Chauvet 1300 User's Manual
Contents
1. HURRICANE 1300 User Manual TABLE OF CONTENTS 1 BEFORE YOU BEGIN WEE 3 What IS eeh te To EE 3 UnpackingIASTUCIOA Sidi il ia taa ab sums ius 3 Fg esse 3 Productata lancia adi T 3 SME le td Dee 4 2 INTRODUCTION u tee en ea el 5 PIOJUEL OVERVIEW EE 5 PLOAUCE DIMENSIONS nao 6 SEH 7 AG POWO E 7 BUSe Heplacemehle nee ee 7 MOUNINO Zee O ee nee ee 8 Oo AAA PP PES RO ir RE SD Ra RA 8 ROIN DEE 8 4 OPERATING INSTRUCTIONS 2220020000000000000nnnnnnnnnnnnnnnnnnnnnnn nn RR RR ARR RR RR RR RR RAR 9 Manual Remote Operation FC M Optional 9 Timer Remote Operation FC T Standard cccoooonncnnncccccoonnccnnncnnnonaoncnnnnonnonananennos 9 Wireless Controller FC W Optional 10 General Troublesbooimg rar rens r rr RAR RASAR RAR RR RKA 11 CONTACT IMO MAU ON EE 11 SAR PEND IM o ee eal 12 General Maintenance 12 Kr Maer anni 13 TECHNICAL SPECIFICATIONS Ga EE 14 Hurricane M 1300 User Manual 2 August 2011 1 BEFORE YOU BEGIN What Is Included 1 x Hurricane 1300 1 x FC T wired timer remote 1 x Warranty Card 1 x User Manual Unpacking Instructions VVVV Immediately upon receiving a fixture carefully unpack the carton check the contents to ensure that all parts are present and have been received in good condition Notify the shipper immediately and retain packing material for inspection if any parts appear damaged from shipping or the carton itself shows signs of mishandling Save2. World Wide Web World Wide Web www chauvetlighting com www chauvetlighting co uk Hurricane M 1300 User Manual 11 August 2011 5 APPENDIX General Maintenance To maintain optimum performance and minimize wear fixtures should be cleaned frequently Usage and environment are contributing factors in determining frequency As a general rule fixtures should be cleaned at least twice a month Dust build up reduces light output performance and can cause overheating This can lead to reduced lamp life and increased mechanical wear Be sure to power off fixture before conducting maintenance Unplug fixture from power Use a vacuum or air compressor and a soft brush to remove dust collected on external vents and internal components Clean all glass when the fixture is cold with a mild solution of glass cleaner or Isopropyl Alcohol and a soft lint free cotton cloth or lens tissue Apply solution to the cloth or tissue and drag dirt and grime to the outside of the lens Gently polish optical surfaces until they are free of haze and lint The cleaning of internal and external optical lenses and or mirrors must be carried out periodically to optimize light output Cleaning frequency depends on the environment in which the fixture operates damp smoky or particularly dirty surrounding can cause greater accumulation of dirt on the unit s optics Clean with soft cloth using normal glass cleaning fluid Always dry the parts carefully Clean the external op
3. 1300 User Manual 8 August 2011 4 OPERATING INSTRUCTIONS Manual Remote Operation FC M Optional 1 Plug in the fog machine to power and turn the power switch to the fixture on 2 Plug in the wired manual remote to the Manual Controller socket on the rear of the fog machine 3 Press the single button located on the remote to trigger the fog output The button is momentary which means that the fog machine will only output while the button is pressed Once the button is released the fog will stop outputting Timer Remote Operation FC T Standard This mode will allow you to control the fogger manually set the fog machine to run continuously or to set the fog machine to run off bursts with adjustable interval and duration settings 1 Plug in the fog machine to power and turn the power switch to the fixture on 2 Plug in the timer remote to the Manual Controller socket on the rear of the fog machine 3 Press the TIMER ON OFF button on the timer remote The LED above the button should light indicating activation of function 4 You may now set the INTERVAL 8 DURATION adjustment knobs to the desired position The INTERVAL is the time between bursts of fog 4 The DURATION is the time the fog machine will run during the burst Interval Duration Adiustment Adjustment Timer LED Manual Indicator Momentary LED Manual Power LED Manual control Momentary Timer Latching cuca CRIS MANDA Button Continuous Latch
4. that you are connecting to the proper voltage and that the line voltage you are connecting to is not higher than that stated on the decal or rear panel of the fixture e This product is intended for indoor use only If applicable e To prevent risk of fire or shock do not expose fixture to rain or moisture Make sure there are no flammable materials close to the unit while operating e The unit must be installed in a location with adequate ventilation at least 20in 50cm from adjacent surfaces Be sure that no ventilation slots are blocked e Always disconnect from power source before servicing or replacing lamp or fuse and be sure to replace with same lamp source e Secure fixture to fastening device using a safety chain Never carry the fixture solely by its head Use its carrying handles e Maximum ambient temperature Ta is 104 F 40 C Do not operate fixture at temperatures higher than this e Inthe event of a serious operating problem stop using the unit immediately Never try to repair the unit by yourself Repairs carried out by unskilled people can lead to damage or malfunction Please contact the nearest authorized technical assistance center Always use the same type spare parts e Never connect the device to a dimmer pack e Make sure the power cord is never crimped or damaged e Never disconnect the power cord by pulling or tugging on the cord e Avoid direct eye exposure to the light source while it is on att
