Home
Product no: 49 66 00, 49 66 01 17.06.2008 NO
Contents
1. gt 655 gt 200 N gt 655 15 FIG 2 40 mm FIG 5 18 Nordpeis AS Gjellebekkstubben 9 11 N 3420 LIERSKOGEN Norway www nordpeis no
2. collar on the posterior flue outlet Screw in place the cast iron lid on the top outlet Place the toplid SN OP ON gt Functions FIG 4 1 5 1 The door is opened by pulling the handle out and up 2 The ash tray is pulled out in front 3 The ash grate is shoved in and out in order to remove ashes from the burn chamber 4 The air vent control is adjusted by turning the wheel under the door in front 5 The hatch under the door is opened by a gentle push on the right side of the door Thermotte Plates The Thermotte plates Fig 5 are already mounted inside the stove Should it be necessary to renew one or several plates contact your dealer See chapter on maintenance A Smoke baffle B Side plate C Side plate D Posterior plate In case the Thermotte plates need to be uninstalled do as follows 1 Lift up the smoke baffle A with one hand 2 Remove one side plate B or C 3 Lower the smoke baffle A and remove all parts Operational Control When the stove is position control that all functions are easy to manoeuvre and appear satisfactory 10 English Air vent control Left position Closed Middle position Opened normally Higher position Fully opened Door Handle turned downward Closed Handle turned upward Opened 6 Making up the fire for the first time When the stove is assembled and all instructions have been observed a fire can be lit Please be aware of the
3. following The smoke baffle and the Thermotte plates can be broken by a strong hit This would not be covered by the warranty Place the wood logs carefully in the burn chamber in order to avoid such a hit Itis advisable to air well when making the fire for the first time as the varnish on the stove will release some smoke or smell which will disappear and is not hazardous Making up a fire Stove small dry pieces of wood ignite and ensure that the flames have a good grip of the wood before closing the door Prior to closing the door open the air vent control Fig 4 4 When the flames are stable and the chimney is warm the air supply is controlled with this regulator When there is a glowing layer of coal new wood logs can be stoveed When stoveing new logs remember to pull the hot ember forward in the stove so that the wood is ignited from the front Using the stove with low combustion effect increases the pollution as well as the risk of a fire in the chimney Regulation of the air vent control takes some experience but after a little while you will find an optimal rhythm for the fire Warning Never allow the stove or tubes to become overheated and glowing red Should this happen close the air vent control 7 Maintenance Remember that stove it must be cold when inspected Door The glass in the door is ceramic and therefore detergents containing abrasive material should not be used Use polish sp
4. for the Environment Our stoves represent a new generation of fireplaces that are more efficient are clean burning and when used properly release low levels of soot and particles In the future it will not only be economical factors driving the necessity for low consumption but requirement for environmental solutions will continuously become more demanding This requires that we use renewable sources of energy that cause little pollution or damage to the environment Wood fuel is labelled as renewable resource biofuel 12 English Some advice in case of combustion problems Error Explanation Solution The chimney is blocked The flue is sooty or there is accumulated soot on the Contact a chimney sweeper dealer for more information or No draught smoke baffle clean the flue and burn chamber The smoke baffle is wrongly positioned Downdraught in the room caused by no draught that Is verified by lighting the fire with an open window If this helps the house is too air tight more bigger vents must be installed Downdraugnt n ne room cassar de ane Turn off regulate extractor and or other ventilation If this helps or central ventilation system that pulls too much air i more bigger vents must be installed out of the room The flues from two fireplaces stoves are connected to One flue must be repositioned The height difference of the two the same chimney at the same height flue pipes should be
