Fisher-Price H8256 User's Manual
Contents
1. and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test your battery for you Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace the battery with a new Power Wheels 12 volt rechargeable battery Do not substitute parts The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe The fuse will automatically reset itself after approximately 25 seconds allowing the vehicle to resume normal operation To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 lb maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the b2. vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other Causes not arising out of defects in materials or workmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU Should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the store Power Wheels has provided a nationwide network of authorized service centers If there is not an authorized service center in your area please visit us on line at www powerwheels com or call Consumer Relations for information 1 800 348 0751 This warranty gives you specific legal rights and you may also have other rights which may vary from state to state PLEASE SAVE YOUR ORIGINAL SALES RECEIPT H8256pr 0920 19 Before first time use you must charge the battery 18 hours Charge the battery immediately after each use Charge the battery once a month even if the vehicle is not used or stored Do not return your vehicle to the store We re a toll free phone call away and we can help If you are missing parts or need assistance please call 1 800 3
3. GUE FA N RENNEN EN Gee are N 16 NEE Ace ee elle 19 IN ZH m IE Tan Ve En 19 A IMPORTANT INFORMATION e Your new vehicle requires adult assembly Please set aside at least To prevent damaging the motors and gears teach your child to 60 minutes for assembly stop the vehicle before switching direction Do not tow anything You must charge your battery for 18 30 hours before you use your behind the vehicle or overload it Do not exceed the maximum vehicle for the first time We recommend that you start charging weight capacity of 65 Ibs 29 5 kg your battery before beginning assembly Please see Battery Charging If you have any questions about your Power Wheels vehicle beginning on page 5 for detailed instructions please call our toll free service lines at 1 800 348 0751 from Read this manual carefully for important safety information and 8 AM to 6 PM EST Monday through Friday Trained customer operating instructions before using your vehicle Keep this manual service representatives are available to take your call in English for future reference as it contains important information or French Habla Espanol Si usted tiene alguna pregunta necesita asistencia llame gratis 1 800 348 0755 para los Estados Unidos Tenemos representantes que hablan espa ol para atender su llamada For your convenience Power Wheels maintains an independently owned and operated Authorized Service Center Network with more than 400 authorized service
4. battery It must be recycled or disposed of in an environmentally sound manner Do not dispose of a lead acid battery in a fire The battery may explode or leak Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of sealed lead acid batteries with household trash is prohibited by law in most areas Return an exhausted battery to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local seller of automotive batteries For the authorized service center location nearest to you please visit us on line at www powerwheels com or call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or the State of Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream J SAFE DRIVING RULES RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps cars steep inclines roads and alleys Teach Safety Rules to Children While children can quickly develop the ski
5. battery from the vehicle N CAUTION Use the charger in dry locations only H8256pr 0920 5 BATTERY CHARGING ASSEMBLY N WARNING Children can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should Battery Connector not handle parts including the battery or help in assembly of the vehicle Front Bumper Connector h ae rm yy Sooo Te ri i fy ae n h k Plug the charger connector into the battery connector EN Plug the charger into a standard wall outlet IE Note If power flow to the wall outlet is controlled by a switch make sure the switch is ON Before first time use charge the battery for at least 18 hours Never charge the battery longer than 30 hours e Recharge the battery for at least 14 hours after each use of your vehicle Do not charge the battery longer than 30 hours 4 J BOTTOM VIEW Once the battery is charged disconnect the battery connector from the charger connector Unplug the charger from the wall outlet The battery is now ready to be installed in your vehicle Please see the Battery Installation section on page 12 for detailed instructions on Fit the front bumper to the front of the vehicle e Carefully lift the front end of the vehicle installing your battery If your batter
