Home

Fisher-Price DODGE 73520 User's Manual

1. 73520 Dodge Ram 6 27 01 2 57 PM Page 16 di ar Assembly Rectangular emr S Bushing with i gt N Round Opening X 354 Cap Nut Assembly Tool Grille e Turn the vehicle body upright e Face the front end of the vehicle e Fit the grille to the front end of the vehicle e Insert four 8 x screws through the grille and into the front end of the vehicle Tighten the screws with a Phillips screwdriver Do not over tighten e Slide a rectangular bushing with round opening onto the front axle and into the rectangular indent in the front LA RJ wheel e Fit a 354 cap nut on the end of a front axle e Cover the cap nut with the assembly tool and tap it with a hammer until the cap nut is secure on the front axle e Remove the assembly tool Pull on the cap nut to be sure it is secure on the front axle e Repeat assembly steps 22 24 to assemble the other front wheel rectangular bushing with round opening and a 354 cap nut to the other front axle 6 Oz ts I o oo OS TE U CLH Bottom View arle e Turn the vehicle body over so that the bottom faces you e Insert two 8 x 3 4 screws through the grille and into the vehicle body Tighten the screws with a Phillips screwdriver Do not over tighten 16 Hint You may need to turn the front wheels one at a time to be able to insert and tighten the screws d SE 73520 Dodge Ram 6 27 01
2. IMPORTANT Use only a Power Wheels Type H 6 volt battery with a Power Wheels 25 Amp fuse installed Use of any other battery or fuse will damage your vehicle Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels 6 Volt charger before operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty La M e While pushing the battery clamp fit the battery into the w AI battery compartment SS e Release the battery clamp to secure the battery in the battery compartment Locked Motor Harness l Connector Battery e Locate the lock fasteners in the hood Connector e Using a slotted screwdriver turn each lock fastener 1 4 turn to the unlocked position e Plug the battery connector into the motor harness connector Note If the battery connector will not plug into the motor harness connector turn it over and try again Do not force gqthe battery connector into the motor harness connector e Lift the hood d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 25 p Battery Installation Lock Fastener Ta ee ae D lo TA A SE ir J Yo ob Sina al e Lower the hood and insert the lock fastener tabs into the slots in
3. Dead Spot on motor Contact your local Power Wheels authorized service center for diagnosis and repair Loud clacking or grinding Broken gears Contact your local Power Wheels authorized service noise from a motor gearbox center for diagnosis and repair Charger gets warm during use It is normal for some chargers to get No action required warm during use and is not reason for concern If your charger does not get warm during use it does not mean that it is not working properly Battery makes a sizzling or It is normal for some battery to No action required gurgling noise when charging make noise and swell slightly while charging and is not reason for If your battery does not make noise or swell slightly concern during charging it does not mean that it is not accepting the charge If after reviewing the Problems and Solutions Guide the vehicle still fails to operate please contact your nearest authorized service center or contact Power Wheels Consumer Relations toll free at 1 800 348 0751 31 di siy 73520 Dodge Ram 6 27 01 2 57 PM Page 32 abs ie Authorized Service Centers We are continually expanding our Authorized Service Center Network Please check this listing for the Authorized Service Center nearest you If there is not one in your area please call Power Wheels Consumer Relations at 1 800 348 0751 ALABAMA BIRMINGHAM Frigid Service amp Sales
4. e Fit the motor between the strut and the wheel well of the vehicle body d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 13 di ar Assembly Assembly 437 Cap Nut AEE p lt gR a ss Be a Rectangular Bushing with Rectangular Opening id mers Y s Bushing Ring End Black Round e Fit a rectangular bushing with rectangular opening into Bushing the rectangular indent in the outside of the rear wheel e Fit a 437 cap nut onto the end of the rear axle JT Bottom View Rectangular Bushing with Rectangular 437 Cap Nut Opening e Slide the spacer onto the rear axle l l e While supporting the other end of the rear axle cover the e Slide a black round bushing with large hole ring end cap nut with the assembly tool Tap the assembly tool with first onto the end of the rear axle a hammer until the cap nut is secure on the rear axle Hint You may need the help of another adult to support the rear axle e Remove the assembly tool Pull on the cap nut to be sure it is secure on the rear axle ee Front Axles Steering Linkage Groove Metal Bar Toward You Circular e Position the steering linkage with the inside grooved side facing up and the metal bar towards you e identify the other rear wheel with flat center tread e Insert the front axles through he holes i h f th e Identify the inside of the rear wheel with circular indents
5. Loose wire or loose connectors service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors Vehicle was running but suddenly stopped Wrong type or improperly installed fuse Make sure that the battery has a properly installed Power Wheels 25 amp fuse installed before charging Do not substitute parts Blown fuse Make sure that the fuse in the battery is in good condition Replace a blown fuse with a Power Wheels 25 amp fuse Do not substitute parts Vehicle is overloaded Make sure you do not overload the vehicle by allowing more than 1 rider at one time by exceeding the 50 Ibs 23 kg maximum weight capacity or by towing objects behind the vehicle Driving conditions are too stressful Use only on generally level ground Extreme temperatures can also affect run time Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Short run time Less than 1 3 hours per charge Check all wires and connectors Make sure the charger connector is plugged into the b
6. 238 1877 KANSAS CITY OVERLAND PARK Mar Beck Appliance Service Co 8471 West 95th Street 66212 913 642 1557 SPEARVILLE Quality Parts PO Box 126 406 North Main 67876 316 385 2624 WICHITA Alan Appliance Service Inc 1300 E Central 67214 316 262 7228 800 290 7228 KENTUCKY GREENVILLE Malone Lumber Do It Center 204 W Depot Street 42345 270 338 3252 LEXINGTON AutoHobby Model Raceway 1474 Anniston Drive 40505 859 299 4925 LOUISVILLE Maury s Fluorescent amp Appliance Service 1521 Bardstown Road 40205 502 456 1671 OWENSBORO Kuester s Hardware 1210 Carter Road 42301 270 685 4916 PADUCAH Hank Brothers True Value 3101 Lone Oak Rd 42003 270 554 4001 LOUISIANA BAKER Gayle Battery Distributors 16555 Plank Road 70714 225 774 7475 BATON ROUGE Home Appliance Service Inc 10781 Florida Blvd 70815 504 272 7727 HAMMOND Battery Depot 2323 Hwy 190 East Suite 4 70401 504 542 4983 LAFAYETTE Cullen s Playland 4498 Johnston Street 70503 337 981 2929 LAKE CHARLES Capitol Schwinn Cyclery 722 E Prien Lake Road 70605 337 474 9090 NEW IBERIA Voorhies Supply Company 401 W St Peter Street 70560 337 364 2431 NEW ORLEANS METAIRIE Le Jouet Inc 1700 Airline Hwy 70001 504 837 0533 SHREVEPORT Shreveport Shaver and Appliance 9750 St Vincent Burt Kouns Ind Loop 71106 318 865 5088 800 349 7722
7. 92104 619 283 6488 SAN JOSE California Electric Service Center 481 So Bascom 95126 408 295 1723 SANTA ROSA Hardisty s Inc 710 Farmers Lane 95405 707 545 0535 SKY FOREST Sky Forest Electrical 28670 Highway 18 PO Box 496 92385 909 337 0811 VAN NUYS California Electric Service Center 14753 Oxnard Blvd 91411 818 997 8855 VENTURA Appliance Advantage 4547 Telephone Rd Suite A 93003 805 650 0716 800 960 2125 YUCAIPA Aire Rite Heating amp A C 34724 Yucaipa Blvd 92399 909 797 2788 COLORADO COLORADO SPRINGS Nelson Appliance Repair Inc 1220 E Fillmore 80907 719 635 1928 800 291 8010 DENVER Appliance Service 4272 Lowell Blvd 80211 303 458 1109 800 631 0941 CO WY only GRAND JUNCTION V amp L Appliance Service 591 25 Road Suite A6 81506 970 243 3360 PUEBLO Direct Maytag Home Appliance 1407 Santa Fe Drive 81006 719 543 0777 CONNECTICUT HARTFORD Hartford Element amp Appliance Service 1500 Albany Ave 06112 860 246 7424 800 787 7977 NEW HAVEN HAMDEN New Haven Appliance Service Center 1627 Dixwell Ave 06514 203 288 6229 SHELTON Jeff s Appliance amp Vacuums 66 Center Street 06484 203 924 8997 STAMFORD Appliance Servicenter of Stamford 15 Cedar Heights Road 06905 203 322 7656 WATERBURY PJ Appliance Repair 935 South Main Street 06706 203 757 1014 DELAWARE WILMINGTON Lyons
