Zanussi ZDEB47209W tumble dryer
Contents
1. User manual Exhaust Dryer U S E R MANUAL ZDEB 47209W ZAN USSI Contents Important safety information Product description Control panel _________________ Before first use 8 Sorting and preparing laundry Programme chart Daily use aoaak RN Important safety information Important In the interest of your safety and to ensure the correct use before installing and first using the appliance read this user manual carefully including its hints and warnings To avoid unnecessary mistakes and accidents it is important to ensure that all people using the appliance are thoroughly familiar with its operation and safety features Save these instructions and make sure that they remain with the appliance if it is moved or sold so that everyone using it through its life will be properly informed on appliance use and safety General safety Itis dangerous to alter the specifications or attempt to modify this product in any way This appliance is not intended for use by per sons including children with reduced physi cal sensory or lack of experience and knowl edge unless they have been given supervi sion or instruction concerning use of the ap pliance by a person responsible for their safe ty Make sure that small pets do not climb into the drum To avoid this please check into the drum before using Any objects such as coins safety pins nails screws stones or any other hard sharp ma terial can c2. amp ASTA approved BS 1363 A fuse must be used 13 The wires in the mains lead are coloured in ac cordance with the following code Blue Neutral cord clamp Brown Live Green and Yellow Earth The wire coloured green and yellow must be connected to the terminal marked with the letter E or by the earth symbol or coloured green and yellow The wire coloured blue must be connected to the terminal N or coloured black The wire coloured brown must be connected to the terminal marked L or coloured red Upon completion there must be no cut or stray strands of wire present and the cord clamp must be secure over the outer sheath Warning A cut off plug inserted into a 13 amp socket is a serious safety shock hazard Environment Recycle the materials with the symbol amp Put the packaging in applicable containers to recycle it Help protect the environment and human health and to recycle waste of electrical and electronic appliances Do not dispose appliances marked with the symbol with the household waste Return the product to your local recycling facility or contact your municipal office 14 Ensure that the cut off plug is disposed of safely Warning The plug must be accessible after installing the machine Permanent connection In the case of permanent connection it is neces sary that you install a double pole switch be tween the appliance and the e
3. the filter after each drying cy cle 5 Close the door the loading aperture 3 Open the filter pressing the button among two slots on fingers Clean the filter using dump hand or cloth After a period of time a patina due to detergent residue on laun dry forms on the filters When this occurs clean the filter with warm water using a brush Close the filter and do not forget to put it back Warning Before You place the filter please check it there is nothing inside the filter seat 4 The filter can be positioned only to one side If position is wrong the filter over hangs If the filter will not snap into place the loading door cannot be closed Warning You must DISCONNECT the To clean the drum Caution Do not use abrasive materials to clean the drum Use a soft detergent to blades clean the inner side of the drum and the drum Keep the inner surface of the drum and the drum blades clean The minerals from the water or cleaning agents can collect on the in ner surface of the drum This cause that the appliance from the electricity supply before you can carry out any cleaning or maintenance work Cleaning the door Clean periodically the interior part of the door to remove any fluff Accurate cleaning ensures cor rect drying What to do if laundry is not sufficient dry Clean operating screen and housing Caution Do not use furniture cleaners or aggressiv
