User Manual
Contents
1. Moen ExactTemp Part No 1167458 lI Invacare Recessed Whirlpool Tubs 3 OVERVIEW 3 4 Minimum Floor Space Clearance Requirements Models 3752G or 3802G I2 K 4 I 1 1 2 TUB LENGTH 3 21 HOT AND COLD WATER STUBS 7 115VOLTPUMP HOOKUP THIS END 3752G OR 3802G RECESSED TUB ALLOW FORA 40 DOOR SWING Tops ke Invacare Recessed Whirlpool Tubs Part 1167458 3 OVERVIEW 3 5 Dimensions Models 3752G or 3802G 41 1 2 3 4 Cold water stub with recommended shut off valve 2 Drain floor drain recommended 115V AC 60 Hz 15 A Input r mio o 3 4 Hot water stub with recommended shut off valve Allow for 40 door swing 60 for wheelchair or lift access Part No 1167458 13 Invacare amp Recessed Whirlpool Tubs 4 INSTALLATION 4 Installation A WARNINGS Check all parts for shipping damage In case of damage DO NOT use Contact the carrier for further instruction The installation area MUST be able to support the 66 pounds per square inch 45 n cm load capacity of the tub Otherwise injury or damage might occur Access for servicing the tub MUST be provided Install the tub in a location that will permit access to the service panels plumbing and electrical hookups CAUTIONS DO NOT lift the tub by the plumbing DO NOT modify2. Invacare Model 37526 Invacare Model 3802G Recessed Whirlpool Tubs User M anu al DEALER This manual MUST be given to the user of the product USER BEFORE using this product read this manual and save for future reference CONTENTS Unnn M 4 Symbols and Signal E 4 Limited Warranty eC 5 2 SAFETY General ECII Ice 6 Important Safety Information oett terere rel Eee ees e eae s cesa bye etg aene ob ede edat enda abre 6 3 OVERVIEW 8 Features Product Labeling 10 11 Minimum Floor Space and Clearance 12 Dimensions ee E RE RN NR ER ce e seca 13 4 INSTALLATION 14 Preparing the Work Area ies o ei eR 15 Electricaland Pl mbirig Hook up Locations tette peteret A CER De ti re eee etu Xe S DU Dn ed esta l6 Electric l Install
3. 5 5 Water Temperature Setting WARNING A The causes symptoms and effects of hyperthermia may be described as follows Hyperthermia occurs when the internal temperature of the body reaches a level several degrees above the normal body temperature of 98 6 F The symptoms of hyperthermia include an increase in the internal temperature of the body dizziness lethargy drowsiness and fainting The effects of hyperthermia include Failure to perceive heat Failure to recognize the need to exit the spa or hot tub e Unawareness of impending hazard Fetal damage in pregnant women Physical inability to exit the spa or hot tub e Unconsciousness resulting in the danger of drowning e The use of alcohol drugs or medication can greatly increase the risk of fatal hyperthermia Flow Water Thermometer measures the temperature of water coming from the tub fill spout or shower massage wand Water Temperature Control Valve sets and maintains constant temperature for all incoming water o X Flow Water Thermometer Hot RED Cold Blue Water Temperature Control Valve Invacare Recessed Whirlpool Tubs 26 Part 1167458 5 6 5 OPERATING INSTRUCTIONS Filling Tub DANGER RISK OF SCALDING AN Check that the water temperature is between 95 and 105 F 35 C and 41 C to avoid scalding the resident Monitor the incoming water temperature on the flow water thermometer ALWAYS hand test the incoming water temperature and the wat
4. 9 5 2 Make sure that the tub has been cleaned disinfected and BEFORE use Refer to Cleaning and Disinfecting on page 21 Open the tub door Transfer the resident to the tub Use the waist strap to help stabilize the resident in the tub as necessary Refer to Waist Strap on page 25 Fill the tub Bathe the resident Drain the tub Remove the waist strap if used Open the door Transfer the resident from the tub Clean and disinfect the tub including the door seal and waist straps Cleaning and Disinfecting WARNINGS A Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the tub DO NOT clean or disinfect the tub when it is occupied Otherwise injury may occur Read and understand ALL information on disinfecting BEFORE use ALWAYS wear rubber gloves an apron and a face shield when using disinfectant In case of eye or skin contact follow procedures on the disinfectant container CAUTION A NEVER use abrasive cleaners like scouring powder or liquid cleaners containing pumice stone The use of these types of cleaners will make the gel coat finish of your tub scratched and dull NEVER use cleaners containing lodine Household Bleach Bromine Betadine or Methylene Blue The use of these types of cleaners will cause the tub to stain Use of unapproved cleaners will dry out the rubber seals and gaskets and the tub will not function properly Part 1167458 21 Invacare amp Recessed Whirlpool
