DEFY Solid Plate Plug In Stove 501 User's Manual
Contents
1. p o Safety regulations stipulate that the ANTI TILT mechanism supplied with the stove must be fitted as shown in methods 1 or method 2 depending on the mechanism supplied with your particular model The Anti tilt bracket kit assembly comprises of 2 x Anti tilt brackets stove 2 x Anti tilt brackets wall 6 x Securing bolts 4 short and 2 long 4x Hilti fasteners Jawe e A is to be fitted at the rear of the stove on the left and right hand side using 2 securing bolts C in the threaded holes provided 2 short bolts per side e Bis fitted to A by the securing bolt C 1 long bolt per side e Slightly loosen the securing bolt C to allow B to slide freely over A e Position the stove and slide B to touch the wall behind the stove e Mark the two holes in B where they touch the wall behind the stove e Remove the stove and unfasten the bracket B e Using a 6 0 mm concrete bit drill two holes at the marked positions e Using the Hilti fasteners D firmly secure B to the wall e Slide the stove back in position and carefully engage the brackets so that B slides over A e Securely fasten the two brackets by tightening bolt C 1 long bolt per side e The stove is then secured and will not accidentally tilt if downward pressure is applied to the open oven door PAGE 3 OF 12 DEFY Anti tilt mechanism Method 1 Anti tilt installation side view Of UU ee Anti tilt installation top view i O2. immediately cover the pot or pan with a lid Switch off the hob if safe to do so and phone the fire service PAGE 6 OF 12 DEFY The Control Panel 501 Model Only INDICATOR LIGHTS FOR OVEN AND PLATES OVEN SELECTOR THERMOSTAT PLATES Electrical Installation Position the stove on a solid level surface near an accessible plug point e The stove is a plug in model with a 15Amp Power supply e Push the electric plug into a 230V 15A earthed wall socket Selector Knob e Itis not possible to use all the elements at the same time e Set the selector to the required position e Do not set the knob to the unmarked position ce 3 Plates we Bake and 2 small plates hal Pi Grill and 2 small plates 15A CONT ROL PANEL PLUG lt PLATES STORAGE COMPARTMENT PAGE 7 OF 12 Baking 501 Model Only For best baking results use an aluminium bake tray 300 x 230 x 30mm These are available from all Defy Parts Centres Part number 067609 Teflon coated baking trays are not recommended e Set the selector to Bake and 2 small plates e Set the oven control to the desired temperature e The indicator light will glow and remain on until the oven has reached the selected temperature e When the indicator light switches off the food should be placed in the oven e During baking the indicator light will regularly cycle on and off as the oven thermostat maintains the selected tempe
3. UJ Wall Assembly The manufacturer strives for continuous improvement For this reason technical specifications text and illustrations in this manual are subject to change without notice Figures in this manual are schematic and may not match your appliance exactly Safety regulations stipulate that the ANTI TILT mechanism supplied with the stove must be fitted as shown in methods 1 or method 2 Depending your particular model either the mechanism outlined in methods 1 or 2 will be supplied with your model PAGE 4 OF 12 DEFY Anti Tilt mechanism Method 2 e A 1x Stability chain e B 1x Stability hook with anchor sleeve e A is factory fitted at the rear of the stove in the centre e Position the stove and move A to touch the wall behind the stove e Mark the hole where A touches the wall behind the stove e Move the stove away from the wall to allow for an area to work in e Using a 8 0 mm concrete bit drill a hole at the marked position e Using the Stability hook and anchor sleeve B firmly secure B to the wall e Slide the stove back in position and engage the stability chain A onto the Stability hook B e The stove is then secured and will not accidentally tilt if downward pressure is applied to the open oven door Anti tilt installation side view Anti tilt installation top view Stability hook B Stability chain to be as short as possible to prevent ov
4. the appliance if it 1s defective or has any visible damage Do not carry out any repairs or modifications on the appliance Never wash down the appliance with water There is the risk of electric shock Never use the appliance when your judgment or coordination is impaired by the use of alcohol and or drugs The appliance must be disconnected from the mains during installation maintenance cleaning and repair procedures Be careful when using alcoholic drinks in your dishes Alcohol evaporates at high temperatures and may cause a fire since it can ignite when it comes into contact with hot surfaces Do not heat closed tins and glass jars in the oven The pressure that would build up in the tin jar may cause it to burst PAGE 10 OF 12 Do not place baking trays dishes or aluminium foil directly onto the bottom of the oven The heat accumulation might damage the bottom of the oven Keep all ventilation slots obstructions The appliance may be hot when it is in use Never touch the hot burners inner sections of the oven heaters etc Always use heat resistant oven gloves when putting in or removing dishes from the hot oven Do not use the appliance with the front door glass removed or cracked The rear surface of the oven gets hot when it is in use Make sure that the gas electrical connection does not come into contact with the rear surface as connections may get damaged Do not trap the mains cable between the oven doo
