Weber 41081 Owner`s manual
Contents
1. A WARNING Never store an extra spare gas supply cylinder near the Weber Gas Barbecue A WARNING This appliance gets very hot Take special care when children or elderly people are present A WARNING Do not move the appliance while it is alight A WARNING Wear protective gloves when using this appliance A WARNING Use this grill only on a flat and level surface GENERAL INSTRUCTIONS COOKING A WARNING Do not move the Weber gas barbecue when operating or while barbecue is hot You can adjust the burners as desired The control settings High H Medium M Low L or Off O are described in your Weber cookbook The cookbook uses these notations to describe the settings of the INSIDE and OUTSIDE burners For example to sear steaks you would set both burners at H high Then to complete cooking you would set OUTSIDE burner at M medium Refer to your Weber cookbook for detailed cooking instructions or log onto our website at www weber com Inside Outside 00 GQ Low Direct I Chicken Pieces Sausages 0 0 0 Low Low High Direct 6 0 0 0 Steak and items oe a S GQ that need searing Medium Medium Indirect Small chickens GQ Off Medium gt gt gt gt lt Preheat GS C L High High Note The temperature inside your cooking box for the first few uses while surfaces are still very reflective may be hotter than those shown in your cookbook Cooking conditions Such as2. Failure to correct the above mentioned symptoms may result in a fire which can cause serious bodily injury or death and cause damage to property ANNUAL MAINTENANCE Inspection and cleaning of the Spider Insect Screens To inspect the Spider Insect Screens remove the control panel If there is dust or dirt on the screens remove the burners for cleaning the screens Brush the Spider Insect Screens lightly with a soft bristle brush i e an old toothbrush A CAUTION Do not clean the Spider Insect Screens with hard or sharp tools Do not dislodge the Spider Insect Screens or enlarge the screen openings Lightly tap the burner to get debris and dirt out of the burner tube Once the Spider Insect Screens and burners are clean replace the burners If the Spider Insect Screen becomes damaged or cannot be cleaned please contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com 28 MAINTENANCE MAIN BURNER FLAME PATTERN The Weber gas barbecue burners have been factory set for the correct air and gas mixture The correct flame pattern is shown 1 Burner tube 2 Tips occasionally flicker yellow 3 Light blue 4 Dark blue If the flames do not appear to be uniform throughout the burner tube follow the burner cleaning procedures MAIN BURNER CLEANING PROCEDURE Turn off the gas supply Remove burners first See section Replacing
3. IGNITION SYSTEM OPERATIONS lf the ignition system fails to ignite the burners then check the igniter Check that both ignition wires are attached properly to igniter electrodes 1 Check that the ignition button pushes in and returns to the out position If the ignition system still fails to light contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com IGNITION SYSTEM OPERATIONS If the electronic ignition system fails to ignite the outside burner light the outside burner with a match If the outside burner lights with a match then check the Electronic Ignition System Check that both of the ignition wires are attached properly to the igniter electrodes 1 on the ignition module Check that the Electronic Ignition Button is working by listening and looking for sparks at the outside burner REPLACE BATTERY IF NECESSARY AAA alkaline battery only See illustration If the Electronic Ignition System still fails to light contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com ELECTRONIC IGNITION SYSTEM REPLACEMENT If replacement of the ignition module is necessary it must be removed and disposed of properly Please see back page for further information on proper disposal A ATTENTION This product has been safety tested and is only certified for use in a specific country Refe
4. Turn on the cylinder valve A2 Turn cylinder valve clockwise B2 Move regulator lever counter clockwise to the On position C2 Move regulator lever to the On position 4 Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles If bubbles form or if a bubble grows there is a leak If there is a leak turn off the gas and tighten the fitting Turn the gas back on and recheck with the soap and water solution If leak does not stop contact the Customer Service Representative in your area using the contact information on our website Log onto www weber com 5 When leak checking is complete turn gas supply OFF at the source and rinse connections with water A WARNING Do not ignite burners when leak checking Check A Valve to regulator hose connection B Valve to Outside burner gas line connection C Valve to Inside burner gas line connection A WARNING If there is a leak at connection A B or C turn OFF the gas DO NOT OPERATE THE GRILL Contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Check D Hose to regulator connection E Regulator to propane cylinder connection A WARNING If there is a leak at connection E remove propane cylinder Do not operate grill Use a different propane cylinder and recheck for leaks with soap and water solution If a leak persists after retightening the propane cyl
