Haier GDZ3.5-61 Clothes Dryer User Manual
Contents
1. Problem Possible Cause What to do Timer knob does not els the powercord inserted e Insert the powercord firmly turn firmly Drum does not turn e Is the door closed e Close the door e Is the power cord inserted e Insert the power cord firmly e Does the receptacle have e Check the power cord power receptacle No hot air blown out Is the timer incorrectly Set to hot air set up in cold air The laundry is not Is the back filter Clean the filter throughly dried some clogged of the clothes still wet Have the clothes Dehydrate the laundry after dryer stops been fully dehydrated completely e Is the laundry too much e Reduce the laundry quantity Have the dryer have been Dry the undried laundry again added during operation Does the laundry twist Loose the twisted laundry and dry again Have any clothes dry easily and Dry the undried laundry again hardly been dried together e Is the dryer placed in a small Place the dryer in a well vented and badly vented space place Dryer does not start e Is power failure e Try again after power recovered e Is the power cord inserted firmly Insert the power cord firmly Is the door closed e Close the door e Is the timer in OFF position e Set dry time 14 Specification Rated Voltage Frequency 220 240V 50Hz Model Rated Input Power Extra 1020W Light 670W GDZ3 5 61 Extra 1070W Light 700W2. Wall hanging brackets 2 i d L Hanging hook 1 l fi rt rt i ied 1 Plastic Spacers 2 o rt ri Exhaust pipe 4 pieces i Ensure brackets are 1 securely fastened Fit Timber slats if necessary Wall Mounting Instructions 3 4 5 6 7 To install the hanging hook to the dryer remove screws 1 2 3 amp 4 as indicated in Fig 2 Align bracket as shown in Fig 3 and fasten screws tightly Remove lower side screws and install the spacers provided as per Fig 2 Install exhaust pipe for upwards discharge join sections 1 and 3 for downwards discharge join sections 1 2 2 amp 3 as per Fig 4 With assistance mount dryer on wall bracket See Fig 5 Fig 2 Fig 3 Fig 4 Fig 5 Using Method 1 Plug the power cord e The appliance shall be supplied with220 240V 50Hz connected to a special receptacle more than 10A reliably grounded 2 Place the dehydrated clothes in your dryer e Check the following items before putting clothes in They shall be loaded in such a way that 2 3 pieces each time and not in a group to avoid tangling which is not easy to turn it over resulting in uneven drying since the clothes were wrapped Please put clothes into the drum Avoid clothes being pressed by the door due
3. A clean filter ensures sufficient drying A layer of lint on the filter reduces airflow through the clothes and prolongs drying time Refer to the instructions on page 13 11 Dry Capacity Dry Time Reference Table Dry Capacity Approx 1kg Approx 2kg Approx 3 5kg Approx 5 0kg Strong Approx 50min Approx 90min Approx 160min Approx 200min Approx 90min Approx 150min Suggest use strong Suggest use strong GDZ3 5 61 GDZ5 0 61 GDZ5 0 61 Dry time affected by many factors such as material weight thickness and the hydrated ratio of clothes the above listed dry time is only for reference 12 Care And Cleaning Clean the buildup such as lints on filters in time after each use otherwise it will affect the performance of your dryer Please unplug the power cord first when cleaning it Cleaning of filters The lint filter must be used for drying The filter fixed in the it must be cleaned in time befor and after each use bottom of the drum 1 Remove the filters Remove by pulling straight up with hands inserted into the four holes around the exhaust vent shroud in the sequence of Exhaust vent shroud Lint filter Exhaust filter as shown in figure 1 i Exhaust Lint Exhaust 2 Clean the lints vent shroud filter Filter Separate exhaust vent shroud lint filter and exhaust filter and clean the lints on the filter and exhaust filter with a soft brush or vacuum cleaner
4. GDZ5 0 61 Rated Fuse Current 10A Rated Max Capacity 3 5kg GDZ3 5 61 5 0kg GDZ5 0 61 Overall Dimension 630mm x 425mm xX 685mm GDZ3 5 61 630mm x 515mm xX 685mm GDZ5 0 61 Net Weight 23kg GDZ3 5 61 26 5kg GDZ5 0 61
