Chief PAC735A
Contents
1. 2 L 2 5 16 18 x 5 8 5 16 8x 1 2 5 16 18 1 4 Key Installation Instructions PAC735 ASSEMBLY AND INSTALLATION Assemble Base Support 1 Place left wedge plate B and right wedge plate on a flat surface with threaded bolts facing up See Figure 1 2 Place front cross bar E and rear cross bar F on top of wedge plates and insert bolts through corresponding holes on cross bars See Figure 1 3 Install eight 5 16 18 hex nuts J over each threaded bolt and tighten until cross bars are secured to wedge plates See Figure 1 Figure 1 Attach Base Support to Cart 1 Partially install two 5 16 18 x 1 2 square head cap screws H and two 1 4 flat washers K into side holes on wedge plates DO NOT TIGHTEN See Figure 2 NOTE Screws should protrude approximately 1 8 beyond wedge plate edge Figure 2 2 Slightly loosen approximately three turns the front button head cap screw on either side of the cart base See Figure 3 NOTE Only one screw should be loosened on only one side of the cart base 3 Place base support inside legs of cart and push toward cart back See Figure 3 Base ISS Figure 3 PAC735 Installation Instructions 4 Push base support back until it snaps in behind front cap of cart base See Figure 4 5 Tighten button head cap screw on cart side which was loosened in Step 2 See Figure 42. 6 Tighten two 5 16 18 x 1 2 square head cap screws H from Step 1 further into cart until base support is secured to cart See Figure 5 Front cap of cart Base support Figure 4 Mount Storage Cabinet 1 Place storage cabinet A on top of base support See Figure 5 A Figure 5 2 Place clamp bracket D around cart stand and line up with holes on back of storage cabinet A See Figure 6 3 Insert four 5 16 18 x 5 8 button head cap screws G through clamp bracket holes and into holes on back of storage cabinet A See Figure 6 rear view Figure 6 4 Open either door on accessory to install remaining four 5 16 18 hex nuts J onto four 5 16 18 x 5 8 button head cap screws G until accessory is fully secured to cart stand See Figure 6 NOTE Up to three storage cabinets can be stacked vertically on top of each other per cart stand Repeat steps 1 4 for additional cabinets and use holes on top of cabinets to bolt cabinets together Rack Installation Optional 1 Open windowed door 2 Slide rack equipment not included into storage cabinet NOTE Each storage cabinet supports 19 483 mm wide rack mount equipment and has a capacity of 4 U 3 Use 10 32 cage nuts not included to secure storage racks to storage cabinet Installation Instructions PAC735 PAC735 Installation Instructions CHIEF Our Mounts Yo
3. INSTALLATION INSTRUCTIONS Secure Storage Cabinet S CHIEF PAC735 Our Mounts Your PAC735 Installation Instructions DISCLAIMER Milestone AV Technologies and its affiliated corporations and subsidiaries collectively Milestone intend to make this manual accurate and complete However Milestone makes no claim that the information contained herein covers all details conditions or variations nor does it provide for every possible contingency in connection with the installation or use of this product The information contained in this document is subject to change without notice or obligation of any kind Milestone makes no representation of warranty expressed or implied regarding the information contained herein Milestone assumes no responsibility for accuracy completeness or sufficiency of the information contained in this document Chief is a registered trademark of Milestone AV Technologies All rights reserved A IMPORTANT WARNINGS AND CAUTIONS WARNING A WARNING alerts you to the possibility of serious injury or death if you do not follow the instructions DIMENSIONS A CAUTION A CAUTION alerts you to the possibility of damage or destruction of equipment if you do not follovv the corresponding instructions WARNING Failure to read thoroughly understand and follow all instructions can result in serious personal injury damage to equipment or voiding of factory warranty I
4. t is the installer s responsibility to make sure all components are properly assembled and installed using the instructions provided WARNING Exceeding the weight capacity can result in serious personal injury or damage to equipment It is the installer s responsibility to make sure the combined weight of all equipment stored within the PAC735 does not exceed 40 Ibs 18 14 kg LI DOORWOTSHO WH DIMENSIONS MILLIMETERS INCHES Installation Instructions PAC735 LEGEND Tighten Fastener Apretar elemento de fijaci n Befestigungsteil festziehen Apertar fixador Serrare il fissaggio Bevestiging vastdraaien Serrez les fixations Pencil Mark Marcar con lapiz Stiftmarkierung Marcar com lapis Segno a matita Potloodmerkteken Marquage au crayon Loosen Fastener Aflojar elemento de fijaci n Befestigungsteil l sen Desapertar fixador Allentare il fissaggio Bevestiging losdraaien Desserrez les fixations Drill Hole Perforar Bohrloch Fazer furo Praticare un foro Gat boren Percez
5. un trou Phillips Screwdriver Destornillador Phillips Kreuzschlitzschraubendreher Chave de fendas Phillips Cacciavite a stella Kruiskopschroevendraaier Tournevis a pointe cruciforme Adjust Ajustar Einstellen Ajustar Regolare Afstellen Ajuster Open Ended Wrench Llave de boca Gabelschl ssel Chave de bocas Chiave a punte aperte Steeksleutel Cl fourche Remove Quitar Entfernen Remover Rimuovere Verwijderen Retirez By Hand A mano Von Hand Com a m o A mano Met de hand la main Optional Opcional Optional Opcional Opzionale Optie En option ka y E 9 3 Hex Head Wrench Llave de cabeza hexagonal Sechskantschl ssel Chave de cabeca sextavada Chiave esagonale Zeskantsleutel Cl t te hexagonale Security Wrench Llave de seguridad Sicherheitsschl ssel Chave de seguran a Chiave di sicurezza Veiligheidssleutel Cl de s curit PAC735 Installation Instructions TOOLS REQUIRED FOR INSTALLATION ff 1 2 12 7mm 3 16 B 1 C 1 Left wedge plate Right wedge plate E 1 F 1 Front cross bar Rear cross bar Clamp bracket P ei Os G 4 H 2 J 12 K
6. ur Vision Chief Manufacturing a products division of Milestone AV Technologies 8807 002016 Revo1 2011 Milestone AV Technologies a Duchossois Group Company www chiefmfg com 01 11 USA International Europe Asia Pacific gt TI U 8401 Eagle Creek Parkwav Savage MN 55378 800 582 6480 952 894 6280 877 894 6918 952 894 6918 Fellenoord 130 5611 ZB EINDHOVEN The Netherlands 31 0 40 2668620 31 0 40 2668615 Office No 1 on 12 F Shatin Galleria 18 24 Shan Mei Street Fotan Shatin Hong Kong 852 2145 4099 852 2145 4477 SCH n D S
Download Pdf Manuals
Related Search