Home

Honeywell HE120 Humidifier

image

Contents

1. paper containing at least 10 post consumer paper fibers www honeywell com yourhome
2. your living area Choose the humidity control setting using the combination relative humidity outdoor temperature setting scale on your humidity control Match the dial setting to the outdoor temperature for optimizing the humidity level while reducing the moisture condensation on your windows The table below can also be used to adjust the humidity control to the recommended setting bum H908A M13155 At Outside Recommended At Outside Recommended Setting Temperature Setting Temperature eremo aerae O F 18 C 4 NOTE Asthe outside temperature drops the recommended humidity control setting is lowered to accommodate for the effects of dewpoint These settings should reduce the accumulation of moisture and ice on your windows and in other areas of your home Some indoor activities such as cooking showering and clothes drying can cause excessive levels of humidity and start the accumulation of moisture on your windows NOTE If this condition persists for more than a few hours set the humidity control to the lowest setting to turn off the humidifier If the condition does not improve ventilate your home to remove the moisture Your Honeywell HE120B Humidifier is controlled by the Honeywell H1008 Auto matic Humidity Control with HumidiCalc Software The automatic humidity control is mounted in the return air duct where it can be exposed to the
3. A Convertible Humidity Control to the highest setting or the H1008A Automatic Humidity Control to the Test position and set the thermo stat to 10 F 6 C above the room temperature Check that the humidifier pad is rotating Reset the thermostat and H908A Convertible Humidity Control to a comfortable setting or the H1008A Automatic Humidity Control to the desired frost factor setting for automatic operation 69 1110 1 H120A B BY PASS DRUM HUMIDIFIER TROUBLESHOOTING YOUR HUMIDIFIER Low Furnace blower not Resetcircuit breaker or check for blown humidity operating fuse Check that the furnace power is on Check all external wiring connections Check the humidity control setting Call a professional heating contractor Rapid air changes Keep doors and windows closed Drafts cold air is dry Close fireplace damper when not in use and is an added load Keep exhaust fan running time to a minimum to the humidifier Seal around doors and windows High Condensation on Turn off the humidity control and water until humidity walls condensation is completely evaporated Heavy condensation Turn humidity control down low enough to on windows eliminate condensation caused by moisture from bathing mopping cooking etc If moisture persists more ventilation is needed 69 1110 1 8 H120A B BY PASS DRUM HUMIDIFIER Adding Perfect Climate amp CONTROLS FOR COMFORT AND CONVENIENCE AO a PER
4. FECT CLIMATE HONEYWELL HUMIDIFIER IS ONE PART OF A PERFECT CLIMATE INDOOR ENVIRONMENT THAT PROVIDES TOTAL INDOOR COMFORT IT MAKES YOU FEEL BETTER AND ALLOWS YOU TO LIVE AND WORK IN A MORE COMFORTABLE ENVIRONMENT How it works HOME HONEYWELL VENTILATION CHRONOTHERM IV PROGRAMMABLE HONEYWELL FRESH AIR THERMOSTAT HUMIDISTAT CONTROL RETURN AIR SUPPLY AIR CONDITIONED REGISTER REGISTER AIR Y i STALE AIR OPTIMAL EFFICIENCY AIR EXHAUST CONDITIONER e HUMIDIFIER LH COLD AIR RETURN j OPTIMAL AIR FROM KE EFFICIENCY THS FORCED AIR L rREsu HONEYWELL VENTILATION SYSTEM HONEYWELL ELECTRONIC AIR CLEANER M12302 1 Honeywell Perfect Climate Comfort Center controls or Chronotherm IV Programmable Thermostats Honeywell F35 media air cleaner or F50 electronic air cleaners Honeywell humidity controls Honeywell humidifiers Honeywell home ventilation systems RON Describing Perfection The most convenient most energy efficient cleanest healthiest and most comfortable indoor environment possible today Perfect climate is achieved when the five core components of a home climate system work together Optimal efficiency heating and cooling equipment Precise programmable temperatu
5. Honeywell HE120A B By Pass Drum Humidifier OWNER S MANUAL H120A B BY PASS DRUM HUMIDIFIER WELCOME to the comfortable world of humidified air With your Honeywell humidifier you will notice a decrease in dry skin scratchy throats and irritated nasal passages that aggravate allergies and asthma You ve also taken the first step to stopping the zapping created by walking on your carpet and touching your TV computer metal door knob or your pet You can even put away your glue bottle because your furniture and woodwork will stop drying out Congratulations You have just made a great investment in your home comfort 69 1110 1 2 H120A B BY PASS DRUM HUMIDIFIER TABLE OF CONTENTS Operating Your Humidifier sirsiran ea enne nnne nennen 4 How Your Humidifier Works nennen nnn nnne 5 Maintaining Your Humidifier sese 5 Checking Your Humidifier Operation nennen 7 Troubleshooting Your Humidifier eese 8 Adding Perfect Climate Controls for Comfort and 9 Wattanty i e cate Ei ee aN ne due Y died codo ees 10 3 69 1110 1 H120A B BY PASS DRUM HUMIDIFIER OPERATING YOUR HUMIDIFIER Your HE120A Honeywell humidifier is controlled by the H908A Convertible Humidity Control that is installed either on the return air duct or on an interior wall in
