APW Wyott W-3V User's Manual
Contents
1. 230 volt 4 8 amp Operations Follow General Operating Instructions on previous page Add hot water 120 140 to well pan W 3V use 4 quarts 1 gallon 4 liter Turn infinite control to HI position and preheat for approximately 10 minutes Place covered inset with preheated food product into well Re adjust control to 2 4 setting depending on the amount and or thickness of product Keep inset steamtable pan s covered to maintain ideal serving temperature EOD M Cleaning Daily Cleaning 1 Refrigerate remaining product 2 Follow General Cleaning Instructions on previous page SERVICE INFORMATION IF A SHORTAGE OR A PROBLEM CALL in the USA 1 888 279 7493 PLEASE FOLLOW THESE INSTRUCTIONS A ON ALL CALLS YOU WILL NEED TO GIVE THE FOLLOWING INFORMATION Name and title of person calling Phone number of person calling Business name Street address City State Zip Model Number from serial plate Serial Number from serial plate ONOARWN old you will be asked to supply proof of purchase 9 Purchased from Date purchased if serial number indicates date of manufacture is over 13 months B FOR SHORTAGE SUPPLY THE ABOVE INFORMATION AND FULLY EXPLAIN WHAT IS MISSING It will be sent immediately prepaid via UPS or equivalent Next Day Air or Priority shipments available at customer s expense C FOR EQUIPMENT PROBLEM IF WITHIN ONE YEAR FROM DATE OF PURCHASE THIS UNIT FAILS TO FUNCTION Y2. INSTALLATION AND OPERATING INSTRUCTIONS COUNTERTOP FULL SIZE 12 x 20 WARMER Model W 3V 22 Qt Capacity E Y P N 67225 5 06 Phone 214 421 7366 Fax e CEI 565 0976 Toll Free 41 800 527 2100 APW WYOTT Website www apwwyott com 729 Third Avenue E mail info apwwyott com Dallas TX 75226 TABLE OF CONTENTS Owner s Information 2 Installation Elec 3 General Installation 2 Operations Cleaning 3 General Operating Instructions 2 _ Service Information 3 4 General Cleaning Instructions 2 Wiring Diagram 4 General Troubleshooting 2 Parts List w Exploded View 5 Specifications 3 Warranty 7 OWNER S INFORMATION General Installation 1 2 3 Always clean equipment thoroughly before first use See general cleaning instructions Check rating label for your model designation amp electrical rating Locate equipment on level counter and plug into a grounded outlet so that the plug is accessible See individual description for electrical loads On units bearing the CE marking the appliance must be connected by an earthing cable to all other units in the complete installation and hence to an independent earth connection General Operating Instructions All foodservice equipment should be operated by trained personnel Do not allow your customers to come in contact with any surface labeled CAUTION HOT Where applicable do not cook warm or hold food directly in liner pans well pans Always use ste
3. OU ARE ENTITLED TO YOUR CHOICE 1 2 or 3 1 APW Wyottwill replace the unit When calling the factory besides the above information you will need Electrical Characteristics voltage and phase describe the problems the best you can The factory will require a Visa or Master Card number and expiration date of same to assure return and or validity of condition Upon validation of credit card information factory will strive to ship a replacement unit the same day if call is received before 3 00 p m Central Time or the next day if later The replacement unit will be shipped prepaid regular UPS or equivalent If requested Next Day Air or Priority shipment will be made at customers expense Upon receipt it is the customers responsibility to unpack the new unit taking care to preserve the packaging Repack the unit being 3 replaced in the same container using caution to pack properly and return this unit to the factory following the instructions supplied Factory will supply return label and UPS call tag both must be used If original unit is returned within 30 days and is as represented the credit card validation will be cancelled IMPORTANT If factory does not receive the unit to be returned within 30 days the unit will be billed to the credit card number supplied If the returned unit is not as represented i e out of warranty customer abuse then it will be billed to the credit card number supplied In these cases the person calling in