5. Genesis Austria Kettle Silhouette Smokey Joe Weber Benelux Kettle Silhouette Smokey Joe Weber Compact Grill Configuration Botswana Weber Canada Smokey Joe Genesis China Kettle Silhouette Denmark Kettle Silhouette Smokey Joe Weber Finland Smokey Joe France Kettle Silhouette Smokey Joe Weber One Touch Germany Smokey Joe Weber One Touch Greece Smokey Joe Ireland Kettle Silhouette Smokey Joe Italy Smokey Joe Weber Japan Smokey Joe Weber Korea Smokey Joe Weber New Zealand Weber Smokey Joe Nigeria Weber Norway Smokey Joe Weber Portugal Weber South Africa Smokey Joe Weber Kettle Configuration Spain Smokey Joe Weber Sweden Kettle Silhouette Smokey Joe Switzerland Kettle Silhouette Smokey Joe Weber United Kingdom Smokey Joe Weber Weber One Touch U S A Kettle Configuration Kettle Silhouette Smokey Joe Weber One Touch Firespice Go Anywhere U S A Kettle Configuration Kettle Silhouette Genesis Flavorizer Crossover Flamgo Performer Rapidfire Tuck N Carry Jumbo Joe Bar B Kettle Master Touch Spirit Grill Out Summit Platinum 1 800 Grill Out Ranch Matchless Flame Zimbabwe Weber Kettle Configuration Kettle Silhouette Printed in USA
6. hands or fingers on the front edge of the cooking box A Should an uncontrolled flare up occur move food away from the flames until flaring subsides A Should a grease fire occur turn off all burners and leave lid closed until fire is out A The Weber gas barbecue should be cleaned thoroughly at regular intervals A When cleaning valves or burners do not enlarge orifices or ports Liquid propane gas is not natural gas The conversion or attempted use of natural gas in a LP gas unit is dangerous and will void your warranty A A dented or rusty gas supply cylinder may be hazardous and should be checked by your gas supplier Do not use a gas supply cylinder with a damaged valve Even though your gas supply cylinder may appear to be empty it might still contain gas The cylinder should be transported and stored accordingly A Under no circumstances should you attempt to disconnect the gas regulator or any gas fitting while your barbecue is in operation A Use heat resistant barbecue mittens or gloves when operating barbecue A Do not use this barbecue unless all parts are in place The unit must be properly assembled according to the instructions outlined in the Assembly Instructions A When changing gas container stay away from ignition sources A Do not build this model of grill in any built in or slide in construction Ignoring this Warning could cause a fire or an explosion that can damage property and cause serious bodily injur
7. or serious injury may occur A WARNING Only use this grill outdoors in a well ventilated area Do not use in a garage building breezeway or any other enclosed area REPLACEMENT HOSE AND REGULATOR Country Hose France Hose Belgium Hose Reg Holland Hose Reg Greece ltaly Hose Reg Germany Austria Hose Reg Spain Denmark Portugal Hose Reg Sweden Hose Reg Switzerland Hose Reg Ireland Hose Reg England Hose Reg Australia Hose Reg Norway Finland GAS INSTRUCTIONS CONNECTING THE LIQUID PROPANE CYLINDER A WARNING Make sure that the LP cylinder valve is closed Close by turning valve clockwise A DANGER Do not use an open flame to check for gas leaks Be sure there are no sparks or open flames in the area while you check for leaks Sparks or flames will result in a fire or explosion which can cause serious bodily injury or death and damage to property To Connect the hose to the cylinder 1 Connect LP cylinder A WARNING The hose must be secured to the cart leg by the hose retention clip Failure to do so could cause damage to hose resulting in a fire or explosion which can cause serious bodily injury or death and damage to property Some regulators push ON to connect and pull OFF to disconnect others have a nut that has a left hand thread that connects to the cylinder valve Follow specific regulator connection instructions A1 Screw regulator fitting onto tank tur
