Karcher KM 100 / 100 R Lawn Sweeper User Manual
Contents
1. Cleaning and maintenance Internal cleaning External cleaning Maintenance intervals Elapsed time meter Maintenance by the customer Maintenance by the customer service department Maintenance tasks Notes on safety Battery safety instructions Charge the battery Check and top up the battery s fluid level Check the tyre air pressure Changing wheels Checking the vacuum system Checking traction belt Checking the sealing cup Replacing side brush Check the sweep roller Replace the sweep roller Adjusting and replacing sealing strips Replace the dust filter Replacing the filter box seal Changing fuses 25 25 25 25 25 25 25 25 25 26 26 26 26 26 27 27 27 27 27 28 28 28 28 29 30 30 30 Fault instructions Accessories Technical data EC conformity declaration 30 31 31 32 18 Operating instructions KM 100 100 R KM 100 100 R P English For your own safety Never absorb explosive liquids General notes It is mandatory to read and observe this prior to using the appliance Notify your sales outlet if during unpacking you detect damage that has occurred in transit gt Read the operating instructions of your appliance prior to putting it into operation especially the safety information The warning signs and information labels attached to the unit provide important advice on its safe operation In addition to the instructions in th2. gt Close the bypass cover on left When the coarse dirt flap is behind the seat open the main brush can hurl stones or stone chips forwards Make sure that nobody no animals or objects are endangered Sweeping damp or wet ground Notes gt For optimum cleaning effect match the driving speed to suit the actual conditions gt During operation the debris container should be emptied at regular intervals gt Lower only the main brush when sweeping large floor surfaces gt Also lower the side brush when cleaning inner surface edges gt Open the bypass cover on left behind the seat This protects the filter from damp Driving over obstacles Fixed obstacles of up to 50 mm in height gt Slowly and carefully drive over them in the forward direction Fixed obstacles over 50 mm in height gt May be driven over only with a suitable ramp Drive system overload warning To prevent damage to the drive system the sweeper is provided with an overload warning and a shut off The overload warning flashes if the overload of the drive system reaches a critical stage The overload can be sustained for 1 min after which the sweeper is switched off by the control The control switches the sweeper off immediately if the drive system s overload exceeds the overload limit Resetting gt Stop machine gt Turn the key switch to position 0 gt Turn the key switch to position I S
3. Voltage 24V Rated current 37A Rated power 750 W Protection class IP44 Speed infinitely variable Fan and main brush motor Type direct curent permanent magnet motor Model B14 Voltage 24 V Rated current 35A Rated power 600 W Protection class IP20 r p m 3500 1 min Side brush motor Type direct curent permanent magnet motor Design Gear motor bevel gear Voltage 24 V Rated current 5A Rated power 100 W Protection class IP44 r p m 70 1 min Battery Type 24V 4 PzS 240 Capacity 240 Ah Charging time of a completely flat battery 10 15 h Operating time following repeated charging approx 2 5 h Battery charger Mains voltage 230 V 50 Hz Output voltage 24 V Output current max 30 A Fuses Master fuse 150 A Side brush motor 30 A Filter drive motor 10A Control 5A Vacuum pump 2A Tyres Large size rear 4 00 8 00 Air pressure rear 6 bar Brake Service brake electronic Parking brake disk brake electrically actuated with spring Filter and suction system Fine dust filter surface 6 0 m Filters application class U for non health hazardous dusts Rated vacuum of suction system 12 mbar Rated volumetric flow of suction system 50 l s Ambient conditions Temperature 5 40 C Atmospheric humidity non dew developing 20 90 Vibrations of unit ISO 5349 and ISO 2631 1 Upper limbs 1 79 m s Whole body seat 0 85 m s Total body feet 0 85 m s Noise emission Sound pressure level EN 60704
4. 1 75 dB A Garanteed sound power level 2000 14 EC 93 dB A 31 Operating instructions KM 100 100 R KM 100 100 R P English EC conformity declaration We hereby declare that the machine specified below as the marketed desigh the machine specified below complies with the relevant fundamental safety and health requirements of the EC directives listed below Modification of the machine without our approval invalidates this declaration Product Ride on vacuum sweeper Type 1 280 xxx Relevant EC directives EC machine directive 98 37 EC EC low voltage directive 73 23 EEC amended by 93 68 EEC EC directive on electromagnetic compatability 89 336 EEC amended by 91 263 EEC 92 31 EEC 93 68 EEC EC guideline on noise emissions 2000 14 EU Applied harmonised standards DIN EN 60 335 1 DIN EN 60 335 2 29 DIN EN 60 335 2 72 DIN EN 55 014 1 2000 A1 2001 DIN EN 55 014 2 1997 DIN EN 61 000 3 2 2000 DIN EN 61 000 3 3 1995 A1 2001 Applied national standards Managing directors Dr Bernhard Graf Hartmut Jenner Georg Metz Applied conformity valuation method Alfred Karcher GmbH amp Co KG Appendix V Cleaning Systems Alfred Karcher Strasse 28 40 Measured sound power level P O Box 160 91 dB A D 71349 Winnenden Phone 49 7195 14 0 Guaranteed sound power level Fax 49 7195 14 2212 93 dB A Internal measures ensure that the in series produced units always Cc comply
