Char-Broil LP Gas Grill User's Manual
Contents
1. If burner does not light turn knob s to OFF wait 5 minutes try again If the burner does not ignite with the valve open gas will continue to flow out of the burner and could accidentally ignite with risk of injury Sideburner Use Do not use a cooking pot larger than 9 on grid Remove grid from sideburner before using griddle Never exceed griddle zone value setting shown on graphics Damage to Teflan amp may occur Do not close lid when using griddle Rotisserie Burner Ignitor Lighting 1 Turn all knobs to OFF 2 Open lid during lighting Turn gas on at LP Tank 3 Push in and turn Burner Selector Knob to ON ROTISSERIE BURNER 4 Press Y Piezo Ignitor Button or Electronic Ignition hold up to 5 seconds Or turn amp Rotary Ignitor Knob rapidly up to 5 times Be sure burner lights and stays lit 5 IFIGNITOR does not work follow match lighting instructions above Match Lighting 1 Open lid Turn on gas at LP tank 2 Place lit match near porthole of burner 3 Push in and turn Burner Selector Knob to ON ROTISSERIE BURNER Be sure burner lights and stays lit To match light use first opening in burner Note Rotisserie burner and main burner cannot be used at the same time redis Ignitor Lighting Turn gas on at LP tank a Push in and turn knob to HIGH 3 Turn or push up to 5 times to light burner Be sure burner lights and stays lit 4 If burner does not2. Clean Wash hands utensils and surfaces with hot soapy water before and after handling raw meat and poultry Separate Separate raw meats and poultry from ready to eat foods to avoid cross contamination Use a clean platter and utensils when removing cooked foods Cook Cook meat and poultry thoroughly to kill bacteria Use a thermometer to ensure proper internal food temperatures Chill Refrigerate prepared foods and leftovers promptly For more information call USDA Meat and Poultry Hotline at 1 800 535 4555 in Washington DC 202 720 3333 10 00 am 4 00 pm EST How To Tell If Meat Is Grilled Throughly Meat and poultry cooked on a grill often browns very fast on the outside Use a meat thermometer to be sure food has reached a safe internal temperature and cut into food to check for visual signs of doneness Whole poultry should reach 180 F breasts 170 F Juices should run clear and flesh should not be pink e Hamburgers made of any ground meat or poultry should reach 160 F and be brown in the middle with no pink juices Beef veal and lamb steaks roasts and chops can be cooked to 145 F All cuts of pork should reach 160 F NEVER partially grill meat or poultry and finish cooking later Cook food completely to destroy harmful bacteria When reheating takeout foods or fully cooked meats like hot dogs grill to 165 F or until steaming hot Storing Your Grill Clean cooking grate s and discard old briquets
3. Four Burner Grill A Do not lean over grill while lighting 1 B om M Open lid Turn on gas at LP tank Turn left knob to Push and hold Electronic Ignitor button If ignition does NOT occur in 5 seconds turn the burner controls off wait 5 minutes and repeat the lighting procedure Ignite left center burner by turning left center knob to d then ignite right center burner by turning right center knob to y then ignite right burner by turning right knob to y Match Lighting for Two and Three Burner Grills A Do not lean over grill while lighting 1 Open lid Turn on gas at LP tank 2 Match holder is on the right rear leg Attach match to match holder light match Place match into match lighting hole from outside of grill bottom as shown 3 Push in and turn right knob to y Be sure burner lights and stays lit 4 Two burner grills push in and turn left knob to y Three burner grill push in and turn center knob to and then right knob to 4 Match holder for two and three burner grills Match Lighting for Four Burner Grills A Do not lean over grill while lighting 1 Open lid Turn on gas at LP tank 2 Place lit match into match lighting hole from outside of grill bottom as shown 3 Push in and turn right knob to Be sure burner lights and stays lit Push in right center burner to light left center and left burner gt Match lighting hole is on side of grill bottom
4. Lighting Turn knobs to HI position for warm up Do not warm up grill with knobs on IGNITE Knobs and handle will become uncomfortably hot if left in IGNITE positions Match Lighting Traditions Series QuickSet and QuickSet Traditional A Do not lean over grill while lighting 1 Open lid Turn on gas at LP tank 2 Place lit match into match lighting hole from outside grill bottom as shown 3 Push in and turn RIGHT knob to IGNITE Be sure burner lights and stays lit 4 Light left burner by pushing LEFT knob in and turning to IGNITE After Lighting Turn knobs to HI for warm up Match lighting hole is in bottom or side Ignitor Lighting Performance and Advantage Series Two Burner Grill A Do not lean over grill while lighting 1 RON 5 Open lid Turn on gas at LP tank Turn left knob to J Push and hold Electronic Ignitor button If ignition does NOT occur in 5 seconds turn the burner controls off wait 5 minutes and repeat the lighting procedure To ignite right burner turn right knob to d Three Burner Grill A Do not lean over grill while lighting 1 ea Ww Open lid Turn on gas at LP tank Turn left knob to y Push and hold Electronic Ignitor button If ignition does NOT occur in 5 seconds turn the burner controls off wait 5 minutes and repeat the lighting procedure Ignite center burner by turning center knob to then ignite right burner by turning right knob to y
5. Polish Penny Brite Copper Brite Rub lightly using dry damp cloth in the direction of polish lines on the stainless steel Grease and Blood Burnt on or Baked on Foods Scotch Brite Power Pad 2001 Easy Off De Grease lt 4 to 6 hot solution of such agents as tri sodium polyphosphate 5 to 15 caustic soda solution Excellent removal on acids all finishes Particularly useful where rubbing is not practical Grease and Oil Any good commercial detergent or caustic cleanser Apply with sponge or soft cloth in direction of polish lines NOTE Use of proprietary names is intended only to indicate a type of cleaner and does not constitute an endorsement Omission of any proprietary cleanser does not imply its inadequacy All products should be used in strict accordance with instructions on package 20 NATURAL HAZARD SPIDERS FACT Sometimes spiders and other small insects climb into the burner tubes attached to the burner The spiders spin webs build nests and lay eggs The webs or nests can be very small but they are very strong and can block the flow of gas Clean burner s prior to use after storing at the beginning of grilling season or after a period of one month not being used Typical spider webs inside burner Spider Guards are on the air intakes in an effort to reduce this problem but it will not eliminate it An obstruction can result in a flashback a fir
6. WWW GRILLREGISTRATION COM If you register online you do not need to send in this registration card PLEASE FILL OUT THIS CARD AND RETURN IT WITHIN 10 DAYS OF PURCHASE FAILURE TO RETURN MAY AFFECT YOUR WARRANTY COVERAGE LLENE ESTA TARJETA Y DEVUELVALA DENTRO DE LOS 10 DIAS DE LA COMPRA SI NO LA DEVUELVE PUEDE VERSE AFECTADA SU COBERTURA DE GARANTIA VEUILLEZ COMPL TER CETTE CARTE ET LA RETOURNER DANS LES 10 JOURS SUIVANT L ACHAT LA COUVERTURE DE VOTRE GARANTIE POURRAIT EN ETRE AFFECTEE SI VOUS NE LE FAITES PAS 1 First Name Nombre Pr nom Initial Inicial Initiale Last Name Apellido Nom de famille LI ft Address number and street Direcci n n mero y calle Adresse num ro et rue Apt Number N de apart N d appt City Ciudad Ville State Estado Province Zip Code C digo zip Code postal Li Lt 2 E mail Address Direcci n de correo electr nico Adresse lectronique If you voluntarily provide us with your email address you give us permission to use your email address to send you offers that may interest you Si nos informa voluntariamente su direcci n de correo electr nico nos da permiso para usarlo a fin de enviarle ofertas que pueden interesarle Si vous choisissez de nous fournir votre adresse lectronique vous nous donnez la permission de l utiliser pour vous faire part d offres sp ciale
