2004 Atwood Ranges service manual
Contents
1. Pilot flame cover 3 Oven pilot assembly hermal bulb Pilot t small oven flame heating slowly gt oven pilot will not go to high Safety flame pilot valve oven flame lifts off burner cycling too frequently Oven temperature bulb oven burner will not come on with high pilot Oven thermostat 9j i t aior Oven knob 10 R noe Cooking Appliance Atwood Mobile Products 4750 Hiawatha Drive Rockford IL 61103 1298 TROUBLE SHOOTING GUIDE PHONE 815 877 5700 FAX 815 877 7469 INTERNET http www atwoodmobile com Effective 8 27 01 Guides are only intended for use on Atwood products by service technicians who have successfully completed Atwood training This guide should be used in conjunction with the appropriate Instruction Manual provided with the product and any applicable Industry Standards This is not intended to be a complete list Please direct questions concerning service of Atwood products to 800 825 4328 before proceeding CAUSE SOLUTION RANGE PILOT WON T LIGHT OR STAY LIT Insufficient gas pressure 1 Check for gas leaks and have regulator checked by qualified LP gas technician 2 Check gas supply 3 Set pressure to 11 W C with two or more gas appliances running Supply valve closed Turn valve on Blo2. oa Atwood Mobile Products 4750 Hiawatha Drive Rockford IL 61103 1298 PHONE 815 877 5700 FAX 815 877 7469 INTERNET http www atwoodmobile com September 2003 INTRODUCTION The 2004 edition of the Atwood Range Service Manual is a resource created to help service technicians identify Atwood product by serial number diagnose service problems and efficiently and effectively process warranty claims Several changes to Atwood product offerings occurred in 2002 2003 The RV series manifold was changed from a square tube manifold to a round tube manifold The Atwood series RA had several components revised including the manifold burner valves burner tubes and stovetop For 2003 the Drop Ins were completely redesigned with a more residential look Each of the manuals within this series offers a general overview of the product as well as more specific product information For each product within the manual you will find model identification recommended tools and equipment a sequence of operation warnings annual maintenance procedures parts and troubleshooting guides warranty procedures flat rate schedules and replacement part reference charts Due to the rapidly changing personal computer revolution we have placed troubleshooting information in a variety of places to make sure that the most accurate information is available The best place to find the current information about Atwood products is our w
3. Screw Valve 56480 56480 3 Valve Bracket 56479 2 56479 3 Screw Burner 51325 5 Screw Top 56377 2 56377 2 Nylon Washer 2 2 51325 4 2 2 52434 2 52434 2 Burner Box 56498 56476 Inlet Pipe Grommet 92610 92610 Gasket Valve 56366 2 31 56366 3 ATWOOD DROP IN S AI Effective 2 24 97 D 26 SG D 21 D 26 D 21 D 26 D 26 SV D 21 D 31 ATWOOD DROP IN S o Effective 8 29 00 Atwood DAS 30 DAS 32E Drop in Cooktops PART REFERENCE SEPTEMBER 2003 Burner D 21 D 26 D 26SV D 26SG D 31 D 36 DA 20 DA 21 DA 30 DA 31 DA 31PE DAS 20 DAS 20E DAS 30 DAS 32E 56073 Burner LEFT 56075 Burner LEFT 56212 Burner LEFT 56302 Burner LEFT VALVE TUBE ASSEMBLY 56074 Burner RIGHT 56076 Burner RIGHT 56213 Burner RIGHT 56303 Burner RIGHT VALVE TUBE ASSEMBLY 56083 Burner LEFT REAR 56215 Burner LEFT REAR 56234 Burner LEFT REAR 56304 Burner LEFT REAR VALVE TUBE ASSEMBLY 56214 Burner LEFT FRONT 56082 Burner LEFT FRONT 56235 Burner LEFT FRONT 56305 Burner LEFT FRONT VALVE TUBE ASSEMBLY 56084 Burner RIGHT REAR 56216 B
4. Burner Knob BLACK Burner Knob WHITE Oven Thermostat Knob BLACK Oven Thermostat Knob WHITE Control Panel black Control Panel Electric white LABEL Piezo black LABEL Piezo white LABEL Electric black LABEL Electric white Wiring Harness Electronic Ignition Switches Wiring Harness Electronic Ignition Electrodes Wiring Harness Electronic Ignition Ground Wiring Lead Piezo Burner Box Burner Clips Oven Can Oven rack Oven shelf DOOR asmbly see DOOR CHART left Oven Door Handle BLACK Oven Door Handle WHITE Safety Valve Pilot Assembly Burner oven Oven Can Trim Safety Valve Plate KIT Door Seal KIT Gas Tube Kit Door Spring 17 Door Spring 21 Hinge Assy N S Towel Bar N S Not shown in illustration RV Series Range amp Slide In Match Light and Piezo order by c in illustration N S shown WEDGEWOOD VISION Oven amp Slide In Cooktop Parts Identification DESCRIPTION Grate BLACK RV 1732 RV 1731 RV 2132 RV 2131 CV 32 56272 5672 56272 56272 56272 Grommet total 4 1 each corner 53009 53009 53009 53009 53009 Top Bracket left 51131 51131 Top Bracket right 51130 51130 Range Top Assy WHITE 52007 52635 52007 5
5. a continually pressurized pipe distributing gas to top burner valves and oven valve Oven Thermostat supplies gas to the oven pilot the safety pilot valve and regulates the oven temperature PILOT ASSEMBLY Standby Pilot with the oven knob placed in the pilot position the oven valve will supply gas to the pilot assembly This standby pilot will stay lit until the oven knob is turned to the OFF position It also supplies the gas for the heater pilot V Heater Pilot on initial start up when the oven thermostat knob is turned to the desired temperature the volume of gas increases from the thermostat and the smaller standby pilot increases to a larger heater pilot flame This higher pilot flame heats the thermocouple thereby opening the safety pilot valve to allow gas to flow to the oven burner The heater pilot thereafter only comes on when the thermostat calls for heat V Safety Pilot Valve controls the gas flow to the oven burner The valve is operated by a thermal bulb located over the heater pilot When this bulb is heated it opens the safety pilot valve which then supplies gas to the oven burner V Oven Thermostat senses oven temperature by means of a thermal bulb located in the top of the oven The oven control knob is set to the desired temperature calling for heat the fluid expands in this bulb opens a seat in the thermostat and supplies gas to the safety pilot for the higher heater pilot This heater pilot i
6. re du comptoir NOTE Maximum countertop overhang 3 4 NOTE rebord maximum du comptoir 19 mm RECESSED BI FOLD COVER COUVERCLE PLIANT EN DEUX PARTIES ENCASTR LAMINATE MATERIAL MPD RV amp RAOVEN CV amp CA CUT OUT DIMENSIONS DIMENSIONS DE LA D COUPE MATERIAU STRATIFIE PART 17 21 SLIDE IN A A A B C D E F G 1 4 56397 16 0 20 0 3 0 17 75 20 0 2317 24 5 213 20 25 6 mm 406 mm 508 mm 76 mm 451 mm 508 mm 59 mm 622 mm 54 mm 514 mm 1 32 56391 16 0 20 0 3 0 17 75 20 0 1 84 24 5 2 13 20 25 8 mm 406 mm 508mm 76 mm 451 mm 508 mm 47 mm 622 mm 54 mm 514 mm SCHEMATIC DIAGRAM FOR ELECTRONIC IGNITION MODELS Burner Valve Switches Ss 12 VOLT DC G e e c IGNITION MODULE re 9 e ELECTRICAL RATING 12 VDC 0 6A For 12 VDC service DO NOT connect SPABRELESIRONES Y to higher voltage DO NOT connect TOP BURNERS to a circuit fused for more than 3A w CONNECTION DIAGRAM FOR ELECTRONIC IGNITION MODELS 12 volt Battery Sa Sal vv Burner Valve Switches Bo B RANGE HOOD MOUNTING INFORMATION 3 Connector Ignition Module A B C D Range Top 19 3 8 Mounting Trim 3 4 Range Top Depth 15 7 8 Range Top plus Oven Vent 19 9 16 R RED Wire G
