Hunter Fan 30735 Air Cleaner User Manual
Contents
1. note the directional arrows printed on the top of the filter The new filter will be installed with the same orientation Refer to Fig 12 Once removed the used filter can be discarded 4 Remove the new filter from its wrapping and look at the directional arrows printed on the side of the filter Install the filter with arrows pointing towards the unit Refer to Fig 12 Press the filter firmly into the air purifier To avoid damaging the filter media you should press on the frame of the filter only FILTER Fig 12 5 Place the front grill back onto the unit First line up the tab on the bottom of the grill with the recess on the purifier base and then push the top of the grill forward until it is closed Refer to Figs 6 and 7 pg 7 NOTE This unit will not operate unless the grill is in the correct position 6 Plug in the unit 7 To reset the filter counter press the FILTER RESET key for 2 seconds The Filter Counter will return to 100 and the Filter indicator will stop flashing 41791 01 12 Air Purifier Maintenance i Obtaining Replacement Filters To obtain replacement filters for your air purifier first determine your model number by looking at the information label on the back of the air purifier The model number will be listed on the label Then call 1 800 4HUNTER for your nearest retailer or Hunter Customer Service at 1 800 313 3326 CAN 1 888 855 8300 to order directly To or der online visi2. FILTER LIFE FILTER INDICATOR COUNTER OFF SPEED RESET KEY KEY IONIZER KEY TURBO KEY CARBON PRE FILTER BLOWER IONIZER ANIMATED CLEANABLE INDICATOR SPEED INDICATOR BLOWER FILTER INDICATOR Fig 3 Air Purifier Control Area and Alpha numeric Display 5 41791 01 VA Operation Initial Operation This section provides basic instructions on the use of your air purifier After following these initial directions please continue reading this booklet to learn how to operate the more advanced features of your air purifier Basic Operation of the Air Purifier 1 Take the air purifier out of the box and remove the clear plastic protective bag Place the unit on a firm level floor 2 Before turning on the air purifier you need to confirm that the filters are firmly in place and have not become loose during shipping To check the filters first open the front grill Release the front grill by placing your fingers under the handle on the grill and pull forward then up Refer to Figs 4 and 5 HANDLE PULL FORWARD THEN UP Fig 4 Fig 5 3 Next check the HEPA filter by pressing firmly on all four corners of the filter to ensure that it is fully inserted into the filter opening 4 The carbon pre filter is mounted inside the front grill with hook tape Confirm that it properly covers the grill vents You may notice a few black particles com ing off the pre filter Those particles are part of the odor removing act
3. in the correct position 7 Plug in the air purifier 8 Finally reset the Pre Filter Counter by pressing the PRE FILTER RESET key for 2 seconds The Pre Filter Counter will return to 100 and the Pre Filter indicator will stop flashing Changing the Filter When the filter exceeds 8000 hours approximately 1 year of use the Filter Life Counter will display 0 life remaining and the Filter indicator will flash refer to Filter Life Counters for additional information pg 8 This is a reminder that you should check the filter and replace if necessary The proper time to change the filter depends on usage and the environ ment Use the following list to help determine if the filter should be changed e Compare the color of the filter to the color coded chart on the inside of the housing If the filter color matches the darkest color on the chart you should replace the filter e If you notice a decrease in air output or an increase in noise at any time during normal operation the filter may be clogged Replace the filter to return to normal operation To change the filter and reset the Filter Life Counter 1 First turn off and unplug the air purifier 2 Next remove the front grill Place your fingers under the handle on the grill and pull forward then up Refer to Figs 4 and 5 pg 6 Continued 11 41791 01 Air Purifier Maintenance 3 Gently pull on the filter to remove it from the unit While removing the filter