8. wind and weather may require the adjustment of the burner controls to obtain the correct cooking temperatures Preheating Your Weber gas barbecue is an energy efficient appliance It operates at an economical low BTU rate To preheat after lighting close lid and turn both burners to high H Preheating to 500 F 260 C will take 10 to 15 minutes depending on conditions such as air temperature and wind Drippings and grease Excess drippings and grease will accumulate in the catch pan under the cookbox Disposable foil drip pans are available that fit the catch pan A WARNING Check the drip pan for grease build up before each use Remove excess grease to avoid a grease fire in the catch pan CLEANING A WARNING Turn your Weber gas barbecue OFF and wait for it to cool before cleaning For availability of replacement cooking grate contact the Customer Service Representative in your region using the contact information on our web site Log onto www weber com Outside surfaces Use a warm soapy water solution to clean then rinse with water A CAUTION Do not use oven cleaner abrasive cleansers kitchen cleansers cleaners that contain citrus products or abrasive cleaning pads on barbecue or cart surfaces Slide out Bottom tray Remove excess grease then wash with warm soapy water then rinse Cooking grate Clean with a suitable brass bristle brush As needed remove from grill and wash with warm soapy wa
9. Main Burners Look inside each burner with a flashlight Clean the inside of the burners with a wire a straightened out coat hanger will work Check and clean the air shutter opening at the ends of the burners Check and clean the valve orifices at the base of the burner orifice 5 Use a Steel bristle brush to clean outside of burners This is to make sure all the burner ports are fully open A CAUTION Do not enlarge the burner ports when cleaning MAINTENANCE REPLACING MAIN BURNERS 1 Your Weber gas barbecue must be OFF and cool 2 Turn gas OFF at source 3 Open lid and remove the cooking grates 4 Remove the 1 4 X 20 inch screw that holds the burner tube to the cookbox x 5 Rotate the outside burner 90 clockwise Slide burner away from burner orifice and remove from cook box 6 Repeat this procedure for the Inside burner y A CAUTION Care must be taken when removing or reinstalling burner tubes Do not force or bend the gas lines that connect the burner tubes to the control valve 7 To reinstall the burners reverse 4 through 7 A CAUTION The burner openings a must be positioned properly over the burner orifices b Check for proper assembly before fastening Burner tubes in place A WARNING After reinstalling the burners they should be leak checked with a soap and water solution before using the barbecue See Step Check for gas leaks MAINTENANCE Q300
10. Portability means you can take your Weber Gas Barbecue with you if you move Liquid Propane LP gas is quicker to use and gives you more cooking control than charcoal fuel These instructions will give you the minimum requirements for assembling your Weber gas barbecue We therefore request that you read them carefully before you use the Weber gas barbecue e Not for use by children Do not connect to natural gas supply city gas The valves and orifices are designed exclusively for LP gas Not to be used with charcoal briquettes or lava rock Use only a 3kg 13kg LP gas cylinder In the United Kingdom this appliance must be fitted with a regulator complying with BS3016 having a nominal output of 37 millibars Supplied with barbecue Avoid kinking the hose The length of hose must not exceed 1 5 meters Change the flexible hose when national conditions require it Any parts sealed by the manufacturer must not be altered by the user Any modification of the appliance may be dangerous Only a nationally approved low pressure hose and regulator must be used STORAGE AND OR NON USE e The gas must be turned off at the liquid propane cylinder when the Weber gas barbecue is not in use e When the Weber gas barbecue is stored indoors the gas supply must be DISCONNECTED and the LP cylinder stored outdoors in a well ventilated space LP cylinder must be stored outdoors in a well ventilated area out of reach of child
