Mustang Survival MD3183 Life Jacket User Manual
Contents
1. Owner s Manual MD3183 Inflatable PFD Hydrostatic Inflation Model Manual with Automatic Backup Recreational USCG Approved Type II Uninspected Commercial Vessels USCG Approved Type V MD3184 Inflatable PFD Hydrostatic Inflation Model Manual with Automatic Backup with Harness Recreational USCG Approved Type V DO NOT REMOVE PRIOR TO SALE CONTENTS Page 1 Approval Conditions and Carriage Requirements 2 Note to Uninspected Commercial Vessel Operators 2 Why are PFDs Required Safety Equipment 2 What is an Inflatable PFD 3 Instructions for Use 4 Uninspected Commercial Vessel Use 4 Component Inspection Instructions 4 Readiness Checklist 5 Sizing and Fit 5 Donning Instructions 5 Inflating Your Inflatable PFD 7 Special Considerations for Inflatable Devices 7 Deflating the Inflatable PFD 8 Usage Below Freezing 9 Re arming Your PFD 13 Repacking 16 Sailing Harness 17 Is Your PFD in Good and Servicable Condition 17 Care and Maintenance Instructions 19 Cleaning and Storing of Your Inflatable PFD 19 How and Why to Test Your PFD 20 How Do You Test Your PFD Using the Automatic Inflator 21 How Do You Test Your PFD Using the Manual Inflator 21 How Do You Test Your PFD Using the Oral Inflator 22 Wear Your PFD 22 Hypothermia 24 Each of These Devices is Intended to Help You Save Your Own Life 25 Inflatable PFD Safety Accessories 25 Additional Information 25 Airline Operator Policy on Carriage of Inflatable PFDs and CO Ca2. Oral Inflator behind cell Hydrostatic Inflator Zipper Adjustment Pull tab Point FIGURE 2 Hydrostatic Inflator Cap Water Inlet Valve lt Black Locking Ring KACIN mil R tepla E Ty Yellow Inflator Cap iji Cap Locking Ring da Tabs Poirt Lanyard Status Indicator Inflator Body Expiry Date Manual Inflation Pull tab nflatable PFD Owner s Manual 3 Uninspected Commercial Vessel Use This Inflatable PFD is not approved for hot work and care must be taken to avoid damage from abrasion and sharp objects Component Inspection Instructions 1 Examine the single point status indicator through the window panel Fig 1 Ensure the indicator is green If the indicator is red the mechanism has been fired or is incorrectly fitted see Re arming Your PED p 9 NOTE The single point status indicator must be green before proceeding Undo the zipper on the wearer s left side exposing the oral inflator Ensure the oral inflation dust cap is in the stowed position Fig 6 Ensure the single point status indicator is green and the pull tab lanyard is hanging on the outside secure the zippers on the Inflatable PFD see Repacking p 13 Ensure the current date is not past the date on the inflator If it is replace the inflator see Re arming Your PFD p 9 Readiness Checklist Check your Inflatable PFD and ensure all of the checkpoints listed below are true bef
3. 80 percent of all boating fatalities the victims were not wearing a PFD Most fatal accidents happen on calm sunny days This Inflatable PFD is much more comfortable to wear than other PFD types Get into the habit of wearing this Inflatable PFD Non swimmers and children especially should wear a hybrid or non Inflatable PFD at all times when on or near the water HYPOTHERMIA Prolonged exposure to cold water causes a condition known as hypothermia a substantial loss of body heat which leads to exhaustion and unconsciousness Most drowning victims first suffer from hypothermia The following chart shows the effects of hypothermia how hypothermia affects most adults 22 Inflatable PFD Owner s Manual How hypothermia affects most adults Water Exhaustion or Expected Temperature C F Unconsciousness Time of Survival 0 3 32 5 Under 15 min Under 15 45 min 0 3 4 32 5 40 15 30 min 30 90 min 4 10 40 50 30 60 min 1 3 hrs 10 16 50 60 1 2 hrs 1 6 hrs 16 21 60 70 2 7 hrs 2 40 hrs 21 27 70 80 2 12 hrs 3 hrs to Indefinite over 27 over 80 Indefinite Indefinite PFDs can increase survival time because they allow you to float without using energy treading water and because of their insulating properties Naturally the warmer the water the less insulation you will require When operating in cold waters below 60 F 15 6 C you should consider using a coat or jacket style PFD or a Type V Thermal Protective PFD
