Honeywell Trendview V5 Replacement/Upgrade Instructions, 43
Contents
1. all non volatile data Ensure all set ups data and layouts are saved Failure to comply with these instructions may result in product damage Figure 1 Rear view showing battery holder Battery holder Battery to be fitted with the positive end outermost 43 TV 33 42 GLO Issue 2 03 04 UK Battery Fitting It is advisable to replace the battery when the recorder is powered down however this is not essential It is important to observe antistatic precautions and hazardous voltage levels being aware of wires carrying voltage within the recorder if the power is still on The battery holder is located on the rear of the recorder it has a circular plastic cover that has a push and twist method of fitting and removal See Figure 7 on page 2 The battery will pop up as soon as the cover is removed To fit the battery there is a positive sign stamped on the inside of the battery cover This is to indicate correct orientation when inserting the battery The positive end of the battery should be pointing outermost for connection with the inside of the cover See Figure 1 on page 2 Drop the new battery into the slot place the cover on top and pus down to locate with the slots in the unit Twist the cover a 1 4 turn to secure A WARNING HAZARDOUS VOLTAGE LEVELS Voltage levels above 30V rms and 42 4V peak or 60V dc are deemed to be Hazardous Live Refer to Battery Data on page 3 for further informat2. 3 2 Thionyl Chloride 7719 09 7 Aluminium Chloride 1446 7 0 e e S C a S ES a a a C a a a w f o l om wer et o o pre wee fet Hazard Identification and Disposal considerations A WARNING HAZARDOUS CONTENTS e Fire explosion and severe burn hazard Do not recharge disassemble heat above 100 C incinerate or expose contents to water e Dispose by incineration or burial at permitted waste treatment and or disposal sites Failure to comply with these instructions could result in death or serious injury 43 TV 33 42 GLO Issue 2 03 04 UK 4
3. Installation Instructions 100mm Key Recorder Battery Replacement Kit Ez 3 6V Battery Kit number LO05201010 S Battery Function With the battery switched on and the recorder power off the battery will last 6 8 months with the battery and recorder power on the battery should last for up to 10 years The battery backs up the setup the realtime clock and any data not stored to disk If the battery becomes exhausted the realtime clock setups and any data will be lost in a power down situation NOTICE BEWARE LOSS OF INFORMATION The realtime clock setups and any data will be lost if the battery is exhausted and the recorder is powered down Ensure all setups data and layouts are saved Battery Replacement Recorders built before July 2002 have an internal battery that is soldered in place and is not easily replaceable If you have a recorder with an internal battery fitted the recorder must be returned to your supplier for replacement For recorders built after July 2002 it is not necessary to remove the rear panel to replace the battery Removing the case and opening the back of the recorder should only be performed under the following circumstances e When an item of hardware requires individual replacement e When an item of hardware is to be retrospectively fitted In all other instances it is recommended that the complete unit be returned for service to an authorised agent or service centre Before atte
4. ion Failure to comply with these instructions could result in death or serious inj A CAUTION BATTERY FITTING PRECAUTIONS This battery must be replaced by an experienced technician Failure to comply with these instructions may result in product damage NOTICE This battery is not a standard 1 5V AA cell Refer to Battery Data on page 3 for recommended manufacturers Battery Data NOTICE Handling Precautions The material in this section may only represent a hazard if the integrity of the bat tery is compromised or if the battery is physically or electrically abused For replaceable batteries fitted in recorders from July 2002 For recorders built before July 2002 refer to the User manual 43 TV 33 42 GLO Issue 2 03 04 UK 3 Identification Recommended manufacturer e 3 6V Tadiran Electronic TL5104 USA order number batteries x 5 L005201010 S Type Inorganic Lithium Battery SL360 S Typical Capacity mAh 2300 mAh Weight g 18g Chemical System Li SoCl2 Voltage 3 6V Chemistry System Lithium Thionyl Chloride Anode Lithium metal Cathode Liquid Thionyl Chloride Composition Information on Ingredients NOTICE Handling Precautions The material in this section may only represent a hazard if the integrity of the bat tery is compromised or if the battery is physically or electrically abused Substance CAS No Approx percent nazara R phrases of total weight symbol Lithium metal 7439 9
5. mpting any maintenance on a recorder it is advisable to clear a suffi cient work space so components such as the front panel can be rested on the work surface without getting scratched or damaged A CAUTION BATTERY FITTING PRECAUTIONS This battery must be replaced by an experienced technician Failure to comply with these instructions may result in product damage 43 TV 33 42 GLO Issue 2 03 04 UK 1 A WARNING HAZARDOUS VOLTAGES Disconnect all power to the recorder before removing the case and attempting any main tenance procedures SAFETY TESTS Upon completion of service procedures detailed in this manual two basic safety tests should be performed in order to ensure continued safe operation of the instrument 1 Earth Resistance 25 Adc applied between case and protective earth bonding resistance should be lt 0 1 Ohm 2 Insulation Resistance 500Vdc applied between the earth terminal and the live and neutral terminal shorted together insulation resistance to be gt 2 0 MOhm Mega Ohm NOT milli Ohm Failure to comply with these instructions could result in death or serious injury A CAUTION OBSERVE ANTI STATIC PRECAUTIONS Refer to BS EN1000151 1992 Basic specification Protection of electrostatic sensitive devices Full anti static precautions MUST be observed when in contact with the electronics of your recorder SAVE DATA amp SETUPS Removal of PCBs and battery back up will result in the loss of
Download Pdf Manuals
Related Search