5. 120V 60Hz AC or 230V 50Hz PUSO ee nie een 13A 250V Power Consumption asus 1 328W 11 2A max at 120V MUSAN OW EE 11 2A at 120V OWE eC OM rr ea ee reg Sessel 0 99 at 120V EE 7A 250V POWER Consumption een 1 325W 5 8A max at 230V A Sea re sele dest rere ee 1 83A at 230V Belg Ge e EE 0 99 at 230V THERMAL Maximum ambient Temperature 104 40 C CONTROL 8 PROGRAMMING Daiana 5 pin amp ground DIN5 female socket Data pin configurationpin1 LED pin2 control pin3 5V pin4 ground pin5 none ground none ORDERING INFORMATION io ae see F1300 Wired manual remote Optional cooooccnnccccnnnnncccnoncnncnonanonnnononncnnnnnnnnnnnnnnoncnnnnnnnns FC M Wired timer remote mecluded EE FC T Wireless manual remote optional FC W SPARE PARTS ORDERING INFORMATION Master ROD ee EEN P170 F3MSPCB el 1P20 HT 13 A ds Sea ada k ns Gecko AE E TE EE deen P200 F3PUMP le Bee ie Ta P170 F3FLC A TE ee A th P170 F1FLOS Bd E e WEE P170 THEF11 Brackek Lei EEN P111 F3BKNOB FUSG eil EE P170 FUSEHOL WEIER TOG DUM e P111 F3FOGB WARRANTY INFORMATION NEE ege ee 1 year limited warranty Hurricane M 1300 User Manual 14 August 2011
6. empt any repairs yourself In the unlikely event your unit may require service There are no user serviceable parts inside the unit Do not open the housing or A please contact CHAUVET at 954 929 1115 FCQ Fog Cleaner Quart was specifically developed by Chauvet to clean your Hurricane 1300 Make sure you use FCQ regularly to increase the life of your fogger Hurricane M 1300 User Manual 4 August 2011 2 INTRODUCTION Product Overview Hanging bracket Safety eyebolt Fluid container Handle Tilt Adjustment ve knob Ozzie Low Fluid indicator Manual Fluid level controller uia leve Power indicator switch E a E Ba Ca E nn Fuse holder E En E E EH Power input E hardwired El E Manual Fog Wireless button Controller Hurricane 1300 User Manual 5 August 2011 Product Dimensions 317 mm 12 5 in 425 mm 16 7 in 306 mm 12 in Hurricane M 1300 User Manual 6 August 2011 3 SETUP AC Power To determine the power requirements for a particular fixture see the label affixed to the back plate of the fixture or refer to the fixture s specifications chart A fixture s listed current rating is its average current draw under normal conditions All fixtures must be powered directly off a switched circuit and cannot be run off a rheostat variable resistor or dimmer circuit even if the rheostat or dimmer channel is used solely for a 0 to 100 switch Before applying power to a fixture c
7. heck that the source voltage matches the fixture s requirement Check the fixture or device carefully to make sure that if a voltage selection switch exists that it is set to the correct line voltage you will use Fuse Replacement A Unplug the IEC power cable before replacing the fuse Always replace with same type of fuse This product has a replaceable fuse In the event that the fuse needs to be replaced follow the instructions provided below Using a flat head screwdriver remove the fuseholder from the IEC housing Remove the bad fuse from the fuseholder Insert the new fuse into the fuseholder Install the fuseholder in the IEC housing IN The fuse is located inside this compartment Remove using a flat head screwdriver Hurricane M 1300 User Manual 7A August 2011 Mounting Orientation This fixture should only be mounted used on a flat surface This fixture may not be tilted Rigging It is important never to obstruct the vents pathways Mount the fixture using a suitable C or O type clamp e When selecting installation location take into consideration the fluid reservoir access and routine maintenance e Safety cables must always be used utilizing the provided safety eye bolt e Never mount in places where the fixture will be exposed to rain high humidity extreme temperature changes or restricted ventilation Hanging Clamp Note Clamp is sold separately Hurricane M