4. MA7214 is required to re arm the device IMPORTANT The Inflatable PFD should be re armed according to the instructions Re arming Your PFD p 9 Deflating the Inflatable PFD 1 To deflate the Inflatable PFD reverse the oral inflation tube dust cap and insert it into the valve or depress valve with fingertip The dust Inflatable PFD Owner s Manual 7 cap will not lock in the deflate position so it is necessary to hold it in place Fig 5 2 Gently squeeze the Inflatable PFD until all air or gas has been expelled To avoid damage do not wring or twist the Inflatable PFD Put the inflation tube dust cap back in its stowed position on the oral inflation tube Fig 6 IMPORTANT Ensure all air has been removed from the PFD 3 Examine the single point status indicator Fig 1 If the indicator is red the mechanism has been fired and the inflator requires service see Re arming your PFD p 9 IMPORTANT The single point status indicator must be green before proceeding 4 Your device is ready to be repacked see Repacking p 13 FIGURE 6 FIGURE 7 Deflate Dust cap Dust cap Position in stowed position for position deflation O Usage Below Freezing When the temperature is below freezing the Inflatable PFD should be worn partially inflated because a fully discharged cylinder may not quickly or adequately inflate your Inflatable PFD Under these conditions use the oral inflator
5. inflator with clean water using a clean rinse cloth Hang the Inflatable PFD to dry on a plastic coat hanger Do not dry clean Always store your Inflatable PFD in a warm dry place out of direct sunlight HOW AND WHY TO TEST YOUR PFD Inflate your Inflatable PFD and try it out in the water to Make sure it floats you e Comfortably when worn properly Inflatable PFD Owner s Manual 19 e Adequately for expected wave conditions body shapes densities affect performance Make sure it works e A flow of bubbles should not appear see CARE AND MAINTENANCE INSTRUCTIONS for leak tests p 17 It should inflate quick and easily Learn how it works by e Activating the CO3 inflation system e Re arming the CO inflation system e Using the oral inflator tube HOW DO YOU TEST YOUR PFD USING THE AUTOMATIC INFLATOR The U S Coast Guard recommends that you purchase at least one spare re arming kit MA7214 1 To test your Inflatable PFD you will need your fully armed Inflatable PFD and re arming kit MA7214 approved for your Inflatable PFD 2 Put on the Inflatable PFD 3 Get into shallow water just deep enough that you can stand with your head above the surface Once the inflator is underwater 4 inches or so the Inflatable PFD should fully inflate automatically within 5 seconds 4 See if the Inflatable PFD will float you on your back or just slightly back of vertical In a relaxed floating position verify that your mouth
6. may be required in the event of very prolonged immersion IMPORTANT See Special Considerations for Inflatable Devices Oral Inflation Properly armed and inspected Inflatable PFDs will inflate when manually or automatically activated However you can fully inflate the Inflatable PFD by mouth Fig 5 should inflation not occur or if you are in a non emergency situation i To orally inflate the Inflatable PFD first ensure that each of the zippers 2 are completely opened Inflatable PFD Owner s Manual NOTE Oral inflation may cause the Inflatable PFD to break out suddenly loudly if any of the zippers are closed ii Locate the oral inflation tube by opening the wearer s left front panel of the Inflatable PFD Remove the dust cap from the end of the oral tube and blow into the tube until the Inflatable PFD is fully inflated FIGURE 5 Special aca for Inflatable Devices The Inflatable PFD might not be armed when needed either knowingly or unknowingly Inadvertant inflation causes several risks that you must address to avoid drowning Much less common but also important are Double inflation CO gt cylinder inflation after full oral inflation could damage the Inflatable PFD Inflation when stored in a tight space could damage the Inflatable PFD and The Inflatable PFD could inflate when you are in an awkward place or position If this Inflatable PFD should inflate inadvertantly a re arm kit
7. remains in good condition 1 Check the single point status indicator before each use 2 Get in the habit of re arming the inflation mechanism right after each inflation 3 Try your wearable Inflatable PFD on and adjust it until it fits comfortably in and out of the water 4 Mark your Inflatable PFD with your name if you are the only wearer 5 Do not alter your Inflatable PFD If it doesn t fit properly get one that does An altered device is no longer Coast Guard approved 6 Your Inflatable PFD is not intended for use as a fender or kneeling pad 7 If your Inflatable PFD is wet allow it to dry thoroughly before storing it Store it in a well ventilated area 8 Do not dry your Inflatable PFD in front of a radiator or other source of direct heat 24 Inflatable PFD Owner s Manual Inflatable PFD Safety Accessories MA7214 Re arm Kit contains 33 gram replacement CO3 cylinder inflator ADDITIONAL INFORMATION If you need more information about PFDs and safe recreational boating contact your state boating authority U S Coast Guard Auxiliary U S Power Squadron Red Cross or your nearest unit of the U S Coast Guard or call the CG Customer InfoLine at 1 800 368 5647 or the free boating course number 1 800 336 BOAT in VA 1 800 245 BOAT DO NOT ATTACH PFD S TO YOUR BOAT Each PFD has straps hooks buckles or other means for securing the device in place on the wearer Some PFDs also incorporate decorative d ri
