Desa 200 Electric Heater User Manual
Contents
1. THEORY OF OPERATION The Fuel System The hose regulator assembly attaches to the propane gas supply This provides fuel to the heater The Ignition System The piezo ignitor lights the burner fuel supply The Automatic Control System The automatic control valve shuts off the heater if the flame goes out PROPANE SUPPLY You must provide propane gas and tank s Use this heater only with a propane vapor withdrawal supply system See Chapter 5 of the Standard for Storage and Handling of Liquefied Petroleum Gas ANSI NFPA 58 and or CAN CGA B149 2 Your local library or fire department will have this booklet The amount of propane gas ready for use from propane tanks varies Two factors decide this amount 1 The amount of liquid propane gas in tank s 2 The temperature of tank s The chart below shows the minimum number of 100 pound tanks needed to run the heater Connect tanks together with a manifold Do not operate this product with any tank smaller than 100 pounds Average Temp F Number Of At Tank Location Tanks 60 40 32 20 10 0 Less gas is vaporized at lower temperatures Two or more 100 pound tanks or one larger tank may be needed in colder weather Your local propane gas dealer will help you select the proper supply system WN VENTILATION INSTALLATION OPERATION To Start Heater VENTILATION A WARNING Provide at least a 6 square foot open ing of fr2. If heater does not ignite release control knob and wait 3 min utes before attempting reignition Note Keep hands and face away from outlet around top of shell of heater while attempting to start heater For more information visit wwwides t Om 103386 01G OPERATION To Start Heater Cont To Stop Heater To Restart Heater STORAGE MAINTENANCE OPERATION Continued 6 After ignition hold control knob down for about 30 seconds This activates the automatic control system 7 When burner remains lit set heater at the desired heat level by turning the control valve counterclockwise If burner goes out turn off gas Turn control knob fully clockwise to the lowest position Check fuel supply If adequate fuel is available re start heater beginning at step 1 A CAUTION Do not operate heater at extremely low input gas pressures 100 yellow flame This may cause sooting inside heater Control Knob AT pusy LO TO START Figure 4 Control Knob and Piezo Ignitor Button Locations TO STOP HEATER 1 Tightly close propane supply valve on propane tank s Allow heater to burn remaining fuel in hose 2 Shut off main burner valve Do this by turning control knob fully clockwise Make sure you turn the knob until it stops TO RESTART HEATER 1 Wait five minutes after stopping heater 2 Restart heater by following steps under To Start Heater page 4 For more information visi 10
3. up for vapor withdrawal Provide adequate ventilation Before using heater provide at least six Square foot opening of fresh outside air This heater pro duces carbon monoxide which is listed by the State of Califor nia as a reproductive toxin under Proposition 65 For indoor use only Do not use heater outdoors Keep heater away from strong drafts wind water spray rain or dripping water Do not use heater in occupied dwellings or in living or sleeping quarters Do not use heater in a basement or below ground level Propane gas is heavier than air If a leak occurs propane gas may sink to the lowest possible level Keep appliance area clear and free from combustible materials gaso line paint thinner and other flammable vapors and liquids Dust is combustible Do not use heater in areas with high dust content Minimum heater clearances from combustibles Sides 3 feet Top 7 feet Keep heater at least six feet from propane tank s Keep propane tank s below 100 F Check heater for damage before each use Do not use a dam aged heater Use only the hose and factory preset regulator provided with the heater Check hose before each use of heater If highly worn or cut replace with hose specified by manufacturer before using heater Do not alter heater Keep heater in its original state Do not use heater if altered Locate heater on stable and level surface if heater is hot or operating Not intended f