8. AONO 1p eecmenetoriny or steering linkage e Slide the other rear wheel inside first onto the end Pache toi aee down So of the rear axle 13 that they fit completely in the steering linkage grooves Inside of Rear Wheel d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 14 abs ie Assembly Metal Ba Facing You I l e Be sure the front end of the vehicle is facing you e Position the steering linkage so that the metal bar is facing you P e Insert the front axles into the posts in the bottom of the 5 vehicle body IMPORTANT Make sure the metal bar on the steering linkage faces you Post Bushing Post Bushing Front e While holding the front steering linkage in place carefully turn the vehicle upright Hint You may need the help of another adult to turn the vehicle upright e Insert a post bushing narrow side down into the holes in the front wheel wells and onto the front axles as shown 14 e Fit a 354 cap nut on the end of a front axle e Cover the cap nut with the assembly tool and tap it with a hammer until the cap nut is secure on the front axle e Remove the assembly tool Pull on the cap nut to be Sure it is secure on the front axle e Repeat this procedure to assemble a 354 cap nut to the end of the other front axle Front Washers Axle Ar U Oy eEeEeooooOororm gt swrr_ aeV3seV3oS ee uqn ee_OR
9. Black Round Bushing 30 Knob 2 Driver Eade POG 31 Post Bushing 2 Cab paces 32 Axle Support 2 Front Axle 2 Bo 33 White Round Bushing 3 u _ Front Wheel with Rib 2 D with Small Hole 2 _ Steering Linkage 10 x 1 2 Screw 34 Rectangular Bushing _ 487 Cap Nut 2 with Rectangular Opening 2 354 Cap Nut 6 Not Shown Label Sheet 2 6 Volt Charger Motor Assembly Tool oS eo SN Steering Wheel Top Steering Wheel Bottom Steering Wheel Cover Steering Column T d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 8 abs ie Battery Charging ELECTRICAL HAZARD AN WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery clamp e PREVENT FIRE Important Notes Do not bypass a Power Wheels fuse e Your new battery must be charged for at least 18 It is a safety device hours before you use it in your vehicle for the Use only a Power Wheels 25 Amp fuse first time Never modify the electrical system e We recommend that you start charging your battery l o before beginning assembly of your new vehicle Alterations could cause a fire resulting in snes tb ahtwnie charai serious injury and could also ruin the PRAE TOE R E nang electrical system e The charger is not a toy Use of the wrong type battery or e Do not short circuit the battery charger could cause a fire or explosion e You do not need to remove the
10. amp Spey 3711 Community Road 31520 912 267 0771 COLUMBUS Burrell s National Appliance Service 1728 Warm Springs Road 31904 706 327 0523 NORCROSS Appliance Connection 5172 C Brook Hollow Parkway 30071 770 734 9888 800 964 7455 GAINESVILLE Bike Town USA 1604 Dawsonville Highway 30501 770 532 7090 LOGANVILLE Loganville Lawn Mower 157 C S Floyd Road 30052 770 466 9111 SAVANNAH Hagins Appliance Service 3 West Victory Drive 31405 912 233 8372 THOMASVILLE Carroll Hill Auto 115 Albany Road 31799 912 266 0717 VALDOSTA Harry B Anderson Inc 204 E Central Avenue 31601 912 242 5945 WOODSTOCK All City Appliance Inc 8477 Highway 92 Suite 110 30189 770 924 2375 HAWAII HONOLULU McCully Bicycle amp Sporting Goods 932 Hausten Street 96826 808 946 1192 WAILUKU MAUI Tom s Appliance Sales amp Service 1816 Mill Street Suite 104 96793 808 244 6278 WAIPAHU Gary s Bike World 94 910 Moloalo Street 96797 808 375 4262 IDAHO BOISE Boise Appliance 1503 Main Street 83702 208 343 0102 IDAHO FALLS Rossiter Electric 1501 South Capital Avenue 83402 208 529 3665 ILLINOIS CHICAGO BERWYN Brand Service Center 6739 West Cermak 60402 708 749 4315 CHICAGO DOWNER S GROVE Authorized Appliance Service Co 1644 W Ogden Avenue 60515 630 852 1550 CHICAGO MORTON GROVE Brand Service Center Inc 5618 Dempster Street
11. 2 57 PM Page 17 abs ie Assembly Dash View Dash View e Insert and snap the knobs into the holes in the right side of the dashboard e Insert and snap the key into the hole in the left side of the dashboard Ala coe a Le RO G A CA E Front Slots 5 ne a e Turn the vehicle body upright pJ e Note the location of the six tabs on the cab Straioht 4 RI e Fit the two front tabs on the cab into the slots in the a vehicle body Steering e Next fit the four side tabs on the side of the cab into the slots in the vehicle body e Push down on the cab to snap all six tabs into the slots in the vehicle body SS Bottom View e Turn the vehicle body over so that the bottom faces you e Insert the straight end of the steering column through the opening in the floor of the vehicle and out through the 17 large hole in the dashboard d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 18 abs ie Assembly N a OOOO O _ Ti H E A j uS Op piy L A j Ea UNE CLE Tot e TH oie hows ee oy e Fit a 354 cap nut on the end of a steering column e Tap the cap nut with a hammer until the cap nut is secure on the steering column e Pull on the cap nut to be sure it is secure on the steering column e Fit the curved end of the steering column through the hole in the steering linkage Steering Whe
12. 510 N Parramore Avenue 32801 407 841 8824 800 940 8824 PANAMA CITY Callaway Vacuum amp Sewing 221 N Tyndall Prkwy 32404 904 763 633 PENSACOLA Fosters Appliance Repair 3836 N Davis Highway 32503 904 432 8853 POMPANO BEACH Authorized Appliance Service Co 2171 N Dixie Highway 33060 954 941 2038 32 d SE PORT ST LUCIE Appliance Doctors 10632 South Federal Hwy 34952 561 878 7869 SARASOTA Sunray Small Appliances 8371 N Tamiami 34243 941 358 9999 800 895 5655 SEBRING Ace Hardware Of Sebring 305 U S 27 North 33870 863 385 2785 SPRING HILL Ace Hardware 5304F 5350 Spring Hill Dr 34606 352 686 4743 SPRING HILL National Floor Care 5588 Commercial Way 34606 352 686 6711 800 245 1946 ST PETERSBURG Keystone Electric 4604 Central Avenue 33711 813 321 1124 STUART Appliance Doctors 3166 S E Dixie Highway 34997 561 287 6437 SUNRISE Muller Appliance Service 2116 North University Drive 33322 954 749 5460 VERO BEACH Hoppe s Authorized Vacuum and Appliance 1872 Commerce Ave 32960 561 562 4466 WEST PALM BEACH Satisfaction TV Video 1980 South Congress Ave 33406 561 489 3733 800 477 3734 WILLISTON Future Electronics 10 SW 7th Street 32696 352 528 5599 800 416 1114 GEORGIA AUGUSTA A amp A Appliance Parts amp Service 1708 Walton Way 30904 706 733 5163 BRUNSWICK Arco Hardware
13. 60053 847 965 5900 DECATUR Rexx Battery of Decatur Inc 1330 East Eldorado 62521 217 422 0281 FAIRVIEW HEIGHTS Rapid Rentals 720 Lincoln Highway 62087 618 632 0630 GRANITE Midwest Golf Car amp Equipment Co 904 Thorngate Road 62040 618 797 2278 HAMILTON Discount Battery Sales 80 S 2nd Rte 136 62341 217 847 3242 JACKSONVILLE Rexx Battery Specialists 847 South Main Street 62650 217 245 2713 73520 Dodge Ram 6 27 01 2 57 PM Page 33 db ie Authorized Service Centers LINCOLN Rexx Battery Specialists 504 Keokuk 62656 217 732 2885 LOVES PARK Hi Tech Controls Inc 2198 Nimtz Road 61111 815 637 4015 MT VERNON Battery Specialists 1018 South 10th Street 62864 618 244 0091 NASHVILLE Kesel Hardware 173 West St Louis 62263 618 327 8957 NILES Household Appliance Sales amp Serv 7411 N Milwaukee Ave 60714 847 647 8250 SPRINGFIELD Bannon Electronics 1224 N Franklin 62702 217 523 0313 TAYLORVILLE Battery Specialists Golf Cars 800 Springfield Road 62568 217 824 3943 INDIANA EVANSVILLE Electro Hygiene Co 1614 S Kentucky 47714 812 425 2671 FT WAYNE Southside Vacuum Co Inc 3702 South Calhoun Street 46807 219 745 7788 888 209 8113 INDIANAPOLIS Brand Service Center 1827 N Meridian Street 46202 317 924 1386 INDIANAPOLIS Sullivan Hardware Do It Center 7021 N Keystone 462
14. 701 Graymont Ave North 35203 205 323 5831 BIRMINGHAM Frigid Service amp Sales 1861 Centerpoint Rd 35215 205 853 3952 BIRMINGHAM HOMEWOOD Frigid Appliance Center 154 West Valley Ave 35209 205 942 3959 DECATUR Peddler II 1000 B Beltline Road 35603 205 350 1044 DOTHAN Bill s Appliance Service 208 Bic Road P O Box 1192 36308 334 792 7746 DOUGLAS Brown Hardware Highway 75 35964 205 593 6086 HUNTSVILLE C amp G Appliance 307 Jordan Lane 35805 205 837 4551 MOBILE Fosters Appliance Repair 1660 South Beltline Highway 36693 334 666 2670 NORTHPORT Appliance Connection 2703 McFarland Blvd 35476 205 339 2774 TROY Specialty Batteries 1317 S Brundidge St P O Box 1045 36081 834 670 6800 800 477 8230 ALASKA ANCHORAGE Ken s Electronics Service 360 E International Ste 8 99518 907 562 3443 FAIRBANKS Appliance Service Co Inc 700 23rd Ave 99701 907 452 1000 ARIZONA GLENDALE Elliott Electric Appliance Service 6242 N 43rd Avenue 85301 623 937 2613 SCOTTSDALE Elliott Electric 7515 E McDowell Road 85257 480 946 7487 ARKANSAS FT SMITH Bromley Appliance Service 614 North 10th Street 72901 501 782 9646 GLENWOOD Gardening Plus 110 North 2nd Street 71948 870 356 2233 JONESBORO Best Sewing amp Vacuum amp Repair 2235 S Caraway Road 72401 501 935 4739 800 844 4739 LITTLE ROCK C amp