5. H 30 hMEIUsacieMiUls Q 3l Part No 1167458 3 Invacare amp Recessed Whirlpool Tubs GENERAL General 1 1 Symbols and Signal Words Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage See the information below for definitions of the signal words DANGER Danger indicates an imminently hazardous situation which if not avoided will result in death or serious injury WARNING Warning indicates a potentially hazardous situation which if not avoided could result in death or serious injury CAUTION Caution indicates a potentially hazardous situation which if not avoided may result in property damage or minor injury or both IMPORTANT Indicates a hazardous situation that could result in damage to property if it is not avoided Gives useful tips recommendations and information for efficient trouble free use Invacare Recessed Whirlpool Tubs 4 Part 1167458 GENERAL 1 2 Limited Warranty PLEASE NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to the original purchaser user of our products This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state Invacare Continuing Care Inc ICC 1 warrants
6. ON 3752G AND 3802G DIMENSIONS IN INCHES Height of Motor Electrical Input 115V AC 60 Hz 15A plug Height of 4 inch Hot Water Stub with Recommended Shut Off Valve Height of 4 inch Cold Water Stub with Recommended Shut Off Valve Height of 2 inch Drain Pipe Center from Floor Distance of End of 2 inch Drain Pipe from Right End of Tub Distance of 4 inch Hot Cold Water Stubs with Recommended Shut Off Valves from Front of Tub Distance of End of 2 inch Drain Pipe from Front of Tub Invacare amp Recessed Whirlpool Tubs 16 Part No 1167458 4 INSTALLATION 4 3 Electrical Installation DANGERS ELECTRICAL SHOCK HAZARD Grounding is required The installation and maintenance of the tub MUST be done by a qualified technician certified electrician or plumber Disconnect electrical supply or turn off circuit breaker before installing or performing any maintenance on the tub The National Electric Code requires the use of a ground fault circuit interrupter on all therapeutic pools and tubs hydro therapeutic tanks Failure to follow this requirement could result in serious or fatal injury Use a 15 AMP GFCI breaker only Be certain ALL electrical work is performed by a qualified electrician and is in compliance with local electrical codes ALL electrical connections MUST be water resistant WARNINGS The unit MUST be connected only to a supply circuit that is protected a ground fault ci
7. Stream Pulse Massage A Shower Spray A Mixture of Shower Spray and Pulse Massage Flow Control serves as a volume control and water saver The use of the Flow Control permits the reduction of water flow without the need for readjustment of water temperature during bathing A trickle of water through the Flow Control when in the closed position is normal 5 8 Using the Whirlpool Function If the water level does not cover the whirlpool jets push the tub fill button to auto fill the tub 2 After the water level covers the whirlpool jets and after bathing the resident add Invacare Defoamer to the bath water Refer to the Defoamer bottle for directions Push the whirlpool button to start whirlpool jets After use press the whirlpool button again to stop the whirlpool jets Drain the tub completely Transfer the resident from the tub Oy ur ot Clean and disinfect the tub including the door seal Refer to Cleaning and Disinfecting on page 21 Part No 1167458 28 Invacare amp Recessed Whirlpool Tubs 6 INSPECTION AND TROUBLESHOOTING 6 Inspection and Troubleshooting If any part of the system is not functioning properly DO NOT use the system For parts and technical service information please contact ICC Technical Service at 800 668 2337 Extension 2 6 1 Safety Inspection Checklists Every six months or as necessary have a qualified technician perform a thorough inspection and servicing Routine m
8. THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS CONTAINED HEREIN THE APPLICATION OF ANY IMPLIED WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN THE MANUFACTURER SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE PROVINCIAL LAWS AND REQUIREMENTS Part No 1167458 5 Invacare amp Recessed Whirlpool Tubs 2 SAFETY 2 Safety The Safety section contains important information for the safe operation and use of this product 2 General Guidelines WARNING AN DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner s manuals service manuals or instruction sheets supplied with this product or optional equipment If you are unable to understand the warnings cautions or instructions contact a healthcare professional dealer or technical personnel before attempting to use this equipment otherwise injury or damage may occur ACCESSORIES WARNING Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products THE INFORMATION CONTAINED THIS DOCUMENT IS SUBJECT TO CHANGE WITHOUT NOTICE 2 2 Important S
9. Tubs 5 OPERATING INSTRUCTIONS Use the drain plug to close the drain 2 Remove and disassemble all jet assemblies Lay all pieces in the footwell of the tub e Rotate each jet assembly counterclockwise and pull away from the jet casing Detail e Remove each impeller cap by rotating it clockwise Detail Remove each impeller Detail Detail Detail Detail C Jet Casing Jet Assembly 3 Remove the waist straps from the mounting attachment points Put the straps into the footwell of the tub Clean the pieces and spray all surfaces of the tub with Dispatch Cleaner and Disinfectant Take a long handled brush and thoroughly clean the interior surfaces of the tub and the jet casings 5 Allow the Dispatch Cleaner and Disinfectant to sit on the surfaces for one minute Rinse all surfaces and pieces in the footwell of the tub with water 7 Use a clean towel to dry all tub surfaces and all pieces in the footwell of the tub Allow the waist straps to air dry A WARNING DO NOT put the waist straps in the dryer otherwise damage to the straps may occur Invacare Recessed Whirlpool Tubs 22 Part No 1167458 5 OPERATING INSTRUCTIONS 8 Replace the impeller and impeller cap on each jet assembly WARNING A Cross threading the jet assembly onto the casing may Jet Casing cause damage to the whirlpool motor After installation ensure that the jet assembl
10. afety Information DANGERS ELECTRICAL SHOCK HAZARD Grounding is required The installation and maintenance of the tub MUST be done by a qualified technician certified electrician or plumber Disconnect electrical supply or turn off circuit breaker before installing or performing any maintenance on the tub The unit MUST be connected only to a supply circuit that is protected by a ground fault circuit interrupter GFCI Be certain ALL electrical work is performed by a qualified electrician and is in compliance with local electrical codes ALL electrical connections are to be water resistant A DANGER RISK OF SCALDING The hot water supply to the tub MUST not exceed 10 F 43 C to protect the user from scalding Invacare amp Recessed Whirlpool Tubs 6 Part No 1167458 2 SAFETY WARNING PLUMBING Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes WARNING FLOOR LOAD CAPACITY The installation area MUST be able to support the 66 pounds per square inch 45 load capacity of the tub Otherwise injury or damage may occur WARNINGS SAFE USE Use this unit only for its intended use as described in this manual If any part of the system is not functioning properly DO NOT use the tub NEVER drop or insert any object into any opening DO NOT operate the tub without the jet assemblies installed The tub MUST be cleaned and disinfected after each use Refer to Cleani
11. aintenance will extend the life and efficiency of your tub Initially Ensure that the maximum water supply temperature does not exceed 10 F Ensure that the maximum water pressure does not exceed 55 PSI Verify the water flow temperature with a separate thermometer Visually inspect for cracks in the tub surface Ensure that the door handle locks the door closed Ensure that the safety pin properly engages the door Check that all labels are present and legible Replace if necessary Before Each Use Clean and Disinfect the tub Refer to Cleaning and Disinfecting on page 36 Ensure that the maximum water fill temperature does not exceed 10 F 43 C Ensure that the maximum water pressure does not exceed 55 PSI Visually inspect for cracks in the tub surface Ensure that the door handle locks the door closed Ensure that the safety pin properly engages the door Every Six Months Verify the water flow temperature with a separate thermometer Check that all labels are present and legible Replace if necessary Clean the Water Temperature Control Valve to remove lime deposit Invacare amp Recessed Whirlpool Tubs 29 Part No 1167458 6 2 Troubleshooting 6 INSPECTION AND TROUBLESHOOTING If problems are not remedied contact technical support at 1 800 668 2337 Extension 2 SYMPTOMS FAULTS SOLUTION Hydromassage System System will not
