HUTC-10 TRAVEL FOGGER - Contronics Engineering BV
Contents
1. 12 14V DC Ensure a stable power supply lt D CONTRONICS 7 WATER CONNECTIONS AND FLUSHING CYCLE IMPORTANT Thoroughly flush out the piping before connecting the humidifier in order to prevent installation debris from blocking the intake valve Water supply Demineralised R O water must be used for the humidifier and will provide adequate protection against bacteria The use of plain tap water will lead to faster contamination of the water tank and transducerss which will result in a shorter service life Moreover the dissolved calcium and mineral particles in ordinary tap water will be blown into the area to be humidified together with the fog droplets and will be precipitated in the area Depending on the hardness of the water this could cause a layer of dust after only a few days see also the warning on page 4 Water discharge Connect a hose with a diameter of 3 8 to the humidifier s water discharge connection point so that any excess water can be discharged from the humidifier The outlet of this hose or pipe must be free the end may not be hanging in the water The water discharge from the humidifier is unpressurised IMPORTANT The water discharge connection point on the humidifier must constitute the highest point on the water discharge channel The water discharge is not pressurised A blocked outlet could damage the humidifier 8 AIR CONNECTIONS Air supply Ensure a clean air supply without water dr2. 8 John Guest fitting Demineralised water 3 8 John Guest fitting 12 14V DC 120W 0 till 35 0 C till 35 0 C till 35 Non condensing 110 x 155 x 600 mm RVS 316L 8 kg GD 5 DISCLAIMER Contronics works continuously on the further development of its humidifiers We therefore reserve the right to modify the design construction and technology of the product at any time For this reason no claims can be made based on the data illustrations and description in this user manual Additional up to date information is available on www contronics nl 15 lt D CONTRON CS lt D CONTRON CS 0 8 144 5 5490 Sint Oedenrode engineering b v The Netherlands Telephone 31 0 413 487000 Telefax 31 0 413 473903 Website www contronics nl E mail info contronics nl
3. CD CONTRONICS HUMIDIFICATION HUTC 10 TRAVEL FOGGER USER MANUAL 18 06 2013 version 1 4 lt D CONTRON CS Contronics Engineering B V Ambachtsweg 8 5492 NJ Sint Oedenrode The Netherlands hereby declares that product HUTC 10 produced and delivered by Contronics Engineering B V is in accordance with the following CE directives EMC Directive 2004 108 EG Directive for low voltage electrical installation 2006 95 EG GD CONTRONICS Table of content A A 4 Z INTRODUCTION elin da AEAEE 5 3 SAFETY REGULATIONS scsssiscsscesscsscssisaadesnsacecsnosasesassennconssanchtiandetneaatessaanss 5 A PACKING 6 5 CONNECTIONS FUNCTIONS AND INSTRUCTIONS 6 6 ELECTRICAL CONNECTIONS cscs essccssssnssssssasacusdasesessasisctsetniesssbesindsiabacnes 7 7 WATER CONNECTIONS AND FLUSHING CYCLE 8 S AIR CONNECTIONS 8 9 SWITCHING ON AND STARTING UP FUNCTIONAL TEST 9 10 asa 10 11 REPLACING SPARE PART Seaside 10 12 MENU OVERVIEW 10 13 FACTORY SETTING AND RANGE 12 14 AE EEE k ba 13 15 TECHNICAL SPECIFICATIONS 14 lt D CONTRON CS 1 PREFACE This user manual contains the operating installation and maintenance instructions for t
4. e by means of high frequency vibrations 1 7 MHz The humidifier s air movement System ensures that these water droplets are then blown into the area to be humidified The major advantages of this humidifier are the very low energy consumption the limited amount of maintenance required and the low noise level Water quality Even though the humidifier itself can be connected to plain tap water up to 8 German hardness Contronics recommends demineralised water This will limit the maintenance of the device to a minimum and the service life of the transducer will be considerably extended This will also prevent certain substances that are contained in tap water such as calcium salts minerals and bacteria ending up in the area to be humidified Contronics has various filters available in its product range operating on the basis of reverse osmosis See also the warning on page 4 3 SAFETY REGULATIONS IMPORTANT The following measures must always be observed Always disconnect the 12V supply voltage from the humidifier before moving it and or carrying out maintenance activities Always keep the humidifier horizontal and motionless while it is in operation and for up to 2 minutes afterwards Ensure that the water is always discharged via the outlet and ensure that this is never blocked It is not necassary to mount the humidifier in level position It also works under an angle of lt 45 The humidifier may only be dismantled by au