5. Checking the sealing cup gt The sealing cup must be regularly checked for a proper fit Sealing cup at the suction turbine Replacing side brush gt Unscrew fastening screws 3 pieces at the underside gt Slip side brush on carrier and screw it tight Check the sweep roller gt Stand sweeper on a flat surface gt Raise the sweep roller gt Turn key switch to 0 and remove key gt Secure the machine against rolling away using a wedge gt Remove the debris container from both sides of the unit ES gt Remove tapes and string from the sweep roller Replace the sweep roller Replacing it is necessary when the sweeping effect visibly deteriorates due to wear of the bristles Stand sweeper on a flat surface Raise the sweep roller Turn key switch to 0 and remove key gt Secure the machine against rolling away using a wedge gt Remove the debris container from both sides of the unit v v v gt Pull off the main brush rocker arm gt Unscrew screws Ss gt Unscrew front screw of right side panellint gt Lift off cover and remove main brush gt Loosen fastening screw of the bowden cable and unhitch the cable gt Unscrew the screw at the fulcrum of the main brush rocker arm gt Unscrew rear screws of right side panelling 28 Operating instructions KM 100 100 R KM 100 100 R P English Adjusting and replacing sealing strips gt Sta
6. flap Note An optimal cleaning effect can be achieved only when the coarse dirt flap is completely lowered gt Lower side brushes for sweeping in border areas Sweeping with side brushes Notes When they are lowered the main and the side brushes automatically start turning Adding the function of the side brush is possible only if the main brush is operative Stop machine gt Raise the side and the main brush gt Turn key switch to 0 and remove key Note The dust filter is automatically dedusted for approx 15 s after shutting down of the machine Do not open the unit cover while this is going on Note The machine is provided with an automatic parking brake which is activated when the engine is stopped and the driver leaves his seat 23 Operating instructions KM 100 100 R KM 100 100 R P English Empty the swept material container gt Wait until automatic filter dedusting is completed and the dust has settled before opening the debris container and emptying it gt Pull out debris container gt Empty the swept material container gt Slide in and lock the debris container gt Then perform the same operations on the opposite debris container Usage instructions Sweeping dry ground Safety instructions when sweeping A Warning Never sweep up packing straps wires or the like as this could damage the sweeping mechanism
7. this work performed by a K rcher after sales service station or an authorised specialist Fault instructions Machine does not move gt Sit on the driver seat gt Disable the EMERGENCY STOP gt Switch ON key switch gt Charge the battery gt Check fuses gt Notify the Karcher service station The sweeper moves only slowly gt Check position of the parking brake gt Notify the Karcher service station Machine not sweeping properly gt Main brush and side brush are worn if applicable replace them gt Main brush does not turn check traction belt gt Check the operation of the coarse dirt flap gt Check sealing strips for wear adjust or replace them as required gt Check the seal on the vacuum system gt Notify the Karcher service station Machine making dust gt Empty debris container gt Check drive belts for the suction turbine gt Check sealing cup at the suction turbine gt Check filter cartridge clean or replace it gt Check filter box seal gt Check sealing strips for wear adjust or replace them as required gt Notify the Karcher service station Side brush does not turn gt Check the fuse gt Notify the Karcher service station Poor sweeping around the edges gt Replacing the side broom gt Notify the Karcher service station Activation of side brush or main brush does not function gt Check the seal on the vacuum system gt By pass cover open gt No
8. with the requirements of sa current EC directives and applied standards The signatories act for and in authority of management Reiser Jenner 5 957 695 01 02 Alfred Karcher Limited Partnership Registered office Winnenden Registration court Waiblingen HRA 169 Personally liable partner Karcher Reinigungstechnik GmbH Registered office Winnenden 2404 Waiblingen Company Register HRB 32 KM 100 100 R KM 100 100 R P DE EN FR IT NL Manuelle Filterabreinigung Manual filter cleaning Nettoyage manuel du filtre Pulizia manuale del filtro Manuele filterreiniging Beim Kehren gro er Fl chen Clean the dust filter regularly when Lors du balayage de surfaces Durante la spazzatura di superfici Bij het vegen van grotere regelm ig Staubfilter abreinigen sweeping large surfaces importantes nettoyer r guli rement grandi pulire regolarmente il filtro oppervlakken regelmatig stoffilter le filtre antipoussi re antipolvere reinigen gt Taste Filterabreinigung kurz gt Press filter cleaning switch gt Appuyer bri vement sur la gt Premere brevemente il tasto per gt Toets filterreiniging kort dr cken Der Staubfilter wird briefly The dust filter is cleaned touche nettoyage du filtre Le pulizia filtro II filtro antipolvere indrukken Het stoffilter wordt ca 15 Sekunden lang for approx 15 seconds Do not filtre antipoussi re est nettoy viene pulito per ca 15 secondi ca 15 seconden lang abgereinig