8. HT 1121 Printed in Canada Rev 01 Dec 05
9. QUIRED SAFETY EQUIPMENT Drownings are the leading cause of fatalities involving recreational and commercial vessels A PFD provides flotation to help keep your head above water help you to stay face up in the water and increase your chances for survival and rescue Most adults only need an extra 7 to 12 pounds 15 4 to 26 4 kg of flotation to keep their heads above water The proper size PFD will properly support the weight of the wearer Since this Inflatable PFD does not have inherent buoyancy it provides flotation only when inflated Familiarize yourself with the use of this Inflatable PFD so you know what to do in an emergency WHAT IS AN INFLATABLE PFD While traditional PFDs are inherently buoyant inflatable PFDs rely entirely on inflation for buoyancy Uninflated the Inflatable PFD is a comfortable slim collar that can be inflated at any time with a 33 gram 2 Inflatable PFD Owner s Manual CO gas cylinder The Inflatable PFD is designed to offer maximum mobility with minimum bulk The Inflatable PFD can be inflated either automatically by water immersion manually by jerking a pull tab or orally by mouth It is recommended that you familiarize yourself with the procedures outlined in INSTRUCTIONS FOR USE p 3 INSTRUCTIONS FOR USE This manual supplies instructional maintenance and safety information for both models MD3183 MD3184 The model number is listed on the underside label FIGURE 1 MD3183 Unpacked
10. YOUR PFD USING THE ORAL INFLATOR This test is not mandatory however may be conducted using the following procedure WARNING Use only a previously fired hydrostatic inflator to perform this test DO NOT test with a fully armed hydrostatic inflator as double inflation may occur possibly resulting in cell damage 1 No spare parts or re arming kits are needed to test your Inflatable PFD 2 Put on the Inflatable PFD Inflatable PFD Owner s Manual 21 3 Get into shallow water just deep enough that you can stand with your head above the surface 4 If you are a weak swimmer or non swimmer inflate the Inflatable PFD partially so that you are supported well enough to be able to complete inflation without touching bottom either orally or manually Note this level of inflation because it is the minimum needed for you to safely use this Inflatable PFD 5 Fully inflate the Inflatable PFD using the oral inflator 6 See if the Inflatable PFD will float you on your back or just slightly back of vertical In a relaxed floating position verify that your mouth is well above the water s surface Note the effect of where you hold your legs and how you float 7 Get out of the water and remove the Inflatable PFD Completely deflate the Inflatable PFD using the oral inflator see Deflating the Inflatable PFD p 7 8 Let the Inflatable PFD dry thoroughly Re arm p 9 and Repack the PED p 13 WEAR YOUR PFD In approximately
11. al FIGURE 13 Caution Do not turn the center shaft Green Indicator 7 Now check the new manual automatic cap as follows Fig 14 1 Is the single point status indicator showing green 2 Is the expiry day OK If YES is the answer to both questions then proceed as follows If the answer is NO to either question get a new cap FIGURE 14 Single Point Indicator 8 Hold the CO3 cylinder through the fabric of the Inflatable PFD Fig 15 Position the replacement cap with the water inlet valve pointing to the right and press firmly onto the inflator body and sealing ring Fig 16 Inflatable PFD Owner s Manual 11 FIGURE 15 9 While pressing FIRMLY onto the inflator body turn the BLACK locking ring clockwise into the locked position Fig 17 Pull on the cap to make sure it has locked onto the inflator body FIGURE 17 Black Locking Ring 10 Check To see that the single point status indicator on the cap is green the pull to inflate lanyard is present and that the locking ring is locked 11 Refold the Inflatable PFD in accordance with the Repacking section p 13 12 Inflatable PFD Owner s Manual Repacking If your Inflatable PFD has been used and or the hydrostatic inflator replaced always inflate through the oral tube and check that it stays inflated at least overnight With the dust cap i
