Electrolux Rex EGG9363NOX hob
Contents
1. 1 2 Installation WARNING Only a qualified person must in stall this appliance Remove all the packaging Do not install or use a damaged appli ance Obey the installation instruction sup plied with the appliance Keep the minimum distance from the other appliances and units ENGLISH 3 Always be careful when you move the appliance because it is heavy Always wear safety gloves Seal the cut surfaces with a sealant to prevent moisture to cause swelling Protect the bottom of the appliance from steam and moisture Do not install the appliance adjacent to a door or under a window This pre vents hot cookware to fall from the ap pliance when the door or the window is opened f the appliance is installed above draw ers make sure that the space between the bottom of the appliance and the up per drawer is sufficient for air circula tion The bottom of the appliance can get hot We recommend to install a non combustile separation panel under the appliance to prevent access to the bot tom Electrical connection WARNING Risk of fire and electrical shock All electrical connections must be made by a qualified electrician Before every wiring make sure the main terminal of the appliance is not live Make sure the appliance is installed correctly Loose and incorrect plug and Socket can make the terminal become too hot Make sure that a shock protection is in stalle2. Carry out connection by using metal rigid pipes copper with mechanical end 7 3 Injectors replacement 1 Remove the pan supports 2 Remove the caps and crowns of the burner 3 With a socket spanner 7 remove the injectors and replace them with the ones which are necessary for the type of gas you use see table in Techni cal Information chapter 4 Assemble the parts follow the same procedure backwards 5 Replace the rating plate it is near the gas supply pipe with the one for the new type of gas supply You can find this plate in the package supplied with the appliance If the supply gas pressure is changeable or different from the necessary pressure you must fit an applicable pressure ad juster on the gas supply pipe 7 4 Adjustment of minimum level To adjust the minimum level of the burn ers 1 Light the burner 2 Turn the knob on the minimum posi tion 3 Remove the knob 4 With a thin screwdriver adjust the by pass screw position A CD A The by pass screw f you change from natural gas G20 20 mbar to liquid gas fully tighten the by pass screw in f you change from liquid gas to natural gas G20 20 mbar undo the by pass screw approximately 1 4 of a turn 1 2 of a turn for Triple Crown burner WARNING Make sure the flame does not go out when you quickly turn the knob from the maximum position to the minimum position 7 5 El
3. Gas connection G 1 2 Gas supply G20 2H 20 mbar Appliance class 3 14 www electrolux com By pass diameters Burner Burner By pass in 1 100 mm Rapid Auxiliary 28 Triple Crown 56 Semi rapid 32 Gas burners RE NORMAL POWER NOR MAL DUCED NATURALGAS LPG Butane Propane power POW G20 2H 20 G30 G31 3 28 30 37 ER BURN mbar mbar ER 630 inj inj 28 30 37 kW kW 1 100 m h 1 100 mbar mbar mm mm g h g h Auxiliary 1 0 0 33 70 0 095 50 13 71 Semi rapid 2 0 0 45 96 0 190 71 145 143 Rapid 2 8 0 75 115 0 267 86 204 200 Triple OI 4 0 1 4 146 0 381 98 291 286 9 ENVIRONMENT CONCERNS Recycle the materials with the symbol 5 Put the packaging in applicable containers to recycle it Help protect the environment and human health and to recycle waste of electrical and electronic appliances Do not dispose appliances marked with the symbol with the household waste Return the product to your local recycling facility or contact your municipal office ENGLISH 15 www electrolux com shop 356993602 172012
4. on the appli ance Cookware made of cast iron aluminium or with a damaged bottom can cause scratches on the glass ceramic Always lift these objects up when you have to move them on the cooking surface Provide good ventilation in the room where the appliance is installed Make sure that the ventilation openings are not blocked Use only stable cookware with the cor rect shape and diameter larger than the dimensions of the burners There is a risk of overheating and rupture of the glass plate if applicable Make sure the flame does not go out when you quickly turn the knob from the maximum to the minimum position Make sure pots are centrally positioned on the rings and do not stick out over edges of the cooking surface Use only the accessories supplied with the appliance Do not install a flame diffuser on the burner 1 4 Care and Cleaning WARNING Risk of damage to the appliance Clean regularly the appliance to prevent the deterioration of the surface material Do not use water spray and steam to clean the appliance Clean the appliance with a moist soft cloth Only use neutral detergents Do not use abrasive products abrasive cleaning pads solvents or metal ob jects 2 PRODUCT DESCRIPTION 2 1 Cooking surface layout ENGLISH 5 1 5 Disposal WARNING Risk of injury or suffocation Contact your municipal authority for in formation on how to discard the appli ance correctly e D
