APW Wyott HFW-23 User's Manual
Contents
1. EXPLODED VIEWS b Dry Set Up Units w o drains 2 WIRING DIAGRAMS eee 8 General Cleaning Instructions RULIOAT 11 OWNER S INFORMATION General Installation 1 2 3 4 Always clean equipment thoroughly before first use See general cleaning instructions Check rating label for your model designation amp electrical rating For best results use stainless steel countertops All dimensions in parenthesis in centimeters unless noted General Operating Instructions 5 All food service equipment should be operated by trained personnel Do not allow your customers to come in contact with any surface labeled CAUTION HOT Where applicable Never pour cold water into dry heated units Where applicable do not cook warm or hold food directly in liner pans well pans Always use steam table pans insets etc Never hold food below 150 F 66 Wet set up and operation procedures units with drains 1 Add hot water 120 140 F 50 60 C to well pan Four Thirds size units 12x27 use 5 1 2 qts 1 1 3 gallon 5 5 litre Full size units 12x20 use 3 3 4 gts 15 cups 3 5 litre Two Thirds size units use 2 1 2qts 10 cups 2 5 litre Half size units use 1 1 2 gts 6 cups 1 5 litre One Third size units use 3 cups 7 litre 4 Quart Round use 2 cups 5 litre 7 Quart Round use 3 cups 7 litre 11 Quart2. 2 182 8 23 7 8 x 15 7 8 HFW 1 4 3 x 4 3 from Stainless Capillary 60 6 x 40 3 back right corner 11 2 3 8 Effective 2 3 Size HFW 23D long Length 16 5 8 x 15 7 8 HFW 23 62 157 5 42 2 x 40 3 1 2 Size HFW 12D 13 5 8 x 15 7 8 HFW 12 34 6 x 40 3 ELECTRICAL SPECIFICATIONS Description Rating at 120VAC 1PH Rating at 208VAC 1PH Rating at 208 240VAC 1PH 1500 Watts 12 5 Amps 1660 Watts 7 7 Amps 1200 1600 Watts 5 7 6 7 Amps 800 Watts 6 7 Amps 800 Watts 6 7 Amps 500 660 Watts 2 4 2 8 Amps INSTALLATION Installation il 2 3 4 5 Follow applicable General Installation Instructions on page 2 Make applicable Cut Out per above table CONNECTION NOTE Unit is designed for installation in stainless steel tops Optional wood mounting kit available Apply putty tape Provided to the underside perimeter of the well rim outer edge Apply a 1 4 6 cm bead of silicone sealant adjacentto the putty tape on the well flange Drop well into opening from the top and push down until entire parameter of rim is flush with the counter surface From below the counter surface insert an 8 to 10 20 cm to 25 cm flat tip screwdriver into the locking ring tab slots and twist in a clockwise motion to lock well in place Trim excess putty and sealantfrom around well rim Mount control to front panel using hardware Maintain 4 clearance between well and front panel Connect power Check power Check namep
3. D FDL FDD FDDL Two 2 YearWarranty on element only No labor second year Glass Windows Doors Seals Rubber Seals Light Bulbs 90 Day Material Only No Labor Inall cases parts covered by extended warranty will be shipped FOB the factory after the first year Portable Carry In Products Equipment weighing over 70 pounds or permanently installed will be serviced on site as per the terms of this warranty Equipment weighing 70 pounds or under and which is not permanently installed i e with cord and plug is considered portable and is subject to the following warranty handling limitations If portable equipment fails to operate in its intended manner on the first day of connection or use at APW Wyott s option or its Authorized Service Agency it will be serviced on site or replaced 7 1 Ly 22 ZZ AH 7 AE q d 7 72 ZZ 77 Nu a By SED From day two through the conclusion of this warranty period portable units must be taken to or sent prepaid to the APW Wyott Authorized Service Agency for in warranty repairs No mileage or travel charges are allowed on portable units after the first day of use If the customer wants on site service they may receive same by paying the travel and mileage charges Exceptions to this rule 1 countertop warmers and cookers which are covered under the Enhanced Warranty Program and 2 toasters or rollergrills which have instore service NN Exclusions The following conditions are not cover