11. WEDEr O su sn LP Gas Grill Owner s Guide Assembly Pg 9 41081 Register your grill online at www weber com YOU MUST READ THIS OWNER S GUIDE A WARNING Follow all leak check BEFORE OPERATING YOUR GAS GRILL procedures carefully in this manual before operating barbecue Do this even A DANGER if barbecue was dealer assembled If you smell gas 1 Shut off gas to the appliance 2 Extinguish any open flames 3 Open lid 4 If odour continues keep away from the appliance and immediately call your gas supplier or your fire service Leaking gas may cause a fire or explosion which can cause serious bodily injury or death or damage to property OUTDOOR USE ONLY A WARNING 1 Do not store or use petrol or other flammable vapours and liquids in the vicinity of this or any other appliance A gas supply cylinder not connected for use should not be stored in the vicinity of this or any other appliance A WARNING Do not try to light the Weber gas barbecue without first reading the Lighting instructions in this manual INFORMATION FOR THE INSTALLER This manual must remain with the owner who should keep it for future use Q 300 CE 0845BQ 0033 41081 11 16 07 LP 1D 0845 GB ENGLISH DANGERS AND WARNINGS A DANGER Failure to follow the Dangers Warnings and Cautions contained in this Owner s Manual may result in serious bodily injury or death or in a fire or an explosion causing damage to pr
12. e 8 Inside Burner Tube 9 Electrode Assembly 10 Front Cradle 11 Ignition Button Ignition Module 12 Burner Tube Hardware 13 14 15 16 17 18 19 20 21 22 23 24 Large Control Knob Small Control Knob Disposable Drip Pan Ya x 20 x 2 Truss Head Screw Left Leg Tank Skirt Bottom Rack Hair Pin Cotter Hinge Pin Lid Warming Rack Rear Cradle 25 26 27 28 29 30 31 32 33 34 35 Fire box Fire Box Mounting Hardware Valve amp Manifold Regulator Assembly Manifold Hardware Catch Pan Rear Bridge Piece Right Leg Wheel Cover Hubcap Wheel Axle PARTS LIST TOOLS NEEDED 2 STAINLESS STEEL PAN HEAD 1 2 TRUSS HEAD SCREW PHILLIPS SCHEW Ow N Bg SS EISEN SNNNSSSSSSSSSNSNS NS of I 2 A E PES amp ex Q A ROY ned A If N A AS e 5 4 Om 6 gt 4 Om A Wheel Frame goes on the right Lighting instruction sticker faces forward ASSEMBLY ASSEMBLY 19 gt 4 Om ASSEMBLY 1 Uncoil the hose and regulator of the Weber Q 300 320 2 Remove leg screw and secure hose and retention clip 1 to cart leg A WARNING The hose must be secured to the cart leg by the hose retention clip Failure to do so could cause damage to hose resulting in a fire or explosion which can cause serious bodily inju
13. hen lid is open Is the Weber Grill Out Handle Light activated Press the power button If problems cannot be corrected by using these methods please contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com To replace batteries remove lightpod by removing screw a Push tab b and pull apart MAINTENANCE WEBER SPIDER INSECT SCREENS Your Weber gas barbecue as well as any outdoor gas appliance is a target for spiders and other insects They can nest in the venturi section 1 of the burner tubes This blocks the normal gas flow and can cause the gas to flow back out of the combustion air opening This could result in a fire in and around the combustion air openings under the control panel causing serious damage to your barbecue The burner tube combustion air opening is fitted with a stainless steel screen 2 to prevent spiders and other insects from accessing the burner tubes through the combustion air openings We recommend that you inspect the Spider Insect Screens at least once a year See Section Annual Maintenance Also inspect and clean the Spider Insect Screens if any of the following symptoms should ever occur 1 The smell of gas in conjunction with the burner flames appearing yellow and lazy 2 Barbecue does not reach temperature 3 Barbecue heats unevenly 4 One or more of the burners do not ignite A DANGER
14. ide burner is lit you can turn on the Inside burner The Inside burner is ignited from the Outside burner TO EXTINGUISH Push in and turn each burner control knob clockwise to the OFF position Turn gas supply OFF at the source me START HI B START HI D LOW TROUBLESHOOTING PROBLEM CHECK CURE Burners burn with a yellow or orange flame in Inspect Spider Insect Screens for possible Clean Spider Insect Screens See Section Annual conjunction with the smell of gas obstructions Blockage of holes Maintenance Some countries have regulators with an excess gas The excess flow safety device which is part of the To reset the excess flow safety device turn all burner control flow safety device barbecue to cylinder connection may have activated knobs and the cylinder valve OFF Disconnect the regulator from the cylinder Turn burner control knobs to HIGH Wait at least 1 minute Turn burner control knobs OFF Reconnect the regulator to the cylinder Turn cylinder valve on slowly Refer to Lighting Instructions Symptoms Burners do not light or Burners have a small flickering flame in the HIGH position or Barbecue temperature only reaches 250 F 121 C to 300 F 148 C in the HIGH position Burner does not light or flame is low in HIGH Is LP fuel low or empty Refill LP cylinder position Is fuel hose bent or kinked Straighten fuel hose Does the outside burner light with a ma
