EDGE Tech 20200 Automobile Parts User Manual
Contents
1. 142. aftermarket company that does not acknowledge this is misleading you Although you have strong legal protection as a consumer in regard to your vehicle s warranty the practical reality is that taking legal action against a dealer or manufacturer to fight a voided warranty is a costly and time intensive process For this reason Edge strongly recommends you always disconnect and remove your module programmer and monitor when you take your vehicle to a dealer for warranty work It is also for this reason that Edge focuses the bulk of their product development efforts on producing modules and digital monitors that can be easily removed Even if you remove your unit you should note that dealers can detect the use of ANY programmer Evolution or otherwise even if the unit has been removed This warranty is void for any new products purchased through auction websites Warranty is valid only for new products purchased through Authorized Dealers proof of purchase required for all warranty claims 4 GM LB7 EZ Manual Edge Products LLC All Edge modules and programmers are built to operate with OEM calibrations When you take your vehicle to a service center they may by your request or otherwise update your vehicles calibrations Therefore it is important that you return your vehicle to stock before taking it in for service Edge updates its active products i e those currently being manufactured to work effectively with updated O
3. gains were measured on a Super Flow Dyno at an altitude of 4400 ft above sea level and represent power delivered to the rear wheels of the test truck The only modification made to the test truck was the addition of the Power Edge EZ module Power gains may vary somewhat on a different vehicle or in different geographic settings Horsepower Torque Level1 30 120 Level2 50 150 Level 3 65 180 Warning It is strongly advised that you do not combine or stack chips to gain more horsepower Warning Do not stack the Edge LB7 EZ with the Edge LB7 Juice It can cause severe damage to the engine 10 GM LB7 EZ Manual Edge Products LLC Making Sense of it All This section is designed to help you understand how the additional power will change your driving experience as well as help you figure out what power level will best suit your driving style The first thing you will probably notice is improved performance especially if this is your first time driving a diesel truck with a performance module You will experience more power better throttle response better passing and acceleration and possible better fuel economy Power level one is specifically designed to maximize fuel economy improvements If you are towing the beauty of the extra power the Edge EZ module delivers is that not only will you be able to maintain speed going up a hill but the added power will also keep you in a higher gear so your transmission
4. will not keep hunting for lower gears We recommend level 1 or level 2 for towing applications Only use level two if you are towing a light load Level 3 should never be used while towing Level 3 is a great overall driving level When driven responsibly and used with an EGT gauge level 3 will not stress the stock engine or transmission as long as you are not towing EGTs What they mean and why EGT stands for exhaust gas temperature and is the single most important indicator of how a diesel engine is performing Unlike a gasoline motor a diesel motor will continue to make power as more fuel is added As more fuel is added heat will be generated until the motor just gets too hot and things start to melt This is a situation you want to avoid Exhaust gas temperature is the ideal measurement of how hot the motor is since temperature fluctuations in exhaust gas are almost instantaneous Just so you know it is possible to generate excessive EGT on a stock truck particularly if you are towing This is why we always recommend installing an EGT gauge In our experience 1350 degrees is about as high as you want to let your EGTs go Keep in mind the stress on your engine created by the heat is a function of both temperature and time A brief spike to 1400 that lasts a second is not that big a deal Pulling up a hill for several minutes at 1400 is far worse 11 Edge Products LLC GM LB7 EZ Manual As you drive your truck in the vari