7. 17 Warranty Procedures ttti 17 Replacement Part Reference RA 1731 RA 1730 RA 2131 RA 2130 CA 30 ttti He 18 19 RV 1732 amp 1731 RV 2132 amp 2131 CV 32 CV 30 aaneen 20 21 RW 1731 amp 1730 RW 2131 amp 2130 CW 30 semel poke du eee atleet nette etend 22 23 G toutand Wiring Diagrams x eee eet c ttd te de ol eti ng 24 25 C 37 amp 38 R 1737 R 1738 R 1746 R 2137 R 2138 R 2146 i 26 27 R 1730 R 1735 R 1736 R 2136 R 2140 R 2145 C 30 C 35 C 36 C 40 C 45 28 30 AAO DET 31 D 21 amp 26 D 26SV D 265G D 31 amp 36 DA 20 DA 21 DA 30 DA 31 DA 31PE DAS 20 amp 20E 32 35 Atwood Training Tapes and Manuals oRDER BLANK After reviewing this manual you should be able to answer the following questions Are the Harper Wyman and Robertshaw valves burners and manifolds interchangeable Can a Wedgewood range oven be converted from LP to natural gas What is the difference between the standby pilot and heater pilot What are the three functions of the oven thermostat What is the function of the oven safety valve What is the difference between High BTU and High Pressure How do you adjust the flame on the top burner and what should the flame look like after that adjustment What is the temperature tolerance range on the oven thermostat What is recommended to clean the oven with How long is it recommended to preheat the oven before placing food in it How many inch
8. 170 degrees Robertshaw system PART DIFFERENCES FOR ALL HIGH BTU RANGES AND MAINTOPS 3 Manifold shape and color Same oven control regulator safety pilot amp oven Both Robertshaw and Harper Wyman use a dull grey square burner as regular ovens amp cooktops Earlier models used 2 52123 burner valves on rear burners Manifolds top burners and maintops are different from standard ranges manifold pipe WARNING PERSONAL INJ URY amp PROPERTY DAMAGE Robertshaw and Harper Wyman gas systems cannot be interchanged 12 HARPER WYMAN SYSTEMS EARLY WEDGEWOOD MODELS WITH OLDER SYSTEMS Between the years of 1991 to 1993 our gas systems were divided between Harper Wyman and Robertshaw The serial numbers that involve a Harper Wyman and Robertshaw system would be in serial number series W73000 to W839999 The burner maintops and all cosmetic parts are the same The gas system will be the only difference DURING 1978 TO 1980 we used all black square manifolds with the above burner valve but we used a different oven control thermostat 3902262 which did not offer a constant burning pilot in oven They light the pilot on LOW TEMP AND THEN MOVE TO DESIRED TEMPERATURE When done cooking they simply turn to off The pilot had to light each time they got ready to use the oven This control is NO LONGER AVAILABLE however you can sub it with the following 51095 Oven control thermostat looks just like t
9. Hand top amp side black No longer available 53022 Right Hand top amp side black No longer available 53024 Right Hand top amp side black No longer available 53524 Right Hand top amp side No longer available 53025 Vent black X X X x K 53525 Vent black X 53526 Bottom black x x x x x K 53668 Bottom No longer available Manifold Cover 53072 Manifold Cover black No longer available 53553 Manifold Cover black No longer available 53556 Manifold Cover black No longer available Burner Box 51684 Burner Box x x x x x K 51685 Burner Box x Oven Rack 51069 Oven Rack X X X x x K Shelf 51657 Oven Bottom No longer available Pilot Assembly 51065 Oven x x x x x K 52242 Oven While Supply lasts use 51065 Knobs 51056 Burner package of 2 x x x x x K X 51057 Thermostat Knob x x x x x K Kits 51076 3 Burner Igniter Kit No longer available 51077 4 Burner Igniter Kit No longer available 51067 Gas Tube Kit 17 X X 51068 Gas Tube Kit 21 x K Grate Boots amp Clips 53160 Grate Boots amp Clips x x 29 Wedgewood Range amp Cooktops PART REFERENCE SEPTEMBER 2003 o Lo o o Lo DE DE EE SVERRE RD MR ERR ac cc cc cc cc cc o o o o o Door amp Door Parts XXXXX Door Assembly No longer available XXXXX Door Assembly black glass No longer available XXXXX Handle black glass doors No longer available XXXXX Solid door pane
10. numbers to consist of 5 digits only so Wedgewood took existing part numbers and dropped the 390 keeping the last four digits and added a 5 to the front example 3902281 became 52281 13 DURING THE YEARS OF 1972 TO 1978 the following systems were used We ve noted the replacements for these no longer available controls Serial numbers started with a J K G H and consisted of 5 to 6 digits 3901183 Oven control mounted to a black square manifold this control used two screws to mount it and the screws went completely through the oven control NO LONGER AVAILABLE USE 51095 Oven controL thermostat old 52281 looks different takes shorter screws for mounting MUST CHANGE KNOB FOR 51095 ro work Order oven knob 51059 old 52286 It is designed for the calibration of the control 3901175 Oven control mounted to a black square manifold This control installs the same as above however it had 3 ports on back one for center gas pilot NO LONGER AVAILABLE USE 51095 Oven control thermostat old 52281 It looks different and will DISCONTINUE the center pilot between burners on top To continue this feature you need to purchase new manifold pipe with ON and OFF valve for center pilot Knob also needs to be replaced with 51059 old 52286 3901184 Oven control mounted to a black square manifold for eye level ranges only NO LONGER AVAILABLE FOR SUBSTITUTE 3901224 Burner valve used with above controls same as 51224 or use blister pack number 51
11. the top vent on back of range it must be clear of all insulation etc Problem thermostat Replace thermostat Oven not preheated Oven must be preheated at least 10 minutes Thermo bulb out of position Thermobulb must be in clip on back of oven pans cannot touch thermo bulb 11 COOKING APPLIANCE continued Effective OVEN PILOT OUTAGE Safety Thermal Bulb out of position Problem thermostat Blocked oven vent Incorrect oven burner gas air mixture YELLOW FLAME TIPS Improper gas air mixture Low gas pressure RA Ranges and Cooktops Improper orifice to burner alignment 8 27 01 Re position the safety thermal bulb Replace thermostat Remove obstruction from vent Readjust air Adjust air shutter if applicable Check gas supply Check for leaks and have the regulator checked Set pressure to 11 water column Realign burner head and orifice tube assembly Replace orifice IDENTIFICATION OF OLDER WEDGEWOOD SYSTEMS Robertshaw Gas System Regular Ovens and Cooktop You can identify the system by one of the following Models Serial s begin with a W and consist of 6 example W840000 Robertshaw Gas System High BTU 3 burner Range and digits 1 Look at the oven control face plate behind the knob H W Harper Wyman R C C Robertshaw Control Co Cooktop Models Serial s begin with a SB and consist of 4 2 By looking at the first temperature on the oven knob to 9 digits 140 degrees Harper Wyman system
