cause injury Do not attempt or allow somersaults This can result in a broken head neck back or leg Landing on the head or neck can cause serious injury paralysis or death even when landing in the middle of the bed Jumpers who lose control of their jump may land on the bed incorrectly land on the frame or springs or fall off the trampoline Attempting maneuvers beyond present skill levels increases the chance of losing control 29 Injury may result from encountering the frame or falling through the springs while getting onto or off the trampoline or while jumping Stay in the center of the bed when jumping Do not use the trampoline without the frame pad securely in place to cover the frame The frame pad is not designed or intended to support the weight of the use2. to the other three tubes 7 with the other seven Straps in the same way Attach the middle of Bungi Cord 14 to the Straight Tube 6 See inset drawing D and E Repeat the other three middle Bungi Cord 14 in the same way Bungi Cord Bung Cord 5 Note During steps 5 and 6 you will sew the lower edge of the Netting 10 to the V rings on the bed using the Cords 13 Locate the V ring closest to the door Thread one end of a Cord 13 through the lower edge of the Netting 10 above the V ring and then thread the Cord through the V ring Tie the Netting to the V ring by making a double knot in the cord 6 Thread the Cord 13 through the lower edge of the Netting 10 halfway between the first V ring and the V ring to the left and then thread the Cord through the V ring to the left Repeat this proce dure until the entire Cord is threaded through the Netting and the V rings as shown Keep the Cord taut Tie the end of the Cord to the last V ring that it reaches Tie a second Cord not shown to the last V ring reached by the first Cord Thread the second Cord through the Netting 10 and the V rings as described above Repeat this procedure with the remaining Cords until the last Cord reaches the first Cord Note The last Cord may overlap the first Cord Make sure that the Netting is sewn to every V ring on the trampoline bed the Netting below the door must also be sewn to the V ring
3. irampatine of into or aver the trampoline anclosure Getting on and off Climb on and off the trampoline at the enclosure door or bamer opening Do not jump on or off Do not craw under the barrier Do nol use the trampoline as a springboard to other objects For skill training information contact a trainer certification organization For Eguipment information ontact Lifestyles USAs LLC Customer Hot Line 77 337 8777 Monday F tday 5 aun 5 pon ATTACH TO NETTING AT DOOR Male In hina ooo BEFORE YOU BEGIN Thank you for selecting a Orbounder trampoline enclosure The enclosure when combined with a properly placed and maintained trampoline will provide many years of backyard fun Your trampoline enclosure comes equipped with warnings and instructions for the assembly care maintenance and use of the enclosure This infor mation must be read by all trampoline supervisors and users before any person is allowed to use the enclosure on a trampoline If you have questions after reading this manual please call our toll free Customer Hot Line at 877 92 7 8777 Monday through Friday 8 a m until 5 p m Central Time excluding holidays To help us assist you please mention the name of the product when calling Airtime Enclosure TRAMPOLINE ENCLOSURE SAFETY INFORMATION NEED FOR TRAMPOLINE ENCLOSURE SAFETY A trampoline enclosure is a recreational product The information on
4. refer to parts by their lighted area Artificial illumination may be descriptions and key numbers see the PART required for indoor or shady areas LIST on page 13 4 Secure the trampoline and enclosure against See the EXPLODED DRAWING AND PART LIST unauthorized and unsupervised use on page 13 and make sure that all liste parts are included If a part is missing see ORDERING REPLACEMENT PARTS at the bottom of page 13 6 The trampoline enclosure is only to be used as an enclosure for a round trampoline 5 Remove any obstructions from beneath the trampoline and enclosure 1 Make sure that you understand the informa tion in the box at the top of this page before you begin assembling the trampoline enclo Sure the frame pad for clarity the frame pad is not SS shown in steps 1 and 3 Do not remove the PPT frame pad from the trampoline a L Socket KI See the inset drawing n Left Leg eg Center Slide a U bolt bracket 2 onto the U bolts 3 then thread locknuts 1 two turns onto the U bolts Repeat this step on the other three leg sections not shown U bolts Loosen the straps not shown on the underside of 2 Lay four Straight Tubes 6 two L tubes 7 and a V Tube 8 on the ground so they form an arch Make sure that the Straight Tubes are orient ed so the small holes are in the positions shown Slide a Foam Sleeve 9 onto each of the Tubes note that the ends of the Straight Tubes