15. Should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the store Power Wheels has provided a nationwide network of authorized service centers Please refer to the list in this manual Power Wheels is continually expanding our Authorized Service Center Network If there is not an authorized service center in your area please call Consumer Relations for information 1 800 348 0751 THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH MAY VARY FROM STATE TO STATE PLEASE SAVE YOUR ORIGINAL SALES RECEIPT Problems and Solutions Guide IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 between 8 AM and 6 PM EST Monday through Friday Or contact your local Power Wheels authorized service center For the location nearest you please refer to the Authorized Service Center list beginning on page 32 Vehicle does not run Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that th
16. fastener 1 4 turn to the locked position IMPORTANT Remember to keep the lock fasteners locked at all times to prevent children from accessing the vehicle battery compartment 21 d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 22 abs ie Label Decoration Proper label application will help to keep the labels looking their best When applying labels keep the following guidelines in mind e Wash your hands before applying the labels e Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils e Place the labels exactly as shown in the illustrations e For best results avoid repositioning a label once it has been applied to the vehicle e After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your vehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles 13 N2 mn om H A Y A oo f AEN al a se i AE D i a DODGE 14 12 22 d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 23 Label Decoration Hint Remove the center of each 3 label ip DPL FZ AT O Q A J T 3 AUKEN N 16 Left Side View a LITAI BS set KY E GZA 15008 Right Side View 23 73520 Dodge Ram 6 27 01 2 57 PM Page 24 abs ie Battery Installation
17. not mix old and new batteries e Do not mix different types of batteries alkaline standard e Replace the battery compartment door and tighten the screw with a Phillips screwdriver Do not over tighten carbon zinc or rechargeable nickel cadmium e Remove the batteries during long periods of non use Always remove exhausted batteries from the sound box Battery leakage and corrosion can damage the vehicle e Dispose of batteries safely e Do not dispose of batteries in a fire The batteries may leak or explode e Never short circuit the battery terminals e Non rechargeable batteries are not to be recharged e Only batteries of the same or equivalent type as recommended in these instructions are to be used e If removable rechargeable batteries are used they are only to be charged under adult supervision it has been properly repaired d SE e Rechargeable batteries are to be removed from the sound box before they are charged e If you use a battery charger it should be examined regularly for damage to the cord plug enclosure and other parts Do not use a damaged battery charger until e When sound from the sound box becomes faint or if the sound stops working it s time to replace the batteries ue 73520 Dodge Ram 6 27 01 2 57 PM Page 20 abs ie Sound Box Steering cD See A T A j C 7 EN ye ay K 9 LAT e Y I e Fit the sound box i
18. 20 317 255 9230 NEW ALBANY Wells Hardware Inc 1011 Vincennes Street 47150 812 944 4523 SOUTH BEND Ray s TV and Appliance 60717 US 31 South 46614 219 291 1630 SOUTH BEND OSCEOLA AAA Appliance Service Co 11868 Lincoln Way West 46561 219 679 4981 TERRE HAUTE Corey Electronics 1101 S 8th Street 47802 812 232 8786 888 232 8786 IOWA BETTENDORF K amp K True Value Hardware 1818 Grant Street 52722 319 359 4473 CEDAR RAPIDS Stalker Electric Inc 110 3rd Ave SW 52404 319 364 5646 COUNCIL BLUFFS Millard Television Inc 1840 Madison Avenue 51501 712 322 9552 DES MOINES Quality Appliance Repair Center 1417 Walnut Street 50309 515 288 0108 DUBUQUE Shaver s Plus 450 Central Avenue 52001 319 556 4442 FT DODGE Messerly Electronics 614 1st Avenue South 50501 515 576 4480 GRINNELL Bikes To You Inc 921 Broad Street 50112 515 236 8600 MARSHALLTOWN Blink Electric Motors Inc Rear 116 N 1st Avenue 50158 641 752 3036 NORTH LIBERTY Ace Electric Inc 165 Hwy 965 NE 52317 319 626 3007 800 326 3007 SIOUX CITY Millard Television Inc 1419 Hamilton Bivd 51103 712 258 3435 KANSAS CHANUTE Zimmerman Electric Service 1202 West Beech P O Box 533 67720 316 431 2260 800 362 0909 COLBY Gavon s Electronics 1870 South Range 67701 913 462 6601 JUNCTION CITY R C Hobbies 115 W 7th Street 66441 913
19. 517 463 5871 ALMONT Almont Do It Center 5336 4545 Vandyke 48003 810 798 8922 BAY CITY Bay Vac amp Pedal 805 Columbus Ave 48708 517 892 7516 BRIGHTON Complete Battery Source 8023 W Grand River 48116 810 220 1050 DEARBORN McNichols Electric Service 1836 Grindley Park 48124 313 563 7550 DETROIT McNichols Electric Service 13725 W McNichols 48235 813 342 6070 800 562 4226 DETROIT ROYAL OAK McNichols Electric Service 4115 West 13 Mile Road 48072 810 288 5135 FLINT DAVISON Gill Roy s Hardware 8405 E Davison 48423 810 653 2288 FLINT SWARTZ CREEK Gill Roy s Hardware 9061 Miller Road 48473 810 635 2020 GAYLORD Alpine Electronics 604 West Main 49735 517 732 5004 800 244 6633 GRAND RAPIDS Superior Appliance Service Co 1050 Scribner Avenue NW 49504 616 459 3271 JACKSON Hammond Hardware 1800 Francis St P O Box 7 49204 517 782 0704 33 d SE LANSING Rapid Appliance Service Inc 1454 E Michigan Avenue 48912 517 485 1320 MARLETTE Thumb Appliance and Retail Center 3441 Main Street 49684 517 635 7848 MIDLAND Gill Roy s Complete Hardware 3128 Jefferson Ave 48640 517 832 2774 PRUDENVILLE Ford s Do It Center 841 W Houghton Lake Drive 48651 517 366 7622 ROYAL OAK McNichols Electric Service 4115 Thirteen Mile Road 48072 248 288 5135 TRAVERSE CITY Gil Roy s Hardware 2701 Zimm
20. 73520 Dodge Ram 6 27 01 2 56 PM Page 1 abs ie Cc LD 6 _ RAM TRUCK Product features and decoration may vary from the picture above Please read this manual and save it with your original sales receipt Tools needed for assembly Phillips Screwdriver Hammer Safety Scissors and Slotted Screwdriver tools not included Use only with a Power Wheels Type H 6 Volt Battery Power Wheels 25 Amp Fuse and Power Wheels Type H 6 Volt Charger all included Dodge is a registered trademark of DaimlerChrysler Corporation Dodge Ram Truck and its trade dress are used under license from DaimlerChrysler DaimlerChrysler Corporation 2001 Goodyear and winged foot design and Wrangler for tires are trademarks of the WWW powerwheels com Goodyear Tire and Rubber Company used with permission Fisher Price Power Wheels Power Wheels by Fisher Price and Power Lock are U S trademarks of Mattel Inc POWER Owner s Manual WHEELS with Assembly Instructions o e by Fisher Price For Model 73520 d ar 73520 Dodge Ram 6 27 01 2 56 PM Page 2 P Table of Contents A Important Information naaa aaa aaa ecg sbeeeuraesca neces eeee ether dbbewuses aees585Ga84 2 B Warnings and Cautions a naa aeaa hee bey ce en ceasee dee eb eeanesdbstheenaewad ease as 3 G Paes errereen bbe oe Gees ohne hess es oe ek BOS ee ee yee bbe eee he ek oA wees ee ane ee eo 4 D Fane DIGG 64 we eo te
21. Hardware Inc 2021 Kirkwood Highway 19805 802 995 1260 SHELBYVILLE Ahern amp Sons Inc 2 S Dupont Hwy RT 2 19975 302 486 4100 FLORIDA ATLANTIC BEACH First Coast Repair 25 Seminole Road 32233 904 246 4616 BOYNTON BEACH Palm Beach Vacuum Inc 1865 W Woolbright Road 33425 561 243 9999 CALLAHAN Arc Electronic Repair 951 Blackhills Dr Suite D 32011 904 879 3556 CAPE CORAL Family Hardware Do It Express 622 SE 47th Terrace 33904 941 542 6365 DELRAY Mister Fix It 209 S E 2nd Avenue 33483 561 243 9999 GAINESVILLE Authorized Appliance Service Co 2614 S W 34th Street 32608 352 375 3886 HIALEAH S O Service Co 925 Hialeah Drive 33010 305 887 6275 HOMESTEAD C M S Inc 1996 N E Campbell Drive 33033 305 247 9700 JACKSONVILLE Authorized Appliance Service Co 6120 5 Powers Avenue 32217 904 737 5312 LAKECITY S amp S Mowers Inc RT 10 Box 35916 32025 904 755 2957 LAKELAND Electric Shaver amp Small Appliance 4243 S Florida Avenue 33813 863 644 4690 MIAMI Goodman s Sales amp Service 13130 SW 128 Street 3 33186 305 278 8822 NORTH PALM BEACH Appliance Doctors 450 Northlake Blvd 33408 407 845 0377 OCALA Vacuums Center and Gifts 422 South Pine Street 103 34474 352 732 6335 ORLANDO Pine Hills Appliance Svc Co 6100 4 W Colonial Drive 32808 407 299 1271 ORLANDO Southern Electric Co
22. ICELLO Wayne s a Engine 66 St John Street 12701 845 796 1851 OCEANSIDE Turnpike Appliance Service 3495A Lawson Boulevard 11572 516 486 5700 POUGHKEEPSIE S amp S Appliance Sales amp Service 390 Violet Avenue 12601 914 452 6122 RICHMOND HILL Lockdoctor Locksmiths 104 37 Atlantic Ave 11418 718 441 6242 ROCHESTER Benfante Appliance Service 1286 Mt Hope Avenue 14620 716 473 8765 STATEN ISLAND Springstead Lumber 6232 4255 Amboy Road 10308 718 984 0300 SYRACUSE County Wide Appliance 1001 N State Street 13208 315 479 5253 877 479 5253 TUCKAHOE Authorized Appliance of Westchester 26 Columbus Ave 10707 914 961 8011 WARWICK Wadeson Home Center 60 Forester Ave 10990 845 987 2215 800 982 2215 NY only YORKVILLE Yorkville Battery Inc 126 Whitesboro Street 13495 315 736 2307 NORTH CAROLINA ANDREWS Smoky Mountain Hobbies 200 Stewart Road 28901 828 321 9836 ASHEVILLE Skyland Hardware 3179 Sweeten Creek Road 28803 704 684 0308 CHARLOTTE Authorized Appliance Servicenter 1020 Tuckaseegee Road 28208 704 377 4501 800 532 6127 CLINTON Danny s Service Center 119 Vance Street 28328 910 592 3200 ELIZABETH CITY Coastal Office Equipment Co 501 East Church Street 27909 919 335 2927 GREENSBORO Little Creek Electronics 3310 N Church Street 27406 336 375 9890 877 446 7144 JACKSONVILLE Discount