12. version NUMBER OF BURNERS 3 OVEN HEIGHT TYPE OF APPLIANCE RW Wedgewood w wide door range C W Wedgewood cooktop SPECIAL FEATURE HP high performance S T stainless top amp taupe frame SV stainless top on Volkswagen SG stainless top amp gray frame GRATE STYLE O round 5 designer 6 high output NUMBER OF BURNERS 2 3 4 TYPE OF APPLIANCE D drop in 4 Model Number Identification ATWOOD Range Oven and Cooktop with Sealed Burners and Slide In cooktops RA 21 3 0 B B E Lo TOP BURNER IGNITION P Rotary Piezo E Electronic DOOR COLOR B black glass 2 white glass S stainless gt TOP COLOR B black W white gt REVISION NUMBER O original version 1 version 2 version gt NUMBER OF BURNERS 3 gt OVEN HEIGHT TYPE OF APPLIANCE RA Atwood range C A Atwood cooktop slide in WEDGEWOOD VISION Range and Cooktops RV 21 3 1 B B P XNR UPS L lt UPS Shippable by UPS R Returnable package N Flush control panel gt X Extended gas tube TOP BURNER IGNITION P Rotary Piezo E Electronic gt DOOR COLOR B black G black glass S stainless I white 2 white glass 3 white panel handle 4 stainless panel white handle gt TOP COLOR B black W white Q bisque S stainless gt REVISION NUMBER 1 original version 2 effective 8 1 01 3 white panel white handle gt NUMBER OF BURNERS 3 gt OVEN HEIGHT gt TYPE OF APPLIANC
13. 068 KIT Gas Tube Kit 56150 56150 50005 Grate Clip 2 53008 53008 53008 Grate Boots 51128 51127 Knob Kits Wedgewood Range amp Cooktops PART REFERENCE e LO e i SEPTEMBER 2003 L l e 5 TS c i5 T T 7 b y X eo 2 Ex T T ac ac ac ac ac CC o o o o o Grates 51007 Tension x x 53006 Top single x 53007 Designer Dual x x 53050 Top 2 No longer available use 56271 56271 Hi BTU one piece 1 2 hole x x Flash Tubes 51089 Top Lighter Kit No longer available includes center cluster amp gas supply tube 51216 Flash Tube long Piezo x x x 51245 Flash Tube x x 51088 Top Lighter Kit No longer available 51089 Top Lighter Kit No longer available Burner 51235 Burner RIGHT REAR No longer available 51243 Burner RIGHT REAR No longer available 53070 Burner RIGHT REAR No longer available 51233 Burner RIGHT FRONT No longer available 51241 Burner RIGHT FRONT No longer available 51233 Burner CENTER FRONT No longer available 51234 Burner LEFT REAR No longer available 51242 Burner LEFT REAR No longer available 53068 Burner LEFT REAR No longer available 51232 Burner LEFT FRONT No longer available 51240 Burner LEFT FRONT No longer available 51244 Burner CENTER FRONT No longer available 53069 Burner CENTER high output x x 52018 Burner Oven x x x x x Air Shutter 51208 Air
14. 096 Still available from Atwood They only mount to BLACK SQUARE MANIFOLDS DROP INS Wedgewood also makes drop in models D20 D25 D30 D35 We have used this system approximately from the END OF 1992 TO 1995 however February and March of 1995 we changed one burner valve on D30 D35 models The front burner has been changed to a Hi BTU burner 6500 BTU valve on both burners for models D20 and D25 Burner valves that are regular 5200 BTU have a black face plate 6500 BTU valves have a gold face plate Maintops are ordered by Model number and color Before Atwood purchased Wedgewood in 1986 the model numbers were different Below is a cross reference chart WEDGEWOOD ATWOOD DISCONTINUED T212 C30 T312 C35 D20 T214 C40 T314 C45 D20 T2122 R1730 T3122 R1735 D25 T2130 R1740 T3130 R1745 D25 T2150 R2140 T3150 R2145 D35 T2142 D25SV D25ST S 25WHP If you have a Wedgewood Model number you can use the parts list for Atwood model numbers for cosmetic parts Depending on the age of the range the gas system may not be the same Gas system parts are ordered by either Model or Serial number Wedgewood Models numbers discontinued are as follow W7102 T2172LL W2172C W7103 W2172LL C7200 C7300 Terminology AGA Calibration CGA Electronic Ignition Heater Pilot Main Burner Orifice Manifold Oven Safety Valve Oven Thermostat Piezo Igniter COOKING APPLIANCE TERMINOLOGY Definition American Gas Association
15. 2635 52007 Range Top Assy BLACK 52008 52636 52008 52636 52008 Range Top Assy BISQUE 52009 52638 52009 52638 52009 Range Top Assy STAINLESS STEEL 56742 56742 56742 Burner Piezo LR 56156 56156 56156 56156 56156 Burner Matchlit LR 56159 56159 56159 56159 56159 Burner Piezo CF 56155 56155 56155 56155 56155 Burner Matchlit CF 56158 56158 56158 56158 56158 O1 07 O1 O1 0707 irc cr lo Burner Piezo RR 56154 56154 56154 56154 56154 Burner Matchlit RR 56157 56157 56157 56157 56157 Bushing Burner 53011 53011 53011 53011 53011 Brass Fitting 52294 52294 52294 52294 52294 Pressure Regulator 51062 51062 51062 51062 51062 3 Burner Manifold 50158 50158 50158 50158 50159 3 Burner Manifold round 53198 53198 53199 Bolt thru Valve 56088 56088 56088 56088 56088 Bolt Oven Thermostat thru Bol 2 56125 56125 56125 56125 Valve Burner Mini 9000 BTU NLA NLA Valve Burner Mini 9000 BTU 53201 53201 53201 53201 53201 zzz t 1 Valve Burner Mini 6500 BTU 2 1 Valve Burner Mini 6500 BTU 2 53200 53200 53200 53200 53200 Thermostat oven control 56116 56116 56116 56116 N Sol on IE I S WW gt gt gt gt Piezo Ignitor 56096 56096 56096 56096 56096 Piez
16. E RV Wedgewood Vision C V Wedgewood Vision cooktop ATWOOD Drop In Cooktop with Open Burners DA 2 0 B S E gt TOP BURNER IGNITION Electronic Ignition BURNER S sealed P porcelain gt TOP B black W white S stainless C chrome gt REVISION 0 1 2 version gt NUMBER OF BURNERS 2 3 gt TYPE OF APPLIANCE DA Atwood drop in DV Atwood drop in 5 Range amp Oven Gas Components Robertshaw LO Oven Control Thermostat Burner Valve Safety Pilot Valve The top burner components mounted on a silver square manifold Ranges in the serial number sequence WT30000 through W840000 used either this system or the Harper Wyman System On a Robertshaw system the following exists a the face of the oven control says R C C Robertshaw Control Company b the lowest temperature on oven knob is 170 c the face plate of oven control and burner valves have silver torx head screws Harper Wyman Oven Control Thermostat Maxi Burner Valve Safety Pilot Valve The top burner components mounted on a silver square manifold Ranges in the serial number sequence WT30000 through W840000 used either this system or the Robertshaw System On a Harper Wyman the following pertains a the face of the oven control says H W Harper Wyman b the lowest temperature on oven knob is 140 c the f