4. you specific legal rights and you may also have other rights which vary from state to state This warranty does not cover discoloration due to operation of heater We reserve the right to amend these specifications at any time without notice The only warranty applicable is our standard written warranty We make no other warranty expressed or implied WARRANTY SERVICE Should your heater require service return it to your nearest authorized service center Proof of purchase must be presented with the heater The heater will be inspected A defect may be caused by faulty materials or workmanship If so DESA International will repair or replace the heater without charge REPAIR SERVICE Return your heater to your nearest authorized service center Repairs not covered by the warranty will be billed at standard prices Each Service Center is independently owned and operated We reserve the right to amend these specifications at any time without notice For information write DESA International P O Box 90004 Bowling Green Kentucky 42102 9004 ATTN Customer Service Department When writing always include model number and serial number DESA INTERNATIONAL Serial No 2701 Industrial Drive P O Box 90004 Bowling Green KY 42102 9004 Date of Purchase 103386 01 Rev G For more information visit www de tech Gom
5. 3386 01G STORAGE A CAUTION Disconnect heater from propane sup ply tank s 1 Store propane tank s in safe manner Refer to Chapter 5 of Standard for Storage and Handling of Liquefied Petroleum Gases ANSI NFPA 58 and or CAN CGA B149 2 Follow all local codes Always store propane tanks outdoors 2 Place plastic cover caps over brass fittings on valve inlet and hose regulator assembly 3 Store in a dry clean and safe place MAINTENANCE A WARNING Never attempt to service heater while it is connected to propane supply operating or hot Severe burns can occur 1 Keep heater clean 2 Inspect heater before each use Check connections for leaks Apply mixture of liquid soap and water to connections Bubbles forming show a leak that must be corrected Correct all leaks at once 3 Inspect hose regulator assembly before each use If hose is highly worn or cut replace with hose specified by manufacturer 4 Have heater inspected yearly by a qualified service person SPECIFICATIONS REPLACEMENT PARTS ACCESSORIES SPECIFICATIONS Rating BTU Hr High 200 000 Medium 150 000 Low 100 000 Fuel Propane Vapor Only Fuel Consumption Gallons Hour 1 09 min 2 19 max Pounds Hour 4 64 min 9 28 max Supply Pressure To Regulator Maximum 200 psi Minimum 20 psi for input adjustment Manifold Pressure High 4 6 ps
6. ARTS LIST 8 VENTILATION see eek egen 4 OWNER S REGISTRATION 9 ata dies AG 4 WARRANTY INFORMATION Back Cover STORAGE gnu 5 Save this manual for future reference DESA SAFETY INFORMATION SAFETY INFORMATION WARNINGS A WARNING This product contains and or generates chemicals known to the State of California to cause cancer or birth defects or other reproductive harm A WARNING FIRE BURN INHALATION AND EX PLOSION HAZARD KEEP SOLID COMBUSTIBLES SUCH AS BUILDING MATERIALS PAPER OR CARD BOARD A SAFE DISTANCE AWAY FROM THE HEATER AS RECOMMENDED BY THE INSTRUC TIONS NEVER USE THE HEATER IN SPACES WHICH DO OR MAY CONTAIN VOLATILE OR AIRBORNE COMBUSTIBLES OR PRODUCTS SUCH AS GASO LINE SOLVENTS PAINT THINNER DUST PARTICLES OR UNKNOWN CHEMICALS WARNING NOT FOR HOME OR RECREATIONAL VEHICLE USE The heater is designed for use as a construction heater in accordance with ANSI Z83 7 CGA 2 14 Other standards govern the use of fuel gases and heating products for specific uses Your local authority can advise you about these The primary purpose of construction heaters is to provide temporary heating of buildings under construction alteration or repair Properly used the heater provides safe economical heating Products of combustion are vented into t
7. CBESA convection HEATER INTERNATIONAL OWNER S MANUAL Variable 100 000 150 000 and 200 000 Btu Hr Models IMPORTANT Read and understand this manual before assembling starting or servicing heater Improper use of heater can cause serious injury Keep this manual for future reference A GENERAL HAZARD WARNING FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER CAN RESULT IN DEATH SERIOUS BODILY INJURY AND PROPERTY LOSS OR DAMAGE FROM HAZARDS OF FIRE EXPLOSION BURN ASPHYXIATION CARBON MONOXIDE POISONING AND OR ELECTRICAL SHOCK ONLY PERSONS WHO CAN UNDERSTAND AND FOLLOW THE INSTRUCTIONS SHOULD USE OR SERVICE THIS HEATER IF YOU NEED ASSISTANCE OR HEATER INFORMATION SUCH AS AN INSTRUCTIONS MANUAL LABELS ETC CONTACT THE MANUFACTURER TABLE OF CONTENTS SAFETY INFORMATION erenvnnnvnnnvnr venn venvennrennrnnvennrervennrenneenvennnn 2 IMAINTENANGE 5 PRODUCT IDENTIFICATION emrnnnrennvnnvnnnvvrvonnvennrrvvennrervennrervennr 3 SPECIFICATIONS Lun jam teie 6 UNPACKING dusin ai 3 REPLACEMENT PARTS 6 THEORY sACCESSORIES iii dies 6 PROPANE SUPPLY sirener ene 3 TROUBLESHOOTING 7 INSTALLATION sn ee ie mesk ee 4 ILLUSTRATED PARTS BREAKDOWN AND P