6. built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe The fuse will automatically reset itself after approximately 25 seconds allowing the vehicle to resume normal operation To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 lb maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center H8256pr 0920 PROBLEMS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAUSE Short run time Less than 1 3 hours per charge Undercharged battery Overcharged battery Battery is old and will not accept full charge Tripped thermal fuse Vehicle runs sluggishly Undercharged battery Battery needs charging Battery is old and will not accept full charge Vehicle is overloaded Driving conditions are too stressful H8256pr 0920 SOLUTION Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all wires and connectors Make sure the charger connector is plugged into the battery
7. by exceeding the 65 Ib 29 5 kg maximum weight capacity or by IN Serious injury towing anything behind the vehicle Avoid severe driving conditions Use of Power Wheels components in such as driving up slopes or running into fixed objects which can products other than Power Wheels cause the wheels to stop spinning while power is still being supplied vehicles could cause overheating fire to the motors and make sure your child stops the vehicle before switching direction or explosion n lf a thermal fuse in a battery continually trios under normal driving e The battery must be handled by adults only conditions please contact your local Power Wheels Authorized The battery is heavy and contains sulfuric Service Center For the location of the Authorized Service Center acid electrolyte Dropping the battery nearest to you visit us on line at www powerwheels com could result in serious injury or call 1 800 348 0751 e Never allow children to charge the battery Battery charging must be done by adults Important Notes only A child could be injured by the elec Your new battery must be charged for at least 18 hours before tricity involved in charging the battery you use it in your vehicle for the first time e Read the safety instructions on the battery e We recommend that you start charging your battery before beginning assembly of your new vehicle e Examine the battery charger and their The battery must be uprigh
8. of the assembly tool e Loosen the screw in the sound box battery compartment door with a Phillios screwdriver Lift to remove the battery compartment door Insert three AAA LRO3 alkaline batteries as indicated inside the battery compartment Hint We recommend using alkaline batteries for longer battery life e Replace the battery compartment door and tighten the screw with a Phillips screwdriver Do not over tighten 15V x3 AAA LRO3 Shown Actual Size Battery Safety Information In exceptional circumstances batteries may leak fluids that can cause a chemical burn injury or ruin your product To avoid battery leakage Do not mix old and new batteries or batteries of different types alkaline standard carbon zinc or rechargeable nickel cadmium Insert batteries as indicated inside the battery compartment e Remove batteries during long periods of non use Always remove exhausted batteries from the product Dispose of batteries safely Do not dispose of product in a fire The batteries may explode or leak e Never short circuit the battery terminals e Use only batteries of the same or equivalent type as recommended Do not charge non rechargeable batteries e Remove rechargeable batteries from the product before charging f removable rechargeable batteries are used they are only to be charged under adult supervision H8256pr 0920 ASSEMBLY VEHICLE CARE Sou
9. 48 0751 Or contact your local independently owned and operated Power Wheels Authorized Service Center For the location nearest you visit us on line at www powerwheels com Disney Pixar Visit the Disney website att www disney com Fisher Price Inc a subsidiary of Mattel Inc East Aurora New York 14052 U S A 2005 Mattel Inc All Rights Reserved and designate U S trademarks of Mattel Inc PRINTED IN MEXICO H8256pr 0920
10. ATION K IMPORTANT Use this vehicle ONLY outdoors Most interior floor ing can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is used indoors Beginner Use Low Speed Drive As assembled your vehicle is ready to roll in low speed 21 2 mph maximum It has been pre set so it will only operate in low speed After your child has mastered the basic skills of driving and understands the rules for safe driving it s time to remove the high speed lock out screw to allow the vehicle to operate in low or high speed See the instructions on this page to remove the high speed lock out screw Make sure the shifter is in the low speed P position EN Press down on the foot pedal EE The vehicle goes forward at a maximum of 21 2 mph IE Help your child practice steering to learn how far and how quickly to turn the steering wheel when driving forward in low speed To Back Up IMPORTANT To avoid damaging the motors and gears stop the vehicle before shifting from forward to reverse Once your child is completely comfortable with operating the vehicle in the forward mode introduce reverse Make sure the shifter is in the reverse position EI Press down on the foot pedal E The vehicle will go in reverse at a maximum of 21 2 mph IE The vehicle is designed to operate in low Speed only in reverse Help your child practice steering to learn ho