7. journal 3 Smoker Ahumadora Fumoir 4 1 Charcoal Grill Parrilla de carb n Barbecue au charbon 5 1 Charcoal Smoker Ahumadora de carb n Fumoir au charbon 6 L Outdoor Fireplace Hogar para exteriores Foyer ext rieur Television commercial Comercial televisivo Publicit la t l vision Grill was assembled Parrilla ensamblada Le gril tait d ja assembl In store display Exhibidor en la tienda Promotion sur le lieu de vente Store circular Circular de la tienda Prospectus de magasin Brand name Marca Marque Product style Estilo del producto Style du produit Price value Precio valor Rapport prix valeur 7 L Cooker Fryer Cocina freidora Product quality Calidad del producto Qualit du produit Cuiseur Friteuse 0 L 1 Friend Relative recommendation Recomendaci n de amigo o pariente 8 L Other Otro Autre Recommandation d un e ami e parent e 11 1 Salesperson recommendation Recomendaci n del vendedor Recommandation d un e pr pos e la vente 3 2079 918 quo Mail to 12 L1 Grill size Tama o de la parrilla Taille du gril 13 L Product warranty Garant a del producto Garantie du produit Product Registaron Dept 14 C Store demonstration Demostraci n en la tienda D monstration en magasin PO BOX 1240 15 C Point of purchase Punto de compra Lieu de vente Columbus Georgia
8. mild soap and water A Do not use household cleaning agents Damage to gas train components can result Brush soapy solution onto areas indicated by arrows If growing bubbles appear do not use or move the LP tank Contact an LP gas supplier or your fire department Connecting Regulator To The LP Tank 1 LP tank must be properly secured onto grill Refer to Assembly Manual 2 Turn all control knobs including sideburner if featured to the OFF position 3 Turn LP tank OFF by turning hand wheel clockwise to a full stop 4 Remove the protective cap from LP tank valve Always use cap and strap supplied with valve Strap and Cap Do not use a POL transport plug plastic part with external threads It will defeat the safety feature of the valve 5 Hold regulator and insert nipple into LP tank valve Hand tighten the coupling nut holding regulator in a straight line with LP tank valve so as to not cross thread the connection Nipple has to be centered into the LP tank valve Hold coupling nut and regulator as shown for proper connection to LP tank valve 6 Turn the coupling nut clockwise and tighten to a full solid stop The regulator will seal on the back check feature in the LP tank valve resulting in some resistance An additional one half to three quarters turn is required to complete the connection Tighten by hand only do not use tools NOTE If
9. tank 2 Disconnect ignitor wire from electrode A 3 Remove thumbscrew from shield B remove shield and clean any accumulation of grease with soap and water 4 Unfasten hinge pins and hitch pin Note how hinge pins and hitch pins are attached 5 Using a garden hose preferably with nozzle force water through burner tube Make sure water comes out of every burner porthole Open clogged portholes with a thin wire 6 Examine rotisserie housing and burner closely C If any cracks or large holes other than portholes are found replace rotisserie burner 7 Wipe ceramic portion of electrode A with rubbing alcohol and cloth 8 If grill is to be stored coat burners lightly with cooking oil Wrap in protective cover to keep insects out If not storing use following steps 9 After burner has been cleaned place rotisserie burner onto back of grill bottom and attach with hinge pins and hitch pins 10 Place gas tube inside burner tube put shield over burner tube and secure with thumbscrew VERY IMPORTANT Burner tubes must engage gas tube as shown D 11 Attach flat end of ignitor wire A to electrode Thumbscrew Hinge Pin DE lA E a r F ac Electrode Gas Tube y X Hinge Pin Ignitor Wire Burner Tube Burner Portholes 945 Tube Burner Tube Rotisserie Burner Use The rotisserie burner is a 10 500 BTU radiant heat burner that transforms your grill into a multilevel cooking center It
10. tank volume Volume of propane in tank will vary by temperature Afrosty regulator indicates gas overfill Immediately close LP tank valve and call local LP gas dealer for assistance Do not release liquid propane LP gas into the atmosphere This is a hazardous practice To remove gas from LP tank contact an LP dealer or call a local fire department for assistance Check the telephone directory under Gas Companies for nearest certified LP dealers LP Tank Exchange Many retailers that sell grills offer you the option of replacing your empty LP tank through an exchange service Use only those reputable exchange companies that inspect precision fill test and certify their cylinders Exchange your tank only for an OPD safety feature equipped tank as described in the LP Tank section of this manual Always keep new and exchanged LP tanks in upright position during use transit or storage Leak test new and exchanged LP tanks BEFORE connecting to grill LP Tank Leak Test For your safety Leak test must be repeated each time LP tank is exchanged or refilled Do not smoke during leak test Do not use an open flame to check for gas leaks Grill must be leak tested outdoors in a well ventilated area away from ignition sources such as gas fired or electrical appliances During leak test keep grill away from open flames or sparks Use a clean paint brush and a 50 50 soap and water solution Use
11. upright position during use transit or storage Do not store an LP tank in an area where children play LP Tank The LP tank used with your grill must meet the following requirements Use LP tanks only with these required measurements 12 30 5cm diameter x 18 45 7 cm tall with 20 Ib 9 kg capacity maximum LP tanks must be constructed and marked in accordance with specifications for LP tank of the U S Department of Transportation DOT or for Canada CAN CSA B339 cylinders spheres and tubes for transportation of dangerous goods Transport Canada TC See LP tank collar for marking LP tank valve must have Type 1 outlet compatible with regulator or grill Safety relief valve UL listed Overfill Protection Device OPD This OPD safety feature is identified by a unique triangular hand wheel Use only LP tanks equipped with this type of valve LP tank must be arranged for vapor withdrawal and include collar to protect LP tank valve OPD Hand Wheel LP Liquefied Petroleum Gas e LP gas is nontoxic odorless and colorless when produced For Your Safety LP gas has been given an odor similar to rotten cabbage so that it can be smelled LP gas is highly flammable and may ignite unexpectedly when mixed with air LP Tank Filling Use only licensed and experienced dealers LP dealer must purge a new tank before filling Dealer should NEVER fill LP tank more than 8096 of LP
12. you cannot complete the connection disconnect regulator and repeat steps 5 and 6 If you are still unable to complete the connection do not use this regulator Do not insert any tool or foreign objects into the valve outlet or safety relief valve You may damage the valve and cause a leak Leaking propane may result in explosion fire severe personal injury or death e If a leak is detected at any time STOP and call the fire department f you cannot stop a gas leak immediately close LP tank valve and call LP gas supplier or your fire department Never attempt to attach this grill to the self contained LP gas system of a camper trailer or motor home Do not use grill until leak tested Safety Tips A Before opening LP tank valve check the coupling nut for tightness A When grill is not in use turn off all control knobs and LP tank valve A Never move grill while in operation or still hot A Use long handled barbecue utensils and oven mitts to avoid burns and splatters A Maximum load for sideburner and side shelf is 10 Ibs A Do not use a cooking pot larger than 9 on the sideburner A A soup can or grease cup must be attached to grease clip grease tray and emptied after each use Do not remove soup can grease cup until grill has completely cooled A If you notice grease or other hot material dripping from grill onto valve hose or regulator