17. E ALLOWED 10 Payment for Warranty Service All parts are replaced at no charge freight prepaid upon our inspection Labor on net 30 accounts is paid by credit memo within 30 days of receipt of parts 11 Flat Rate Schedule A reasonable flat rate schedule for warranty repairs has been set for each Atwood product and or parts Should unusual circumstances take you beyond the standard time allowance you must have prior approval by contacting the Atwood Mobile Products Service Department at 1 800 825 4328 and press option 5 after the recording RA SERIES RANGE amp SLIDE IN Piezo and Electronic Ignition 30 DOOR CHART RA 1732 RA 1731 RA 1730 RA 2132 RA 2131 RA 2130 BLACK PANEL BLACK HANDLE 51977 1977 51983 51871 WHITE PANEL BLACK HANDLE 51978 1978 51984 51850 WHITE GLASS WHITE FRAME BLACK HANDLE 51982 1982 51988 51849 BLACK GLASS BLACK FRAME BLACK HANDLE 51980 1980 51986 51870 WHITE GLASS BLACK FRAME BLACK HANDLE 51981 1981 51987 STAINLESS PANEL WHITE HANDLE 51951 1951 DOOR Glass Insert Sm BLACK 51881 1881 DOOR Glass Insert Lg BLACK 51882 DOOR Glass Insert Sm WHITE 51883 1883 DOOR Glass Insert Lg WHITE 51884 DOOR Panel Sm BLACK door style w frame NLA use 51581 Lg BLACK door style w frame NLA use 51583 Sm WHITE door style w frame NLA use 51582 Lg wHITE door style w frame NLA use 51584 Sm BLACK new solid door style no trim Lg BLACK new solid door style no trim Sm WHITE new solid door style no t
18. E LP DETECTORS Atwood Mobile Products Salt Lake City Operations 1874 South Pioneer Road Salt Lake City UT 84104 CO DETECTOR KIDDE Safety 1 800 880 6788 1394 South Third Street Mebane NC 27302 RANGE COOK TOPS DROP INS SOL A VENTS Atwood Mobile Products Wedgewood Operations 6320 Kelly Willis Road Greenbrier TN 37073 Must Return Parts List Under Atwood s Warranty Administration Program we require with the return of warranty claims the specific parts noted below Failure to accompany your claims with these parts will result in the non shipment of a replacement part or the non processing of the appropriate credit until such time as the part is received by Atwood Before returning the part a RGN Return Goods Number must be obtained This number can be acquired for all products except seating by calling the Atwood Mobile Products Service Department at 1 800 825 4328 To obtain RGN s for seating components please call 1 219 522 7891 Without this RGN appearing on the outside of the shipping carton the shipment will be refused at our receiving department FURNACE SEATING COMPONENTS All parts All parts HARDWARE WATER HEATER Pouplers Complete water heaters Jacks Inner tanks Actuators Gas thermostat valves Circuit boards Gas solenoid valves Electric thermostats Heating elements Pilot assem blies Spark probe assemblies Master cylinders Shock absorbers Foundation brakes Power jacks Power jack motors Al
19. GEWOOD Range amp Slide In Match Light and Piezo order by color not shown in illustration N S WEDGEWOOD Oven amp Slide In Cooktop Parts Identification WEDGEWOOD DESCRIPTION RW 1731 RW 1730 Rw 2131 RW 2130 Grate 2 hole BLACK Grate Boot Grate Clip Range Top 2 hole WHITE Range Top 2 hole BLACK Range Top 2 hole ALMOND Burner Piezo left rear Burner Matchlit left rear Burner Piezo center front Burner Matchlit center front Burner Piezo right rear Burner Matchlit right rear Bushing Burner Brass Fitting Pressure Regulator 3 Burner Manifold Valve thru Bolt Bolt Oven Thermostat thru Bolt 2 Valve Burner Mini 9000 BTU 1 Valve Burner Mini 6500 BTU 2 Thermostat oven control Piezo Ignitor KNOB Piezo BLACK KNOB Burner BLACK KNOB Oven Thermostat BLACK Burner Box Manifold Cover LABEL without Piezo LABEL with Piezo TRIM Left hand BLACK TRIM Right hand BLACK TRIM Vent BLACK Top Retaining Clip 4 Oven Can Oven rack DOOR assembly includes handle BLACK steel DOOR assembly includes handle WHITE steel DOOR assembly includes handle ALMOND steel DOOR assembly includes handle WHITE glass DOOR assembly includes handle BLACK glass DOOR Glass Insert Sm BLACK DOOR Glass Insert Lg BLACK DOOR Glass Insert Sm WHITE DOOR Glass Insert Lg wHITE DOOR Panel Sm BLAC
20. GREEN Wire T W WHITE Wire OE e Wire Connection Wired by Installer 27 C 37 C 38 O O E 4 e 9 0 5 5 0 lt a 9 5 7 O 9 3 9 R 1737 R 1738 R 1746 R 2137 R 2138 R 2146 PART REFERENCE oo og CM TR EE N EK T 00 CO e 4 o ge 28 Su o ce Te e B N er 00 St Ww Sr co Bau Tou oz o LO I Fa E oO m XD a o E OD o o e E gt B 22 z cc LU z Effective 10 1 96 26 WEDGEW OOD Oven amp Slide In Cooktop Part Reference ITEM R 1737 R 1746 R 2137 56271 R 2146 DESCRIPTION Grate 1 piece 1 2 53582 53582 skRange Top 2 hole ALMOND 2 53583 skRange Top 2 hole BLACK 2 53584 53584 skRange Top 2 hole WHITE 3 52294 52294 Fitting Brass 4 51062 51062 Pressure Regulator 5 56160 3 Burner Manifold 6 56088 56088 Valve thru Bolt 53200 53200 Valve Burner MiNI 6500 BTU 2 53201 53201 Valve Burner MINI 9000 Bru 1 56096 56096 Piezo Igniter 51344 51344 Piezo Knob 51337 51337 10 x 3 8 Screw 2 56148 56148 Knob burner 56097 56097 Wire Assembly 3 56108 56108 Control Panel Assembly Matchlit 56107 56107 Control Panel Assy w piezo 53023 53024 53023 53024 Trim left hand top
21. K DOOR Panel Lg BLACK DOOR Panel Sm WHITE DOOR Panel Lg WHITE Oven Door Handle BLACK Safety Valve Pilot Assembly Burner oven TRIM Oven Can Enamel Door Liner Wiring Lead Piezo KIT Door Seal KIT Gas Tube Kit CABINET amp COUNTER CUT OUT CHART D 26SLG D 26SV CUT OUT DIMENSIONS D DAModels 2 Burners 11 5 8 16 3 8 D DA Models 3 Burners 16 1 16 19 3 16 D 26SLG 19 14 1 8 D 26SV 11 5 8 Minimum dimension 9 Overall depth of cooktop 16 3 8 CONNECTION DIAGRAM FOR ELECTRONIC IGNITION MODELS 12 volt r Battery Burner Valve Switches RENE tirs G GREEN Wire W WHITE Wire gt Wire Connection 4 Connector Wired by Installer Flgnition Module w Top Burners CUT OUT CHART Model A B C D IN IN IN IN 2 burners 16 3 8 11 3 8 4 3 4 2 1 4 24 CABINET amp COUNTER CUT OUT CHART RECESSED BI FOLD COVER CUT OUT CHART Notch for N Series only All Ovens All Slide In Cooktops Recessed Bi Fold Cover CABINET amp COUNTER CUT OUT CHART TABLEAU DE DECOUPE DES ELEMENTS ET DU COMP
22. NDLE 51957 DOOR asmbly w handle STAINLESS BLACK HANDLE 51958 DOOR Glass Insert Sm BLACK 51881 51881 DOOR Glass Insert Lg BLACK 51882 DOOR Glass Insert Sm WHITE 51883 51883 DOOR Glass Insert Lg WHITE 51884 DOOR Panel Sm BLACK door style with frame NLA use 51581 51885 51885 DOOR Panel Lg BLACK door style with frame NLA use 51583 51886 DOOR Panel Sm WHITE door style with frame NLA use 51582 51887 51887 DOOR Panel Lg WHITE door style with frame NLA use 51584 51888 DOOR Panel Sm BLACK new solid door style no frame 51581 DOOR Panel Lg BLACK new solid door style no frame 51583 DOOR Panel Sm WHITE new solid door style no frame 51582 DOOR Panel Lg WHITE new solid door style no frame 51584 DOOR Panel Sm STAINLESS new solid door style no frame 51578 Oven Door Handle BLACK 51124 51124 51124 Oven Door Handle WHITE 51126 51126 Safety Valve 56120 56120 56120 Pilot Assembly 56121 56121 56121 Burner oven 56123 56123 56123 Oven Can Trim 51975 51976 51976 Safety Valve Plate 56139 56139 56139 Wiring Lead Piezo 56097 56097 56907 56097 KIT Door Seal 51060 51061 51061 KIT Gas Tube Kit 51067 51068 51068 Hinge Assy 51972 51991 51991 U Channel Edge Guard 53218 53218 53218 53218 WED