5. should not be covered Insert the two L tubes 7 into the two Straight Tubes 6 Next insert the two L tubes into the V Tube 8 Tighten six Self tapping Screws 5 into the small holes in the Straight Tubes 6 and the V tube 8 Note The small holes may be on the opposite side the V tube Assemble the remaining Straight Tubes L tubes V tubes and Foam Sleeves in the same way 3 See inset drawing Attach the other arch in the same way not shown Slide a Black C clip 4 onto the Straight Tube 6 and align the bottom of the Black C clip with the bottom of the socket Next slide one of the U bolts 3 up gt SS gt r ocke a SY until it touches the bottom of TUT i ni i 5 p the socket and tighten the two Locknuts 1 on the U bolt Slide the other U bolt up until it is 2 above the lower end of z the Straight tube and tighten Left Leg the two Locknuts on the U bolt Then press two Plastic Caps 11 onto each U bolt 4 Spread the Netting 10 on the trampoline bed with the door of the Netting below the V Tube 8 where jumpers will climb onto and off the trampoline Next locate one of the D rings attached to the upper edge of the Netting Lift the D ring and hold it near an L tube 7 as shown See inset drawing A See inset drawing B See inset drawing C Pull the end of the Strap to remove any slack Do not fully tighten the Strap yet Attach the Netting 10
6. the frame pad and climb head first through the door Refasten the plastic clips and close the zippers To exit the enclosure first unzip the zippers on the door and unfasten the plastic clips Sit on the bed of the trampoline and climb feet first through the door When you are through the door and sitting on the frame pad step or jump Safely to the ground Close the zippers and refasten the plastic clips ne ee an ASSEMBLY IMPORTANT ASSEMBLY INFORMATION TRAMPOLINE PLACEMENT Assembly requires a 8 16 socket and ratchet or 1 Place the trampoline and enclosure on a level a 8 16 open end wrench and a Philips screw surface before use driver not included 2 Adequate overhead clearance is essential A Assembly requires two adults Keep children minimum of 7 3 m 24 ft from ground level is away from the trampoline enclosure until it is fully recommended Provide clearance for wires assembled tree limbs and other possible hazards Lateral clearance is also essential Place the trampo line and enclosure away from walls struc tures fences and other play areas Maintain a clear space on all sides of the trampoline and enclosure Use gloves to protect your hands from pinch points during assembly Make sure that the trampoline is properly assem bled with the frame pad properly attached before you assemble the trampoline enclosure 3 Use the trampoline and enclosure in a well The assembly steps
7. the user Secure the trampoline against unauthorized and unsupervised use Keep the trampoline free of objects that could interfere with the jumper This trampoline enclosure is not recommended for use by children under 6 years of age or by anyone weighing more than 90 kg 200 Ibs Use the trampoline only when the bed is clean and dry Inspect the trampoline and enclosure prior to each use and replace any worn or damaged parts Use only when the enclosure netting has no holes the clamps are tightly secured to the tubes and the frame and the netting is properly suspended For the Jumper Do not use the trampoline enclosure when under the influence of drugs or alcohol Avoid jumping too high or for too long Always control your jump Avoid bouncing when tired Take turns jumping one at a time and always have someone watch you Do not attempt to jump over the netting Do not inten tionally rebound off the netting Do not hang from kick cut or climb on the netting Wear clothing that is free of drawstrings hooks loops or anything that could get caught in the netting Do not attach anything to the netting that is not a Bazoongi approved accessory or part of the tram poline enclosure How to Enter and Exit the Trampoline Enclosure Enter and exit the trampoline enclosure only through the door in the netting To enter the enclosure first unfasten the plastic clips on the door and unzip the zippers Place one knee on
8. ATIONS High Wind It is possible for the tram poline and enclosure to be blown about by high wind If you antici pate high winds move the trampo line and enclosure to a sheltered location Disassemble the enclosure neiting Tie the trampoline frame down to the ground using ropes and stakes not included At least three ropes and three stakes should be used The tops of the stakes should be at ground level so that they will not create a tripping hazard In addition the tops of the stakes should be covered if necessary so that users will not be injured by falling onto the stakes Make sure to attach the ropes to the top of the trampoline frame do not simply secure the legs or the bases to the ground as they can separate from the frame sockets Moving the Trampoline and Enclosure If the trampoline and enclosure are to be moved a short distance they should be moved by two persons kept horizontal and lifted slightly If the trampoline and enclosure are to be moved a long distance they should first be disassembled See DISASSEMBLY on page 11 In addition see the trampoline manufactur er s user s manual E EXPLODED DRAWING AND PART LIST Qty Description Description Locknut Netting with attached Hardware U bolts Bracket Plastic cap U bolts User s Manual and Safety Placard Black C clip Cord Self tapping Screw Bungi Cord Straight Tube L tube V tube These parts are not illustrated Foam S