4. Round use 1 1 4 gts 5 cups 1 4 litre Turn the thermostat control to 10 setting or if equipped with infinite controls to or Hi Preheat for approximately 30 minutes Place covered inset with preheated product into well Re adjust control after another 30 minutes of operation to the 6 setting depending on the amount and thickness of product Keep inset steamtable pan s covered to maintain ideal serving temperature Do notlet well run dry Dry set up and operation procedures units without drains 1 Turn the thermostat control to 10 setting or if equipped with infinite controls to 7 or Hi Preheat for approximately 30 minutes Place covered inset with preheated product into well Re adjust control after another 30 minutes of operation to the 6 setting depending on the amount and thickness of product Keep inset steamtable pan s covered to maintain ideal serving temperature General Cleaning Instructions 1 NEVER clean any electrical unit by immersing it in water Turn off before surface cleaning 2 Always clean equipment thoroughly before first use Clean unit daily Use warm soapy water except where noted on charts Mild cleansers and PLASTIC scouring pads may be used to remove baked on food and water scale 3 Turn off electrical units before cleaning or servicing All service should be performed by an APW Wyott authorized service agency General Troubleshooting 1 Istheunit connected to alive power sou
5. a a D INSTALLATION AND OPERATING INSTRUCTIONS Models HFW 1 1D HFW 23 23D HFW 12 12D HOT FOOD WELLS TOP MOUNT INSULATED INTENDED FOR OTHER THAN HOUSEHOLD USE RETAIN THIS MANUAL FOR FUTURE REFERENCE UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES WARNING Improper installation adjustment alteration service or maintenance can A cause property damage injury or death Read the Installation Operating and Maintenance Instructions thoroughly before installing or servicing this equipment Initial heating of unit may generate smoke or fumes and must be done in a well ventilated area Overexposure to smoke or fumes may cause nausea or dizziness This equipment has been engineered to provide you with year round dependable service when used according to the instructions in this manual and standard commercial kitchen practices SANITATION uy c UL Jus qp P N 79967144 6 06 Phone 1 214 421 7366 Fax 1 214 565 0976 Toll Free 1 800 527 2100 APW WYOTT Website www apwwyott com 729 Third Avenue E mail info apwwyott com Dallas TX 75226 CONTENTS OWNER S 2 General Troubleshooting 3 General Installation 2 JSPECIFICATIGOINS uud 3 General Operating Instructions 2 INSTALLATION ua 4 Wet Set Up Units w drains 2 PARTS LISTS w
6. d if equipment is installed in other than commercial application Water Quality Requirements Water supply intended for a unit that has in excess of 3 0 grains of hardness per gallon GPG must be treated or softened before being used Water containing over 3 0 GPG will decrease the efficiency and reduce the operation life of the unit Note Product failure caused by liming or sediment buildup is not covered under warranty THE FOREGOING WARRANTY IS IN LIEU OF ANY ANDALL OTHER WARRANTIES EXPRESSED OR IMPLIED INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES AND CONSTITUTES THE ENTIRE LIABILITY OFAPW WYOTT IN NO EVENT DOES THE LIMITED WARRANTY EXTEND BEYONDTHE TERMSSTATED HEREIN i Weer ZA NIS 27 NN SSS lt 222 SS 7 ps p Zf A 22 77 iN IN SSSSS 2222 II 22 S gt s 222 ZZ ZZ LE SSS ez SS os OSZT 05622 t Y Phone Fax Toll Free Website E mail a 1 214 421 7366 1 214 565 0976 1 800 527 2100 www apwwyott com info apwwyott com APW WYOTT 729 Third Avenue Dallas TX 75226