23. Leaving the battery in a discharged condition will ruin it e Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle e Do not store the battery on a surface such as a kitchen countertop which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you store the battery e Do not store the battery in temperatures above 75 F or below 10 F e Prevent the battery from moving freely inside the battery compartment Always use the battery clamp to secure the battery in the battery compartment e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage is detected do not use the charger or the battery until you have replaced the worn or damaged part Battery Care and Disposal Disposal amp X e Your Power Wheels battery is a sealed lead acid battery It must be recycled or disposed of in an environmentally sound manner e Do not dispose of a lead acid battery in a fire The battery may explode or leak e Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of sealed lead acid batteries with household trash is prohibited by law in most areas e Return exhausted batteries to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local selle
24. MAINE GREENE Brule s Auto Clinic amp Sales 968 Sawyer Road 04236 207 375 4872 PERU Mountain Valley Sports 58 Ridge Road 04290 207 562 7164 PORTLAND Colonial Electronics Inc 259 St John Street 04102 207 774 6666 MARYLAND ABERDEEN Burkheimer Garden Equipment 651 Gilbert Road 21001 410 734 4577 BALTIMORE Colgate Hardware 6711 Holabird Ave 21222 410 633 6363 BERLIN Myers Auto Power Tool Rental Co Inc 10714 Ocean Gateway 21811 410 641 3497 GAITHERSBURG Waters Appliance Service 216 E Diamond Avenue 20877 301 258 7500 800 225 5009 GLEN BURNIE Taylor Rental 7389 Baltimore Annapolis Blvd 21061 410 768 1933 800 836 8464 LOVEVILLE Hancock Refrigeration Co Inc 28650 Point Lookout Rd 20656 301 475 8298 MASSACHUSETTS BOSTON MEDFIELD Wills Hardware 5 Janes Avenue 02052 508 359 4381 LOWELL Lowell Appliance Service Center Inc 564 Dutton Street 01854 508 454 8731 MAYNARD Gramp s Garage 16 Main Street 01754 508 461 0463 NEEDHAM Suburban Applicance Service Center 34 Wexford Street 02492 781 449 8787 QUINCY Appliance Service and Parts Inc 582 Washington Street Rt 3A 02169 617 773 6656 SALEM Fix Master Inc 190 North Street 01970 508 745 0004 SPRINGFIELD Utility Electric Service Inc 810 Main Street 01101 413 781 1635 MICHIGAN ALMA JTS Electronics LLC 306 East Center Street 48801
25. MONTANA BILLINGS Radio Equipment Company 1120 16th Street West 59104 406 256 9778 800 711 4024 NEBRASKA GRAND ISLAND Mundt s Small Appliance amp Vacuum Repair 1822 W Northfront Street 68803 308 382 5084 LINCOLN CB Small Appliance 432 South 11th Street 68508 402 475 2546 LINCOLN Sperry TV 1115 North 47th St 68503 402 464 9181 LINCOLN Sperry TV 3201 Pioneer Suite 33 68502 402 327 8111 NORTH PLATTE Sperry TV 1855 West A Street Westfield Shopping Center 69010 308 532 5200 OMAHA Myers Electric Co 7342 Farnam 68114 402 393 8388 800 234 1414 NEVADA LAS VEGAS Burney s Commercial Service Inc 4480 Aldebaran Avennue 89108 702 736 0006 MINDEN Valley Home amp Sport Center 1587 Highway 395 89423 775 782 5111 NEW HAMPSHIRE MARLBOROUGH Electronics Aid Inc 32 Roxbury Road P O Box 325 03455 603 876 4161 NEW JERSEY DENVILLE Ranft s Denville Vacuum amp Appliance 12 Broadway 07834 973 627 1156 HAWTHORNE Ter Kuile Inc 206 Diamond Bridge Avenue 07506 201 423 1142 73520 Dodge Ram 6 27 01 2 57 PM Page 34 abs ie Authorized Service Centers HIGHLAND PARK Dash Electronics 10 North Second Ave 08904 732 247 2495 HOWELL South Jersey TV Service Inc 4232 Rt 9 South 07731 908 363 5550 800 244 3094 MAPLEWOOD Kiss Electrical 36 Newark Way 07040 973 275 9400 SOUTHAMPTON Southamp
26. Market Street 45801 419 229 9070 800 826 9663 MANSFIELD Boliantz Hardware 860 Ashland Road 44905 419 589 5467 PORTSMOUTH Market St Hardware amp Toy Town 217 Market Street 45662 740 456 5704 TOLEDO Broadway Sales and Appliance Repair 1621 Broadway 43609 419 241 9731 800 436 5415 WELLINGTON Travelite Inc 100 Industrial Avenue P O Box 60 44090 440 647 3670 800 326 0406 YOUNGSTOWN O Connor s 3224 Market Street 44507 330 782 4705 OKLAHOMA McCALESTER Quality Upholstery 803 East Gene Stipe Blvd 74501 918 423 4747 OKLAHOMA CITY Appliance Services by CK 101 East Madison 73105 405 525 8862 OKLAHOMA CITY Oaklahoma Service Center 1940 North May Street 73107 405 946 9841 TULSA H L Moss Inc 1714 E 15th Street 74104 918 744 1305 800 248 5948 OREGON EUGENE Oldfield s 1465 West 7th 97402 541 485 6000 800 944 0238 PORTLAND Appliance Repair Central 2033 N E Columbia Blvd 97211 503 285 1828 800 588 7339 PENNSYLVANIA ALTOONA Frye s Sweeper amp Sewing Center Inc 1400 Valley View Boulevard 16602 814 943 5001 800 640 1308 BUTLER Battery Warehouse 469 Cunningham Street 16001 724 287 3191 CRANBERRY Batteries Plus North Cranberry Towne Plaza 20808 Route 19 16066 724 742 1690 ERIE Parke T Morrow Inc 627 West 26th Street 16508 814 455 7566 GROVE CITY Battery Warehouse 620 E
27. NM SS a o wwg sm aT Bottom View e Turn the vehicle body over so that the bottom faces you e Slide two washers onto one of the front axles e Slide a white round bushing with small hole ring end first onto the front axle e Repeat this procedure to attach two washers and the other white round bushing to the other front axle White Round Bushing White Round Bushing d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 15 p Assembly Circular Indents Rectangular Indent M K i DA Inside of Front Wheel Outside of Front Wheel AN2 Center Rib e Identify the inside and the outside of the front wheel Inside of front wheel has circular indents e Fit a traction band onto the center rib on one of the front Outside of front wheel has a rectangular indent wheels as shown Hint If it is difficult to position the traction band on the wheel try soaking it in hot water for about two minutes to soften it Front Wheel Hil my Traction Band lt 5 Tons R e Using a slotted screwdriver pull the other side of the traction band around the front wheel e Make sure the traction band covers the center rib all Circular around the front wheel Bottom View e Repeat assembly steps 20 and 21 to assemble the other Y traction band to the other front wheel Inside of Front Wheel e Slide a front wheel inside first onto a front axle 15
28. Sales and Service 468 B Western Blvd 28456 910 455 6700 RALEIGH Authorized Appliance Service Center 800 North Person Street 27604 919 834 3476 WINSTON SALEM Authorized Appliance Service Center 904 S Marshall Street 27117 910 725 5396 NORTH DAKOTA BISMARCK Guitarland 210 E Main Street 58501 701 255 0212 DICKINSON Fix It Shop 316 21st Street E 58601 800 871 0766 FARGO General Parts amp Supply Co 10 S 18th St 58108 701 235 4161 800 279 9987 OHIO AKRON Advanced Appliance Service Company 73 W Exchange Street 44308 330 762 8968 BROOKLYN HEIGHTS Philips Consumer 950 Keynote Circle 44131 216 741 3334 800 331 7037 CANTON Appliance Parts Co 1267 Dueber Avenue SW 44706 330 453 8077 CINCINNATI H amp S Service 458 Cincinnati Batavia Pike 45244 513 528 0808 CLEVELAND M ENTOR Lake Erie Lawn amp Garden 7833 Munson Rd 44060 216 257 9000 CLEVELAND PARMA Majors Appliance 5785 Ridge Road 44129 216 884 7200 CLEVELAND WESTLAKE Philips Consumer Electronics 24090 Detroit Avenue 44145 216 899 2040 800 331 7037 DAYTON Layer Electric 603 South Ludlow Street 45402 937 224 9608 DAYTON NEW CARLISLE Ballweg Do It Center 3300 South Dayton Lakeview Rd 45344 937 849 1306 GALION Allied Electrical Repair 1404 Harding Way East 44833 419 468 4962 800 648 6771 LIMA Crouse Lumber Do It Center 333 E
29. TO RICO MAYAGUEZ Cardona Appliance Service 8 San Vicente Street 00680 787 832 8366 MAYAGUEZ AAA Melendez Rental Calle Post 319 Sur 00680 787 832 5225 PONCE Ferreteria Vivian Centro Comercial Los Caobos 7 00731 787 840 0677 PUERTO NUEVO Buckeye Service 1013 Jesus T Pinero Avenue 00920 787 782 6175 SOUTH CAROLINA AIKEN Dunagan s Sewing amp Vacuum 1536 Whiskey Road 29803 803 649 6777 BELTON American Pro Office Equipment 309 Forest Lane 29627 864 338 9041 CHARLESTON HEIGHTS Dorchester Electric Service 3575 Dorchester Avenue 29405 803 747 5221 COLUMBIA Authorized Appliance Servicenter 1811 Taylor Street 29202 803 254 8414 DARLINGTON Hobbies and More 1570 South Main Street 29532 803 393 0355 FAX 803 393 8171 EASLEY Trails End are 110 Pendleton Street 29640 864 306 1684 FORT MILL Service Engines Inc 3356 SC Highway 51 29715 803 548 1778 800 845 1191 GREENWOOD Bikes amp Boards amp Mopeds 203A Montague Avenue 29646 864 229 2453 SENECA Seneca Micronics 110 East North First 29678 864 882 6593 SOUTH DAKOTA RAPID CITY Mick s Electric Inc 1304 Oregon Street 57701 605 348 2335 WINNER Nelson s Electronics Inc 422 West 2nd Street P O Box 369 57580 605 842 1611 888 842 1699 TENNESSEE CHATTANOOGA Consumer Service Company 2607 E 47th Street 37407 423 867 8629 DANDRIDGE Save More Sa