9. KARCHER KM 100 100 R KM 100 100 RP 1 280 101 i 1 280 111 www kaercher com 5 960 294 A2008261 05 04 KM 100 100 R KM 100 100 R P Betriebsanleitung 3 Anhang Manuelle Filterabreinigung 237 Ersatzteilliste 240 Operating Instructions 18 Appendix Manual filter cleaning 237 Spare Parts List 240 Notice d utilisation 33 Annexe Nettoyage manuel du filtre 237 Liste des pi ces de rechange 240 Istruzioni per l uso 49 Appendice Pulizia manuale del filtro 237 Elenco pezzi di ricambio 240 Gebruiksaanwijzing 65 Bijlage Manuele filterreiniging 237 Reserveonderdelenlijst 240 Instrucciones de servicio 80 Anexo Limpieza manual del filtro 238 Lista de piezas de requesto 240 Manual de instrugoes 96 Anexo Limpeza manual do filtro 238 Lista de pecas sobresselentes 240 O dnyieg AeEITOUPYIGG 112 Map prnua KaB PIONA PIATPOU HE TO X PI 238 AVTQAAQKTIKO 240 Driftsvejledning 130 Bilag Manuel filterreng ring 238 Reservedelsliste 240 Bruksveiledning 145 Tillegg Manuell filterrensing 238 Reservedels liste 240 Driftinstruktion 159 Bilaga Manuell filterrensning 239 Reservdelslista 240 Kayttoohje 174 Liite Suodattimen manuaalinen puhdistus 239 Varaosalista 240 Instrukcja obstugi 189 Zatacznik Reczne czyszczenie filtra 239 Lista cz ci zamiennych 240 letme k lavuzu 205 Ek Man el filtre temizleme 239 Yedek par a listesi 240 Cihaz n kullan m 10 y ld r PykoBOACTBO no a3KcrinyaTa
10. KU punbTpa PUNbTP OT nbinn OYULLAETCA OK 15 CEKYHA B 3TO Bpema KOXYX annapata OTKPbIBaTb HENb3a 239 KM 100 100 R KM 100 100 R P YKARCHER 6 654 143 0 i 6 368 217 0 A 6 435 253 0 6 375 212 0 Ki a Ke a 5 115 233 0 gt 5 120 343 0 VE Re 7 306 031 0 eee 7 304 801 0 435 686 7 306 031 0 5 116 060 0 6 906 375 0 6 905 986 0 08 2002 240
11. and then release it Seat contact switch If the machine is left during operation the engine switches off via the seat contact switch Risk of overturning on too high gradients A Danger The machine could topple over when driving and turning on slopes Drive only on slopes up to 18 in the travelling direction At right angles to direction of travel only negotiate gradients up to a maximum of 15 Risk of overturning when taking bends rapidly A Danger The machine can topple over when driving fast around curves gt Drive slowly in curves Danger of tipping over given an unstable travelling surface A Danger The machine can tip over given an unstable travelling surface gt Move the machine exclusively on a solid travelling surface Danger of tipping over given a sideways incline that is too large A Danger The machine can tip over given an incline of more than 15 For our environment Caution danger to the environment from used batteries amp Do not dispose of exhausted batteries as ordinary household garbage gt Ensure environmentally compatible disposal Endangerung of environment by packaging materials es Domestic rubbish is not the proper place for used packaging materials gt Make sure that they are ecologically recycled Intended use Function description Control elements sweeping machine This sweeper is int
12. denne de los equipos durante la Durante este per odo nao abrir a Kata To 1I o0TNuUA aut unv sk rm i l bet af denne tid tiden limpieza tampa do aparelho avoiyete TO KANAKI TNS OUOKEUNS 238 KM 100 100 R KM 100 100 R P SV FI PL TR RU Manuell filterrensning Vid sopning av stora ytor ska dammfiltret rensas regelbundet Suodattimen manuaalinen puhdistus Puhdista p lysuodatin s nn llisesti suuria alueita lakaistessasi R czne czyszczenie filtra Przy zamiataniu du ych powierzchni nale y regularnie czy ci filtr py u Man el filtre temizleme B y k alanlar n s p r lerek temizlenmesinde muntazam aral klar ile toz filtresi temizlenmelidir gt Tryck p knappen f r filterrensning kort Dammfiltret rensas i ca 15 sekunder ppna inte maskinhuven under denna tid gt Paina lyhyelti suodattimenpuhdistuspainiketta P lysuodattimen puhdistus kest n 15 sekuntia l avaa t n aikana laitteen kantta gt Kr tko nacisna przycisk czyszczenia filtra Filtr pytu jest czyszczony przez ok 15 sekund W tym czasie nie otwiera pokrywy urzadzenia gt Filtre temizleme tusuna kisaca basilmalidir Toz filtresi yaklasik 15 saniye boyunca temizlenir Bu sure i inde cihaz kapa a lmamal d r PyuHasi 4ucTKa pnnbTpa Ipu y60pke Sonbuiux nnowagen cneayeT MpoBOAMTb perynapHyto YUCTKY MUNbTPA OT NbINM gt KpaTKOBpemMeHHO HaxaTb KHONKy Oy4NCT