11. Oa FisherPrice 2 SS e ui ge y te a Same a Bu Please ead this manual and save it with your original sales receipt Tools needed for assembly Phillips Screwdriver not included Assembly Tool included Use only a Power Wheels 12 Volt Rechargeable Battery and wer Wheels 12 Volt Charger with Type 12V connector both included Requires 3 AAA LRO3 alkaline ries for sound box operation not included a 4 A Pa I i Ma Re a TABLE OF CONTENTS FR MDOH An INIONNANON ee ee ert Da ne eae ee er me Ne E re eee ee ge ae eee ee 2 Varn e GC AUTO SE E A ren cere com preteen meeien dears EN 3 Ge AMS ere E te tes ea E ee ate sy eae Gee aay eae Etat E E eg S eae Se ney ta Nee iat dive puna eeohebr cy bat cheat 4 B EEWO NEETA o wats cae corer ries cae te trae tite an ee a rte a age tes Cee naam oman ny marian ae ate 5 A 12 18 8 AN were ence eet rere ety are ere ee E tera Wir ary Mere C ener ren ir ure were e nina tras ea mae eer 6 Bs VGRICIG CAG terete aaron on iets hance ee ee 9 GPeC orat Mice ret weet ee es res eee ne ea cea es a N E ee eee aed cent cre 10 RB alle ra Sal lallOme ee are ee eet ate ec re te ee ane ore ae ee ee sete en oe aren ey aoe acne aera me 12 BL Ballen 6 aleranasWiSpOsalins tauren sure mek eset an yee N N ore Ser wale cient a Ar Teed en Cee ee As GENE 13 BE SOA EEEE NER 14 EE vence Operon canna wane RE Re wm aiuamene meron emirate reef 15 BAROD Om ando ou On
12. S GUIDE IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 between 8 AM and 6 PM EST Monday through Friday Or contact your local Power Wheels authorized service center For the location nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 PROBLEM POSSIBLE CAUSE SOLUTION Vehicle does not run Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Charger is not working There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your charger contact your local Power Wheels authorized service center They can test your charger for you Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe The fuse will automatically reset itself after approximately 25 seconds al
13. attery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Be sure to charge the battery after each use Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on the vehicle use and use conditions Replace the battery with a new Power Wheels 12 volt rechargable battery Do not substitute parts Make sure you do not overload the vehicle by allowing more than one rider at one time by exceeding the 65 Ib maximum weight Capacity or by towing objects behind the vehicle Use only on generally level ground PROBLEMS AND PROBLEM Vehicle runs in low speed but does not run in high speed Please note The vehicle is designed to operate in low speed only in reverse When the foot pedal is pressed one rear wheel spins Sometimes the vehicle doesn t run but other times it does When the go foot pedal is pressed the vehicle won t run without a push Battery s thermal fuse constantly trips but the vehicle is not overloaded nor the driving conditions too severe Loud clacking or grinding noise from a motor gearbox Charger gets warm during use Battery makes a sizzling or gurgling noise when charging POSSIBLE CAUSE High speed lock out not disconnected Operation of vehicle in low speed L
14. battery for at least 14 hours after each use Never charge the battery longer than 30 hours Charge the battery after each use regardless of how long the vehicle was used The battery must be upright while charging Do not allow the battery to run down completely before charging Charge the battery before storing the vehicle Charge the battery at least once per month even if the vehicle has not been used Leaving the battery in a discharged condition will ruin it Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle Do not store the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you store the battery Do not store the battery in temperatures above 75 F or below 10 F Use only a Power Wheels 12 volt battery Remember to charge the new battery for at least 18 hours before first use Prevent the battery from moving freely inside the battery compart ment Always use the battery clamp to secure the battery in the battery compartment Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage is detected do not use the charger or the battery until you have replaced the worn or damaged part H8256pr 0920 Disposal amp X Your Power Wheels battery is a non spillable sealed lead acid
15. centers nationwide Our authorized service centers will repair or replace parts under warranty at no extra charge and can perform non warranty repairs for a minimal charge To find the authorized service center nearest you please visit us e This vehicle is designed for use on concrete grass asphalt and other hard surfaces on generally level terrain and by children 3 years of age and older e This vehicle has been pre set so it will only operate in low speed See the instructions on page 15 to remove the high speed lock out screw e Make sure children know and follow these rules for safe driving and riding always sit on the seat on line at www powerwheels com or call 1 800 348 0751 always wear shoes only 1 one rider at a time e Use this vehicle ONLY outdoors Most interior flooring can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is used indoors e To register your vehicle please visit us on line at www powerwheels com r H8256pr 0920 WARNINGS AND CAUTIONS B ELECTRICAL HAZARD N WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in seriou
