Masterbuilt 20010106 Fryer User Manual
Contents
1. The National Wild Turkey Federation recommends refrigerator thawing and to allow approximately 24 hours for every five pounds 2 3kgs of bird thawed in the refrigerator COOKING INSTRUCTIONS 1 Insure that the turkey is completely thawed free of ice and water Remove neck giblet bag plastic pop up cooking indicator and leg ties Pay special attention to inner cavity area when checking for ice or water 2 Fill pot with oil to the fill line 3 Set control dial to 400 F 204 C pre heating time may take up to 55 minutes 4 Place lid on the fryer 5 While oil is pre heating prepare the turkey Inject with a marinade of your choice and season the outside of the turkey with a Cajun rub 6 CALCULATE COOKING TIME The formula for calculating turkey cooking time is fry turkey 3 minutes per pound 0 45kg then add 5 minutes to total cooking time 13 86 Ibs X 3 min 41 58 min Plus 5 minutes 5 00 min Total Cooking Time 46 58 min NOTE Cooking conditions vary Insert a food thermometer 2 inches 5 08cms into the deepest part of turkey and make sure an internal temperature of 180 F 82 C is reached 7 Heating indicator light will go OFF when temperature is reached 8 Place turkey horizontally in basket breast side up 9 Wearing protective gloves or mitts hook the basket handle with the lifting hook and very slowly lower the basket into the hot oil 10 With basket in place cover with lid 11 Set a ki2. the Electric Turkey Fryer be used outdoors Outdoor use is not recommended for Masterbuilt s Electric Turkey Fryer If you do not want to use the unit in your house please use in a garage or covered patio to prevent Electric Turkey Fryer from being exposed to rain showers VISIT OUR WEBSITE FOR MORE INFORMATION AND GREAT TASTING RECIPES www masterbuilt com ASSEMBLY INSTRUCTIONS Step 1 Align notch of inner pot 2 with notch on outer shell 1 Insert inner pot into outer shell Step 2 Attach control panel and element 6 to outer shell mounting bracket as shown fig a Control must be correctly attached for appliance to operate A built in safety switch on control panel will prevent unit from heating if not mounted properly Step 3 Place basket 3 inside inner pot Step 4 Insert breakaway cord 7 into magnetic connection attached to control panel as shown fig b Make sure This Side Up is on top for proper connection Step 5 Place glass lid 4 on last REMINDER Do NOT operate appliance with a damaged cord plug or after appliance malfunctions or has been damaged in any manner Contact Masterbuilt Customer Service for assistance at 1 800 489 1581 STARTER TIPS FOR SAFETY heating element only heats up when properly attached to the mounting bracket see assembly instructions This is a powerful heating element and may cause circuit breaker to trip Minimize occurrences by operating any
3. Masterbuilt Manufacturing Inc 450 Brown Avenue Columbus GA 31906 A Customer Service 1 800 489 1581 MASTERBUILT Cooking Made Simple ASSEMBLY CARE amp USE MANUAL WARNING amp SAFETY INFORMATION MODEL 20010106 ELECTRIC TURKEY FRYER L X THIS PRODUCT IS FOR HOUSEHOLD USE ONLY Manual Code 988060017 rev 060727 HOUSEHOLD CSA CERTIFIED TO USE ONLY US UL STANDARD 1083 A WARNINGS amp IMPORTANT SAFEGUARDS As When using electrical appliances basic safety precautions should always be followed including but not limited to the following Read all instructions Never move appliance when oil or water is above 100 F 38C Do NOT touch hot surfaces Use handles and knobs To protect against electric shock do NOT immerse cord plugs or any part of control panel in water or other liquids Do NOT move appliance while in use or HOT This is an ATTENDED appliance Do NOT leave this appliance unattended during use Even after use never allow children or pets near appliance Heated liquid inside cooking pot remains dangerously HOT for a period of time after use Close supervision is necessary when appliance is used near children Do NOT let children handle or put cord in mouth ALWAYS keep children and pets away from appliance Unplug from outlet when not in use and before cleaning Allow to cool before removing parts for cleaning and storing Do NOT operate appliance with a damaged cord plug or after appliance malfun
4. NEVER place frozen poultry in oil Use extreme caution when cooking frozen foods Never fill oil past fill line or exceed maximum amount of food in basket Spill over can cause serious injury Slowly lower basket into hot oil and cover with lid Always wear protective gloves or mitts L CAUTION When using drain hook on basket make sure that basket is firmly in place on rim of pot before releasing handle so basket will not fall back into hot oil or water causing personal injury PARTS LIST Ooo f o peso E a a a a E a T a ek a Panstand ements REPLACEMENT PARTS LIST ITEM NO DESCRIPTION ITEM NO DESCRIPTION 902060002 Outer Shell 902060004 902060003 902060005 Breakaway Cord 902060006 990060166 Element Bracket Kit 902060001 990060167 Outer Shell Foot Kit 902060007 Lifting Hook 990060168 Outer Shell Handle Kit DO NOT RETURN TO RETAILER For Assembly Assistance Missing or Damaged Parts Call MASTERBUILT Customer Service at 1 800 489 1581 or EMAIL us at Customerservice masterbuilt com STOP ATTACHING OUTER SHELL FEET Philips Head Screws io Y Tools Needed Phillips Head Screwdriver Insert tabs on top of feet into holes in bottom of outer shell and secure with phillips head screws provided as shown RECIPES DEEP FRIED WHOLE TURKEY MAXIMUM RECOMMENDED TURKEY SIZE IS 14 POUNDS 6 35kgs Allow turkey to reach room temperature or set out 1 hour before frying THAWING TURKEY