12. ation 17 Plumbing Installation tia ER Sc coal la a 18 Installati n Checklists I9 Invacare amp Recessed Whirlpool Tubs 2 Part No 1167458 CONTENTS nnnn 20 NA 20 Cleaning and Disinfecting o E eet te be oet e RO Me ERE E E e E RR dca 21 Opening Closing th Tub DOO uA 24 Waist Strap dosi age ee ee NUI YAT AUR ee cedat lage eee ELE ENRE Rei toad eek e A E dee N 25 Water Temperature Setting ie eee iib Le FR e Deb coe Fe eoe EUIS ERE pe ceo 26 Filling the Tub teer RR LEER HL TR AER VU ERREUR DA EUREN ELA rere 27 Using the Shower Massage VVand iiie ti Ae RU Ee EROR ER ee ERE EEE 27 Using the Whirlpool F nctior 2 1 rtt tc pce t t rc Ut ate egt ee le t eee Deere E E De D GA 28 6 INSPECTION AND TROUBLESHOOTING seta season seas enses seen senses sensns 29 Safety Inspection Checklists RD I 29 Troubleshooting M
13. be refused please prepay shipping charges LIMITATIONS AND EXCLUSIONS THE WARRANTY SHALL NOT APPLY TO PROBLEMS ARISING FROM NORMAL WEAR OR FAILURE TO ADHERE TO THE ENCLOSED INSTRUCTIONS LABOR EXPENDABLE ITEMS I E SHOWER HOSES VALVES RINGS SEALS PARTS BROKEN DUE TO ABUSE OR IMPROPER USE ITEMS THAT BECOME INOPERABLE DUE TO LACK OF MAINTENANCE OR NON COMPATIBLE CHEMICALS STAINS DUE TO HARD WATER IODINE SOLUTIONS OR OTHER UNAPPROVED CHEMICALS SPIDER CRACKS OR CRACKING DUE TO MISHANDLING OR ABUSE IN ADDITION THE FOREGOING WARRANTY SHALL NOT APPLY TO SERIAL NUMBERED PRODUCTS IF THE SERIAL NUMBER HAS BEEN REMOVED OR DEFACED PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE OR PRODUCTS MODIFIED WITHOUT ICCI S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF ICCI PRODUCTS DAMAGED BY CIRCUMSTANCES BEYOND ICCI S CONTROL PRODUCTS REPAIRED BY ANYONE OTHER THAN AN ICCI DEALER SUCH EVALUATION SHALL BE SOLELY DETERMINED BY ICCI THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE AND THE SOLE REMEDY FOR VIOLATIONS OF ANY WARRANTY WHATSOEVER SHALL BE LIMITED TO REPAIR OR REPLACEMENT OF
14. e unit will be built against one two or three walls gt Three wall installation only ensure a stud wall pocket has been constructed to receive the tub unit The opening of the pocket should be sized to allow the tub to slide in easily without any binding between the studs and the tub Minor gaps can be covered by drywall or paneling In remodeling situations where tub or shower units have been removed it may be necessary to modify the pocket to receive the tub If desired a wooden nailer may be attached to the stud walls as an additional mounting fixture for the tub 5 Temporarily slide the tub into place 6 Mark the location of the fiberglass lip against the studs 7 Mount 2 inch by 2 inch cleats approximately 1 8 below the marks made in STEP 6 Ensure the cleats do not interfere with any components of the tub or restrict the installation in any way 8 a service access panel minimum 16 by 14 on the wall the back wall or right wall to allow the tub components to be serviced Part No 1167458 15 Invacare amp Recessed Whirlpool Tubs 4 INSTALLATION 42 Electrical and Plumbing Hook up Locations Refer to Electrical Installation on page 17 and Refer to Plumbing Installation on page 18 Model 3752G shown below Front View Top View Model Ren ud Model 3752G 3752G LETTER DESCRIPTI
15. er temperature in the tub WARNING DO NOT stand in the tub The tub surfaces are slippery when wet Serious injury may occur Close the drain with the blue stopper Push the tub fill button to start auto fill The tub will fill to a predetermined level To stop the tub from filling press the fill button a second time there will be a 5 second delay After the tub has auto filled push in and hold the tub fill button to add additional water Use the water temperature control valve to adjust the water temperature while watching the flow water thermometer Test the water temperature with your hand After the tub has auto filled push in and hold the tub fill button to add additional water Using the Shower Massage Wand Make sure that the