Dacor Ventilation Hood 85516 Rev. B User's Manual
Contents
1. 222 Securing the Electronic 2 CARE AND 2 3 Top Cap Cleaning 2 Filter 2 Intake Panel 2 Electronic Keypad 3 PROBLEM 0 4 Troubleshooting 4 Product Maintenance 4 If You Need Service 4 PRODUCT 4 What Is Covered 4 What Is Not 4 Purpose of This Manual This Use amp Care Manual is designed to enable you to properly operate and maintain your new appliance Please keep this manual handy for easy access and quick reference Additional information may be requested by e mailing writing or phoning the DACOR Customer Service Department The address and phone number of this department are listed on the inside front cover of this manual Product Registration becomes necessary Model No Date Purchased Purchased From Address What to Do Begin by ensuring proper installation and grou2. Unnecessary service calls may be expensive frustrating and time consuming Before you call for service please review the potential problems possible causes and remedies shown in the table below Problem 1 Nothing works Vent intake raises or lowers partially then stops Gas flame is being pulled by draw of vent Clean filter symbol is illuminated Only in RV Models Possible Vent power seupply interrupted or not energized Fuse in Raised Vent Junction box is blown Electronic keypad controls are deactivated Only in RV Models An obstruction is interfering with the vent intake movement Short duct run or high output of system make ventilating force very strong Blower has operated for 40 hours Troubleshooting Guide Product Maintenance What Is Covered No maintenance other than the CARE AND CLEANING INSTRUCTIONS identified in this Use amp Care Manual should be attempted by the owner operator All other maintenance and service must be performed by a qualified appliance technician If You Need Service First review the recommended checks listed in the preceding Troubleshooting Guide Then be certain that the appliance has been installed properly and is being operated correctly Familiarize yourself with the warranty terms and conditions listed in the PRODUCT WARRANTY section If the above checks have been completed and the problem has not
3. the flame or use an appropriate class dry chemical or foam type fire extinguisher Never leave the appliance unattended when using high heat settings Boil overs and greasy spills may smoke and or ignite Do not leave children alone or unattended in the area where the cooktop and vent are in use Never allow children to sit or stand on an appliance Do not let children play with the cooktop or vent CAUTION Do not store items of interest to children above or at the back of the cooktop and vent as they could climb on the appliances to reach items and be injured Serial No Date Installed 6 Do not repair or replace any part of the raised vent system unless specifically recommended in literature accompanying this appliance All service should be referred to a qualified technician 7 Do not set or rest any objects on top of the vent top cap Do not interfere with the movement of the vent intake in any way Getting Started Ny WARNING If the vent intake becomes jammed while being raised or lowered immediately press the Up Down switch once to stop the intake motion then disconnect the power supply Remove the obstruction then restore power and pres the Up Down switch to continue raising or lowering the intake NOTE The direction of travel of the vent intake cannot bo reversed while it is moving The intake must complete a full up or down cycle before changing directions ERV PRV Downdraft Ve
4. YEAR WARRANTY If your DACOR product fails to function within one year of the original date of purchase due to a defect in material or workmanship DACOR will furnish a new part F O B factory to replace the defective part All delivery installation and labor costs are the responsibility of the purchaser The owner must provide proof of purchase upon request and have the appliance accessible for service What Is Not Covered Service calls to educate the customer in the proper use and care of the product Failure of the product when used for commercial business rental or any application other than for residential consumer use Replacement of house fuses or fuse boxes or resetting of circuit breakers Cause Remedy Have electrician check power supply including house circuit breaker and fuses Have electrician or qualified appliance service technician replace fuse Reactivate the controls by pressing the High and Low keys simultaneously and holding for one 1 second Immediately press Up Down key the turn off power to vent and remove the obstruction Restore power to vent and press Up Down key to raise or lower intake Reduce blower speed to a lower setting Inspect and clean filters then press the Clean Filter key to turn off light Damage to the product caused by accident fire flood or other acts of God Breakage discoloration or damage to glass metal surfaces plast
5. product Yes Comments Oo Dishwasher D Refrigerator m No F G H l J Builder Architect Designer Another Dacor Owner Model Home Other Builder Other New Home Other 150 000 200 000 200 000 250 000 Over 250 000 Thank you very much for your assistance The information you have provided will be extremely valuable in helping us plan for the future and giving you the support you deserve Web Site www dacor com For a Dealer Service 800 772 7778 Corporate Phone 800 793 0093 Place Serial Number Label Here cut here cut here
