GV55 User Manual
Contents
1. 25 mah 20107 Figure 6 Backup Battery Installation There is an internal backup Li ion battery 3 5 Switch ON the Backup Battery To use the GV55 backup battery the switch must be at the ON position Switch on the case and ON OFF position are shown below Figure 7 Switch and ON OFF position Note 1 The switch must be on the OFF position when shipped on an aircraft TRACGV55UMOOI 13 la GV55 User manual Que Ch mnk 2 When the switch is on the OFF position the battery cannot be charged or discharged 3 To reset the device Remove the external DC power and second switch off the backup battery And then supply the external power and switch on the backup battery 3 6 Power Connection PWR PIN1 GND PIN2 are the power input pins The input voltage range for this device is from 8V to 32V The device is designed to be installed in vehicles that operate on 12V or 24V systems without the need for external transformers Figure 8 Typical Power Connection 3 7 Ignition Detection Table 6 Electrical Characteristics of Ignition Detection Logical State Electrical State Inactive OV to 3V or Open TRACGV55UMOOI 4 GV55 User manual 5 NM RETES SOLUTIONS Vehicie ander sath Figure 9 Typical Ignition Detection IGN Pin3 is used for ignition detection It is strongly recommended to connect this pin to ignition key RUN position as shown up An alternative to connecting to the ignition switch2. is to find a non permanent power source that is only available when the vehicle is running For example the power source for the FM radio IGN signal can be configured to start transmitting information to backend server when ignition is on and enter power saving mode when ignition is off 3 8 Digital Inputs There are one general purpose digital inputs on GV55 They are all negative trigger Table 7 Electrical Characteristics of the digital inputs Logical State Electrical Characteristics Inactive The following diagram shows the recommended connection of a digital input TRACGV55UMOOI 15 la GV55 User manual Que Ch nk Panic button Figure 10 Typical Digital Input Connection 3 9 Digital Outputs There are two digital outputs on GV55 All are of open drain type and the maximum drain current is 150mA Each output has the built in over current and recovery PTC fuse TRACGV55UMOOI 16 GV55 User manual 5 NM RETES SOLUTIONS oa ER ee Gate 1 source 2 Figure 11 Digital Output Internal Drive Circuit Table 8 Electrical Characteristics of Ddigital Outputs Electrical Characteristics 1 5V 150mA Disable Open drain Figure 12 Typical Connection with Relay TRACGV55UMOOI 17 la GV55 User manual Que Ch mnk Figure 13 Typical Connection with LED Note 1 OUT1 will latch the output state during reset 2 All outputs are internally without pulled up to PWR pin by a di
3. o Pe FEE EE EE E E 9 Table 4 Description of 6 PIN Connections cece ee ee EE ee EE Ee ee EE ee Ee ee Ee ee EE ee ee ee ee ee 10 Table 5 GV55 User Cable Colour definitlON ee ee ee EE ee EE RE RE ee EE ee RE ee ee ee 10 Table 6 Electrical Characteristics of Ignition DetectON ees ee EE Re RE Ee ee 14 Table 7 Electrical Characteristics of the digital inputs sesse ee EE Re ee ee ee 15 Table 8 Electrical Characteristics of Ddigital Outputs sesse sees ee ee EE Ee RE ee ee ee ee ee 17 Table 9 Definition of Device status and LED iese ee ee ee Ee ee EE ee EE ee Ee ee EE ee ee ee ee ee 19 TRACGV55UMOOI 4 Gy5 Usermangal 24242020 NE ER RERO TM Figure Index FIGURE 1 APPEARANCE O GY 5 Se Ge Gee 8 FIGURE 2 THE 6 PIN CONNECTOR ON THE GV55 11 ee ee ee ee ee ee ee ee ee ee ee ee ee ee nnn nnns 9 FIGURE 3 OPENING II T T dee poese diese sd ese ed ae ei eed Sk ede ee ee 11 FIGURE 4 CEOSING ITHE CASE RE RE EE 11 FIGURE 5 SIM CARDINS TAELAFTON asses des ees ede ae Ge ede ie bes Eed bees ee ee ee ed eb Ge ke ies da 12 FIGURE 6 BACKUP BATTERY INSTALLATION esse ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee 13 FIGURE 7 SWITCH AND ON OFF POSITION esse sesse ees ee ee ee ee ee ee ee eene ee Re Ee 13 FIGURE 8 TYPICAL POWER CONNEC TION 4 Es see de ee ee cvs ode ee Ge be E 14 FIGURE 9 TYPICAL AGNETION DETECTION sissies es See SO GEN