4. Once in its permanent operating position check that the tumble dryer is absolutely level with the aid of a spirit level If it is not raise or lower the feet until it is The feet must never be removed Do not re strict the floor clearance through deep pile carpets strips of wood or similar This might cause heat built up which would interfere with the operation of the appliance Important The hot air emitted by the tumble dryer can reach temperatures of up to 60 C The appli ance must therefore not be installed on floors which are not resistant to high temperatures When operating the tumble dryer the room temperature must not be lower than 5 C 12 and higher than 35 C as it may affect the performance of the appliance Should the appliance be moved it must be transported vertically The appliance must not be installed behind a lockable door a sliding door a door with a hinge on the opposite side to that of the ap pliance in such a way that a full opening of the tumble dryer is restricted Removing transport safety packaging Caution Before use all parts of the transport packaging must be removed 3 Remove foil hose and polystyrene pad ding from the ma chine 1 Open loading door 2 Pull off adhesive strips from inside ma chine on top of drum Fitting the vent hose To simplify the installation there is a choice of vent outlets one at the back the others in the www z
5. anussi com left and right hand side Connect the hose to whichever is the more convenient by pulling the ring nut A from the vent outlet at the back screwing it on to the hose and pushing it firmly back into place The unused vents should now be sealed with the special snap covers provi ded If the hose is long and the room temperature low the moisture might condense to water inside the hose This is an unavoidable natural phenomenon To prevent this water from lying in the hose or flowing back into the tumble dryer it is advisable to drill a small hole via 3 mm in the lowest point of the hose and to place a small container below it See picture point B Once connected to the dryer run the vent hose to the desired outlet point ensuring that the run s overall length is less than 2 m and that it contains no more than two bends As to the outlet itself if you have decided on a fixed wall window grille a good local builder s merchant should be able to supply you with the necessary fittings and installation advice A Warning It is important not to connect the vent hose to for example a cooker hood or a chimney or flue pipe designed to carry the exhaust from a fuel burning appliance www zanussi com Note that to avoid condensation problems it is essential that the dryer be fitted with the flexible hose to carry its exhaust at least beyond the kitchen units preferable outside the kitc
6. ause extensive damage and must not be placed into the machine In order to avoid danger of fires caused by excessive drying do not use appliance to dry Careandcleaning 9 Whattodoif 10 Machine settings ______________ 11 Technical data ________________ 11 Installation ____ 12 Environment 14 Service 15 Subject to change without notice the following items Cushions quilts and the like these items accumulate heat Items such as foam rubber latex foam shower caps waterproof textiles rubber backed articles and clothes or pillows fitted with foam rubber pads should not be dried in the tumble dryer Always unplug the appliance after use clean and maintenance Under no circumstances should you attempt to repair the machine yourself Repairs car ried out by inexperienced persons may cause injury or serious malfunctioning Contact your local Service Centre Always insist on genu ine spare parts Items that have been soiled with substances such as cooking oil acetone petrol kerosene spot removers turpentine waxes and wax re movers should be washed in hot water with an extra amount of detergent before being dried in the tumble dryer Danger of explosion Never tumble dry items that have been in contact with inflam mable solvents petrol methylated spirits dry cleaning fluid and the like As these sub stance are volatile they could cause an ex plosion Only tumble dry items washed wi
7. brief Sorting and preparing laundry Sorting laundry Sort by fabric type Cotton linen for programmes in COTTONS programme group Mixtures and synthetics for programmes in SYNTHETICS programme group Sorting by care label The care labels mean Dry at re FIALE duced SRI thetueble Det tempere lin a poe ture ble dryer Di tempera press ae i i ture DELI Ae principle CATE sible button Important Do not place in the appliance any wet laundry which is not specified on the care label as being suitable for tumble drying This appliance can be used for all wet laundry items which are labelled as suitable for tumble drying Do not dry new coloured textiles together with light coloured laundry items Textile col ours may bleed Do not dry cotton jersey and knitwear with the EXTRA programme Items may shrink Preparing laundry To avoid laundry becoming tangled close zips button up duvet covers and tie loose ties or ribbons e g of aprons www zanussi com Filter light Start Pause button drying cycle ca 30 min with damp cloths in the machine Empty pockets Remove metal items paper clips safety pins etc Turn items with double layered fabrics inside out e g with cotton lined anoraks the cotton layer should be outermost These fabrics will then dry better Important Do not overload the appliance Observe max loading volume of 7 kg Laundry weights ipo