6. the draft is strongest closest to the vent intake WARNING 1 Do not operate the vent system without the grill and filters in place or with dirty grease laden filters Do not raise or lower the vent without first verifying that pot handles or other objects will not interfere with the moving vent intake Do not set hot cookware utensils or any other objects on the vent top cap Do not leave the vent intake in the down position when using the cooktop Using Delay Off Filter Cleaning RV Model Only When the cooking process is complete the user may select the Delay Off feature to remove any residual exhaust by pressing and releasing the designated key After choosing this function the blower will continue to run at the selected fan speed for five 5 minutes then automatically turn off The vent intake will remain in the fully raised position after the blower shuts off The intake may be lowered by pressing and releasing the Up Down key at your convenience While the blower is operating in Delay Off mode the blower speed may be adjusted to set the desired blower speed and corresponding noise level Simply press and release the High Medium or Low key at your discretion To manually cancel the Delay Off function at any time press and release the Off key or the Up Down pushbutton This will shut off the blower and in the case of pressing the Up Down button also cause the vent intake to
7. yet been remedied call your local authorized DACOR service representative Your dealer can normally provide the name and telephone number of the nearest service company DACOR works diligently to ensure your satisfaction when service is necessary However if you are not completely satisfied with the service provided contact the company that performed the service and express why you are not pleased Normally they will be willing and able to resolve the problem If the service agency is not able to respond effectively call or write the DACOR Customer Service Department The phone number and address of this department are listed on the inside front cover of this manual Please include your telephone number if you choose to write We will then do our utmost to assure your happiness and satisfaction CERTIFICATE OF WARRANTIES DACOR APPLIANCE WITHIN THE FIFTY STATES OF THE U S A THE DISTRICT OF COLUMBIA AND FULL ONE YEAR WARRANTY If your DACOR product fails to function within one year of the original date of purchase due to a defect in material or workmanship DACOR will remedy the defect without charge to you or subsequent users The owner must provide proof of purchase upon request and have the appliance accessible for service Warranty is null and void if non CSA approved product is transported from the U S OUTSIDE THE FIFTY STATES OF THE U S A THE DISTRICT OF COLUMBIA AND CANADA LIMITED FIRST
8. ARRANTY INFORMATION Your warranty for this product CANNOT BE ACTIVATED until this form has been returned to Dacor If you have purchased more than one Dacor product Please return all forms in one envelope Please rest assured that under no conditions will Dacor sell your name or any of the information on this form for mailing list purposes We are very grateful that you have chosen Dacor products for your home and do not consider the sale of such information to be a proper way of expressing our gratitude Please Print or Type Owner s Name Last First Middle Street City State Zip Purchase Date Email Telephone Dealer City State Zip Your willingness to take a few seconds to fill in the section below will be sincerely appreciated Thank you 1 How were you first exposed to Dacor products Please check one only Cooking Show Magazine Appliance Dealer Showroom Kitchen Dealer Showroom Home Show 2 Where did you buy your Dacor appliances A Appliance Dealer Kitchen Dealer Builder Supplier 3 For what purpose was the product purchased Replacement only Part ofa Remodeled 4 What is your household income A Under 75 000 B 75 000 100 000 100 000 150 000 5 For what purpose was the product purchased A Cooktop B Oven 6 Would you buy or recommend another Dacor
9. Use amp Care Downdraft Vent Family Owned American Made SAFETY IS EVERYONE S RESPONSIBILITY ALL DACOR APPLIANCES ARE DESIGNED IMPORTANT INFORMATION AND CONSTRUCTED TO GIVE YOU MANY YEARS OF SAFE OPERATION THE e Operating Instructions OPERATION WILL BE FURTHER ENHANCED IF PROPER CARE AND JUDGEMENT ARE Care and Cleaning Instructions EXERCISED IN THE USE AND MAINTENANCE OF THIS APPLIANCE Safety Tips WARNINGS Y Must be followed carefully to avoid personal injury or damage lia ance NOTES ul Contains helpful hints and tips Using Yo ba ee Se eS ee ee ee Se eS Part No 85516 Rev B Ser dacor Family Owned American x American Made Dear DACOR Consumer Congratulations You have purchased the very latest in kitchen appliances Your new DACOR product offers features styling and performance not found in any other appliance your new appliance itis imperative that you read the IMPORTANT ntrols and procedures to understand the full potential of this Please read this manual before operating INSTRUCTIONS section and become familiar with the product 5 are designed and manufactured to meet the highest quality standards Each unit is thoroughly All DACOR appliance tested Should yOu have a problem however please first check the PROBLEM SOLVING section in this manual This of possible problems and soluti