5. e desired setting using the 4 or 4 button Press to confirm the selection Scroll using the button 4 4 to lt lt Press to leave the menu Screen display On the display the text standby appears Push the briefly and on the display appears information about 96 RH Push the set button and the mainmenu appears HYGROSTAT MENU Setting the hygrostat RH Setting the bandwith Setting the capacity Setting the maximum and minimum humidification Settintg the fan speed Modus gt hygrostat or capacity SYSTEM MENU Setting the language Setting the display contrast Setting tyhe background lighting Setting the key tone Consult the software version and return to factory settings GD 5 Push the 1 0 button to start the humidifier Start screen with text standby Hold the 1 0 button briefly Information screen RH Push the set button Main menu Hygrostat Humidity setpoint 0 99 Humidification bandwidth 1 20 Capacity 100 Minimum humidification O 100 Maximun humidification 0 100 96 Fan speed 20 100 e e EMR Hygrostat Capacity Frost protection Shutdown temperature 10 10 Battery monitor Shutdown
6. he ultrasonic humidifier HUTC 10 WARNING It is possible that bacteria could be present in the humidifier s water supply Some bacteria Legionella could be harmful to health if they are present in the aerosols that are blown out by the humidifier Through the construction and materials used Contronics has ensured that the stimulation of bacterial growth is kept to the absolute minimum In order to ensure the supply of pure water it is strongly recommended that demineralised water is used see the Contronics product range Contronics cannot be held liable for any harm caused by bacteria or micro organisms It is the responsibility of the user to regularly carry out maintenance and to check the quality of the supplied water WARNING It is possible that bacteria could be present in the humidifier s water supply Some bacteria Legionella could be harmful to health if they are present in the aerosols that are blown out by the humidifier The Travel Fogger is specially developed for humidification in mobile areas including cargo area of cool trucks containers and railway carriages The humidifier continues to work even though this experience G forces during movements The reservoir is closed Movements up to 45 from the vertical axis are allowed GD 5 2 INTRODUCTION Principle of ultrasonic air humidification Minute water droplets with a size of 1 to 3 microns are ejected above the water surfac
7. heck if a The water content is drained away b After 30 sec the remaining water is discharged from the pump c After about 1 minute the water reservoir is emptied completely disconnect the hose from the water discharge Connect the water drain and check for leakages Switch on the main supply again Put the set point in the desired position Adjust if necessary the airspeed See the menu overview on page 11 IMPORTANT If the humidifier becomes overheated it will switch off Once it has cooled down it will automatically switch on again In case of overheating an Alarm will sound and information appears on the display The following conditions could cause overheating A blockage in the air inlet A blockage in the air outlet Air intake temperature too high Water temperature too high Water discharge blocked Ambient temperature too high Ventilator speed set too low lt D CONTRON CS Low Level If the water level in the humidifier becomes too low the humidification will stop An alarm will sound and information appears on the display 10 MAINTENANCE IMPORTANT maintenance must be carried out by Contronics or an organisation authorized by Contronics 11 REPLACING SPARE PARTS Replacing the transducers The replacement of the transducers can only be done by Contronics or representatives authorised by Contronics 12 MENU OVERVIEW setings Pushon to activate the menu Scroll to th