15. inder turn OFF the gas DO NOT OPERATE THE GRILL Contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com GAS INSTRUCTIONS REFILLING THE LIQUID PROPANE CYLINDER We recommend that you refill the LP cylinder before it is completely empty To refill take LP cylinder to a Gas Propane dealer Removal of the gas supply cylinder 1 Shut off gas supply 2 Disconnect hose with regulator from the cylinder A Unscrew regulator fitting from tank turning clockwise B Move regulator lever b to down off position Push in regulator lever b until it releases from tank C Move regulator lever to off position Slide collar of regulator up 1 to disconnect from tank 3 Exchange empty cylinder for a full cylinder RECONNECTING THE LIQUID PROPANE CYLINDER See CONNECTING THE LIQUID PROPANE CYLINDER SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS e Liquid Propane LP gas is a petroleum product as are petrol and natural gas LP gas is a gas at normal temperatures and pressures Under moderate pressure inside a cylinder LP gas is a liquid As the pressure is released the liquid readily vapourises and becomes gas LP gas has an odour similar to natural gas You should be aware of this odour LP gas is heavier than air Leaking LP gas may collect in low areas and prevent dispersion The LP cylinder must be installed transpo
16. let the gas clear before you try again or try to light with a match 7 After the Outside burner is lit you can turn on the Inside burner The Inside burner is ignited from the Outside burner TO EXTINGUISH Push in and turn each burner control knob clockwise to the OFF position Turn gas supply OFF at the source OPERATING INSTRUCTIONS MANUAL LIGHTING A DANGER Failure to open the lid while igniting the barbecue s burners or not waiting 5 minutes to allow the gas to clear if the barbecue does not light may result in an explosive flame up which can cause serious bodily injury or death 1 Open the lid 2 Make sure all burner control knobs are turned OFF Push each knob in and turn clockwise to ensure they are in the off position A WARNING The burner control knobs must be in the OFF position before turning on the liquid propane cylinder valve 3 Turn the gas on by slowly turning the cylinder valve counterclockwise Wait 60 seconds 4 Strike a match and put the flame into the matchlight hole under the igniter A WARNING Do not lean over open barbecue when lighting the barbecue 5 Select Outside burner push control knob in and turn to START HI 6 Check that the burner is lit by looking down through the cooking grate You should see a flame A WARNING If the burner does not light turn the burner control knob to OFF and wait 5 minutes to let the gas clear before you try again 7 After the Outs
17. lism improper installation or improper maintenance or service or failure to perform normal and routine maintenance including but not limited to damage caused by insects within the burner tubes as set out in this owner s manual Deterioration or damage due to severe weather conditions such as hail hurricanes earthquakes or tornadoes discolouration due to exposure to chemicals either directly or in the atmosphere is not covered by this Limited Warranty There are no other express warrants except as set forth herein and any applicable implied warranties of merchantability and fitness are limited in duration to the period of coverage of this express written Limited Warranty Some regions do not allow limitation on how long an implied warranty lasts so this limitation may not apply to you Weber is not liable for any special indirect or consequential damages Some regions do not allow the exclusion or limitation of incidental or consequential damages so this limitation or exclusion may not apply to you Weber does not authorise any person or company to assume for it any other obligation or liability in connection with the sale installation use removal return or replacement of its equipment and no such representations are binding on Weber This Warranty applies only to products sold at retail GAS TYPE amp PRESSURE 30mbar lsp Iceland Hungary Czech Republic Cyprus Estonia Lithuania Latvia Morocco Slovenia Slovak Rep