5. Do not damage the filters as shown in figure 2 3 Install the filters Lint Filter Lints Exhaust Filter Dust Cleaner After cleaning assemble in the sequence of exhaust filter Figure 2 filter exhaust vent shroud align the recesses in the center of filter with the projection in the center of drum and make sure that it is firmly inserted as shown in figure 3 N Note The filter fixed in the bottom of the drum shall also fon gt be cleaned with a soft brush N DO NOT USE YOUR DRYER WITHOUT THE LINT FILTER Figures Clean the interior drum or dryer housing with wet soft cloth if stained Do not wash directly with water Do not use thinner gasolene or alcohol Do not use any type of spray cleaner when cleaning the interior Hazardous fumes or electric shock could occur If dryer drum becomes stained clean the drum with a damp cloth Remove any residue before drying the next load Clean cabinet with mild soap and water Donot use harsh or abrasive cleaners this could damage the dryer e Do not let any kind of liquid get into the air intake or on the control panel 13 Trouble Shooting If your dryer exhibits problems please unplug the power cord before checking The following maybe unrelated to a malfunction of the dryer itself please reconfirm before calling a serviceman If it does relate to a malfunction please contact our service agent or after sales service and do not repair it by yourself
6. of the flammable liquids and its fumes have been removed 21 This dryer shall be connected to a three wire single phase 220 240V AC power receptacle more than 10A which must be reliably grounded A leakage protector shall be used if possible 22 Do not share a receptacle with other appliances Do not use it when a plug loosely inserted into a receptacle 23 Do not excessively bend stretch twist bind power cord or put heavy stuff on it Keep the terminator of power cord clean Carefully clean it with dry cloth if dusts accumulated If damaged power cord or plug must be replaced by our service agent or qualified after sale service person to avoid the risk of danger Important Safety Instructions 24 When normally using the power cord of dryer shall be easily plugged or unplugged by hand It must be unplugged during power blackout moving not in use or cleaning Do not plug or unplug the power cord with wet hands 25 Always disconnect dryer from electrical supply before attempting any service Disconnect power cord by grasping the plug not the cord 26 Do not block the exhaust vent when dryer operating to prevent it from overheating or other dangers 27 Do not let your dryer operate on packing foam Otherwise it maybe cause fire since heat accumulation or other external factors 28 Only place sufficiently dehydrated clothes into your dryer for drying to prevent leakage and longer drying time 29 Do not place washed wet clothe
7. to exposure out of the port which will cause clothes entangle and door gasket release and consequently poor drying effect e Make sure if clothes have any special requirements and suitable for drying Do not dry your clothes in your dryer if the materials of which cannot be dried in a dryer or they bear the following labels Ky WY Eh lL Do not tumble dry Hang to dry Drip dry Dry flat Dry In the shade Carefully check the clothes to be dried and remove int tong material such as lighter and match as well as sharp metal item like coin hair clip and safety pin maybe mixed with the clothes So and in pockets e Clothes with zipper or fastener shall be put into your dryer inside out with zipper zipped and fastener buckled Separate dark and light colored items like you do for washing Check for stains that may not have been removed in washing Dryer heat may permanently set some stains Properly dried clothes will need minimum of care when removed from dryer e For optimum results use dryer load of similar fabric weight and construction Placesmall items in a mesh bag prevent from tangling Do not overload the dryer An average load will fill up half the drum Using Method 3 Control panel and its functions Heat Selector Knob Select drying level according to the material quantity and drying requirements of the clothes to be dried as shown in the figure Select strong Dr