13. 1 8 teas Kitchen Bouquet 2 hard boiled eggs finely chopped milk if needed giblet broth if needed Boil giblets until tender reserving broth Chop giblets and set aside Remove grilled turkey from baking pan and place on hot platter Pour all pan juices into large measuring cup Skim off fat reserving 3 to 4 Tbles Place reserved fat into a deep saucepan heating over moderate heat Stir in flour whisking well with wire whisk Cook over low heat until bubbly then remove from heat Add fat free pan juices add milk and giblet broth to juices to make 2 full cups Blend well with wire whisk Season with salt pepper Accent thyme and Kitchen Bouquet whisking continuously Return mixture to heat and continue stirring for 3 to 4 minutes Add chopped eggs Smoked Turkey Breast Cooking time 25 minutes per pound Method Grill indirect heat 1 turkey breast fresh or thawed 1 large bottle Italian dressing 1 large plastic roasting bag 1 small bottle soy sauce Mix dressing and soy sauce Place turkey breast in bag and pour mixture over turkey breast Marinate in refrigerator overnight Light one side of grill with setting on low Remove turkey from marinade and reserve liquid Put meat thermometer in turkey breast being certain not to touch bone Place turkey on the grill away from direct heat Grill over low fire basting and rotating often Remove when meat thermometer registers 180 F 28 29 30 Please register your grill online at
14. 16 424 Other Patents Pending 2004 W C Bradley Co All Rights Reserved 31 Jey9e aJJOA ep 1I9J9 A 9119y9U8 9 p Iesse un zanj9943 m jueauoe seo a Id JloAJ8S9J 9 Zessi duieM rj 330 uonisod ue juos epueuJuioo ap suojnoq sa enb sno zaeJnssy N sJno nJq sep xneAn saj uns segj eijsur Juaula 99 J09 JUOS SAAJEA Sa AND sno zaJnssy N 9 nsuyanueJeb ep ayeo e zassiidway E uonesi nn p sjenueu sa sno zasi7 O ojunoes ejnoj ue Spe Mod ejeoey 11149 NA 31N3 SIAdV SDIAYAS 4 Ins sunof J pz Ins seJneu pz ZS09 Z8 008 b d3dlv SNOA SNOANOd SNON uiseBeuu ne jinpoud 39 sed zeueuJeJ e QqHOav ad SNON ZILOVINOO eulo qoJd ep seo uy Z1ILIdAV STOP Should you encounter any problem CALL US FIRST Do not return this product to the store WE CAN HELP 1 800 241 7548 24 Hours a Day 7 Days a week GRILL SERVICE CENTER s Manuals Complete Warranty Card Ensure valves are correctly Read all Owner Ensure control knobs lock on OFF position Fill LP Tank if provided a a a installed in burner tubes a a AU Perform Leak Test Thank You for Your Purchase 32
15. 31902 1240 16 O Other Otras Autre Thank you for completing this questionnaire Your answers will help us and other companies reach you with offers that may interest you If you prefer not to receive these offers please check here Gracias por completar este cuestionario Sus respuestas nos ayudar n a nosotros y a otras compa as a llegar a ustedes con ofertas que puedan resultarles de inter s Si prefiere no recibir estas ofertas por favor marque aqu Merci d avoir bien voulu remplir ce questionnaire Vos r ponses nous aideront et aideront d autres compagnies vous communiquer des offres sp ciales susceptibles de vous int resser Si vous pr f rez ne pas recevoir d informations concernant ces offres sp ciales veuillez cocher ici Certified Grill Parts And Accessories amp Char Broil and Design Char Broil Gas Grill Briquettes Char Diamonds Cooking Zone and Design Diamond Flame Executive Chef Faststart amp Flare Fighter FlavorMaster Gas Grill Silouette and Design amp H20 Smoker Lava Flame MasterFlame MasterFlame Precision Cooking System PowerSpark Quantum PrecisionFlame and Design Sierra and TruFlame are registered Trademarks of the W C Bradley Company ThermosQ is a registered trademark of the Thermos Company and its affiliates Artisan Collectiion by Char Broil C3 and Design Char Broil and Design Flame Design FlavorTents G
16. A KEEPERS OF THE FLAME L P Gas Grill Use and Care For Outdoor Use Only J QUICK GET PERFORMANCE AUICKSET ATERAT TRADITIONAL To installer or person assembling grill Leave this manual with grill for future reference To consumer Keep this manual for future reference This manual applies to a variety of grill styles Your grill will not have all of the features shown Read this manual before cooking on grill Failure to follow all manufacturers instructions could result in serious personal injury and or property damage Combustion by products produced when using this product contain chemicals known to the State of California to cause cancer birth defects or other reproductive harm Printed in USA 2005 Generic U amp C E 4165451 01 31 05 2 FOR YOUR SAFETY 1 Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance 2 An LP tank not connected for use Installation Safety Precautions shall not be stored in the vicinity of Use grill only with LP propane gas and the this or any other appliance regulator valve assembly supplied For residential use only Do not use for commercial cooking FOR YOUR SAFETY If you smell gas 1 Shut off gas to the appliance 54 ANSI Z223 1 or CAN CGA B149 2 Propane 2 Extinguish any open flame Installation Code Handling and storage of LP 3 Open lid cylinders mus
17. P tank Coupling nut and LP tank valve not fully connected ELECTRICAL ISSUES Electrode cracked or broken sparks at crack Electrode tip not in proper position Wire and or electrode covered with cooking residue Wires are loose or disconnected Wires are shorting sparking between ignitor and electrode Dead battery Prevention Solution Turn off gas at LP tank or at source on natural gas systems If hose is cut or cracked replace valve hose regulator If burned discontinue use of product until a gas service technician plumber has investigated cause and correction is made Turn off LP tank valve Call LP gas dealer 800 number on tank label or call local fire department Remove regulator from tank and visually inspect rubber seal for damage Reinstall and check for leaks Ensure black knob is on tight Turn off LP tank valve if possible without injury to self If fire cannot be controlled with baking soda extinguisher call local fire department Remove burner and inspect for spider nest or rust Clean using bottle brush Ensure valves and burner tubes are aligned per assembly instructions Turn off LP tank valve Leave lid open to allow flames to die down After cooling clean food particles and excess grease from inside firebox area grease cup pan tray and other surfaces Prevention Solution See instructions on control panel and in Use and Care manual Make sure
18. Store in dry location When LP tank is connected to grill store outdoors in well ventilated space and out of reach of children Cover grill if stored outdoors Choose from a variety of grill covers offered by Char Broil Store grill indoors ONLY if LP tank is turned off and disconnected removed from grill and stored outdoors When removing grill from storage follow Cleaning Burner Assembly instructions before starting grill 23 Troubleshooting Emergencies Gas leaking from cracked cut burned hose Gas leaking from LP tank Gas leaking from LP tank valve Gas leaking between LP tank and regulator connection Fire coming through control panel Grease fire or continuous excessive flames above cooking surface Problem Burner s will not light using ignitor See Electronic Ignition Troubleshooting also Continued on next page Possible Cause Old hose cut in hose Mechanical failure due to rusting or mishandling Failure of tank valve from mishandling or mechanical failure Improper installation connection not tight failure of rubber seal Fire in burner tube section of burner due to partial blockage Misalignment of valve to burner tube Too much grease buildup in burner area Possible Cause GAS ISSUES Trying to light wrong burner Burner not engaged with control valve Obstruction in burner No gas flow Vapor lock at coupling nut to L
