Nano Doser 1 User Manual
Contents
1. check the pump is running at the expected rate and administering the correct dose for 24 before dosing into the aquarium Step 3 Attach the dosing line Attach the dosing line to the Syringe you selected The conector on the dosing line will lock onto the tip of the Syringe by turning it clockwise Step 4 Fill the Syringe With your thumb push the plunger of the Syringe all the way to the end to squeeze out the air Then place the tip of the dosing line into the solution you wish to dose and slowly and gently draw back with the Syringe to fill it This will take some time as the solution is being drawn through the fine dosing line Do not force the Syringe as it may break Draw back slightly past the capacity of the syringe eg on a 30mL Syringe draw back only a little past the 30mL mark 7 Nano Doser 1 user manual V1 0 13 11 2014 CONVEM SOM Step 5 Fit the dosing tip Install the dosing tip on to the end of the dosing line and push slightly until the plunger is at the capacity marker for the Syringe eg 20mL Syringe should have the plunger at the 20mL mark exactly Note how the end of the plunger is the following diagram Note The dosing line and nozzle is not shown in his diagram Step 6 Install the Syringe into the pump 1 Put the syringe on top of the pump with its barrel in the V shaped recess 2 Move the actuator up to the syringe plunger This is done by pressing and holding in the white button on the side and sliding2. it along The push button on the plunger of the syringe must be fitted in the slot in the actuator 3 Put the rubber strap over the top of the syringe barrel and pull it tight Hook and then press it into the groove in the side of the case Step 7 Start the pump running 1 Press and hold down the Boost button The motor will turn and stop after 10 seconds The alarm will sound 2 Release the boost button to start the pump The indicator lamp will begin to flash once ever 25 seconds to indicate the pump is now running Top up dose To administer a small boost of the substance you are dosing the BOOST button can be pressed The syringe plunger moves forwards with each beep The calculator will tell you how much is dispensed per beep htip saltwater conversion com pages nano doser calculator Stopping the Syringe Driver when the syringe is empty The pump will stop automatically and the alarm will sound for about 15 seconds There is no OFF switch to stop the Syringe Driver before the syringe is empty To stop it move the rate switches to 00 the indicator lamp will still flash or alternatively just remove the battery from the pump 8 Nano Doser 1 user manual V1 0 13 11 2014 CONVEM SOM Section 3 Troubleshooting Alarms The Syringe Driver will make a beep noise lasting about 15 seconds e When the syringe is empty e When you insert a battery e When the BOOST button is pressed for more than 10 seconds e When the pum
3. this product you accept the risks associated with it Otherwise please return the product at the time of purchase for a full refund excluding return shipping changes 10 Nano Doser 1 user manual V1 0 13 11 2014 COMVer SOM
4. A E a Oba aaa Raat 8 SECTION 3 TOUBIGSMOONNG sie assa surra dera casa ent nn an 9 SYFMOTOM ENS sair a A nt A eda Petal hones 9 Disclaimer of liability and warranty information no rono no rono nor rrn ono rnn nono 10 3 Nano Doser 1 user manual V1 0 13 11 2014 CONVeTFSIOmM Section 1 Introduction The Nano Doser 1 takes ultra precision medical dosing technology and makes it available to aquarium hobbyists for the first time The clever design is capable of precisely administering tiny doses as small as 0 07mL per day for periods of up to two months at a time This makes it ideal for substances that have typically been administered by hand due to their precise dosing requirements such as vodka and ZEOvit products It also opens the way for dosing substances like vodka in smaller tanks where precision is a must What s in the box e Nano Doser 1 Pump e 3mlL Syringe e 5m_L Syringe e Om Syringe e 30mlL Syringe e High Precision PTFE Microbore Dosing Line with Locking Connectors 1 6m 63 300um ID e High Precision 190um Dosing Nozzle with Locking Connector 4 Nano Doser 1 user manual V1 0 13 11 2014 SOUCWALEeEs1 Nano Doser 1 at a Glance Strap Syringe Actuator Se p F MA Mza Es ae Nano Doser 1 E la 9 e e Boost and Start Button Rate Setting Status LED Other equipment you may need to supply Dosing tube holder A dosing tube holder will help keep your dosing lines securely hel
5. Nano Doser User Manual soakwoter conversion Nano Doser 1 User Manual These instructions set out the steps required to set up and maintain your Nano Doser 1 This manual must be read prior to using the Nano Doser 1 to ensure correct setup procedures are followed 2014 Saltwater Conversion Al rights reserved The written and graphic product descriptions in this manual are correct at the time of printing This manual is updated as required Visit the Saltwater Conversion website to access the latest version This pump is NOT to be used as a medical device under any circumstances ted Saltwater Conversion Unit 16 595 Willoughby Rd Willoughby NSW 2067 Australia Tel 61 448833089 www saltwater conversion com au Email _info saltwater conversion com 2 Nano Doser 1 user manual V1 0 13 11 2014 CONVEM SOM Contents 210708910 e Ue o sas diaria r O 4 Whats In TIS DO A A AAA a AA 4 Nano Doser rara GIAA andan 5 Other equipment you may need to SUppIy i rar rr rr nn rr nr rra 5 Section 2 Setting up the Nano Doser TU 6 Step Fitting the DAMN ras sais eras RS a a DUAS GS aa USO aa 6 Step 2 Calculate pump settings ns 6 7 step 3 Atach the dosing INS ui ann TUE SOS SS RS teeta ond cals aa 7 Sn ABI TRS SIA casais wheats Eee dis 7 Step DEMOS AO TD tai ears ist ial asa ga pa SS a aed A hun Mea tas 7 Step 6 Install the syringe into TNE pump 8 step Start THe DUMP TUNING ease wierd a dad noida AT COS eR 8 TOP UP
