Axor Montreux 16534XX1 User's Manual
Contents
1. Axor Montreux Wall Mounted Widespread Lavatory Set 16532XX1 Cross handles 16534XX1 Lever handles 4 4 D a2 vr 7 a2 dA fe 2 Si 5 co x 27 8 6 8 _ 6 2 87 gt 7 9 7 a 16532XX1 16534XX1 Technical Information Recommended water pressure 14 7 72 5 psi Max water pressure 147 psi Recommended hot water temp 120 140 F Max hot water temp 176 F Flow rate 2 2 gpm Please know and follow all applicable local plumbing codes when setting the temperature on the water heater Installation Considerations e For best results Hansgrohe recommends that this unit be installed by a licensed professional plumber e Please read over these instructions thoroughly before beginning installation Make sure that you have all tools and supplies needed to complete the installation e Rough 10303181 must be installed and the wall surface completed and made watertight before installation of this trim kit Installation Make sure that the water is turned off at the main before beginning Remove the caps from the plaster shields Cut the plaster shields so that they extend 1 16 outside the wall A Seal the wall around the plaster shields with waterproof sealant Failure to seal the wall can lead to possible water damage Model 16534XX1 only Remove the cartridges Install the new cartridges included with the trim The new hot cartridge is marked with notches on the w2. such as unsuitable cleaning powders sponge pads or micro fiber cloths Cleaning Instructions for Faucets and Showers Please follow the cleaning material manufacturer s instructions In addition pay attention to the following points e Clean the faucets and showers as and when required e Use the amount of cleaning product and the amount of time recommended by the manufacturer Do not leave the cleaner on the fixture longer than necessary e Regular cleaning can prevent calcification e When using spray cleaners spray first onto a soft cloth or sponge Never spray directly onto the faucet as droplets can enter openings and gaps and cause damage e After cleaning rinse thoroughly with clean water to remove any cleaner residue Important Residues of liquid soaps shampoos and shower foams can also cause damage so rinse with clean water after using Please note if the surface is already damaged the effect of cleaning materials will cause further damage Components with damaged surfaces must be replaced or injury could result Damage caused by improper treatment is not covered under the warranty Limited Lifetime Consumer Warranty This product has been manufactured and tested to the highest quality standards by Hansgrohe Inc Hansgrohe This warranty is limited to Hansgrohe products which are purchased by a consumer in the United States after March 1 1996 and installed in either the United States or Canada WHO IS
3. performance of your Hansgrohe product or this warranty please call or write to us or call us toll free at 800 334 0455 ansgrone Hansgrohe Inc e 1490 Bluegrass Lakes Parkway Alpharetta GA 30004 Tel 770 360 9880 Fax 770 360 9887 www hansgrohe usa com US Installation Instructions Part No 90595623 Revised 04 2008
4. turn the water on clockwise for hot counter clockwise for cold Turn the handle downward to turn the water off In the off position the handles should be paral lel to the floor Replacement Parts cross handle screw cover for cold hot water flange for handle flange for spout aerator cpl fixing set extension kit 1 optional spout lever handle hot cartridge 16534XX1 only cold cartridge 16534XX1 only Colors chrome brushed nickel polished nickel 16291XX0 97987000 98578XX0 98576XX0 98583XX0 96392000 96259000 98574XX0 16991XX0 96351000 96350000 Cleaning Recommendation for Hansgrohe Products Modern lavatory faucets kitchen faucets and showers consist of very different materials to comply with the needs of the market with regard to design and functionality To avoid damage and returns it is necessary to consider certain criteria when cleaning Cleaning Materials for Faucets and Showers Acids are a necessary ingredient of cleaning materials for removing lime however please pay attention to the following points when cleaning faucets and showers e Only use cleaning materials which are explicitly intended for this type of application e Never use cleaning materials which contain hydrochloric formic phosphoric or acetic acid as they cause considerable damage e Never mix one cleaning material with another e Never use cleaning materials or appliances with an abrasive effect