Shower Massage wand is in the cradle and the shower wand head is over the tub The angle of the wand cradle can be adjusted to accommodate the user s need Turn the shower massage on by pushing the ON OFF button Adjust the water temperature using the water temperature valve while watching the flow water thermometer Test the water temperature with your hand Adjust the flow of the water by turning the flow control Adjust the shower spray by rotating the shower wand head Turn the shower massage off by pressing the ON OFF button again Part 1167458 27 Invacare amp Recessed Whirlpool Tubs 5 OPERATING INSTRUCTIONS Refer to the following chart for shower head adjustment settings
16. ise serious injury or damage may occur Opening the Tub Door Place one hand on top of the door handle 2 Use the other hand to pull the safety pin out and release the door handle 3 Lift up on the door handle and open the door Closing the Tub Door l Close the door 2 Push down on the door handle to lock the door into position 3 Lift the door handle to ensure the safety pin has engaged the door properly 4 Ifthe door handle lifts repeat STEPS 1 3 Invacare amp Recessed Whirlpool Tubs 24 Door Handle ERIT Safety Pin Door Part No 1167458 5 OPERATING INSTRUCTIONS 5 4 Waist Strap The waist strap is a positioning guide only The strap is not designed for use as a safety device or as a restraint The strap MUST be washed and disinfected after each use Refer to Cleaning and Disinfecting on page 36 Installation On each end of the waist strap insert the lead into the round portion of the slot in the attachment point slide the lead up and turn it Use Bring both ends of the waist strap around the resident Secure the ends together with the plastic clasp 2 Adjust the straps for comfort as necessary Strap Strap attachment point Attachment Point Waist Strap shown in place attached to tub shell in two places Tub Shell Strap Lead Plastic clasp Part No 1167458 25 Invacare amp Recessed Whirlpool Tubs 5 INSTRUCTIONS
17. its bathing whirlpool products to be free from defects in materials and workmanship for a period of three years from the date of purchase The door seal is warranted for the life of the tub Warranty obligation is limited to parts replacement only Warranty replacement parts are only covered for the duration of the warranty period All purchased replacement parts will carry a 30 day warranty from the date of shipment If within such warranty period any such product shall be proven to be defective such product shall be repaired or replaced at ICCI s option This warranty does not include any labor or shipping charges incurred in replacement part installation or repair of any such product ICCI s sole obligation and your exclusive remedy under this warranty shall be limited to such repair and or replacement For warranty service please contact the dealer from whom you purchased your ICCI product In the event you do not receive satisfactory warranty service please write directly to ICCI at the address below Provide dealer s name address model number date of purchase indicate nature of the defect and if the product is serialized indicate the serial number ICCI will issue a return authorization The defective unit or parts must be returned for warranty inspection using the serial number when applicable as identification within thirty days of return authorization date DO NOT return products to our factory without our prior consent C O D shipments will
18. l On Off valves at wall and use unions between valves and stubs Connect hot and cold supply lines to copper pipes found on back of tub in accordance with applicable building codes Connect 2 inch drains in accordance with local plumbing codes Attach the shower massage wand and flow valve Be sure to use the washers supplied Check for leaks in supply or drain lines and check operation of tub Refer to Operating Instructions on page 35 Invacare amp Recessed Whirlpool Tubs 18 Part No 1167458 4 INSTALLATION Check local codes regarding maximum water temperature allowed at hot water outlets for facility type In House Water Service HOT COLD Optional Pressure Regulator Mixing Valve Tub Spout Shower Control Valve Tub Fill Valve Shower Massage Wand Backflow Preventor located inside tub cabinet 4 5 Post Installation Checklist Before putting the tub into service check the following Water lines have been purged of any foreign matter Both hot and cold water lines are properly connected to the tub Dedicated 1 15 15 AMP AC power line is properly wired to the unit Power line is protected by a 15 AMP GFCI All water lines are checked for leaks ICCI skin care and cleaning products have been ordered To place your order call 800 668 2337 Ooooocdo representative has been called to arrange for an In Service the tub To sched
