USER MANUAL
Contents
1. Seat Cushion Ledge Extra Positioning Wedges Kit 1 8 Adjustability and Specifications Adjustability Seat Depth 6 5 15 17 38cm Seat Width 8 14 20 36cm Lower Leg Length 8 17 20 43cm Back Height 11 19 28 49cm Hip Angle Adjustment 90 120 Tilt Adjustment 0 45 Specifications Monty ame waste 2256 135 Rear Tire Diameter 16 41cm Folded Dimensions 36 x 20 x 25 92 x 51 x 64cm Reversing Width 33 5 85cm Page 7 User Manual TRAK User Manual Section 2 Warnings Read this Manual Completely Before Using All caregivers and or attendants must read this user manual prior to operating the Trak chair Familiarize yourself with the handling and functions of the product prior to actual use If there is any information in this manual that you do not understand please contact your authorized Leggero provider for assistance Failure to follow instructions or comply with warnings within this manual could result in personal injury and or damage to the Trak chair potentially voiding the warranty Symbols Used on Product Warning Labels and in User Manual WARNING The word WARNING or this symbol indicate practices that are unsafe or dangerous and could result in serious injury to the occupant and or caregiver WARNING READ INSTRUCTION MANUAL Choose The Right Chair amp Safety Options In the mobility industry there are several options available to2. Ww Page 18 TRAK 4 14 Seat Extension Installation If your Trak chair was originally configured with a seat depth of 8 inches or less you will need to install the seat depth extension and longer seat tubes supplied with the chair to increase the seat depth beyond 9 inches 1 Remove seat cushion 2 Remove seat depth adjustment knob and carriage bolt 3 Remove front seat plate assembly 4 Install seat extension 1 using 4 socket head bolts 2 5mm hex wrench required Reference Figure 24 5 Remove short seat tubes 3 from front seat assembly 4mm hex wrench and 10mm wrench required Reference Figure 25 6 Install long seat tubes 4 with same hardware Reference Figure 26 7 Install front seat plate assembly and adjust to desired seat depth 8 Install carriage bolt and tighten knob 9 Install seat cushion and tighten straps Page 19 User Manual D MIS N up Figure 26 TRAK User Manual 4 15 USING THE TRAK CHAIR AS A SEAT IN A MOTOR VEHICLE The Trak Chair is approved for transporting children in motor vehicles when it is equipped with the OPTIONAL transit feature and used in accordance with these instructions The chair must be secured in a forward facing position with a Wheelchair Tie down and Occupant Restraint System WTORS which meets the requirements of SAE J2249 Recommended Practice Wheelchair Tie down and Occupant Restraint Systems For Use in Motor Vehicles IMPORTANT IN
3. Section 19 4 9 2 4 9 5 and 5 2 that have been dynamically tested in accordance with Annex A amp 5 3 of the same should be used on the chair for use as a restraint in a motor vehicle Figure 27 WARNING If your chair is not equipped with the transit option do not use it as a seat in a motor vehicle Transfer the child from the chair to an approved motor vehicle seat Page 20 TRAK User Manual 4 16 Respond Seating Respond Seat Cushion 1 Ischial inserts 1 are available in different foam types and densities 2 The ischial ledge 2 is adjustable front to back 3 Adduction abduction wedges 3 are adjustable in width angle and position front to back 4 Wedges 4 can be used to provide proper support for smaller occupants Figure 29 Respond Back Cushion 1 Respond back cushion features dual density back pad and shoulder pads 2 Can be configured with optional components such as wedges or lumbar supports from the Extra Positioning Kit Configure based on individual child s needs Lumbar Support Figure 30 Page 21 Ww TRAK User Manual Section 5 Limited Warranty A THIS WARRANTY IS EXTENDED ONLY TO THE ORIGINAL PURCHASER OF OUR PRODUCTS B FOR LIFETIME Leggero LLC warrants the frame and quick release axles of this chair against defects in materials and workmanship for the life of the original purch
4. 9 If chair is equipped with pneumatic tires check tire pressure Tire pressure should be Ang 35 PSI 240 kPa 6mm Hex Wrench Figure 1 aR WN A WARNING Please keep packaging material away from children Discard all plastic packaging material immediately after unpacking Figure 3 Page 11 Ww TRAK User Manual Section 4 Operation and Adjustment Tools Required 4mm Hex Wrench 5mm Hex Wrench 4 1 Wheel Lock Operation 1 To engage wheel lock push down on crossbar Reference Figure 4 2 Verify wheel locks are engaged on each side by slightly moving chair front to back 3 To disengage wheel lock push forward on top of crossbar U bend Reference Figure 5 Ww Page 12 TRAK User Manual 4 2 Handlebar Angle Adjustment 1 Press and hold buttons on outside of each adjustment ratchet reference Figure 6 2 Adjust handlebar to desired angle 3 Release buttons 4 3 Knee Angle Adjustment 1 Press and hold buttons on outside of each adjustment ratchet reference Figure 7 2 Adjust knees to desired angle 3 Release buttons DEA gt 4 4 Hip Angle Adjustment 1 Engage wheel locks 2 Pull back left and right hip angle adjustment mechanisms reference Figure 8 3 Adjust hip angle to desired position 4 Make sure hip angle position is properly engaged Test by applying upward and downward force on the handlebar WARNING While chair is occupied nev
