Zanussi ZV11R Freezer User Manual
Contents
1. 8 Internal Cleaning 00 0 0 e eee 9 External Cleaning 00 000 eeu 9 Defrosting the freezer oooooooocooomoo 9 To Change the Light Bulb 10 When the appliance is not inuse 10 Something Not Working 10 Service and Spare Parts 11 Customer Care Department 11 Guarantee Conditions 11 Guide to use the instruction book Instructions for the installer Technical specification 12 Installation o oooooooo 13 Unpacking an se a eee 13 Clear ansehen 13 Installing the cabinet 2222220 13 Electrical connection 2 222222 14 Door Reversal ooooooooooooommmooo 15 The following Symbols will be found in the text to guide you through the instructions Safety instructions gt Hints and tips Step by step instructions for an operation Zanussi 818 15 02 00 9 Description of the Appliance O Control Panel A Red warning light Flashes when one of the alarms in the cabinet has been triggered B Yellow indicator light Lights when Fast Freeze is operating C FAST FREEZE button Used to switch the Fast Freeze feature on and off Use Operation This appliance is designed for do mestic use only specifically for the storage of edible foodstuffs This appliance is designed to operate in ambient temperatures2. or coloured red Upon completion there must be no cut or stray strands of wire present and the cord clamp must be secure over the outer sheath 14 GREEN amp YELLOW BLUE 13 AMP FUSE CORD CLAMP Zanussi 818 15 02 00 9 Door Reversal 1 Close the cabinet and pull out the plug from the electrical outlet 2 Remove the ventilation grille There is a part on the grille that can be removed Remove it and transfer to the opposite side 3 Support the cabinet on a wooden block when it is laid down It will be easier to grip under the cabinet when resupporting to an upright positon 4 On the upper part of the cabinet Put the hinge pin on the other side 5 On the lower part of the cabinet Unscrew the hinge Move the hinge pin and plastic cover Secure the hinge on the other side Raise the cabinet and replace the ventilation grille 6 Unscrew the handle Carefully press in the plastic plugs on the opposite side using a punch Secure the handle in the plug holes Then press the supplied plastic plugs into the holes to which the handle was previously fitted 7 Put the cabinet in position Check that it stands straight See the section Positioning the cabinet 15 Zanussi 818 15 02 00 9 MARIESTAD DD AV
3. surronding air temperature between 10 C and 32 C If these temperatures are exceeded i e colder or warmer the appliance will not operate correctly PD Model ZV11R 1 ventilation grille 2 shelf with flap 3 freezer basket 4 control panel o o S l C B C D E D Green indicator light Lights when the freezer is operating E Thermostat control Use to switch on and set the desired temperature in the freezer Zanussi 818 15 02 00 9 Before use eRemove all securing tapes eWash the inside of the appliance with lukewarm water a little bicarbonate of soda added 5ml to 0 5 litre of water Do not use soap or detergent as the smell maylinger Dry the appliance thoroughly Do not use detergents abrasive powders highly perfumed cleaning products wax polishes or products containing alcohol eBefore inserting the power plug into the outlet and switching on the cabinet for the first time leave it standing upright for about 30 minutes or for 4 hours if it was transported horizontally Otherwise the com pressor may sustain damage This time will allow the oil sufficient time to return to the compressor To start the freezer and thermostat control 1 Plug in the appliance Turn the thermostat control to the desired position 1 The lowest position of the thermostat control results in the highest temperature inside the cabinet 6 The highest position of the thermostat control results in the lowest
4. freezing capacity number of compressors 12 Zanussi 818 15 02 00 9 Installation Unpacking Unpack the cabinet and check that it is in good condition and free of any transport damage Notify the dealer immediately of any damage Hand the packaging over for recycling N Do not allow children to play with the packaging The plastic film can cause suffocation Cleaning Wash the inside of the cabinet using lukewarm water a mild washing up detergent and a soft cloth Installing the cabinet To otain the best performance from the cabinet ensure e the cabinet is placed in a dry cool place and is not exposed to direct sunlight e the cabinet is not placed close to a source of heat e g a cooker or dishwasher e the room in which the cabinet is placed has a temperature of 10 C to 32 C e the cabinet is level The cabinet should not lean against any wall If necessary adjust the feet using the supplied adjustment spanner e there is good air circulation around the cabinet and that the air channels below and behind the cabinet are not blocked The ventilation space above the cabinet and any grocery top cabinet must be at least 200 cm2 The ventilation space can either be a directly above the cabinet or b behind and above the top cabinet In this case the space behind the cabinet must be at least 50 mm deep If the cabinet is placed in a corner and the side with the hinges faces the wall the distance between the wall and th