23. Shutter x x Extreme Pressure Regulator 51062 Extreme Pressure Regulator Kit x x x x x x 52154 Extreme Pressure Regulator No longer available use 51062 Manifold Robertshaw 52125 3 burner manifold No longer available 52126 3 burner manifold silver square R S No longer available 53049 3 burner manifold silver square R S No longer available 52284 4 burner manifold black square R S No longer available Burner Valves 51096 valve No longer available 52123 valve No longer available Supply Valves 51066 Top Pilot Valve Kit x 52282 Top Lighter No longer available use 51066 53014 Rear Valve x x x 53047 High Output Valve x x 28 Wedgewood Range amp Cooktops o 1 w CD CD CD CD PART REFERENCE XI RIR SI Z sigle se g SEPTEMBER 2003 t do 6 66 o Safety Valve 51063 Safety Valve Kit No longer available 51177 Safety Valve No longer available High Output Spark Igniter Assembly 53078 High Output Spark Igniter Assembly No longer available Piezo 52279 Piezo Push Button x x x K X Thermostat 51095 Oven control fits black square manifold No longer available must also order 51059 knob 52122 Oven control fits grey manifold No longer available Trim 53021 Left Hand top amp side black No longer available 53023 Left Hand top amp side black No longer available 53523 Left
24. TOIR CUT OUT DIMENSIONS DIMENSIONS DE LA D COUPE B C D E F G t TT dut Read EVE ET ET z z PIG ET materials typical two 2 sides and bac Hi RY amp RA Ranges 17 3 4 20 1 4 1 3 4 t 16 0 1 3 4 1 1 2 The overall unit depth for CA models with S rie RA 17 451 mm 514 mm 45mm 406mm 0mm 45 mm 38 mm Electronic Ignition is 18 1 4 from 21 RV amp RA Ranges 17 3 4 20 1 4 1 3 4 20 0 1 3 4 1 1 2 cabinet face to back wall of cutout below S rie RA 21 451 mm 514 mm 45 mm t 508mm Omm 45 mm 338 mm counter uk n Suge amp CA 17 3 4 20 1 4 1 3 4 t 3 0 1 3 4 1 1 2 1 loignement minimum des mat riaux S rie CA encastrement 451 mm 514mm 45 mm 76 mm 0mm 45 mm 38 mm combustibles Typiquement sur les deux 17 RV amp RA N Series 17 3 4 20 1 4 1 3 4 16 7116 1 3 4 1 1 2 c t s et l arri re S rie RW 43cm RW et RA N 451 mm 514 mm 45mmt 406mm 11 mm 45 mm 38 mm La profondeur totale des mod les CA 21 RV amp RA N Series 17 3 4 20 1 4 1 3 4 t 20 7116 1 3 4 1 1 2 allumage lectronique est de S rie RW 53cm RW et RA N 451 mm 514 mm 45mm t 508mm 11 mm 45 mm 38 mm 464 mm Ces dimensions sont celle de Slide In CV amp CA N Series 17 314 20 14 1 3 4 3 7h16 1 3 4 1 1 2 la d coupe entre la facade de l l ment S rie CW encastrement CW et CA N 451 mm 514 mm 45mm t 76mm 11mm 45 mm 38 mm de MB et la paroi arri
25. The condition that determines whether the thermostat is registering temperatures properly Canadian Gas Association 12v DC module activated by switch to ignite top burners An extension of the standby pilot that opens the oven safety valve to enable gas to flow to the oven burner A precision drilled thimble shaped component that meters gas flow to the main burner The constantly pressurized tube or pipe that supplies gas to the burner valves The valve that controls the gas flow to the main burner It is the component that regulates the temperature of the oven at the desired cooking temperature and supplies gas for both the standby and heater pilots An electro mechanical device that can be used to ignite a top burner 14 Terminology Pilot Orifice Regulator Sealed Burner Standby Pilot Thermal Bulb Top Burner Lighter Pilot UL Yellow Tipping Definition A precision drilled thimble shaped component that meters gas flow to the pilot Device that reduces the high pressure from the LP bottles to a lower pressure for the appliances A burner head attached directly to the porcelain main top which prevents spilling to the burner box The oven pilot that burns constantly and provides the base for the heater pilot The bulb located in the oven and connected to the thermostat that contains thermal fluid and causes the thermostat to close and open based on the set cooking temperature T
26. ace plate screws on the burner and oven valves are black and have octagonal heads Range amp Oven Gas Components Combination Harper Wyman Robertshaw Robertshaw Oven Control Harper Wyman Mini Burner 2 Thermostat Valve Robertshaw Safety Pilot Valve Products whose model number is R or C ___7 ___ have combined system R2137 ABP Top burner system is Harper Wyman Lowest temperature on oven knob is 170 Oven control system is Robertshaw Harper Wyman Harper Wyman Oven Control Harper Wyman Mini Burner Thermostat Valve Safety Pilot Valve Range Ovens whose model number is R 8 ___ to current model have a complete Harper Wyman oven and range valve system Cooktops whose model number is C 8 to current model have a complete Harper Wyman range valve system Top burners are Harper Wyman and linear Lowest temperature on oven knob is 170 Oven control and safety pilot valve are also Harper Wyman 7 Regulators Maxitrol Harper Wyman Standard Pressure Regulator Used on all of our standard drop ins cooktops and ranges Regulate pressure at 10 W C High Pressure Regulator Product Serial begins with HP Pressure is 16 psi Special cooking appliances designated for outdoor use only Sequence of Operation Standard Pressure Regulator this valve receives up to 13 W C pressure gas from LP bottles and reduces it to 10 W C for the manifold V Manifold
27. amp side blk Trim right hand top amp side blk 53525 53525 Trim vent black 53526 53526 Trim bottom black 51684 51684 Burner Box 53011 53011 Burner Bushing 56071 56071 Burner ctr hi output Matchlit 56068 56068 Burner ctr hi output w Electrode Burner left front 56069 56069 Burner left rear Matchlit 56066 56066 Burner left rear w electrode 56070 56070 Burner right rear Matchlit 56067 56067 Burner right rear w electrode Burner right front 52120 56125 Screw Thermostat 2 NA 56114 Thermostat oven control 53001 56171 Knob oven thermostat 51069 51069 51069 Oven rack NO LONGER AVAILABLE Door assembly NO LONGER AVAILABLE Enamel door liner w window NO LONGER AVAILABLE Enamel door liner NO LONGER AVAILABLE Solid door panel When replacing top you MUST replace grate When replacing Burner Knobs use Knob Kit 53426 53426 53426 Insert black glass NO LONGER AVAILABLE Insert black glass w wndow 51421 51421 51421 Window inner assembly 51112 51112 51112 Oven Door Handle 56120 56120 Safety Valve 51065 56121 56121 Pilot Assembly 51063 Pilot Assembly MSC valve 52018 56123 56123 Burner oven 51061 51061 51061 KIT Door Seal 51071 51071 51071 KIT Designer Acc 51068 51068 51
28. cked pilot orifice or Clean pilot orifice with toothpick clean flash tubes blocked flash tubes Pilot flame cover out of position Reposition pilot flame cover and or remove carbon and or coated with carbon build up BURNER S WON T LIGHT OR STAY LIT Insufficient gas pressure Check for gas leaks have regulator checked by qualified LP gas technician Incorrect air gas mixture Adjust air shutter if applicable Blocked orifice Clean with toothpick BURNER LIGHTS BUT FLAME IS TOO SMALL Improper gas pressure Check for gas leaks have regulator checked by qualified LP gas technician Improper air gas mixture Adjust air shutter if applicable Problem burner valve Replace burner valve Blocked orifice Clean with toothpick BURNER FLAME LIFTS OFF BURNER HEAD Gas pressure too high Have regulator check by a qualified LP gas technician OVEN BURNER LIGHTS BUT FLAME REMAINS VERY SMALL AND OVEN HEATS VERY SLOWLY Improper gas pressure Check for gas leaks have regulator checked by qualified LP gas technician Blocked orifice Clean with alcohol and cotton swab OVEN BURNER FLAME LIFTS OFF BURNER AND OVEN CYCLES TOO FREQUENTLY Gas pressure too high Have regulator checked by qualified LP gas technician or improper gas mixture OVEN COOKS UNEVENLY AND OR FOOD BURNS ON THE BOTTOM Poor oven ventilation Oven too full for proper circulation must have 1 clearance in all directions Ventilation holes in oven bottom shelf above burner are covered Check