9. ONDER MODEL JK14EN2A 05 14 Enclosure System A WARNING Read the assembly installation U S R S MAN U AL o O mad amp E kt 3 care maintenance and use instructions in this manual prior to assembling and using this Assembly Installat 100 Care trampoline enclosure Save this manual for future reference Maintenance and Use Instructions WARNING The trampoline enclosure is designed for users weighing 90 kg 200 Ibs or less Pkwy Suite 400 Plano TX 75074 877 927 8777 7 2005 Lifestyles USA LLC Plano TX www Jumpking com QUESTIONS if you have questions after reading this manual please call our toll free Customer Hot Line The trained technicians on our Customer Hot Line will provide immediate assistance Customer Hot Line 877 927 8777 Monday Friday 8 a m 5 p m Excluding Holidays REPLACEMENT PARTS www jumpking com SOUNDER MODEL JK14EN2A 05 14 Enclosure System CONTENTS IMPORTANT PRECAUTIONS ese a x s onssa as posms as OOK WS 4 WARNING PLACARD PLACEMENT lt csaa amp seces i 5 8 senuis 5 EP GEE FOAL GEO ow 2 eaaa a mm S OGIE R e K ORDES we eN 6 TRAMPOLINE ENCLOSURE SAFETY INFORMATION 6 I nance 4 Ws eek amp E E amp RR beeen dw 8 CARE AND MAINTENANCE sa amp sews sotgani area 5 Es 12 EAPLODED DRAWING AND PART LIST cc aasiss s s wewu uwa 13 ORDERING REPLACEMENT PARTS 44 13 IM
10. PORTANT PRECAUTIONS Aw WARN NG To reduce the risk of serious injury read and follow all warnings precau tions and instructions in this manual before assembling and using the trampoline enclosure 1 The owner and supervisors of the trampoline and enclosure are responsible to make all users aware of practices specified in this manual 2 The trampoline enclosure is to be used only as an enclosure for a round trampoline 3 Place the trampoline and enclosure on a level surface before use 4 Adequate overhead clearance is essential A minimum of 7 3 m 24 ft from ground level is recommended Provide clearance for wires tree limbs and other possible hazards 5 Lateral clearance is essential Place the tram poline and enclosure away from wats struc tures fences and other play areas Maintain a clear space on all sides of the trampoline and enclosure 6 Use the trampoline and enclosure in a well lighted area Artificial illumination may be required for indoor or shady areas 7 Secure the trampoline and enclosure against unauthorized and unsupervised use If an access ladder is used it should be removed when the trampoline is not in use 8 Inspect the trampoline enclosure before each use Make sure that the netting enclosure tubes and foam sleeves are correctly posi tioned Replace any worn defective or miss ing parts 9 Remove any obstructions from beneath the trampoline and enclosure 10 Do
11. able supervision Enforce all safety rules and be familiar with the information in the Users Manual to help users in following trampoline enclosure instructions and trampoline safety Do nat exceed the weight limit recommended by Ihe manufacturer Use only when the enclosure barner has no holes pole clamps are tightly secured to the poles and the Support frame and the bamer is properly suspended Do not intentsonally rebound off the barrier Do not hang from kick cut or climb on the barrier Wear clothing free of drawsinngs hooks loops or anything that could get caught in the barner Do not attach anything to the barrier that is not a manufacturer approved accessory or part of the enclosure system For the Jumper Do not use the trampoline ancosure system when under the influence of drugs cr alcohol Jumping Leam fundamental jumps and body positions thoroughly before trying more advanced skills Review the Users Manual to learn about how to do basic jumps Stop your bounce by flexing your knees as your feet come in contact with the trampoline mat bed Avoid jumping too high or for too long Always control your sump A controlled jump is one where the take off and land spots are the same Bounce in the center of the trampoline Focus your eyes on the trampoline mat bed Failure to do so may result In a loss of balance and control Do not jump from other objects building of surfaces onto the
12. leeve Specifications are subject to change without notice OMAN A NBWN i aaaaaaaaaaalalalalalalalaaaaaaaalalalll lllllllullllllllllMlMl ORDERING REPLACEMENT PARTS To order replacement parts visit our Web site at www jumpking com or call our toll free Customer Hot Line at 877 927 8777 Monday through Friday 8 a m until 5 p m Central Time excluding holidays To help us assist you please provide the following information when calling e the MODEL of the trampoline enclosure the NAME of the product Airtime by JumpKing Enclosure gt the KEY NUMBER and DESCRIPTION of the part see the PART LIST above the quantity needed e the desired method of shipping 13