19. System See Electronic Ignition Troubleshooting also No spark some ignition noise e See Section II of Electronic Ignition System Sparks but not at electrode or at full See Section Ill of Electronic Ignition System strength PIEZO PUSH BUTTON AND ROTARY Push button sticks at bottom Replace ignitor Rotary knob rotates without clicking Replace knob Sparking between ignitor and electrode Inspect wire insulation and proper connection Replace wires if insulation is broken Burner s will not See GAS ISSUES on previous page match light Match will not reach Use paper match long stem match fireplace match or match holder where supplied Improper method of match lighting See Match Lighting section of Use and Care manual Sudden drop in gas Out of gas Check for gas in LP tank flow or low flame Excess flow valve tripped Turn off knobs wait 30 seconds and light grill If flames are still low turn off knobs and LP tank valve Disconnect regulator Reconnect regulator and leak test Turn on LP tank valve wait 30 seconds and then light grill Vapor lock at coupling nut LP tank Turn off knobs and LP tank valve Disconnect coupling nut from connection tank Reconnect and retry Flames blow out High or gusting winds Turn front of grill to face wind or increase flame height Low on LP gas Refill LP tank Excess flow valve tripped Refer to Sudden drop in gas f
20. and can cause serious injury Me renee or death Never burn charcoal inside homes vehicles or tents Table of Contents For Your Safety Call Grill Service Center For He Fill Out Warranty Information Installation Safety Precautions Table of Contents Safety Symbols Warranty s cs setcveraedves LP Tank Removal Transport an LP Tank LP Liquefied Petroleum Gas LP Tank Fillitig uos LP Tank Exchange LP Tank Leak Test pand Par iio caida atado oco AA Po keas artdandebaesem aces ec Connecting Regulator To The LP Tank 2c dest cies bean coda bead dw the ewan adie ace ad Safety TiPS Leak Testing Valves Hoses and Regulator 0 cece eee eee een eben ees Valve Check Hose Check nuuanu Turning Grill Off lgnitor Check sac ce eee cans For Safe Use Of Your Grill and To Avoid Serious Injury 000 e eee Ignitor Lighting and Match Light Ignitor Lighting and Match Light Sideburner Use ing Traditional Series QuickSet and QuickSet Traditional ing Performance and Advantage Series oooocccocccccocccccoo Rotisserie Burner Ignitor and Match LightiMgG ooooooocorcconrnocrre eee eens Sideburner Ignitor and Match Lighlitig uus o ma aer be toe EPR RELY DERE detnr Eh ber kane Burner Flame Check Before Your First Cookout Cleaning T
21. ants to the original consumer purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning with the date of purchase Castings Limited Lifetime All Burner 3 years Electronic ignition excluding battery 3 years Remaining parts excluding battery 1 year This limited warranty is for replacement of defective parts only Manufacturer will not be responsible for failure or damage resulting from use accident alteration misuse transportation commercial use abuse hostile environments improper installation or installation not in accordance with local codes Manufacturer will at its option refinish or replace any product or part found to be defective during its respective warranty period Manufacturer will require return of the part s claimed to be defective for its inspection freight or postage prepaid Manufacturer may require reasonable proof of purchase and suggests that receipts be retained This limited warranty does not cover scratches dents corrosion or discoloring by heat abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance This limited warranty does not cover surface rust or the discoloration of stainless steel surfaces This limited warranty does not include the cost of any inconvenience personal injury or property damage due to failure o
22. aporizer Tents Will eventually decompose and weaken with use Remove from grill and tap to loosen any scaling Brush vigorously with a wire brush to remove any additional scaling rust or residue Plated wire grate s Wash grate s and V bar with concentrated grill cleaner or use soap and water solution Dry thoroughly and store indoors between cookouts Plastic parts Wash with warm soapy water and wipe dry A Do not use citrisol abrasive cleaners degreasers or a concentrated grill cleaner on plastic parts Damage to and failure of parts can result Porcelain grate s Because of glass like composition most residue can be wiped away with baking soda water solution or specially formulated cleaner Use non abrasive scouring powder for stubborn stains Repainting Your Grill After extended use and exposure to weather paint on grill may change color slightly or become spotted Although this detracts from grill s appearance it will not impair its performance To refinish your grill brush outside of grill lid and bottom with wire brush and lightly sand with fine grit sandpaper Sanding allows new paint to adhere more easily Wash grill lid and bottom with soap and water to remove dust and grease Do not use a grill cleaner on outside of grill Wipe with vinegar Refinish outside with heat resistant paint Do not paint inside of grill Care And Cleaning Of Stainless Steel Routine cleaning is necessary to preserve the
23. appearance and corrosion resistance of Stainless Steel The methods below are suggestions for cleaning stainless steel surfaces Choose a cleaning method appropriate to the requirement If you choose to use scouring powder or solvents consult with the solvent manufacturer or supplier before use Before cleaning first test any cleaning product in an inconspicuous location and consider the possibility of scratching and the potential for corrosion caused by not completely removing cleaners Never use brushes or steel wool as they will scratch and leave particles embedded on stainless steel surfaces which can lead to rusting Always rub or wipe in the direction of the polish lines in the stainless steel surface not across them Thorough rinsing with clean water is recommended after all cleaning procedures Dry all surfaces completely after rinsing Be careful not to let any stainless steel cleaner come in contact with painted or plastic components as damage may occur Routine Care The Char Broil Stainless Steel Grill Cleaner and the Thermos Stainless Steel Grill Cleaner are good choices for routine cleaning of stainless steel surfaces Mild stains and loose dirt and soil can also be removed with a soft cloth and clean warm water Rinse with clean water and wipe dry Stubborn Stains Stubborn stains discoloration and possibly rust and rust pitting can occur from cooking exposure to harsh outdoor conditions or extreme cooking temperatures There
24. are many cleaning agents commercially available formulated to restore the finish of stainless steel Obtain advice from the solvent manufacturer or supplier when choosing the appropriate cleaner for your requirement These cleaners can be acidic Care should be taken to avoid contact with eyes or mouth Be careful not let any powder or solvent come in contact with painted or plastic components as damage may occur The chart below has been reproduced with permission from the Specialty Steel Institute of North America For additional details regarding the care and cleaning of stainless steel visit their website at www ssina com for more information For the latest new products for the care and cleaning of stainless steel go to www charbroil com Job Routine Cleaning Cleaning Agents Warm Water Soap Ammonia Detergent Comments Apply with sponge or soft cloth Can be used on all finishes Fingerprints and Smears 3M Stainless Steel Cleaner and Polish Arcal 20 Lac O Nu Lumin Wash O Cedar Cream Polish Stainless Shine Provides barrier film to minimize fingerprints Can be used on all finishes Stubborn Stains and Discoloration 3M Stainless Steel Cleaner and Polish All chem Concentrated Cleaner Samae Twinkle Cameo Copper Cleaner Grade FFF or Grade F Italian Pumice Whiting or Talc Liquid Nu Steel Copper s or Revere Stainless Steel Cleaner Household Cleaners Lumin Cleaner Zud Restoro Sta Clean Highlite Allen