30. W Tool Repair 1303 W Markham 72201 501 374 1911 ROGERS Kressel s Vacuum amp Repair 115 North 5th Street 72756 501 636 7894 STUTTGART Davis Lumber Company 301 East Michigan 72160 501 673 3601 CALIFORNIA ANDERSON Hardware Express Do It Best 2681 Balls Ferry Road 96007 916 365 3783 BAKERSFIELD Southwest TV 6300 White Lane Suite B 93309 805 397 4940 CONCORD California Electric Service Center 1170 G Burnett Avenue 94520 510 827 1011 COVINA California Electric Service Center 612 Shoppers Lane 91723 818 915 4935 FORT JONES Ft Jones Frontier Hardware 11911 Main Street 96032 916 468 2266 FRESNO Valley Small Appliance 4005 E Ashlan Avenue 93726 209 224 5530 FULLERTON California Electric Service Center 1208 E Ash Avenue 92631 5020 714 870 0900 LAKE FOREST California Electric Service 22500 Muirlands Suite B 92630 949 586 9440 LOS ALAMITOS California Electric Service Center 11284 Los Alamitos Blvd 90720 562 430 2668 OAKLAND California Electric Service Center 1139 E 12th Street 94606 510 834 1050 PASADENA California Electric Service Center 2594 E Colorado Blvd 91107 818 792 3194 SACRAMENTO California Electric Service Center 1821 Q Street 95814 916 443 5711 SALINAS SRS Hobbies 1038A North Davis Road 93907 831 424 4044 800 414 4547 SAN DIEGO California Electric Service Center 3430 El Cajon Blvd
31. ace a cap nut on a flat surface inside up as shown Hint You may want to place a scrap block of wood underneath the cap nut to protect the assembly surface e Fit the rear axle into the cap nut e Tap the opposite end of the rear axle with a hammer to secure the cap nut in the rear axle Pull on the cap nut to be sure it is secure e Set the rear axle assembly aside for Assembly step 6 e Turn the vehicle body over so that the bottom is facing you e Using safety scissors cut the plastic retainer holding the motor in place e Throw away the plastic retainer Rear Wheel Front Wheel e Identify the rear wheels and the front wheels Rear wheels have a flat center tread Front wheels have a ribbed center tread e Select a rear wheel with flat center tread and go onto 10 Assembly step 4 d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 11 de a Assembly 4 Circular Indents Rectangular Indent Outideofi Rectangular Rear Wheel Bushing with Rectangular Opening Rear Axle Inside of Rear Wheel Outside of Rear Wheel e Slide the rear axle into the outside of the rear wheel e Fit a rectangular bushing e Identify the inside and the outside of the rear wheel Inside of rear wheel has circular indents Outside of rear wheel has a rectangular indent with rectangular opening e Turn the rear wheel so that the inside of the wheel is into the rectangular
32. ast Main Street 16127 724 458 1655 HARRISBURG C A Juillard Inc 2301 North Seventh Street 17110 717 233 3488 800 633 3488 JOHNSTOWN Cambria True Value Hardware West Hills Square Goucher Street 15905 814 255 4752 34 d SE KINGSTON Vac Way Appliance amp Service 595 Market Street 18704 570 288 4508 LANCASTER Colonial Electronics Inc 241 West Roseville Suite 2t 17601 717 560 2222 McDONALD Small Engine World 130 East O Hara Street 15057 724 926 3330 MOSCOW Vac Way Appliance amp Service RR 6 Box 6237 18444 570 842 4668 ORANGEVILLE Hess Do It Center amp Market Route 487 Box 4 M 17859 570 683 5162 PHILADELPHIA Appliance Care Service Corp 6407 Rising Sun Ave 19111 215 725 3112 Arhan A OLLINGDALE J F Kenney Electric 920 MacDade Blvd 19023 610 534 7373 PITTSBURGH Batteries Plus 3912 Library Road 15234 412 531 1690 READING Electric Repair Co 502 504 N 9th Street 19604 610 376 5444 800 422 8171 PA only SCRANTON Vac Way Appliance and Service 601 Cedar Avenue 18505 570 343 1121 SHAMOKIN DAM Willard Battery Outlet 138 S Old Trail 17876 570 743 5383 SHIPPENVILLE Battery Warehouse 11105 Rt 322 Riverhill 16254 814 227 2123 TROY Hoover Hardware 9 Canton 16947 800 251 2156 570 297 3445 WILKES BARRE Walter Hardware DO IT Center 57 N Welles Street 18702 570 823 1406 PUER
33. attery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Overcharged battery Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test your battery for you Battery is old and will not Even with proper care a rechargeable battery does not accept full charge last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace the battery with a new Power Wheels 6 volt rechargeable battery Do not substitute parts Wrong type or improperly installed fuse Make sure that the battery has a properly installed Power Wheels 25 amp fuse installed before charging For best performance do not use substitute parts Driving conditions are too stressful Use only on generally level ground Extreme temperatures can also affect run time 30 d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 31 ain Problems and Solutions Guide Possible Cause Solution Undercharged battery Vehicle runs sluggishly Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger con
34. attery e If your battery is old and will not accept a charge do not and men ily CAUSE a fire resulting in leave it in the vehicle Always remove a dead battery serious injury Lift and carry the battery from the vehicle by the case only Read the safety instructions on the battery Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part di siy abs ie 73520 Dodge Ram 6 27 01 2 56 PM Page 9 Battery Charging IMPORTANT The battery must be removed from your vehicle for the initial charge in order to complete assembly E After assembly is complete you do not need to remove Charger Battery the battery from your vehicle to recharge it Connector Connector POWER WHEELS e Plug the battery connector into the charger connector Battery Clamp e While pushing the battery clamp lift and remove the battery from the battery compartment e Remove and throw away the protective cardboard material 25 Amp Fuse e Plug the charger into a standard 120 volt wall outlet Note If power flow to the wall outlet is controlled by a switch make sure the switch is ON e Before first time use charge the battery for at least 18 hours Never charge the battery longer than 30 hours Note The battery must be u
35. battery from your vehicle resulting in serious injury tO Tenet aHtt U fP Wheels tsi e Before charging the battery examine the battery case for D a ate A cracks or other damage which may allow sulfuric acid products other than Power Wheels electrolyte to leak during the charging process Never vehicles could cause overheating attempt to charge a damaged battery If damage is fire or explosion detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to surfaces it contacts Take precautions CAUTION Use the charger in dry locations only e The battery must be handled by adults only The battery is heavy and contains to protect any surface on which you charge the battery sulfuric acid electrolyte Dropping the e Do not charge the battery on a surface such as kitchen battery could result in serious injury Sete Hope which alll be damaged gt the acid Never allow children to charge the battery contained inside the battery Take precautions to protect Battery charging must be done by adults the surface on which you charge your battery only A child could be injured by the e Use only a Power Wheels Type H 6 volt charger electricity involved in charging the battery 120 VAC 60 Hz 12W with an output of 6 VDC Never lift or carry the battery by the wires 4 8W 800 mA to charge your Power Wheels 6 volt battery or connector This can damage the b
36. cally stops the vehicle when your child s foot is lifted from the pedal e Make sure your child is comfortable with steering the vehicle and automatically knows how to stop Reverse Reverse Button IMPORTANT To avoid damaging the motors and gears be sure to stop the vehicle before switching from forward to reverse e Press the REVERSE O button below the seat e Press the foot pedal The vehicle backs up ata maximum of 2 2 mph 28 FCC Statement United States Only This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to part 15 of the FCC rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver Connect the equipment into an outlet on a circuit different from t
37. e and can perform non warranty repairs for a minimal charge Please see the Authorized Service Center list beginning on page 32 to find the authorized service center nearest you or call 1 800 348 0751 e Please complete and return the enclosed Registration Card today or call 1 800 348 0751 to register your vehicle by phone 73520 Dodge Ram 6 27 01 2 56 PM Page 3 abs ie Warnings and Cautions ELECTRICAL HAZARD N WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery clamp e PREVENT FIRE Do not bypass a Power Wheels fuse It is a safety device Use only a Power Wheels 25 Amp fuse Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Never lift or carry the battery by the wires or connector This can damage the battery and possibly cau
