MODEL : QUICK 2
Contents
1. the wheel In order to put INOKIM back together do all the steps in reverse order See Page 34 NOTICE MAKE SURE THE INOKIM IS UNPLUGGED AND POWERED OFF INOKIM REAR FLAT TIRE REPAIR OPEN BOTH REAR PLASTIC COVERS Always slide plastic cover aligned with QUICK 2 body lines as shown with blue arrow Do not pull the covers as shown with the red arrow INOKIM REAR FLAT TIRE REPAIR IMPORTANT NOTE When assembling the motor back note the arrows on both plugs make sure they are aligned or you may damage the connector DISASSEMBLE MOTOR WHEEL Use 19mm ring key to open nuts Remove the washer Disassemble nuts and washers from both sides INOKIM REAR FLAT TIRE REPAIR DISASSEMBLE MOTOR WHEEL Carefully slide out the Motor wheel DON T PLACE MOTOR ON THE FLOOR WITH ROTOR DISC BRAKE TOUCHING THE GROUND TO PREVENT IT FROM BENDING INOKIM REAR FLAT TIRE REPAIR REPLACING A TUBE Start next to the air valve Use professional levers to dismount flat tire from Wheel Motor Rim Be careful not to damage the motor Slowly open about 1 4 of the Tire using the levers Use hand to help tire slide out of the rest of the tire out of the rim INOKIM REAR FLAT TIRE REPAIR REPLACING A TUBE Remove inner tube to fix or replace it if needed Place tire back on rim using your hands only You can use lubricant such as soap to ease this operation2. using any function the scooter will automatically shut down DRIVE SPEED CONTROL Start twisting the thumb throttle with your thumb for accelerating Max twisting angle 60 for full speed O THROTTLE OPERATION SPEED MODE When power on the default display is 33 mode appear at top right You may change it using the 2 buttons Speed mode this function is to limit the maximum speed of the scooter either for a beginner user or for more accurate riding in a crowded surrounding speed mode 3 using full throttle will gain maximum speed of the scooter 25KM H at default speed mode 2 using full throttle will gain 70 of scooter top speed speed mode 1 using full throttle the maximum speed will be under10 KM H DISPLAY MODES To enter the display modes setings Touch buttons for 2 seconds will enter in the first mode Press to switch between modes Long press will back to normal function menu CD BACKLIGHT first mode When power is on you can open or close the LCD backlight by long press There are 3 levels for different LCD brightness Press to change level from 1 to 3 low middle high Long touch to save settings Short touch to enter second mode SPEED LIMIT MODE second mode Default and highest speed 25KM H at full throttle You can define other speed limits from 6KM H to 30KM H Press E buttons to change speed limit number Long touch to save setting Short touch 8 to enter thir
3. AKE LEVER EVA CRIPS FRONT BRAKE LEVER HEIGHT ADJUSTABLE HANDLEBARS QUICK RELEASE FRONT V BRAKES ORIGINAL ALLOY WHEEL by MYWAY 10 INCH PNEUMATIC TYRES REMOVABLE FOR MAINTENANCE KICKSTAND CARRY HANDLE ACCESSIBILITY QUICK FOLDING MECHANISM INOKIM WHEEL MOTOR SELF LOCKING RELEASE M BUTTON a ALUMINIUM DECK WITH CARRY HANDLE ANTI SKID CRIPS REAR DISC BRAKE BATTERY CHARGER CONNECTOR QUICK 2 MAIN PARTS MAINTENANCE PLASTIC COVER SPEED CONTROL THROTTLE WITH LCD DISPLAY QUICK RELEASE KICKSTAND WARNINGS amp GENERAL INFORMATION READ THIS MANUAL IMPORTANT INFORMATION WHY IS IT NECESSARY TO READ THIS USER MANUAL This Manual was written help you understand the proper use and maintenance of INOKIM It is Important for you to understand your new its features and performance so that you will enjoy the most from your first and every ride Also it is important that your first ride with INOKIM will be in a remote location without any obstacles INOKIM needs a short period for all moving parts such as hinges and brakes to adjust themselves into their correct position The responsibility for INOKIM maintenance is yours and will help reduce risks of injuries Therefore read this manual and follow it s instructions they will help you avoid these risks WARNINGS amp GENERAL INFORMATION PLEASE NOTICE IN