13. e operating instructions general safety and accident prevention regulations from lawgivers must be followed Use gt The unit shall be exclusively used in accordance with the specifications given in these operating instructions gt Prior to utilization the appliance and its working facilities must be checked regarding their proper condition and that they operate safely It must not be used if its condition is not faultless The unit is intended for sweeping inside and outside surfaces No modifications permitted on the machine inflammable gases or undiluted acids and solvents This includes petrol paint thinner or fuel oil which can form explosive fumes due to the swirling suction air in addition acetone undiluted acids and solvents since they corrode the materials used for the appliance Do not sweep up absorb burning or smouldering objects Only if expressly marked as such is this appliance suitable for sucking up health hazardous dust types Observe the safety related notes given in the operating instructions Suitable only for the surfaces listed in the operating instructions The appliance may be used on only the areas cleared for its use by the factory owner or a person authorized by him Keep clear of the danger area Its operation in explosion hazardous locations is prohibited The following applies generally Keep combustible materials away from the machine dange
14. ended for sweeping inside and outside surfaces It is not intended for use on public traffic routes It is not suitable for health hazardous dusts The KM 100 100 R sweeper operates according to the throw 1 Steering wheel 2 Raising lowering coarse dirt flap over principle pedal The side brush 3 cleans corners 3 Forward driving reversing drive and edges of the sweeping pedal surface and transports the dirt in the path of the main brush The rotating main brush 4 transports the dirt directly into the debris container 5 The dust swirled up in the container is separated by way of the dust filter 2 and the filtered clean air removed by the suction turbine 1 Horn Elapsed time meter Raising lowering main brush Raise lower side brush Filter de duster EMERGENCY STOP switch Key operated switch Drive system overload warning Main brush overload warning Battery charge indicator 1 2 3 4 5 6 7 8 9 0 20 Operating instructions KM 100 100 R KM 100 100 R P English Machine components 1 Unit cover 2 Debris container bilateral 3 Coarse dirt flap 4 Roller 5 Side brush Before first operating The sweeper has an electric drive The machine can be pushed only if the trigger is pulled away from the wheel See chapter Moving the sweeper without its own drive Open close unit cover Open unit cover g
15. ening nuts of the panelling gt Set the sealing strip s clearance rear sealing strip to the floor so that it bends gt Screw on new sealing strip backwards with a lag of 35 40 mm gt Tighten nuts gt Unscrew rear screws of side panelling 29 Operating instructions KM 100 100 R KM 100 100 R P English Replace the dust filter A Danger gt Empty the debris container prior to beginning work on replacing the dust filter gt Wear a dust protection mask when working on the filter system gt Observe the safety precautions for handling fine dust gt Open unit cover engage stay bar gt Pull out the handle of the filter bracket and engage it gt Take out filter cartridge gt Insert the new filter DK as gt On the drive side engage the carrier into the holes gt Re engage the handle of filter dedusting Note Make sure when mounting the new filter that the lamella are not damaged Replacing the filter box seal Remove filter box seal from the groove in the unit cover and insert the new seal Changing fuses gt Unscrew the screws at both sides of the covering CALA gt Replacing blown fuses gt Refasten front covering Note Use only fuses with the same current rating Battery terminal fuse gt Replace defective fuses 1 Nut 2 Battery charging cable 3 Terminal fuse 4 Bridge 5 Screw Note It is strongly recommended to have
16. gt Turn key switch to 0 and remove key gt Secure the machine with wedges on the wheels gt Secure the machine with stretch belts or ropes Fastening areas Notes Observe markings for fastening areas on base frame chain symbols For loading or unloading the machine may be operated on slopes of only up to a max of 18 Cleaning and maintenance External cleaning Clean with a damp cloth previously soaked in mild suds Note Do not use any aggressive cleaning agents Maintenance intervals gt Stand sweeper on a flat surface gt Turn key switch to 0 and remove key Internal cleaning A Danger Wear dust mask Wear safety goggles gt Open unit cover engage stay bar gt Clean with a rag Note The filter cartridge can be cleaned with water Prior to re inserting it the filter must be completely dried Elapsed time meter Elapsed time meter indicates maintenance interval times Maintenance by the customer Daily maintenance gt Check the tyre air pressure gt Check roller and side brush for wear and trapped straps gt Check the function of all operating controls Maintenance weekly gt Checking the battery acid level gt Check freedom of movement of Bowden cables and moving parts gt Check setting and wear of sealing strips in sweeping area gt Checking the vacuum system Maintenance every 100 operating hours gt Check operation of seat contact sw