8. can be removed at any time during the anti crease phase When the option is active the ANTI CREASE light is on 8 Selecting additional functions You can choose from the additional functions button 1 DELICATE button 2 ANTI CREASE button 3 ALARME button 4 START PAUSE ALARM When the drying cycle has finished an intermit tent audible signal will sound By depressing button ALARM the acoustic signal is switched off in the following cases when selecting the programme when depressing the buttons when the programme selector dial is turned to another position during the programme or when you depress an option button during the cycle at the end of the programme The corresponding light comes on Starting the programme Press the START PAUSE button The pro gramme is started www zanussi com The programme phase is shown by appropriate lights light 7 DRYING light 6 END Changing programme To change a programme which has been selec ted by mistake once the programme has started first turn the programme selector to O OFF position The programme is cancelled The programme can no longer be changed directly once the programme has started If nevertheless there is an attempt to change the programme on the programme knob or if an function button excluding the ALARME but ton is pressed led on the START PAUSE button starts flashing temporarily in red The drying programme is not ho
9. e cleaning agents to clean the appliance Use a damp cloth to wipe down the operating screen and housing Dryer does not work Drying results unsatisfactory Loading door does not close Drying cycle ends shortly after pro gramme starts Drying cycle lasts an unusually long time Note After around 5 10 Mains plug is not plugged in or fuse is not working correctly Loading door is open Have you pressed the START PAUSE button Wrong programme selected Fluff filter clogged Overloading of laundry Ventilation slots covered up Residue on inside surface of drum or drum ribs Conductance of water at installa tion site differs from standard set ting of machine Filter not in place Not enough washing loaded or washing loaded is too dry for se lected programme Filter clogged Plug in at mains socket Check fuse in fuse box domestic installa tion Close loading door Press the START PAUSE button again Select a different programme the next time you dry see Programme chart chapter Clean fluff filter Observe recommended loading volumes Uncover ventilation slots Clean inside surface of drum and drum ribs Re programme standard setting for degree of drying see Machine settings chapter Install filter into place Select time programme or higher drying level e g EXTRA DRY in stead of CUPBOARD DRY Clean filter www zanussi com ho
10. er if the power sup ply cable the control panel the working sur face or the base are damaged so that the in side of the tumble dryer is accessible Fabric softeners or similar products should be used as specified by the fabric softener in structions Caution hot surface Do not touch the door light cover surface when the light is switched on A Hot surface Do not touch the back of the appliance while it is operating Child safety This machine is not intended for use by young children or infirm persons without su pervision Children should be supervised to ensure that they do not play with the appliance The packaging components e g plastic film polystyrene can be dangerous to children danger of suffocation Keep them out of chil dren s reach Keep all detergents in a safe place out of Make sure that children or pets do not climb children s reach into the drum Product description Control panel Adjustable feet Door E Sideways vent outlets back vent outlet Fluff filter Ring nut Rating plate Control panel OOO Programme knob and OFF switch Function buttons 4 www zanussi com k Function status led 555 Drying light End Anti crease light Before first use In order to remove any residues which may have been produced during production wipe the dry er drum with a damp cloth or carry out a
