Equator ED 620 User's Manual
Contents
1. 5 Tumble Dryer Owner s Manual JEGUATOR HELPFUL HINTS This Dryer is a 110 Volt machine so the heating element requires more time to achieve full heat than a larger 220 volt unit requires The heating element will take about 10 minutes to reach full heat To dry your laundry the Dryer blows heated air into the rotating drum As the drum tumbles your laundry the warm air dries it If the drum is overfilled with laundry the air is not allowed to circulate and clothes will not dry properly DRYER EFFICIENCY Your dryer operates on 110 volts and the heating element is rated at 1200 watts it will take a longer time to dry clothes than a traditional dryer which operates on 220 volts 5 000 watts However with the following tips you can increase the efficiency of the dryer 1 FABRIC SOFTENER Prior to putting clothes into the this unit adding liquid fabric softener e g Downey to the wash load will help improve the drying efficiency by at least 30 2 OVERLOADING The drum has a capacity of 14 Ibs 1 90 cu ft With too many clothes airflow is reduced increasing drying time A maximum of 9 0 Ibs or 3 5 of the drum full of clothes is recommended for ideal drying SAFETY The model number of this product may be found on AN CAUTION AN the back of the unit the serial number of the label affixed to the back of the unit You should note the model and serial numbers of DONOTOPEN this unit in the space provided Ret2. points The dryer fails to start Is the plug correctly inserted into the socket Is there electricity in the house Is the door closed properly Is the power button pressed The dryer is not drying Is the plug correctly inserted into the power outlet Is the door properly closed Is the dryer knob in the correct position indicating minutes for drying The dryer is not drying efficiently Is the drum overloaded Is fabric softener being used 16 Tumble Dryer Owner s Manual JEGUATOR COMPANY INFORMATION www EquatorAppliances com SERVICE amp SUPPORT service equatorappliances com 800 935 1955 Equator Appliances 2801 W Sam Houston Pkwy N Suite 150 Houston Texas 77043 1611 Phone 713 464 3422 Fax 713 464 2151 All nights reserved Manual subject to change without notice 17 Tumble Dryer Owner s Manual
3. an automatic dryer with a capacity of up to DRYING 9 Lbs dry weight of clothes PRE INSTALLATION 1 The unit must be installed on a strong level floor and in protected dry and well ventilated area close to a power source 2 Installation on Carpet or Wood increases vibrations e Carpets place on light carpet only Wood brace floor with screws and place additional sheets of plywood before installation 3 This unit s installation and grounding should be done in accordance with local codes by a qualified installer Installation Instructions are included in this manual for the Installer s reference 4 The unit should be plugged into a properly grounded three 3 prong electrical outlet of 110 V 60Hz with minimum 15 amps It should not be controlled by a wall switch or pull cord which might be turned off accidentally 7 Tumble Dryer Owner s Manual j EOUATOR PICTURE OF THE DRYER Detergent dispenser Control Panel Dryer Knob Adjustable Feet 8 Tumble Dryer Owner s Manual j EQUATOR INSTALLATION UNPACKING LEVELING amp POSITIONING Remove the packing and check that the dryer is undamaged If you have any doubt do not use the dryer and call Customer Service Keep all packing parts plastic bag foam rubber screws etc out of the reach of children since they could be dangerous Important The inside of the Dryer consists of a free floating drum that is affixed with shi
4. can be mounted onto the Equator Combo Washer Dryer or the Equator Washer 3 Temperature Selection Choose your drying temperature for the quantity and quality of clothes you place in the dryer High and low heat settings are available for cottons mixed thread clothing and for delicates 4 Meeting Standards The dryer vent uses a standard 4 duct that fits dryer exhaust 5 Convenient Lint Control This unit does not use a lint filter and no cleaning is required after every load 6 110V operation The dryer power cord plugs into a standard 110V outlet available in most homes 7 Safety The dryer has a built in safety switch that reset when airflow is restricted This lets the dryer electronics remain unharmed by pausing the appliance till the conditions are corrected 8 Easy Operation Just set the dryer time based on type of clothing and press the Power button 9 Convenience This appliance can be permanently installed and be made portable with the installation of the portability kit sold separately where needed 4 Tumble Dryer Owner s Manual j EQUATOR IMPORTANT SAFETY INSTRUCTIONS Your safety and that of you children Your machine has been built in compliance with safety regulations to protect you and all your family WARNING To reduce the risk of fire electric shock or injury to persons when using your appliance follow basic precautions including the following Read all instructions before using t