17. itch gt Check tightness wear and operation of drive belts V belts and round belts Maintenance according to degree of wear gt Replace sealing strips gt Replacing the sweep roller gt Replacing the side broom See maintenance tasks chapter for description Note All service and maintenance work must be performed by qualified and Skilled personnel A Karcher specialist dealer can be consulted whenever support is necessary 25 Operating instructions KM 100 100 R KM 100 100 R P English Maintenance by the customer service department Maintenance after 8 operating hours First inspection Maintenance after 20 operating hours Maintenance every 100 operating hours Maintenance every 300 operating hours Maintenance every 500 operating hours Maintenance every 1000 operating hours Maintenance every 1500 operating hours Note To safeguard warranty rights during the warranty period all service and maintenance work must be performed by an authorised Karcher after sales service Maintenance tasks Notes on safety A Warning Preparations gt Stand sweeper on a flat surface gt Turn key switch to 0 and remove key Battery safety instructions A Danger Always heed safety precautions for handling batteries Comply with the battery manufacturer s service manual Work on batteries is permitted only after instruction by trained personnel A Danger gt Wear safet
18. nd sweeper on a flat surface gt Raise the sweep roller gt Turn key switch to 0 and remove key gt Secure the machine against rolling away using a wedge gt Remove the debris container from both sides of the unit gt Screw off side panelling on both Front sealing strip Rear sealing strip Side sealing strips sides gt Slide the new main brush into the gt The floor clearance of the sealing gt Slightly loosen fastening nuts of main brush box and slip it onto the front sealing strip unscrew it strip is set so that it bends the side sealing strip unscrew the drive peg to replace it backward with a lag of them to replace it gt Screw on new sealing strip but 5 10 mm gt Screw on new sealing strip but Notes do not yet tighten nuts gt Replace if worn do not yet tighten nuts Pay attention to the position of gt In order to set the clearance to the bristle set when installing the gt Dismantle the sweeping drum the floor slide in the 1 2mm new main brush spacer The bowden cable is to be adjusted so that the main brush is raised approx 10 mm from the floor gt Align the sealing strip gt Tighten nuts gt Screw on side panelling gt Insert the swept material gt Follow the instructions in reverse container to mount the main brush rocker arm gt Screw on side panelling gt Insert the swept material container gt Unscrew front screw of side gt Align the sealing strip gt Unscrew fast
19. ng it performing maintenance work on it replacing parts or resetting it to a different operation gt For battery run appliances the battery plug must be pulled out of the socket prior to work on the electrical equipment i e the battery is to be disconnected Repairs may only be carried out by approved customer service centres or by technical personnel trained in this field which are familiar with all relevant safety regulations Industrially used appliances in changing locations are subject to the safety inspection according to VDE 0701 Use only the main brushes side brushes fitted in the unit or specified in the operating instructions Using other main brushes side brushes can be detrimental to safety The unit may not be cleaned with a hose or a high pressure water jet danger of short circuits or other damages Accessories and spare parts Only accessories and spare parts cleared by the manufacturer may be used Genuine accessories and spare parts guarantee that the unit can be operated safely and trouble free Riding appliances Riding appliances are not approved for public highways Please ask your retailer for the conversion kit for street worthiness Giving companions lifts is not permissible Riding appriances may be set in motion only from the seat Battery driven appliances Warranty is valid only when you use the batteries and charging units recommended by Ka
20. r of explosions fire Operation The rules regulations and stipulations applying to motor vehicles must always be observed The operator must use the unit in accordance with its intended purpose She must adapt her mode of operation to the local conditions and when working with the appliance keep a look out for third parties especially children The appliance may only be used by persons instructed in its handling or who have proved their capability of operating it and who are expressely authorized to use it The unit must not be operated by children and youths gt To prevent unauthorized utilization of appliances provided with an ignition key the ignition key must be removed gt The appliance must never be left unattended as long as the motor is running The operator may not leave the appliance until the motor is turned off the appliance is safeguarded against unintentional motion if necessary the parking brake actuated and the ignition key removed On slopes the angle of inclination to the side and in the direction of motion must not exceed the value given in the operating instructions Transport gt The motor must be turned off when the appliance is transported gt Secure the machine with guy belts ropes or chains gt Immobilise the machine at the wheels with chocks Maintenance gt The unit must be switched off and if necessary the ignition key removed prior to cleani