11. ervice In the event of technical faults please first check whether you can remedy the problem yourself with the help of the operating instruc tions Chapter What to do if If you were not able to remedy the problem yourself please contact your local service cen tre In order to be able to assist you quickly we re quire the following information Model description Product number PNC Serial number S No for numbers see rating plate Type of fault Model description PNC S No www zanussi com Your dryer will function most economically if you always keep the ventilation slots on the base of the dryer unobstructed use the loading volumes specified in the programme overview clean the filter after each drying cycle spin the laundry well before drying Any error messages displayed by the appli ance So that you have the necessary reference num bers from your appliance at hand Typ XX X XXXXXXX 20K mim 2000 W MA XX He OV PNC XXX XXX XXX XX S No XXXXXXXX 15 www zanussi com shop e ee 9 6 136926290 B 092013 MN
12. hen In order to prevent the appliance from overheating it is important that the steam exhaust is unob structed Therefore in case of a permanent hose fitted to an exterior wall or ceiling it must be ensured an exhaust capacity of at least 150 m3 h If the dryer is fitted next to kitchen units make sure that the vent hose is not squashed If the hose is partially squashed drying efficiency will be reduced resulting in longer drying times and higher energy consumption If the hose is completely squashed the safety cut outs with which the machine is fitted may operate When operating the tumble dryer the room tempera ture must not be lower than 5 C and higher than 35 C as it may affect the performance of the appliance Electrical connection Details on mains voltage type of current and the fuses required should be taken from the rating plate The rating plate is fitted near the loading aperture see Product description chapter Connect the machine to an earthed socket in accordance with current wiring regulations Warning The manufacturer declines any responsibility for damage or injury through failure to comply with the above safety precautions Should the appliance power supply cable need to be replaced this must be carried out by an authorised service engineer or a qualified electrician The appliance is supplied with a 13 amp plug fitted In the event of having to change the fuse in the plug supplied a 13
13. ick or multi layered fabrics e g pull D overs bedding table linen pe For thin fabrics which are not ir oned e g easy care shirts ta ble linen baby clothes socks 2 lingerie with bones or wires a For thin fabrics which are also to be ironed e g knitwear cot D ton shirts pe O For further drying of individual CI items of laundry or for small vol umes of less than 1 kg O www zanussi com Programmes max load weight when dry 1 kg EASYIRON or5 shirts MIX 3 kg BABY 5 2 kg JEANS 7 kg COOLING 7 kg 1 In accordance with IEC61121 2 Select DELICATE button www zanussi com Additional functions options DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME ALARME Application properties Special programme with anti crease mechanism for easy care textiles such shirts and blouses for minimum ironing effort The result depends on the type and quality of textiles The loading volume corre sponds to approx 5 to 7 shirts Recommendation Place textiles in the dryer straight af ter spinning Once dried imme diately remove textiles and place on clothes hanger For drying cotton and synthetic fabrics uses low temperature Baby cycle is a special pro gramme for jumpers to be dried ready to wear For leisure clothing such as jeans sweat shirts etc of dif ferent material thicknes
14. ions mm Width Height Depth 85 x 60 x 58 cm Max depth 1090 mm with the appliance door open Max width 950 mm with the appliance door open Electrical connection Voltage 230 240 V Frequency 50 Hz Fuse 13A Total power 2600 W Drum volume 108 Weight of the appliance 32 5 kg Laundry max weight 7 kg www zanussi com 11 Type of use Ambient temperature Min Max Energy consumption 1 kWh cycle Annual energy consumption 2 Energy efficiency class Power consumption Off mode Left on mode Household 5 C 35 C 4 25 kWh 512 kWh C 0 70 W 0 70 W 1 With reference to EN 61121 7 kg of cotton and a spin speed at 1000 rpm 2 Energy consumption per year in kWh based on 160 drying cycles of the standard cotton programme at full and partial load and the consumption of the low power modes Actual energy consumption per cycle will depend on how the appliance is used REGULATION EU No 392 2012 Installation Appliance positioning It is recommended that for your convenience the appliance is positioned close to your washing machine The tumble dryer must be installed in a clean place where dirt does not build up Air must be able to circulate freely all round the appliance Do not obstruct the front venti lation grille or the air intake grilles at the back of the appliance To keep vibration and noise to a minimum when the tumble dryer is in use it should be placed on a firm level surface