38. e Centers Or contact your local Power Wheels Authorized Service Center POWER WHEELS For the location nearest you refer to the DAME e sie Authorized Service Center list in this manual Fisher Price Inc a subsidiary of Mattel Inc East Aurora New York 14052 U S A 2001 Mattel Inc All Rights Reserved Printed in Mexico 73520pr 0920 ae Se
39. e charger is plugged into the wall Make sure power flow to the wall outlet is ON Charger is not working There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your Charger contact your local Power Wheels authorized service center They can test your charger for you Wrong type or improperly installed fuse Make sure that the battery has a properly installed Power Wheels 25 amp fuse before charging Do not substitute parts Blown fuse Make sure that the fuse in the battery is in good condition Replace a blown fuse with a Power Wheels 25 amp fuse Do not substitute parts d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 30 rain Problems and Solutions Guide Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors Dead battery If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized service center Electrical switch damage The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt Motor damage sand or gravel Contact your local Power Wheels authorized Loose wire or loose connectors Vehicle does not run con t
40. e soap and water or spray the vehicle with a hose e To ensure that your vehicle stays in good operating order we recommend that you periodically have your vehicle checked by a Power Wheelse authorized service center See page 32 for the list of authorized service centers or call 1 800 348 0751 for the location of the authorized 26 service center nearest you A ay 73520 Dodge Ram 6 27 01 2 57 PM Page 27 abs ie Rules for Safe Driving RIDING HAZARD N WARNING Prevent Injuries and Deaths 8 e Direct Adult Supervision Required e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings 9 generally level to prevent tipovers away from steps driveways roads and alleys Teach Safety Rules to Children While children can quickly develop the skill necessary to drive this vehicle it is important to remember that their judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before children use this vehicle an adult should carefully evaluate the driving area as well as the children s skill level and ability to drive this vehicle safely Children are not always able to recognize or anticipate hazards even when they have been taught about them THERE IS NO ACCEPTABLE SUBSTITUTE FOR DIRECT ADULT SUPERVISION Teach appropriate safety rules to your child before allo
41. ed Oe eae eee ede Ae eee tae Ge On eeRE He Eee E Aswad 7 E Battery Charging 1 2426c 0558 eben G82 bE hE SOLER SE CHO SEPA S EL EATER eee eee 8 F ASOMOV 6 sxe eee oe bbb deen bs FO nn od Sea eee eee eee bh Bore 26 ee hee eee eo 10 G Label Decoration a 5 lt inc cing oe See Reba g Oe eee ee BE he ee a ee ob eee bee RE ee be oS elem eas 22 m Boater NSM j2tispace tatacienceaet ote teed ee ee et bee bee eee eee oe ee 24 l Battery Care and Disposal nnana eh eee boa ee ee ee Oa ae OR ee we ES ee Row 26 J Canad For Your Vehicle 4 24cceetaacase nds phe hae heen ee ee heed ek OBA eae ee ee eee oe 26 K Rules Forsala DVINO 2 sa0n 06 540 ceo beens eed EEE EO E ey a eee eae a 27 L How to Operate Your Vehicle 10 nanana aaa 28 M FCC Statement United States Only nnan aana aaa eee eens 28 N Statement of Limited Warranty 0 0 0 0 00 ccc eee eee eee eee eens 29 O Problems and Solutions Guide 0 0 0 ee ee eee 29 P Authorized Service Centers 0 0 0 cc ee ee eee eens 32 Important Information e Your new vehicle requires adult assembly Please set aside at least 45 minutes for assembly e You must charge your battery for 18 30 hours before you use your vehicle for the first time We recommend that you start charging your battery before beginning assembly Please see Battery Charging beginning on page 8 for detailed instructions e Read this manual carefully for important safety information and operating instructi
42. el Bottom Steering Wheel Top e Place the steering wheel top face down on a flat surface e Fit the steering wheel bottom to the steering wheel top e Insert four 8 x 4 screws through the steering wheel 18 bottom and into the steering wheel top Tighten the screws with a Phillips screwdriver Do not over tighten d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 19 abs ie Assembly a Assembly Tool 354 Cap Nut SS Steering Wheel Large Opening Upright Steering Column 354 Cap Nut a e Turn the vehicle body upright e Position the steering wheel with the large opening upright Fit the steering wheel onto the steering column e Fit a 354 cap nut on the end of a steering column e Cover the cap nut with the assembly tool and tap it with a hammer until the cap nut is secure on the steering column e Remove the assembly tool Pull on the cap nut to be Sure it is secure on the steering column e The assembly tool is no longer needed for assembly Throw away the assembly tool 19 AAA LRO3 1 5V x3 e Loosen the screw in the sound box battery compartment door with a Phillips screwdriver Battery Compartment Door e Lift to remove the battery compartment door e Insert three AAA LROS alkaline batteries as indicated inside the battery compartment Hint We recommend using alkaline batteries for longer battery life Battery Tips e Do
43. erman Road 49684 231 929 8160 MINNESOTA BLAINE Barness 1 8701 Central Ave NE 55434 763 780 7229 BRAINERD Git A Round 4299 Hwy 371 North 56401 218 828 8088 DULUTH All Brand Mr Fixit 16 West First Street 55802 218 722 1499 ST PAUL Barness 1573 University Avenue 55104 612 646 3109 MISSISSIPPI HATTIESBURG Champion Cycle amp Fitness 2625 Lincoln Road 39402 601 310 0270 IUKA W H Fairless Hardware Co Inc 117 Fulton Street 38852 662 423 9256 800 797 9457 JACKSON RIDGELAND Propeller Service 291 Hwy 51 Suite D6 39157 601 856 3191 MERIDIAN Broadmoor Home Center 2420 Old North Hills Street P O Box 3280 39305 601 483 7373 SALTILLO Polaris Outdoor World 3463 Tom Watson Drive 38866 662 680 4733 STARKVILLE East Mississippi Lumber Co 300 Russell Street 39759 662 323 3554 MISSOURI GLADSTONE Mar Beck Appliance Service Co 6559 North Oak Traffic Way 64118 816 436 9191 HANNIBAL Williams Equipment amp Electric Motor 124 Corporate Square 63401 573 248 3887 877 234 6873 INDEPENDENCE Mar Beck Appliance Service Co 4476 South Noland Road 64055 816 478 1889 KANSAS CITY Mar Beck Appliance Service Co 303 W 79th Street 64114 816 523 6931 POPLAR BLUFF Mills Iron amp Supply 1919 S Westwood Blvd 63901 573 785 2628 ST LOUIS Authorized Appliance Inc 2355 Hampton Avenue 63139 314 647 4250
44. hat to which the receiver is connected Consult the dealer or an experienced radio TV technician for help CAUTION Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user s authority to operate the equipment d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 29 abs ie Bumper to Bumper Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle Six month limited warranty on the 6 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 6 volt battery included by Power Wheels with the original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other causes not arising out of defects in materials or workmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAWFUL FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU
45. indent face up in the outside of the rear wheel Driver Ribbed Side Up Ww U O O ms U A Inside of Rear Wheel Fart Struts We 5 a a a ee ee se e Position the driver so that the ribbed side is up e Fit the driver into the inside of a rear wheel as shown e Insert a 10 x 2 screw through one of the the holes in the driver Tighten the screw with a Phillips screwdriver Do not over tighten e Locate the struts on the underside of the vehicle body Note the angle on the top edge of each strut e Position the axle supports so that the top edge angle matches the top edge angles of the struts e Fit an axle support into each of the struts Be sure the hole in each axle support aligns with the holes 1 in the struts d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 12 abs ie Axle Support ee Rear Wheel Driver Inside Rear Wheel e Fit the end of the rear Black Round axle assembly through Bushing LA i the motor strut and axle support e Align the ribs on the rear wheel driver with the motor teeth Fit the rear wheel driver to the D motor teeth e Insert a black round bushing with large Tos hole barrel side first through the outside edge of each strut and into each axle support as shown Axle Support mH ES Bottom View e Continue to insert the rear axle through the other strut and axle support