16. dent Operate the vehicle only in the daytime or a well lit area 7 Do not allow your child to drive on sloped or inclined surfaces Restrict your child s driving to generally level ground ONLY 8 Do not allow your child to drive down or across a steep slope The vehicle may gain unsafe speed even if the pedal is released to stop The vehicle may tilt and tip over The wheels could lose traction causing the vehicle to slip 9 Do not allow your child to drive up steep inclines The motor may stop and the vehicle could roll backwards at an unsafe speed 10 Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near flammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off The presence of flammable liquids or vapors could cause an explosion or a fire Keep all flammable products in tightly sealed containers and away from the vehicle 12 Do not allow a child to operate the vehicle without direct adult supervision To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use 14 H8256pr 0920 VEHICLE OPER
17. duct to the store Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded e Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant 12 Volt Battery Vehicle Body 12 Volt Charger Sound Box Front Bumper 8 x 3 4 Screw 6 Steering Wheel Steering Wheel Cover 3 8 16 Lock Nut 2 Steering Column For your convenience we included extra fasteners Note Tighten and loosen all screws with a Phillips screwdriver Do not over tighten the screws Assembly Tool Fasteners Shown Actual Size Part not shown Label Sheet H8256pr 0920 BATTERY CHARGING D ELECTRICAL HAZARD AN WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE About Thermal Fuses Btls Ach Pen a Han ie ee Alterations could cause a fire resulting automatically trios and shuts down operation of the vehicle if the in serious injury and could also ruin the vehicle is overloaded or the driving conditions too severe Once a electrical system fuse has tripped it will automatically reset itself after approximately Use of the wrong type battery or charger see u nn the re nn Be P o avoid repeated automatic shut downs do not overload the vehicle could cause a fire or explosion resulting
18. e in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver Consult the dealer or an experienced radio TV technician for help Note Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user s authority to operate the equipment Bumper to Bumper Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle Six month limited warranty on the 12 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 12 volt battery included by Power Wheels with the original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels
19. ll necessary to drive this vehicle it is important to remember that their judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before children use this vehicle an adult should carefully evaluate the driving area as well as the children s skill level and ability to drive this vehicle safely Children are not always able to recognize or anticipate hazards even when they have been taught about them There is no acceptable substitute for direct adult supervision Teach appropriate safety rules to your child before allowing operation of this vehicle These rules should also be reviewed with neighborhood children or other playmates who want to drive this vehicle Riding Rules Make sure children know and follow these rules for safe driving 1 Always sit on the seat 2 Always wear shoes 3 Only 1 one rider at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off cause a tip over or block the driver s view A child could be seriously injured 4 Do not allow any child to drive the vehicle in the street or near moving motorized vehicles 5 Do not allow any child to drive near bodies of water Such as pools or creeks obstructions such as furniture low tree limbs or play equipment or drop offs such as stairs or decks 6 Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an acci
20. longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty Assembly Tool Place the battery in the battery compartment and release the battery clamp Make sure the battery clamp slides over the top of the battery Close the hood and fit the tabs on the hood into the slots in the vehicle body e Press down to snap the hood in place Insert the end of the assembly tool or a coin into the slot on the side of the hood e Use the tool to lift the hood and access the battery compartment Power Wheels 12 Volt Battery Battery Clamp Motor Harness Connector Lift and pull the battery clamp forward e Plug the motor harness connector into the battery H8256pr 0920 BATTERY CARE AND DISPOSAL Care If a battery leak develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See information below for proper disposal If acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician If acid is internally ingested give water milk of magnesia or egg whites immediately Never give emetics or induce vomiting Call a physician Charge a new battery for at least 18 hours before first use Never charge the battery longer than 30 hours Overcharging or undercharging the battery may shorten battery life and decrease vehicle running time After the first charge recharge the