15. lectricity supply mains with a minimum gap of 3 mm between the switch contacts and of a type suitable for the required load in compliance with the current electrical regulations The switch must not break the yellow and green earth cable at any point Door reversal To make it easier to load or unload the laundry the door can be reversed The door must only be reversed by an authorised service engineer Please contact your local Service Force Centre The engineer will carry out the door reversal at your cost Special accessories Stacking kit A special stacking kit is available through your dealer to enable the mounting of the dyer on top of a front loading washing machine with cover s depth between 48 and 60 cm Read carefully the instruc tions supplied with the kit Packaging material The packaging materials are environmentally friendly and can be recycled The plastic com ponents are identified by markings e g gt PE lt gt PS lt etc Please dispose of the packaging materials in the appropriate container at the community waste disposal facilities www zanussi com Warning When disposing of old appliances remove the mains cable and dispose of together with the plug Remove the door hook and ensure it is no longer lockable to prevent young children being trapped inside Environmental tips In the dryer laundry becomes fluffy and soft Fabric softeners are not therefore needed when washing S
16. ottaunay weon Bathrobe 1200 g Napkin 100g Quilt cover 700 g Sheet 500 g Pillow case 200 g Tablecloth 250 g Towelling towel 200 g Tea cloth 100g Night dress 200g Ladies briefs 100g Man s work shirt 600g Man s work shirt 200g Man s pyjamas 500 g Blouse 100g Men s underpants 100g Programme chart E o i v fs Programmes 2 no 2 x COTTON EXTRA DR DRY 9 COTTON STRONG DRY 9 COTTON CUP sa BOARD DRY 1 9 COTTON DAMP 7kg COTTON IRON ae DRY 1 9 SYNTHETICS EX DA TRA DRY 9 SYNTHETICS CUP BOARD DRY SYNTHETICSIRON gx DRY 9 30 MIN 1kg Additional functions options DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME DELICATE ANTI CREASE ALARME Application properties Thorough drying of thick or multi layered fabrics e g terry O towelling items bathrobes Thorough drying of thick or multi layered fabrics e g terry towelling items bathrobes F Thorough drying of fabrics of even thicknesses e g terry towelling items knitwear tow lt els For thin textiles which are still 3 to be ironed e g knitted items 7 cotton shirts For thin fabrics which are also 9 to be ironed e g knitwear cot ton shirts Thorough drying of th
17. ses e g at the neck cuffs and seams Special programme lasting around 10 minutes for refresh ing or gently cleaning textiles with commercially available dry cleaning sets Only use those products which are declared as suitable for the drier by the manufacturer please observe the manufacturer s instructions for use 79 Tan LA 79 O OO ZN C IFN ASI S J 5S PNF OC Daily use Switching machine on Turn the programme selector to any programme The machine switches on Q sere sane 1 2 Door opening and laundry loading 1 Door opening and laundry loading 2 Load your laundry Selecting the pro gramme Turn the programme selector dial to the re quired programme The light START tf it in SIOE PAUSE starts to flash Caution Do not jam laundry in be tween the loading door and rubber seal 3 Close loading door securely Lock must audibly lock DELICATE Pressing this button allows drying to be per formed at a lower temperature for delicate items The corresponding pilot light comes on This option can also be used for time controlled drying ANTI CREASE A long anti crease phase lengthen the anti crease phase 30 min at the end of the drying additionally by 60 minutes The drum rotates at intervals during this phase This keeps the laun dry loose and free of creases Phase lasts in to tal 90 minutes The laundry
18. th water Risk of fire items that have been spotted or soaked with vegetable or cooking oil consti tute a fire hazard and should not be placed in the tumble dryer If you have washed your laundry with stain re mover you must execute an extra rinse cycle before loading your tumble dryer www zanussi com Please make sure that no gas lighters or matches have accidentally been left in pock ets of garments to be loaded into appliance Warning Never stop a tumble dry be fore the end of the drying cycle unless all items are quickly removed and spread out so that the heat is dissipated Risk of fire Risk of electric shock Do not spray down the appliance with jets of water The final part of a tumble dryer cycle occurs without heat cool down cycle to ensure that the items are left at a temperature that en sures that items will not be damaged Ensure you have adequate ventilation in the installation room to avoid the back flow of gases into the room from appliances burning other fuels including open fires Installation This appliance is heavy Care should be taken when moving it When unpacking the appliance check that it is not damaged If in doubt do not use it and contact the Service Centre All packing and transit bolts must be removed before use Serious damage can occur to the product and to property if this is not adhered to See relevant section in the user manual Any electrical work required