29. e Assembly 56302 Left 56303 Right 56305 Left front 56304 Left rear 56306 Right rear 56309 Left front 56308 Left rear 56310 Right rear gt gt lt gt lt 35 NOTES THIS PAGE INTENTIONALLY LEFT BLANK 36
30. ebsite www atwoodmobile com At our website brochures may be downloaded trouble shooting guides reviewed and the latest information bulletins can be read In addition all Atwood Authorized Service Centers are listed on our site accessible via an easy to use search system Service for all Atwood products is handled out of our Rockford location Should you have any questions regarding our products or the information contained in this manual simply dial 1 800 825 4328 Be sure to have the Model and Serial Number when you call Atwood Service Department Disclaimer The data presented in this publication is obtained from the most reliable sources and is believed to be accurate as of the date of publication Responsibility for typographical errors or omission of data cannot be assumed by the publishers 1 TABLE OF CONTENTS Atwood amp Wedgewood Ranges Slide In s and Drop In s Atwood Letter atto da Nee beed 1 Questions Fe 3 Model Identification 10ers 4 5 Range amp Oven Gas Components Robertshaw Harper Wyman ananas 6 Combination Harper Wyman Robertshaw Harper Wyman aaan 7 REQUIS Se tm NN 8 Sequence of Operation os ee e t etl ace Bd d mc Rd 9 Common Top Burner Problems Oven Burner amp Pilot Problems aaan 10 Trouble Shooting Guide irisi 11 12 Identification of Older Wedgewood SystemSs 13 Cooking Appliance Terminology aaan 14 Flat Rate Schedule 15 Return Goods Policy RETURN ADDRESS 16 Warranty 0 ou UEM M oe
31. es should the edge of a pan be from any oven surface After the thermostat is turned to the desired temperature approximately how long should it take for the oven burner to come on Will the oven burner cycle on and off in the broil mode Can piezo ignition be added to a match lit range Model Number Identification NARROW DOOR OLD WEDGEWOOD Range Cooktop and Slide In cooktop R 173 6 A B P _ gt gt gt gt gt gt EE e TOP BURNER IGNITION P Piezo DOOR COLOR A almond B black G black glass S stainless W black glass w window 1 white steel door 2 white glass 3 white glass w window TOP COLOR A almond B black S stainless W white GRATE STYLE OR OUTPUT 0 round 5 designer 6 high output 7 Harper Wyman manifold amp burner top linear valves amp high output 8 high output Harper Wyman top burner amp oven gas system NUMBER OF BURNERS 2 3 4 OVEN HEIGHT 17 21 TYPE OF APPLIANCE C cooktop R range WIDE DOOR WEDGEWOOD Range Cooktop and Slide In cooktop RW 21 3 0 A B P gt gt gt gt gt oLD WEDGEWOOD Drop In cooktop D 2 5 HP E ss TOP BURNER IGNITION P Piezo DOOR COLOR A almond B black 1 white 2 white glass G black glass TOP COLOR A almond B black W white REVISION NUMBER O original version 1 First
32. esulting from misuse including failure to seek proper repair service misapplication alterations water damage or freezing are owner s responsibility 8 Atwood does not assume responsibility for any loss of use of vehicle loss of time inconvenience expense for gasoline telephone travel lodging loss or damage to personal property or revenues Some States do not allow the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you 9 Any implied warranties are limited to two 2 years Some States do not allow limitations on how long an implied warranty lasts so the above limitation may not apply to you This warranty gives you specific legal rights and you may also have other rights which may vary from State to State 10 Replacement parts purchased outside the original cooking warranty carry a 90 day warranty This includes the part at no charge and reasonable labor charges to replace it This Atwood product is designed for use in recreation vehicles for the purpose as stated in the data plate Any other use unless authorized in writing by the Atwood Engineering Department voids the warranty Atwood Wedgewood Vision Products include range oven drop in slide in and high pressure stoves 9 03 17 Warranty Procedures Atwood water heater furnace range hardware or detector warranties can be submitted in one of two ways If you are already set up with an
33. he 3902262 but this will have a pilot on position where they don t have to light pilot before each use This control when subbing for the 3902262 must change the oven knob to 51059 also known as 52286 even though the controls look alike the knobs must be changed to provide correct substitution Rest of the gas system is as follow 51096 Burner Valve No LONGER AVAILABLE same as 51224 51063 Safety Valve same as 51177 51062 Regulator same as 52154 All these parts are still available no substitutes DURING 1981 TO 1983 we used the black square manifold systems along with a different Harper Wyman system different from the one in 1991 to 1993 DURING THE MIDDLE YEARS 1960 S TO 1972 Wedgewood used a gas system that used a black round manifold with the oven control mounting to the front of the stove and does not mount to a manifold This system is no longer available and no substitutions are available for that system Part numbers and listed Johnstone Supply Co was the supplier The obsolete part numbers were as follow Serial numbers on these ranges would start with the letters C E F and consist of 5 to 6 digits Atwood will not be able to supply any parts Contact Leisure Time in New Hampshire at 1 800 258 3078 when your customer has the above gas system They can refer you to the nearest location During the Wedgewood years the part numbers consisted of 7 digits When Atwood took over they needed the part
34. he following items classified as normal maintenance and or customer damage a Damage discoloration or scratches to porcelain enamel or other finishes from improper use and care b adjustment of gas pressure c cleaning or adjustment of any burners d cleaning or replacement of burner orifices e cleaning or adjustment of pilot and thermal bulbs f damage to glass g products purchased for commercial industrial or rental use 3 In the event of warranty claim the owner must contact in advance either an authorized Atwood Service Station or the Atwood Service Department Warranty claim service must be performed at an authorized Atwood Service Station a list will be provided at no charge or as approved by the Atwood Service Department Atwood Mobile Products 4750 Hiawatha Drive Rockford IL 61103 12998 USA Phone 815 877 5700 4 Return parts must be shipped to Atwood Mobile Products prepaid Credit for shipping costs will be included with the warranty claim The defective parts become the property of Atwood Mobile Products and must be returned to the Consumer Service Department Atwood Mobile Products Greenbrier Operations 6320 Kelly Willis Road Greenbrier TN 37073 USA 5 This warranty applies only if the unit is installed according to the installation instructions provided and complies with local and state codes 6 The warranty on replacement parts is the unused portion of the original warranty period 7 Damage or failure r