12. ar attention must be paid to the stitching straps and hardware If in doubt send it to your Mustang dealer for evaluation and or servicing Every Two 2 Months i Leak Test The Inflatable PFD should be tested for general leakage by orally inflating your Inflatable PFD until firm and let stand 16 hours A leaking Inflatable PFD will not hold its firmness and should be replaced If your Inflatable PFD leaks take it to your Mustang dealer for evaluation and or servicing Repack the Inflatable PFD as outlined in the Repacking section p 13 ii Oral Inflation Valve Test To check the oral inflation valve fully inflate the Inflatable PFD using the oral inflator and hold valve under water If bubbles appear deflate and re inflate to test again Should the leak persist take your Inflatable PFD to your Mustang dealer for evaluation and or servicing CAUTION To avoid accidental inflation don t allow the water to contact the hydrostatic inflator iii Perform a thorough visual examination See Readiness Checklist p 3 Perform these tests more often if exposed to potential damage or used in extreme conditions After Each Inflation Re arm the Inflatable PFD See Re arming Your PFD p 9 Annually Perform the following at the beginning of each boating season after inflation or whenever the integrity of the Inflatable PFD is in doubt i Check all components for dirt or corrosion Clean or replace as neccessary See Rea
13. as they cover more of the body than the vest or belt style PFDs Some Points to Remember About Hypothermia Protection 1 Always wear your Inflatable PFD Even if you become incapacitated due to hypothermia the Inflatable PFD will keep you afloat and greatly improve your chances of rescue Do not attempt to swim unless it is to reach a nearby craft fellow survivor or a floating object on which you can lean or climb Swimming increases the rate of body heat loss In cold water drown proofing methods that require putting your head in the water are not recommended Keep your head out of the water This will greatly lessen heat loss and increase your survival time Use the standard H E L P position when wearing an Inflatable PFD drawing the legs up to a seated position because doing so will help you conserve body heat Fig 32 Keep a positive attitude about your survival and rescue This will improve your chances of extending your survival time until rescued Your will to live does make a difference If there is more than one person in the water huddling is recommended while waiting to be rescued This action tends to Inflatable PFD Owner s Manual 23 reduce the rate of heat loss and thus increase the survival time FIGURE 33 HELP Position EACH OF THESE DEVICES IS INTENDED TO HELP YOU SAVE YOUR OWN LIFE For your Inflatable PFD to function properly follow these suggestions to verify that it fits floats and
14. diness Checklist p 3 Inflatable PFD Owner s Manual ii Visually examine your Inflatable PFD for damage or excessive abrasion wear tear or contamination Particular attention must be paid to the stitching straps and hardware If in doubt send it to your Mustang dealer for evaluation and or servicing iii Perform the Oral Inflation Valve Test See the Oral Inflation Valve Test in the Every Two 2 Months Care and Maintenance Instructions section iv Perform the Leak Test See the Leak Test in the Every Two 2 Months Care and Maintenance Instructions section v Ensure the current date is not past the date on the inflator If it is replace the inflator see Re arming Your PFD p 9 vi Ensure the single point status indicator is green Fig 1 vii Record as an Annual inspection in permanent ink on the Care and Storage label in the Date Maintained column Repack the Inflatable PFD as outlined in the Repacking section p 13 WARNING If you are not confident in the self inspection and servicing of your Inflatable PFD in accordance with these instructions take your Inflatable PFD to a Mustang dealer for professional servicing or contact Mustang Survival see contact information on back of manual Cleaning and Storing of Your Inflatable PFD To avoid inflation do not submerge the Inflatable PFD or directly spray the inflator Hand wash or sponge down the Inflatable PFD in warm soapy water Rinse the PFD and
15. elt must always be worn at least 2 inches 5 cm above the lowest rib and adjusted to a tight personal fit 2 Put the Inflatable PFD on just like a jacket Fig 3 and fasten the front buckle Adjust the waist belt using the side buckle on the belt and secure the belt s loose end in the belt loop WARNING Do not wear Inflatable PFDs under clothing as the inflation could be restricted or you could be injured FIGURE 3 Inflating Your Inflatable PFD It is recommended that the following procedures be followed to inflate your Inflatable PFD Inflatable PFD Owner s Manual 5 1 Manual Inflation Activate the inflation system by jerking firmly downward on the pull tab Fig 4 The Inflatable PFD should fully inflate within 5 seconds FIGURE 4 2 Automatic Backup Inflation When the inflator is lowered more than about 4 inches in the water then the hydrostatic valve opens and lets the water meet the water sensitive element that in turn releases a stainless steel coil spring The spring then drives a needle into the end of the gas cylinder which is now punctured so that the gas instantly fills the life jacket Total buoyancy is normally reached within 4 5 seconds Information When inflated the carbon dioxide CO gas used to inflate the PFD will slowly escape through the fabric over time A slight reduction of pressure will be observed after several hours of inflation Topping up by oral inflation