5. plug is disposed of safely A cut off plug put into a 13 amp socket is a safety hazard There is a risk of electrical shock A supplied seal B supplied brackets 7 8 Possibilities for insertion Kitchen unit with door The panel installed below the hob must be easy to remove and let an easy access in case a technical assistance intervention 15 necessary 2 frui 20 mm max 150 mm A Removable panel B Space for connections 8 TECHNICAL INFORMATION Hob dimensions Width 894 mm Length 510 mm Hob recess dimensions Width 830 mm Length 480 mm Heat input Triple Crown 4 0 kW burner Rapid burner 2 8 kW Semi rapid burn 2 0 kW er Auxiliary burner 1 0 kW ENGLISH 13 Kitchen unit with oven The hob recess dimensions must obey the indication and the kitchen unit must be equipped with vents to let a continu ous supply of air The electrical connec tion of the hob and the oven must be in stalled separately for safety reasons and to let easy remove oven from the unit gt A A 50 cm2 120 cm2 lt PZ 360 cm2 80 cm2 TOTAL POWER 0920 2H 20 mbar 12 8 kW G30 3 28 30 mbar 931 g h G31 3 37 mbar 914 230 V 50 Hz supply 3 core flexible cable with non rewireable plug fitted with a 3 amp cartridge Electric supply fuse Category II2H3
6. the burner N 91 e Be very careful when you replace the pan supports to prevent the hob top from damage After cleaning dry the appliance with a soft cloth 8 www electrolux com The stainless steel can become tarnished if it is too much heated Refer to this you must not cook with potstones earthen ware pans or cast iron plates Do not use aluminium foil to prevent damage the top during operation Removing the dirt 1 Remove immediately melting plastic plastic foil and food con taining sugar Stop the appliance and let it cool down before you clean lime scale rings water rings fat stains shiny metallic discolorations Use a special cleaner applicable for sur face of hob 2 Clean the appliance with a damp cloth and some detergent 6 TROUBLESHOOTING Problem There is no spark when lighting the gas supply Possible cause 3 Atthe end rub the appliance dry with a clean cloth 5 1 Cleaning of the spark plug This feature is obtained through a ceramic ignition candle with a metal electrode Keep these components well clean to prevent difficult lighting and check that the burner crown holes are not obstructed 5 2 Periodic maintenance Periodically speak your local Service Force Centre to check the conditions of the gas supply pipe and the pressure ad juster if fitted Rem
7. d Do not let the electricity bonds touch the appliance or hot cookware when you connect the appliance to the near Sockets Do not let the electricity bonds tangle Use a strain relief clamp on cable Use the correct mains cable Make sure not to cause damage to the mains plug and to the mains cable Contact the Service or an electrician to change a damaged mains cable The electrical installation must have an isolation device which lets you discon 4 www eelectrolux com nect the appliance from the mains at all poles The isolation device must have a contact opening width of minimum 3 mm e Use only correct isolation devices line protecting cut outs fuses screw type fuses removed from the holder earth leakage trips and contractors Gas connection e All gas connections should be made by a qualified person Make sure that there is air circulation around the appliance The information about the gas supply is on the rating plate This appliance is not connected to a device which evacuates the products of combustion Make sure to connect the appliance according to current in stallation regulations Pay attention to requirements regarding adequate venti lation 1 3 Use WARNING Risk of injury burns or electric shock e Use this appliance in a household envi ronment Do not change the specification of this appliance e Do not use an external timer or a sepa rate remote control syst
8. ectrical connection e Make sure that there is access to the mains plug after the installation ENGLISH 11 Do not pull the mains cable to discon nect the appliance Always pull the mains plug Do not connect the appliance with an extension cable an adapter or a multi ple socket There is a risk of fire Make sure that the ground connection com plies with the standards and regulations force Do not let the connection cable parts to heat to a temperature above 90 C Electrical Requirements Permanent electrical installation must comply with the latest 1 Regulations and local Electricity Board regulations For your own safety the installation must be done by a qualified electrician e g your local Electricity Board or a contractor who is on the roll of the National Inspec tion Council for Electrical Installation Con tracting NICEIC The manufacturer declines any lia bility if these safety measures are not observed The appliance must be connected to a 230 V 50 Hz AC electrical supply Before activating the appliance make sure the electrical supply voltage is the same as that indicated on the rating plate The rating plate is located on the bottom of the appliance The appliance is supplied with a 3 core flexible supply cord with a 3 amp plug If it is necessary to change the fuse use a 3 amp ASTA approved BS 1362 fuse 12 www electrolux com A B N The current regula