5. a Ww USER MANUAL CHAIR PROVIDER THIS MANUAL MUST BE GIVEN TO THE USER OF THIS DEPENDENT MOBILITY BASE USER READ THIS MANUAL BEFORE USING THIS DEPENDENT MOBILITY BASE AND SAVE FOR FUTURE REFERENCE Product delivered may vary from the one described and pictured in this manual Revision 15 0729 TRAK User Manual You have made a great choice for your child by choosing a Leggero chair We believe that every child should be able to function to the best of their ability We welcome questions and comments about our products and services Please contact us or an authorized provider using the information below Leggero 174 D Shepherd Trail Bozeman MT 59718 Toll Free 1 844 503 KIDS www leggero us Authorized Leggero Provider Ww Page 2 TRAK Table of Contents Section 1 Introduction amp Features 1 1 1 2 1 3 1 4 1 5 1 6 1 7 1 8 Introduction Intended Trak User Intended Trak Attendant Terms of Warranty Service amp Repairs Features Seating amp Positioning Components Adjustability amp Specifications Section 2 Warnings Section 3 Unpacking Trak Chair Section 4 Operation and Adjustment 4 1 4 2 4 3 4 4 4 5 4 6 4 7 4 8 4 9 4 10 4 11 4 12 4 13 4 14 4 15 4 16 Wheel Locks Handlebar Angle Adjustment Knee Angle Adjustment Hip Angle Adjustment Tilt Adjustment Folding and Unfolding Footbed Height Adjustment Footbed Angle Adjustment Back Height Adjustment
6. in back plate Reference Figure 18 4 Reinstall back cushion Figure 18 Ww Page 16 TRAK User Manual 4 10 Seat Depth Adjustment Loosen seat cushion straps Loosen knob under center of seat plate Adjust front seat assembly to desired depth Tighten knob Tighten seat cushion straps DI ND i 4 11 Armrest Adjustment amp Removal 1 To adjust height push in button 1 and adjust armrest up or down Release button to lock in place 2 To remove armrest push in button 1 and pull armrest assembly upward out of receiver 3 Toreinstall push armrest back in until it clicks into place Adjust downward if needed 4 To adjust angle pull plunger 2 outward and rotate front of armrest downward Release plunger and ensure that it locks into position Figure 20 Page 17 W7 TRAK User Manual 4 12 Positioning Tray Use 1 Adjust armrests tray receivers to desired angle 2 Swing left and right tray cam locks downward Reference Figure 21 3 Slide tray into receivers and adjust to desired depth 4 Swing left and right tray cams upward to lock in place Reference Figure 22 4 13 Caster Swivel Locks 1 Align each caster parallel to side of chair 2 Pull plunger up and rotate 90 3 Release plunger Verify that swivel lock is engaged by applying light twisting force to caster fork 4 To unlock pull plunger up rotate 90 and release _ A k A Locked Figure 23
7. two people for lifting to prevent injury and damage to the chair WARNING Please keep packaging material away from children Discard all plastic packaging material immediately after unpacking WARNING If your chair is not equipped with the transit option do not use it as a seat in a motor vehicle Transfer the child from the chair to an approved motor vehicle seat If your chair is equipped with the transit option refer to the section 4 15 in this manual WARNING The chair must be inspected and maintained per the chart in Section 6 Maintenance Problems detected must be repaired prior to resuming use of the chair WARNING Many of the fasteners used to construct the Trak chair consist of a bolt with a nut that contains a nylon lock ring These connections must be maintained and secured with the original equipment fasteners and properly adjusted For proper adjustment of pivot points consult your authorized service provider Ww Page 10 TRAK User Manual Section 3 Unpacking the Trak Chair Remove chair from packaging Discard all plastic packaging materials Install front casters reference Figure 1 Install rear wheels reference Figure 2 Check for proper adjustment of quick release axles by pulling outward on wheel Wheel should hold in place 6 Engage wheel locks reference section 4 1 of this manual 7 Install anti tips reference Figure 3 8 Unfold frame and seat back reference Section 4 6 of this manual