8. Exhaust Type Tumble Dryer User s Manual GDZ3 5 61 GDZ5 0 61 e Please read this manual carefully before using e Retain it for future reference Important Safety Instructions Warning To reduce the risk of fire electric shock or injury to persons when using your appliance follow basic precautions including the following 1 Read all instructions before using the appliance 2 The tumble dryer is not to be used if chemicals have been used for cleaning 3 The tumble dryer is intended only for drying textile material washed in water 4 There has to be adequate ventilation to avoid the back flow of gases into the room from appliances burning other fuels including open fires when operating the tumble dryer 5 The lint trap is to be cleaned frequently 6 Lint is not to be allowed to accumulate around the tumble dryer 7 For appliances with ventilation openings in the base that a carpet must not obstruct the openings 8 Exhaust air must not be discharged into a flue which is used for exhausting fumes from appliances burning gas or other fuels 9 Do not dry articles that have been previously cleaned in washed in socked in or spotted with gasoline dry cleaning solvents or other flammable or explosive substances as they give off vapors that could ignite or explode 10 Do not place items exposed to cooking oils in your dryer Items contaminated with cooking oils may contribute to a chemical reaction that could cause a load t
9. avoided to prevent the clothes overdried or incompletely Please flip clothes over manually from time to time if necessary when drying large ones Itis not easy to flip over large clothes such as overcoat in the drum uneven drying therefore happens sometimes If necessary flip them over manually from time to time to make them dried completely gt Flip over clothes Anti wrinkle method for clothes crumpled easily Decrease capacity to get good anti wrinkle result the capacity shall be 4 5 of that of normal clothes 5 Capacity reduced Remove the clothes out of your dryer as early as possible to reduce rumples ee Please hang the easily crumpled clothes up with a hanger after dried Installation Instructions For your safety and correct using your dryer please observe all the instructions in this manual toinstall and adjust your dryer Location of your dryer e Dryer should be located in a dry and well vented place not filled with moisture and vapors and where rain cannot reach like bathroom open balcony and water faucet Do not locate your dryer in a place where sunlight directly shines Do not use stove gas etc near your dryer to avoid dangers ZA a A e Locate your dryer on horizontal solid ground floor or a Z special bracket to prevent vibration and noise Keep a dista EB nce of 10cm 15cm away from the rear wall when installing EB A e The dryer has air inta
10. ke and exhaust cycles which 40 15cm a needs good air exhaust vent in the rear and well vented A room If used in a small space air exchange fan or a exhaust duct can be installed at the vent to exhaust hot wet air outdoors The length of exhaust duct shall not exceed 2m Install and use the fixed legs of your dryer e If the dryer is not used with bracket take fixed legs out of the accessory bag and screw them into the assembly hole of the dryer to ensure it be placed stable Soft items Wall Mounting Instructions 1 Determine dryer position on wall and mark 2 Fix the wall hanging brackets to the wall securely required bracket position eg into the stud If the studs are too far apart fit a timber slat to the studs then mount the brackets onto the slat The distance between each bracket is 155mm as per diagram A minimum 50mm is needed between the top of the dryer and the ceiling for ease of installation If mounting above a washing machine allow sufficient room to open the lid of the washer 155mm 7 7 1 4 Drill amp 3mm Bit For Plaster Philips Head Screw 1 wooden wall Driver Wood Screws 12g x 50mm Timber Screws Fig 1 Ceiling f ro 155mm im iu N a 1 4 1 1 om 1 25x75mm _ Si Si Timber 13 9 i0 1 0 3 Description
11. knob to select Strong dry or Soft dry level Strong dry level for large quantity and low room temperature a Soft Soft dry for non heat resistant clothes Strong Heat selector knob 5 Dry time settings Select dry program according to clothes materials and quantity turn the timer knob to relative position The Do not point the dryer starts running cursor to blank Please refer to page 10 Canthall pamal amd itts f unottoorss eee 60 0 and page 12 Dry Capacity Dry Time Reference Table Air drying e TA 3 Caution Dry timing knob cursor 5 shouldn t be set at the blank area as indicated in the right figure Do not point the cursor to 6 Do not take the laundry out until drying process is done The last 20 minutes of hot air drying is cooling to reduce the temperature of laundry inside the drum To take the laundry out during drying please run cooling operation first since the temperature inside the drum must be high Static electricity due to friction will be generated on clothes made of chemical fibre after dried You can feel it when taking them out which is normal and shall not to be worried about 7 Unplug the power cord 0 e Please hold plug to unplug power cord from a receptacle Do not pull electrical wire directly to prevent internal breakage or bad connection 8 Clean filters e Clean the lint filter after every load and before each use