19. to install this ap pliance should be carried out by a qualified electrician or competent person Care must be taken to ensure that the appli ance does not stand on the electrical supply cable If the machine is situated on a carpeted floor please adjust the feet in order to allow air to circulate freely After having installed the appliance check that it is not pressing or standing on its elec trical supply cable or and inlet hose If the tumble dryer is placed on top of a washing machine it is compulsory to use the stacking kit optional accessory 1 Only dryers equipped with internal drum light www zanussi com Use This appliance is designed for domestic use lt must not be used for purposes other than those for which it was designed Only wash fabrics which are designed to be machine dried Follow the instructions on each garment label Do not dry unwashed items in the tumble dry er Do not overload the appliance See the rele vant section in the user manual Clothes which are dripping wet should not be placed in the dryer Garments which have been in contact with volatile petroleum products should not be machine dried If volatile cleaning fluids are used care should be taken to ensure that the fluid is removed from the garment before placing in the machine Never pull the power supply cable to remove the plug from the socket always take hold of the plug itself Never use the tumble dry
20. urs the drying cycle ends auto Load volume too big Reduce load volume matically Laundry insufficiently spun Laundry must be adequately spun 1 Only dryers with conductance programming 2 Only dryers with removable filter Machine settings Setting Implementation BUZZER permanent off 1 Turn the programme selector to any programme 2 Press simultaneously the DELICATE and ANTI CREASE buttons and hold down for approx 5 seconds 3 The buzzer is by default always off Water hardness 1 Turn the programme selector to any programme Water contains a variable quan 2 Press simultaneously the ANTI CREASE and START PAUSE but tity of limestone and mineral tons and hold down for approx 5 seconds Lights show the current salts of which quantities vary ac setting ily 9 gacra Par END low conductivity lt 300 micro S cm tions thus varying its conductivi ty values DRYING medium conductivity 300 600 micro S cm Relevant variations of the con DRYING and END high conductivity gt 600 micro S cm ductivity of the water compared 3 Press the START PAUSE button sequentially until you set desired to those prefixed by the factory level CZ To memorize setting press simultaneously the the ANTI CREASE and A ENGR START PAUSE buttons or tum knob to OFF position the end of the cycle Your dryer allows you to regulate the sensi tivity of the drying sensor based on conductivity values of the water Technical data Dimens
21. wever affected by this laundry protection Drying cycle complete removing laundry Once the drying cycle is complete the lights END and light 5 FILTER are on If the buzzer is active an acoustic signal sounds intermittently for about one minute The drying cycles are automatically fol lowed by an anti crease phase which lasts Care and cleaning Cleaning fluff filter The filter collect all the fluff which accumulates during drying To ensure that the dryer works perfectly the fluff filter must be cleaned after ev ery drying cycle The warning light FILTER is on to remind you this operation A Caution Never operate the dryer without fluff filter or with damaged or blocked fluff filter 1 Open loading door and re move laundry 2 Remove the filter which is built into the lower part of 2 Only dryers with ALARME button www zanussi com around 30 minutes The drum rotates at inter vals during this phase This keeps the laundry loose and free of creases The laundry can be removed at any time during the anti crease phase The laundry should be taken out to wards the end of the anti crease phase at the latest to prevent creases from forming 1 Open door 2 Remove laundry 3 Remove filter after clothes has been re moved Clean the filter Warning Before You place the filter please check it there is nothing inside the filter seat 4 Turn the programme selector to OFF Important Clean
Download Pdf Manuals
Related Search