8. ing Button Hurricane M 1300 User Manual 9 August 2011 Wireless Controller FC W Optional This mode will allow you to control the fogger using the optional wireless controller This consists of the transmitter and the receiver You may control up to 4 independent fog machines or many more if you run them simultaneously See the below instructions on setting up your fogger to operate with the FC W 1 Plug the wires receiver into the fog machine 5 pin port labeled Wireless Controller 2 There are 4 buttons on the wireless remote transmitter which act as triggers Each button can be assigned to a different fog machine You may only choose 1 dipswitch on each receiver See the below configuration for setting the receivers to operate with the transmitter remote Mode Dipswitches CH1 1 On 2 4 Off CH2 2 On 1 3 4 Off CH3 3 On 1 2 4 Off CH4 4 On 1 2 3 Off 3 Press the fog button and the fog machine will output fog momentarily for as long as you hold down the button LED indicator ready LED indicator heating Dipswitches Wireless Transmitter Fog Triggers Wireless Receiver Hurricane 1300 User Manual 10 August 2011 General Troubleshooting Symptom Solution s No Power Check mains power Check external fuse Check internal fuse No fog output Check fluid level Check remote If using wireless check batteries If using wireless check dipswitches on receiver Breaker F
9. the carton and all packing materials In the event that a fixture must be returned to the factory it is important that the fixture be returned in the original factory box and packing Claims The carrier is responsible for any damage incurred during shipping to this product or any part that shipped with it Therefore if the received merchandise appears to have damages caused during shipping the customer must submit the damage report and any related claims with the carrier not CHAUVET The customer must submit the report upon reception of the damaged merchandise Failure to do so in a timely manner may invalidate the customer s claim with the carrier For other issues such as missing components or parts damage not related to shipping or concealed damage the customer must make claims to CHAUVET within seven 7 days of receiving the merchandise Product at a Glance Auto Programs e Auto ranging Power Supply Replaceable Fuse S S Use on Dimmer Outdoor Use Sound Activated DMX Master Slave User Serviceable Duty Cycle Hurricane M 1300 User Manual 3 August 2011 Safety Instructions A Please read the following notes carefully because they include important safety information about the installation usage and maintenance of this product e Please keep this User Guide for future consultation If you sell the unit to another user be sure that they also receive this instruction booklet e Always make sure
10. tics at least every 20 days Clean the internal optics at least every 30 60 days Hurricane 1300 Make sure you use FCQ regularly to increase the life of your E FCQ Fog Cleaner Quart was specifically developed by Chauvet to clean your fogger Hurricane M 1300 User Manual 12 August 2011 Returns Procedure Returned merchandise must be sent prepaid and in the original packing call tags will not be issued Package must be clearly labeled with a Return Merchandise Authorization Number RMA Products returned without a RMA will be refused Call CHAUVET and request a RMA prior to shipping the fixture Be prepared to provide the model number serial number and a brief description of the cause for the return Be sure to properly pack fixture any shipping damage resulting from inadequate packaging is the customer s responsibility CHAUVET reserves the right to use its own discretion to repair or replace product s As a suggestion proper UPS packing or double boxing is always a safe method to use If you are given a RMA please include the following information on a piece of paper inside the box 1 Your name 2 Your address 3 Your phone number 4 The RMA 5 A brief description of the symptoms Hurricane M 1300 User Manual 13 August 2011 TECHNICAL SPECIFICATIONS WEIGHT amp DIMENSIONS Baren EE 16 7 in 425 mm de EE 12 5 in 317 mm Held seele Dee 12 0 in 306 mm A Eee ee ee ans 21 lbs 9 5 kg POWER RRA e e no
11. use keeps Possible electrical short Contact Chauvet or a Chauvet Dealer distributor for further blowing instruction Low fog output Run a cleaning solution through the fog machine Check that the fog machine is plugged into the correct voltage Fog machine is not Check to replace the external fuse heating up Check to replace the internal fuse Possible bad part Contact Chauvet or a Chauvet Dealer distributor for further instruction Remote does not Make sure connector is firmly connected to device work Try using another controller Possible bad controller Check the internal fuse Check the external fuse Fluid indicator states Try resetting the fog machine by turning the power off and then on again no fog but the Possible bad part Contact Chauvet or a Chauvet Dealer distributor for further container if full instruction If you still have a problem after trying the above solutions please contact CHAUVET Technical Support at the location listed below Contact Information World Headquarters United Kingdom amp Ireland CHAUVET CHAUVET Europe Ltd General Information General Information Address 5200 NW 108th Avenue Address Unit 1C Sunrise FL33351 Brookhill Road Voice 954 929 1115 Pinxton Nottingham UK Fax 954 929 5560 NG16 6NT Toll free 800 762 1084 Voice 44 0 1773 511115 Technical Support Fax 44 0 1773 511110 Voice 954 929 1115 Press 4 Email uktech chauvetlighting com Fax 954 756 8015
Download Pdf Manuals
Related Search