35. he pilot used to light the top burners on older ranges Underwriters Laboratories A burner flame with yellow tips caused by improper gas air mixture Caused by improper gas pressure improper alignment or restriction of orifice and venturi tube noor Atwood Mobile Products 4750 Hiawatha Drive e Rockford IL 61103 PHONE 815 877 5700 FAX 815 877 INTERNET http www atwoodmobile 1298 7469 COM TIME ALLOWANCE SCHEDULE in hours Complete Unit Bifold Cover Burner Head Hinge Door Ignition Module Ignition Switch Oven Control Thermostat Oven Door Maintop Manifold Pipe Piezo Igniter Regulator Safety Valve Pilot Assembly Seal Spring Hinge Trim Bottom Trim Maintop LH RH Trim Vent Top Valve Burner All Other Parts RA 17 amp 21 Recreation Vehicle Ranges RV1732 RV2132 RV1731 RV2131 RW1731 RW2131 RW1730 RW2130 Flat Rate Schedule March 4 2003 D 21 26 31 36 D 26 SV amp SG DA 20 21 30 31 DA 31PE DAS 20 20E 30 32 indicates 0 5 hours will be allowed to remove and install the appliance If two or more parts are replaced on the same appliance during the repair the R amp R allowance to remove the appliance will be applied to only one part NO LABOR IS ALLOWED TO CHANGE KNOBS Above time allowances include all operations involved in the diagnosis location and replacement of part Also included is the time required to remove and replace a
36. it Shipping Damage Once the product has been accepted at its final destination it is the customers responsibility to file a damage claim with the carrier Follow Warranty Procedures for Atwood returns Return Parts When returning parts there are three divisions responsible for specific product and their claims Prior to returning parts a Return Goods Number RGN must be obtained by calling the Atwood Mobile Product Service Department at 800 825 4328 Shipping Reasonable shipping charges are reimbursed on defective and warranty parts if the analysis determines Atwood is responsible for the disposition All products not shipped via Atwood trucks should be shipped prepaid via UPS ground unless negotiated at the time the RGN is given No collect shipments will be accepted Packaging The RGN must be identified on each container amp all packing information Product returned must be properly packaged to prevent shipping damage Full credit will not be issued on product sent back on an open skid or improperly packaged Additional product boxes are available upon request Submit claims to the correct division Failure to do so makes claim processing amore difficult and lengthy process delaying payment of your claims Together we can maintain a speedy and efficient warranty program WATER HEATERS HARDWARE jacks couplers 5th wheel amp braking systems Atwood Mobile Products 4750 Hiawatha Drive Rockford IL 60013 16 FURNAC
37. l 5th Wheel items RANGE amp OVENS E C O amp T stat kits Regulators Thermal cut offs Oven therm ostats Pressure Temperature Safety pilot valves Relief Burner valves Valves Manifolds Top pilot valves 12v ignition module Burners w ignition electrode Complete ranges BY APPROVAL ONLY COOKING APPLIANCE LIMITED WARRANTY Atwood Mobile Products warrants to the original owner and subject to the below mentioned conditions that this product will be free of defects in material or workmanship for a period of two years from the original date of purchase Atwood s liability hereunder is limited to the replacement of the product repair of the product or replacement of the product with a reconditioned product at the discretion of the manufacturer This warranty is void if the product has been damaged by accident unreasonable use neglect tampering or other causes not arising from defects in material workmanship This warranty extends to the original owner of the product only and is subjectto the following conditions 1 For two years from the date of the original owner Atwood warrants that this product will be free of defects in material and workmanship with the exceptions noted below This warranty includes reasonable labor charges required to remove and replace the part Service calls to the customer s location are not considered part of these charges and are therefore the responsibility of the owner 2 This warranty does not cover t
38. l No longer available 51112 Handle solid doors x x X X 53087 Handle black glass doors No longer available 53605 Enamel door liner w window No longer available 53611 Enamel door liner w window No longer available 53612 Enamel door liner No longer available 53655 Solid door handle No longer available 53663 Solid door handle No longer available 53425 Insert black glass x x x 53426 Insert black glass x 53445 Insert black glass w window No longer available 53446 Insert black glass w window No longer available 51421 Window inner assembly x x 51060 Door seal sides x x X 51061 Door seal sides X Range Tops 53582 Top ALMOND No longer available 53583 Top BLACK 2 hole x x x 53584 Top WHITE 2 hole x x x When replacing top you must also replace grate 30 DESCRIPTION Round Grate DV20 56378 DV30 56378 1 Oval Grate 56379 56379 Burner Knob 56380 2 56380 3 Label 56388 56491 Top WHITE 56376 56375 Top BLACK 56496 56474 Top STAINLESS STEEL 57099 57102 Right Burner 56385 56483 Left Front Burner 56384 56482 Left Rear Burner NA 56481 Manifold Pipe 56383 56478 Regulator Valve 7200 Btu h 51062 56468 51062 56468 Valve 5200 Btu h 56469 56469 2
39. nitiates the process for starting the oven burner as described above When the oven temperature is satisfied the fluid in this bulb decreases which closes a seat in the oven valve and throttles the pilot size down to the standby pilot mode thereby shutting the oven burner OFF This cycle will continue until the range is turned off Com ponent Identification Orifice Air shutter Oven burner o E ER 00000000000000000000000000000000000000000d000 Pilot flame cover d Oven pilot assembly Pilot thermal bulb The temperature tolerance of the thermostat is 25 F The oven burner will come on approximately 1 1 2 minutes from a cold start and 10 seconds from a hot start Oven temperature bulb The oven burner may cycle during the broil mode Oven thermostat t ded Oven knob 9 Common Top Burner Problems burners won t light or stay lit piezo doesn t ignite burner top burner lights but flame too small burner flame lifts off burner Refer to Trouble shooting Guide for causes and solutions Oven Burner and Pilot Problems Refer to Trouble shooting Guide for Orifice Air shutter Oven burner causes and solutions e oven pilot outage dea o be
