JobSite Systems V-12/AWE User's Manual
Contents
1. INSTALLATION amp USER GUIDE Jobsite PURE CUSTOM For Precise Volume Adjustment in All Weather Conditions 12 STEP ALL WEATHER ENCLOSED VOLUME CONTROL V 1 2 AWE V 12 AWE 12 STEP ALL WEATHER ENCLOSED VOLUME CONTROL TABLE OF CONTENTS 1 Product OWervi CW iiaa ARNAR 2 Package 3 Preparing for 2 44404 1 1 41 3 4 EA ET 6 Specifications anasini aeaiee aiiai aai Eeeeh iaa 7 e a 8 FEATURES Includes PVC weatherproof housing and stainless steel hardware Safely connect up to eight speaker pairs to a single amplifier or receiver UL listed to comply with local building codes Stylish indicator knob 12 step make before break volume control switch design Installation friendly design Accepts up to 14 gauge wire Snap and lock connector secures wire in place without the use of a screwdriver Mounts easily to any surface or directly on PVC conduit LISTED PRODUCT OVERVIEW N 2 O b Faceplate c Gasket 4 Volume Control amp Enclosure 1 PACKAGE CONTENTS V 12 AWE Volume Control x 1 Knob x 1 Device m2. MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE WITH RESPECT TO THE PRODUCT REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE CONSUMER PURCHASER NILES SHALL NOT BE RESPONSIBLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES EXCEPT TO THE EXTENT PROVIDED OR PROHIBITED BY APPLICABLE LAW Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state For the name of the nearest authorized JOBSITE wholesale distributor contact JobSite Systems 12331 S W 130 Street Miami Florida 33186 WWW JOBSITESYSTEMS COM 9 Jobsite PURE CUSTOM JOBSITE SYSTEMS 12331 S W 130 STREET MIAMI FLORIDA 33186 866 4JB SITE 866 452 7483 F 305 238 0185 WWW JOBSITESYSTEMS COM 2004 JobSite Systems All rights reserved JobSite Pure Custom and Niles are registered trademarks of Niles Audio Corporation and the JobSite Logo is a trademark of Niles Audio Corporation All other trademarks are the property of their respective owners Some JobSite products or components thereof are manufactured under one or more U S Patents foreign equivalents and or pending patents see product for details Because we constantly strive to improve our products JobSite reserves the right to change product specifications desc
3. Adjustable impedance 1x 2x 4x 8x settings Total attenuation 54dB maximum Wiring requirements 2 individual runs of 2 conductor 14 18 gauge speaker wire or 1 run of 4 conductor Mounting Surface mount PVC single gang enclosure included mounts on 3 4 PVC conduit Dimensions 3 wide x 4 13 16 high x 3 3 8 deep Depth behind faceplate 2 9 16 Warranty 10 year limited LIMITED WARRANTY JobSite Systems JOBSITE a Niles Audio Corporation company warrants its passive products those not requiring AC or battery power to the original purchaser to be free of manufacturing defects in material and workmanship for a period of ten years from date of purchase JOBSITE warrants its passive loudspeaker products those not requiring AC or battery power to the original purchaser to be free of manufacturing defects in material and workmanship for a period of five years from date of purchase JOBSITE warrants its indoor outdoor loudspeaker products to the original purchaser to be free of manufacturing defects in material and workmanship for a period of two years from date of purchase JOBSITE warrants its all weather rock loudspeaker products to the original purchaser to be free of manufacturing defects in material and workmanship for a period of five years from date of purchase JOBSITE warrants its active products those requiring AC or battery power to the original purchaser to be free of manufacturing def
4. ects in material and workmanship for a period of two years from date of purchase This Warranty is subject to the following additional conditions and limitations The Warranty is void and inapplicable if JOBSITE deems that the product has been used or handled other than in accordance with the instructions provided by the manufacturer including but not limited to damage caused by accident mishandling improper installation abuse negligence or normal wear and tear or any defect caused by repair to the product other than by JOBSITE or an authorized JOBSITE wholesale distributor To obtain warranty service you must write to JOBSITE Include your name address telephone number model number and serial number of your unit and a brief description of the problem A factory Return Authorization Number will be sent to you DO NOT RETURN ANY UNIT WITHOUT FIRST RECEIVING WRITTEN AUTHORIZATION AND SHIPPING INSTRUCTIONS FROM JOBSITE If the above conditions are met the purchaser s sole remedy shall be to return the product to JOBSITE in which case JOBSITE will repair or replace at its sole option the defective product without charge for parts or labor JOBSITE will return the unit repaired or replaced under warranty by shipping it by its usual shipping method from the factory only at its expense within the United States of America THERE ARE NO OTHER WARRANTIES INCLUDING WITHOUT LIMITATION EITHER EXPRESS OR IMPLIED WARRANTIES OF