19. maintenance of the Tub MUST be done by a technician certified in or plumber Disconnect I supply or turn OFF eaker before performing any maintenance to the Tub DO NOT remove this label Label located on Interior Hardware DO NOT operate or service this equipment without first reading and understanding the user manual Invacare Recessed Whirlpool Tubs 10 D MODEL NO 2000762 INVACARE CONTINUING CARE INC Ehia 44036 USA SERIAL NO MFG DATE vours 119 vac amps 7 0 Continuous Duty cvete 60 tz Part No 1167458 3 3 Typical Product Parameters 3752G 3802G 3 OVERVIEW Weight Tub shipping weight Tub empty Tub filled without user Floor Load Capacity 319 pounds 144 kg 260 pounds 117 kg 796 pounds 361 kg 66 PSI 45 n cm Minimum Space Requirements 7 feet x 6 feet Exterior Length Interior Length 59 1 2 inches 49 inches Exterior Width Interior Seat Width 31 1 2 inches 21 inches Deck Height 41 1 2 inches Side Access Door Swing 40 inches Volume Capacity with user 47 gallons Lift Base Clearance 6 1 4 inches Electrical Classification Class B Power 115 VAC 60 Hz Current Rating 7 Amps Number of Jet Outlets 4 Tub Material Double wall gel coated fiberglass Thermometer 2 inch dial 75 to 120 F 25 50 C Anti Scald Water Regulator
20. ment for angle of wand in cradle Service Access Door Door Invacare Recessed Whirlpool Tubs 8 Part 1167458 3 OVERVIEW Model 3802G ster Temperstune Thermometer Shower Massage Wand Flow Control Valve Whirlpool ON OFF Button Fill Button Push in once auto fill push in and hold to add additional water to tub Water Temperature Control Tub Fill Spout Overflow Shower Spray Adjustment Adjustment for angle of Shower Massage wand in cradle ON OFF Button Service Access Door Door Part No 1167458 9 Invacare Recessed Whirlpool Tubs 3 OVERVIEW 3 2 Product Labeling Labels located inside the Service Access Door CAUTION Some state and local plumbing codes require the installation of a reduced pressure zone RPZ assembly on both the incoming hot and cold supply lines to prevent back flow contamination into the potable water system Invacare recommends you check local plumbing code requirements to determine if RPZs are required on your tub installation RPZs are NOT supplied by Invacare and are to be provided by the customer if required PIN 1150759 Rev A 1167464 Rev A 4 DANGER ELECTRICAL SHOCK HAZARD The National Electrical Code requires the use of a ground fault circuit interrupter GFCI on all therapeutic pools and tubs hydro therapeutic tanks Failure to follow requirement could result in serious or fatal inju disassembly and
21. ng and Disinfecting on page 36 Keep hair and body away from the jet assemblies when pump is running Hyperthermia occurs when the internal temperature of the body reaches a level several degrees above the normal body temperature of 98 6 F The symptoms of hyperthermia include an increase of the internal temperature of the body dizziness lethargy drowsiness and fainting To reduce the risk of injury DO NOT permit children or infirm persons to use this tub UNLESS THEY ARE SUPERVISED ALL TIMES Recommended length of time spent a bath is 5 to 10 minutes However if you or the person you are caring for becomes nauseated or dizzy or the person develops a headache get out of the tub at once and safely bring the body temperature back to normal 98 6 F Seek medical attention if symptoms or sickness persist Check with the physician BEFORE using the tub again Anyone under a doctor s supervision pregnant or with poor health should check with a physician BEFORE using this tub gt Part 1167458 7 Invacare amp Recessed Whirlpool Tubs 3 OVERVIEW 3 Overview 3 1 Features Model 3752G Water Temperature Control Tub Fill Spout Water Temperature Thermometer Overflow x gt Whirlpool ON OFF Button Y Fill Button ARA Push in once to auto fill push in and a hold to add additional water to tub Shower Massage ON OFF Button Shower Massage Wand Flow Control Valve Shower Spray Adjustment Adjust