12. o catch fire 11 Fabric softeners or similar products should not be used in a tumble dryer to eliminate the effects of static electricity unless this practice is specifically recommended by the manufacturer of the fabric softener or product 12 Do not use heat to dry articles containing foam rubber or similarly textured rubber like materials Important Safety Instructions 13 Do not allow children to play on climb on or in the appliance Close supervision of children is necessary when the appliance is used near children 14 Before the appliance is removed from service or discarded remove the door to the drying compartment 15 Keep your dryer away from combustible materials such as gasoline during operation to prevent the risk of fire 16 Do not use or place stove gas device water heater tinder or similarities close to your dryer Do not install or store this appliance where it will be exposed to water and or to the weather 17 Do not tamper with controls 18 Do not repair or replace any part of the appliance or attempt any servicing unless specifically recommended in the user maintenance instructions or in published user repair instructions that you understand and have skills to carry out 19 Keep area around the exhaust opening and adjacent surrounding areas free from the accumulation of lint dust and dirt 20 If material has been used with any flammable liquids or solids it should not be used in the dryer until all traces
13. s in your dryer for a long time not drying them which may result in water leakage 30 Don t touch the intake for the high temperature during the drying cycle 31 Do not exceed dryer rated Max Capacity 32 The appliance must not be installed behind a lockable door a sliding door or a door with a hinge on the opposite side to that of the tumble dryer Names Of The Parts Drum Exhaust Shroud Timer Selector Knob Air Intake Shroud Heat Selector Knob Door Gasket Power Cord Exhaust Vent Casing Back Cover e Please check if the power receptacle has good earthing Condition before using to guarantee your safety The manufacturer will not take responsibility for those Risks occurred from not obeying this manual Operation Cautions Clothes with ribbon or lace should be dried in a nylon net Put chemical fiber and or clothes with ribbon or lace into a nylon net Py before drying Avoid to dry starched clothes in your dryer to prevent link filter from clogging which may lead to bad exhaust performance Clothes with zipper Dry this kind of clothes with zipper zipped or fastener E A Put rumpled clothes in order Put all clothes in order after dehydrated _ before drying them buckled and inside out to reduce the impact noise between metal and the drum Do not load your dryer when it is running Loading the dryer when it is running shall be
14. y for clothes particularly thick and in large HL Soft quantities or in lower room temperature wm Strong Select Soft Dry for clothes not resistant to heat like nylon chemical fibre and silk Heat Selector Knob Drying Timer Knob J Select dry program according to clothes materials and quantity turn the timer knob to relative position Alr dry OFF Cooling For down sweater Power off when the Motor keeps running after dryer time mohair cotton sweater timer knob in heating finished while heater stops and cotton padded OFF position working and cold air into the drum to clothes needing The dryer starts cool laundry The whole cooling will be freshening tumbles when turn the knob finished once the timer knob gets to without heat Also can clockwise OFF position be individually used for clothes long time in closet with the _same results Hot gt For clothes resistant to heat Check the lable on the article ra S z OFF to be dried to make sure it can be safely tumble dried Power off when the the heater is working timer knob in According to clothes materials OFF position and quantity turn the timer The dryer starts knob to relative position when turn the knob Select Strong Dry for clothes clockwise particularly thick and in large quantities Refer to Dry Time Reference Table DA 10 Using Method 4 Set heat selector
Download Pdf Manuals
Related Search