21. lowing the vehicle to resume normal operation To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Loose wire or loose connectors Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors Dead battery If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized service center Electrical switch damage The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Motor damage Contact your local Power Wheels authorized service center for diagnosis and repair Vehicle was running but Loose wire or loose connectors Check all wires and connectors Make sure the motor harness suddenly stopped connector is plugged into the battery and that there are no loose wires around the motors Tripped thermal fuse The
22. nd Box DASH VIEW Fit the sound box inside the steering wheel as shown Make sure the buttons face toward the back end of the vehicle Large Tab Small Slot _ Fit the large tab on the steering wheel cover into the large slot in the steering wheel Insert and snap the small tab on the steering wheel cover into the small slot in the steering wheel H8256pr 0920 Check all screws cap nuts and their protective coverings regularly and tighten as required Check plastic parts on a regular basis for cracks or broken pieces During snowy or rainy weather the vehicle should be stored inside or under a protective cover Remember to charge the battery at least once per month while your vehicle is not in regular use Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Do not wash the vehicle with soap and water Water or moisture in the motors or electrical switches can cause them to corrode and could cause switch or motor failure Avoid operating the vehicle on sand loose dirt or gravel Sand loose dirt or gravel in the motors or electrical switches can cause them to jam and could cause switch or motor failure The vehicle can be wiped down with a soft dry cloth For a shiny finish you can wipe plastic parts with a non wax furniture polish applied to a soft cloth Do not use automotive wax Do not use soap and water or spray the vehicle with a hose To ensu
23. oose wire or connector Motor or electrical switch damage Loose wire or connector Dead Spot on motor Damaged battery Child is switching between FORWARD and REVERSE without stopping Broken gears It is normal for some chargers to get warm during use and is not reason for concern It is normal for some batteries to make noise and swell slightly while charging and is not reason for concern SOLUTIONS GUIDE SOLUTION The vehicle was pre set to run only in low speed To allow the vehicle to run in low and high speed you must disconnect the High Speed Lock Out Follow the instructions on page 15 to remove the High Speed Lock Out screw It is possible that only one rear wheel may spin when both rear wheels are raised off the ground and the vehicle is in low speed This does not necessarily indicate a problem Check for proper operation of the drive system by raising the rear wheels off the ground and pressing the foot pedal If only one rear wheel spins carefully press your hand on the spinning wheel to slow it down The other rear wheel should begin to spin If the other rear wheel does not begin to spin there may be a problem with the vehicle Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires aro
24. re that your vehicle stays in good operating order we recommend that you periodically have your vehicle checked by a Power Wheels authorized service center For the location of the authorized service center nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 G DECORATION Proper label application will help to keep the labels looking their best When applying labels keep the following guidelines in mind e Wash your hands before applying the labels Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils Place the labels exactly as shown in the illustrations For best results avoid repositioning a label once it has been applied to the vehicle After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your vehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles FRONT VIEW H8256pr 0920 DECORATION G TOP VIEW ees H8256pr 0920 MH BATTERY INSTALLATION IMPORTANT Use only a Power Wheels 12 volt lead acid rechargeable battery Use of any other battery will damage your vehicle Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels 12 volt charger before operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery
25. s injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you Charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part e HOT motors Handle carefully RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps cars steep inclines roads and alleys AN CAUTION e In the unassembled state this package contains small parts Adult assembly is required e Use the charger in dry locations only H8256pr 0920 3 PARTS e If you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this pro