4. pre filter and reset the Pre Filter Life Counter 1 First turn off and unplug the air purifier 2 Next remove the front grill Place your fingers under the handle on the grill and pull forward then up Refer to Figs 4 and 5 pg 6 3 The pre filter is attached to the inside of the grill with hook tape Pull gently on the pre filter to remove it Refer to Fig 11 4 If needed use a soft damp cloth to wipe off the grill 5 Install the new pre filter by placing it in the grill and pressing gently on the pre filter so that it adheres to the hook tape You may notice a few black particles coming off the pre filter Those particles are part of the odor removing activated carbon and will be collected on the filter during regular use 41791 01 10 Air Purifier Maintenance A A o PRE FILTER ze 44a 4 3 samm a a EEE HOOK A HOOK TAPE TAPE z QE ja S n ma E mw 143 S a A A rh r a bh bh gt ER PF mr b gt HAS urb AS mr mr ur r ur ar a wr al y y EA 14 4 Ad de Pa _ Cal ur r El f A l 7 Pl Sl a 3 A 4 ru aa a Gas Fig 11 6 Place the front grill back onto the unit First line up the tab on the bottom of the grill with the recess on the purifier base and then push the top of the grill forward until it is closed Refer to Figs 6 and 7 pg 7 NOTE This unit will not operate unless the grill is
5. D NO WARRANTY EXPRESSED OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE IN RESPECT TO THE FILTER MATERIAL OR CARBON FILTER THIS WARRANTY IS IN LIEU OF ALL OTHER EXPRESS WARRANTIES THE DU RATION OF ANY IMPLIED WARRANTY INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IN RESPECT TO THE MOTOR IS EXPRESSLY LIMITED TO THE PERIOD OF THE EXPRESS WARRANTY SET FORTH ABOVE This warranty is voided if the air purifier is not purchased and used in the USA or Canada This warranty excludes and does not cover defects malfunctions or failures of the Air Puri fier which were caused by repairs by persons not authorized by us use of parts or accesso ries not authorized by us mishandling modifications or damage to the Air Purifier while in your possession or unreasonable use including failure to provide reasonable and necessary maintenance This warranty does not cover Air Purifiers used in commercial applications There are no express or implied warranties as to commercial purchasers or users To obtain service contact the nearest Hunter authorized service center or the Hunter Fan Company Service Department 2500 Frisco Avenue Memphis Tennessee 38114 1 888 830 1326 For the name of our nearest authorized Hunter Fan Company Service Center 15 41791 01 5 Warranty write to the Hunter Fan Company at the preceding address You will be r
6. QuietFlO Ultra lonizing HEPA Air Purifier Model 30735 amp 30736 Replacement Filter Information Pre Filter HEPA Filter 30901 30960 30901 30960 www hunterfan com 41791 01 08 02 2005 2005 Hunter Fan Company Table of Contents Satety ASUS ooo 3 Introd ction eean AAA 3 Description of Air Filtration System wad N How the A IN 4 Air Pure Components id iia 4 Display and OntroOL KEYS nas 5 Y YY Operation A Mita Operator tr 6 AN A II IS 8 Locking Unlocking the Keypad ococcccccccnnncnnnnnnnononononononnnonnnnnnnnnnnnononnnnnos 8 Rescttins the Adi PUTAS tido 9 Usine the TOMES AA IES 9 Controlling the Back ideas 9 ME Air Purifier Maintenance e Cleaning Your Arr PUTA dices 10 Changing the Prestan 10 Chans meethe A e 11 Obtaining Replacement Filters serna isc 13 Troubleshooting Problem and SOMOS as 14 Un A SUPP Ol A o 14 Warranty Information 00 cccccecceeesseecceseseesessssessssesseessseesseseseseeseeeeseeeeeees 15 Yeats 41791 01 2 SAFETY INSTRUCTIONS IMPORTANT READ ALL INSTRUCTIONS BEFORE USING THIS AIR PURIFIER 1 This air purifier is designed for use on a flat level floor and may not work properly on an uneven floor ALWAYS place the air purifier on a firm level floor ALWAYS place the air purifier at least six 6 inches away from walls and heat sources such as stoves radiators or heaters 2 Place the air purifier in an area that 1s out of the rea
7. ch of children 3 Before using the air purifier extend the cord and inspect for any signs of damage DO NOT 3 41791 01 Description of Air Filtration System How the QuietFlo Ultra lonizing HEPA Air Purifier System Works As the air is pulled into the purifier the activated carbon pre filter absorbs odors and catches large particles Then the air travels through the HEPA filter where the smaller particles are collected Then the ionizer releases negative ions into the air that attract positively charged dust smoke and pollen particles Finally the clean purified air is released back into the room 0 Dust amp Irritants M Potten amp Allergens Odors Bacteria eso Pet Hair amp Dander 9 9 0 0 9 0 0 0 9 9 Carbon HEPA Filter lonizer Pre filter 99 7 7 Microns Fig 1 Illustration of the Air Filtration System Air Purifier Components HEPA FILTER I Fig 2 Air Purifier Components PRE FILTER BASE NT FRONT GRILL 41791 01 4 Description of Air Filtration System Display and Control Keys The display and control keys allow for easy operation of the air purifier 09 OFF SPEED Adjusts the blower speed and turns the unit on and off ES PRE FILTER RESET Resets the Carbon Pre Filter Life Counter FILTER RESET Resets the HEPA Filter Life Counter a IONIZER KEY Turns the ionizer on and off PRE FILTER PRE FILTER KEYPAD CLEANABLE RESET KEY LIFE COUNTER LOCKED
