Brinkmann Max Million II
Contents
1. ANY LIABILITY FOR INDIRECT INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE MAX MILLION I RECHARGEABLE LIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED CUSTOMER ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY SET OUT ABOVE SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE 140 2655 0 5 02 7 02 8 03 Owner s Manual for Model 6 04 10 05 800 2655 2 amp 800 2655 12. INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 ai gaes 1 BRINCMANN th SSE we READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS MANUAL TO AVOID PERSONAL INJURY OR PROPERTY DAMAGE 2 000 000 A WARNING TO PREVENT DAMAGE TO AN D LE P WE R EYESIGHT NEVER LOOK INTO SPOTLIGHT WHEN LIGHT IS ON DO NOT SHINE LIGHT INTO THE FACE OF SOMEONE ELSE ILLION II SPOTLIGHT OWNER S MANUAL OPERATING INSTRUCTIONS INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 ai gaes 2 IMPORTANT SAFETY WARNINGS A READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER S MANUAL BEFORE OPERATING SPOTLIGHT A WARNING e Never place spotlight face down when light is on or is still hot from recent use Doing so could burn ignite surfaces such as seats carpeting etc and cause major property damage Always turn spotlight off when not in use e To prevent serious damage to eyesight never look into spotlight when light is on DO NOT shine light into the face of someone else e DO NOT touch lens of spotlight when light is on or if it was recently on The lens will be hot and could cause serious burns e DO NOT place spotlight in water Keep all components dry and out of water at all times e DO NOT allow children to handle or operate this spotlight e DO NOT use this product for other than its intended use e DO NOT charge or operate in close proximity of combustible or flammable materials e DO NOT c
3. Step 13 Step 14 Holding the front housing secure slowly lift the rear housing off Pull reflector away from rear housing being careful not to pull wire connections inside Do not touch the inside of reflector The glass lens is not attached to front housing Use care when disassembling to avoid breaking lens Pinch the ends of the wire retainer together and lift up as illustrated Pull bulb straight out from the reflector mounting plate Disconnect bulb wire from connector by holding the connector firmly with fingers then pulling bulb wire straight out To install new bulb grasp the bulb from the metal end DO NOT TOUCH THE GLASS PART and insert into the reflector mounting plate Align the slots in the bulb base with those in the reflector mounting plate Replace wire retainer by pinching ends together while pressing down Push ends apart so they catch on the reflector mounting plate Reconnect the bulb wire to the connector as illustrated To reassemble place the front housing face lens down on a flat surface Set the reflector into the rear housing Insert the rear housing into the font housing of the spotlight Replace the two screws that were removed in Step 3 Do not over tighten screws Replacement bulbs may be purchased from The Brinkmann Corporation Customer Service Department by calling 800 468 5252 INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 mies 7 Step 1 Disconnect spot flood light from power s
4. and skin If contact occurs flush immediately with large amounts of water DO NOT ingest If contact with eyes or ingestion occurs consult physician immediately Step 4 Place charged battery inside light so that metal contacts on battery and light are making contact Note Press battery firmly until fully inserted and locked with quick release tabs For extended lighting requirements we recommend purchasing an additional battery as a back up Additional replacement batteries may be purchased from The Brinkmann Corporation Customer Service Department by calling 800 468 5252 Only use Brinkmann s 12V75W halogen bulb that is designed for the Q Beam Max Million Rechargeable spotlight as a replacement Use To Replace Bulb of any other bulb may result in poor performance and may damage Rear your spotlight Housing Reflector IMPORTANT Do not touch the glass part of bulb with fingers as natural oils affect the life and performance of bulb Handle bulb by metal end only Step 1 Disconnect spotlight from power source Step 2 Remove battery from spotlight Step 3 Remove the two screws from top and bottom of front housing Front Glass Lens Housing Step 4 Lay the spotlight face lens down on a flat surface INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 a gaes 6 Connector Connector Step 5 Step 6 NOTE Step 7 Step 8 Step 9 Step 10 Step 11 Step 12