9. edy There is no electrical Make sure that the unit is connected and the electrical supply is switched on e Control the fuse If the fuse is released more than one time refer to a qualified electrician e Burner and crown Make sure that the are placed uneven The flame is blow out im mediately after ignition burner cap and crown are in correct positions e Thermocouple is not After lightning the heated sufficient flame keep the knob pushed for approxi mately 5 seconds The gas ring burns un evenly dues If there is a fault first try to find a solution to the problem yourself If you cannot find a solution to the problem yourself speak your dealer or the local Service Force Centre Burner crown is Make sure that the in blocked with food resi jector is not blocked and the burner crown is clear of food parti cles i you operated the appliance in correctly or the installation was not carried out by a registered en gineer the visit from the customer service technician or dealer may not take place free of charge even during the warranty period These data are necessary to help you quickly and correctly These data are available on the supplied rating plate Model description e Product number Serial Number S N Use the original spare parts only They are available at Service Force Ce
10. em to operate the appliance Do not let the appliance stay unatten ded during operation Do not operate the appliance with wet hands or when it has contact with wa ter Do not put cutlery or saucepan lids on the cooking zones They become hot Set the cooking zone to off after use e Do not use the appliance as a work surface or as a storage surface If the surface of the appliance is cracked disconnect immediately the appliance from the power supply This to prevent an electrical shock WARNING Risk of fire or explosion Fats and oil when heated can release flammable vapours Keep flames or heated objects away from fats and oils when you cook with them The vapours that very hot oil releases can cause spontaneous combustion Used oil that can contain food rem nants can cause fire at a lower temper ature than oil used for the first time Do not put flammable products or items that are wet with flammable products in near or on the appliance Do not try to extinguish a fire with wa ter Disconnect the appliance and cover the flame with a lid or a fire blanket WARNING Risk of damage to the appliance Do not keep hot cookware on the con trol panel Do not let cookware to boil dry Be careful not to let objects or cook ware fall on the appliance The surface can be damaged Do not activate the cooking zones with empty cookware or without cookware Do not put aluminium foil
11. ffective area 10 www electrolux com of 100 cm is required If it is installed in room of volume between 5 m and 10 m an air vent of effective area of 50 is required while if the volume exceeds 11 no air vent is required However if the room has a door which opens directly to the outside no air vent is required even if the volume is between 5 m 11 m8 If there are other fuel burning appliances in the same room B S 5440 Part 2 Cur rent Edition should be consulted to deter mine the requisite air vent requirements For appliances installed in the Republic of Ireland please refer to the NSAI Domestic Gas Installation I S 813 Current Editions Table Four Location The hob may be located in a kitchen a kitchen diner or bed sitting room with volume greater than 20 ms but not in a bathroom or shower room The minimum distance combustible mate rial can be fitted above the hob in line with the edges of the hob is 400 mm If it is fit ted below 400 mm a space of 50 mm must be allowed from the edges of the hob For appliances installed in the Republic of Ireland please refer to NSAI Domestic Gas Installation 1 5 813 Current Edition Section 7 Permitted Locations of Appli ance 7 2 Gas Connection WARNING Any gas installation must be car ried out by a GAS SAFE REGIS TER installer Make sure that once the hob is installed it is easily accessible for the engineer in