16. he chest as possible but in all cases at least 2 inches 5 cm above the lowest rib measured from the bottom of the belt and should not be used if it does not fit in this manner Adjust the harness using the strap adjuster so that the harness is as snug as tolerable Failure to adjust the harness properly could result in injury When attached to the boat use a tether of less than 6 feet 6 inches 2 m in length with quick release under load hardware Fig 31 Ensure that a tether is secured to both D rings When not in use the D rings can be pushed under the lapels Warning Use of a sailing harness to prevent falls overboard presents several risks In case of capsizing or sinking the boat may take you down As such ensure that any tether used has 16 Inflatable PFD Owner s Manual quick release under load hardware This harness has not been designed for fall arrest lifting or climbing and should not be relied upon in any of these instances US Coast Guard approval does not apply to this harness and the potential for injury has not been assessed FIGURE 32 Chest Buckle Chest Belt Webbing Tether 7 Webbing IS YOUR PFD IN GOOD AND SERVICEABLE CONDITION Check your Inflatable PFD between outings to be sure that it is properly armed that it is free of rips tears or holes that all seams are securely sewn and that the fabric straps and hardware are still strong See Readiness Checklist p 4 Inspect t
17. he inflatable portion of the Inflatable PFD in accordance with the CARE AND MAINTENANCE INSTRUCTIONS CARE AND MAINTENANCE INSTRUCTIONS Federal Regulations require Coast Guard approved personal flotation devices PFDs that are legibly marked with the Coast Guard approval number are in good and serviceable condition and are the correct size for each person on board It is the responsibility of the operator to be sure this PFD is in serviceable condition To be considered serviceable this PFD shall not exhibit deterioration that could diminish its performance such as broken or deformed hardware detached webbing rotted structural components air leaks or nonfunctional inflators Unless worn inflated this PFD must also be properly armed with a cylinder installed in the inflator and single point status indicator showing green See Page 1 for instructions Failure to follow these instructions rigorously could result in a non functioning PFD causing injury or death eae Release Lanyard Check the following at the intervals listed below Inflatable PFD Owner s Manual 17 1 Before Each Use i Examine the single point status indicator through the window panel ensuring it is green If the indicator is red the mechanism requires service See Re arming Your PFD p 9 ii Ensure the manual pull tab is accessible iii Visually examine your Inflatable PFD for damage or excessive abrasion wear tear or contamination Particul
18. intenance Instructions p 17 for servicing information 3 The operator of an uninspected commercial vessel is responsible for providing each person onboard with the safety information required for use of the MD3183 See page 2 for information When fully inflated the MD3183 will provide Type II in water performance The MD3183 will turn most wearers from a face down to a face up position and provide support suitable for offshore conditions See page 9 for re arming instructions Inflatable PFDs are not approved for water skiing or other high speed activities This Inflatable PFD was designed to be more comfortable and Inflatable PFD Owner s Manual 1 less restrictive to wear than inherently buoyant PFDs When worn used and serviced according to this owner s manual this PFD can greatly increase your chances of survival in the water Not recommended for non swimmers or weak swimmers Users of inflatable PFDs must be at least 16 years old NOTE TO UNINSPECTED COMMERCIAL VESSEL OPERATORS The operator of the vessel is required to provide the following user information to each person on board Inflatable PFDs will not provide any buoyancy without being inflated Follow these instructions to be sure your PFD is armed and donned correctly and that you understand how to inflate the device Basic visual inspection for readiness see p 4 Inflation system status check see p 4 Donning see p 5 Inflation see p 6 WHY ARE PFDS RE