26. t while charging connectors for excessive wear or damage The charger is not a toy each time you charge the battery lf Do not short circuit the battery damage or excessive wear is detected do l e You do not need to remove the battery from your vehicle to not use the charger or the battery until you recharge it have replaced the worn or damaged part Before charging the battery examine the battery case for cracks and other damage which may cause sulfuric acid electrolyte to leak during the charging process If damage is detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to surfaces it contacts Do not charge the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you charge your battery Use only a Power Wheels 12 volt charger with 12 V connector 120 VAC 60 Hz 28W with an output of 12 VDC 1200 mA to charge your Power Wheels 12 volt battery Adults Note Regularly examine the charger for damage to the cord plug housing or other parts that may result in the risk of fire electric shock or injury In the event of any damage do not use the charger until the damage has been properly repaired Please call 1 800 348 0751 f your battery is old and will not accept a charge do not leave it in the vehicle Always remove a dead
27. und the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Teach your child to stop the vehicle before switching direction Contact your local Power Wheels authorized service center for diagnosis and repair No action required If your charger does not get warm during use it does not mean that it is not working properly No action required If your battery does not make noise or swell slightly during charging it does not mean that it is not accepting the charge If after reviewing the Problems and Solutions Guide the vehicle still fails to operate please contact your nearest authorized service center or contact Power Wheels Consumer Relations toll free at 1 800 348 0751 Hint For faster service when calling Consumer Relations completely charge the battery before calling and have the following available by the phone e vehicle e vehicle model number see label in battery compartment e vehicle production run number see label in battery compartment H8256pr 0920 Mi FCC NOTE LIMITED WARRANTY INI United States Only This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to Part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interferenc
28. w far and how quickly to turn the steering wheel when driving in reverse H8256pr 0920 e Your vehicle has a patented electronic braking system that automatically stops the vehicle when your child s foot lifts from the pedal Make sure your child is comfortable with steering the vehicle and automatically knows how to stop Advanced Use High Speed Drive Remove l Be lock out Screw GES Place for high speed lock out screw here for storage Before you disconnect the high speed lock out make sure your child knows how to steer how to start and stop the vehicle and knows the rules for safe driving When the high speed lock out is disconnected the vehicle can be driven forward in low speed 21 2 mph maximum or high speed 5 mph maximum e Make sure the shifter is in the low speed P position e Loosen and remove the screw in the shifter box e Place the lock out screw into the hole in the top of the engine for future use It can be re inserted into the shifter box to lock out high speed To Drive IMPORANT To avoid damaging the motors and gears stop the vehicle before shifting between low and high speed Make sure the shifter is in the high speed position IM Press down on the foot pedal EE The vehicle goes forward at a maximum of 5 mph Help your child practice steering to learn how far and how quickly to turn the steering wheel when driving forward in high speed PROBLEMS AND SOLUTION
29. y is already installed in your vehicle simply re connect the motor harness connector to the battery Insert four screws into the underside of the bumper and tighten Hints You may need to turn the wheels to fit all four screws into the bumper You may need to push and pull on the bumper to align the screw holes 6 H8256pr 0920 ASSEMBLY Steering Linkage Front Bumper Fit the curved end of the steering column through the hole in the Steering linkage Set the vehicle upright Insert two screws into the front bumper and tighten Lock Nut Steering Column Place the lock nut rounded side out onto the end of the Steering column Carefully lift the front end of e Tighten the lock nut firmly using the closed end of the assembly tool the vehicle e Wipe the steering column with a paper towel to remove any excess lubricant Insert the straight end of the steering column through the slot in the vehicle and out through the large hole in the center of the dash Be sure the steering column comes through the hole in the dash H8256pr 0920 ASSEMBLY Steering Wheel Lock Nut Hold the steering column in place and gently lower the vehicle e While supporting the steering column fit the steering wheel onto the Steering column e Place the lock nut rounded side out onto the end of the Steering column Tighten the lock nut firmly using the closed end
Download Pdf Manuals
Related Search