American Standard Palisade 7103 User's Manual
Contents
1. Installation AMERICAST BRAND Instructions S 4F RIMMING SILHOUETTE KITCHEN SINKS MODELS 7145 7163 7172 7179 7183 7185 7196 PALISADE KITCHEN SINK MODEL 7103 LAKELAND KITCHEN SINK MODEL 7173 Certified to comply with ANSI A112 19 4 M U S Patent No 4 664 982 Thank you for selecting American Standard the benchmark Other patents pending CAN C S A B 45 of fine quality for over 100 years Observe local plumbing and building codes To ensure that your installation proceeds smoothly please aie sig read these instructions carefully before you begin F07 iE ACO ROR amp Refer to American Standard roughing in information for BEFORE YOU BEGIN specific dimensions for each model Unpack new sink and inspect carefully for damage Replace the sink in its original packing CUTOUT DIMENSIONS FOR SINKS carton to protect it until you are ready to begin P f Below are the dimensions needed to determine the cutout size installation for each sink Select the correct diagram for your sink and refer to the instructions below Locate and mark center lines of sink on countertop Spooner eaan Eis Provide proper clearance under the countertop for the faucet Putty Knife Basin Wrench Pipe Wrench Saber Saw supply lines and the structural parts of the cabinet By using the diagrams below and measuring your sink draw the Channel Locks Tubing Cutter l 1 yY Phillips Screwdriver Tape Measure arith of the sin2. d sink Fe Silicone Sealant Sink PA gt NOTE Silicone must be removed within 10 minutes of application or a permanent residue may remain on the surfaces Connect supply lines to faucet finger tight and carefully bend to engage with the supply stops Tighten connections to faucet for secure seal Connect drain assembly hand tight to check align ment lt may be necessary to cut off part of the tailpiece area A or part of the horizontal leg of the trap area B Secure joint for watertight assembly Trap Trap Single Bowl Double Bowl CARE AND CLEANING For all porcelain enamel surfaces regular gentle care is best The recommended way to preserve the finish avoid scratches and clean porcelain enamel fixtures is to rinse them with detergent and water Generally any of the light duty liquid dishwashing detergents such as Palmolive or Dawn work well In areas where the water is hard a heavy duty liquid laundry detergent such as liquid Tide will work better Product names listed herein are trademarks of American Standard Inc unless otherwise noted Palmolive is a registered trademark of Colgate Palmolive Co Tide and Dawr are registered trademarks of Procter and Gamble In Mexico Customer Service Manager Ideal Standard S A de C V Via Morelos 330 Col Santa Clara Ecatepec 55540 Edo Mexico www AmericanStandard com mx AMERICAN STANDARD INC 2004
3. ervice under these warranties it is suggested that a claim be made through the contractor or dealer from or through whom the product was purchased or that a service request including a description of the product model and of the defect be sent to the following address In the United States American Standard Inc P O Box 6820 Piscataway New Jersey 08855 Attention Director of Consumer Affairs For residents of the United States warranty information may also be obtained by calling the following toll free number 800 442 1902 www AmericanStandard US com 790715 100 Rev S In Canada American Standard 2480 Stanfield Rd Mississauga Ontario Canada L4Y 1S2 Toll Free 800 387 0369 www AmericanStandard ca 5 Remove sink and apply a masking tape outline 1 8 outside traced outline as a guide for application of silicone sealant Cutout pe Sn 1 8 Sink we outline tape outline Apply a generous portion of silicone sealant inside line traced on countertop Carefully lower sink into place and press down firmly Use guidelines for proper positioning Using water to dampen your finger remove excess sealant for a smooth even line Apply additional sealant if necessary to provide a uniform bead from the rim of sink to the masking tape line as shown Carefully remove tape Dampen finger and run it slightly over the sealant to remove any high spots Use mineral spirits to remove excess silicone from countertop an
4. k onto the countertop This is not the cutting outline Regular Screwdriver Hacksaw Adjustable Wrench Mineral Spirits Recommended Tools amp Materials Refer to the diagram for your sink and draw a line 5 8 16mm in from the sink outline Cut on this line i 33 888mm a 5 685mm 4 R 25mm TYP 5 8 16mm 4 R 25mm TYP i SINK SINK 5 8 16mm OUTLINE OUTLINE SNK CUTTING LINE 5 8 i K 16mm CUTTING LINE OUTLINE SILHOUETTE ISLAND SINK MODEL 7185 SILHOUETTE DOUBLE BOWL SINK CUTTING 14 LINE MODEL 7145 SHALLOW SILHOUETTE DOUBLE BOWL SINK SILHOUETTE j 31 MODEL 7163 SINGLE BOWL SINK 787mm SILHOUETTE SINK MODEL 7172 MODEL 7179 DUAL LEVEL Fo 19 1 2 1 R 25mm TYP 495mm 5 8 16mm SINK 38 _ OUTLINE Saye 1054mm 965mm 5 8 CUTTING LINE 16mm i 5 8 5 8 16mm PALISADE SINGLE BOWL 16mm 29 l 81 MODEL 7103 559mm ge 3 SINK T SINK OUTLINE Cen os CUTTING CUTTING LINE A 1 R 25mm TYP 16mm LINE SILHOUETTE DUAL LEVEL SINK SILHOUETTE TRIPLE BOWL SINK 5 8 16mm MOREL aaas MODEL 7196 SINK OUTLINE CUTTING LINE IMPORTANT DIMENSION OF FIXTURES ARE NOMINAL AND MAY VARY WITHIN LAKELAND SINGLE BOWL THE RANGE OF TOLERANCES ESTABLISHED BY A N S I AND C S A STANDARDS MODEL 7173 AMERICAN STANDARD INC 2004 1 AFTER THE CUTOUT IS DRAWN Perimeter Drill a clearance hole of sink inside the cu
5. rican Standard such whirlpool components and accessories are covered under separate limited warranties This warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to assure local code compliance before installation This warranty shall be void if the Americast brand product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damage if it was not installed in accordance with American Standard s instructions or if it was modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this warranty Some states or provinces do not allow the exclusion or limitation of implied warranties so this exclusion may not apply to you This warranty gives you specific legal rights You may have other statutory rights that vary from state to state or from province to province in which case this warranty does not affect such statutory rights For s
6. tout line as marked on the countertop Cutout Cut opening on cut line inside the perimeter of sink Note Formica counter top installation only is illustrated Contact your countertop distributor for the best method of cut ting other materials such as marble hard syn thetics etc Perimeter 2 Mount the faucet and drain assembly on the sink or countertop following the manufacturer s instructions Before applying the sealant place the sink temporarily into the cutout Check for alignment and clearance then trace around the outside edge of the sink as a guide for installation location and application of sealant AMERICAST LIMITED LIFETIME WARRANTY If an American Standard Americast brand product is found to be defective in materials or workmanship after inspection by an authorized American Standard representative American Standard will repair or at its option exchange the product for a similar model This warranty extends for the lifetime of the product so long as it remains in use in its original place of installation except that the warranty applies to a bathing vessel s slip resisting surface only for the first year after the product s initial installation This warranty applies only to the original purchaser and installation of these products This warranty does not apply to whirlpool components or to faucets drains mounting rims grab bars or other accessories If manufactured or supplied by Ame
Download Pdf Manuals
Related Search