6. OSS OR DAMAGE OF ANY KIND INCLUDING ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING DIRECTLY OR INDIRECTLY FROM ANY BREACH OF ANY WARRANTY EXPRESS OR IMPLIED OR ANY OTHER FAILURE OF THIS PRODUCT Some states do not allow the exclusion or limitation of incidental or consequential damages so this limitation may not apply to you THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEYWELL MAKES ON THIS PRODUCT THE DURATION OF ANY IMPLIED WARRANTIES INCLUDING THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE IS HEREBY LIMITED TO THE ONE YEAR DURATION OF THIS WARRANTY Some states do not allow limitations on how long an implied warranty lasts so the above limitation may not apply to you This warranty gives you specific legal rights and you may have other rights which vary from state to state If you have any questions concerning this warranty please write to Home and Building Control Customer Relations Honeywell 1985 Douglas Drive North Minneapolis MN 55422 In Canada write Retail Products ON15 02H Honeywell Limited Honeywell Limit e 35 Dynamic Drive Scarborough Ontario M1V 4Z9 69 1110 1 10 11 69 1110 1 Honeywell Home and Building Control Honeywell Inc Honeywell Plaza Box 524 Minneapolis MN 55408 0524 69 1110 1 J S Rev 5 98 Home and Building Control Honeywell Limited Honey well Limit e 155 Gordon Baker Road North York Ontario M2H 3N7 Printed in U S A on recycled
7. W YOUR HUMIDIFIER WORKS Your Honeywell humidifier uses the principle that vapor evaporated water is created when warm air blows over a water soaked area As the vapor circulates the relative humidity rises Your humidity control monitors the relative humidity and activates the humidifier accordingly The humidifier has a water supply that disburses water evenly over a humidifier pad The warm dry air from the furnace passes over the humidifier pad and picks up the moist air to circulate it through your home BEARING END OF COVER ES HUMIDIFIER HOUSING WATER PAN WATER VALVE OPENING DRUM SHAFT N Humidified air feels warmer and more comfortable so you may be able to lower your thermostat heating setpoint and save money on your heating fuel bills The end result is that your humidifier gives you a comfortable environment that is also energy efficient MAINTAINING YOUR HUMIDIFIER A regular maintenance program prolongs the life of your humidifier and provides a more comfortable home The frequency of cleaning will depend on the condition of your water You can use either hard or soft water in your humidifier but hard water mineral deposits are more difficult to clean than soft water deposits DRUM M ASSEMBLY M12252 69 1110 1 H120A B BY PASS DRUM HUMIDIFIER Every 1 to 3 Months Depending on Water Quality N CAUTION Voltage Hazard Can cause electrical shock and equipment damage Disconne
8. air stream of the return air The HumidiCalc Software inside your auto H1008A M12817 69 1110 1 matic humidity control is designed to auto matically adjust the humidity level based on indoor temperature and humidity inferred or measured outdoor temperature and the setting of the frost factor dial The frost factor allows for variations in furnace size window insulation and average daily climate tempera ture The Automatic Humidity Control with HumidiCalc Software requires an initial adjustment period Set the frost factor dial on 5 and use the following table to adjust the frost factor only one setting at a time increasing the dial setting if you feel you need more humidity or reducing the setting if you see moisture on the inside of your windows For more precise humidity adjustment set the frost factor between dial settings Allow two days for the humidity level to subside before making further adjustments Once you have tuned in the proper setting you should never have to adjust it again HumidiCalc Software takes over and makes any future adjustments caused by varying outdoor temperatures thus reducing moisture build up on windows while maintaining the optimal humidity level H120A B BY PASS DRUM HUMIDIFIER Humidity Level Recommended Adjustment Insufficient humidity Increase the frost factor dial by one setting Condensation on windows Decrease the frost factor dial by one setting HO