5. temperature inside the cabinet 0 Off Allow the cabinet to run for a period of 24 hours whenever the temperature setting is changed This will allow the temperature to stabilise inside the cabinet Switching off Set the thermostat control to the 0 position Unplug the power supply plug from the wall socket or alternatively remove the fuse Freezing You need not press the fast freezing button when freezing smaller quantities of food during any 24 hour period In all other cases press the fast freezing button approx 24 hours prior to placing the food in the freezer Press the fast freezing button to switch off fast freezing again about 24 hours after placing the food in the freezer The yellow fast freezing lamp remains lit as long as the fast freezing button is engaged 257 Zanussi 818 15 02 00 9 Practical advice on freezing e When freezing products use the top shelf and if necessary the shelf beneth that Place the foods directly on the freezer shelves Spread out the products as much as possible to allow air to circulate between them e Do not place food products which are to be frozen directly against other frozen food The heat from the unfrozen food may cause the frozen food to thaw on the surface e Once frozen re arrange the products and put them as close as possible to each other The food will then stay cold longer in the event of a power failure e Do not freeze too much food at the sam
6. the refrigernat to settle Child Safety e Do not allow children to tamper with the controls or play with the product e Thereis arisk of suffocation Keep packaging material away from children During Use e This appliance is designed for domestic use only specifically for the storage of edible foodstuffs only It is not intended for commercial or industrial use e Containers with flammable gases or liquids can leak at low temperatures Do not store any containers with flammable materials such as spray cans fire extinguisher refill cartridges etc in the refrigerator or freezer Maintenance and Cleaning e Before cleaning always switch off the apppliance and disconnect from the electrical supply e When unplugging always pull the plug from the mains socket do not pull on the cable Servicing e This product should be serviced by an authouriesed engineer and only genuine spare parts should be used e Under no circumstances should you attempt to repair the appliance yourself Repairs carried out by inexperienced persons may cause injury or serious malfunctioning Contact your local Service Force Centre At the end of the Appliance Life e When disposing of your appliance use an authorised disposal site e Remove the plug and ensure that any locks or catches are removed to prevent young children being trapped inside e Do not let sharp objects come into contact with the refrigerating system on the back of and insid
7. 818 15 02 00 9 the United Kingdom eAppliances found to be in use within a commercial enviroment plus those those which are subject to rental agreements e Products of Zanussi manufacture which are not marked by Zanussi European Guarantee If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications e The guarantee starts from the date you first purchased your product eThe guarantee is for the same period and the same extent for labour and parts as exists in the new country of use for this brand or range of products eThis guarantee relates to you and cannot be transferred to another user eYour new home is within the European Community EC or European Free Trade Area e The product is installled and used in accordance with our instructions and is only used domestically i e a normal household e The product is installed and taking into account regulations in your new country Before you move please contact your nearest Customer Care Centre listed below to give them details of your new home They will then ensure that the local Service Organisation is aware of your move and able to look after you and your appliances France Senlis 33 0 3 44 62 22 22 Germany N rnberg 49 0 911 323 26 00 Italy Prodenone 39 0 1678 47053 Sweden Stockholm 46 0 20 78 77 55 UK Slovgn 44 0 1753 21 98 97 Technical specification energy class ID rated power
8. ZANUSSI FREEZER ZV11R INSTRUCTION BOOKLET Important Safety Instructions These warnings are provided in the interests of your safety Ensure that you understand them all before installing or using the appliance Your safety is of paramount importance If you are insure about any of the meanings or warnings contact the Customer Care Department Keep the instruction booklet It will come in hand if you later sell the cabinet or give it to somebod else Prior to Installation e Check the appliance for transport damage Under no circumstances should a damaged appliance be installed In the event of damage please contact your retailer Installation e This appliance is heavy Care should be taken when moving it e It is dangerous to alter the specifications or attempt to modify this product in any way e Ensure that the appliance does not stand on the electrical supply cable Ifthe supply cable is damaged it must be replaced by a cable avaliable from your local Service Force Center e Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person e Parts which heat up should not be exposed Whenever possible the back of the appliance should be close to a wall but leaving the required distance for ventilation as stated in the installation instructions The appliance should be left for 2 hours after installation before it is turned on in order to allow