5. Not withstanding this limitation of warranty the following specific restrictions apply if service repair or replacement of the product is not commercially practical the retailer selling the product or Masterbuilt will refund the purchase price paid for the product less the amount directly attributable to use by the original buyer prior to the ciScovery ot the nonconformity Owner may take the product to the retail establishment selling this product in order to obtain performance under warranty This expressed warranty gives you specific legal rights and you may also have other rights which vary from state to state COMPLETE amp RETURN TO ATTN WARRANTY REGISTRATION Masterbuilt Outdoor Products 450 Brown Avenue Columbus GA 31906 Name City State Province Postal Code Phone Number E Mail Address Model Number Serial Number Place of Purchase 1 1 1 1 1 1 1 1 1 1 I Address 1 1 1 1 1 1 Purchase Date I k 10 COOKING CHART Frying Non Frozen Foods Oil may take up to 55 minutes to reach desired temperature pare Fish Fish Fillets SY 2 Ibs a 400 kanan Whole aan 10 14 Ibs 4 5 6 4kgs 400 eae 3 min per Ib 0 45kg plus 5 min Hot Wings 3 Ibs 1 36kg 400 F 204 C Frying Frozen Foods Refer to instructions on food packaging first STS m Boiling Non Frozen Foods Steamed Foods refer to instructions on food packaging first C la L WARNING
6. additional appliances on a separate circuit Tripping the circuit breaker will NOT damage unit or household electrical system PRE HEATING oil or water may take up to 55 minutes to reach cooking temperature Take advantage of this time to prepare foods for cooking For optimum performance completely pre heat unit to cooking temperature before frying or boiling foods Keeping lid ON during pre heating and cooking cycles will reduce heating time and keep temperature more consistent INDICATOR LIGHT green will turn OFF when heating liquid in unit It will turn ON when liquid has been heated to designated temperature Indicator light may turn on and off during cooking as heating element works to maintain a constant temperature J WARNING Do not use appliance without water or oil in pot It can be severely damaged if heated while empty L WARNING Place unit on level and stable surface to prevent tipping L CAUTION Hot when in use 1 CAUTION Do not fill past fill line in pot L CAUTION Do not mix different type oils at same time 1 CAUTION Never melt fat or lard on heating element or in basket OPERATING INSTRUCTIONS Step 1 Mount control panel amp element onto bracket on outer shell Step 2 Plug power cord into an outlet refer to Warnings amp Important Safeguards section of manual Power light red will illuminate indicating unit is plugged in element is mounted correctly and unit is on Step 3 Turn contro
7. ctions or has been damaged in any manner Contact Masterbuilt Customer Service for assistance 1 800 489 1581 Accessory attachments not supplied by Masterbuilt Manufacturing Inc are not recommended and may cause injury Do NOT use outdoors appliance is for indoor use only Do NOT let cord hang over edge of table or counter or touch hot surfaces Do NOT place on or near a HOT gas or electric burner or in a heated oven ALWAYS attach breakaway cord with plug to appliance first then plug cord in outlet To disconnect turn thermostat control knob to OFF then remove plug from outlet Do NOT use appliance for other than it s intended use If oil begins to smoke IMMEDIATELY turn appliance off NEVER overfill cooking pot Do NOT exceed max fill line in pot Do NOT immerse electric cord or control panel in water Open lid with caution to prevent burns by escaping steam STEAM IS HOT 5 SAVE THESE INSTRUCTIONS l IMPORTANT INFORMATION DO NOT USE AN EXTENSION CORD Use of extension cord increases rick of entanglement or tripping Use of extension cord causes loss of energy and appliance may not heat properly WARRANTY INFORMATION Masterbuilt warrants its products to be free from defects in material and workmanship under proper assembly normal use and recommended care for 90 days from the date of original retail purchase Masterbuilt warranty does not cover paint finish as it may burn off during normal use Mas
8. l knob clockwise to desired temperature Element will not begin heating until knob goes past 100 F 38 C Indicator light green will illuminate when temperature has been reached Step 4 When cooking time has elapsed and food is done turn knob counter clockwise to MIN and unplug power cord Allow excess oil to drain by hooking basket on side of pot with drain clip 5 HOW TO STEAM USING APPLIANCE Add water until it reaches bottom of the basket Do not allow water to evaporate so that element is exposed This will cause the element to overheat and may damage the unit S WATER ELEMENT RESET FUNCTION e This appliance is equipped with an overheat safety feature If appliance overheats it will shut off automatically e To reset appliance unplug from outlet then insert a tooth pick into small hole found on control panel as shown CLEANING MAINTENANCE amp STORAGE Masterbuilt recommends cleaning unit prior to and after use Clean lid inner pot and basket with a damp cloth or sponge using a mild detergent Rinse and dry thoroughly These parts may also be cleaned in a dishwasher Clean outer shell cord control panel and element with a damp cloth or sponge using a mild detergent Dry thoroughly NEVER put these parts in a dishwasher L DANGER Disconnect electric cord from oF bc outlet before cleaning servicing and or removing heating element Electrical shock can result in perso