22. nuing Care Inc is a subsidiary of Invacare Corporation Manufacturing Location 899 Cleveland Street Elyria Ohio 44036 Part No 1167458 2010 Invacare Corporation All rights reserved Republication duplication or modification in whole or in part is prohibited without prior written permission from Invacare Trademarks are identified by and All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted Dispatch is a registered trademark of Clorox Industries Inc Sanijet and Pipeless TM are registered trademarks of Maple Industries LLC d b a Sanijet ExactTemp is a registered trademark of Moen Incorporated Rev A 06 10
23. on DANGER RISK SCALDING The hot water supply to the tub MUST NOT exceed 110 F 43 C to protect the user from scalding WARNINGS Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes Some state and local plumbing codes require the installation of a reduced pressure zone RPZ assembly on both the incoming hot and cold supply lines to prevent back flow contamination into the potable water system Invacare recommends you check local plumbing code requirements to determine if RPZs are required on your tub installation RPZs are NOT supplied by Invacare and are to be provided by the customer if required CAUTIONS Purge water lines Hot and cold lines MUST be purged blown down to clear lines of debris prior to connection Valves and spray heads may become inoperable and or damaged if lines are not properly cleared Items damaged in this way are not covered under the warranty When operating water pressure exceeds 55 PSI pressure regulators similar to the Watts U5 MUST be installed Refer to Electrical and Plumbing Hook up Locations on page 16 for the location of the hot water stub and cold water stub Measure the location of the drain on the unit Install the drain in the floor in the appropriate location determined in STEP 2 Purge water lines Hot and cold lines MUST be purged blown down prior to connection to clear lines of debris Instal
24. rcuit interrupter GFCI Such a should be provided by the installer and should be tested on a routine basis To test the GFCI push the test button The GFCI should interrupt power Push the reset button Power should be restored If the GFCI fails to operate in this manner GFCI is defective If the GFCI interrupts power to the bathtub without the test button being pushed a ground current is flowing indicating the possibility of an electric shock DO NOT use this tub Disconnect the tub and have the problem corrected by a qualified service representative BEFORE use All electrical conduit fittings and wire to unit are to be supplied and installed by a professional electrician in accordance with the National electrical code as a minimum requirement including the supply and installation of a Ground Fault Circuit Interrupter GFCI For Canadian installation ground fault interrupter and a 30 minute maximum timer MUST be installed in the electrical circuit Parts not supplied by ICCI The unit must be operated through the circuit The 30 minute timer must be located in a position where a person in the unit cannot reach the timer Use a 15 AMP GFCI breaker only Ensure a 15 breaker is installed to protect the unit Insert the plug into a pre installed protected hospital grade receptacle Part No 1167458 17 Invacare amp Recessed Whirlpool Tubs 4 INSTALLATION 4 4 30 Q0 b Qv Ur ie w T Plumbing Installati
25. start No electrical power to tub Check and reset breaker Switch air hose disconnected Reconnect hose to switch and controller System is ineffective Water deposits in whirlpool jets Disassemble and clean whirlpool jets System is noisy Whirlpool jets are turned on without water completely covering the jet assemblies Turn off the whirlpool jets Add water to the tub to completely cover the jet assemblies and test the whirlpool function again Tub Operation No water flow Water supply turned off Turn on water supply Restricted water flow Water temperature control valve Inspect and clean the water temperature control valve Refer to the Moen service manual at www moen com Search for Model 3371 ExactTemp Temperature Control Valve Service Manual Number 153768 Part No 1167458 30 Invacare amp Recessed Whirlpool Tubs 6 INSPECTION AND TROUBLESHOOTING 6 3 Maintenance Record MAINTENANCE PERSON OF MAINTENANCE PERFORMED Invacare Recessed Whirlpool Tubs 3l Part No 1167458 Invacare Corporation www invacare cc com USA and Canada One Invacare Way Elyria Ohio USA 44036 2125 Customer Service 1 800 668 2337 Technical Support 1 800 668 2337 Yes Extension 2 For more information regarding Invacare products parts and services please visit www invacare cc com Invacare Conti