5. ONS A READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER S MANUAL BEFORE OPERATING SPOTLIGHT Inspect contents of the box to ensure all parts are included and undamaged Part List Q Beam Max Million I Rechargeable Spotlight Rechargeable Battery Extra Battery with Model 800 2655 1 12 volt DC Charger Adapter 4 120 volt AC Charger Owner s Manual To Operate IMPORTANT Unlock and turn spotlight OFF before charging Step 1 Follow charging instructions on page 3 of this manual and allow from AC or DC outlet The battery cannot charge if battery to fully charge the spotlight is ON Leaving spotlight ON during charging may cause damage to battery and AC Step 2 Depress trigger switch in handle to turn spotlight ON Release charger trigger switch to turn spotlight OFF 12 volt DC charger adapter operates from a R cigarette lighter receptacle for charging battery in Step 3 To lock trigger switch to ON depress trigger switch and slide spotlight or continuous corded operation with or down lock button on side of handle To unlock and turn spotlight without battery OFF depress trigger and slide lock button up NOTE prevent car battery from completely A WARNING Never place spotlight face down when light is on or is still discharging it is recommended that car hot from recent use Doing so could burn ignite surfaces
6. ch upon examination shall indicate to Brinkmann s satisfaction they are defective If Brinkmann confirms the defect and approves the claim Brinkmann will elect to repair or replace the rechargeable light as covered by the terms of this warranty e This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers The Brinkmann Corporation requires reasonable proof of purchase Therefore we strongly recommend that you retain your sales receipt or invoice To obtain repair or replacement of your Max Million I Rechargeable Light under the terms of this warranty please call Customer Service Department at 800 527 0717 for a Return Authorization Number and further instructions A receipt will be required Rechargeable lights returned to Brinkmann must include your name address and telephone number Please make sure the light is properly packed postage prepaid and insured A Return Authorization Number must be clearly marked on the outside of the box Brinkmann cannot be responsible for any rechargeable lights forwarded to us without a Return Authorization Number EXCEPT AS ABOVE STATED THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO 1 YEAR FROM THE DATE OF PURCHASE SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU
7. engine remain running while in use such as seats carpeting etc and cause major property damage Always turn spotlight off when not in use e life expectancy of the battery is approximately 500 cycles at which time a replacement battery is recommended A replacement battery may be purchased from The Brinkmann Corporation Customer Service Department by calling 800 468 5252 not allow battery to completely discharge A dim light indicates a Lock Button low battery Turn OFF and UNLOCK spotlight and recharge battery as soon as possible 1 Trigger Switch INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 a gaes 4 To Charge Contains lead acid Pb batteries Batteries must be recycled or disposed of properly THE BATTERY CAN BE CHARGED INSIDE OR OUTSIDE OF SPOTLIGHT To Charge Battery Inside of Spotlight Step 1 Step 2 Step 3 WARNING Make sure the trigger switch is not locked ON Plug the AC charger directly into back of battery or DC charger adapter into bottom of spotlight handle Note L E D Indicator light will turn on when battery is charging from AC charger only For DC Charger Adapter Battery charges only while vehicle engine is running For AC Charger Allow battery to fully charge L E D indicator on battery will automatically turn off when battery is fully charged See chart for recommended charge times Charge Times Charge ti
8. harge battery in gas tight enclosures e DO NOT attempt to charge battery pack using both AC and DC chargers at the same time e DO NOT attempt to charge or operate this spotlight if cord plug battery bulb or any part of the spotlight is damaged or corroded e DO NOT allow metal parts to touch metal contacts on battery as this can cause a short circuit and result in a fire DO NOT use an outdoor AC outlet to recharge battery e prevent accidental electrical shock we recommend this product always be charged on a GFCI Ground Fault Circuit Interrupter outlet e Only use charging devices that are provided with the Q Beam Max Million Rechargeable Spotlight or its replacements e DO NOT disassemble or tamper with the battery e DO NOT dispose of battery in fire as this may result in explosion e When disposing of battery place electrical tape over metal contacts on battery to prevent short circuit which could cause a fire e sealed battery contains lead and must be recycled or disposed of properly Contact your local county solid waste authority for proper recycling or disposal information USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR RECHARGEABLE LIGHT FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE SAVE THIS MANUAL FOR FUTURE REFERENCE INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 a gaes 3 OPERATING INSTRUCTI