5. Nelson Mandela Drive Superbia 0699 Tel 0152 92 1166 7 8 9 Polokwane Service defy co za JOHANNESBURG Commercial Head Office Administration Distribution National Groups Tel Sales Contracts and Credit Cnr Mimetes amp Kruger Sts Denver ext 12 Johannesburg 2094 Tel 011 621 0200 or 011 621 0300 Gauteng Service defy co za PORT ELIZABETH 112 Patterson Road North End Port Elizabeth 6001 Tel 041 401 6400 PortElizabeth Service defy co za PRETORIA Block A1 Old Mutual Industrial Park Cnr D F Malan Drive amp Moot Str Hermanstad 0082 Tel 012 377 8300 Pretoria Service defy co za OTHER AREAS ARE SERVICED BY OVER 200 AUTHORISED AGENTS FOR FURTHER DETAILS PLEASE CONSULT THE NEAREST REGIONAL DEFY TECHNICAL SUPPORT CENTRE If you have followed the instructions and still have a problem contact the nearest Defy Service Centre They will be able to advise you on any aspect of the product or send a qualified technician to repair it The Manufacturer strives for continuous improvements For this reason the information in this book is subject to change without notice For future reference record the listed information in the space below The Serial number label may be found at the upper back panel SERIAL NO sceteicitetiscastarereesiotiders DATE OF PURCHASE 4 PURCHASED FROM 0 005 PAGE 11 OF 12 Warranty This certificate is issued by DEFY APPLIANCES PTY LIMITED m
6. OWNER S DEFY MANUAL You can rely on Defy To simplify MODEL 501 MODEL 520 MODEL 521 SOLID PLATE SPIRAL PLATE SOLID PLATE PLUG IN STOVE STOVE STOVE Available in Available in Available in White only White amp Black White amp Black PART NUMBER 068 517 www defy co za Introduction Congratulations on the purchase of this quality appliance We trust that you will enjoy many years of trouble free use Please read these instructions carefully before using the appliance This manual will provide you with information on how to operate and care for your appliance in order that you gain the maximum benefit from it Unpacking e Please ensure that packaging material is disposed of in a responsible manner e Plastic bags should be cut up to prevent children playing with them and accidentally suffocating e Remove all packing from the oven cavity and position the accessories e If the appliance is damaged in any way do not use it Report the damage to your dealer who will take the necessary corrective action Installation e Surfaces immediately adjacent to the oven should be able to withstand temperatures of up to 100 C without delaminating or discolouring Owner s responsibility Since the following are not factory faults they are the owner s responsibility e Damage to exterior finish e Breakage of glass and components e Damage through improper use or installation of the appliance e D
7. al position for e Gentle simmer to simmer e Fast simmer to medium heat e Hot to maximum heat Note To switch plate ON rotate the dial knob in a clockwise direction to the required setting To switch plate OFF rotate the dial knob in a counter clockwise direction to the 0 position Cleaning spiral plates e Switch off the electrical supply to the stove e When the plates are cold lift the hinged plate up remove the supports and trims e Slide the under cup out from under the Use hot soapy water to clean the plates supports trims and under cups If necessary use a nylon bristle brush to remove stubborn dirt Wipe dry and re fit the plates supports trims and under cups Solid plates Before using the plates for the first time switch them on for four minutes at the highest setting so that the factory applied protective coating can burn in The markings around the plate control knobs represent the following heat settings 1 Warming 2 Slow simmer 3 Simmer 4 Medium heat 5 High heat 6 Boiling and frying Caring for solid plates To prevent discolouration and corrosion moisture from spatters and spills should be cleaned off immediately To clean the plates wipe them with a damp cloth or nylon pad A little liquid detergent may be used Do not use metal scourers or sharp metal objects After cleaning dry the plates by switching them on for a short while To prev
8. amage caused by moving the appliance other PAGE 2 OF 12 Electrical installation This appliance must be earthed and the manufacturer and the seller do not accept responsibility for any damage due to incorrect installation or electrical connection This appliance should not be connected through an earth leakage system Refer to S A N S 10142 Connection to the power supply This appliance has a Y type supply cord connection and must be installed by a licensed electrician who will ensure that the stove is correctly connected and safely earthed The rated current is printed on the serial number label attached to the stove upper back panel The appliance must be connected to the mains through an all pole isolating switch which has a minimum clearance between the contacts of 3 mm in all poles A means for disconnection must be provided in the fixed wiring Push the electric plug into a 230V 15A earthed wall socket The stove is a plug in model with a 15A power supply It is therefore not possible to use all the elements at the same time Set the selector to the required position Do not set the knob to the unmarked position DANGER Prior to installation visually check if the appliance has any defects on it If so do not have it installed Damaged appliances are a Safety risk Anti tilt mechanism Method 1 All stoves can tilt if you or a child sit or lean on an open oven door JN warnine