5. EM calibrations However this process can take some time as Edge is not always made aware of calibration changes made by the OEM In the case of discontinued products Edge cannot ensure that your unit will work effectively if you take your vehicle to a dealership and you are given by your request or otherwise a new calibration About the Edge LB7 EZ Thank you for purchasing the Power Edge LB7 EZ Module for the Chevy GMC Duramax Diesel LB7 The EZ module has been developed and produced from the highest quality materials available to ensure the best performance for years to come If you have any questions please contact Edge Products We will be very happy to answer your questions about our complete product line 1 888 360 3343 The EZ Module is an add on Engine Control Module ECM for the Duramax Engine that offers additional features not available with the factory setup Since it is an add on ECM it uses all the factory data and then enhances the factory settings to optimize your truck s performance These features include e Engine temperature monitoring and power increase from the EZ module as engine reaches operating temperature e Three selectable power level settings that can be changed on the fly e Smart power control during torque converter lockup to allow a smooth easy torque converter clutch lock up The EZ module offers a large power increase over stock throughout the rpm range but the power is most n
6. HAS READ AND UNDERSTANDS THIS AGREEMENT AND ACCEPTS ITS TERMS AND CONDITIONS Edge Products LLC GM LB7 EZ Manual IMPORTANT INFORMATION ABOUT YOUR VEHICLE S WARRANTY PLEASE READ Many of our customers ask Will your product void my vehicle s manufacturer s warranty While the answer is straightforward from a legal standpoint it s important to educate our customers and all after market consumers on some industry realities and offer some common sense precautions to minimize your risk Consumers of aftermarket products are protected by the Federal Magnusson Moss Warranty Act The Act states that if something breaks on your vehicle and you take it in for warranty repair the dealer must honor your warranty unless whatever modifications you have added to your vehicle actually caused the problem in question Edge is committed to providing quality products that are safe to use Our products do not cause damage to a vehicle when used as intended Please keep in mind that towing in anything higher than level two and hard driving in levels four and five are not recommended However the reality is that many dealerships have been known to void warranties on vehicles that use aftermarket products as a matter of policy This applies in particular to those aftermarket products that produce horsepower such as performance enhancement chips modified intake manifolds or aftermarket exhaust systems regardless of product brand Any
7. kill or judgment to select or furnish goods suitable for any particular purpose and that there are no liabilities which extend beyond the description on the face hereof and the BUYER hereby waives all remedies or liabilities expressed or implied arising by law or otherwise including without any obligations of the SELLER with respect to fitness merchantability and consequential damages or whether or not occasioned by the SELLER s negligence The SELLER disclaims any warranty and expressly disclaims any liability for personal injury or damages The BUYER acknowledges and agrees that the disclaimer of any liability for personal injury is a material term for this agreement and the BUYER agrees to indemnify the SELLER and to hold the SELLER harmless from any claim related to the item of the equipment purchased Under no circumstances will the SELLER be liable for any damages or expenses by reason of use or sale of any such equipment The SELLER assumes no liability regarding the improper installation or misapplication of its products It is the installer s responsibility to check for proper installation and if in doubt contact the manufacturer LIMITATION OF WARRANTY Edge Products LLC hereafter SELLER gives Limited Warranty as to description quality merchantability fitness for any product s purpose productiveness or any other matter of SELLER s product sold herewith The SELLER shall be in no way responsible for the product s open use and