8. N 098853 07 098851 06 098831 05 101284 02 Not a field replaceable part For more information visit www de Tradename Decal TC200V Tradename Decal RCP200V Information Decal Operation Decal 103386 01G OWNER S REGISTRATION FORM Complete registration form and mail or complete on line registration at www desatech com within 30 days after purchase Brand Reddy Heater Master Remington etc Model R60 HD15 etc Date Purchased Note Keep receipt for warranty verification Serial Number 2 7 or 9 digit number located on product or identification tag First Name Last Name Address City State Zip Country Phone E Mail Please answer the following questions to register your product with DESA International 1 L 10 11 12 13 14 15 16 17 18 19 Who will heater be used by Individual Business Will you use your heater more than one location Yes No Where will the product be used You may select more than one O Workshop O Barn O Residential Construction Commercial Construction Garage Factory Recreation Warehouse Utility Shed Outbuilding O Other Specify Cost of product excluding sales tax Maintenance service work will be performed by O Self Service Center Other If you bought this product yourself did you plan to purchase this type of
9. VICE KEEP THIS WARRANTY LIMITED WARRANTY DESA International warrants this product and any parts thereof to be free from defects in materials and workmanship for one 1 year from the date of first purchase when operated and maintained in accordance with instructions This warranty is extended only to the original retail purchaser when proof of purchase is provided This warranty covers only the cost of parts and labor required to restore the product to proper operating condition Transportation and incidental costs associated with warranty repairs are not reimbursable under this warranty Warranty service is available only through authorized dealers and service centers This warranty does not cover defects resulting from misuse abuse negligence accidents lack of proper maintenance normal wear alteration modification tampering contaminated fuels repair using improper parts or repair by anyone other than an authorized dealer or service center Routine maintenance is the responsibility of the owner THIS EXPRESS WARRANTY IS GIVEN IN LIEU OF ANY OTHER WARRANTY EITHER EXPRESSED OR IMPLIED INCLUDING WARRANTIES OR MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE DESA International assumes no responsibility for indirect incidental or consequential damages Some states do not allow the exclusion or limitation of incidental or consequential damages or limitations or exclusions may not apply to you This Limited Warranty gives
10. and Over What is the population of your area Under 10 000 10 000 to 25 000 25 000 to 50 000 50 000 to 100 000 100 000 to 250 000 Over 250 000 Store where product was purchased Name City State In choosing this product how important were the following Not Somewhat Very Not Somewhat Very Availability O O O Size O O O Price O O O Prior Brand Experience O O O Brand Name O O O Built In Thermostat O O O Overall Quality O Ease of Operation Heat Output Btu Hr Rating O O O Special Features O Variable Heat Output Btu Hr O O Salesperson s Recommendation O O O Made in USA O O O Friend Relative s Recommendation O Warranty O O O Portability O O O Local Service O O O Quiet Operation O O O Value for Price O O O This question will allow us to better understand the demographic profile of our customers Which of the following best describes you not required O African American Asian American Mexican Puerto Rican Cuban Other Hispanic White Other AdVL Postage Required DESA INTERNATIONAL 2701 Industrial Drive P O Box 90004 Bowling Green KY 42102 9004 TAPE OTHER OUTDOOR HEATING PRODUCTS PORTABLE KEROSENE DIESEL FORCED AIR HEATERS EE TH PROPANE LP AND NATURAL GAS GARAGE HEATERS PROPANE LP PROPANE LP AND NATURAL PATIO HEATERS GAS CHIMENEAS WARRANTY AND REPAIR SER
11. es out when auto 1 Not enough warm up time 1 Relight hold automatic control valve but matic control valve button is released ton in 45 seconds 2 Low gas pressure 2 Check propane tank s for proper gas supply 3 Thermocouple loose or needs to be replaced 3 Tighten connection or replace thermocouple 4 Automatic control valve needs to be re 4 Replace automatic control valve placed 1 Main burner valve not fully open 1 Fully open main burner valve by turning control knob towards HIGH position until Burn rate is low it stops 2 Plugged gas orifices 2 Replace gas orifice 3 Low gas pressure 3 Check gas supply check regulator output 4 Low fuel supply 4 Consult propane gas supplier For more information visi 103386 01G ILLUSTRATED PARTS BREAKDOWN AND PARTS LIST Models TC200V and RCP200V ILLUSTRATED PARTS BREAKDOWN AND PARTS LIST MODELS TC200V RCP200V This list contains replaceable parts used in your heater When ordering parts follow the instructions listed under Replacement Parts on page 5 of this manual 103925 01 103923 01 101263 01 097162 02 103031 02 103924 01 102445 01 103906 01 103927 01 103926 01 103398 01 103396 01 DESCRIPTION Top and Shell Assembly Burner Ring Assembly Burner Plate Burner Nozzle Base Knob Assembly Piezo Ignitor Thermocouple Kit Thermocouple Bracket Fuel Tube Kit Valve Assembly Ignitor Electrode Heat Shield PARTS AVAILABLE NOT SHOW