18. ning counter clockwise Position the regulator so that the vent hole a faces down B1 Make sure regulator lever b is in the down off position Push regulator down on tank valve until regulator snaps into position C1 Make sure regulator leveris in the off position Slide the collar of the regulator up 1 Push the regulator down onto the tank valve and maintain pressure Slide collar closed 2 If regulator does not lock repeat procedure CHECK FOR GAS LEAKS CHECK THAT THE BURNER VALVES ARE OFF Check by pushing the control knob in and turning clockwise Confirm that the knob is set in the OFF indicator position Proceed to the next step If the control knob does turn continue turning clockwise until it stops It is now in the OFF position Proceed to the next step A WARNING You should check for gas leaks every time you disconnect and reconnect a gas fitting A WARNING Perform these leak checks even if your barbecue was dealer or store assembled A WARNING Do not ignite burners when leak checking GAS INSTRUCTIONS A DANGER Do not use an open flame to check for gas leaks Be sure there are no sparks or open flames in the area while you check for leaks Sparks or open flames will result in a fire or explosion which can cause serious bodily injury or death and damage to property You will need LP cylinder a soap and water solution and a rag or brush to apply it 2 Mix soap and water 3
19. ol knobs are turned OFF Push control knob in and turn clockwise to ensure that it is in the OFF position A WARNING The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve 3 Turn the gas on by slowly turning the cylinder valve counterclockwise Wait 60 seconds A WARNING Do not lean over the open barbecue when lighting the barbecue 4 Select the Outside burner push control knob in and turn to START HI 5a Q300 Push the ignition button so that it clicks Repeat if necessary 5b Q320 Push the electronic ignition button several times You will hear it spark 6 Check that the burner is lit by looking down through the cooking grate You should see a flame OPERATING INSTRUCTIONS A WARNING Check hose before each use of barbecue for nicks cracking abrasions or cuts If the hose is found to be damaged in any way do not use the barbecue Replace using only Weber authorized replacement hose Contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Ignition System Q300 Note The ignition system ignites the burners with a spark from the igniter electrode inside the ignition chamber You generate the energy for the spark by pushing the ignition button until it clicks START H Ono gt A WARNING If the burner does not light turn the burner control knob to OFF and wait 5 minutes to
20. operty A WARNINGS A Follow regulator connection instructions for your type of gas grill A Do not store a spare or disconnected gas supply cylinder under or near this barbecue A Do not put a barbecue cover or anything flammable on or in the storage area under the barbecue A Improper assembly may be dangerous Please carefully follow the assembly instructions in this manual A After a period of storage and or non use the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before use See instructions in this manual for correct procedures A Do not use a flame to check for gas leaks A Do not operate your Weber gas barbecue if there are any leaking gas connections A Flammable materials should not be present within approximately 60 cm of the back or sides of the barbecue A Your Weber gas barbecue should not be used by children Accessible parts of the barbecue may be very hot Keep young children away while it is in use Exercise caution when using your Weber gas barbecue It will be hot during cooking or cleaning and should never be left unattended or moved while in operation If the burners should go out during cooking turn off all gas valves Open the lid and wait five minutes before attempting to re light the gas flame while observing the Lighting Instructions A Do not use charcoal briquettes or lava rock in your Weber gas barbecue A While cooking never lean over the open barbecue or place
21. r to country designation located on outside of box These parts may be gas carrying or gas burning components Please contact Weber Stephen Products Co Customer Service Department for genuine Weber Stephen Products Co replacement part s information A WARNING Do not attempt to make any repair to gas carrying or gas burning components without contacting Weber Stephen Products Co Customer Service Department Your actions if you fail to follow this product warning may cause a fire or an explosion resulting in serious personal injury or death and damage to property This symbol indicates that the product cannot be disposed of with household refuse For instructions regarding proper disposal of this product in Europe please visit www weber com and contact the importer listed for your country If you do not have internet access contact your dealer for the importer s name address and telephone number When you decide to dispose of or discard your grill all electrical components e g rotisserie motor batteries ignition module handle lights must be removed and disposed of properly according to WEEE They should be disposed of separately from the grill WEDERR WEBER STEPHEN PRODUCTS CO www weber com 2008 The following trademarks are registered in the name of Weber Stephen Products Co an Illinois corporation located at 200 East Daniels Road Palatine Illinois 60067 U S A Australia Smokey Joe Weber Kettle Silhouette