21. rcher gt It is mandatory to comply with the battery manufacturer s operating instructions Heed the statutory recommendations on handling batteries gt Never leave a battery in a run down condition but recharge it as soon as possible gt Keep the batteries always clean and dry to prevent leaking currents Protect it from contamination for example by metallic dust gt When mounting the batteries in the KM 100 100 R make absolutely sure you also install the battery terminal fuse see maintenance work chapter on replacing fuses gt Do not place tools or similar objects on the battery Hazard of short circuits and explosion gt Do not under any circumstances work with an open flame create sparks or smoke near a battery or in a battery recharging room Explosion hazard gt Do not touch hot parts for example the driving engine hazard of burns 19 Operating instructions KM 100 100 R KM 100 100 R P English gt Take care when handling accumulator acid Heed the relevant safety regulations gt Used batteries are to be disposed of in an environmentally friendly way according to EC guideline 91 157 EWG Safety features Safety features are provided for the protection of the operator and it is forbidden to disconnent them or circumvent their operation EMERGENCY STOP pushbutton For an instant stop of all operations To unlatch it turn it slighly to the left or the right
22. t In dieser Zeit die open the unit cover during this pendant env 15 secondes Ne Durante questo tempo non schoongemaakt In deze tijd de Ger tehaube nicht ffnen period pas ouvrir le capot de l appareil aprire il cofano dell apparecchio apparaatkap niet openen pendant ce temps 237 KM 100 100 R KM 100 100 R P ES PT EL DK NO Limpieza manual del filtro Limpeza manual do filtro KaB PIONA PIATPOU pE TO Manuel filterreng ring Manuell filterrensing x EPI Al barrer superficies grandes limpie Ao varrer grandes superficies Ved fejning af store arealer skal Rens st vfilteret med jevne el filtro de polvo a intervalos limpar regularmente o filtro de Kat TO OkOUNIONG HEYGAWV man regelm ssigt reng re mellomrom n r du feier store regulares poeira enimavelwv va kaBapizete st vfiltret arealer TOKTIKA TO QIATPO OKOVNG gt Apriete brevemente el pulsador gt Premir a tecla de limpeza do filtro gt Natnote yia Aiyo To MANKTPO gt Tryk kort pa tasten gt Trykk kort pa tasten for para la limpieza del filtro El filtro durante um curto espa o de KABAPIOUOU PIATPOU To Filterreng ring St vfiltret filterrensing St vfilteret renses i de polvo se limpia durante unos tempo O filtro de poeira limpo MIATEO OK VNG KaBapiZeTal reng res i ca 15 sekunder ca 15 sekunder Ikke pne 15 segundos No abra la capota durante aprox 15 segundos yia nep 15 Deutep denta Undlad at bne apparatets maskindekslet i l pet av
23. t Swivel unit cover upwards at the provided handle grip When opened the unit cover is secured by a stay bar a eo gt Pull stay bar out of the bracket gt Insert the stay bar into the adapter at the suction turbine gt To close the unit cover pull the stay bar out of the holder and engage it in the bracket in the unit cover Operating sweeping machine without automotive power A Danger Prior to manually releasing the parking brake the sweeper is to be secured against movement After the parking brake is released the sweeper coasts unbraked gt Pull the brake lever away from the wheel and hold it tight in this position The function of the parking brake is thus out of action and the sweeper can be pushed Unloading instructions A Warning Generally it is not permitted for the parking brake to be released when loading the machine The machine was secured on a pallet with stretch belts or ropes for safe transport Proceed as follows when unloading gt Cutthe plastic packing tape and remove the film gt Remove the blocks for securing the wheels and drive the machine off the pallet using a suitable ramp A Warning Do not use a fork lifter for unloading the machine can be damaged by it 21 Operating instructions KM 100 100 R KM 100 100 R P English Before every operation Commissioning General notes gt Stand sweeper on a flat surface gt T