25. clean and or replace parts of burner assembly or if you have trouble igniting the grill 1 2 3 Turn gas off at control knobs and LP tank Remove cooking grate and V Bar Under grill remove soup can unscrew ignitor button and remove battery on electronic ignition models disconnect short ignitor wire A and clips from burner B To remove clips pull down on large end of clip attached to the valve turn away from valve rotate upward and remove small end of clip from burner tube Inside grill remove burner assembly C clean ceramic portion of electrode with rubbing alcohol and a swab Clean outside of burner with soap and water Lay burner upside down on flat surface insert garden hose to force water through tubes Make sure water comes out of all burner holes Open clogged holes with a thin wire Shake out excess water and examine holes Due to normal wear and corrosion some holes may become enlarged If any large cracks or holes are found replace burner If grill is to be stored coat burner lightly with cooking oil Wrap in protective cover to keep insects out If not storing grill after cleaning replace burner into grill bottom C To reattach clips hold large curved end away from burner tube insert small curved end into hole under burner tubes turn clip towards valve snap into place VERY IMPORTANT Clips must be attached correctly for proper grill function B 9 Reattach ignitor wire to ignitor A Reinstall ba
26. coal tray on pan supports e Rotate grate support wires in the tray into upright positions Fill charcoal tray with one layer of charcoal briquettes e Place warming rack in the upper position on the wire grate supports par N A Use oven mitts during cooking Grill Series 7000 amp 8000 QuickSet Traditional Follow standard lighting instructions to light the grill e Turn both control knobs to HI position Close lid and wait 10 minutes Open lid and continue to heat for 5 to 10 minutes e Turn control knobs to OFF position e Let charcoal briquettes continue to whiten for 10 to 15 minutes Make sure ashes are cool and there are no hot embers prior to storing your grill Do not store grill until coals are cold Use only enough charcoal to cover the bottom of the pan Grill Series 7000 4 briquets wide by 10 long Grill Series 8000 5 briquets wide by 12 long Always light grill using gas Never use lighter fluid kerosene gasoline or alcohol Burning charcoal produces carbon monoxide a toxic odorless fume Carbon monoxide accumulation may cause illness and or death Cooking Chart Cooking times and temperatures may vary according to specific recipes cooking conditions or barbecue equipment used Take these factors into consideration to insure best results If you use the indirect cooking method indirect cooking is lighting only one burner and placing food on opposite side of cooking grate a
27. e in the burner tubes The grill may still light but the obstruction does not allow full gas flow to the burner s IF YOU EXPERIENCE THE FOLLOWING Smell gas Burner s will not light A small yellow flame from burner should be blue Fire coming from around or behind a control knob A CN STOP Immediately turn off gas at LP tank A After a venturi fire you must inspect the hose and do a Leak Test to assure no damage has occurred to the parts SOLUTION Wait for grill to cool Follow the cleaning instructions for your appropriate grill Clean burners often Spiders and insects don t care if your grill is brand new or you just cleaned it We have found in trying to remove web s from the burner tubes a 12 pipe cleaner cleans out the tubes or water from a hose with a nozzle attached Forced water is needed to wash out the web Charcoal Gas Grills Warming Rack If you haven t attached the handles to the grate follow step 1 Handle in correct position J Step 1 Left handle is shown in the correct position between second and third wire from end Hook end of right handle over back and pull to hook over front wire Grate support wires gt e Remove cooking grate s and hang on back of grill using the hanger wire e Remove V bar and place two pan supports into grill bottom Remove warming rack from leg wire and straight wire Rotate leg wire toward back of grill bottom e Place char
28. ed and reheated when necessary Cut bread in half lengthwise Scoop out center of bread so that it looks like a boat Fill bread with hot ratatouille Sprinkle with Basil Parmesan and Mozzarella Place filled breads over low heat Cover grill and cook until cheese is melted and bread is toasted Char Broil Turkey Yield 14 to 16 generous servings or 1 Ib per person Cooking time 25 minutes per pound Method Grill on low 12 to 14 Ib turkey thawed completely vegetable oil 1 large apple quartered 1 quart water 1 1 2 sticks butter 2 stalks celery cut in 2 pieces 1 orange quartered 2 onions cut in large cubes 1 lemon thinly sliced or 4 tbs lemon juice salt and pepper cheesecloth optional Heat grill to medium Wash and rinse turkey removing giblets Dry with absorbent paper Bend wings back behind turkey Season inside of turkey with salt and pepper Rub outside of bird with oil Stuff with onions celery orange and apple Completely fill cavity this gives moisture to the turkey Cover openings of turkey with excess skin Melt butter in a large aluminum foil pan Add turkey water and lemon juice Place on grill and turn heat to low Baste with butter cover top with cheesecloth and baste again Baste every 1 2 hour until done Serve with Giblet Gravy Giblet Gravy 2 to 3 turkey or chicken giblets salt and pepper to taste 3 4 Ibs turkey or chicken fat 1 4 teas Accent 1 4 cup flour dash of thyme 2 cups fat free pan juices
29. f the product THIS EXPRESS WARRANTY IS THE SOLE WARRANTY GIVEN BY THE MANUFACTURER AND IS IN LIEU OF ALL OTHER WARRANTIES EXPRESS OR IMPLIED INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies in addition to or inconsistent with those stated above Manufacturer s maximum liability in any event shall not exceed the purchase price of the product paid by the original consumer purchaser NOTE Some states do not allow an exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you This limited warranty gives you specific legal rights as set forth herein You may also have other rights which vary from state to state In the state of California only if refinishing or replacement of the product is not commercially practicable the retailer selling this product or the Manufacturer will refund the purchase price paid for the product less the amount directly attributable to use by the original consumer purchaser prior to discovery of the nonconformity In addition in the state of California only you may take the product to the retail establishment selling this product in order to obtain performance under this limited warranty If you wish to obtain performance of any obligation under this limited warranty y
30. h the tank and it should not be used on any product Return to supplier Valve Check Important Make sure gas is OFF at LP tank before checking valves Knobs lock in OFF position To check valves first push in knobs and release knobs should spring back If knobs do not spring back replace valve assembly before using grill Turn Knobs to LOW position then turn back to OFF position Valves should turn smoothly Hose Check Before each use check to see if hoses are cut worn or kinked Replace damaged hoses before using grill Use only valve hose regulator specified by manufacturer Normal Kinked Hose Hose Turning Grill Off Turn all knobs to OFF position Turn LP tank OFF by turning hand wheel clockwise to a full stop Ignitor Check Turn gas off at LP tank Press ignitor button or turn ignitor knob rapidly Click should be heard and spark seen each time between collector box or burner and electrode See Troubleshooting if no click or spark For Safe Use Of Your Grill And To Avoid Serious Injury Do not let children operate or play near grill Keep grill area clear and free from materials that burn Do not block holes in bottom or back of grill Check burner flames regularly Usegrillonlyinwell ventilated space NEVERusein enclosedspace suchascarport garage porch covered patio orunderanoverheadstructure of any kind e Donotusecharcoalorceramicbriquetsin a gas gr
