9. 4PP065.0571-X74F
Contents
1. pro vided by an external fuse 5A fast acting al re Required accessories 0TB103 9 Connector 24 VDC 3 pin female screw clamp 3 31 mm protected 3 pin multipoint plug against vibration by the screw flange 0TB103 91 Connector 24 VDC 3 pin female cage clamp 3 31 mm protected against vibration by the screw flange Table 89 4PP065 0571 X74F Pin assignments Supply voltage Important The pin s connection to the functional ground should be as short as possible e g in the control cabinet We recommend using the largest possible conductor cross section on the supply plug Power Panel 65 User s Manual V 1 00 105 Chapter 2 Power Panel 65 4PP065 0571 X74F Operating mode and node number switches 9 6 Operating mode and node number switches Figure 29 4PP065 0571 X74F Operating mode and node number switches The Power Panel 65 is equipped with 2 hex switches that are used for the operating mode or node number of the device Switch positions 01 FE are used to set the INA station number for the Ethernet interface wooo e 01 FE INA node number of the Ethernet interface FF Diagnostic mode The CPU boots in diagnostic mode Program sections in User RAM and User FlashPROM are not initialized After diagnostic mode the CPU always boots with a cold restart Table 90 4PP065 0571 X74F Operating mode and node number switches 106 Power Panel 65 User s Manual V 1 00 4PP065 0571 X74F Dimensio2. 28 kB MMX technology 3D Now Yes At 25 C Typ 30 ppm 2 5 seconds per day Yes Geode LX800 8 MB shared memory reserved in application memory 128 MB DDR SDRAM 200 kB SRAM Primary IDE device 2 USB 1 1 USB 2 0 Type A Low speed 1 5 Mbit s full speed 12 Mbit s to high speed 480 Mbit s Max 500 mA per connection 1 Shielded RJ45 port 10 100 Base T Intel 82551ER 10 100 Mbit s 100 Mbit s S STP Category 5 Link Activity Table 80 4PP065 0571 X74F Technical data Power Panel 65 User s Manual V 1 00 4PP065 0571 X74F Technical data Product ID 4PP065 0571 X74F X2X Amount 1 Type X2X Link master Design 4 pin multipoint plug Number of stations Max 253 Distance between stations Max 100 m Network topology Line Internal bus supply No Bus termination resistor Internal Contrast 350 1 Viewing angle Horizontal Direction R direction L 60 Vertical Direction U 65 direction D 50 Backlight Brightness 500 cd m Half brightness time 50 000 h Touch screen Technology Analog resistive Controller B amp R 12 bit Degree of transmission 70 10 Screen rotation Yes see Chapter 4 Commissioning section Screen rotation on page 131 IP20 back side only with installed CompactFlash card IP65 NEMA 250 type 4X dust and sprayed water protection front side Table 80 4PP065 0571 X74F Technical data Power Panel 65 User s Manual V 1 00 99 Chapter 2 Power Panel 65 4PP065 0
3. 3 01 B3 06 Blink code 200 ms grid Weaning OOO O A ELL esnearen SSS Table 84 4PP065 0571 X74F Status LED blink codes Since only one error can be indicated by a blink code more important errors are assigned a high er priority Fatal errors for example have a much higher priority than unimportant errors e g battery capacity low 9 4 3 ACT LNK LEDs for the RJ45 ports There are two additional LEDs next to the Ethernet interface LNK green ACT orange i p pue E Figure 27 4PP065 0571 X74F Ethernet LEDs Orange No Ethernet activity on bus Blinking Ethernet activity on the bus A link to the remote station has been established Table 85 4PP065 0571 X74F ACT LNK LEDs for the RJ45 ports 102 Power Panel 65 User s Manual V 1 00 4PP065 0571 X74F Connection elements 9 5 Connection elements Supply voltage Ehernet interface USB interfaces X2X Link interface Chapter 2 Power Panel 65 Figure 28 4PP065 0571 X74F Connection elements 9 5 1 X2X Link interface Application interface X2X Link Ee 0TB704 9 Accessory terminal block 4 pin screw clamp 1 5 mm 0TB704 91 Accessory terminal block 4 pin cage clamp 2 5 mm 4 pin multipoint plug Table 86 4PP065 0571 X74F Pin assignments X2X Link Power Panel 65 User s Manual V 1 00 103 4PP065 0571 X74F Connection elements 9 5 2 USB interface This Power Panel 65 device has a USB 2 0 Univ