12. isconnect the appliance from the mains supply Cut off the mains cable and discard it Flat the external gas pipes Auxiliary burner Semi rapid burner Triple Crown burner m Control knobs Rapid burner 000999 2 2 Control knobs Symbol Description Symbol Description minimum gas no gas supply supply off position ignition position maximum gas X 0 3 DAILY USE supply WARNING Refer to Safety information chapter 3 1 Ignition of the burner AS WARNING Be very careful when you use open fire in kitchen environment Manufacturer decline any respon sibility in case misuse of the flame 6 wwweelectrolux com Always light the burner before you put cookware To light the burner 1 Turn the control knob counterclock wise to the maximum position pa and push it down 2 Keep the control knob pushed for ap proximately 5 seconds this will let thermocouple to warm up If not the gas supply will be interrupted 3 Adjust the flame after it is regular i If after some tries the burner does not light check if the crown and its cap are in correct positions A Burner cap B Burner crown Ignition candle D Thermocouple 4 HELPFUL HINTS AND TIPS WARNING Refer to Safety information chapter Ej WARNING Do not keep the control knob pushed for more than 15 sec onds If the burner does not light afte
13. ly before you do cleaning or maintenance work i Scratches or dark stains on the surface have no effect on how the appliance operates You can remove the pan supports to easily clean the hob To clean the enamelled parts cap and crown wash them with warm soapy water and dry them carefully before you put them back Wash stainless steel parts with water and then dry them with a soft cloth The pan supports are not dishwasher proof They must be washed by hand When you wash the pan supports by hand take care when you dry them as ENGLISH 7 AN WARNING Make sure pot handles do not protrude over the front edge of the cooktop and that pots are centrally positioned on the rings in order to achieve maximum stabili ty and to obtain lower gas con sumption Do not place unstable or deformed pots on the rings to prevent from spill and in jury Information on acrylamides Important According to the newest Scientific knowledge if you brown food specially the one which contains starch acrylamides can pose a health risk Thus we recommend that you cook at the lowest temperatures and do not brown food too much the enamelling process occasionally leaves rough edges If necessary re move stubborn stains using a paste Cleaner Make sure you position the pan sup ports correctly after cleaning To make the burners work correctly make sure that the arms of the pan supports are in the centre of
14. ntre and ap proved spare parts shops ENGLISH 9 6 1 Labels supplied with the accessories bag Stick the adhesive labels as indicated be low 1 T MOD TYPE PROD NO PROD NO C Ew ae SER NO SER NO a DATA DATA MADE IN ITALY MODEL MODEL H X X Stick it on Guarantee Card and send this part Stick it on Guarantee Card and keep this part 7 INSTALLATION WARNING Refer to Safety information chapter A WARNING The following instructions about installation connection and main tenance must be carried out by qualified personnel in compliance with standards and local regula tions in force 7 1 Important safety requirements This hob must be installed in accordance with the Gas Safety Installation and Use Stick it on instruction booklet Regulations Current Edition and the IEE Wiring Regulations Current Edition For appliances installed in the Republic of Ireland please refer to NSAI Domestic Gas Installation 1 5 813 Current Editions and the ETCI Rules for Electrical Installa tions Provision for ventilation Detailed recommendations are contained in the following British Standards Codes Of Practice B S 6172 B S 5440 Par 2 and B S 6891 Current Editions The hob should not be installed in a bed Sitting room with a volume of less than 20 m8 If it is installed in a room of volume less than 5 m an air vent of e
15. r 15 seconds release the control knob turn it into off position and try to light the burner again after minimum 1 minute In the absence of electricity you can ignite the burner without elec trical device in this case approach the burner with a flame push the relevant knob down and turn it counter clockwise to maximum gas release position If the burner accidentally goes out turn the control knob to the off position and try to light the burner again after minimum 1 minute The spark generator can start au tomatically when you switch on the mains after installation or a power cut It is normal 3 2 Turning the burner off To put the flame out turn the knob to the symbol 6 A WARNING Always turn the flame down or switch it off before you remove the pans from the burner 4 1 Energy savings f possible always put the lids on the pans e When the liquid starts to boil turn down the flame to barely simmer the liquid Use cookware with diameters applicable to the size of burners Burner Diameters of cook ware Triple 180 260 mm Crown Rapid 160 260 mm Semi rapid 120 220 mm Auxiliary 80 180 mm WARNING Do not put the same pan on two burners x CaS E ae 5 CARE AND CLEANING A WARNING Refer to Safety information chapter N WARNING Deactivate the appliance and let it cool down before you clean it Disconnect the appliance from the electrical supp