46. l 2 Note The motor is temporarily fastened to the inside of the vehicle body Refer to step 1 in the Assembly section page 10 Cab 73520 Dodge Ram 6 27 01 2 56 PM Page 5 p Rear Axle Grille a a Steering Column Seat EN Steering Linkage T ee Axle Support 2 Driver Sound Box Steering Wheel Cover Front Axle 2 Steering Wheel Top Steering Wheel Bottom Traction Band 2 abs ie 73520 Dodge Ram 6 27 01 2 56 PM Page 6 Note For your convenience an extra 25 amp fuse is included QD CI Rectangular Bushing Black Round Bushing th Circul nd with Large Hole 3 with Circular Opening AD LI Rectangular Bushing Key A bl White Round Bushing with Rectangular i with Small Hole 2 l n 2 PECA Em EEE ovo 25 Amp Fuse 6 Volt Charger nz 6 Volt Battery Not Shown Label Sheet 2 Note For your convenience one extra 437 cap nut and two extra 354 cap nuts are included D N See 8 x 3 4 Screw 12 437 Large Cap Nut 2 i 10 x 1 2 Screw 354 Small Cap Nut Washer 4 All Shown Actual Size d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 7 abs ie Parts Diagram Vehicle Body Sound Box 26 6 Volt Battery Seat Hood 27 Traction Band 2 Grille Rectangular Bushing 28 25 Amp Fuse Rear Wheel 2 with Circular Hole 2 Key Assembly Rear Axle
47. le could roll backwards at an unsafe speed Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near flammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off The presence of flammable liquids or vapors could cause an explosion or a fire Keep all flammable products in tightly sealed containers and away from the vehicle Do not allow a child to operate the vehicle without direct adult supervision To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use 73520 Dodge Ram 6 27 01 2 57 PM Page 28 di ar How to Operate Your Vehicle IMPORTANT Use this vehicle ONLY outdoors Most interior flooring can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to floors if the vehicle is used indoors Drive Forward Forward Button e Press the FORWARD button below the seat e Press the foot pedal The vehicle drives forward at a maximum of 2 72 mph To Stop e Your vehicle has a patented electronic braking system that automati
48. les 1291 W Hwy 25 70 37725 865 397 1255 KNOXVILLE Ay eat amp Electric Service Company 3613 Sutherland Avenue 37919 865 588 5395 800 585 5395 KNOXVILLE Authorized Appliance Service Center 1206 North Central Street 37917 865 524 3376 MEMPHIS Camp Electric Co 647 Madison Avenue 38103 901 527 7543 800 238 7345 NASHVILLE Webb s Appliance Service Center Inc 1519 Church Street 37203 615 329 4079 800 899 4079 PINEY FLATS Appalachian Small Engines 6192 Hwy 11E 37686 423 391 0185 73520 Dodge Ram 6 27 01 2 57 PM Page 35 abs ie Authorized Service Centers TEXAS AMARILLO Reid s Appliance Service Inc 9 06 Georgia 79102 806 373 8812 CORPUS CHRISTI Brand Appliance amp Microwave 2751 South Staples 78404 361 854 1851 DALLAS All Type Sales and Service Co Inc 2835 Irving Blvd 75207 214 638 1170 800 717 1170 DALLAS Pearsol Appliance Co 3127 Main Street 75226 214 939 0930 FT WORTH Ft Worth Shaver and Appliance Center 1900 Montgomery Street 76107 817 335 9970 800 816 2126 HOUSTON Brand Service Center 5727 Richmond Avenue 77057 713 782 8910 KILLEEN Master Tech Repairs 501 West Elms Road Suite 10 76542 254 618 5480 LONGVIEW Foster s 3315 Gilmer Road 75604 903 759 3939 LUBBOCK Minter s 4409 50th Street 79414 806 799 3170 LUFKIN STS Audio and Video 1505 South Firs
49. lue 307 Broad Street 24592 804 572 6666 VIRGINIA BEACH Commonwealth Electric Shaver 549 Newton Road 108 23462 757 490 0500 WINCHESTER Battery Mart of Winchester Inc 1 Battery Dr 22601 703 655 0065 WASHINGTON ARLINGTON Cordz Limited 105 North Olympic Avenue 98223 360 435 2471 FEDERAL WAY Martha Lake Electronics 2118 South 314th Street 98003 253 946 9033 KENNEWICK At Home Electronic Service 313 East First Avenue 99336 509 586 3800 LYNNWOOD Martha Lake Electronics 16521 13th Avenue West 98037 425 743 4178 RENTON Martha Lake Electronics 212 South West 43rd 98055 425 251 5417 SEATTLE Action Small Appliance 2125 2nd Avenue 98121 206 448 2020 SEATTLE BELLEVUE Action Small Appliance Service 1500 145th Place SE 98007 206 643 9806 SPOKANE Aalwaco Appliance N 3007 Argonne Road 99212 509 487 1089 TACOMA Martha Lake Electronics 2913 South 38th Street 98409 253 475 0668 35 di siy WEST VIRGINIA BECKLEY Jerry s Detectors Vacuum amp Appl Svc 411 Second Street 25801 304 253 3521 CHARLESTON Sneed s Vacuum amp Sewing Center 2614 7th Avenue 25312 304 744 3670 800 245 8048 WV only HUNTINGTON Mike s Appliance and Service 212 20th Street 25703 304 522 0737 MARTINSBURG Battery Mart 1161 3 Winchester Avenue 25401 304 267 7033 800 464 7918 PARKERSBURG Battery Mart 656 Seventh St
50. nector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Battery needs charging After each use the battery needs charging Make sure that the battery has a properly installed Power Wheels 25 amp fuse installed before charging For best performance do not use substitute parts Wrong type or improperly installed fuse Battery is old and will not accept full charge Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on the vehicle use and use conditions Replace the battery with a new Power Wheels 6 volt rechargable battery Do not substitute parts Vehicle is overloaded Make sure you do not overload the vehicle by allowing more than one rider at one time by exceeding the 50 Ib maximum weight capacity or by towing objects behind the vehicle Driving conditions are too stressful Use only on generally level ground Sometimes the vehicle doesn t Loose wire or connector Check all wires around the motors and all connectors to run but other times it does make sure they are tight Motor or electrical switch damage Contact your local Power Wheels authorized service center for diagnosis and repair Loose wire or connector Check all wires around the motors and all connectors to make sure they are tight When the foot pedal is pressed the vehicle won t run without a push
51. nside the steering wheel as shown Make sure the buttons face toward the back end of the vehicle e Insert a hood hinge pin into the slot in the front end of manu 36 the slots in the vehicle as shown Large Tab a Steering Large Slot i ING Wheel e Fit the large tab on the steering wheel cover into the large slot in the steering wheel e Insert and snap the small tab into the small slot in the steering wheel e Gently bend the hood to insert the other hood hinge pin into the slot in the front end of the vehicle body 20 d SE 73520 Dodge Ram 6 27 01 2 57 PM Page 21 abs ie Assembly Lock Fastener mh ae Sr rn SA N i 2nd Position i Vehicle Body e Lower the hood and insert the lock fastener tabs on into B the slots in the vehicle body Note The seat can be assembled in either of two positions for your child s comfort e Insert the seat into the vehicle body in either the 1st position or the 2 position e Insert two 8 x 3 4 screws through the seat and into the vehicle body Tighten the screws with a Phillips screwdriver Do not over tighten Assembly is now complete IMPORTANT Please carefully read the owner s information in this manual and teach your child about proper vehicle operation and rules for safe driving before allowing operation of this vehicle Unlocked Locked e Using a slotted screwdriver turn each lock
52. ons before using your vehicle Keep these instructions for future reference as they contain important information e Use this vehicle ONLY outdoors Most interior flooring can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to floors if the vehicle is used indoors e This vehicle is designed for use on asphalt and other hard surfaces on generally level terrain and by children 1 2 4 years of age e Make sure children know and follow these rules for safe driving and riding always sit on the seat always wear shoes only 1 one rider at a time e To prevent damaging the motors and gears do not tow anything behind the vehicle or overload it Do not exceed the maximum weight capacity of 50 Ibs 23 kg e f you have any questions about your Power Wheels vehicle please call our toll free service lines at 1 800 348 0751 from 8 AM to 6 PM EST Monday through Friday Trained customer service representatives are available to take your call in English or French Habla Espa ol Si usted tiene alguna pregunta necesita asistencia llame gratis 1 800 348 0755 para los Estados Unidos Tenemos representantes que hablan espa ol para atender su llamada e For your convenience Power Wheels maintains an Authorized Service Center Network with more than 400 authorized service centers nationwide Our authorized service centers will repair or replace parts under warranty at no extra charg