4. A Oueciink WIRELESS SOLUTIONS GSM GPRS GPS Tracker aV 55 User Manual TRACGV55UMOO1 Revision 1 02 Designed by Queclink n TV GV55 we C 0678 me May explode d disposed of in fire met IMEI 868034001001031 x THIS SIDE TOWARDS SKY http www queclink com sales queclink com GV55 User manual 55 5 0 Teese SOLUTIONS Document Title GV55 User Manual Version 1 02 Date 2012 11 16 Status Release Document Control ID TRACGV55UMOO1 General Notes Queclink offers this information as a service to its customers to support application and engineering efforts that use the products designed by Queclink The information provided is based upon requirements specifically provided to Queclink by the customers Queclink has not undertaken any independent search for additional relevant information including any information that may be in the customer s possession Furthermore system validation of this product designed by Queclink within a larger electronic system remains the responsibility of the customer or the customers system integrator All specifications supplied herein are subject to change Copyright This document contains proprietary technical information which is the property of Queclink Limited copying of this document and giving it to others and the using or communication of the contents thereof are forbidden without express authority Offenders are liable to the payment of damages All rights res
5. C power input 8 32V GND GND 3 Ignition input positive trigger Digital input negative trigger OUT2 Open drain 150mA max 6 OUT1 Open drain 150mA max with latch circuit 2 4 GV55 User Cable Colour Table 5 GV55 User Cable Colour definition Definition Color TRACGV55UMOOI 10 GV55 User manual WIRELESS SOLUTIONS 3 Getting Started 3 1 Opening the Case Figure 3 Opening the Case Insert the triangular pry opener into the gap of the case as shown below push the opener up until the case unsnapped 3 2 Closing the Case 1 mg ia go paandup p apuna aps ME N POT sn 9190 3 2 mL ET saver OEAD Figure 4 Closing the Case TRACGV55UMOOI GV55 User manual 5 RETEST SOLUTIONS Place the cover on the bottom in the position as shown in the following figure Slide the cover against the direction of the arrow until it snapped 3 3 Installing a SIM Card Open the case and ensure the unit is not powered unplug the 6Pin cable and switch the internal battery to off position Slide the holder right to open the SIM card Insert the SIM card into the holder as shown below with the gold colored contact area facing down taking care to align the cut mark Close the SIM card holder Close the case Figure 5 SIM Card Installation TRACGV55UMOOI 12 77 GV55 User manual Ouer FK WIRELESS SOLUTIONS 3 4 Installing the Internal Backup Battery _ oO e Ji dj Xem me
6. E dee Ge Ge de N GE ei 15 FIGURE 10 TYPICAL DIGITAL INPUT CONNECTION ese esse sees ee sees ee ee ee ee ee ee ee ee ee ee ee ee ee 16 FIGURE 11 DIGITAL OUTPUT INTERNAL DRIVE CIRCUIT esse sesse se ee ee ee ee ee ese ee ee ee ee 17 FIGURE 12 TYPICAL CONNECTION WITH RELAY ees esse ee ee ee esse esse ee ee ee ee ee ee ee ee ee ee ee ee ee 17 FIGURE 13 TYPICAL CONNECTION WITH LED ees esse see ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee 18 FIGURE 14 GV55 LED ON THE CASE O See Nene 18 TRACGV55UMOOI 5 GV55 User manual 5 5 0 ETREESE SOLUTIONS Revision History 2012 11 1 1 change the internal circuit 6 TRACGV55UMOOI 6 GV55 Usermanud 5 N WORETESS SOLUTIONS 1 Introduction The GV55 is a powerful GPS locator designed for vehicle or asset tracking It has superior receiver sensitivity fast TTFF Time to First Fix and supports Dual Band GSM frequencies 850 900 1800 1900 its location can be monitored in real time or be periodically tracked by a backend server or other specified terminals The GV55 has multiple input output interfaces that can be used for monitoring or controlling external devices Based on the integrated Track protocol the GV55 can communicate with a backend server through the GPRS GSM network to transfer reports of Emergency geo fence boundary crossings low backup battery or scheduled GPS position as well as many other useful functions U