5. Do not modify the plug provided with the appliance if it will not fit the outlet have a proper outlet installed by a qualified electrician Connecting the dryer vent hose R This Dryer vents the hot air out of the unit and reguires a vent hose to be installed To install the vent hose attach the vent hose 2 into the connector 1 Fig 3 c A flexible aluminum vent hose is recommended 10 Tumble Dryer Owner s Manual j EQUATOR RECESSED CLOSET AND ALCOVE INSTALLATION Instructions The machine may be installed in a recessed area closet or alcove The installation spacing is in inches and is the minimum acceptable Additional spacing should be considered for easy installation servicing and compliance with local codes and ordinances Closet installation must be exhausted Other installations must use the minimum dimension indicated Additional clearances for wall door and floor molding may be required Additional space is needed when an external exhaust elbow is used The closet s front door must be a shutter and the clearance between the slats must be more than 1 3 area the front door See Fig 4 NOTE If a door is installed that potentially encloses the unit while running the door must allow for a minimum of 20 square inches of free air movement There must also be a 1 space in front of the unit to the closed door and 1 from the back of the unit to the wall Additiona
6. FRONT LOADING 4 EQUATOR Dryer ED 620 Owner s Manual EQUATOR TABLE OF CONTENTS Warianty eera Kl EE EE l eo doc 2 3 PMU PIC TONY eier 4 Important Safety Instructions Jaccug ssivsaecesndesseceacacecestexgucedsdecsecdacogeeuesseees 5 Helpful Hints amp Dryer Efficiency en 6 Pre lnstallation e x 7 Picture of the Dryer See 8 installation e 9 11 eniin S 11 12 Operating uunc nie 13 HOW tO QFY od M 14 Maintenance dc 15 Technical D ta E P 15 Ele sje 16 Company Information suisse dod dd rd dok 17 Please read the Owner s Manual carefully before using your new Eguator Dryer 1 Tumble Dryer Owner s Manual j EQUATOR WARRANTY INFORMATION Your Equator Appliance is protected by this warranty under normal personal family or household use 5 Year Limited Warranty 1st year parts amp labor 2nd year parts 3rd 5th year main motor and limited commercial use 90 days in the USA and Canada WARRANTY Manufacturer undertakes to the consumer owner to repair or at our option to replace any part of this product which proves to be defective in workmanship or material under normal personal family or household use in the USA and Canada for a period of one year from the date of original
7. ain this booklet CAUTION TO REDUCE THE RISK op 2S a permanent record of your purchase to aid in ELECTRIC SHOCK DO NOT REMOVE identification in the event of theft COVER OR BACK NO USER SERVICABLE PARTS INSIDE REFER MODELY SERVICING TO QUALIFIED SERVICE PROFESSIONALS SERIAL 6 Tumble Dryer Owner s Manual EQUATOR INTRODUCTION Your new appliance is carefully engineered product Many times what appears to be a reason to call for service is a situation that may require nothing more than a simple adjustment you can easily make in your own home You will be charged for a service call while the appliance is in warranty if the problem is not caused by defective product workmanship or materials covered by this warranty To avoid a charge for an unnecessary service call and before calling a serviceman please refer to the troubleshooting section for situations that you can remedy This section is included on pages 15 of this Owner s Manual Your Dryer is front loading with an extra large door opening for easier access You will obviously want to obtain the best possible dry By reading and following the instructions in this booklet you will achieve excellent results Please ensure that the instructions are followed If you should need any further advice or assistance please contact the dealer where your machine was purchased or contact customer service at custserv appliancedesk com This appliance is
8. ances You can also register online or by calling Equator Appliances Customer Service at 1 866 218 6902 This warranty gives you specific legal rights and you may also have other rights which vary from State to State Corporate Office Equator Appliances 2801 W Sam Houston Pkwy N Suite 150 Houston TX 77043 1611 Phone 713 464 3422 Fax 832 464 2151 Toll Free 866 218 6902 EM tigre European Testing Laboratories US N 3094367 CANADA The ETL Listed Mark is the legal equivalent to the UL and CSA Listed Marks Equator CONTACTS Website www equatorappliances com Service 1 866 218 6903 service equatorappliances com Parts amp Accessories parts equatorappliances com Technical Support techsupport equatorappliances com 3 Tumble Dryer Owner s Manual EQUATOR INTRODUCTION Congratulations on your new Equator Vented Tumble Dryer In addition to its unique design this is a highly sophisticated product that will give you many years of satisfaction Please take the time to read this Owner s Manual in order to understand the machine and get the best use out of your valuable purchase Here are some of the best reasons for buying your Equator Dryer 1 Energy Savings This appliance is engineered to provide valuable energy savings when compared to other dryers 2 Space Savings The Dryer is designed to utilize horizontal and vertical space effectively By using the stacking kit available separately this unit