13. n a trampoline is raised off the ground The height of the enclosure increases the risk of a fall when a jumper is entering or exiting the enclosure Young children in particular may have difficulty getting into and out of the enclo sure To reduce the risk of falling help young children to get into and out of the enclosure Enter and exit the trampoline enclosure only through the door of the enclosure the opening in the netting walls The trampoline bed and the netting walls of the enclosure are separate pieces jumpers particularly young children must not exit the enclosure by going out between the bed and the netting walls Trying to exit in this way poses a risk of strangulation from being caught between the trampoline frame and the netting walls Darkness increases the chances of a fall when a jumper is entering or exiting the enclosure Do not use the trampoline unless adequate lighting is provided Hazards Associated with Animals and Sharp and Breakable Objects To avoid damage to the trampoline enclosure and the trampoline do not allow pets or other animals inside of the enclosure The claws and teeth of animals can damage the netting Do not jump on the trampoline while holding or wearing a sharp or breakable object An Hazards Associated with High Winds A trampoline with an enclosure can be moved or blown over by high winds potentially injuring anyone in its path or anyone inside of the enclosure If you a
14. not attach anything to the netting that is not a manufacturer approved accessory or part of the enclosure 11 Bounce only when the surface of the bed is dry Wind or air movement should be calm to gentle The trampoline must not be used in gusty or severe winds 12 The trampoline enclosure is designed for users weighing 90 kg 200 Ibs or less The enclosure is not recommended for use by children under 6 years of age 13 Do not allow more than one person inside the trampoline enclosure Use by more than one person at the same time can result in serious injury 14 Wear clothing free of drawstrings hooks loops or anything that could get caught in the netting 15 Do not jump on the trampoline while holding or having an object particularly one that is sharp or breakable 16 Do not use the trampoline enclosure while under the influence of alcohol or drugs These substances impair reaction time judg ment and physical coordination 17 Use the trampoline enclosure only with mature knowledgeable supervision 18 Misuse and abuse of the trampoline enclo Sure is dangerous and can cause serious injuries 19 Climb onto and off the trampoline Do not jump onto it or off it Do not use the trampo line as a springboard to other objects 20 Enter and exit the trampoline enclosure only at the door designated for that purpose 21 Do not attempt to crawl under the netting 22 Do not attempt to jump over the netting
15. nticipate high winds take down the enclosure net ting and stake the trampoline frame to the ground see page 12 or move the trampoline and enclosure to a sheltered location Storing the Trampoline Enclosure Safely Specific steps for storing the trampoline enclosure are presented later in this manual There are specific safety precautions to be aware of when storing the enclosure Remove the attached tube sections as a unit and separate them on the ground Avoid pinching your fin gers by keeping your fingers away from pinch points near the bracket assembly while you are removing the tubes from the frame Placing the Trampoline in a Safe Place There must be at least 7 3 m 24 ft of clear open space above the trampoline bed Do not place or store anything underneath the trampoline To avoid injury the trampoline must be kept away from objects and possible hazards including electric power wiring tree limbs and fences Do not place the trampoline near any other recreational devices or structures such as a swimming pool or swing set The trampoline must be placed on a level surface before use and the area around the trampoline must always be well lighted For the Supervisor Be familiar with the information in this manual and enforce all of the safety rules Help new users and all users to use the trampoline and enclosure safely All trampoline users must have someone watch them regardless of the skill or age of