9. advisable to periodically clean the refrigeration system at the back of the appliance with a duster or vacuum cleaner e Avoid unnecessary frosting in the cabinet by packing all foodstuffs into airtight packages before placing them in the freezer e Carefully follow the advice on freezing products in the section Use This will prevent wasting energy e Do not set the temperature too low in the freezer A suitable temperature is in the range of 18 C to 20 C e Defrost the freezer when the frost layer reaches a thickness of 3 5 mm Regularly check the door seal to ensure that it is clean and free from debris e Make sure the door gasket is complete and always clean Food Storage e Avoid buying frozen food if you can not store it straight away The use of an isulated container is advisable When you arrive home place the Maintenance and Cleaning Before any maintenance or cleaning work is carried out DISCONNECT the appliance from the ELECTRICITY supply A Removing the ventilation grille The ventilation grille can be removed e g to wash the grille Make sure the door is open when removing the ventilation grille Unsnap the upper edge of the grille by pulling outward downward Then pull the grille straight out to completely remove it frozen food in the frezzer immerdiately e Ennsure that food placed in teh freezer is dated and labelled and used in date order to ensure that food is consumed at its best Rem
10. check the door seals and wipe clean to ensure they are clean and free from debris External Cleaning Wash the outer cabinet with warm soapy water Remove the ventilation grille see the section Removing the ventilation grille and vacuum clean under the cabinet Once or twice a year dust the condenser black grille and the compressor at the back of the appliance with a brush or vacuum cleaner as an accumulation of dust will affect the performance of the appliance and cause excessive electricity consumption Do not use detergents abrasive powders high perfumed cleaning products wax polishes or cleaning products containing bleach or alcohol Defrosting the freezer A certain amount of frost will always form on the freezer shelves and around the top compartment Defrost the freezer when the frost layer reaches a thickness of about 3 5 mm Remove the freezer drawers and place them on top of each other by turning every other drawer one half turn Put insulating material around the drawers e g blankets or newspapers The frozen products can also be packed closely together and be kept in a cold location e g in the fridge Defrosting can be accelerated by placing bowls with hot water not boiling inside the freezer Take out the drain spout and place it in the bottom freezer drawer where water can collect Loosen the ventilation grille to enable the bowl to fit under the drain spout Carefully scrape off the ice when i
11. e the cabinet If the refrigerating system is punctured the cabinet will be damaged and foodstuff inside may spoil If the refrigurant circuit should become damaged avoid open flames and sources of ignition thoroughly ventillate the room in which the appliance is situated The refrigerant isobutan R600a is contained within the refrigerant circuit ofthe appliance a natural gas with a high level of environmental compatibillity which is nevertheless flammable e Do not place carbonated or fizzy drinks in the freezer compartment Bottles and cans must not be placed in the fresser compartment they can burst when the contents freeze Zanussi 818 15 02 00 9 Instructions for the user Important Safety Instructions 2 Contents rss 3 Description of the Appliance 4 Control Panel tarta betes ee een 4 Use ua a 4 Operation rer sn en oia lage 4 Before USE ai ae 5 To start the freezer and thermostat control 5 Switching off sos scere cec regre rus ee 5 Free ing ua ate Hee wee kenn 5 Alarms and other features 222222000 6 Suitable storage periods 222222222220 6 Temperature inside the freezer 6 PRA Wat BA ca 6 Cabinetinterior Guia at ie 7 Hints and Tips 4 4 44 4242 3 8 Energy Saving Advice 000000 eee 8 Food Storage 2 0 0 ec eee eee mosso 8 Normal Operating Sounds 8 Maintenance and Cleaning 8 Removing the ventilation grille