12. esh outside air while running heater If proper fresh outside air ventilation is not provided carbon monoxide poisoning can occur Provide proper fresh outside air ventilation before running heater FRESH OUTSIDE AIR OPENING REQUIREMENTS HEATER SIZE SQ FT OPENING 200 000 Btu Hr 6 0 INSTALLATION A WARNING Review and understand the warnings in the Safety Information section pages 2 and 3 They are needed to safely operate this heater Follow all local codes when using this heater A WARNING Test all gas piping and connections for leaks after installation or servicing Never use an open flame to check for a leak Apply a mixture of liquid soap and water to all joints Bubbles forming show a leak Correct all leaks at once Provide propane supply system see Propane Supply page 3 Connect fuel gas fitting on hose regulator assembly to pro pane tank s Turn fuel gas fitting counterclockwise into threads on tank Tighten firmly using a wrench IMPORTANT Tighten regulator with vent pointing down Pointing vent down pro tects regulator from weather damage Connect hose to the valve inlet Tighten firmly using a wrench You must use the regulator supplied with heater even if pro pane tank has one Open propane supply valve on propane tank s slowly Note If not opened slowly excess flow check valve on propane tank may stop gas flow If this happens you may hear a click inside the regulator assembl
13. he area being heated We cannot foresee every use which may be made of our heaters CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE QUESTIONS ABOUT HEATER USE Other standards govern the use of fuel gases and heat producing products for specific uses Your local authorities can advise you about these Carbon Monoxide Poisoning Some people are more affected by carbon monoxide than others Early signs of carbon monoxide poison ing resemble the flu with headaches dizziness and or nausea If you have these signs the heater may not be working properly Get fresh air at once Check for proper ventilation and have heater serviced Propane Gas Propane gas is odorless An odor making agent is added to propane gas The odor helps you detect a propane gas leak However the odor added to propane gas may fade Propane gas may be present even though no odor exists Make certain you read and understand all warnings Keep this manual for reference It is your guide to safe and proper operation of this heater Install and use heater with care Follow all local ordinances and codes In the absence of local ordinances and codes refer to the Standard for Storage and Handling of Liquefied Petroleum Gas ANSI NFPA 58 and the Natural Gas Installation Code CGA B149 2 This instructs on the safe storage and handling of propane gases This product has been approved for use in the Commonwealth of Massachusetts Use only propane gas set
14. i Low 5 9 psi Minimum Temp 20 F 29 C Surrounding Air Weight pounds Heater cesis 16 21 Size L x W x inches Heater 15x16x30 18 x 18 6 x 31 25 REPLACEMENT PARTS A WARNING Use only original replacement parts This heater must use design specific parts Do not substitute or use generic parts Improper replace ment parts could cause serious or fatal injuries This will also protect your warranty coverage for parts replaced under warranty PARTS UNDER WARRANTY Contact authorized dealers of this product If they can t supply original replacement part s either contact your nearest Parts Cen tral or call DESA International s Technical Service Department at 1 866 672 6040 When calling DESA International have ready your name how heater was malfunctioning your address e purchase date model and serial numbers of your heater In most cases we will ask you to return the part to the factory PARTS NOT UNDER WARRANTY Contact authorized dealers of this product If they can t supply original replacement part s either contact your nearest Parts Cen tral or call DESA International at 1 866 672 6040 for information When calling DESA International have ready model number of your heater the replacement part number ACCESSORIES Purchase these accessories and parts from your local dealer