31. he Traditional Series Cleaning The Performance and Cleaning The Rotisserie Burner Rotisserie Burner Use Cooking General Grill Cleaning QuickSet and QuickSet Traditional Burner Assembly Advantage Burner Assembly lesser eee Chart and Cooking TIS usate d ba UR ot UR Pra Care And Cleaning Of Stainless Steel oooooooccocccocccono o Natural Hazard Spiders Charcoal Gas Grills Cooking Chart Food Safety naaa How To Tell IF Meat ls Grilled Throughly 4e imas Sox kb you croacia E Storing Your Grill Troubleshooting Troubleshooting Electronic Ignition 5 2 uoo cr a noe wiee VE Rd e Wa Recipes by Chef Christopher Koetke CEC CCE 2 cnet tee eens Recipes www grillregistration com Safety Symbols The symbols and boxes shown below explain what each heading means Read and follow all of the messages found throughout the manual DANGER Indicates an imminently hazardous situation which if not avoided will result in death or serious injury WARNING Indicates a potentially hazardous situation which if not avoided could result in death or serious injury CAUTION Indicates a potentially hazardous situation or unsafe practice which if not avoided may result in minor or moderate injury Warranty Manufacturer warr
32. ill Unless briquets are supplied with your grill Usegrillatleast3ft from any wallorsurface Maintain 10ft clearance toobjectsthatcan catch fireorsources ofignition suchas pilotlights on water heaters liveelectrical appliances etc ApartmentDwellers Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex If allowed use outside on the ground floor with a three 3 foot clearance from walls or rails Do not use on or under balconies NEVER attempt to light burner with lid closed A buildup of non ignited gas inside a closed grill is hazardous Never operate grill with LP tank out of correct position specified in assembly instructions Always close LP tank valve and remove coupling nut before moving LP tank from specified operation position Ignitor Lighting Traditions Series QuickSet and QuickSet Traditional A Do not lean over grill while lighting 1 Open lid during lighting Turn on gas at LP tank 2 Turn LEFT knob to d IGNITE 3 Push Y Piezo Ignitor Button rapidly or hold Electronic Ignition or turn amp Rotary Ignitor Knob up to 5 times to light Be sure burner lights and stays lit 4 If ignition does NOT occur in 5 seconds turn the burner controls OFF wait 5 minutes and repeat the lighting procedure 5 To ignite right burner turn right knob to d 6 If IGNITOR does not work follow match lighting instructions After
33. is attached to the back of the bottom casting above the main grid You can use the burner as a broiler to cook foods on the cooking grates or bonus grid If you do then you cannot use the bottom burner Or you can remove the cooking grates or bonus grid install a rotisserie and use the burner to perfectly roast foods on the split This is the most common use for the burner You cannot use the bottom burner with this process either By not using the lower burner the grease and food drippings won t burn and cause flare ups It s healthier it s fuel efficient and it creates a delicious slow cooked roast beef chicken or veggie kabob on the rotisserie or a beautiful broiled salmon lobster or vegetable medley on the grid Cooking Chart For Rotisserie Burner Chicken Fryer 65 minutes Internal temperature 180 F Turkey Breast 1 hr 30 min Internal temperature 170 F Bone in Cornish Hens 20 oz 1 hr 10 min Internal temperature 180 F Duck 2 hr 15 min Internal temperature 180 F Pork Shoulder 3 25 Ibs 2hr 45 min Place pan of water in bottom of grill Internal temperature 170 F Pork Boston Butt 3 3 lbs 2 hr 45 min Place pan of water in bottom of grill Internal temperature 170 F Pork Tenderloin 1 25 lbs Med 40 min Internal temperature Med 160 F Well 50 min Well 170 F Pork Spareribs 2 75 lbs 1 hr 30 min Place pan of water in bottom of grill Beef Back Ribs Beef Bottom Med rare 1 hr 50
34. is to be stored coat burners lightly with cooking oil Wrap in protective cover to keep insects out If not storing use following steps ao Se ee VERY IMPORTANT Burner tubes must engage valve openings as shown A 9 Attach ignitor wire to electrode Replace battery 10 Reposition cooking grids and vaporizer tents Place clean grease tray and pan into grill bottom 11 Before cooking again on grill perform a Leak Test and Burner Flame Check A Do not use ceramic briquets or charcoal in your grill Cleaning the Performance and Advantage Grease Tray Performance and Advantage Series grills are equipped with a removable grease tray Although grease will drain from the grease tray to the grease cup provided food particles and debris may accumulate in the bottom and should be removed after cooking 5 to 10 times This can easily be done by sliding the grease tray out of the rear of the unit Make sure in replacing the tray to push it all the way forward Handles close to the lid can become hot Lift handle in the middle where it remains cool _ Vaporizer Tents Pal Nuts Carry Over Tube Burner Burner tubes correctly engaged in valves Fa Burner 1 Tube Valve 15 Cleaning The Rotisserie Burner Follow these instructions to clean and or replace parts of burner assembly or if you have trouble igniting the grill 1 Turn gas off at control knobs and LP
35. light turn knob s to OFF wait 5 minutes try again Match Lighting 1 Turn gas on at LP tank 2 Hold lit match to any port on the burner Push in and turn sideburner knob to HIGH Be sure burner lights and stays lit Burner Flame Check Light burner rotate knob s from HIGH to LOW You should see a smaller flame in LOW position than seen on HIGH Always check flame prior to each use Perform flame check on sideburner if equipped If only low flame is seen refer to Sudden drop or low flame in the Troubleshooting Section HIGH LOW 0m gt o WD ou gt ou gt Rotisserie burner only has one setting so flame cannot be checked Before Your First Cookout e Light burners check to make sure they are lit close the lid and warm up grill on HI for 15 minutes Curing of paint and parts will produce an odor only on first lighting CAUTION e Putting out grease fires by closing the lid is not possible Grills are well ventilated for safety reasons e Do not use water on a grease fire Personal injury may result If a grease fire develops turn knobs and LP tank off e Do not leave grill unattended while preheating or burning off food residue on HI If grill has not been regularly cleaned a grease fire can occur that may damage the product 12 Cleaning The Traditional Series QuickSet and QuickSet Traditional Burner Assembly Follow these instructions to
36. llow more grilling time Temperatures High 650 F Medium 450 F Low 300 F Beef Hamburger 1 2 thick Medium Med 7 10 min Well done 10 15 min Steak 1 2 Medium Hot Rare 3 6 min Med 6 9 min Well done 9 12 min Roast Low Rare 18 22min per Ib Med 22 28 min per Ib Well done 28 32 min per Ib Pork Chops 1 2 Medium Well done 15 20 min Ribs 5 6 Ibs Low Medium Well done 45 90 min Roast 3 5 Ibs Low Medium Well done 18 23 min per Ib Ham Steak 1 2 Medium Hot 12 15 min Ham 5 Ib fully cooked Low Medium 20 min per Ib Lamb Chops 1 2 Medium 6 12 min Poultry Chicken 2 1 2 to 3 1 2 lbs Low 1 hr 15 min to 1 hr 30 min Chicken halved or quartered Low 40 60 min Turkey Low Medium 18 20 min per Ib Seafood Steaks 1 thick Medium Hot Well done 10 25 min Fillets 6 8 oz Medium Hot 8 12 min Shrimp large or jumbo Low Medium 8 12 min Venison Steak 1 thick Medium Rare 8 10 min Med 10 12 min Burgers 1 2 Medium Rare 10 12 min Med 12 15 min Roast 3 4 Ibs Low Medium Rare 20 22 min per Ib Med 22 25 min per Ib Vegetables Wrap vegetables in foil Baking Potato whole Low 55 60 min Onions whole Low 45 min Tomatoes half Medium 30 40 min Corn whole Low 35 45 min Mushrooms Medium 15 20 min Food Safety Food safety is a very important part of enjoying the outdoor cooking experience To keep food safe from harmful bacteria follow these four basic steps