12. e cabinet must be at least 10 mm to allow the door to open enough so that the shelves can be removed 13 i Vv 1 Zanussi 818 15 02 00 9 Electrical connection A Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person This appliance must be earthed The manufacturer declines any liability should these safety measures not be observed Electrical Requirements Before switching on make sure the electricity supply voltage is the same as that indicated on the appliance rating plate The appliance is supplied with a 13amp plug fitted In the event of having to change the fuse in the plug supplied a 13amp ASTA approved BS1362 fuse must be used Should the plug need to be replaced for any reason The wires in the mains lead are coloured in accoordance with the following code Green and yellow Earth Blue Neutral Brown Live The wire coloured green and yellow must be connected to the terminal marked with the letter E or by the earth symbol or coloured greeen and yellow The wire coloured blue must be connected to the terminal marked N or coloured black The wire coloured brown must be connected to the terminal marked L
13. e time The freezing capacity of the unit is indicated in the specifications section Alarms and other features Temperature alarm A red warning lamp lights if it gets warmer than 12 C Find out what caused the alarm and correct the situation The lamp goes out when it becomes colder than 13 C Suitable storage periods Food purchased in frozen condition Follow the advice on the maximum storage period indicated on the packaging Food frozen at home Fatty and salty food should not be kept frozen for more than three months Cooked food and low fat food may be kept up to about six months Lean food and berries can be kept for approximately one year Temperature inside the freezer To ensure that foodstuff will keep for a long time be sure that the temperature inside the freezer is 18 C or below Please note however that the energy consumption increases as the temperature decreases Thawing It is best to use a fridge to thaw food Place the foodstuff on a plate with a raised edge to prevent liquids from running out To quickly thaw food put it in room temperature or in cold water When using a microwave oven to thaw foodstuffs follow the manufacturer s instructions Zanussi 818 15 02 00 9 Cabinet interior Freezer drawers The freezer drawers make it easy to quickly and easily find the food package you want To gain space the drawers can be remo
14. i SS 77 High Street Slovgh Berkshire SL1 1DZ Phone 08705 727727 Guarantee Conditions We undertake that if within 12 months of the date of the purchase this appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials we will at our option repair or replace the same FREE OF CHARGE for labour materials or carriage on condition that e The appliance has been correctly installed and used only on the electrical supply stated on the rating plate e The appliance has been used for normal domestic purposes only and in accordance with the manufactuer s instructions e The appliance has not been serviced maintained repaired taken a part or tampered with by any person not authorised by us e All service work under this guarantee must be undertaken by a ZANUSSI SERVICE CENTRE e Any appliance or defective part replaced shall become the company s property e This guarantee is in addition to your statuory and other legal rights Home visits are made between 8 30am and 5 30pm Monday to Friday Visits may be available outside these hours in which case a premium will be charged Exclusions This guarantee does not cover e Damage or calls resulting from transportation improper use or neglect the replacement of any light bulbs or removable parts of glass or plastic e Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside 11 Zanussi
15. lating strip is complete and clean If warm food products have been put inside the freezer wait for a couple of hours and then check the temperature again Distribute the food products to allow cold air to circulate around them The temperature is too low inside the Set a higher temperature freezer Action Freeze could have been switched on Too much frost and ice are produced Make sure that the door is completely closed and that the insulating strip is complete and clean Set a higher temperature The compressor operates continuously Set a higher temperature Make sure that the door is completely closed and that the insulating strip is complete and clean The temperature where the cabinet is placed is above normal room temperature The cabinet does not operate at all The power plug is not properly connected Cooling or interior light does not The fuse has blown operate No indicator lamps light The cabinet is not switched on Power does not reach the cabinet Try connecting another electrical device to the power outlet Power failure Do not unnecessarily open the cabinet except when the power outage seems to be long in which case the food products should be moved to another cabinet that works See hte chapter Hints and Tips Noise See Normal operating Sounds in chapter Hints and Tips The freezer door will not open Has door just been opened If so leave for few minutes to allow the air pressure to equali