5. ff at all times Tools Required 1 8 Slotted screwdriver 1 4 Slotted screwdriver No2 Phillips screwdriver Wire stripper Wire labels INSTALLATION 1 Identify the Speaker wire and Amplifier wire Label the wires for future reference 2 Run the necessary wiring up through the conduit and the opening at the base of the enclosure 3 Mount the entire enclosure atop the PVC conduit Secure the enclosure with galvanized mounting screws 4 Strip 1 4 of insulation from the end of each wire Tightly twist the end of each wire until no frayed ends remain 5 Locate the snap and lock connectors and remove them if they are plugged in See figure 5 Figure 5 6 Use a small flathead screwdriver or your thumb to INSTALLATION DIAGRAM raise the locking tabs exposing the holes on the connector 7 Insert each wire into the appropriate hole and snap down the locking tabs 8 Insert the smooth side of the connector plug into the smooth side of the V 12 AWE socket Input From V 12 AWE 9 Install the V 12 AWE into the all weather enclosure 10 Set the Impedance Magnification Switch as determined by the impedance charts r V 12 AWE 11 Set the switches on all of the controls to the sie View same position 1x 2x 4x or 8x Output to Speakers 12 Attach the cover plate See installation dia
6. gram O o HEHH e Stereo Receiver 5 Speakers OPERATION 1 Make sure the amplifier or receiver power is OFF and set the volume to minimum 2 Set the volume on the volume control to maximum fully clockwise 3 If you are using a JobSite speaker selection system locate the on off button that corresponds to the speaker pair you wish to play Set it to the ON position Make sure the defeatable protection circuit is not enabled See Using Speaker Selectors with IM Volume Controls on page 5 4 Turn ON the amplifier or receiver and select a source such as the Tuner or CD player 5 Slowly turn up the amplifier or receiver volume and set it to a comfortable not maximum listening level Don t overdrive clip your amplifier If the sound becomes muddy or distorted you have 6 reached the limit of your amplifier s volume capability Reduce the volume at once to avoid damaging your speakers 6 Use the volume control to adjust the volume of the speakers to the desired listening level If all the speaker pairs in your system are equipped with JobSite volume controls you can set the amplifier or receiver volume at one position and use the JobSite controls exclusively 7 To turn OFF the speakers turn the knob on the volume control fully counter clockwise or press the ON OFF button on your speaker selector SPECIFICATIONS High power rating 100 watts per channel RMS 200 watts peak
7. ounting screws x 2 Snap and lock removable speaker connectors x 2 Standard faceplate screws x 4 Enclosure x 1 Gasket x 1 AMPLIFIER S MINIMUM SPEAKER LOAD IS 4 OHMS AMPLIFIER S 8 OHM Speaker Pairs 1 40 2x 4x Speaker 40HM 8 Speaker Pairs Figure 2 PREPARING FOR INSTALLATION Consider the most convenient location to mount the V 12 AWE Use the PVC junction box supplied mounted atop a PVC conduit through which the wires will run Count the number of pairs of 4 ohm speakers and the number of pairs of 8 ohm speakers you are connecting Count pairs of 6 ohm speakers as 4 ohm pairs Determine the correct switch position from the impedance charts See figures 2 3 and 4 MINIMUM SPEAKER LOAD 15 8 OHMS 8 OHM Speaker Pairs om x 2 1 x Figure 3 Figure 4 Using Speaker Selectors with IM Muting Volume Controls Although IM controls provide volume and on off at the volume control location they do not give you central control of speakers playing throughout the house Speaker selection systems give you central control but some speaker selectors have non defeatable impedance protection circuits Combining IM controls with such a selector will reduce your maximum volume substantially To solve this problem specify a speaker selector with a defeatable protection circuit JobSite models S 4 or S 6 Then keep the protection circuit o
8. riptions and prices without notice The technical and other specifications of information contained herein are not intended to set forth all technical and other specifications of JobSite products Additional information can be obtained at WWW JOBSITESYSTEMS COM or by calling JobSite at 866 452 7483 Printed in China 7 04 DS00397BCN
Download Pdf Manuals
Related Search