37. low above Flare up Grease buildup Clean burners and inside of grill firebox Excessive fat in meat Trim fat from meat before grilling Excessive cooking temperature Adjust lower temperature accordingly Persistent grease fire Grease trapped by food buildup around Turn knobs to OFF Turn gas off at LP tank Leave lid in position and burner system let fire burn out After grill cools remove and clean all parts Flashback Burner and or burner tubes are blocked Turn knobs to OFF Clean burner and or burner tubes See burner fire in burner tube s cleaning section of Use and Care manual Unable to fill LP tank Some dealers have older fill nozzles The worn nozzles don t have enough bite to engage the valve Try with worn threads a second LP dealer One burner does not light from other burner s Grease buildup or food particles in Clean carry over tube s with wire brush end s of carryover tube s Troubleshooting Electronic Ignition Problem Ignition SECTION No sparks appear at any electrodes when ignition button is pushed no noise can be heard from spark module SECTION II No sparks appear at any electrodes when ignition switch is pushed noise can be heard from spark module SECTION III Sparks are present but not at all electrodes and or not at full strength Possible Cause Battery not installed properly Dead battery Button assembly n
38. min Internal temperature Med rare 140 Round Roast Med 2 hrs Med 150 F Well 2 hrs 10 min Well 160 Cooking Tips e f you set a foil pan in the bottom casting right on the burner it will catch any food drippings created by cooking with the Rotisserie Burner You ll have no grease in the grill to clean e If you group different vegetables by the length of time it takes to cook then everything will be done at the same time Check the enclosed food chart for cooking times General Grill Cleaning Keep the outside of your grill looking new by cleaning it once a month with warm soap and water or a non abrasive cleaner If you don t have a grill cover wipe off dust and grime before starting your grill e Coating the cooking grids with spray on cooking oil will keep the food from sticking and make clean up easier After cooking scrape the grates with a long handled brass wire bristle brush e Check inside the grill bottom for grease build up and clean often especially after cooking fatty meat e Do not mistake brown or black accumulation of grease and smoke for paint Interiors of gas grills are not painted at the factory and should never be painted Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom Rinse and allow to completely air dry Do not apply a caustic grill oven cleaner to painted surfaces V
39. ot installed properly Faulty spark module Output lead connections not connected Electrode tip not in proper position Output lead connections not connected Arcing to grill away from burner s Weak battery Electrodes are wet Electrodes cracked or broken sparks at crack Check Procedure Check battery orientation Has battery been used previously Check to ensure button assembly is fully engaged Button should travel up and down without binding f no sparks are generated with new battery and good wire connections module is faulty Are output connections on and tight Are the electrode tips pointing in the right direction Is the gap too big Are output connections on and tight If possible observe grill in dark location Operate ignition system and look for arcing between output wires and grill frame All sparks present but weak or at slow rate Has moisture accumulated on electrode and or in burner ports Inspect electrodes for cracks Prevention Solution Install battery make sure that and connectors are oriented correctly with and end down end up Replace battery with new AAA size alkaline battery Remove button cap assembly and reinstall making sure it can be fully engaged Replace spark module assembly Remove and reconnect all output connections at module and elect
40. ou should write to Consumer Warranty P O Box 1240 Columbus GA 31902 1240 Never fill the cylinder beyond 80 full An overfilled LP tank is hazardous due to possible gas released from the safety relief valve The safety relief valve on the LP tank could activate releasing gas and cause an intense fire with risk of property damage serious injury or death NEVER store a spare LP tank under or near grill or in enclosed areas If you see smell or hear escaping gas immediately get away from the LP tank grill and call your fire department All spare LP tanks must have safety caps installed on the LP tank outlet LP Tank Removal Transport And Storage Turn OFF all control knobs and LP tank valve Turn coupling nut counterclockwise by hand only do not use tools to disconnect Remove attachment holding LP tank then lift up and off support bracket Install safety cap onto LP tank valve Always use cap and strap supplied with valve Failure to use safety cap as directed may result in serious personal injury and or property damage LP Tank Valve Safety Cap Retainer Strap A disconnected LP tank in storage or being transported must have a safety cap installed as shown Do not store an LP tank in enclosed spaces such as a carport garage porch covered patio or other building Never leave an LP tank inside a vehicle which may become overheated by the sun Always keep LP tank in
41. rill 2 Go Grillin Stick Keeper of the Flame Keepers of the Flame Natural Grip Outdoor Cooking Collection and Design Patio Bistro PrecisionFlame Pro Check QuickSet Grills and Design SmokerTents The Big East The Minute Grill The Edge The Tuscan Collection and The Urban Grill are Trademarks of the W C Bradley Company Universal Grill Parts and Design is a trademark of the Thermos Company and its affiliates Protected under one or more of the following U S Patents 4 598 692 4 624 240 4 747 391 4 747 391 4 817 583 4 924 846 4 989 579 5 003 960 5 076 256 5 076 257 5 090 398 5 109 834 5 224 676 5 277 106 5 421 319 5 441 226 5 452 707 5 458 309 5 566 606 5 579 755 5 582 094 5 613 486 5 649 475 5 706 797 5 711 663 5 765 543 5 931 149 5 996 573 6 095 132 6 135 104 6 173 644 6 279 566 6 397 731 6 418 923 6 439 222 6 523 461 6 792 936 D282 619 D339 714 D341 292 D343 337 D358 059 D361 466 D364 535 D372 637 D373 701 D377 735 D383 035 D397 910 D405 643 D405 643 D406 005 D406 009 D413 043 D413 229 D413 229 D414 982 D415 388 D416 164 D416 441 D417 587 D422 516 D423 274 D423 876 D428 303 D435 396 D463 004 D438 059 D438 060 D438 427 D439 110 D442 505 D443 179 D443 354 D447 384 D447 385 D447 909 D448 610 D448 614 D448 615 D448 616 D448 975 D449 492 D451 759 D456 202S D460 313 D461 359 and D477 501 Canada 87743 87744 92607 92608 and 1 3
42. rodes Main Burners Traditional Series QuickSet or QuickSet Traditional Tip of electrode should be pointing toward tip of collector box The distance should be 1 8 to 1 4 Adjust if necessary Performance and Advantage Series Tip of electrode should be pointing toward port hole in burner The distance should be 1 8 to 3 16 Adjust if necessary Sideburner Tip of electrode should be pointing toward gas port opening on burner The distance should be 1 8 to 3 16 Adjust if necessary Remove and reconnect all output connections at module and electrodes If sparks are observed other than from burner s wire insulation may be damaged Replace wires Replace battery with a new AAA size alkaline battery Use paper towel to remove moisture Replace cracked or broken electrodes Recipes by Chef Christopher Koetke CEC CCE Five Spice Grilled Duck Breast with Asian BBQ Sauce Serves 4 4 boneless skinless duck breasts 1 garlic clove minced 2 teas finely grated orange zest 1 1 2 teas five spice mix 1 1 2 teas salt 1 4 teas black pepper Combine garlic orange zest five spice salt and pepper with duck breasts Let marinate in refrigerator for 4 24 hours Grill duck breasts over high heat Turn the breasts and liberally brush Asian BBQ sauce on top Grill until breasts are 150 155 internal temperature While breast are cooking grill green onions over high heat until they begin to soften abou