7. erved in the event of grant of a patent or the registration of a utility model or design All specification supplied herein are subject to change without notice at any time Copyright Queclink Wireless Solutions Co Ltd 2012 TRACGV55UMOOI 2 GV55User manual oo TINI TrETESS SOLUTIONS Contents Mise Su ee RR re 7 LJ SCIO DOE sod UNSEREM IUE UNI EG ES ue rane ene aa E MU NU 7 1 2 Terms and Abbreviations sesse ee KG N Ge ee ee E de se Ne dee ee se 7 LPO O ad AR RE EO O A AEA EAN N 8 PNE dy is EE N N N EE N EE 8 PAN ii ORE EE NO OR EE OE OE N EE 9 2 3 Interface De EO ENTE 9 DA EN ser Cable eU Fem 10 9 ATS WI dee NER ERR 11 3 1 Opening the Oase EER N u m 11 RO r A T Rm 11 3 3 Installing a SIM Card PCT 12 3 4 Installing the Internal Backup Battery esses 13 3 5 Switch ON the Backup Battery 49 ee 99 999 ee oes 13 3 6 Power Connection eene Ee e eee eee 14 Mb ete IDC ente Tm T T Nm 14 3 8 Digital Inputs e Qe soe esse ER se se EE oa ese dad ee RA a 15 3 9 Digital Outputs im ee Mees ees ese ese deer ale Mos 16 3 10 Device Status LED 88 2499 eR ee m 18 TRACGV55UMOOI 3 GV55 User manual oo ELEn BOUT Table Index Table 1 GV55 Protocol REISIEN CE vs use N ER RE SEE N ed Ge si ees OR ee Ge Ge ES DR SR EDE 7 Table 2 Terms and AD OIC VIGUONS os Ee GE ee ee Re N ee es T Toe
8. ode So an external flyback diode is needed when the output is connected to an inductive load 3 10 Device Status LED GOM LED GPS LED PWR LED Figure 14 GV55 LED on the Case TRACGV55UMOOI 18 GV55 User manual TREES SOLUTIONS GV55 has three status led that GSM GPS PWR led Table 9 Definition of Device status and LED Device is searching GSM network Fast flashing Device has registered to GSM network Slow flashing ON SIM card needs pin code to unlock ON GPS chip is powered off GPS sends no data or data format error Slow flashing GPS chip is searching GPS info Fast flashing GPS chip has gotten GPS info PWR No external power and internal battery voltage is OFF note 2 lower than 3 35V Ko No external power and internal battery voltage is Slow flashing External power in and internal battery is charging Fast flashing External power in and internal battery is fully ON charged Note 1 GSM LED cannot be configured 2 GPS LED and PWR LED can be configured to turn off after a period of time using the configuration tool 3 Fast flashing is about 60ms ON 780ms OFF 4 Slow flashing is about 60ms ON 1940ms OFF TRACGV55UMOOI 19
9. sers can also use GV55 to monitor the status of a vehicle and control the vehicle by its external relay output System Integrators can easily setup their tracking systems based on the full featured Track protocol 1 1 Reference Table 1 GV55 Protocol Reference GV55 g Track Air Interface Protocol The air protocol interface between GV55 and backend server 1 2 Terms and Abbreviations Table 2 Terms and Abbreviations Abbreviation Description AGND Analog Ground AIN Analog Input DIN Digital Input DOUT Digital Output GND Ground MIC Microphone RXD Receive Data TXD Transmit Data opeaker Negative opeaker Positive TRACGV55UMOOI 7 GV55 Usermanual 5 5 7T EST SOLUTIONS 2 Product Overview 2 1 Check Part List Before starting check all the following items have been included with your GV55 If anything is missing please contact your supplier Figure 1 Appearance of GV55 TRACGV55UMO001 8 GV55 Usermanual oo ETREESE SGUUTIONS 2 2 Parts List Table 3 Part List GV55 Locator 63mm 50mm 21 8mm User Cable DATA CABLE M Optional 2 3 Interface Definition The GV55 has a 6 PIN interface connector It contains the connections for power I O The sequence and definition of the 6PIN connector are shown in following figure Figure 2 The 6 PIN connector on the GV55 TRACGV55UMOOI 9 GV55 Usermanual 55 5 ETREESE SOLUTIONS Table 4 Description of 6 PIN Connections External D
Download Pdf Manuals
Related Search