Avalon Stoves 21 TRV User's Manual
Contents
1. for Thick Facin The 21 TRV has a sliding heat shield that must be properly positioned when using thick facing See the directions below for adjusting the heat shield Loosen these two nuts above Slide the heat shield forward until it is flush with the firebox 3 8 wrench the facing and tighten the nuts to secure Face Installation and Removal Face Attachment The upper slots have a spring tensioned lever that catches the small teeth on the brackets Lip Pull the bottom of the face out then disengage the face from the frieplace i Loosen the lower screws Once the face is in place o open the access door and tighten this screw 5 16 wrench This locks the face in place 1a Page 4 of 4 TRROUSE OF FIRE Printed April 16 20082. Avalon Hideaway Bungalow Face 5700121 COMPATIBILITY PACKING LIST e Avalon Hideaway Fireplace e Face includes Backing Plate and Doors e 2 Handles e 4 8 32 x 1 2 Screws e Push On Face Brackets for 21 TRV Only INSTALLATION INSTRUCTIONS NOTE If installing with thick facing or retrofitting tile follow the directions for Push On face brackets on page 3 Turn off gas to the appliance and make sure it has fully cooled prior to conducting service 1 Remove the doors from the backing plate Install the backing plate as shown in the illustration below Lift and rotate the backing plate forward until the top brackets lock into the upper slots Backing Plate q yo 35 3 8 Tilt the backing plate back and cy insert the bottom brackets into the lower slots until they lock in place Access Door for accessing controls Page 1 of 4 TRROUSE OF FIRE Printed April 16 2008 Avalon Hideaway Bungalow Face _ 5700121 2 Hang the left and right doors on the backing plate Attach the handles and verify magnet position if applicable Page 2 of 4 A VW A Hold each door at a 90 angle to the backing plate and hang in l S place I Aa Attach the handles to the doors with the included screws Verify the magnets are in the correct position on bot
3. h doors with the felt facing outwards contacting the face 1a TRHOUSE OF FIRE Printed April 16 2008 Avalon Hideaway Bungalow Face _ 5700121 PUSH ON FACE BRACKETS NOTE The push on brackets are only compatible with the 21 TRV 2008 or later Overview The optional push on brackets allow the face to be installed up to 1 from the front of the fireplace In addition the new brackets allow the face to be installed straight on to the fireplace This permits the use of thick facing material directly above the face no gap is required to slide the face into place Tile Retrofit Installations Ifa 21 TRV is already installed into a standard drywall installation with the standard brackets it is extremely difficult to install tile behind face this requires the fireplace location to be moved forward With the new push on brackets the face may be located up to 1 from the front of the fireplace allowing tile or other non combustible to be placed behind the face Bracket Installation Remove the stock brackets and install the push on brackets to the back of the face following the directions below The upper brackets are installed with the notch facing to the left this insures the brackets are installed right side up o g a DA S Note how the lower K brackets angle inwards 1a Page 3 of 4 TRHOUSE OF FIRE Printed April 16 2008 Avalon Hideaway Bungalow Face _ 5700121 Preparing the Fireplace
Download Pdf Manuals
Related Search