16. ove suspect food from you refrigerator and clean refer to cleaning and maintenance e In the event of a power failure causing the temperature within your freezer to rise do not refreeze the food without checking its condition Thre following guidelines should assist you Ice cream once thawed should be discarded Fruits amp Vegetables if soft should be cooked and used up Breads amp Cakes can be re frozen without danger Shellfish should be refrigerated and used up quickly Cooked Dishes i e casseroles should be refrigerated and used up Large Pieces of Meat can be re frozen providing there are still ice crystals remaining within them Small Joints should be cooked and can then be refrozen as cooked dishes Chicken should also be cooked and re frozen as a cooked dish Normal Operating Sounds e You may hear faint gurgling or bubbling sounds when the refrigerant is pumped through the coils or tubing at the rear to the cooling plate evaporator e When the compressor is on the refrigerant is being pumped round and you will hear a whirring sound or pulsating noise from the compressor e A thermostat controls the compressor and you will hear a faint click when the termostat cuts in and out Zanussi 818 15 02 00 9 Internal Cleaning Clean the inside and the accessories with warm water and bicarbonate of soda 5 ml to 0 5 litre of water Rinse and dry thoroughly N Regulary
17. se 10 Zanussi 818 15 02 00 9 If after above checks there is still a fault call your local Service Force Center In guarantee customers should ensure that the above checks have been made as the engineer will make a charge if the fault is not a mechanical or electrical breakdown Please note that proof of purchase is required for in guarantee service calls Service and Spare Parts In the event of your appliance requiring service or if you wish to purchase spare parts please contact your local Zanussi Service Force Centre by telephoning 08705 929929 Your call be routed the Service Force Centre covering your post code area The address of your local Service Force Centre is detailed in the accompanying Customer Care Book Before calling out an engineer please ensure you have read the details under the heading Something Not Working and have the model number and purchase date to hand Please note that it will be necessary to provide proof of purchase for any in guarantee service calls In guarantee customer should ensure that the checks under the headning Something Not Working have been made as the engineer will make a change if the fault is not a mechanical or electrical breakdown Customer Care Department Fore general enquiries concerning your Zanussi appliance or futher information on Zanussi products you are invited to contact our Customer Care Department by letter or phone as follows Customer Care Department Zanuss
18. t starts to thaw Use a wood or plastic scraper Do not use sharp objects as these may damage the interior When all the ice has melted clean and wipe the cabinet dry then push the drain spout back in place Switch on the cabinet and replace the frozen foodstuff When moving the cabinet lift it by the front edge to avoid scratching the floor Never use a hair drier or other heating appliances to speed up defrosting Excessive heat may damage the plastic interior and humidity could enter the electric appliance making it live Zanussi 818 15 02 00 9 To Change the Light Bulb The light is switched on automatically when the door is opened Before replacing the light bulb disconnect the power plug from the outlet To replace the lamp in the chiller compartment only cabinets with two doors first unscrew the lamp grille with a screwdriver Use a bulb of the same type E14 socket maximum rating of 25 W When the appliance is not in use Discconnect the appliance from electricity supply Empty all foods and clean the appliance leaving the doors ajar to prevent unpleasant smells Something Not Working Before contacting your local Service Force Centre check the following points Sympton Sohlen O The temperature is too high inside the Set a lower temperature freezer Make sure that the door is completely closed and that the insu
19. ved and the products can be put directly on the shelves On all shelves except the top shelf it is possible to place products that protrude 20 mm from the front edge This allows maximum use of the available space Do not remove the bottom drawer It is required to assure proper air circulation Ice cubes Fill the ice tray to max 3 4 since water expands as it freezes Release the ice cubes by twisting the ice tray If ice cubes are kept for a long time they will dry out and the taste is affected Thus throw away old ice cubes and prepare new ones when needed Removeable shelf There is a middle shelf inside the freezer Remove the shelf when large food products need to be frozen Zanussi 818 15 02 00 9 Hints and Tips Energy Saving Advice e Do not install the cabinet close to sources of heat such as a cooker dishwasher or radiator e Locate the appliance in a cool well ventilated room and make sure that the air openings of the cabinet are not obstructed e Always leave warm food to cool down to room temperature before placing in the fridge e Try to avoid keeping the door open for long periods or opening the door too frquently as warm air will enter the cabinet and cause the compressor to switch on unnecessarily often e Ensure there are no obstructions preventing the door from cloosing properly e It is
Download Pdf Manuals
Related Search