24. the specifications of the battery charger s and the battery s manufacturers KM 100 100 R P gt Open unit cover engage stay bar gt Insert power plug Charging condition indicator Yellow Battery is charging Green Battery is charged Red Fault inform Karcher s after sales service 26 Operating instructions KM 100 100 R KM 100 100 R P English Check and top up the battery s fluid level A Warning gt Regularly check the fluid level of acid filled batteries gt Open all cell plugs gt If the fluid level is too low fill up cells with distilled water up to mark gt Close cell plugs gt Charge the battery Check the tyre air pressure gt The air pressure in the rear tyres must be set to 6 bar Changing wheels A Danger Preparations gt Stand sweeper on a flat surface gt Turn off key switch and remove the key gt Wear warning clothing when performing repair work on public streets where it is dangerous because of moving traffic gt Check that the ground is stable gt Protect the machine additionally from moving with a wheel chock Recommended express assistance gt Check the tyre tread for imbedded objects gt Remove the objects gt Use a suitable commercially available tyre repair agent Notes Comply with the recommendations of the respective manufacturers Continuing the journey is possible if the recommendations of the product man
25. the driving pedal 22 Operating instructions KM 100 100 R KM 100 100 R P English Drive backwards gt Slowly press the driving pedal Note Driving behaviour The driving speed can be varied continuously with the driving pedals Slightly release drive pedal if power decrease is registered uphill Braking gt Ease pressure on drive pedal the sweeper brakes automatically and stops A Warning If while the drive pedal is actuated the seat contact switch or the key switch are turned on the drive system will be turned off and the side brush the main brush the blower fan as well as the LEDs will be turned on Service operation Remedy gt Release pedal Sweeping operation A Warning In order to avoid damaging the floor do not operate the sweeper while it is stationary When stopped the sweeping system continues running for approx four more seconds A Danger Do not stand up when driving danger of falling gt Lower main brush Sweeping with the main brush gt The coarse dirt flap must be briefly raised for sweeping in largish objects up to a height of 60 mm e g drinks cans A Warning It is possible for debris to be thrown forwards when the coarse dirt flap is raised A hazard for bystanders Raise coarse dirt flap gt Press pedal forwards and keep it depressed gt To lower it lift foot off pedal Sweeping with raised coarse dirt
26. tify the Karcher service station 30 Operating instructions KM 100 100 R KM 100 100 R P English Accessories Technical data Side brush 6 905 986 Provided with standard bristles for indoor and outdoor surfaces Soft side broom 6 906 133 For fine dust on indoor surfaces resistant to moisture Hard side broom 6 906 065 For cleaning hard to remove dirt from outdoor surfaces Standard main brush 6 906 375 Wearproof and wetproof Universal bristles for indoor and outdoor cleaning Main brush soft 6 906 533 With natural bristles specially for sweeping fine dust on smooth indoor floors Not moisture resistant not for abrasive surfaces Main brush hard 6 906 532 For removing stubborn external dirt damp proof Filter cartridge 6 414 532 Battery set 6 654 112 Battery charger 6 654 143 Unit data Length x width x height 2006 x 1005 x 1343 mm Empty weight 300 kg Permissible total weight 660 kg Empty dead weight 470 kg Driving sweeping speed 5 5 km h Climbing ability max 18 Main brush diameter 285 mm Main brush width 710 mm Side brush diameter 450 mm Area performance with 2 side brushes 7150 m h Working width without side brush 710 mm with side brush 1000 mm Volume of debris container 100 litres Protection class drip proof IPX 3 Motors Traction motor Type wheel hub motor in front wheel Design direct current permanent magnet motor for forward driving and reversing
27. ufacturer are observed Change the tyre or the wheel as soon as possible gt Unscrew wheel bolt gt Place the jack in position Jack fixing point rear wheels gt Lift the machine with the jack gt Remove wheel bolt gt Slide the wheel off gt Position the spare wheel gt Screw in wheel bolt gt Lower the machine with the jack gt Tighten wheel bolt Note Use an appropriate commercially available jack and a chock Checking the vacuum system Adding a sweeping system is with the aid of a vacuum system If the side brush or the main brush cannot be lowered check the vacuum canisters for proper connection of the hose lines if applicable re connect the hose concerned The vacuum system is leaky if the side brush or the main brush still cannot be lowered In this case after sales service must be contacted Hose connection to vacuum canister of side brush lowering Hose connections to vacuum canister for lowering main brush Hose connections to vacuum pump and to vacuum canister storage Note The vacuum pump operates only if vacuum is built up in the system Consult after sales service if the pump operates continuously Checking traction belt gt The traction belts must be regularly checked for wear and damage b e Traction belt for suction turbine Traction belt for main brush 27 Operating instructions KM 100 100 R KM 100 100 R P English