22. ren Disconnected LP cylinder must not be stored in a building garage or any other enclosed area e When the LP cylinder is not disconnected from the Weber gas barbecue the appliance and LP tank must be kept outdoors in a well ventilated space The Weber gas barbecue should be checked for gas leaks and any obstructions in the burner tubes before using See Section Gas Instructions and Maintenance Check that the areas under the control panel and the slide out bottom tray are free from debris that might obstruct the flow of combustion or ventilation air The Spider Insect Screens should also be checked for any obstructions See Section Maintenance OPERATING A WARNING This appliance is intended for outdoor use only and should never be used in garages and roofed or enclosed porches or verandas A WARNING The Weber Gas Barbecue must never be used under an unprotected combustible roof or overhang A WARNING The barbecue should not be used when combustible materials are within 60 cm of the back or sides of the grill A WARNING Your Weber Gas Barbecue is not intended to be installed in or on caravans and or boats A WARNING When in use the entire barbecue gets hot Never leave it unattended A WARNING Keep any electrical supply cord and the fuel supply hose away from any heated surface A WARNING Keep the cooking area clear of flammable vapours and liquids such as petrol alcohol etc and combustible materials
23. rted and stored in an upright position LP cylinders should not be dropped or handled roughly Never store or transport the LP cylinder where temperatures can reach 51 C too hot to hold by hand for example do not leave the LP cylinder in a car on a hot day e Treat empty LP cylinders with the same care as when full Even when the LP tank is empty of liquid there still may be gas pressure in the cylinder Always close the cylinder valve before disconnecting Do not use a damaged LP cylinder Dented or rusty LP cylinders or LP cylinders with a damaged valve may be hazardous and should be replaced with a new one immediately Liquid Propane LP Cylinder s e The joint where the hose connects to the LP cylinder must be leak tested each time the LP cylinder is reconnected For example test each time the LP cylinder is refilled Be sure the regulator is mounted with the small vent hole pointed downward so that it will not collect water This vent should be free of dirt grease insects etc 24 LIGHTING Summary lighting instructions are posted on the cart leg under the control knobs L A DANGER Failure to open the lid while igniting the barbecue s burners or not waiting 5 minutes to allow the gas to clear if the barbecue does not light may result in an explosive flame up which can cause serious bodily injury or death B START HI D LOW 1 Open the lid 2 Make sure all burner contr
24. ry or death and damage to property ASSEMBLY Place top right post of side table into right side cradle slot A approximately one inch behind cradle slot opening B Y Place opposite top left post into the opposite cradle slot C Using both hands apply pressure towards the right until the top left post pivots into cradle slot e Line up both lower table posts and snap into lower cradle slots ASSEMBLY ASSEMBLY 7k ose Requires 3 AAA alkaline batteries not Use alkaline batteries only Do not mix old and new batteries or different types of included batteries standard alkaline or rechargeable If you do not plan to use the Weber Q Grill Out Handle Light for a month or more remove the batteries ASSEMBLY You may hear a rattle in lightpod This is normal The Weber Q Grill Out Handle Light has a Tilt Sensor Lid up ON Lid Closed OFF The power button a activates or deactivates the Tilt Sensor For daytime use deactivate the sensor by pressing power button a ASSEMBLY 0320 Lo GENERAL INS RUCTIONS General Instructions Your Weber Gas Barbecue is a portable outdoor cooking appliance With the Weber Gas Barbecue you can grill barbecue roast and bake with results that are difficult to duplicate with indoor kitchen appliances The Weber Gas Barbecue is portable so you can easily change its location in your garden or on your patio