4. WARRANTIES EXPRESSED OR IMPLIED INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES AND CONSTITUTES THE ENTIRE LIABILITY OF APW WYOTT IN NO EVENT DOES THE LIMITED WARRANTY EXTEND BEYOND THE TERMS STATED HEREIN zz Z N NN IN SI gt ZZ ZZ WINANS RYM HYNY AN N XXI ry tH ISIS Ses gt SS Phone 1 214 421 7366 Fax 1 214 565 0976 Toll Free 1 800 527 2100 APW WYOTT Website www apwwyott com 729 Third Avenue E mail info apwwyott com Dallas TX 75226
5. am table pans insets etc Never hold food below 150 F 66 C General Cleaning Instructions 1 2 NEVER clean any electrical unit by immersing it in water Unplug unit before surface cleaning NEVER POUR COLD WATER INTO DRY HEATED UNITS Always clean equipment thoroughly before first use Clean unit daily Except where noted on charts Use warm soapy water Mild cleansers amp PLASTIC scouring pads may be used to remove baked on food amp water scale Unplug all units before cleaning or servicing All service should be performed by an APW authorized service agency Do not use chlorides or chloride based products in this unit Always clean equipment before first use Clean unit daily Use warm soapy water Rinse thoroughly to remove all residue Chlorides chloride based products and improper cleaning may cause corrosion and pitting FAILURE TO COMPLY WITH THESE INSTRUCTIONS MAY VOID UNIT WARRANTY GENERAL TROUBLESHOOTING Always ask amp check Pons Is the unit plugged in Check circuit breaker Is power switch on amp pilot light glowing Check rating label Are you operating unit on proper voltage If the supply cord is damaged it should only be replaced by an identical supply cord If the above checks out and you still have problems call an APW authorized service agency SPECIFICATIONS Installation Follow General Instructions on previous page W 3V 22dt 120 volt outlet 10 amp load or
6. elivery or installation fire flood riot or act of god Equipment that has the model number or serial number removed or altered If the equipment has been changed altered modified or repaired by other than an Authorized Service Agency during or after the warranty period then the manufacturer shall not be liable for any damages to any person or to any property which may result from the use of the equipment thereafter This warranty does not cover services performed at overtime or premium labor rates Should service be required at times which normally involve overtime or premium labor rates the owner shall be charged for the difference between normal service rates and such premium rates APW Wyott does not assume any liability for extended delays in replacing or repairing any items beyond its control Inall cases the use of other than APW Wyott Authorized OEM Replacement Parts will void this warranty This equipment is intended for commercial use only Warranty is void if equipment is installed in other than commercial application Water Quality Requirements Water supply intended for a unit that has in excess of 3 0 grains of hardness per gallon GPG must be treated or softened before being used Water containing over 3 0 GPG will decrease the efficiency and reduce the operation life of the unit Note Product failure caused by liming or sediment buildup is not covered under warranty THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL OTHER
7. nfinite Control US Knob Infinite Control CE Infinite Control 120V Infinite Control 240V Indicator Light Amber Indicator Light Green Limiting Thermostat Strain Relief Bushing US DESCRIPTION Strain Relief Bushing CE P ower Cord 120V US Power Cord 230V Cont Europe CE J iffy Clip Set Screw Wire Nut Rubber FootAssembly Insulation 6 32 KEPS Nut 8 X 1 2 Sheet Metal Screw 10 24 Green Hex Nut 10 24 Speed Nut 10 24 Hex Nut 10 Ext Lockwasher N S NOT SHOWN Notes h h LACAN ZN AN GER GE FR WDD DL Fa APW WYOTT EOUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it s equipment against defects in materials and workmanship subject to the following conditions OZ ZEN AL VE CLE Y N This warranty applies to the original owner only and is not assignable Should any product fail to function in its intended manner under normal use within the limits defined in this warranty at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency APW Wyott will only be responsible for charges incurred or service performed by its Authorized Service Agencies The use of other than APW Wyott Authorized Service Agencies will void this warranty and APW Wyott will not be responsible for such work or any charges associated with same The closest APW Wyott Authorized Service Agent must be used This warranty covers products shipped into the 48 contiguou