5. COVERED BY THE WARRANTY This warranty extends to the original consumer purchaser only This warranty is non transferable WHAT IS COVERED BY THE WARRANTY This warranty covers only your Hansgrohe manufactured product Hansgrohe warrants this product against defects in material or workmanship as follows Hansgrohe will repair at no charge for parts only or at its option replace any product or part of the product that proves defective because of improper workmanship and or material under normal installation use service and maintenance If Hansgrohe is unable to provide a replacement and repair is not practical or cannot be timely made Hansgrohe may elect to refund the purchase price in exchange for the return of the product LENGTH OF WARRANTY Replacement or repaired parts of products will be covered for the term of this warranty as stated in the following two sentenc es If you are a consumer who purchased the product for use primarily for personal family or household purposes this war ranty extends for as long as you own the product and the home in which the product is originally installed If you purchased the product for use primarily for any other purpose including without limitation a commercial purpose this warranty extends only i for 1 year with respect to Hansgrohe and Commercial products and ii for 5 years with respect to AXOR products THIS WARRANTY DOES NOT COVER AND HANSGROHE WILL NOT PAY FOR A Conditions malfunctio
6. e When warranty service is completed any repaired or replacement product or part will be returned to you postage prepaid EXCLUSIONS AND LIMITATIONS REPAIR OR REPLACEMENT OR IN LIMITED CIRCUMSTANCES REFUND OF THE PURCHASE PRICE AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER HANSGROHE NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY OBLIGATION OR LIABILITY IN CONNECTION WITH THIS PRODUCT HANSGROHE SHALL NOT BE LIABLE TO PURCHASER OR ANY PERSON FOR ANY INCIDENTAL SPECIAL OR CONSE QUENTIAL DAMAGES ARISING OUT OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY INCLUDING MERCHANTABILITY 10 Some States do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclu sion may not apply to you This warranty gives you specific legal rights and you may have other rights which vary from State to State You may be required by law to give us a reasonable opportunity to correct or cure any failure to comply before you can bring any action in court against us under the Magnuson Moss Warranty Act PRODUCT INSTRUCTIONS AND QUESTIONS Upon purchase or prior to installation please carefully inspect your Hansgrohe product for any damage or visible defect Prior to installing always carefully study the enclosed instructions on the proper installation and the care and maintenance of the product If you have questions at any time about the use installation or
7. ns or damage not resulting from defects in material or workmanship B Conditions malfunctions or damage resulting from 1 normal wear and tear improper installation improper mainte nance misuse abuse negligence accident or alteration or 2 the use of abrasive or caustic cleaning agents or no rinse cleaning products or the use of the product in any manner contrary to the product instructions 3 Conditions in the home such as excessive water pressure or corrosion C Labor or other expenses for the disconnection deinstallation or return of the product for warranty service or for installa tion or reinstallation of the product including but not limited to proper packaging and shipping costs or for installation or reinstallation of the product D Accessories connected materials and products or related products not manufactured by Hansgrohe TO OBTAIN WARRANTY PARTS OR INFORMATION Contact your Hansgrohe retailer or contact Technical Service at Hansgrohe Inc 1492 Bluegrass Lakes Parkway Alpharetta GA 30004 Toll free 800 334 0455 In requesting warranty service you will need to provide 1 The sales receipt or other evidence of the date and place of purchase 2 A description of the problem 3 Delivery of the product or the defective part postage prepaid and carefully packed and insured to Hansgrohe Inc 1492 Bluegrass Lakes Parkway Alpharetta Georgia 30004 Attention Technical Service if required by Hansgroh
8. rench flats All models Install the extension spindles 1 Cut them so that they extend 9 16 outside the surface of the wall 2 Remove the plug from the spout housing 3 Install the slip couplings 1 Cut the slip couplings so that they extend 1 5 16 outside the surface of the wall 2 Measure the distance between the front of the spout hous ing and the surface of the wall Record this measurement x Add 9 16 to X Record this measurement Cut the threaded end of the spout so that it extends 9 16 X from the rear of the flange Remove the aerator 1 Wrap the threads on the spout with Teflon tape Install the sealing ring and spout Use a rod or dowel inserted into the end of the spout fo assist in tightening it 2 A Do not overtighten the spout or damage may result Tighten the spout flange against the wall 1 Install the aerator 2 Push the sealing ring and handle over the rough Rotate the handle flange clockwise so that it threads down over the extension spindle 3 Model 16532XX1 only Install the screw covers Model 16534XX1 only Both levers should be parallel to the floor If one is not remove the slip coupling 1 turn it slightly 2 and reinstall it Install the screw covers 3 It is also possible to remove the lever turn it slightly and reinstall it Install the screw covers 3 User Instructions Turn the handle upward to
Download Pdf Manuals
Related Search