10. els accumulate grease over time and should be cleaned whenever the filters are washed After removing the grill and filters wipe all external and internal aluminum surfaces with a sponge or cloth moistened with a mild detergent Rinse off with water then remove all moisture by wiping with a soft dry polishing cloth Always wipe in the direction of the grain RV Model Only The anodized aluminum intake panels accumulate grease over time and should be cleaned whenever the filters are washed After removing the grill and filters wipe all external and internal aluminum surfaces with a sponge or cloth moistened with a mild detergent Rinse off with water then remove all moisture by wiping with a soft dry polishing cloth Always wipe in the direction of the grain Do not use any abrasive substances on the intake panels as this may permanently mar the finish NOTE Restore the electronic controls to operating status after cleaning the grill filters and intake panels Refer to the preceding section Securing the Electronic Keypad Dry and reinstall all components prior to operating the vent system Electronic Keypad Cleaning RV Model Only The keypad and surrounding the plastic bezel should be gently wiped with a lightly dampened sponge or cloth Any material that becomes lodged between the pushbuttons and the surrounding bezel may be removed by carefully dabbing with a cotton swab or the edge of a clo
11. filter gently grasp the filter on both ends and push down then pull the top of the filter out of the upper groove The filter should be cleaned regularly by hand washing in hot water with mild detergent solution Dry the filters completely before using them again RV Model Only The filters must be cleaned regularly The Clean Filter indicating light will illuminate after 40 hours of blower usage to remind you to clean the filters However the filters may need to be cleaned more often based upon the type and amount of cooking Check the filters at regular intervals To gain access to the filters remove the grill as described below The two filters are positioned side by side within the vent intake When properly situated the tops of the filters lean against the rear intake panel and the filter bottoms rest in a slot attached to the front intake panel Remove one filter at a time by gently grasping the top center of the filter and lifting Cap N Rear Intake Panel se Grasp Filter amp Lift __ Front Intake Panel Removing the Filters RV Shown The filters may be cleaned by hand washing in hot water with a mild detergent solution or by placing them in an automatic dishwasher Dry the filters completely before using them again After cleaning reinstall the filters carefully Intake Panel Cleaning ERV PRV Models Only The anodized aluminum intake pan
12. ic components trim paint or other cosmetic finish caused by improper usage or care abuse or neglect THE REMEDIES PROVIDED FOR IN THE ABOVE EXPRESS WARRANTIES ARE THE SOLE AND EXCLUSIVE REMEDIES THEREFORE NO OTHER EXPRESS WARRANTIES ARE MADE AND OUTSIDE THE FIFTY STATES OF THE UNITED STATES THE DISTRICT OF COLUMBIA AND CANADA ALL IMPLIED WARRANTIES INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR USE OR PURPOSE ARE LIMITED IN DURATION TO ONE YEAR FROM THE DATE OF ORIGINAL PURCHASE IN NO EVENT SHALL DACOR BE LIABLE FOR INCIDENTAL EXPENSE OR CONSEQUENTIAL DAMAGES NO WARRANTIES EXPRESS OR IMPLIED ARE MADE TO ANY BUYER FOR RESALE Some states do not allow limitations on how long an implied warranty lasts or do not allow the exclusion or limitation of inconsequential damages so the above limitations or exclusions may not apply to you This warranty gives you specific legal rights and you may also have other rights that vary from state to state fold here NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST CLASS MAIL PERMIT NO 4507 DIAMOND BAR CA POSTAGE WILL BE PAID BY ADDRESSEE ATTN WARRANTY PROCESSING DEPT DACOR 1440 BRIDGEGATE DR STE 200 PO BOX 6532 DIAMOND BAR CA 91765 9861 1 gacor Family Owned American Made IMPORTANT Please visit www dacor com to activate your warranty online W
13. lower will then turn on automatically and run on the High speed setting The blower speed may be adjusted by pressing and releasing either the Medium or Low pushbuttons The fan speed may be changed whenever desired as long as the vent intake is in the fully raised position The blower will not operate if the intake is in any other position The blower may be turned off in one of two ways First the user may press and release the Off pushbutton which will shut off the blower The intake may then be lowered by pressing and releasing the Up Down key Alternatively the user may press and release the Up Down key only which shuts off the blower and also lowers the vent intake NOTE 1 Activate the blower a few minutes before starting to cook to establish an airflow pattern in the room 2 Adjust the fan speed according to the volume and weight of the cooking exhaust 3 Reduce the fan speed if the flame on a gas cooktop is being drawn by the vent system Drawing of the flame is a normal occurrence with these powerful vent systems especially when installed with short duct runs 4 Always raise the vent intake and activate the blower whenever using the cooktop 5 Eliminate air currents in the vent vicinity by shutting nearby windows and doors turning off ceiling fans and closing adjacent heating and air conditioning outlets Place your largest frying pans skillets and stock pots on the rear burners whenever possible as
14. nding of the appliance by a qualified technician Have the installer show you where the fuse or junction box is located so that you know how and where to turn off power 2 Always be certain that nothing will interfere with the raising and lowering of the vent intake Ensure that cookware handles are turned to the side so that they will not be hit by the moving vent intake This will prevent accidental spilling of the cookware contents and reduce the possibility of damaging the vent intake drive system 3 Use the vent system for its intended purpose only as outlined in this manual Clean the filters grill and all grease laden surfaces often to prevent grease fires and maintain performance 5 Clean liquid spills immediately If liquid enters the vent intake then turn off the blower disconnect the power supply and carefully wipe up all liquid See the CARE AND CLEANING INSTRUCTIONS in this manual If the cooktop and vent are near a window use an appropriate window treatment Avoid long drapes or other window coverings that could blow over the cooktop and vent resulting in a fire hazard or tangling with the moving vent intake Always raise the vent intake and run the blower whenever the cooktop is operating What Not to Do Never operate the vent without the filters in place Do not operate the blower if a flame or flare up develops In the event of a flame immediately turn off the blower Smother