8. of the cover Connecting The Harness 2 Disconnect both stock connectors by squeezing the i Ta Conn n ears on the backside of the OO e connector and pulling the gray lever 3 Gently insert the EZ connectors and lock in place with the gray levers and then gently connect the stock connectors to the other end of the EZ connectors s f Wil ULL d q SS Notice Use caution when inserting connector bodies If the connector does not slide smoothly remove the connector inspect the pins and retry installation Final Inspection 4 Recheck all connections for a properly secure installation Using the supplied wire ties secure the wiring harness to prevent possible damage 5 Start the engine The engine should start and run like a stock truck If the engine does not start or run properly turn off the motor remove the keys from the ignition then remove the EZ module and inspect the pins inside both connectors Straighten pins or clear foreign material from the pins and connector surfaces then re install the connectors If failure conditions still exist contact your dealer or Edge Products LLC When trying to restart make sure that the key has been turned off for at least 10 seconds before cranking the engine GM LB7 EZ Manual Edge Products LLC Using the Power Edge LB7 EZ Adjusting Power Levels The EZ has three power levels The EZ module was designed to allow the user to select any of the three power le
9. oticeable in the midrange rpm s This greatly improves drivability and towing performance Transmission downshifting is greatly reduced especially while passing or towing The EZ also regulates power delivery based on engine temperature This means that while the engine temperature is below 140 F no additional fueling is delivered At 140 F the module begins delivering fuel at 25 of the calculated additional fuel and the percentage increases as the engine temperature increases until at full engine temperature 174 F the EZ delivers 100 of the calculated additional fuel Edge Products LLC GM LB7 EZ Manual Warning Do not stack the Edge LB7 EZ with the Edge LB7 Juice It can cause severe damage to the engine GM LB7 EZ Manual Edge Products LLC Power Edge LB7 EZ Getting Connected Supplied Items 1 Power Edge EZ Module 2 Three Wire Ties 3 Two Velcro Strips 4 Power Adjustment Switch Required Tools None Please read these instructions completely so that you understand each step prior to installation The Power Edge LB7 EZ Module This picture shows the Power Edge LB7 EZ Module with the harness cable Edge Products LLC GM LB7 EZ Manual Installing the EZ Module 1 The Power Edge LB7 EZ Module can mount on top of or to the side of the black plastic fuse box cover located on the driver s side fender Adhere the module using the supplied Velcro allowing enough harness movement for removal
10. ous power settings keep your eye on the EGTs Depending on how you drive and where you drive you may find a particular power level is more suitable to your power needs The EZ Module and your Transmission The automatic transmission has a fluid filled clutch like device called a torque converter This device uses the spinning motion of the motor to drive the transmission which drives your wheels As the truck speed stabilizes the torque converter engages a mechanical connection which locks the two halves of the torque converter so the output shaft is going the same speed as the input shaft This mechanical linking of the two halves is called Transmission Lock up If the motor produces too much power this mechanical lock up can start to slip When this slippage occurs the EZ module reduces the power output to allow the transmission to function properly This is a great feature that provides an extra level of protection for your vehicle 12 GM LB7 EZ Manual Edge Products LLC Transmission Relearning The Allison transmission is a Smart transmission That means that it pays attention to how smoothly the transmission is changing gears and modifies the shifting to improve drivability When the motor delivers more power by adding the EZ module the transmission has to re learn how to shift After first installing the EZ module you may notice rough shifting The best way to re teach the transmission is to set the
11. service and the BUYER hereby waives all rights other than those expressly written herein This Warranty shall not be extended or varied except by a written instrument signed by SELLER and BUYER The Warranty is Limited to one 1 year from the date of sale and limited solely to the parts contained within the product s kit All products that are in question of Warranty must be returned shipping prepaid to the SELLER and must be accompanied by a dated proof of purchase receipt All Warranty claims are subject to approval by Edge Products LLC Under no circumstances shall the SELLER be liable for any labor charged or travel time incurred in diagnosis for defects removal or reinstallation of this product or any other contingent expenses If the BUYER sends back a failed unit that is out of warranty and chooses to buy a refurbished unit the refurbished unit will only carry a 60 day warranty If the BUYER purchases a new unit at a predetermined discounted rate it will have the standard 1 year warranty Under no circumstances will the SELLER be liable for any damage or expenses insured by reason of the use or sale of any such equipment IN THE EVENT THAT THE BUYER DOES NOT AGREE WITH THIS AGREEMENT THE BUYER MAY PROMPTLY RETURN THIS PRODUCT IN ANEW AND UNUSED CONDITION WITH A DATED PROOF OF PURCHASE TO THE PLACE OF PURCHASE WITHIN SIXTY 60 DAYS FROM DATE OF PURCHASE FOR A FULL REFUND THE INSTALLATION OF THIS PRODUCT INDICATES THAT THE BUYER