16. rts When contacting Service ensure that you have the following data available The information can be found on the rating plate Model PNC Serial Number A Warning Caution Safety information i General information and tips 62 Environmental information Subject to change without notice 1 A SAFETY INFORMATION This appliance is suitable for the following markets GB Before the installation and use of the ap pliance carefully read the supplied in structions The manufacturer is not re sponsible if an incorrect installation and use causes injuries and damages Always keep the instructions with the appliance for future reference 1 1 Children and vulnerable people safety WARNING Risk of suffocation injury or per manent disability This appliance can be used by children aged from 8 years and above and per sons with reduced physical sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction for the opera tion of the appliance by a person who is responsible for their safety Do not let children play with the appli ance Keep all packaging away from children Keep children and pets away from the appliance when it operates or when it cools down Accessible parts are hot If the appliance has a child safety de vice we recommend that you activate it Cleaning and user maintenance shall not be made by children without super vision
17. the event of a breakdown The manufacturer will not accept liability should the above instructions or any of the other safety instructions incorporated in this instruction booklet be ignored On the end of the shaft which includes the G 1 2 threaded elbow adjustment is fixed so that the washer is fitted between the components as shown in the diagram Screw the parts together without using excessive force gt 1 2779 C A End of shaft with nut B Washer C Elbow Connection to the gas supply should be with either rigid or semi rigid pipe i e steel or copper The connection should be suitable for connecting to R 1 2 1 2 BSP male thread When the final connection has been made it is essential that a thorough leak test is carried out on the hob and installa tion Make sure that the main connection pipe does not exert any strain on the hob If you use flexible metal pipes make sure that they agree to ISO 10380 and ISO 10807 standards Be careful they do not come in touch with mobile parts or they are not squeezed Also be careful when the hob is put together with an oven A is important to install the elbow correctly with the shoulder on the end of the thread fitted to the hob connecting pipe Failure to ensure the correct as sembly will cause leakage of gas A A Rigid connection Make sure that the gas supply pressure of the appliance obeys the recommended values
18. tions let only a qualified electrician or a compe tent person to replace the mains cable Do not try to replace it if you are not qualified to do that 7 6 Replacement of the connection cable replace the connection cable use only 2 HO5V2V2 F T90 or equivalent type Make 1 2 0 sure that the cable section is applicable to the voltage and the working temperature The yellow green earth wire must be ap proximately 2 cm longer than the brown or black phase wire A Green and Yellow B 3 amp fuse 7 7 Building In C Brown D Cord clamp E Blue min 600 mm Should you need to replace the plug for any reason the wires in the mains lead are coloured in accordance with the fol min 450 mm min 650 mm lowing code Green and yellow Earth Blue Neutral Brown Live 1 Connect the green and yellow earth wire to the terminal in the plug which is marked with the letter E or the earth symbol or coloured green Sa and yellow 2 Connect the blue neutral wire to the M A terminal in the plug which is markeq with the letter N or coloured black 3 Connect the brown live wire to the terminal in the plug which is markeq with the letter L or coloured red There must be no cut or stray strands of wire present The cord clamp must be correctly attached on the outer sheath N WARNING Make sure that the cut off
19. us ere lt Electrolux 9363 USER MANUAL 2 wwweelectrolux com CONTENTS 1 SAFETY INFORMATION 3 eee seen en See 3 2 PRODUCT DESCRIPTION rot RUE De esaet Peg trate 5 3 DAILY USE sur p RERO Re RE Ae Chee de FR ROCA 5 4 HELPFUL HINTS AND TIPS ne ERE REN ee EE e tnn nei niens 6 5 GARE AND CLEANING unr mng sin ooa A i qa usia XO RU sup up BCE NS E 7 6 TROUBLESHOOTING crat uci acce oo isea tp ae ew ok 8 Te INSTALLATIONS 21 nmt dtd it baat dae REPRE E re Res x S deg 9 8 TECHNICAL INFORMATION m s 18 9 ENVIRONMENT CONCERNS i ete ineo ale AA eRe 14 WE RE THINKING OF YOU Thank you for purchasing an Electrolux appliance You ve chosen a product that brings with it decades of professional experience and innovation Ingenious and stylish it has been designed with you in mind So whenever you use it you can be safe in the knowledge that you ll get great results every time Welcome to Electrolux Visit our website for Gi Get usage advice brochures trouble shooter service information 483 www electrolux com 7 Register your product for better service www electrolux com productregistration Buy Accessories Consumables and Original spare parts for your appliance w www electrolux com shop CUSTOMER CARE AND SERVICE We recommend the use of original spare pa
Download Pdf Manuals
Related Search