9. mes are dependent on usage of the product See chart below for recommended charge times DC Charge Tar AC Charge USAGE Minutes 4 6 8 10 CHARGE TIME Hours A damaged battery can leak acid Avoid contact with eyes and skin If contact occurs flush immediately with large amounts of water DO NOT ingest If contact with eyes or ingestion occurs consult physician immediately IMPORTANT If battery is not used for more than 90 days remove battery from the spotlight Charge battery every 2 months to ensure battery does not completely lose charge A completely discharged battery may not recharge properly INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 mies 5 To Charge Battery Outside of Spotlight Step 1 Remove battery from back of spotlight by pressing on the quick release tabs Step 2 Plug the AC charger into battery as illustrated Note L E D Indicator light will turn on when battery is charging from AC charger only Step 3 For AC Charger Allow battery to fully charge L E D indicator on battery will automatically turn off when battery is fully charged IMPORTANT If battery is not used for more than 90 days remove battery from the spotlight Charge battery every 2 months to ensure battery does not completely lose charge A completely discharged battery may not L E D Indicator Light recharge properly Ay WARNING A damaged battery can leak acid Avoid contact with eyes
10. ource Step 2 Unscrew cap of lighter plug and pull straight away from fuse Step 3 Pull fuse holder and fuse out of lighter plug Observe to see if fuse is burned out NOTE Use a 8A fuse only Fuse is burned out when fuse element is missing or broken inside glass tube Replace with new 8A fuse if fuse element is missing or broken Step 4 Pull fuse out of fuse holder Insert new fuse into holder Step 5 Insert fuse holder and fuse into lighter plug Step 6 Screw cap onto lighter plug To Prevent Damage to Spotlight and Battery Do not attempt to use spotlight while charging directly from AC outlet Doing so may cause damage to battery and AC charger 12 volt DC charger adapter operates from a cigarette lighter receptacle for charging battery in spotlight only while vehicle engine is running or continuous corded operation with or without battery Do not attempt to charge battery pack using both AC an DC chargers at the same time Only use charging devices that are provided with the Q Beam Max Million I Rechargeable Spotlight or its replacements For DC Charger Adapter Battery charges only while vehicle engine is running For AC Charger Allow battery to fully charge L E D indicator on battery will automatically turn off when battery is fully charged See chart for recommended charge times Do not allow battery to completely discharge A dim light indicates a low battery Recharge battery as soon as possible after each u
11. se Always keep the battery fully charged when not in use To Replace Cigarette Lighter Plug Fuse Lighter Plug Lighter Cap Fuse y Po Fuse Holder Lighter Plug Charging Tips Charge Times Charge times are dependent on usage of the product See chart below for recommended charge times USAGE Minutes 20 4 1 DC Charge X 4 6 8 10 CHARGE TIME Hours INSTR_800 2655 2 MM2_10 05 qxd 10 14 05 10 48 8 2002 The Brinkmann Corporation Dallas Texas 75244 U S A www brinkmann net 1 YEAR LIMITED WARRANTY For 1 year from date of purchase The Brinkmann Corporation warrants the Max Million Million I Rechargeable Light against defects due to workmanship or materials to the original purchaser The Brinkmann Corporation s obligations under this warranty are limited to the following guidelines e This warranty does not extend to the bulb or battery e This warranty does not cover rechargeable lights that have been altered or damaged due to normal wear abuse improper maintenance improper use disassembly of parts and or attempted repair by anyone other than an authorized employee of The Brinkmann Corporation e This warranty does not cover surface scratches or weathering as this is considered normal wear e Warranty service is limited to repair or replacement of rechargeable lights which prove defective under normal use and whi
Download Pdf Manuals
Related Search