12. truck in the power level you will be using most of the time Then set out to drive some city some highway varying the driving and the speed Make sure that you shift through each gear 20 to 30 times A good rule of thumb would be 100 to 200 miles Remember that the truck must go through each gear 20 to 30 times You will notice the shifting becoming better and your truck responding better to the additional power as you go through the learning cycle Technical Support Edge Products takes a great deal of pride in the quality of our customer service If you have any questions or concerns about your EZ module please feel free to call us at 888 360 3343 Please have the Part Number the Version Number and Manufacture Date prior to calling Tech Support This will help ensure quick and accurate support 13 Edge Products LLC GM LB7 EZ Manual Index About the Juice _ _ 6 Juice picture __ 7 Connecting the harness _____ 8 Juice Power Level Confirmation 9 Disclaimer sisi 4 Making Sense ofitall__ sid T Horsepower gains ___ 10 Mounting the Juice _ 8 Juice Adjusting Power Levels__ 9 Torque gains 10 Juice features _ 6 Towing Recommendations__ __ 9 Juice final inspection _ 8 Using the Juice ___ _ 9 Juice getting connected _ ss 7 2007 Edge Products All rights reserved Edge Products 1080 South Depot Dr Ogden UT 84404 888 360 3343 www edgeproducts com Manual Version 4
13. vels on the fly with the supplied three position switch Level 3 is with the switch towards the tab Power Level Confirmation To confirm the power level that you have selected with your switch you can do the following procedure 1 Place gear selector in Park with your foot off of the accelerator while engine is idling 2 Set the Parking Brake 3 Place gear selector to reverse neutral reverse then back to park P R N R P 4 The engine will rev to coincide with the power level selected revving 3 times for level 3 and so on Towing It is recommended that you use the Tow Haul transmission mode while towing This provides torque converter lockup in gears 2 5 which reduces transmission heat and also raises the shift rpm threshold to keep the rpm s higher It is recommended that you maintain engine rpm above 1800 while towing While towing the EZ module allows the engine to pull many grades in the mid rpm s rather than having to downshift and pull them in the high rpm s This provides for lower EGT Exhaust Gas Temperature with the same power output EGT rises significantly with rpm especially above 2500 It is highly recommended that you install an EGT gauge while using the Power Edge EZ It is recommended while towing you use power levels 1 or 2 due to EGT and transmission stress Edge Products LLC GM LB7 EZ Manual Power Gains The following power gains are representative of an actual test vehicle These
14. y 2001 2004 GM Duramax 6 6L LB7 Power Edge LB7 EZ Installation Instructions and Manual OLD P N EZC1000 NEW P N 20200 Z gt 2a a Fs PROD Edge Products LLC GM LB7 EZ Manual Table of Contents DISCLAIMER OF LIABILITY 3 LIMITATION OF WARRANTY 3 About the Edge LB7 EZ 5 Power Edge LB7 EZ Getting Connected 7 Using the Power Edge LB7 EZ 9 Power Gains 10 Making Sense of it All 11 Transmission Relearning 13 Technical Support 13 Index 14 2007 Edge Products All rights reserved Edge Products 1080 South Depot Dr Ogden UT 84404 888 360 3343 www edgeproducts com Manual Version 5 GM LB7 EZ Manual Edge Products LLC The EZ Module is a high performance product It is strongly recommended that EGT and boost gauges be installed when using this product USE THIS PRODUCT AT YOUR OWN RISK Do not use this product until you have carefully read the following agreement This sets forth the terms and conditions for the use of this product The installation of this product indicates that the BUYER has read and understands this agreement and accepts its terms and conditions DISCLAIMER OF LIABILITY Edge Products LLC and its successors distributors jobbers and dealers hereafter SELLER shall in no way be responsible for the product s proper use and service THE BUYER HEREBY WAIVES ALL LIABILITY CLAIMS The BUYER acknowledges that he she is not relying on the SELLER s s
Download Pdf Manuals
Related Search