7. ed by warranty Equipment failure relating to improper installation improper utility connection or supply and problems due to ventilation Equipment that has not been properly maintained calibration of controls adjustments damage from improper cleaning and water damage to controls Equipment that has not been used in an appropriate manner or has been subject to misuse or misapplication neglect abuse accident alteration negligence damage during transit delivery or installation fire flood riot or act of god Equipment that has the model number or serial number removed or altered Tf the equipment has been changed altered modified or repaired by other than an Authorized Service Agency during or after the warranty period then the manufacturer shall not be liable for any damages to any person or to any property which may result from the use of the equipment thereafter This warranty does not cover services performed at overtime or premium labor rates Should service be required at times which normally involve overtime or premium labor rates the owner shall be charged for the difference between normal service rates and such premium rates APW Wyott does not assume any liability for extended delays in replacing or repairing any items beyondits control NN Y D Inall cases the use of other than APW Wyott Authorized OEM Replacement Parts will void this warranty This equipment is intended for commercial use only Warranty is voi
8. iner Heat Transfer P late Wire Set Perma Gum Package 105 iffy Clip Infinite Control Plate Parts Not Shown 10 24 Hex Nut 5 16 X 3 4 X 1 16 Flat Washer 10 Flat Washer 310 24 Green Hex Nut Ground 38 X 1 2 Hex Sheet Metal Screw 310 External Lockwasher P N VOLTS WATTS HFW 12D 56435 120V 800W HFW 12 56439 120V 800W FOR 72 THERMOSTAT ADD SUFFIX 72 TO MODEL amp P N FOR UL KIT ADD SUFFIX 36UL OR 72UL TO MODEL amp P N Item P N m CO C Ui amp CO HFW 23 23D PARTS LIST amp EXPLODED VIEW Description Pan amp Wrapper W Drain Pan amp Wrapper No Drain Insulation Element Cover Element Clamp Anti Rotation Clamp Heating Element 120V 800W Control Housing Increase Decrease Plate Cap Bulb Thermostat Models Only Indicator Light Thermostat Knob Thermostat Conduit Box Conduit Box Cover Flex Conduit Anti short Bushing Conduit Connector 90 P N Description Heat Transfer P late Infinite Control Limiting Thermostat Only w Infinite Control Knob Infinite Control Wire Set Perma Gum Package 105 J iffy Clip Infinite Control Plate Parts Not Shown 10 24 Hex Nut 5 16 X 3 4 X 1 16 Flat Washer 10 Flat Washer 310 24 Green Hex Nut Ground 38 X 1 2 Hex Sheet Metal Screw 310 External Lockwasher MODEL P N VOLTS WATTS HFW 23 Thermostat 56451 120V 800W HFW 23D Infinite Control 56296 120V 800W HFW 23D Thermostat 56450 120V 800W Conduit Connector Bot
9. late for proper voltage NOTE Electrically connect unit in compliance with local and NEC codes ltem P N HFW 1 1D PARTS LIST EXPLODED VIEW Description Pan amp Wrapper W Drain Pan amp Wrapper No Drain Side Insulation End Insulation Reflector P late Element 120V 1500W Element 208 240V 1200 1600W Control Housing Increase Decrease Plate Indicator Light Thermostat Knob Conduit Box Flex Conduit Anti Short Bushing Conduit Connector 90 Conduit Connector Conduit Box Cover Bottom Panel Bottom Insulation Hole Cover P N Description Dial Setting Plate Drain Strainer Permagum Package Wire Set Parts Not Shown 10 24 Green Hex Nut 10 24 Hex Nut Flat Washer 5 16 X 3 4 X 1 16 10 Flat Washer 10 External Lockwasher 8 X 1 2 Sheet Metal Screw J iffy Clip WATTS 208 240V 1200 1600W 208 240V 1200 1600W 120V 1500W 1500W Item P N CO C U gt NN FR o HFW 12 12D PARTS LIST amp EXPLODED VIEW Description Pan amp Wrapper W Drain Pan Wrapper No Drain Side Insulation End Insulation Element Cover Element Clamp Anti rotation Clamp Heating Element 120V 800W Control Housing Increase decrease Plate Cap Bulb T Stat Models Only Indicator Light Thermostat Knob Conduit Box Conduit Box Cover Flex Conduit Anti short Bushing Conduit Connector 90 Conduit Connector Bottom Panel Hole Cover P N Description Dial Setting Label Drain Stra