4. DO NOT USE ANY TOOLS FOR PLACING BACK TIRE ON THE RIM USE HANDS ONLY INOKIM REAR FLAT TIRE REPAIR PLACING THE MOTOR WHEEL BACK Slide back Motor Check right order of washers at both sides Note inner washers are in place Note external washer with lug is in correct slot Safety extension lock of the washer must enter this slot on both sides of motor hinge PLASTIC COVER ASSEMBLY Align plastic cover lines to INOKIM body lines Slide in plastic cover Both corners of Aluminium and plastic should be aligned Align plastic cover hole with 4mm hole on INOKIM body and screw it A WORD FROM THE DESIGNER Congratulation on your new purchase When started the design of MYWAY INOKIM envisioned a world where leaving your car behind would be an easy decision After three years of design and development focusing on every detail the INOKIM Quick 2 offers no compromises the riding experience folding and unfolding or between the rides We created Quick 2 to be an integrated part of your life Enjoy ride carefully and return safely back home Riccardo Nimrod Sapir OPERATION amp MANAGEMENT NINGBO MYWAY MACHINERY CO LTD NO 22 1 INDUSTRIAL ZONE XIAN FENG VILLAGE BEILUN DIST 315806 P R CHINA WWW INOKIM COM DAISY INOKIM CN
5. IUO KINN Urban Freedom MODEL QUICK 2 USER GUIDE MANUAL IMOKIM QUICK 2 EN 6100 6 3 2007 Al A EMO EN 6100 6 1 2007 TUVRheinland 4 Table of Contents QUICK 2 aia di o dida 3 4 5 Warnings amp General information eese eene 6 7 See Ugo 8 Opening amp Folding QUICK 2 ME 9 15 Em 16 Me 17 ROTILE c 18 21 Sel PE Keller T 22 Diving a Go ais TM 25 Flat Tire Repair Instruction 27 35 REMOVING Rear Plastic COVENS ninia id tad 28 DISCONNECTING Motor ContiecTO S assistant 29 Removing Rear Motorized Wheel 30 3 REDICGCING IVs TUDO session dia eta 32 33 REOSSEMDIING Rear Wheel ii 34 wies COVE dM UTE 35 QUICK 2 APPEARANCE QUICK 2 FEATURES QUICK FOLDING MECHANISM SELF LOCKING RELEASE BUTTON LITHIUM ION BATTERY 36V 9Ah ALUMINIUM DECK ANTI SKID GRIPS MUDGUARD 3 REAR REFLECTORS REAR DISC BRAKE EFFICIENT INTEGRAL BRUSHLESS HUB MOTOR by MYWAY FOLDING TBAR NEW THROTTLE BELL with Icd display and functions BATTERY CHARGER CONNECTOR REAR DISC BR
6. OKIM 15 not liable for incidental damages or consequential damages due directly or indirectly to the use of this product BEFORE RIDING Ensure that the M button is inserted all the way in to the middle folding mechanism bridge GENERAL WARNING Always follow the local laws and regulations Never ride your scooter in conditions of poor visibility Do not do stunts wheelies or jumps They will increase your chances of injury and damage your INOKIM Never carry passengers SERIAL NUMBER RECORD SERIAL NUMBERS Write down the serial number of your INOKIM Keep this information separately and in a safe place Each INOKIM has a unique serial number These numbers can provide information that may be useful later on for insurance claims and in case of loss or theft To find your INOKIM serial number 1 The number is on the top of the board on the side of the front wheel 2 Note the serial number and keep it in a safe place OPENING INOKIM IMPORTANT NOTE To release the M button lock button hold the Steering rod in one hand in a far point from the folding mechanism to create a momentum and find a point in which there is no pressure on the opening mechanism meanwhile creating a gentle pull on the M button in the other hand At the right point of no pressure the mechanism will be released and the M button will come out easily That will enable the folding of the handlebar INOKIM s patent for
7. both positions A Push Steering pole Forward B Pull Out M Button C Fold back the Steering Part until it s locked in it s place d S Ne X NS 2 L You may fold INOKIM more compact by folding T bar as well at any stage of the folding process OPERATION BATTERY e Do not operate motor while charging Indicator lights in the throttle are intended only for general knowledge full empty and does not give a precise indication to the battery status Do store INOKIM for long terms more than two months with fully charged battery e From time to time Discharge the battery by riding INOKIM in the red led light position until it slows down and stops DO NOT USE THE BATTERY IF THE BOARD 5 Broken Emits an Unusual odour or excessive heat e Presents any leakage Avoid contact with substance oozing from the battery Keep the battery away from children and pets Exposure to the battery voltage can cause death or serious injury The use storage or charging of the INOKIM battery outside specified limits may result in the annulment of the warranty battery damage and an ineffective battery charging OPERATION CHARGING AND BATTERY Your INOKIM has an external charger Connect the charging cable to INOKIM s charging socket under the footboard on the right side at the rear Than connect the chargers electric cable to an electrical outlet Charging Ligh