19. is well above the water s surface Note the effect of where you hold your legs on how you float 5 Get out of the water and remove the Inflatable PFD 6 Deflate the Inflatable PFD by depressing the oral inflator valve see Deflating the Inflatable PFD p 7 Remove the used inflator 7 Let the Inflatable PFD dry thoroughly Re arm p 9 and Repack the PED p 13 20 Inflatable PFD Owner s Manual HOW DO YOU TEST YOUR PFD USING THE MANUAL INFLATOR The U S Coast Guard recommends that you purchase at least one spare re arming kit MA7214 1 To test your Inflatable PFD you will need your fully armed Inflatable PFD and re arming kit approved for your Inflatable PFD MA7214 2 Put on the Inflatable PFD 3 Actuate the inflation system by jerking firmly downward on the pull tab The Inflatable PFD should fully inflate within 5 seconds 4 Get into shallow water just deep enough that you can stand with your head above the surface 5 See if the Inflatable PFD will float you on your back or just slightly back of vertical In a relaxed floating position verify that your mouth is well above the water s surface Note the effect of where you hold your legs and how you float 6 Get out of the water and remove the Inflatable PFD Completely deflate the Inflatable PFD using the oral inflator see Deflating the Inflatable PFD p 7 7 Let the Inflatable PFD dry thoroughly Re arm p 9 and Repack the PED p 13 HOW DO YOU TEST
20. latable PFD Owner s Manual 6 Fasten the Velcro tab H to keep zipper closed FIGURE 27 7 ZIP 1 Reset the 2 step zipper by pulling the slider I to the Velcro tab H ZIP 2 Close by pulling slider I in the opposite direction to the end the zipper Fig 29 Ensure that the Inflatable cell does not get caught by the zipper when closing FIGURE 28 a y N FIGURE 29 a fn N FIGURE 30 nflatable PFD Owner s Manual 8 Use a finger to push the zipper ends into the openings at the bottom of the the packed Inflatable PFD Fig 30 9 Ensure the pull tab J is on the outside of the folded Inflatable PFD Fig 30 depicts a correctly folded Inflatable PFD FIGURE 31 Sailing Harness CAUTION Use only as a sailing harness Models with a sailing harness MD3184 are designed to prevent the user from falling overboard when used with a tether with an under load quick release hook and have been designed and tested in accordance with Offshore Racing Council ORC requirements Care and attention must be taken to ensure that the harness is used and maintained correctly The harness is designed to be worn by persons at least 5 feet 5 inches tall 165 cm The harness should be worn as high on t
21. n the top of the oral tube gently squeeze the Inflatable PFD until all air or gas has been expelled Fig 6 Do not wring or twist the Inflatable PFD Put the oral tube dust cap back in its stowed position on the oral tube Fig 7 Let the life jacket dry before packing IMPORTANT Ensure all air is removed before repacking Before following the repacking sequence be sure to properly re arm your Inflatable PFD p 9 1 Lay out the Inflatable PFD flat on a clean surface Fig 18 FIGURE 18 NOTE The fold lines on the diagram are provided to assist with packing 2 Fold side A inward along the full length of the dotted line Fig 19 Fold cover B over covering side A Fig 20 FIGURE 19 FIGURE 20 3 Repeat step 2 with side C cover D nflatable PFD Owner s Manual 13 FIGURE 21 FIGURE 22 4 Fold over the top side E and cover F FIGURE 23 FIGURE 24 5 Mustang Survival uses advanced 2 step zippers ZIP 1 Reset the zipper by pulling the slider G around the top to the Velcro tab H ZIP 2 Close by pulling the slider G in the opposite direction to the end the zipper Fig 26 Ensure that the Inflatable cell does not get caught by the zipper when closing FIGURE 25 FIGURE 26 14 Inf
22. ngs or tabs Such items are not to be used to attach the device to the boat Attaching the device to the boat will not permit it to perform as intended NOTE Model MD3184 has a built in sailing harnesses intended for attaching to boats with quick release under load tethers secured to both d rings see Sailing Harness p 16 Do not attach the MD3184 to boats using any other means AIRLINE OPERATOR POLICY ON CARRIAGE OF INFLATABLE PFDS AND CO CARTRIDGES Please be aware that the following regulations apply to the air transport of this product According to U S Research and Special Programs Administration Regulations Title 49 CFR 75 10 a 25 With the approval of the aircraft operator one small carbon dioxide cylinder fitted into a self inflating jacket plus one spare cartridge may be carried by a passenger or crew in checked or carry on baggage Please refer to the governing body s documentation found online at http hazmat dot gov Inflatable PFD Owner s Manual 25 WE SAVE LIVES FOR A LIVING www mustangsurvival com 3870 Mustang Way TOLL FREE 1 800 526 0532 Bellingham WA EMAIL mustangusa mustangsurvival com USA 98226 Mustang Survival and seahorse design is a registered trademark of Mustang Survival Corp Our commitment to quality has earned our Richmond facilities ISO 9001 registration the highest of all international standards This is our guarantee you re receiving the ultimate in design and manufacturing