4. 4PP065 0571 X74F Order data 9 4PP065 0571 X74F 9 1 Order data 4PP065 0571 X74F Power Panel PP65 5 7 QVGA color TFT display with touch screen resistive 10 function keys 10 MB DRAM 232 kB SRAM CompactFlash slot Ethernet 10 100 1x X2X Link 2x USB IP65 protection front side Order application memory separately Order TB103 and TB704 terminal blocks separately Required accessories 0TB103 9 Connector 24 VDC 3 pin female screw clamp 3 31 mm protected against vibration by the screw flange 0TB103 91 Connector 24 VDC 3 pin female cage clamp 3 31 mm protected against vibration by the screw flange Table 79 4PP065 0571 X74F Order data 96 Power Panel 65 User s Manual V 1 00 4PP065 0571 X74F Technical data Modeinumber Stonesin age Optional accessories 4PP065 IF23 1 PP65 interface module 1 RS232 RS485 RS422 interface RS422 electrically isolated RS485 electrically isolated and network capable 1 CAN interface electrically isolated and network capable Order 0TB710 91 terminal blocks separately 4PP065 IF24 1 PP65 interface module 1 PROFIBUS DP slave interface electrically isolated and network capable 1 RS232 RS422 RS485 interface RS422 RS485 electrically isolated and network capable A4PP065 IF33 1 PP65 interface module 2 CAN interfaces electrically isolated and network capable Order 0TB710 91 terminal blocks separately 5MMUSB 2048 01 USB 2 0 flash drive 2048 MB B amp R Included in del
5. 571 X74F Product ID Environmental conditions Temperature Operation Storage Transport Relative humidity Operation Storage Vibration Operation continuous Operation occasional Storage Transport Shock Operation Storage Transport Supported interface modules 4PP065 0571 X74F 0 to 50 C 20 to 70 C 20 to 70 C 10 to 90 non condensing T lt 40 C 5 to 90 non condensing T gt 40 C lt 90 non condensing 2 to 9 Hz 1 75 mm amplitude 9 to 200 Hz 0 5 g 2 to 9 Hz 3 5 mm amplitude 9 to 200 Hz 1 g 2 to 8 Hz 7 5 mm amplitude 8 to 200 Hz 2 g 200 to 500 Hz 4 g 2 to 8 Hz 7 5 mm amplitude 8 to 200 Hz 2 g 200 to 500 Hz 4 g 15 g 11 ms 30 g 15 ms 30 g 15 ms Installation at altitudes above sea level Front Outer dimensions Width Height Depth Table 80 4PP065 0571 X74F Technical data 1 Typical service life at 50 buffer operation 25 C when device turned off 50 C when device turned on Maximum service life in 24 hour operation no buffer 6 years at 25 C 5 years at 50 C Maximum service life when device turned off 2 years at 25 C 1 year at 50 C 2 Maintenance Controller Extended 3 At max specified ambient temperature Typ 50 ppm 4 s worst case 100 ppm 8 s 4 Weight including fasteners and battery 46 5 g but without an interface module 9 3 Supported interface modules Interface modules are supported beginning with the following Automation Runtime vers
6. ersal Serial Bus host controller with two USB ports that are easily accessible to the user USB interface Low speed 1 5 Mbit s full speed 12 Mbit s to high speed 480 Mbit s Table 87 4PP065 0571 X74F USB ports 1 The actual value depends on the operating system or driver being used 2 For safety every USB port is equipped with a maintenance free USB current limiting circuit breaker max 500 mA Warning Peripheral USB devices can be connected to the USB ports Due to the vast number of USB devices available on the market B amp R cannot guarantee their performance B amp R does guarantee the performance of all USB devices