15. or service center If your dealer or service center can not supply an accessory or part contact your nearest Parts Central listed in the separate Authorized Service Center booklet or call DESA Interna tional at 1 866 672 6040 for referral information You can also write to the address listed on the back page of this manual Part Number Description LPA1020 10 Rubber Hose with Brass Fitting ULL listed LPA2005 Propane Gas Regulator ULL listed LPA3005 Hose Regulator Assembly ULL listed LPA4020 Fuel Gas Connector Connects regulator to all standard propane tanks U L and A G A listed For more information visit www d 103386 01G TROUBLESHOOTING TROUBLESHOOTING www desatech com Note For additional help visit DESA International s technical service website at A WARNING Never attempt to service heater while it is connected to propane supply operating or hot Severe burns can occur SYMPTOM POSSIBLE CAUSE REMEDY Burner fails to light 1 Propane supply valve closed on propane 1 Open propane supply valve slowly tank s 2 Excess flow check valve closed 2 Close propane supply valve on propane tank and reopen slowly 3 Blockage in burner nozzle 3 Replace burner nozzle 4 Piezo ignition system not sparking 4 Check to assure ignitor electrode gap is 130 Check wire lead for damage Replace piezo ignitor and or ignitor electrode as nec essary Burner lights but go
16. or use on finished floors Never block air inlet bottom of shell or air outlet around top of shell of heater Do not leave heater unattended Keep children and animals away from heater Never move handle or service a hot or operating heater Severe burns may result Wait 15 minutes after turning heater off For more information visit www at Om 103386 01G SAFETY INFORMATIO Continued To prevent injury wear gloves when handling heater e Never attach duct work to heater Turn off propane supply to heater when not in use e Use only original replacement parts This heater must use de sign specific parts Do not substitute or use generic parts Im proper replacement parts could cause serious or fatal injuries PRODUCT IDENTIFICATI Ignitor Electrode Thermocouple Piezo Ignitor Button Hose Regulator Assembly Nak a 9 h I j 3 Valve Inlet Control Knob DF Figure 1 Product Identification For more information visi 103386 01G ON Top Shell SAFETY INFORMATION PRODUCT IDENTIFICATION UNPACKING THEORY OF OPERATION PROPANE SUPPLY UNPACKING 1 Remove all packing items applied to heater for shipment Keep plastic cover caps attached to valve inlet and hose regulator assembly for storage Remove all items from carton 3 Check all items for shipping damage If heater is damaged promptly inform dealer where you bought heater
17. product before going into the store O Yes ONo Type of store where product was purchased Hardware Propane Dealer Natural Gas Utility Co Home Center or Builder s Supply Farm Ag Supply Auto Parts Warehouse Club Industrial Contractor Supply Rental Store O Discount Store HVAC Dealer Other What is your primary source of heat Propane LP Gas Natural Gas Kerosene Diesel Electric Other What motivated you to buy this product Sudden Cold Weather Replace Older Model D I Y Home Project Emergency Back Up Heat Heater on Sale Construction Project Hard to Heat Location Other How did you learn about this product brand Advertisement Relative or Friend Co Worker Store Representative O Store Display Previously Owned a Heater Other Specify What other brands did you consider O None O Master O Remington O All Pro O Dayton O Universal O Mr Heater O L B White Tradesman John Deere O Dyna Glo Dura Heat O Paulin Coleman Vogelzang American Other Who selected the product O Male O Female O Both Level of Education of Purchaser High School Vocation Technical School Some College Completed College Graduate School Age of Purchaser O Under 20 20 29 030 39 040 49 O50 59 O60 or Over Buyer s total annual household income Under 19 999 20 000 to 34 999 35 000 to 49 999 O 50 000 to 74 999 75 000 to 99 999 100 000
18. y this is the check valve closing To re set the excess flow check valve close propane supply valve and open it again slowly Check all connections for leaks Apply mixture of liquid soap and water to gas joints Bubbles forming show a leak that must be corrected Close propane supply valve Propane Supply Valve Valve Inlet Hose Figure 3 Hose and Valve Inlet OPERATION A WARNING Review and understand the warnings in the Safety Information section on pages 2 and 3 They are needed to safely operate this heater Follow all local codes when using this heater TO START HEATER 1 2 Follow all installation ventilation and safety information Locate heater on stable and level surface Make sure strong drafts do not blow on heater Open propane supply valve on propane tank s slowly Note If not opened slowly excess flow check valve on propane tank may stop gas flow If this happens you may hear a click inside the regulator assembly this is the check valve closing To re set the excess flow check valve close propane supply valve and open it again slowly Turn control knob clockwise to the lowest position and push in see Figure 4 page 5 With the control knob pushed all the way in press and release the piezo ignitor button see Figure 4 page 5 Keep pressing piezo ignitor button until the burner lights Hold control knob down for a maximum of 10 seconds while attempting ignition
Download Pdf Manuals
Related Search