53. pright while charging e Recharge the battery after each use of your vehicle for at least 14 hours Do not charge the battery longer than 30 hours e Once the battery is charged disconnect the charger e Insert a Power Wheels 25 amp fuse into the battery connector from the battery connector Unplug the Note The top of the fuse will not be flush with the top of pene clie or ee ieee A ready to ne ate Me IOP ny Sianet Installation on page 24 for detailed instructions on installing your battery If your battery is already installed in your vehicle simply re connect the battery connector and motor harness connector and lower the hood Using a slotted screwdriver turn each lock fastener 1 4 turn to 9 the locked position d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 10 abs ie Assembly N WARNING Children can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children Rear Axle should not handle parts including the battery or help in assembly of the vehicle Rectangular Bushing with Rectangular 437 Cap Nut Opening 437 Cap Nut Rectangular Bushing with Rectangular Opening ie CE e Fit a rectangular bushing with rectangular opening onto the end of the rear axle Make sure the base on the rectangular bushing is down as shown e Pl
54. r of automotive batteries For the service center location nearest you please call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream Caring For Your Vehicle e Check all screws cap nuts and their protective coverings regularly and tighten as required Check plastic parts on a regular basis for cracks or broken pieces e During snowy or rainy weather the vehicle should be stored inside or under a protective cover Remember to charge the battery at least once per month while your vehicle is not in regular use e Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Do not wash the vehicle with soap and water Water or moisture in the motors or electrical switches can cause them to corrode and could cause switch or motor failure e Avoid operating the vehicle on sand loose dirt or gravel Sand loose dirt or gravel in the motors or electrical switches can cause them to jam and could cause switch or motor failure e The vehicle can be wiped down with a soft dry cloth For a shiny finish you can wipe plastic parts with a non wax furniture polish applied to a soft cloth Do not use auto motive wax Do not us
55. reet 26101 304 424 7250 VIENNA T amp S Lawn Landscape amp Power Equipment 1100 10th Street 26105 304 295 7633 800 559 7633 WHEELING Fast Service Center 1058 Main Street 26003 304 232 5561 800 874 4090 WISCONSIN ELK MOUND Epp Electronics E9485 A County Road EE 54739 715 879 4634 GREENBAY Kastle Carts Inc 2301 N Irwin Ave 54313 414 465 6121 LACROSSE Paul s Shaver Service 1224 Caledonia Street 54603 608 782 6291 MILWAUKEE Brand Appliance Repair Inc 6601 W Oklahoma Avenue 53219 414 54i 4340 MONONA Kiefers Shaver amp Appliance 4511 Monona Drive 53716 608 221 3322 73520 Dodge Ram 6 27 01 2 57 PM Page 36 abs ie IMPORTANT DO NOT use this vehicle for the first time until you have charged the battery for 18 hours Remember to V insert a 25 amp fuse included into the battery WV charge the battery immediately after each use WV charge the battery once a month during storage even if the vehicle has not been used Failure to follow these instructions will permanently damage your battery and void your warranty Please refer to the Battery Care Section in this manual for more information DO NOT Return your ia Vehicle to the Store 7 If you are missing parts or need assistance please call us toll free Over 400 Authorized Power Wheels Consumer Relations 1 800 348 0751 8 AM 6 PM EST Monday through Friday Servic
56. se a fire resulting in serious injury Lift and carry the battery by the case only EJ e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part e HOT motors Handle carefully RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps driveways roads and alleys N CAUTION e In the unassembled state this package contains small parts Adult assembly is required e Use the charger in dry locations only d SE 73520 Dodge Ram 6 27 01 2 56 PM Page 4 p e f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this product to the store e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded e Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant Front Wheel with Rib 2 Rear Whee
57. t Street 75901 936 639 4529 MC ALLEN All In One Berle Shop 2313 Lark Avenue 78504 210 682 8858 MIDLAND Midland Tool Specialty 918 South Main 79701 915 682 4647 800 499 0755 PASADENA Larry s TV Service 3520 Fairmont Parkway 77504 713 998 0122 ROMA True Value Hardware 1004 E Highway 83 210 849 1322 SAN ANTONIO Texas Shaver amp Appliances 8121 Callaghan Road 78230 210 344 8577 TEMPLE Master Tech Repairs 2819 West Avenue North 76504 817 773 8991 WICHITA FALLS Allens Appliance Service 2403 10th Street 76309 940 766 2635 UTAH OREM The Mending Shed 1735 South State Street 84058 801 225 8012 800 339 9297 SALT LAKE CITY Appliance Service Center Inc 210 East 6th South 84111 801 328 9703 WILLARD Peak Electric Co Inc 780 N 200 W 84340 435 723 7104 VIRGINIA ALEXANDRIA D amp S Repair Service 20 South Dove Street 22314 703 683 0009 FREDERICKSBURG Fredericksburg Electrical Repair Inc 10825 D Houser Drive 22408 540 891 7911 HARRISONBURG PENN LAIRD J L Maintenance amp Repair Inc Rt 2 Box 308 22846 540 289 9844 LOUISA Lakeside Electric Const 4344 Davis Highway Suite 2 23093 540 967 3000 RICHMOND Wells Inc 3502 Jefferson Davis Highway 23234 804 233 6726 ROANOKE Commonwealth Shaver amp Appliance Service 5524 Williamson Road NW 24012 540 366 6038 SOUTH BOSTON South Boston True Va
58. the vehicle body a A RI e Using a slotted screwdriver turn each lock fastener 1 4 turn to the locked position IMPORTANT Remember to keep the lock fasteners locked at all times to prevent children from accessing the vehicle battery compartment 25 oe 73520 Dodge Ram 6 27 01 2 57 PM Page 26 Battery Care and Disposal Care If a battery leak develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See information below for proper disposal If acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician If acid is internally ingested give water milk of magnesia or egg whites immediately Never give emetics or induce vomiting Call a physician e Charge a new battery for at least 18 hours before first use Never charge the battery longer than 30 hours Overcharging or undercharging the battery may shorten battery life and decrease vehicle running time e After the first charge recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Charge the battery after each use regardless of how long the vehicle was used e The battery must be upright while charging e Do not allow the battery to run down completely before charging e Charge the battery before storing the vehicle e Charge the battery at least once per month even if the vehicle has not been used e
59. ton Auto Center 1831 Rt 206 08088 609 859 3987 609 859 3341 SICKLERVILLE Sicklerville Hardware 540 Williamstown Road 08081 856 728 3800 TOMS RIVER South Jersey TV Service Inc Stella Towne Center 1258 Rt 166 08753 908 505 1771 TRENTON Tattersall Inc 309 N Willow Street 08618 609 393 4293 NEW MEXICO ALBUQUERQUE ey Service Center 5505 Silver Avenue 87108 505 265 7774 CLOVIS Burns Hardware 1511 N Prince 88101 505 769 2528 NEW YORK ALBANY Lake Electronic Service 1650 Central Avenue 12205 518 869 8424 800 585 3777 BAYSHORE L I Turnpike Appliance of Suffolk Inc 1253 Sunrise Highway 11706 631 665 8311 BINGHAMTON Hardware Fare DO IT Center 1139 Front Street Nimmonsburg Square 13905 607 722 9202 BRONX Home Appliance Vacuum Word 5902 Riverdale Avenue 10471 718 884 4600 BUFFALO Road 14221 718 Hectors Hardware 876 Maple Road 14221 716 688 4488 BUFFALO HAMBURG nee 5424 Abel Road 14075 716 649 5460 COMMACK L I Turnpike Appliance Service 6181 Jericho Turnpike 11725 631 499 3355 EAST AURORA Sem Fab of Western New York 455 Olean Road 14052 716 655 5228 ELMIRA Capabilities Inc 1149 Sullivan Street 14901 607 734 2006 HOWARD BEACH Crossbay Appliance Service 158 34 Crossbay Blvd 11414 718 843 4422 HUDSON Sweeps Vacuum amp Repair Center Inc 705 Warren Street 12534 518 828 5457 MONT
60. wing operation of this vehicle These rules should also be reviewed with neighborhood children or other playmates who want to drive this vehicle Riding Rules Make sure children know and follow these rules for safe driving 1 Always sit on the seat 2 Always wear shoes 3 Only 1 one rider at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off Cause a tip over or block the driver s view A child could be seriously injured 4 Do not allow any child to drive the vehicle in the street or near moving motorized vehicles 5 Do not allow any child to drive near bodies of water such as pools or creeks obstructions Such as furniture low tree limbs or play equipment or drop offs such as stairs or decks 6 Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in the daytime or a well lit area 27 10 12 d SE Do not allow your child to drive on sloped or inclined surfaces Restrict your child s driving to generally level ground ONLY Do not allow your child to drive down or across a steep slope The vehicle may gain unsafe speed even if the pedal is released to stop The vehicle may tilt and tip over The wheels could lose traction causing the vehicle to slip Do not allow your child to drive up steep inclines The motor may stop and the vehic

Fisher-Price DODGE 73520 User's Manual

Contents

Download Pdf Manuals

Related Search

Related Contents