8. d mode THROTTLE OPERATION DISPLAY MODES 9 CRUISE CONTROL third mode The default setting is Cruise Control off letter to indicate Press or ES to choose enable Cruise Control Letter Y to indicate Long touch to save setting Short touch to enter first mode TRIP RESET Reset TRIP by long press EB OTHER DISPLAY MODES ARE 9 TRIP your trip distance since your last trip reset Press to swap 9 ODO your scooter total distance since its factory assembled or new repaired battery was placed Battery voltage Your battery state 9 Error your system has encountered an error please contact your local dealer to find out what it is CRUISE CONTROL Wile riding at full speed for more then Ten 10 seconds the Cruise Control will turn on If this option is defined in SETTINGS it does not come as a default for safety reasons When Cruise Control is operated you can release your thumb from the throttle and the scooter will continue to ride at full speed To slow down simply apply pressure on one of the brake levers or press the throttle again the Cruise Control will be turned off When riding with cruise control and braking Cruise Control system powers off Please be aware that when using Cruise Control system releasing your thumb from the throttle will not slow you down you may fined yourself in danger or in danger of others SAFETY Certain countries or regions require safety
9. devices or gear It is your responsibility to know the state laws and follow them TIRES AIR PRESSURE Air pressure in tires 40psi to 50psi SAFETY GEAR Helmet most serious injuries that occur while riding are head injuries This could have been prevented if a helmet had been worn You must wear a helmet while riding your QUICK 2 The helmet must be worn according to its instructions MECHANICAL SAFETY TESTS Before using QUICK 2 Perform a visual inspection that all screws and nuts are tight and in place Note if anything looks amiss or is showing signs of wear If you are unsure bring your QUICK 2 to the authorized distributor Tires and wheels check the tires for signs of wear To do this spin them to make sure that they are not yet in the need of replacing Make sure that the wheels are freely rotating from the brakes If not take QUICK 2 to the authorized distributor Before each ride always check your brakes and mechanical function As you accelerate lean forwards As you brake tilt your weight backwards SAFE DRIVING 1 Get to know QUICK 2 before driving it Test your control over it Make your turns slowly and cautiously and give yourself stopping distance Your driving capability to gain control over your scooter practice your first ride on QUICK 2 in an open space with no obstacles to disturb you DRIVING TECHNIQUE Foot Position before ri
10. ding put your foot as close as possible to the front section of the scooter and your other foot on the ground Make sure that your driving route is clear To start riding boost yourself forwards as on non motorized scooters with your foot that is on the ground Immediately after press the thumb throttle downwards tilt your body forwards so you shouldn t fall backwards during acceleration QUICK 2 will be in motion Avoid your body pressure on the handle bars in acceleration and deceleration Keep one foot behind the other it s more comfortable to place one foot forward and the other one turned backwards at 70 909 like on It will help you gain more stability NOTICE Riding like most sports Involves risks of injury and damage By choosing to ride INOKIM the responsibility and all inherent risk is on you It is crucial that you know understand and act according to safety rules DRIVING TECHNIQUE DRIVING TECHNIQUE Turns The turns on INOKIM are done as on surf ski snowboard The handlebar should be in parallel to the body Before turning look at the approaching direction and make sure turning is safe Braking Tilt your weight backwards so that the brake action will come through the feet and not trough the handlebar and steering system It is best to learn how to adjust the centre of gravity during Stopping otherwise there is a dual concern forward turning over Stopy and