43. s susceptibles de vous int resser Example your name your host com Ejemplo su nombre su host com Exemple votre nom votre h te com 3 Phone Number N mero telef nico Num ro de t l phone 6 Date of Purchase Fecha de compra Date de l achat IMPORTANT IMPORTANTE IMPORTANT Write Serial Number and Model Number in spaces below Escriba en los espacios de abajo el n mero de serie y el n mero 5 S LI LLLLI 1 Store Name Nombre de la tienda Nom du magasin de modelo Inscrivez le num ro de s rie et le num ro de modele dans les 8 Purchase Price Precio de compra Prix d achat espaces ci dessous d SL I B Your Gender Su sexo Sexe 1 Male Masculino Masculin 2 1 Female Femenino F minin Q Which product are your registering 10 Which of these sources influenced your decision to buy this product check all that apply Qu producto est registrando Cu l de estas fuentes influenci a su decisi n de comprar este producto Marque todas las Quel produit enregistrez vous que correspondan 1 1 Gas Grill Parrilla de gas Parmi les l ments ci dessous qu est ce qui a influenc votre d cision d acheter ce produit Gril au gaz o Cochez tous les l ments s appliquant 2 Electric Grill Parrilla el ctrica 1 1 Magazine newspaper advertisement Propaganda en revista peri dico Gril lectrique Publicit dans un magazine ou dans un
44. t 2 minutes Serve with duck breasts Additional Asian BBQ sauce perhaps thinned with a little water can be served on the side Asian BBQ Sauce Serves 3 4 2 Tbles oyster sauce 6 Tbles hoisin sauce 1 4 teas Tabasco 2 Tbles orange juice 1 teas sesame oil Mix ingredients together until blended Store covered in refrigerator until needed Ratatouille Melts Serves 3 4 2 zucchini diced about 3 cups 1 medium eggplant diced about 4 cups 1 large red pepper diced about 1 1 2 cups 1 large onion finely diced about 1 1 2 cups 4 garlic cloves minced 4 large tomatoes seeded and diced 1 2 to 3 4 cup extra virgin olive oil 1 1 2 teas salt 1 2 teas black pepper 1 3 cup Parmesan cheese 2 cups grated Mozzarella cheese 1 2 cup chopped fresh basil 1 foot long French bread In a large saut pan saut zucchini over high heat in 2 Tbles olive oil Cook until zucchini are lightly browned and softened Set aside in a bowl Saut eggplant over high heat in 3 4 Tbles olive oil until lightly browned and softened Add to bowl In the same saut pan saut red pepper over moderate heat in 2 Tbles olive oil Cook until red peppers are lightly browned and softened Add to bowl Saut onions in 3 Tbles olive oil until translucent add garlic cook 2 more minutes Add zucchini eggplant and red pepper Reduce heat and cook 15 minutes or until all ingredients are very soft Season with salt and pepper At this point ratatouille can be chill
45. t conform to LP Gas Code 4 If odor continues immediately call your NFPA ANSI 58 Grill is not for use in or on gas supplier or your fire department recreational vehicles and or boats e Grill installation must conform with local codes or in their absence with National Fuel Gas Code NFPA All electrical accessories such as rotisserie must be electrically grounded in accordance with local eu E Mons codes or National Electrical Code ANSI NFPA iao 241 Ed yP P 70 or Canadian Electrical Code CSA C22 1 Keep any electrical cords and or fuel supply hoses away from any hot surfaces Business hours Open 24 hours Seven days a week This grill is safety certified for outdoor use in the Toorder non warranty replacement parts or United States and or Canada only Do not modify for accessories grill cover cleaners paint call use in any other location Modification will result in a 1 800 993 2677 or send a FAX to safety hazard 1 706 565 2121 Visit us on the web at www charbroil com To insure your satisfaction Attach receipt here and for follow up service register your grill online at www grillregistration com Important Fill out Warranty information below Warranty Information se WN warnine MN Serial Number ___ CARBON MONOXIDE HAZARD See rating label on grill for serial number g g Burning charcoal releases carbon monoxide Date Purchased which has no odor
46. ttery and ignitor button on electronic ignition models 10 Reposition v bar and cooking grate s Reattach clean can to grease clip 11 Before cooking again on grill perform a Leak Test and Burner Flame Check A Do not use ceramic briquets or charcoal unless a charcoal pan comes with your grill QuickSet Burner Electrode Short Ignitor Wire Remove button and battery on electronic ignition models Cleaning The Performance and Advantage Burner Assembly Follow these instructions to clean and or replace parts of burner assembly or if you have trouble igniting the grill 1 Turn gas off at control knobs and LP tank Remove cooking grids and vaporizer tents Remove two pal nuts carry over tube and burners Under grill remove grease pan and tray Clean with soap and water Disconnect battery and under console disengage ignitor wire Wipe ceramic electrode with rubbing alcohol and cloth Clean carry over tube and burners exterior with soap and water Lay burners on flat surface insert garden hose preferably with nozzle into burner tubes forcing water through tubes Make sure water comes out of every porthole Open clogged portholes with a thin wire Shake out excess water and examine porthole Due to normal wear and corrosion some portholes may become enlarged if so replace burner If any horizontal cracks appear from porthole to porthole or large holes other than portholes are found replace burner 8 If grill
47. turn off gas supply at once Determine the cause correct it then clean and inspect valve hose and regulator before continuing Perform a leak test A The regulator may make a humming or whistling noise during operation This will not affect safety or use of grill A If you have a grill problem see the Troubleshooting Section Leak Testing Valves Hose and Regulator 1 Turn all grill control knob s to OFF 2 Be sure regulator is tightly connected to LP tank 3 Completely open LP tank valve by turning hand wheel counterclockwise If you hear a rushing sound turn gas off immediately There is a major leak at the connection Correct before proceeding 4 Brush soapy solution onto areas where bubbles are shown Sideburner Hose if featured HeatWave Hose if featured A Never remove opening at end of valve Mr r 5 If growing bubbles appear there is a leak Close LP tank valve immediately and re tighten connections If leaks cannot be stopped do not try to repair call for replacement parts Order new parts by giving the serial number model number and name of items needed to the Grill Service Center at 1 800 241 7548 6 Always close LP tank valve after performing leak test by turning hand wheel clockwise 8 Sideburner G Valve If the regulator frosts turn off grill and LP tank valve immediately This indicates a problem wit
48. valves are positioned inside of burner tubes with clips attached if featured Ensure burner tubes are not obstructed with spider webs or other matter See cleaning section of Use and Care manual Make sure LP tank is not empty If LP tank is not empty refer to Sudden drop in gas flow Turn off knobs and disconnect coupling nut from LP tank Reconnect and retry Turn the coupling nut approximately one half to three quarters additional turn until solid stop Tighten by hand only do not use tools Replace electrode s Main Burners Traditional Series QuickSet and QuickSet Series Tip of electrode should be pointing toward tip of collector box The distance should be 1 8 to 1 4 Adjust if necessary Main Burners Performance and Advantage Series Tip of electrode should be pointing toward port hole in burner The distance should be 1 8 to 3 16 Adjust if necessary Sideburner Tip of electrode should be pointing toward gas port opening on burner The distance should be 1 8 to 3 16 Adjust if necessary Clean wire and or electrode with rubbing alcohol and clean swab Reconnect wires or replace electrode wire assembly Replace ignitor wire Replace with a new AAA size alkaline battery Troubleshooting continued Problem Possible Cause Prevention Solution Burner s will not light ELECTRONIC IGNITION using ignitor No spark no ignition noise See Section of Electronic Ignition
Download Pdf Manuals
Related Search