8. oplets Air outlet The air outlet must always be extended by a 75 cm pipe to allow larger droplets to be captured Mount the outlet so that it slopes towards the humidifier to ensure that any condensed fog can flow back The connected pipe must be free from dust dirt and oil residues The length of the air outlet channel to the outlet may not exceed 3 m with a diameter that remains the same GD CONTRONICS 9 SWITCHING ON AND STARTING UP FUNCTIONAL TEST Switching on Check the following before the humidifier is switched on for the first time The humidifier is mounted All pipes are connected The water discharge channel has been connected according to the instructions The water supply has been connected according to the instructions The water piping has been flushed in order to prevent any installation debris blocking the water valve Start up and functional test Open the water valve Switch on the power check and take the following steps if Control a On the display appears the text stand by Action b Push the I O for 2 till seconds audio signal is given the appliance start Control c In about 10 seconds the reservoir is filled with water Control d Depending on the ambient air humidity the humidification will start Action e If there is no fog formed set in the menu the humidity setpoint on 9996 and the production of fog will start after a few seconds Switch the humidifier of with the I O button and c
9. thorized Contronics technicians lt D CONTRON CS 4 PACKING The HU is delivered in recyclable packaging that should be kept for re shipping the unit for maintenance activities Any shipment using other packaging could cause damage to the HU for which the manufacturer cannot be held liable It is possible that some traces of water could be found in the packaging all the functions of the HU are thoroughly tested during the quality control and for this reason some water could still remain in the HU before it is packed The package contains HU humidifier Instructions for use PVC connection to 40 mm 5 CONNECTIONS FUNCTIONS AND INSTRUCTIONS IMPORTANT The guarantee will become void if the humidifier is installed incorrectly or if it is handled in an improper manner GD 5 Connections and functions Water supply 3 8 John Guest push in fitting min 0 1 bar max 6 bar Supply voltage connection 12V Waterafdischarge 3 8 John Guest push in fitting Pushbuttons for adjustments Display omm Installation 1 Mount the humidifier in an environment with a temperature between 0 C and 35 C and humidity lt 100 2 The humidifier upright mount See mounting instructions Mounting The humidifier is attached at the top and secured at the bottom See drawing below Suspension point Secure point 6 ELECTRICAL CONNECTIONS Supply voltage
10. voltage 6 15V Hysteresis 0 2 0 2 lt lt lt Sensor settings Humidity offset 50 50 Temperature offset 50 50 lt lt lt System Language English Dutch German French LCD contrast 10 100 LCD backlight 60 Key sound on off L Start up mode on off Factory defaults yes Software version Factory service Service only Setting only available hygrostat modus Setting only available in capacity modus 11 lt D CONTRON CS 13 FACTORY SETTING AND RANGE Parameter Min Factory Unit settings Shutdown temperature 10 protection OR Battery Shutdown voltage a Humidification off set Temperature off set a LCD contrast 100 LCD background light LA N wl a a S o ole 12 CONTRONICS 14 o o 5 10 ueioiuuoe leuaelul nes 2 O LE lt SeA dn BuiuseA jo doup ppy ou 1sn py ou 191uu9e BU 66 oldn julodjes asie
11. y ueloludoel 10 uoneoyipiunu ou ng Ayajoe 919 S sok amp sunu eu sok LSum 941 sok se JeuBiu yulodjas SeA Ane OY ou Ajddns jeje M By Ay p edid Jaye oyu S ol eunssejd jeje M dej lddns f E Rn dey eu uedo jddns 5 ueioiuuoe NInsuoD y 4 sok Buiuus 97 eui SI ou Lpeloeuuoo y jou seop 13 lt D CONTRON CS 15 TECHNICAL SPECIFICATIONS Transducer frequency Maximum capacity Service life of the transducers Size of the water droplets Diameter of the outlet flange Airflow Outlet pipe length Water pressure Water connection Maximum water hardness Water discharge Mains voltage Power consumption Ambient temperature Water temperature Air temperature Ambient temperature compared to supply ait temperature Dimensions LxWxH Housing Weight 14 1 7 MHz 0 0 8 kg hour adjustable 10 000 20 000 hour 1 3 micron 1x40 mm Adjustable 3 meter 0 1 6 bar 3
Download Pdf Manuals
Related Search