8. esponsible for insurance and freight or other transportation to our factory service center We will return the Air Purifier freight prepaid The Air Purifier should be properly packaged to avoid damage in transit since we will not be responsible for any such damage Proof of purchase is re quired when requesting warranty service The purchaser must present sales receipt or other document that establishes proof of purchase IN NO EVENT SHALL HUNTER FAN COMPANY BE LIABLE FOR DIRECT INDI RECT SPECIAL CONSEQUENTIAL OR INCIDENTAL DAMAGES IN EXCESS OF THE PURCHASE PRICE OF THE AIR PURIFIER YOUR SOLE REMEDY WILL BE REPAIR OR REPLACEMENT AS PROVIDED ABOVE SOME AMERICAN STATES AND CANADIAN PROVINCES DO NOT ALLOW e LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS e THE EXCLUSION OR LIMITATION OF DIRECT INDIRECT SPECIAL INCI DENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATIONS MAY NOT APPLY TO YOU THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE OR PROVINCE TO PROVINCE 41791 01 16 Other Home Comfort Products from Hunter The Care Free Programmable Humidifier Thermostat To learn more about Hunter Fan Company products please see our Web page at www hunterfan com
9. ife left since the counter was reset NOTE The per centage level drops in 5 increments The values of the Pre Filter and Filter Life Counters are stored in the air purifier s memory The unit may be unplugged and moved or stored without losing the Pre Filter and Filter Counter values To properly track filter usage the Pre Filter and Filter Life Counters should be reset each time the filters are changed Refer to Changing the Pre Filter pg 10 or Changing the Filter pg 11 for instructions on how to reset the counters Locking Unlocking the Keypad Once you enter the desired speed you may want to lock the keypad to prevent accidental changing of the speed When the keypad is locked all keys will be disabled If you press a key the Keypad Locked Indicator will be displayed on the screen for 1 2 seconds To Lock or Unlock the Keypad 1 To lock the keypad press and hold the OFF SPEED and TURBO keys simultaneously for 2 3 seconds The Key pad Locked Indicator will appear on the display Refer to NANANA Fig 9 After releasing the keys the Keypad Locked Indi cator will disappear 2 To unlock the key pad press and hold the OFF SPPED Fig 9 and TURBO keys simultaneously for 2 3 seconds The Keypad Indicator will disappear and the keypad will be functional 41791 01 8 Operation VA Resetting the Air Purifier In the unusual situation that the unit or the display is exhibiting erratic behavior you may want to reset
10. ivated car bon and will be collected on the filter during use 41791 01 6 Operation VA 5 Place the front grill back onto the unit First line up the tab on the bottom of the grill with the recess on the purifier base and then push the top of the grill forward until it is closed Refer to Figs 6 and 7 NOTE This unit will not operate unless the grill is in the correct position LINE UP TAB WITH RECESS IN BASE Fig 6 Fig 7 3 6 Plug the unit into a 120V electrical outlet and press the OFF SPEED key The air purifier will start with a low blower speed 7 Use the OFF SPEED and TURBO keys to adjust the blower speed to the desired level Off Sleep Active Turbo Clean Refer to Fig 8 7 8 Use the TURBO key to adjust the blower speed to high After 11 2 hours the fan A will return to the previous speed setting 7 41791 01 Va Operation Filter Life Counters The pre filter and filter are critical to the proper operation of the air purifier To help you know when to change the filters your Hunter Air Purifier has Filter Life Counters that will monitor the percentage of life your filter has left Although the exact life of the filters de pends on the environment the table below gives typical usage times of the filters Table 2 Typical Usage Times of the Filters Filter Type Typical Usage Activated Carbon Pre Filter 2000 hours HEPA Filter 8000 hours The display shows the percentage of l
11. questions or problems with your Hunter air purifier please call 1 888 830 1326 from 8 00 am to 5 00 pm Central Time or contact us over the Internet at www hunterfan com 41791 01 14 Warranty 5 Hunter Fan Company QuietFlo Ultra lonizing HEPA Air Purifier 5 YEAR LIMITED WARRANTY The Hunter Fan Company makes the following limited warranty to the original residential user or consumer purchaser of the QuietFlo Ultra Ionizing HEPA Air Purifier If any part of your QuietFlo Ultra Ionizing HEPA Air Purifier motor or control panel fails during the first five 5 years from the date of installation due to a defect in material or workmanship we will provide a replacement Air Purifier free of charge Installation is deemed to occur at the date of purchase If the Air Purifier cord or front grill fails any time within one 1 year after installation due to a defect in material or workmanship we will replace or at our option repair the unit free of charge at our nearest service center or at our Service Department in Memphis Tennessee You will be responsible for all parts and labor costs after this one year period USE OF A NON HUNTER FILTER WILL INVALIDATE THIS WARRANTY IF THE ORIGINAL RESIDENTIAL USER OR CONSUMER PURCHASER CEASES TO OWN THE AIR PURIFIER THIS WARRANTY AND ANY IMPLIED WARRANTY WHICH THEN REMAINS IN EFFECT INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ARE VOIDE
