Cres Cor R171S1828 User's Manual
Contents
1. 3 www crescor com TO SHUT UNIT OFF Turn power switch to OFF Series R 171 S any C CRES COR a Rev 3 10 06 Page 2 of 4 5925 Heisley Road Mentor OH 44060 1833 OPERATING and MAINTENANCE INSTRUCTIONS for Cres Cor Refrigerated Cabinets Model R 171 S Series HOW TO REVERSE DOOR HARDWARE FOR OPPOSITE HAND Single Door Cabinet ONLY 1 Remove hinge covers with a screwdriver 2 Open door and lift up to remove door from cabinet 3 Unscrew and re mount the hinges and latch strike to the opposite sides of the cabinet 4 Remove the door hinges and the door latch Turn hinges and handle over and remount in the same holes 5 Remove plastic cam from each hinge rotate cam 180 with Vy groove on cam toward inside of cabinet Reseat cam into hinge 6 Plug all the extra holes with screws 7 Put door onto cabinet and adjust as necessary 8 Snap on hinge covers HOW TO CLEAN THE CABINET Cleaning Hints 1 Use the mildest cleaning procedure that will do the i WARN i N G BEFORE cleaning job the cabinet 2 Always run in the direction of polish lines to avoid 1 Unplug cord from wall scratching the surface 2 Do NOT hose cabinet with water 3 Use only a soft cloth sponge fibrous brushes 3 Do NOT get water into bottom compartment plastic or stainless steel pads for cleaning and scouring 4 Do NOT use abrasives or harsh chemicals Rinse thoroughly with fresh water after every f cleanin2. e Cause 1 Power light off 1 Power Cord 2 Compressor off 2 Power supply down 3a Thermostat defective 3b Defective start relay compressor 3 Evaporator fan on Power light on and Compressor off 4a Low charge Ab Frost build up on evaporator coil 4c Evaporator fan defective 4 Compressor on and cabinet 4d Thermostat defective not cooling 5 Compressor starts and stops 5a Low Charge cabinet not cooling 5b Faulty start capacitor compressor 5c Faulty start relay compressor 6a Low charge 6b Defective 6 Noisy compressor NOTES 1 Thermostat is pre set at approximately 38 F 3 8 C Temperature adjustment can only be made by a Service Agency 2 For replacement of the electrical parts refer to our list of authorized service centers FL 1400 Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Series R 171 S aie P Refrigerated Cabinets PEENIS CRES CO EE ey 5925 Heisley Road Mentor OH 44060 1833 Rev 3 10 06 Page 4 of 4 OPERATING and MAINTENANCE INSTRUCTIONS for Cres Cor Refrigerated Cabinets Model R 171 S Series REPLACEMENT PARTS Description 120V 240V Condenser Compressor Assembly 0854 040 0854 041 Cord Set 0810 029 05 0810 039 06 Door Assembly 1221 553 K 1221 553 K Evaporator Assembly for R171SUA10 1828 1416 068 K 1416 070 K Evaporator Assembly for R171SUA20 1856 1416 069 K 1416 071 K Gasket Kit 0861 261 0861 261 Hinge Kit 0519 087 K 0519 087 K Pi
3. g operation m Wipe up spills as soon as possible m Clean regularly to avoid heavy dirt build up 5 Always wipe dry to avoid water marks Soil Cleaner Method 1 Sponge on with cloth 2 Rinse with water Soap Ammonia or mild CABINET OEE ERRANEN detergent and water 3 Wipe dry Inside STUBBORN SPOTS Mild abrasive made for 1 Apply with damp sponge or cloth and AND STAINS stainless steel 2 Rub lightly Outside GREASE OIL Chemical oven cleaner for Follow oven cleaner manufacturer s stainless steel directions Stainless Steel HARD WATER 1 Swab or wipe with cloth SPOTS amp SCALE 2 Rinse and dry Mild detergents include soaps and non abrasive cleaners Vinegar Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Series R 171 S Rev 3 10 06 Page 3 of 4 CRES COR 5925 Heisley Road Mentor OH 44060 1833 OPERATING and MAINTENANCE INSTRUCTIONS for Cres Cor Refrigerated Cabinets Model R 171 S Series MAINTENANCE Note The refrigerator is shipped fully charged HOW TO CHARGE AND SERVICE THE REFRIGERATION SYSTEM The high side pressure should be approximately 175 PSI low pressure should be approximately 18 PSI at 75 F 24 C room temperature The charge should be 18 ounces of R134a Service valves are located on the condenser compressor assembly TROUBLE SHOOTING GUIDE Unit Condition Unit is plugged in Switch is ON Failure Probabl
4. lot Light Power ON 0766 094 0766 095 Post 0696 237 0696 237 Receptacle 0713 057 0713 058 Switch ON OFF 0808 116 0808 116 Terminal Block 0852 091 0852 091 Thermometer Kit 5238 035 K 5238 035 K Thermostat cold control 0854 043 K 0854 043 K Valve Thermal Exp R171SUA10 1828 0854 042 K1 0854 042 K1 Valve Thermal Exp R171SUA20 1856 0854 042 K2 0854 042 K2 Vent Fan R171SUA20 1856 ONLY 0769 045 K 0769 029 K 5 15P 6 15P 120V 15A 240V 15A TRANSFORWER 110 220V EPEA R A VENT FAN USED ON DOUBLE DOOR ONLY POWER TEMPERATURE CONTROL POWER SWITCH Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com
5. ol Ey EEE SEE EEE 5925 Heisley Road Mentor OH 44060 1833 OPERATING and MAINTENANCE INSTRUCTIONS Series R 171 S Rev 3 10 06 Page 1 of 4 CRES COR for Cres Cor Refrigerated Cabinets Model R 171 S Series Model No Volts Amps Hertz Phase NEMA R171SUA10 RI71S1828 120 7 8 60 l 5 15P R171SUA10240 R171S1828240 oie 3 7 60 l 6 15P R171SUA20 R171S1856 8 6 60 l 5 15P R171SUA20240 R171S1856240 a 4 2 60 l 6 15P Note The above model numbers are basic models They may be followed by letters M L D or ending with S Z and or CAN POWER LIGHT THERMOMETER SWITCH CONTROL PANEL HOW TO OPERATE Continued If you do not hear the compressor running turn power switch to OFF right away See Troubleshooting HOW TO INSTALL THE CABINET 1 Remove all packing material from inside the page 3 3 Pre chill the cabinet for approximately 40 minutes TELINE LCAN or until the temperature reaches approximately 38 F Load the food DO NOT PUT HOT FOOD INTO COLD cabinet 2 INSTALL ALL ANGLES BEFORE UNIT IS 3 Allow enough clearance around cabinet for air CABINET flow HOW TO OPERATE 1 Plug cord into proper wall outlet 2 Turn the power switch to ON Light will come on and compressor will start Listen closely for the compressor It will be slightly loud at first then quiet down Call Toll free 877 CRES COR 273 7267 Fax 800 822 039
Download Pdf Manuals
Related Search