11. or wear and breaking of the handlebar and steering system INOKIM QUICK MAINTENANCE INOKIM was assembled by professional people Any attempt to independently fix or change INOKIM or parts of it in any way will cause damage to the INOKIM Quick E Scooter and will cancel the manufacturer warranty given upon delivery REQUIRED TOOLS 3 mm Allen key 19 mm ring key Professional spoons Tire Pump INOKIM REAR FLAT TIRE REPAIR Make sure the INOKIM is unplugged and powered off Place INOKIM on a high stable surface where it s placed only on its body so that rear and front wheels will be in the air Use 3 mm Allen key to open both rear plastic covers See Page 28 From INOKIM s right side gently disconnect all motor connectors attached to wires See Page 29 Use 19 mm ring key to disassemble motor nuts and motors See page 30 Remember the exact order and place of washers on each side of the motor See page 30 Use professional spoons not plastic or small ones to dismount tire from motor be careful not to damage the motor rim tire and tube use liquid soap around the rim to help tire slide out of the rim See Page 32 Fix or replace tube Put the tire back in place Use liquid soap around the rim to put the tire back in place Do not use any tools for placing back tire on the rim use hands only See Page 33 Check that your repair is completely done by pumping air to 45 psi Into
12. quick and steady locking is based on exact pressures Imprudence in this act will harm and cause wear to the folding system OPENING INOKIM A Unfold firmly for locking the folding mechanism B Visually check that M BUTTON is inserted all the way in NOTICE Before driving you must ensure that the M button is inserted all the way in to the central folding mechanism Otherwise you risk injuring yourself and damaging the folding system OPENING INOKIM Use your thumbs to help red buttons to get in and out their place in the foldable T bar ai NA M 7 eA m 4 2 A A OPENING INOKIM A Open Quick Release B Pull Handle bar up to adjust height C Lock Quick Release OMIC 2 STEP The telescopic steering rod Start by opening the quick release slide the top steering rod into the main steering rod where the INOKIM logo is written and lock the Quick Release A Open Quick Release B Slide Handle Bar down C Lock Quick Release NOTICE INOKIM has a unique folding mechanism which enables a quick and easy fold for carrying transportation and storage FOLDING QUICK 2 STEP 2 Folding of the steering system is achieved by pulling out the M button and folding the steering rod towards the rear wheel till you hear a Click That confirms the locking of the mechanism Make sure the M button is inserted all the way in
13. t Red Battery is charging Charging Light Green Charging is complete Avoid long periods of time with an uncharged or fully charged battery To maximize your INOKIM s battery performance fully charge it for 9 hours once a month or after each use of twelve hours Unplug INOKIM from the outlet before installing removing the battery or performing any maintenance It is dangerous to work on INOKIM when plugged into an AC outlet Electrical shock can cause serious injury and damage the scooter Do not attempt to open the battery Do not insert anything in the battery and do not attempt to open its case with any tool Inserting an object into openings or in the battery can cause electrical shock injury burns or fire Any attempt to open the battery case will damage it and cause release of dangerous toxic substances Charge the battery only using tools approved by INOKIM Remove the battery and carry INOKIM according to all applicable local and national requirements THROTTLE OPERATION LCD DISPLAY THROTTLE FUNCTIONS Gp KI GRA KM h TRIP travel soeed cruise control distance battery status speed mode Total trip background light automatic power off ODO ACCELERATE thumb button THROTTLE POWER ON Pressing to power the scooter on THROTTLE POWER OFF Press for three seconds to shut down the system ho EN AUTO OFF After five minutes of non
Download Pdf Manuals
Related Search