10. rce 2 Checkcircuit breaker Is power switch on amp pilot light glowing 4 Checkrating label Are you operating unit on proper voltage SPECIFICATIONS Description Outside Dimensions Inside Dimensions Cut Out Shipping Model COC CO CO AC CI LT FullSize 53 15 734 97 9 117 8 61 4 213 4 133 70 25 lbs HFW 1 54 4 38 1 19 7 50 5 80 2 15 9 55 2 84 9 11 4 Kg 2 3 Size 16 15 734 19 11778 614 14 5 8 13 3 0 22 Ibs HFW 23 40 6 88 1 19 7 33 30 2 15 9 37 1 34 9 10 kg 1 2 Size i2w 15 73 4 912 117 8 61 4 111 2 13374 22 Ibs HFW 12 30 5 38 1 19 7 24 1 80 2 15 9 29 2 34 9 10 kg NOTE Top Flange 1 9 16 3 9cm all 4 sides 4 corners 1 2 5 cm radius Standard thermostat has 36 91 4 cm capillary effective length 26 66 cm CONTROL SIZE 5 5 16 Wx6 7 16 H 13 5 x13 8 CONTROL CUTOUT 5 3 4 W x6 1 4 H 14 6x 15 8 DRAIN OPTIONAL 11 7 8 0 23 HFW 1 Outside 16 HEW 23 30 2 Length 0 12 1 2 HF W 12 Inside Length Recessed Bezel Cut Out A 6 1 4 219 7 8 HFW 1 15 9 ILLO 13 23 Y 9 1 2 HFW 12 Fi 3 8 Dia 14 6 1 0 OPTION SPECIFICATIONS Models Drain Drain Wood Mt Wood Mt Description w Drains Location Couplings Thermostat KitNo s Kit Cut Out Full Size HFW 1D 111 16 x 1 11 16 Y NPT 7
11. t will only be responsible for charges incurred or service performed by its Authorized Service Agencies The use of other than APW Wyott Authorized Service Agencies will void this warranty and APW Wyott will not be responsible for such work or any charges associated with same The closest APW Wyott Authorized Service Agent must be used This warranty covers products shipped into the 48 contiguous United States Hawaii metropolitan areas of Alaska and Canada There will be no labor coverage for equipment located on any island not connected by roadway to the mainland Warranty coverage on products used outside the 48 contiguous United States Hawaii and metropolitan areas of Alaska and Canada may vary Contact the internationalAPW Wyott distributor dealer or service agency for details Time Period One year for parts and one year for labor effective from the date of purchase by the original owner The Authorized Service Agency may at their option require proof of purchase Parts replaced under this warranty are warranted for the un expired portion of the original product warranty only Exceptions Gas Electric Cookline Models GCB GCRB GF GGM GGT CHP H EF EG EHP Three 3 Year Warranty on all component parts except switches and thermostats 2 additional years on parts only No labor on second or third year Broiler Briquettes Rock Grates Cooking Grates Burner Shields Fireboxes 90 Day Material Only No Labor Heat Strips Models F
12. tom Panel Hole Cover Dial Setting Label Drain Strainer FOR 72 THERMOSTAT ADD SUFFIX 72 TO MODEL amp P N FOR UL KIT ADD SUFFIX 36UL OR 72UL TO MODEL amp P N WIRING DIAGRAMS HEATING INDICATOR ROBERT SHAW ELEMENT LIGHT THERMOSTAT HEATING INDICATOR ELEMENT THERMOSTAT HFW 12 HFW 12D HFW 23 HFW 23D THERMOSTAT CONFIGURATION INDICATOR LIGHT HEATING ELEMENT HEATING ELEMENT INDICATOR LIGHT LIMITING THERMOSTAT IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment For Warranty Service and or Parts this information is required Model Number Serial Number Date Purchased Notes Notes 10 D LD Lt LD AN ZA OS SS Hr II WH a III AZ LZ BAN APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it s equipment against defects in materials and workmanship subject to the following conditions This warranty applies to the original owner only and is not assignable Should any product fail to function in its intended manner under normal use within the limits defined in this warranty at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency APW Wyot
Download Pdf Manuals
Related Search