15. nt To operate the ERV PRV downdraft vent system press the Up Down switch located on the top cap once while the vent intake is in the down position The intake will take approximately 10 seconds to reach its uppermost position where it will stop The blower will then turn on to the last position the variable speed control was set when the intake was lowered last The blower speed may be adjusted by turn the variable speed control The blower speed may be adjusted when ever desired as long as the vent intake is in the fully raised position The blower will not operate if the intake is in any other positition If you received a damaged product immediately contact your dealer or builder Do not install or use a damaged appliance oN Please enter the information requested in the spaces provided below This information will be required in the unlikely event that a service call Phone _ _ _____ _ _ The blower may be turned off by pressing the Up Down switch once which shuts off the blower and also lowers the vent intake Top Cap a s Up Down Switch Variable Speed Control Filter Screen s Countertop Features ERV Shown RV Model Only To operate the RV raised vent system press and release the Up Down pushbutton when the vent intake is in its lowered position The intake will take approximately ten 10 seconds to reach its uppermost position where it will stop The b
16. ons that may save you the time and expense of an section contains a checklist unnecessary service call rized Service f you cannot readily find the solution to the problem please contact your nearest DACOR Autho please contact vent they are unable to solve your problem to your satisfaction Representative the unlikely DACOR Customer Service Web site www dacor com Fora Dealer Service 800 772 1778 Corporate Phone 800 793 0093 Fax 626 441 9632 Business Hours 7 7 30 AM to 4 00 Pacific Time DACOR Customer Service 4440 Bridge Gate Diamond Bar CA 91765 Thank you for selecting DACOR for your home We are dedicated to you and ensure that this appliance in your home ding performance for your family and friends will bring years of outstan sincerely S Michael Josep Chairman CEO TABLE OF 1 Purpose of this 1 Product Registration IMPORTANT INSTRUCTIONS 1 What 10 Doi 1 What Not 1 VENT 1 2 Getting started 1 2 Using Delay
17. retract Securing the Electronic Keypad RV Model Only In order to prevent accidental raising or lowering of the vent the electronic keypad may be secured so that the pushbuttons do not function This is especially helpful when young children are present or when cleaning the top cap end caps and electronic keypad While the vent is in the fully lowered or fully raised position press the High and Low keys simultaneously and hold for approximately one second This will secure the electronic controls making all pushbuttons inoperative The High and Low indicating lights will illuminate to indicate that the controls have been secured The keypad may be reactivated by again pressing the High and Low buttons simultaneously and holding for approximately one second After reactivation the Up Down key and all other pushbuttons will become functional once again Top Cap Cleaning NOTE The top cap should be cleaned while the vent intake is in the lowered position The top cap and end caps feature painted finishes that will scratch or stain if cleaned with abrasive materials or harsh chemicals Gently wipe them with a sponge or soft cloth moistened in a mild detergent solution whenever they becomes soiled Avoid introduction of moisture into the electronic keypad area NOTE The vent intake must be in the up position to allow for filter cleaning ERV PRV Models Only To remove the intake
18. th This will prevent the pushbuttons from sticking After cleaning immediately dry the keypad area with a soft cloth Do not use any abrasive materials to clean the keypad Grill Cleaning RV Model Only Remove the anodized aluminum grill by gently grasping it on both ends and lifting up then rotate the bottom of the grill out of the lower groove The grill should be cleaned regularly by hand washing in hot water with a mild detergent solution Set the grill on a flat surface and wipe only in the direction of the grill grain Avoid the use of abrasive materials such as steel wool or scouring powder to prevent permanent scratching or marring of the grill finish Do not use any cleaners containing ammonia as this will damage the anodized aluminum finish A soft toothbrush or nylon bristle dish brush may be used to clean the grill grooves Slide Bottom Out Lift Here Lift Here a nen Q DISES Removing the Grill RV Shown Vertical Grill Guide Left Shown Grill Mount Groove Location of Mounting Groove RV Shown After cleaning reinstall the grill by aligning the left and right edges of the grill with the vertical grill guides and inserting the upper edge of the grill into the slot in the top cap Then pivot and drop the bottom of the grill into the lower locating slot Troubleshooting
Download Pdf Manuals
Related Search