9. ble A to the side and follow the instructions provided for drying cycle Follow the instructions see page13 the section Starting the Dryer Set the dryer time on Dryer knob Press the Power button Table A The best dry time also depends on the amount of laundry to be dried Selecting the correct drying time Use the following table as a guide p Max load Drying Knob Drying Time Fabrig Load Ibs Sector minutes Laundry of Cottons different sizes 9 High Heat 120 Cottons Only eny 9 High Heat 120 towels Mixed fabric Cotton Sheets or shirts 8 Less Heat 80 90 polyester Acrylics dps SOUS 8 Less Heat 60 70 Petticoats Nylon Stockings etc 7 Less Heat 40 50 Load the clothes no more than 9 Ibs for cottons see table for other fabrics make sure that The door is shut correctly Power button has not been pressed Set dryer time on the Dryer knob Press Power button to start When Drying is Complete Turn the dryer off by pressing the Power button Now you can open the appliance door Once you have removed the dry clothes from the appliance leave the door open or ajar to avoid the formation of bad odors USEFUL TIPS Denim Alert Some overalls have straps with hooks that can damage the drum of your machine or other garments during the dry To minimize the risk place hooks in the pocket and fasten with safety pins Vacations unplug the appliance It is recommended tha
10. defining factor is has the machine malfunctioned manufacturer is responsible or has the customer omitted or done something to cause machine to malfunction customer is responsible Some States do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you REMOTE LOCATIONS In case the area of service is in a remote location Equator Appliances may have to request for the appliance to be taken to the nearest authorized service agent we can find in order to provide service 2 Tumble Dryer Owner s Manual j EQUATOR WARRANTY SERVICE This warranty is given by Equator Appliances 2801 W Sam Houston Pkwy N Suite 150 Houston TX 77043 1611 Service under this warranty must be obtained by the following steps in order Call a Equator Appliances Authorized Service Agent obtain number of nearest agent from your dealer or by calling Equator Service at 1 800 678 8002 Under normal circumstances Service will be provided during regular business hours 9 00 a m to 5 00 p m weekdays GENERAL Since it is responsibility of the consumer owner to establish the warranty period by verifying the original purchase date Equator Appliances recommends that a receipt delivery slip or some other appropriate payment record be kept for that purpose Remember to send in your Warranty Registration Card so that a proof of your purchase exists with Equator Appli
11. he appliance Do not dry articles that have been previously cleaned in washed in or spotted with gasoline dry cleaning solvents other flammable or explosive substances as they emit vapors that could ignite or explode Do not allow children to play on or in the appliance Close supervision of children is necessary when the appliance is used near children Before the appliance is removed from service or discarded remove the door Do not reach into the appliance if the tub or drum is moving Use caution as drum interior becomes hot after use Do not install or store this appliance where it will be exposed to the weather Do not tamper with controls Do not repair or replace any part of the appliance or attempt any servicing unless specifically recommended in the user maintenance instructions or in published user repair instructions that you understand and have skills to carry out Do not use fabric softeners or products to reduce static unless recommended by the Equator appliance of the fabric softener product Do not use heat to dry articles containing foam rubber or similarly textured rubber like materials For vented dryers keep the exhaust opening and surrounding areas free from accumulation of lint dust and dirt Do not place items exposed to cooking oils in your dryer Item contaminated with cooking oils may contribute to a chemical reaction that could cause a load to catch fire SAVE THESE INSTRUCTIONS
12. l spacing should be considered for easy installation servicing and compliance with applicable local state and federal codes y rk Fig 4 11 Tumble Dryer Owner s Manual j EQUATOR CONTROL PANEL A Dryer knob D Heat Button B Power button E Power Indicator Light C Run B C D E A A Dryer Knob Turn dryer knob to set minutes for drying B Power Button Pressed in for ON Not pressed for OFF C Run Button Press this button to run the dryer D V2 Heat Button Press this button to produce less heat E Power Indicator Light This indicates power to the dryer 12 Tumble Dryer Owner s Manual j EQUATOR Warning to reduce the risk of fire electric shock or injury to person read the IMPORTANT SAFETY INSTRUCTIONS before operating this appliance OPERATING INSTRUCTIONS Make sure Dryer is turned off Indicator light should be off Separate clothes into cottons permanent press Load clothes of the selected type loosely into the drum Do not load clothes more than 3 5 full Close the Dryer door You will hear a click when it is correctly closed 5 Turn the Dryer knob to the desired amount of minutes for drying High Heat for Cottons and Less Heat for Perma Press clothing 6 Review these steps and check all the settings on the c