9. anufacturers of Defy and Ocean products hereinafter the Company to the original purchaser only of the appliance described on the certificate and shall constitute the only warranty given in respect of this appliance The Company warrants to the original purchaser that for a period of TWO YEARS from date of purchase the appliance is free from defect under normal domestic use both in workmanship and material subject to the following conditions 1 Repair or replacement of any part of this appliance found by the Company to be defective shall be at the election of the Company The Company reserves the right to effect such service through any of its Service Divisions or Authorised Service Dealers The cost of such service shall be borne by the Company in full provided that the appliance is located no further than 50 km from a Company Service Centre or an Authorised Service Dealer Where the appliance 1s located beyond the 50 km radius the purchaser shall be liable for the standard travelling charges as determined by the Company CARRY IN SERVICE Microwave ovens Compact cookers and small appliances are repaired in our service centres and are not collected from the customers home Faulty units should be delivered to the purchasing dealer or to the nearest Company Service Centre for warranty repairs 2 Rusted or corroded plates vitreous enamelware fuses and lamps are specifically excluded from these warranties It is an express condition of thes
10. e warranties that the purchaser takes due care and attention in the use and maintenance of the appliance Abuse misuse in conflict with operating instructions connection to incorrect voltages and subjection to commercial use shall release the Company from its obligations 3 This warranty shall become void and cease to operate if the appliance is dismantled by or any repairs to the appliance are effected by any persons not duly authorised by the Company or if substitute parts not approved by the Company are used in the appliance or if the serial number of the appliance is removed 4 The Company shall not be responsible for damages resulting from fire flood civil disturbances or any Act of God The Company shall not in terms of these warranties be responsible nor held liable for any consequential loss or damage of any kind caused by or due to the failure or malfunction of the appliance 5 The Company shall not be responsible for transportation or other costs other than those incurred within the provisions of Point of this Certificate 6 These warranties shall not apply to the appliance if it is purchased or used beyond the borders of the Republic of South Africa Namibia Botswana Swaziland and Lesotho 7 Where service 1s requested under warranty and no fault or defect can be found by the Company all costs incurred will be for the purchaser s account 8 This Certificate as well as your invoice will serve as proof of purchase For
11. en from tilting in any direction PAGE 5 OF 12 DEFY Oven door Only applies to models with removable oven door The oven door may be removed to improve access to the oven for cleaning purposes 1 Open the door fully to expose the hinges A on either side 2 Flip the hinge locking levers B to the upright position 3 Partially close the oven door and lift it free of the side panel retaining slots 4 After cleaning re fit the oven door in reverse order making sure that the bottom hinge notches locate properly onto the bottom edges of the side panel retaining slots SIDE OF DOOR SIDE OF DOOR 1 2 WARNING Under no circumstances should the bake element be covered with aluminium foil Nor should a pan or tray be positioned directly above the bake element Doing so would reflect the heat from the bake element downwards Heat to the oven would be restricted and overheating of the space below the element would result in damage to the oven enamel Figures in this manual are schematic and may not match your appliance exactly DANGER Risk of scalding by hot steam Take care when opening the oven door as steam may escape WARNING Hot surfaces may cause burns Do not touch the hot surfaces of the appliance Use oven gloves Keep children away from the appliance DANGER Risk of fire by overheated oil When heating oil do not leave it unattended Never try to extinguish a fire with water When oil has caught fire
12. ent rust periodically apply some sewing machine oil or electrical hotplate polish available from Defy Service Centres Extra attention is required in areas of high humidity or in close proximity to the sea HEO ea aL x be Note The warranty does not cover the replacement or repair of rusted or corroded solid plates It is the owners responsibility to care for them as described above PAGE 9 OF 12 e Some plates are fitted with stainless steel trim rings Over time and when exposed to heat these may discolour e Regular use of a cleaner labelled Suitable for Stainless Steel will restore the original sparkle Recommendations e Use only pots with a solid level base An uneven base can prolong cooking times and waste energy e Use pots with a base diameter slightly larger than the plate This will ensure even heat distribution and prevent spillage from dripping onto and staining the hot plate e Always cover the pot with a lid This will conserve energy and minimise spillage e Thermal shock could damage the plates Do not put cold pots on very hot plates Cleaning Do not use a steam cleaner Cleaning the Exterior e Switch off the electrical supply to the stove before cleaning any part of it e Use a damp soapy cloth and avoid the use of abrasive powders and scouring pads Cleaning the Oven e Switch off the electrical supply to the stove before cleaning any part of it e Use a hot soapy dam