8. 11 arrows indicate potential pinch points Pull Hip Angle Mechanisms Push Tilt Lever with Foot 4 7 Footbed Height Adjustment Optional Angle Adjustable Footbed 1 Loosen bolts on inside of clamps with 4mm hex wrench 2 bolts per side Reference Figure 13 2 Adjust footbed to desired height 3 Tighten bolts Standard Height Adjustable Footbed 1 Loosen bolts nuts on clamps with 4mm hex wrench and 10mm wrench 2 bolts nuts per side Reference Figure 14 2 Adjust footbed to desired height 3 Tighten bolts nuts Figure 14 Page 15 TRAK User Manual 4 8 Footbed Angle Adjustment Optional Angle Adjustable Footbed Only 1 Grab center of adjustment bar and pull rearward Reference Figure 15 2 Rotate footbed to desired position 3 Release adjustment bar 4 Check that adjustment bar is fully engaged in footbed slot by lifting up and pushing down on front of footbed 4 9 Back Height Adjustment 1 Pull back height adjustment levers outward reference Figure 16 2 Adjust back height to desired position 3 Push back height adjustment levers inward until they snap into locked position Unlocked To adjust back height higher than 17 it will be necessary to adjust the pack plate position 1 Remove back cushion 2 Remove bolts that attach back plate to cross tube with 4mm hex wrench and 10mm wrench Reference Figure 17 3 Reinstall plate with bolts through lower holes
9. FORMATION This chair conforms to and has been dynamically tested in compliance with ANSI RESNA WC Vol 1 Section 19 5 3 Please contact Leggero or your authorized Leggero provider if you have any questions regarding use of the chair for seating in a motor vehicle Contact information can be found on page 2 of this manual WARNINGS amp INSTRUCTIONS e The Trak chair must be used as indicated in these instructions and the instructions supplied by the vehicle mounted tie down manufacturer e Chair occupant should be transferred to the vehicle seat and use the vehicle restraint system whenever possible e The Trak Chair can accommodate up to 80 Ib Do not exceed this occupant weight e The Trak Chair must be placed in a forward facing position when used as a seat in a motor vehicle Use an approved 4 point strap type tie down system for the chair Use an approved 3 point belt for occupants over 501b 23kg For occupants under 50Ib 23kg a 5 point transit harness is required e For approved transit tie down locations and location of belt narness attachment pin see Figures 27 and 28 e Restraints must not be held away from the child s body by chair components or accessories e Belt and harness straps should be adjusted until they are snug and do not have slack If you can pinch the webbing of the harness or belt straps between your fingers then the harness is too loose e Only belt restraints that comply with the provisions of ANSI RESNA WC Vol 1
10. ING Never leave your child unattended in the chair even if they are strapped in and the wheel locks are engaged WARNING If the chair occupant reaches for objects in front to the side or behind the chair be sure that they do not lean too far The shift in the center of gravity might cause the chair to tip over WARNING If equipped with pneumatic tires the handling of the chair is influenced by tire pressure Correctly inflated tires considerably improve its maneuverability Front and rear tire air pressure should be at least 35 PSI 240 kPa WARNING Be aware that with certain footrest settings the footrest can collide with the front casters WARNING Do not stand on the footplate when transferring into or out of the chair WARNING While chair is occupied never attempt to adjust hip angle and tilt angle simultaneously Adjustment of hip angle while tilting chair could result in chair moving into partially folded state which could injure the occupant WARNING When folding the chair be aware that there is a risk of injury through fingers becoming crushed or trapped Reference section 4 6 of this manual for further information WARNING The chair is only intended to carry one child at a time Do not carry more than one child at a time WARNING Only lift the chair by parts that are solidly attached The chair should be lifted by the side frame members whenever possible If folded hold the chair by the lower side frame tubes Always use
11. Seat Depth Adjustment Armrest Adjustment and Removal Positioning Tray Use Caster Swivel Locks Seat Extension Installation Using the Trak as a Seat in a Motor Vehicle Respond Seating Section 5 Limited Warranty Section 6 Maintenance and Maintenance Record Page 3 Page Oo N O dl A A A A N N N N a Ax x o A A A gt Q N gt O O N N O Q a A FBP 0 OO W N N gt User Manual TRAK User Manual Section 1 Introduction Warnings amp Features 1 1 Introduction Thank you for selecting the Trak chair This manual explains how to operate adjust and maintain your Trak chair The product as described is subject to technical alterations without notice We are sorry that we cannot offer this user information in a format appropriate for use by visually impaired people The visually Impaired must contact an authorized Leggero provider to obtain information and instruction in the form of verbal communication and hands on training if necessary 1 2 Intended Trak User Rehab pushchairs and pediatric positioning systems are appropriate for children who are limited to a seated position and require mobility and positioning assistance Individuals who need such assistance can have a wide variety of diagnosis limiting their ability to achieve mobility without such a system For maximum occupancy rating and additional specifications reference section 1 7 of this manual 1 3 Intended Trak Attend