25. tch If you can light the outside burner with a match then check the ignition system Experiencing flare ups Are you preheating barbecue in the prescribed All burners on high for 10 to 15 minutes for preheating manner Are the cooking grates heavily coated with burned on Clean thoroughly See Section Cleaning grease A CAUTION Do not line the bottom tray with aluminum foil Is the bottom tray dirty and not allowing grease to Clean bottom tray flow into catch pan Burner flame pattern is erratic Flame is low when Are burners clean Clean burners See Section Maintenance burner is on HIGH Flames do not run the whole length of the burner tube Inside of lid appears to be peeling Resembles The lid is Cast Aluminum not paint It cannot peel Clean thoroughly See Section Cleaning paint peeling What you are seeing is baked on grease that has turned to carbon and is flaking off THIS IS NOT A DEFECT If problems cannot be corrected by using these methods please contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Q320 Handle Light Troubleshooting PROBLEM CHECK Weber Q Grill Out Handle Are the batteries old Replace batteries Light does not light Are the batteries installed correctly See assembly illustration Is the lid in the up position with the power button ON Light will activate w
26. ter then rinse with water Catch pan Disposable foil trays are available or you can line the catch pan with aluminum foil To clean the catch pan wash with warm soapy water then rinse Inside cooking Box Brush any debris off of burner tubes DO NOT ENLARGE BURNER PORTS OPENINGS Wash inside of cooking box with warm soapy water and a water rinse Inside Lid While lid is warm wipe inside with paper towel to prevent grease build up Flaking built up grease resembles paint flakes Swing up work tables Wash with a soft cloth and a soap and water solution Do not use cleaners that contain acid mineral spirits or xylene Rinse well after cleaning Swing up work tables are not to be used as cutting boards GAS INSTRUCTIONS PURCHASE A FULL CYLINDER OF GAS FROM YOUR GAS DEALER The cylinder must always be installed transported and stored in an upright position Never allow the cylinder to drop or be handled carelessly Never store cylinder where temperatures can exceed 51 C too hot to hold by hand For example do not leave the cylinder in your car on hot days See Section Safe handling tips for LP gas IMPORTANT LP CYLINDER INFORMATION Failure to follow these DANGER statements exactly may result in a fire causing death or serious injury ADANGER A NEVER store a spare LP Cylinder under or near this barbecue A NEVER fill the tank beyond 80 full If this is not followed exactly a fire causing death
27. ublic United Kingdom France Spain Portugal Belgium I 28 30 37mbar Ireland Greece Luxembourg Italy Switzerland CONSUMPTION DATA ment oO I gt m Lu m oO ar A gt lt fr EXPLODED VIEW LIST Q300 1 Swing Up Work Surface 13 Small Control Knob 25 Valve amp Manifold Regulator 2 Thermometer Assembly 14 Disposable Drip Pan Assembly 3 Handle Assembly 15 x 20 x 1 Truss Head Screw 26 Manifold Hardware 4 Cooking Grate 16 Left Leg 27 Catch Pan 5 Wire Brace 17 Tank Skirt 28 Bridge Piece 6 Outside Burner Tube 18 Bottom Rack 29 Right Leg 7 Inside Burner Tube 19 Hair Pin Cotter 30 Wheel Cover 8 Electrode Assembly 20 Hinge Pin 31 Hubcap 9 Front Cradle Frame 21 Lid 32 Wheel 10 Igniter 22 Rear Cradle Frame 33 Axle 11 Burner Tube Hardware 23 Fire box 12 Large Control Knob 24 Fire Box Mounting Hardware N 0 a I gt m LL m oO ar a gt lt ft 5860XX_Q320_EURO_100207 20 21 22 23 24 25 26 21 28 29 30 31 32 EXPLODED VIEW LIST Q320 1 Swing Up Work Surface 2 Thermometer Assembly 3 Handle Light Assembly 4 Handle Assembly 5 Cooking Grate 6 Wire Brace 7 Outside Burner Tub
28. y or death WARRANTY In order to validate your warranty please register your grill online at www weber com Weber Stephen Products Co Weber hereby warrants to the ORIGINAL PURCHASER of this Weber gas grill that it will be free of defects in material and workmanship from the date of purchase as follows Aluminium Castings 5 year 2 years paint excluding fading or discoloration Thermoplastic Thermoset Parts All Remaining Parts Stationary cart 5 years excluding fading 2 years 2 years Weber may require reasonable proof of your date of purchase THEREFORE YOU SHOULD RETAIN YOUR SALES RECEIPT OR INVOICE This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use and service and which on examination shall indicate to Weber s satisfaction that they are defective Before returning any parts contact the Customer service representative in your region using the contact information sheet provided with your manual If Weber confirms the defect and approves the claim Weber will elect to replace such parts without charge If you are required to return defective parts transportation charges must be prepaid Weber will return parts to the purchaser freight or postage prepaid COUNTRY Denmark Sweden Norway Finland Netherlands This Limited Warranty does not cover any failures or operating difficulties due to accident abuse misuse alteration misapplication vanda
Download Pdf Manuals
Related Search