9. ct power and shut off water supply before installing or servicing IMPORTANT Never oil any part of the humidifier Use the following steps to clean your Honeywell humidifier 1 2 3 4 Disconnect the power and turn off the humidifier water supply Remove the humidifier cover by lifting the bottom of the cover upward Lift up the drum shaft from the bearing end and slide it out of the motor coupling to remove the drum assembly NOTE You will encounter some resistance when removing the drum shaft until you hear an audible click Remove the drum from the assembly DRUM END PAD 10 TINNERMAN P DRUM SHAFT METAL TABS 69 1110 1 CLOSED DRUM END Grasp the rubber valve seat between your thumb and forefinger and lift it upward to remove the valve seat from the valve The seat is located inside the humidifier housing at the water valve opening Raise up the float and remove the water pan Refer to the drawing to disassemble the drum Clean all humidifier parts in a 50 solution of vinegar or a humidifier cleaner and water Soak overnight to remove stubborn deposits NOTE Replace humidifier pad yearly The actual frequency depends on the quality of the water used After the humidifier components are clean reassemble the humidifier by re versing the order of steps 1 through 7 NOTE sure that the drum shaft is completely seated listen for the click Verify the h
10. re control Effective indoor air quality control Controlled humidity Proper ventilation and air distribution Contact your local Perfect Climate amp dealer for an evaluation of your home 9 69 1110 1 H120A B BY PASS DRUM HUMIDIFIER WARRANTY Honeywell warrants this product excluding humidifier pad to be free from defects in the workman ship or materials under normal use and service for a period of one 1 year from the date of purchase by the consumer If at any time during the warranty period the product is defective or malfunctions Honeywell shall repair or replace it at Honeywell s option within a reasonable period of time If the product is defective i return it with a bill of sale or other dated proof of purchase to the retailer from which you purchased it or ii package it carefully along with proof of purchase including date of purchase and a short description of the malfunction and mail it postage prepaid to the following address Honeywell Return Goods Dock 4 MN10 3860 1885 Douglas Drive Golden Valley MN 55422 This warranty does not cover removal or reinstallation costs This warranty shall not apply if it is shown by Honeywell that the defect or malfunction was caused by damage which occurred while the product was in the possession of a consumer Honeywell s sole responsibility shall be to repair or replace the product within the terms stated above HONEYWELL SHALL NOT BE LIABLE FOR ANY L
11. umidifier operation by following the steps in the Checking the Humidifier for Proper Operation section SQUEEZE SLIGHTLY TO INSTALL End of Humidification Season Clean the humidifier and shut it off at the end of the heating season Use the Every 1 to 3 Months section steps 1 through 9 to shut down for the season IMPORTANT Be sure the humidifier power is off and the humidifier water pan is empty Vacation When leaving on vacation turn off the humi difier water supply and your humidity control Turn on the humidifier water supply and reset your humidity control when you return CHECKING YOUR HUMIDIFIER OPERATION After winter startup or maintenance use the following steps to check the humidifier operation 1 Turn on the humidifier power and water supply 2 Check the water level in the humidifier water pan water level setting should be 1 3 8 in Turn the valve adjustment Screw located on the water valve inside the humidifier clockwise to lower the water level and counter clockwise to raise it H120A B BY PASS DRUM HUMIDIFIER NOTE The H1008A Automatic Humidity control stays in the test mode for thirty minutes After thirty minutes the control automatically resets to the maximum frost factor setting If system checkout has not been completed in thirty minutes the test mode can be extended by turning the dial back to one of the dial settings and then returning it to the test mode Turn the H908

Download Pdf Manuals

image

Related Search

Related Contents

USER`S MANUAL  Systema Super Híbrido Digital  NGS Breëze  Comfee M4OA-36HFN1 air conditioner  Consultez notre brochure produits Mobil Delvac  Philips AVENT Lid CRP408  Instrukcja i charakterystyka pracy DRP  Chauffages au bois à combustion inférieure  Phonix HU630GPW mobile phone case  

Copyright © All rights reserved.
Failed to retrieve file