that they provide Important Because of general PC specifications these interfaces should be handled with ex treme care with regard to EMC location of cables etc 104 Power Panel 65 User s Manual V 1 00 4PP065 0571 X74F Connection elements 9 5 3 Ethernet interface ee T Ethernet interface RXD Receive signal inverted faa MAUI RJ45 twisted pair socket D TXD Transmit signal inverted 10BaseT 100BaseT jw Temiaion Table 88 4PP065 0571 X74F Pin assignments Ethernet interface 9 5 4 Supply voltage Pin assignments can be found both in the following table and printed on the back of the Power Panel The Power Panel has reverse polarity protection that prevents the supply voltage from being connected incorrectly which would damage the device Overload protection must be
7. ions Interface modules 4PP065 1F 10 1 4PP065 1F23 1 4PP065 1F24 1 Automation Runtime version 4PP065 1F33 1 C2 96 C2 96 C2 96 A3 07 Table 81 4PP065 0571 X74F Supported interface modules 100 Power Panel 65 User s Manual V 1 00 4PP065 0571 X74F Diagnostic LEDs 9 4 Diagnostic LEDs There are four diagnostic LEDs on the back of the PP65 Status x2x Rar CF i oo TI VA s ARRE EAEE or Poy Figure 26 4PP065 0571 X74F Diagnostic LEDs Information The behavior of the status LED has been changed beginning with AR versions J2 96 E3 01 and B3 06 9 4 1 Diagnostic LEDs until AR versions 12 96 D3 01 and A3 06 Status Red lm Error Reset User On Off This LED can be operated by the user with the ASHW library X2X The module is sending data via the X2X Link interface CompactFlash card being accessed Table 82 4PP065 0571 X74F Diagnostic LEDs until AR versions 12 96 D3 01 and A3 06 Power Panel 65 User s Manual V 1 00 101 Chapter 2 Power Panel 65 4PP065 0571 X74F Diagnostic LEDs 9 4 2 Diagnostic LEDs beginning with AR versions J2 96 E3 01 B3 06 s oer Sis won SSS See Table 84 4PP065 0571 X74F Status LED blink codes On Off This LED can be operated by the user with the ASHW library The module is sending data via the X2X Link interface CompactFlash card being accessed Table 83 4PP065 0571 X74F Diagnostic LEDs beginning with AR versions J2 96 E
8. ivery 4PP065 0571 X74F Power Panel 65 including installation accessories 4A0006 00 000 Lithium battery 3 V 950 mAh button cell Table 79 4PP065 0571 X74F Order data cont 9 2 Technical data Product ID 4PP065 0571 X74F General information B amp R ID code B9BC LEDs 4 CF CompactFlash Orange Status Red green X2X Orange User Green Battery Type Renata 950 mAh Method Lithium lon Service life 4 years 1 Removable Yes accessible from the outside Backup capacitor Buffer time 10 min Certification Yes Yes Yes Table 80 4PP065 0571 X74F Technical data Power Panel 65 User s Manual V 1 00 97 Chapter 2 Power Panel 65 4PP065 0571 X74F Technical data Product ID 4PP065 0571 X74F Boot loader operating system Automation Runtime PP65 supported beginning with ver C2 96 sion Processor Type Clock frequency L1 cache L2 cache Expanded command set Floating point unit FPU Flash Cooling Mode Node switches Remanent variables Watchdog Real time clock Accuracy Battery buffered Power failure logic Controller Buffer time Graphics Controller Memory Standard memory RAM User RAM PP65 Compact IF slot CompactFlash slot 1 Amount Type Design USB Amount Type Design Transfer rate Current load Ethernet Amount Design Controller Transfer rate Max transfer rate Cables Status LEDs 98 Geode LX800 32 bit x86 500 MHz 128 kB 64 kB I Cache 64 kB D Cache 1
9. ns 9 7 Dimensions Figure 30 4PP065 0571 X74F Dimensions Installation cutout 188 0 5 mm x 130 0 5 mm Power Panel 65 User s Manual V 1 00 107 Chapter 2 Power Panel 65 4PP065 0571 X74F Dimensions 108 Power Panel 65 User s Manual V 1 00
Download Pdf Manuals
Related Search