12. UFACTURER WILL DO Our sole liability is to repair or replace covered parts This is the exclusive remedy for consequential damages F WHAT YOU MUST DO 1 Obtain from us while this warranty is in effect prior approval for return or repair of covered parts 2 Return the product or part s freight pre paid to Leggero LLC Contact Leggero customer service at 1 844 503 KIDS for a return address and to obtain a return authorization number RA 3 Pay the cost of labor to repair remove or install parts G NOTICE TO CONSUMER 1 If allowed by law this warranty is in place of any other warranty written or oral express or implied including a warranty of merchantability or fitness for a particular purpose 2 This warranty gives you certain legal rights You may also have other rights that vary from state to state Ww Page 22 TRAK User Manual Section 6 Maintenance Please consult your authorized provider if you have questions regarding maintenance of your Trak chair Consistent and thorough maintenance will extend the useful life of your chair Improper maintenance can significantly decrease the useful life of the chair Any damaged parts should be replaced prior to resuming use of the chair The chair should be cleaned regularly and should be serviced by an authorized dealer at least once per year Warranty might be affected if proper maintenance is not performed at the specified intervals Please see table below for recommended maintena
13. ant Attendants who operate the chair must be visually mentally and physically capable of safely operating the chair under all circumstances Attendants must read and follow all instructions provided in this manual 1 4 Terms of Warranty Warranty applies only when the product is used in concordance with the manufacturer s recommendations and for the intended purposes and specified conditions of the product 1 5 Service and Repairs Service and repair of the Trak chair should be performed only by Leggero authorized providers Should any problems arise please contact the provider that supplied the chair Authorized providers only replace and install original Leggero spare parts W7 Page 4 K User Manual 1 6 Features e ni amp Weather Shade Hip Reale di 97 Adjustment Handlebar Angle Adjustment Rear Storage Pocket Calf Protector Ta LAM ETE Lip _ OEE Za Quick Release Ns Rear Wheels Angle Adjustable Legrest Anti Tips Curb Assist Lever Hub Lock Lever Serial Number Label Cae Page 5 XA TRAK User Manual 1 7 Seating amp Positioning Components Ischial Inserts Choose One Adjustable Ischial Ledge PU Foam Op Contour Wedges L ez Hip Width Wedges Respond Back Cushion Respond Seat Cushion See Section 4 16 for Detailed Information See Section 4 16 for Detailed Information Hook Loop Ca Wedges
14. aser The expected life of this frame is five years C FOR ONE 1 YEAR We warrant all original equipment parts and components of this chair against defects in materials and workmanship for one year from the date of the first consumer purchase D LIMITATIONS 1 We do not warrant e Tires tubes upholstery push handle grips or armpads Damage resulting from neglect misuse or from improper installation or repair Damage resulting from transit use Damage from exceeding the weight limit indicated on the serial number label 2 This warranty is valid only when the product is used according to the specified conditions and the intended purposes following all manufacturer recommendations It is void otherwise 3 This warranty shall not apply to problems arising from normal wear and such evaluation will be solely determined by Leggero LLC 4 This warranty is void if the product is modified without Leggero s express written consent including but not limited to modification through the use of unauthorized parts or attachments products damaged by reason of repairs made to any component without specific consent of Leggero or to a product damaged by circumstances beyond Leggero s control and such evaluation will be solely determined by Leggero 5 This warranty is void if the original serial number is removed or altered 6 This warranty applies in the USA only Check with your supplier if international warranties apply E WHAT MAN