6. d above the surface of the water Chiller mini fridge Some substances may require cooling to prevent spoilage A USB can cooler can commonly be found on online auction sites and be used to cool the pump plus its contents The pump should never be cooled below 10 C 50 F Battery A standard 9 volt battery is required and should be easy to source locally Unfortunately due to safety concerns transport companies no longer allow shipping of batteries in many regions so we are unable to include it in the kit 5 Nano Doser 1 user manual V1 0 13 11 2014 COMVer SOM WARNING Before use please read alloperating instructions and our lia bility disclaimer on page 10 Section 2 Setting up the Nano Doser 1 This chapter sets out the steps to set up the Marine Pac 3 To start remove all the components from the box and unwrap Step 1 Calculate pump setting Step 2 Install syringe into pump Step 3 Install dosing line Step 4 Install dosing nozzle Step 5 Fill pump Step 6 Start pump Step 1 Fitting the battery Use a brand new standard 9v battery 1 Take off the battery cover 2 Push in the battery The label in the battery compartment shows which way round to put it Accidentally putting it in the wrong way round will not do any harm 3 Slide the battery cover back on the pump 4 The alarm will sound for about 15 seconds and fade away after the battery is fitted This alarm sound is to let you know the unit is n
7. n touch and let you know the necessary action to correct problems covered by this warranty In the event your product is faulty during the warranty period please contact us and we will offer a replacement or parts for the faulty item How State Law applies This warranty gives you specific legal rights and you may also have other rights which vary from state to state IMPORTANT Disclaimer and Accepted Risks Please read carefully This pump is NOT to be used as a medical device under any circumstances Saltwater Conversion assumes no liability for any and all associated damages including but not limited to damage to property to the tank and its inhabitants flooding water damage etc As with all aquarium products the risk of malfunction and damage to your tank and livestock is very real This tisk is increased further when using when dosing highly concentrated supplements This product should only be used by experienced users and the pump should always be test run before being connected to the tank NEVER assume the calculator tool to be correct all the time and TEST that the pump is running at the correct rate BEFORE connecting it to your tank This pump should only be used in a situation where the customer understands and accepts the risk that may occur in the event of a fault or miscalculation or error in the calculator tool The extent of the warranty provides for replacement of parts supplied by Saltwater Conversion only By using
8. ow operational and the battery has charge Step 2 Calculate the pump settings 1 Select one of the included syringes e 3mL Syringe 0 05mL 0 2mL per day dosing e Sm Syringe 0 083mL 0 5mL per day dosing e Om Syringe 0 16mL ImL per day dosing e 30mlL Syringe 0 5mL 3mL per day dosing 2 Use the table on the following page combined with our online calculator tool found here http saltwater conversion com pages nano doser calculator 6 Nano Doser 1 user manual V1 0 13 11 2014 CONVEM SOM Enter the capacity mL and length mm for the syringe you have selected into the calculator Please note this table applies only to the syringes included Other brands may vary in length and should be measured Select the Syringe type with the minimum dose closest to the amount you plan to dose For example if your minimum dose is to be 0 1mL then you ll need the 3mL Syringe as it is capable of dosing as low as 0 07mL If your minimum dose requirements are a little higher say anywhere from 0 13mL 0 189mL then go up to the next size being the 5mL Syringe as that will be the dose range best matching Syringe Type Length Minimum dose 3mL 45mm 0 07mL 5mL 38mm 0 13mL 10mL 52mm 0 19mL 20mL 65mm 0 3mL 30mL 71mm 0 42mL Using the included screwdriver dial in the Millimetres mm output on the pump the same as calculator tool shows IMPORTANT When calculating a dose for the first time ALWAYS
9. p has stopped blocked dosing line or nozzle The Indicator Lamp will stop flashing e When the pump has stopped and switched off e When the battery needs replacing The following table will enable a user to diagnose basic problems and implement a solution that may enable the device to resume operation Symptom checklist Symptom Check for the following Pump will not start e Boost button has not been pressed e Battery is flat check another even if the battery is new Pump has stopped before emptying e Blocked Dosing Line syringe l e Blocked Dosing Nozzle e Battery is flat 9 Nano Doser 1 user manual V1 0 13 11 2014 CONVeTFSIOmM Disclaimer of liability and warranty information 2 Year Warranty What is covered This warranty covers any defects in materials or workmanship with the product with the exceptions stated below How long coverage lasts This warranty runs for 24 months The warranty starts from date of shipping What is not covered This warranty does not cover associated damage to the aquarium any equipment or its inhabitants or damage to property Syringes are not covered under this warranty Warranty shipping costs The Customer shall be responsible for shipping costs associated with returning this product to Saltwater Conversion for warranty should it be required How to get Service Contact Saltwater Conversion at info saltwater conversion com A service representative will be i
Download Pdf Manuals
Related Search