16. r Do not step or jump directly onto the frame pad WARNING PLACARD PLACEMENT The placard shown at the right must be attached to the trampoline enclosure by the owner see assembly step 7 on page 11 If the placard is missing or illegible call our Customer Hot Line toll free at 877 927 8777 Monday through Friday 8 a m until 5 p m Central Time to order a free replacement placard Note The placard is not shown actual size TRAMPOLINE ENCLOSURE SAFETY INSTRUCTIONS Season ae gt SRG A EERE aa Do not land on head or neck Only one person at a time in the trampolineenclosure Paralysis or death can result J even if you land in the middle This trampoline enclosure system of the trampoline mat bed is not recommended for use by children under 6 years of age To reduce the chance of landing on your head or neck Multiple jumpers increase the do not do somersaults flips chances of loss of control and this can result in broken head neck back or leg For the Supervisor Inspect lhe trampoline before using Keep frame pad in place Do not use when tramooline is wet or in a windy condition A wom or damaged mat bed spring or frame piece should he replaced immediately Keep objects away that could interfere with the jumper Secure the trampoline against unauthonzed and unsupervised use Use trampoline enclosure only with Mature knowledge
17. rampoline dur ing harsh weather conditions or during long periods of non use Inspect the trampoline enclosure before each use and replace any worn defective or missing_parts The following conditions could represent potential hazards and increase the danger of personal injury e missing improperly positioned or insecurely attached netting enclosure tubes or foam sleeves e punctures frays tears or holes worn in the netting or foam sleeves e deterioration in the stitching or fabric of the netting e bent or broken enclosure tubes e sagging netting e sharp protrusions on enclosure tubes If any of these conditions exists the trampoline enclosure should be disassembled or otherwise protected against use until the condition is reme died REMOVING AND STORING THE TRAMPOLINE ENCLOSURE Make sure that the trampoline enclosure is dry before removing and storing it The enclosure tubes can be removed in sections Hold two straight tubes and loosen the U bolts securing them Lift the straight tubes the attached L tubes and the attached v tube out of the clamps Lay the tubes on the ground Use caution while removing the tubes due to the 12 weight of the tubes and the tendency of the tubes to rotate Store the enclosure in a safe dry location Once the enclosure is removed from the trampoline remove all items from the trampoline bed Make sure that the bed is clean and that it has no tears or holes SPECIAL CONSIDER
18. s gt y V rings 10 7 Tighten the eight Straps attaching the Netting 10 to the L tubes 7 see step 4 Tie the free end of each Strap around the rest of the Strap to prevent the Strap from loosening Tighten the straps not shown on the underside of the frame pad Using the included plastic tie attach the Safety Placard 12 to the Netting 10 near the door as shown The trampoline enclosure is now fully assem bled Make sure that all parts are securely attached Familiarize yourself and all users of the trampoline and the enclosure with the safety precautions use and instructional materials and care and maintenance instruc tions in this manual before using the enclo sure DISASSEMBLY To disassemble the trampoline enclosure follow assembly steps 1 through 7 in reverse order 11 CARE AND MAINTENANCE TRAMPOLINE ENCLOSURE CARE AND MAINTENANCE To avoid damage to the trampoline and enclosure do not allow pets or animals inside the enclosure Appropriate shoes should be worn inside the enclo sure to reduce wear to the bed Follow the trampoline manufacturer s recommendations Prolonged exposure to the sun especially ultraviolet rays will shorten the life of the enclosure fabric For longer fabric life store the enclosure when it is not being used A dry enclosure properly stored will pro vide the longest life of the fabric sewing and hard ware Remove the enclosure from the t
19. this page and on page 7 identifies important safety precautions The precautions are not all inclusive because an enclosure can be used in ways that this manual cannot cover completely To prevent pinches and cuts during enclosure use a frame pad must be installed on the trampoline See the trampoline manufacturer s instructions The frame pad must be installed before the enclosure is erected The frame pad reduces the chance of injury from acci dental contact with the springs and frame USING THE ENCLOSURE SAFELY Adult Supervision of Children Children using a trampoline with a trampoline enclo sure must be supervised by adults Young children must be supervised constantly Adults must pay par ticular attention to things that children bring into the enclosure children s activities inside the enclosure conditions inside the enclosure while children are using it the way children get into and out of the enclosure Additional details of safe enclosure use are described below Electrocution Hazard Associated with the Metal Frame of the Trampoline and Enclosure The trampoline and enclosure frames are made of metal They are not grounded and they will conduct electricity Lights electric heaters extension cords and household electrical appliances are not permitted in or on the trampoline or enclosure Hazards Associated with Entering and Exiting the Trampoline Enclosure A trampoline enclosure installed o
Download Pdf Manuals
Related Search