12. r Maintenance Cleaning Your Air Purifier Proper maintenance of your Hunter Air Purifier will help ensure years of trouble free service Follow these steps to properly maintain your air purifier 1 Approximately every 90 days the outside of the unit should be cleaned with a soft damp cloth 2 If needed the front grill can be removed from the unit and cleaned with soapy water Simply remove the pre filter before exposing the grill to water 3 Follow the instructions in Changing the Pre Filter and Changing the Filter pgs 10 and 11 to determine when and how to replace the filters NOTES e The air purifier must be unplugged during the cleaning process e Be sure the unit is completely dry before plugging in and using e Never immerse unit in water Changing the Pre Filter When the Pre Filter exceeds 2000 hours refer to Filter Life Counters for additional infor mation pg 8 the Pre Filter Life Counter will display 0 life remaining and the Pre Filter indicator will flash as a reminder that you should replace the pre filter To maintain proper odor removing capability and overall filtration performance the pre filter should be changed every 2000 hours approximately 3 months of use If necessary the pre filter can be changed more often Proper maintenance of the pre filter will help extend the life of the HEPA filter Refer to Obtaining Replacement Filters pg 13 if you need help finding replacement filters To change the
13. t our Website at www hunterfan com To ensure that you obtain the cor rect filters please find your model number below that specifies the correct replacement filters Hunter Air Purifier Model No c occccccccnnnnnnnnnnoo 30735 30736 Pre Filter Replacement Model No 30901 30901 HEPA Filter Replacement Model No 30960 30960 13 41791 01 Troubleshooting Problem Solutions 1 No display or operation e Confirm that the unit is plugged in e Check the installation of the front grill e Reset the air purifier See Resetting the Air Purifier on pg 9 2 Keypad does not work Key pad has been locked to prevent accidental changes to the programs See Keypad Lock on pg 8 to unlock the key pad 3 Erratic Display or Reset the air purifier See Resetting the Air Purifier Operation on pg 9 4 Filter and or Pre filter The Filter and or Pre Filter Life Counters have reached the Indicator is Flashing estimated usage times Check and replace filters if needed Refer to Filter and Pre Filter Counters on pg 8 5 HEPA Filter and or Carbon e The Filter and or Pre Filter Life Counters have greatly Pre Filter Life Counter is exceeded the estimated usage times Replace the flashing 0 corresponding filters 6 Unit has reduced air flow e The filter is clogged and should be changed Refer to or increased noise Changing the Filter on pg 11 Technical Support If you have any additional
14. the air purifier If you still have problems after resetting the air purifier please contact Hunter for additional assistance refer to Technical Assistance pg 14 To Reset the Air Purifier 1 Unplug the unit for at least 30 seconds 2 Plug the unit back in Using the lonizer Using the ionizer improves the quality of air in the room Negative ions are released into the air and positively charged dust smoke and pollen particles are attracted to the negative ions These particles settle out of the air and can be vacuumed up during normal cleaning These particles are also more easily captured by the HEPA filter as they pass through the HEPA Air Purification System To ensure the best air circulation in the room we recom mend that you place your air purifier six 6 inches away from any walls To turn the ionizer on or off 1 To turn the ionizer on press the IONIZER key The Ion 7 izer Indicator will appear on the display Refer to Fig 10 2 To turn the ionizer off press the IONIZER key The Ion izer Indicator will disappear Controlling the Backlight Your air purifier display has a backlight that is continuously lit as long as there is power to the unit The backlight may be turned off To turn the backlight off or on g Press the PRE FILTER RESET and FILTER RESET keys at the same time 9 NOTE Do not hold down the keys for longer than 2 seconds This may reset a filter counter and 9 41791 01 A Air Purifie
Download Pdf Manuals
Related Search