9. nal injury or death Turn appliance off unplug and let cool for 2 hours if using water 5 hours if using oil before cleaning or storing L CAUTION Do not pour used oil in 5h sink Drain it back into oil containers Periodically check mounting screws on handles and feet to make sure they are still secure Tighten as needed L CAUTION Over tightening can result in stripping of screws or cracking of handles or feet WARNING Do not place control panel under running water Immersing control panel and cord can cause electrocution
10. r will require approximately 1 5 gallons 5 7L of oil The fill line is the maximum amount of liquid that can safely be used in this unit Filling to the line provides more than enough water or oil to prepare any dish in this unit What type of oil should I use Peanut oil is recommended because of the great taste and higher smoke point but any common cooking oil may be used How hot will the oil become Oil will reach 400 F 204 C in approximately 55 minutes Oil temperature will decrease to 275 280 F 135 138 C when turkey is placed in fryer which is an appropriate turkey frying temperature Should I keep the lid on during use Yes the lid helps retain heat and keeps splatter inside unit What size turkey can I deep fry in this unit You can deep fry up to a 14 Ib 6 35kgs turkey in this unit Can an extension cord be used with this unit No extension cords will lose electric current resulting in increased cooking time and decreased performance Extension cords can also pose a trip hazard Does the turkey go in the basket breast side up or down Turkey and turkey breasts should be placed horizontal in basket breast side up followed the formula and the turkey did not fully cook What went wrong Cooking conditions may vary Turkey could have been cold Bring turkey to room temperature before frying Sometimes a cold or frozen spot in a joint or deep in the turkey breast does not allow that section to cook properly Can
11. tchen timer or mark time 12 Heating light will come on indicating the element is heating Be certain to cook for complete calculated time 13 When time is up turn the turkey fryer OFF and lift the basket from the hot oil slowly hooking the basket to the side of the pot with the drain clip 14 Carefully tilt the turkey up on one end to allow oil to drain out of the center cavity The turkey can remain in the basket to cool until ready to serve DEEP FRIED TURKEY BREAST Follow the above directions and safety precautions and adjust formula to 7 minutes per pound 0 45kg then add 5 minutes to total cooking time LOW COUNTRY BOIL BOILING e 1 Ib 0 45kg shrimp 1 Ib 0 45kg crawfish 1 Ib 0 45kg smoked sausage 8 pieces of short ear corn e 2 bags of crab boil mix 2 lbs 0 91kg of whole new potatoes Fill inner pot with water to fill line add 2 bags of crab boil mix and bring water to a boil Allow water to boil for 15 minutes then add sausage cut sausage in 1 4 inch 0 64cm thick slices Three minutes later add potatoes 3 minutes later add corn 3 minutes later add shrimp and crawfish together 3 minutes later remove and serve FREQUENTLY ASKED QUESTIONS Why won t my turkey fryer turn on The Control Panel features a Safety Switch that must be aligned properly for unit to power on Green light will illuminate when control panel is mounted correctly How much oil do I need to use Frye
12. terbuilt warranty does not cover rust of the unit Masterbuilt requires reasonable proof of purchase for warranty claims and suggests ihat you keep your receipt Upon the expiration of such warranty all such liability shall erminate Within the stated warranty period Masterbuilt at its discretion shall repair or replace defective components free of charge with owner being responsible for shipping Should Masterbuilt require return of component s in question for inspection Masterbuilt will be responsible for shipping charges to return requested item This warranty excludes property damage sustained due to misuse abuse accident damage arising out of transportation or damage incurred by commercial use of this product This expressed warranty is the sole warranty given by Masterbuilt and is in lieu of all other warranties expressed or implied including implied warranty merchantability or fitness for a particular purpose Neither Masterbuilt nor the retail establishment selling this product has authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above Masterbuilt s maximum liability in any event shall not exceed the purchase price of the product paid by the original consumer purchaser Some states do not allow the exclusion or limitation of incidental or consequential damages In such a case the above limitations or exclusions may not be applicable California residents only
Download Pdf Manuals
Related Search