15. er attempt to adjust hip angle and tilt angle simultaneously Adjustment of hip angle while tilting chair could result in chair moving into partially folded state which could injure occupant Page 13 TRAK User Manual 4 5 Tilt Adjustment 1 Engage wheel locks 2 Place both hands on handlebar 3 Using your foot push down on tilt adjustment lever 4 Adjust seat tilt angle to desired position 5 Release foot lever 6 Before releasing handlebar push up and down to ensure that seat frame is securely locked into position Figure 9 WARNING While chair is occupied never attempt to adjust hip angle and tilt angle simultaneously Adjustment of hip angle while tilting chair could result in chair moving into partially folded state which could injure occupant 4 6 Folding and Unfolding 1 Engage wheel locks 2 Pull back on hip angle adjustment mechanisms and hold 3 Use foot to push down tilt adjustment lever 4 Push handlebar forward 3 until chair folds 5 To unfold grab handlebar and pull backrest rearward until the seat frame locks into position 6 Engage the back assembly into the most upright hip angle position 7 Adjust to desired tilt position 8 Adjust to desired hip angle position ITS Uh Figure 10 TRAK User Manual 4 6 Folding and Unfolding Cont WARNING When folding or unfolding keep arms hands and feet clear of moving components to avoid injury Reference Figure
16. meet the needs of children Make sure that your and your provider s choice of chair and other options takes into account your child s comfort positioning physical limitations and hazards that may be encountered during daily use Ww Page 8 TRAK User Manual Warnings Failure to Follow These Warnings Could Result in Serious Injury or Death WARNING All caregivers and or attendants must read this user manual prior to operating the Trak chair Familiarize yourself with handling and functions of the product prior to actual use If there is any information in this manual that you do not understand please contact your authorized Leggero provider for assistance WARNING Non conventional use and or handling of the product can be dangerous The pushchair is not suitable for jogging running skating or similar activities Swiveling front wheels can wobble at higher speed and can cause a sudden stop and tip over of the chair Use the pushchair only at regular walking speed Under no circumstance should you let go of the handlebar while pushing Do not ever push the chair away WARNING The initial set up of this pushchair must be performed by a qualified technician WARNING Procedures other than those described in this manual must be performed by a qualified technician WARNING The weight carried by the Trak chair must not exceed the total weight limit of 80Ib 36kg Maximum occupant weight plus weight of accessories and or items car
17. nce procedures and frequency There is a maintenance record on the following page of this manual that should be used to document maintenance activities Maintenance Activity Weekly Monthly Check tire air pressure if applicable Check wheels and tires for wear or damage Check wheel lock function and clean wheel lock rotors Check for proper caster alignment Verify that all fasteners are tight Verify that quick release axles function properly Check tilt lock mechanism for proper engagement Check recline lock mechanism for proper engagement Check all structural components for wear or damage Check all accessory components for damage We recommend that the chair be cleaned regularly Clean all frame components and plastic parts using mild detergents only Fabric parts may be washed If using a washing machine put them in a linen bag or pillow case Air dry In most cases wiping with a damp cloth is sufficient Do not use your chair in salt water as severe damage may result Keep sand or other particles from damaging the wheel and caster fork bearings Page 23 WT TRAK User Manual Maintenance Record Service Provider Technician Description of Service AIN Legg a 4 D ro Page 24 Page 25 Ad Leggero Leggero LLC 174 D Shepherd Trail Bozeman MT 59718 Toll Free 1 844 503 KIDS www leggero us
18. ried WARNING Adjustments made to the chair may affect stability increasing the risk of tipping Adjustments must be made by your authorized Leggero provider WARNING Avoid getting the chair wet or storing the chair in damp environments Excess moisture can cause rust or corrosion which can result in component failure If the chair is exposed to moisture dry thoroughly WARNING Do not leave the chair or child in the sun or near other heat sources since the surfaces on the chair may reach temperatures capable of burning the child Do not leave the chair or child outside in cold temperatures because contact with a chair in temperatures below freezing could result in injury Damage to the chair may also result from exposure to extreme hot or cold temperatures WARNING The chair should only be used on solid and level ground Do not attempt to push the chair over or into obstacles Always remove the child from the chair when lifting chair to clear obstacles WARNING Do not use the chair on slopes steeper than 5 degrees Do not leave the chair parked on a slope or an incline Pay particular attention when on slopes and inclines to prevent the child from falling out of the chair the chair from tipping over or the chair from rolling away WARNING Before leaving the chair and before getting into and out of it always engage the wheel locks Do not use the wheel locks to stop the chair while moving Page 9 W7 TRAK User Manual WARN
Download Pdf Manuals
Related Search