28. urn off key switch position 0 Testing and maintenance work gt Check charge condition of battery gt Check side brushes gt Check main brush gt Empty the swept material container gt Check tyre inflation pressure See maintenance work chapter for instructions Adjust driver seat gt Open unit cover engage stay bar gt Slightly loosen wing nuts of seat runners gt Push the seat into the appropriate position gt Retighten wing nuts Note There is a further adjustment possibility if the adjusting range is insufficient gt Unscrew the 4 screws at the seat contact switch plate gt Remove the plate gt Turn the seat forward gt Unscrew 4 screws of seat mounting gt Shift seat and refasten with screws gt Remount seat contact switch plate Switching on the machine gt Sit on the driver seat gt Do NOT actuate the drive pedal Note The machine is equipped with a seat contact switch The machine is switched off and the parking brake is automatically applied when the driver leaves his seat gt The main brush and side brush switches are in their upper position gt Turn the key switch to position I Run machine A Danger Do not stand up when driving danger of falling Prior to start of the machine gt The main brush and side brush switches are in their upper position gt Switching on the machine Drive forwards gt Slowly press
29. uuu 220 MpunoxeHue PyyHaa ounctka pUNbTPa 239 3anacHble YacTu 240 Operating instructions KM 100 100 R KM 100 100 R P English Contents For your own safety General notes Safety features Risk of overturning on too high gradients Risk of overturning when taking bends rapidly Danger of tipping over given an unstable travelling surface Danger of tipping over given a sideways incline that is too large For our environment Caution danger to the environment from used batteries Endangerung of environment by packaging materials Intended use Function description sweeping machine Control elements Machine components 19 19 20 20 20 20 20 20 20 20 20 20 20 21 Before first operating Open close unit cover Operating sweeping machine without automotive power Unloading instructions Before every operation General notes Testing and maintenance work Commissioning Adjust driver seat Switching on the machine Run machine Sweeping operation Stop machine Empty the swept material container Usage instructions Safety instructions when sweeping Sweeping dry ground Sweeping damp or wet ground Driving over obstacles Drive system overload warning Sweeping system overload warning Battery discharging warning 21 21 21 21 22 22 22 22 22 22 22 23 23 24 24 24 24 24 24 24 24 25 Decommissioning Transport Transport instructions
30. weeping system overload warning In order to avoid damage to its sweeping system the sweeper is provided with an overload warning and a shut off If the load on the sweeping system reaches the overload limit the overload warning lights up and the control switches the sweeping system off after 4 s Resetting gt Switch off sweeping system gt Turn the key switch to position 0 gt Turn the key switch to position I 24 Operating instructions KM 100 100 R KM 100 100 R P English Battery discharging warning Green Battery is charged Yellow Battery is almost dead gt Stop sweeping and charge battery Red Battery flat Sweeping system switched off by control gt Charge the battery see chapter on Maintenance Flashing red Discharge limit reached 3 more min driving possible then the sweeper turns itself off gt Then the sweeper cannot be restarted any more the battery must be recharged for at least 3 hours Decommissioning Please heed the following if sweeper is not to be used for a lengthy period gt Stand sweeper on a flat surface gt Turn key switch to 0 and remove key gt Safeguard the sweeping machine from rolling away gt Clean inside and outside of sweeper gt Turn off the machine ona protected and dry place gt Charge the battery and recharge it at intervals of approx every two months Transport Transport instructions
31. y goggles and protective clothing gt Observe regulations for the prevention of accidents as well as DIN VDE 0510 VDE 0105 T 1 A Danger Risk of fire and explosion Smoking prohibited No naked flames glowing embers or sparks in the vicinity of batteries Do not place any objects or tools on the battery because voltage is always present between the battery poles Areas in which batteries are charged must be well ventilated as highly explosive gas forms during charging Danger of acid burns gt Rinse out or rinse off splashes of acid in the eye or on the skin with copious quantities of clean water gt Then consult a doctor immediately gt Wash contaminated clothing with water Sy Old batteries with this symbol are reusable commodities and must therefore be returned for recycling Old batteries which are not returned for recycling must be disposed of as special waste thereby observing all statutory regulations A Danger Have the battery installed only by a K rcher service mechanic and in compliance with the battery manufacturer s specifications Charge the battery A Danger The unit cover must remain open while the battery is charged Explosion hazard KM 100 100 R Danger gt Always heed safety precautions for handling batteries gt Charge the battery with an appropriate charger recommended by K rcher manufacture no 6 654 107 gt Strictly comply with
Download Pdf Manuals
Related Search