13. lling Grilling Keep the oven door closed during grilling Set the selector to grill and the oven thermostat to the grill position Place the oven shelf on the top shelf position Place the item to be grilled in a roast pan on the shelf under the pre heated grill element PAGE 8 OF 12 e The oven door may be opened to check on the grilling process every 5 to 10 minutes to avoid burning the food e The oven control must be turned to the OFF position when grilling is complete Baking For best baking results use an aluminium bake tray 300x230x30mm These are available from all Defy Parts Centres Part number 067609 Teflon coated baking trays are not recommended e Set the selector to pre heat and set the oven thermostat to the desired temperature e The indicator light will glow and remain on until the oven has reached the selected temperature e When the indicator light switches off the food should be placed in the oven e Set the selector to bake e During baking the indicator light will regularly cycle on and off as the oven thermostat maintains the selected temperature e The door may be opened for inspection purposes after about half the cooking time has elapsed Storage Compartment e This compartment may be used to store pots pans and dishes Spiral Plates e The plate will operate at any setting between minimum and maximum as depicted on the control knob With experience you will soon find the ide
14. p cloth to clean any part of the oven Stubborn stains may require the use of a nylon scrubbing brush and a liquid cleaner Do not use metal scouring pads or abrasive cleaners Element and guard e After cleaning the oven ensure that the oven element is securely clipped into the hook of the element guard Failure to observe this will allow the element to rest on and damage the oven enamel ELEMENT GUARD ELEMENT Safety advice This section contains safety instructions that will help you avoid risk of injury and damage All warranties will become void if you do not follow these instructions General safety This appliance is not intended for use by persons including children with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety Children should be supervised to ensure that they do not play with the appliance Connect the appliance to an earthed outlet line protected by a fuse of suitable capacity Have the earth installation made by a qualified electrician Our company shall not be liable for any problems arising due to the appliance not being earthed in accordance with the local regulations If the supply cord is damaged it must be replaced by the manufacturer its service agent or similar qualified persons in order to avoid a hazard Do not operate
15. r and frame and do not route it over hot surfaces as the cable insulation may melt and cause a fire as a result of a short circuit Make sure that the function knobs are switched off after every use When using Gas ensure that the room is well ventilated Always keep children and infirm persons away from the appliance when it 1s in use Only use the appliance for preparing food Use a deep pan large enough to cover the appropriate burner Always dry food thoroughly before placing it in hot oil or fat Frozen food in particular will spit and splatter if added too quickly Never fill the pan more than one third full of fat or oil Never heat fat or fry with a lid on the pan Do not fry too much food at once This lowers the temperature of the oil or fat and results in fatty foods Do not leave hot fat or oil unattended If overheating occurs these could catch fire Do not store flammable items in the oven Always keep the oven door gasket clean clear of Defy Service Centres BLOEMFONTEIN 160 Long Street Hilton Bloemfontein 9301 Tel 051 400 3900 Bloemfontein Service defy co za CAPE TOWN 5A Marconi Rd Montague Gardens 7441 Tel 021 526 3000 Cape Town Service defy co za DURBAN 35 Intersite Avenue Umgeni Business Park Durban 4051 Tel 031 268 3300 Durban Service defy co za EAST LONDON 16 Bowls Rd Arcadia East London 52071 Tel 043 743 7100 EastLondon Service defy co za POLOKWANE 8
16. rature e The door may be opened for inspection purposes after about half the cooking time has elapsed Grilling 501 Model Only Keep the oven door closed during grilling e Place the oven shelf on the top shelf position e Set the selector to Grill and 2 small plates e Set the oven control to the Grill symbol on the knob Place the item to be grilled in a roast pan on the shelf under the pre heated grill element e The oven door may be opened to check on the grilling process which should be done every 5 to 10 minutes to avoid burning the food e The oven control must be turned to the OFF position when grilling is complete The Control Panel 520 Model only OVEN INDICATOR LIGHT OOOO OC OVEN SELECTOR PLATES THERMOSTAT The Control Panel THERMOSTAT 521 Model only OVEN INDICATOR LIGHT PLATE INDICATOR LIGHTS OVEN SELECTOR PLATES Four Position Selector The selector is used to select one of four oven operating modes OFF POSITION 0 Nx 1 Oor OFF 4 ir 2 Bake Z J J 3 Pre Heat so ZF 4 Grill PSH BB BAKE 1s used for baking and roasting PRE HEAT utilises all the oven elements to quickly bring the oven up to the selected temperature The oven indicator light will remain on until the selected temperature is reached Thereafter the selector must be set to BAKE You may use the oven without PRE HEAT it just takes a little longer to warm up GRILL is used for conventional gri
17. the purpose of watranty it will be essential to produce this Certificate and invoice Failure to do so will render the purchaser liable for service costs KEEP THIS CERTIFICATE AND SALES INVOICE AS PROOF OF PURCHASE FOR WARRANTY PURPOSES PAGE 12 OF 12 DEFY
Download Pdf Manuals
Related Search