8. s United States Hawaii metropolitan areas of Alaska and Canada There will be no labor coverage for equipment located on any island not connected by roadway to the mainland Warranty coverage on products used outside the 48 contiguous United States Hawaii and metropolitan areas of Alaska and Canada may vary Contact the international APW Wyott distributor dealer or service agency for details Time Period One year for parts and one year for labor effective from the date of purchase by the original owner The Authorized Service Agency may at their option require proof of purchase Parts replaced under this warranty are warranted for the un expired portion of the original product warranty only Exceptions Gas Electric Cookline Models GCB GCRB GF GGM GGT CHP H EF EG EHP Three 3 Year Warranty on all component parts except switches and thermostats 2 additional years on parts only No labor on second or third year Broiler Briquettes Rock Grates Cooking Grates Burner Shields Fireboxes 90 Day Material Only No Labor Heat Strips Models FD FDL FDD FDDL Two 2 Year Warranty on element only No labor second year Glass Windows Doors Seals Rubber Seals Light Bulbs 90 Day Material Only No Labor Inall cases parts covered by extended warranty will be shipped FOB the factory after the first year Portable Carry In Products Equipment weighing over 70 pounds or permanently installed will be serviced on site as per the
9. terms of this warranty Equipment weighing 70 pounds or under and which is not permanently installed i e with cord and plug is considered portable and is subject to the following warranty handling limitations If portable equipment fails to operate in its intended manner on the first day of connection or use at APW Wyott s option or its Authorized Service Agency it will be serviced on site or replaced From day two through the conclusion of this warranty period portable units must be taken to or sent prepaid to the APW Wyott Authorized Service Agency for in warranty repairs No mileage or travel charges are allowed on portable units after the first day of use If the customer wants on site service they may receive same by paying the travel and mileage charges Exceptions to this rule 1 countertop warmers and cookers which are covered under the Enhanced Warranty Program and 2 toasters or rollergrills which have in store service Exclusions The following conditions are not covered by warranty Equipment failure relating to improper installation improper utility connection or supply and problems due to ventilation Equipment that has not been properly maintained calibration of controls adjustments damage from improper cleaning and water damage to controls Equipment that has not been used in an appropriate manner or has been subject to misuse or misapplication neglect abuse accident alteration negligence damage during transit d
10. the problem will be contacted and if applicable the returned unit if charged for will be returned to the original owner if requested 2 You may take this unit to the APW Wyott Authorized Service Distributor List of same is included with each product If the problem is covered under warranty the unit will be repaired at no cost to you If the Authorized Agency cannot repair same within a reasonable time while you wait it will be returned to you prepaid via UPS 3 You can request the Authorized Service Distributor to service the equipment on site If problem is covered under the warranty the parts and labor will be billed to the factory the mileage and travel time will be responsibility of the owner THIS REPLACEMENT WARRANTY IS ONLY AVAILABLE ON SELECTED PRODUCTS SHIPPED WITHIN THE CONTINENTAL USA ALASKA HAWAII AND CANADA AS WITH MOST WARRANTIES WARRANTY IS ONLY VALID TO THE ORIGINAL END USER OWNER INSTRUCTIONS AND PROCEDURES MUST BE FOLLOWED OR THE WARRANTY IS VOID W 3V COUNTER TOP WARMER WIRING DIAGRAM Robert Shaw EGO Infinite Control Indicator Light Heating Element Heating Element EGO Infinite Control Limiting Thermostat W 3V COUNTER TOP WARMER PARTS LIST w EXPLODED VIEW P N 54815 54813 54816 56506 55446 55440 55825 55826 55564 EGO 87053 EGO 56530 56633 69106 89101 DESCRIPTION P N Pan Assembly Wrapper Assembly Bottom Cover Reflector Pan Element 120V 1200W Element 240V 1200W Knob I
Download Pdf Manuals
Related Search