26. the tub in any way Modifications to the system or any component may cause the system to malfunction and will void the warranty The door MUST be closed and latched during installation to avoid deformation of the tub shell ICCI assumes no responsibility for code infractions or damage to components due to improper installation Use extreme care during installation After installation and before use ensure all parts are properly and securely installed Ensure the bathroom floor is dry and free of obstructions before transporting or assembling the unit Invacare Recessed Whirlpool Tubs 14 Part 1167458 4 INSTALLATION 41 Preparing the Work Area Access for servicing the tub MUST be provided Follow the recommended floor plan Refer to Minimum Floor Space and Clearance Requirements on page 12 The tubs are designed to be built in against one two or three walls much the same way a traditional tub shower unit is installed in an alcove Optional end panels are available for corner or one wall installation and are only available at the time of the tub order One wall installation Two wall installation corner Three wall installation recessed Carefully remove the tub from the carton and inspect for shipping damage If damage is found contact the carrier Measure the tub Ensure the floor in the area of installation will be able to support the 66 pounds per square inch 45 n cm load capacity of the tub Determine whether th
27. ule call 800 668 2337 Part No 1167458 19 Invacare Recessed Whirlpool Tubs 5 OPERATING INSTRUCTIONS 5 Operating Instructions 5 Overview WARNINGS A Read and understand ALL information in this manual BEFORE use Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the tub DO NOT clean or disinfect the tub when it is occupied Otherwise injury may occur To reduce the risk of injury DO NOT permit children or infirm persons to use this tub UNLESS THEY ARE SUPERVISED ALL TIMES Recommended length of time spent in a bath is 5 to 10 minutes However if you or the person you are caring for becomes nauseated or dizzy or the person develops a headache get out of the tub at once and safely bring the body temperature back to normal 98 6 F Seek medical attention if symptoms or sickness persist Check with the physician BEFORE using the tub again Anyone under a doctor s supervision pregnant or with poor health should check with a physician BEFORE using this tub Fill Button Whirlpool ON OFF Button E Push in once to auto fill push in Flow Control Valve and hold to add additional water to tub Water Temperature Control Valve Shower Massage ON OFF Button a amp L ij Hl Invacare amp Recessed Whirlpool Tubs 20 Part No 1167458 5 OPERATING INSTRUCTIONS Perform these procedures in the following order 30 00 5 gv Un Re Io
28. y is flush against the jet casing 2 Sanijet 9 Assemble each jet assembly to the jet casings Logo Position the Sanijet logo at the 11 o clock position nsertthe jet assembly into the receptacle in the tub and rotate the jet assembly clockwise until it locks into place Removing Soap Film and Hard Water Deposits Use a commercially available cleaner such as Invacare Heavy Duty Cleaner Remove the jet assemblies Remove the impeller caps Thoroughly spray the exposed surfaces including the jet casings Use a long handled soft brush or similar product to wipe down all surfaces and allow the heavy duty cleaner to remain in contact with the exposed surfaces for approximately ten minutes Rinse off surfaces using the shower wand adjusted to spray position Removing Calcium Deposits Scale and Lime Build up Spray a commercially available cleaner full strength for the intended application on all surfaces to be cleaned Allow the cleaner to remain in contact with surfaces for at least five minutes to as long as 12 hours Rinse off surfaces using the shower wand adjusted to the spray position Use the cleaner according to the manufacturer s instructions Part No 1167458 23 Invacare amp Recessed Whirlpool Tubs 5 OPERATING INSTRUCTIONS 5 3 Opening Closing the Tub Door WARNINGS A DO NOT open the door when water is in the tub otherwise serious injury could result DO NOT fill or use the tub if the door does not lock otherw
Download Pdf Manuals
Related Search