40. ny part or assembly that is in the path of a part being replaced and gas leak test when applicable 15 FOR EFFICIENT PROCESSING OF CLAIM Call for a RGN number 2 Fill Warranty Service Report form out completely 3 Using tape or a tag mark the returning part with the RGN 4 Package part including the Warranty Service Report in the box 5 On the outside of the package clearly mark the RGN number 6 Return part to the correct Division of Atwood Mobile Products Return Goods Policy Effective August 7 1995 all Atwood defective returns will no longer be repaired at the warehouses and returned to customers Defective returns will be shipped back to the respective manufacturing facility for problem cause analysis within 30 days of sales Full credit will be issued if the cause analysis determines Atwood is responsible If the cause analysis determines the customer is responsible partial or no credit will be issued Warranty Returns the warranty policy must return policy and approved labor rates provide the framework for warranty returns by product line Non Defective Returns A restocking fee of 20 will be charged for handling of overstock returns or standard stock items ordered incorrectly by the customer providing the product is received in resalable condition Product that has been specifically designed at a customers request is non returnable Obsolete or out dated product will not be accepted for cred
41. o Knob BLACK 51344 51344 51344 51344 51344 Piezo Knob WHITE 53223 53223 Burner Knob BLACK 56148 56148 56148 56148 56148 Burner Knob WHITE 53221 53221 Oven Thermostat Knob BLACK 53097 53097 53097 53097 Oven Thermostat Knob WHITE 53222 53222 Control Panel Assy BLACK 52621 52621 52621 52621 52621 Control Panel Assy WHITE 52606 52606 52606 52606 52606 LABEL Piezo BLACK 56219 56219 56219 56219 56223 LABEL Piezo WHITE 56224 56224 56224 56224 LABEL Matchlit BLACK 56218 56218 56218 56218 56220 Burner Box 51687 51687 51687 51687 51687 Oven shelf 51670 51670 Oven Can 51969 51969 51970 51970 Top Spring Clip 51035 51035 51035 Top Locating Clips 4 51111 51111 Top Hold Down Clip 53057 53057 Oven rack 51069 51069 51069 51069 DOOR asmbly w handle BLACK STEEL BLACK PANEL BLACK HANDLE 51977 51977 51983 51983 DOOR asmbly w handle WHITE STEEL WHITE PANEL BLACK HANDLE 51978 51978 51984 51984 DOOR asmbly w handle BLACK GLASS BLACK FRAME BLACK HANDLE 51980 51980 51986 51986 DOOR asmbly w handle WHITE GLASS BLACK FRAME BLACK HANDLE 51981 51981 51987 51987 DOOR asmbly w handle WHITE GLASS WHITE FRAME BLACK HANDLE 51982 51851 51988 51849 DOOR asmbly w handle WHITE STEEL WHITE PANEL WHITE HA
42. owner care program with an OEM you should submit the faulty part and claim through their system To submit a claim directly through Atwood the following information is required 1 Owner s Name and Address 2 Date of Purchase obtain from copy of original bill of sale 3 Model and Serial Number The model and serial number which is located on every water heater furnace and range is required on all Atwood appliance claims 4 Manufacturer Model Year and VIN of RV 5 Work Performed Describe in detail findings of existing problem and corrective measure taken 6 Return Parts A MUST RETURN parts list is attached Failure to return parts listed will result in denial of your warranty claim 7 Return Good Number a Return Goods Number RGN must accompany all returned parts This number may be obtained by calling the Atwood Mobile Products Service Department at 1 800 825 4328 The RGN must be clearly marked on the outside of each carton Failure to do so will result in your shipment being refused at our receiving department 8 Return Freight Atwood does not accept C O D shipments Freight to return parts to Atwood should be indicated on your claim or repair order and you will be reimbursed 9 Travel Time Because our warranty is based on the customers ability to present the unit for service and in an attempt to maintain our low cost products reimbursement for mileage service calls and travel time WILL NOT B
43. ped Steel Grate 53437 Stamped Steel Grate Rear OPEN 53438 Stamped Steel Grate Front OPEN 53439 Stamped Steel Grate 53441 Stamped Steel Grate Rear SEALED 53442 Stamped Steel Grate Front SEALED Grate Boots amp Clips 53301 Grate Clips 2 2 2 4 51410 Grate Top Clip N S 4 2 4 4 53008 Grate Boot 4 4 4 8 Knobs 53000 Burner Knob 2 2 2 3 56129 Burner Knob 2 2 3 2 3 3 Manifold 52523 Manifold Cover 52524 Manifold Cover 52516 Manifold Cover 56079 Manifold Pipe 50160 Manifold Pipe Misc 52016 Thumb screw 52537 Thumb screw 52434 Nylon Washer 2 Pressure Regulator 51062 Pressure Regulator Top Cook Almond top ORDER BY COLOR Black top ORDER BY COLOR White top ORDER BY COLOR Valve 53124 6500 Linear Valve after SN B020 53114 5200 Linear Valve after SN B020 56090 Valve Burner 6500 BTU 2 2 1 2 56300 Valve Burner 6500 BTU 2 1 56089 Valve Burner 5200 BTU 2 56301 Valve Burner 5200 BTU 2 56145 Valve Ignition Switch 2 57055 Valve Ignition Switch 3 Valve thu Bolt 56091 Valve thru Bolt 2 2 2 3 2 2 3 2 3 Wire Harness 56164 Wire Harness Valve Tub
44. rim Lg WHITE new solid door style no trim Sm STAINLESS new solid door style no trim RA 1730 amp 1731 18 18 ATWOOD Oven amp Slide In Cooktop Parts Identification RAT730 RA 2132 RA 2131 RA 2130 CAST DESCRIPTION Grate BLACK RA 1732 RA 1731 CA 30 Grommet 4 Sealed Grate U Channel Top Spring Clip 2 Range Top Assy WHITE Range Top Assy BLACK Burner Piezo Electronic Ignition Burner Piezo Electronic Ignition BLACK Bushing Burner 3 Hex Nut Brass Fitting Pressure Regulator 3 Burner Manifold old 3 Burner Manifold round Bolt thru Valve Bolt Oven Thermostat thru Bolt 3 Valve Burner Mini 9000 BTU 1 Valve Burner Mini 65000 BTU 2 Burner Tube Assy RR Burner Tube Assy LR Burner Tube Assy CF Valve Orifice Tube Assy Mini 6500 RR NLA USE 53206 Valve Orifice Tube Assy Mini 6500 LR NLA USE 53203 Valve Orifice Tube Assy Mini 9000 CF NLA USE 53202 Valve Orifice Tube Assy Mini 6500 RR rd mfd Valve Orifice Tube Assy Mini 6500 LR rd mfd Valve Orifice Tube Assy Mini 9000 CF rd mfd Straight Tube old design Thermostat oven control Piezo Ignitor 12V Ignition Module Valve Ignition Switch Piezo Knob BLACK Piezo Knob WHITE
45. urner RIGHT REAR 56233 Burner RIGHT REAR 56306 Burner RIGHT REAR VALVE TUBE ASSEMBLY 56307 Burner SEALED PLAIN 56208 Burner SEALED BLACK 56207 Burner ELECTRONIC IGNITION PLAIN 56325 Burner ELECTRONIC IGNITION BLACK De De De Xx De De Xx Xx x Xx Control Panel Label 52539 Black label 52437 Black labe 51454 Black labe 52540 Black label 56346 Black labe 57700 Black labe 56347 Black labe 57051 Black label Before S N B0220 53126 Black label After S N B0200 57050 Black label Before S N B0200 53126 Black label After S N B0200 56350 Black label 56348 White label 56351 Black labe 56349 White label 57052 Black labe Cover 56204 Cover 56205 Frame 51443 Cooktop amp Cover Asbly Electronic Ignition 56162 12V Ignition Module 56184 Ground Lead 56165 Electrode Lead Fitting Brass 52294 Fitting Brass 34 Drop in Cooktops PART REFERENCE SEPTEMBER 2003 Grates D 21 D 26 D 26SV D 26SG D 31 D 36 DA 20 DA 21 DA 30 DA 31 DA 31PE DAS 20 DAS 20E DAS 30 DAS 32E 51007 Medallion Grate 2 53304 Designer Grate 53303 Designer Grate Rear x 53302 Designer Grate Front x 53436 Stam
Download Pdf Manuals
Related Search