Autonet K6860631 User's Manual
Contents
1. Routan PROCEDURE STEPS WIFI Router MINIVAN NOTE Using a test light verify the keyed power outlet being used is ignition switched Power must not be present with the ignition in the OFF position 1 Move the passenger seat to the full rearward position 2 Disconnect the negative battery cable 3 Remove the four fasteners 2 on both sides of the stor age bin 4 Carefully disengage the two spring clips from the top center of the bin and pull the lower bin towards the rear of the vehicle 5 Route the Wi Fi power harness 1 under the carpet from the passenger seat to the instrument panel stor age bin 2 K6860631 Rev 1 6 Secure the Wi Fi Router under the passenger seat 1 with the supplied tie straps and Velcro tape 3 7 Connect the power harness connector 2 to the Wi Fi router NOTE Do not use the power outlet for the power supply to the Wi Fi router 8 Locate the keyed power outlet wiring harness 9 Cut each wire and remove 13 mm 0 5 in of insula tion from each wire that needs to be soldered spliced 10 Place a piece of supplied adhesive lined heat shrink tubing on one side of each cut wire Insure the tubing will be long enough to cover and seal the entire sol dered area CAUTION Do not use acid core solder 11 Solder the supplied fused pigtail to Wi Fi power har ness power wire 12 Place the strands of the power side wires overlapping each other inside of the s2. plice clip 1 along with the red fuse holder wire 2 K6860631 Rev 1 March 2A ONNA 13 Using crimping tool crimp the splice clip and wires together 14 Repeat the previous two steps for the ground side wires 15 Solder 3 the connection 2 together using rosin core solder 1 16 Center the heat shrink tubing 2 over the solder joint and heat using a heat gun Heat the joint until the tub ing is tightly sealed and sealant 1 comes out of both ends of the tubing March 15 2009 TIGI814 K6860631 Rev 1 17 Position lower bin into place and connect the elec trical connectors 18 Seat the storage bin and engage the spring clip retain ers 19 Install the four fasteners 4 on both sides of the stor age bin 20 Connect the negative battery cable 21 Verify system operation March 24 2009
Download Pdf Manuals
Related Search