23. ore use Single point status indicator is green Fig 1 and 2 Ensure the current date is not past the date on the inflator If it is replace the inflator see Re arming Your PFD p 9 All zippers Velcro and waist buckle are securely fastened Oral inflation dust cap is in the stowed position Fig 7 Inflatable PFD is not twisted Ensure the inflation pull tab is hanging on the outside Fig 30 No rips tears excessive abrasion or holes all seams are securely sewn and the cover straps and hardware are still strong Your Inflatable PFD is ready for use if all applicable boxes are checked NOTE Contact your Mustang Dealer if you have any concerns Inflatable PFD Owner s Manual about the readiness of your Inflatable PFD Sizing and Fit This PFD provides a minimum of 33 7 lbs of buoyancy when inflated and is designed for wearers over 16 years of age with a chest range of 30 52 inches 76 112 cm weighing over 80 pounds 36 kg Donning Instructions It is important that the Inflatable PFD is properly adjusted to fit the person wearing it An incorrect fit or improper fastening of attachments could impede its effectiveness 1 All belts and straps are already threaded correctly and only need to be adjusted for fit For the non harness model MD3183 the belt should fit below your rib cage adjusted to a tight personal fit For the harness model MD3184 the bottom of the b
24. rtridges Inflatable PFD Owner s Manual APPROVAL CONDITIONS AND CARRIAGE REQUIREMENTS Approved for recreational use by the U S Coast Guard USCG as a Type II Model MD3183 or Type V Model MD3184 Personal Flotation Device PFD Neither are approved for water skiing or other high impact high speed activities Model MD3184 has Type II performance but is approved as a Type V PFD because it has a built in sailing harness that can cause injury if not properly used A separate section titled SAILING HARNESS p 15 discusses requirements and features on the MD3184 only USCG approval does not apply to the sailing harness because some of the risks associated with its use have not been evaluated Model MD3183 is a U S Coast Guard approved Type V inflatable PFD approved ONLY WHEN WORN for use on uninspected commercial vessels less than 40 feet in length not carrying passengers for hire as a substitute for a Type II PFD when used in accordance with this owner s manual NOTE MD3184 is not USCG approved for Uninspected Commercial Vessels Conditions for Type V Approval in commercial applications 1 The MD3183 must be worn before getting underway and whenever above deck and not within an enclosed space to meet the carriage requirement 2 The operator of an uninspected commercial vessel is responsible for servicing and maintaining the MD3183 in good serviceable condition in accordance with this owner s manual See Care and Ma
25. to adequately top up the PFD after CO3 inflation WARNING CO inflation could over pressurize and damage your Inflatable PFD if already fully inflated 8 Inflatable PFD Owner s Manual Re arming Your PFD NOTE A valid re arm kit MA7214 is required for this procedure 1 Place the Inflatable PFD Personal Flotation Device on a smooth flat surface and wipe off any water Access the inflator by reaching under the cover and pull it toward you turning the cell and cover inside out to fully expose the inflator for re arming Hold the CO cylinder through the fabric using one hand Fig 8 FIGURE 8 2 Insert the metal key between the black locking ring and labeled yellow cap Turn the key counter clockwise Fig 9 Locking Ring Key 3 Turn the black locking ring counter clockwise and lift off the cap yellow inflator operating head Fig 10 Dispose of the used cap Inflatable PFD Owner s Manual 9 FIGURE 10 4 Squeeze the sealing ring to elongate and remove the inflator body through the sealing ring Fig 11 FIGURE 11 Red Indicator Inflator Body Sealing Ring 6 Check that the inflator body indicator is green Insert the new inflator body with CO3 cylinder pointing upward inside the Inflatable PFD Fig 13 Let the sealing ring rest on the adapter around the four lugs 10 Inflatable PFD Owner s Manu
Download Pdf Manuals
Related Search