13. ontrol panel before starting the machine 7 Press the Power button The indicator light will come on and in a few seconds you will hear the cycle begin 8 When the Dryer has completed the cycle the machine will stop automatically although the indicator light will remain on until you manually press out the Power button Note You can open the door any time during the Dry cycle without waiting Be aware if heat builds up STARTING THE DRYER Starting your dryer in the right way is important for the quality of your dry to help prevent future problems and enhance life expectancy of your appliance Once you have loaded your dryer always check that 1 The door is closed correctly 2 The plug is secured in the socket Choose the desired program The program is selected according to the type of garments that need to be dried To choose a dryer time refer to the table on page 13 then 1 Turn Dryer knob to the desired position 2 If necessary use heat button 3 Press the Power button At the end of the dry cycle Turn the dryer off by pressing Power button You can now open the dryer door safely After having removed the dried laundry leave the door open to allow air circulation inside the drum Remember that in the event of a power failure or should the dryer switch itself off the program chosen will remain in memory 13 Tumble Dryer Owner s Manual EQUATOR DRYER HEAT HOW TO DRY Dryer e Look at ta
14. pping bolts at the back of the cabinet Fig 1 during transport Before starting the machine remember to remove the shipping bolts Close the holes left open by the bolts with the plastic caps provided It is important for the machine to be perfectly level For this reason the machine is fitted with adjustable feet used for leveling the machine before use Fig 2 Fig 1 Fig 2 9 Tumble Dryer Owner s Manual j EQUATOR ELECTRICAL CONNECTION Connect the plug to a power outlet 110V 60Hz with minimum 15 Amps Make sure that the voltage and frequency available corresponds with those stated on the serial number plate located on the back of the machine Do not use adaptors or extension cords since they could result in overheating and burn out GROUNDING This appliance must be grounded In the event of malfunction or breakdown grounding will reduce the risk of electric shock by providing a path of least resistance for electric current This appliance is equipped with a power cord having an equipment grounding conductor and a grounding plug The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances WARNINGS Improper connection of the equipment grounding conductor can result in a risk of electric shock Check with a qualified electrician or service representative if you are in doubt as to whether the appliance is properly grounded
15. purchase For commercial use the product is warranted for a period of 90 days During this period we will provide all labor and parts necessary to correct such defect free of charge if the appliance has been installed and operated in accordance with Equator Appliances written instructions with the appliance Ready access to the appliance for service is the responsibility of the consumer owner Equator Appliances will not be responsible for the installation and uninstallation of the unit EXCLUSIONS In no event shall Equator Appliances be liable for incidental or consequential damages or for damages resulting from external causes such as abuse misuse incorrect voltage or acts God This warranty does not cover service calls which do not involve defective workmanship or materials covered by this warranty or incorrect installation procedures Accordingly diagnosis and repair costs for a service call which does not involve defective workmanship or materials will be the responsibility of the consumer owner Specifically the following work is not covered under warranty and does not constitute warranty work Installation e g improper hook up or leveling or non removal of shipping bolts Maintenance e g cleaning of air and or water filter Damage e g replacing broken door handle damage to cabinet or external parts RV s Boats e g excessive movement caused by travel or movement of vehicle Most work is covered The
16. t you should unplug the machine from the socket Leave the door ajar to allow air to circulate through the door gasket area This will prevent unpleasant odors 14 Tumble Dryer Owner s Manual EQUATOR UNDERSTANDING FABRIC CARE LABELS The symbols on labels of your garments will help you in choosing the suitable wash program the right temperature wash cycles and ironing methods Don t forget to give a glance to these useful indications R Machine Wash PX Z Cyclo en M A T X ET Water Temp A 4 Hot War OH vo 50 C 120 F 40 C 105 F 30 C 85 F Tumble Dry Special Instructions QS y Select the fight temperature Bleach A Symbols Look MAINTENANCE Your Dryer is designed to operate without complicated maintenance Follow these simple maintenance procedures for good results 1 Ensure that your machine was installed according to the correct installation procedures detailed in this Manual 2 Do not use solvents to clean the machine TECHNICAL DATA Model ED 620 Rated Volt 110 120V 60Hz Drying input power 1560 W Drying capacity 9 lbs Outside dimensions WXHXD 33 5 x 23 5 x 21 6 inches Weight 140 Ibs 15 Tumble Dryer Owner s Manual EQUATOR TROUBLESHOOTING In most cases when your dryer fails to work the problems arising can be easily solved without having to call for a technician Before calling for assistance always check these
Download Pdf Manuals
Related Search