5. monteringsanvisningen pa byggeplass St Sted Dato Montgrens signatur KONTROLLERKLZERING Installasjonen er kontrollert ved hjelp av Utfylt sjekkliste 3 Visuell kontroll 3 3 Videokamera I Installasjonen er kontrollert og funnet i orden Kontrollert curras ra a aa Sted Dato Kontrollgrens signatur Det er en stor fordel at bekreftelse p kontroll av installasjonen finnes S rg for at denne siden blir utfylt og ta vare p den Dette er et verdipapir for boligen Husk at huseier plikter melde fra til kommunen ved brann og feiervesenet om at ildstedet er montert Send gjerne en kopi av denne siden til det lokale feiervesen 8 Norsk INDEX 1 Prior to assembling the stove 1 Prior to assembling the stove 9 All our stoves are tested according to the latest European requirements and also to the Norwegian 2 Technical Information 10 SINTEF standard which includes particle tests 3 Distance to combustible material 10 Several European countries however have individual 4 Fresh ai 10 rules for installation of stoves stoves and fireplaces resh air supply You as a client are totally responsible for the fulfilling 5 Assembly 10 of these local rules concerning the installation in Thermotte Plates 10 your region country Nordpeis Northstar is not Operational Control 10 responsible regarding correct installation You should 6 Making up the fire for the fir
6. nbl sintef no The CE mark is situated on inside of the hatch door 9 Advice on making up a fire The best way to make up a fire is with the use of fire briquettes Newspapers cause a lot of ashes and the ink is damaging for the environment Advertising flyers magazines and milk cartons etc are not suitable for making up a fire Warning NEVER use a lighting fuel such as petrol paraffin methylated spirits or similar for lighting a fire This could cause you injury as well as damaging the product It is extremely important that clean and dry wood is used at all times Humid wood requires a lot of air for the combustion as extra energy heat is required for drying the humid wood The heat effect is therefore minimal In addition this causes soot creation in the chimney with the risk of creosote and chimney fire Warning NEVER use impregnated wood painted wood plywood chipboard rubbish milk cartons and printed material or similar If any of these items are used as fuel the warranty is invalid as they can contain hazardous etching and dangerous fumes when burnt In addition the poisonous gas dioxin can develop that can damage the stove and be harmful to the environment Combustion complications Too much air supply to the combustion creates an uncontrollable flame that very quickly will heat up the entire stove to extremely high temperatures valid when heating with closed or almost closed door Never complet
7. Nordpeis NO Monteringsanvisning s 2 GB Installation manual S Ca sa Product no 49 66 00 49 66 01 17 06 2008 INNHOLD For du installerer peisovnen Krav til gulvplate Teknisk informasjon Brannmur Tilforsel av forbrenningsluft o Ae O N Montering Thermotteplatene Kontroll av funksjoner 6 F rste opptenning Opptenning 7 Vedlikehold 8 Garanti Feil fyring Pipetrekk Varmedanning og fordeling Milj messige hensyn R d og tips ved problemer med forbrenningen Kontrollskjema ONO A AIR Bwilw lS 0 0 NIN NB TILPASSET NORSKE SIKKERHETSKRAV EU SAMSVARSERKL ERING Utstedt dato 04 06 2008 Samsvarserkl ring utstedt av Company name Address Postal Nordpeis AS Gjellebekkstubben 9 11 N 3420 Lierskogen Country Norway Phone 47 32 24 47 00 Fax 47 32 24 47 11 Web www nordpeis no E mail post nordpeis no Nordpeis Dette produktet samsvarer med EN 13240 og tillegg ZA Produktnavn Nordpeis CASA SINTEF 010 0251 Ovn for oppvarming av rom Plategods og st pejernsovn for vedfyring Kun ren ved se bruksanvisningen 280 C 0 14 Produkt type Ovnstype Brensels type Roykgass temperatur CO innhold ved 13 O OCG innhold ved 13 03 75 mg m Varmeeffekt nominell verdi 5 4 kw Energieffektivitet ved 5 4 kW 78 Minimumskrav til trekk 14 Pa Sikkerhetsm l M plasseres i henhold til monteringsanvisni
8. aller fireplace or build new chimney with larger cross section Possibly install a smoke suction device The chimney is too low and hence a poor draught Increase the height of the chimney The fireplace release smoke inside when it is windy outside The chimney is too low in relationship to the surrounding terrain buildings trees etc Increase the height of the chimney Possibly install a chimney cap or a smoke suction device Turbulence around the chimney due to the roof being too flat Increase the height of the chimney or install a chimney cap The fireplace does not heat The fireplace combustion receives too much oxygen due to a leakage under the lower border of the insert or too strong chimney draught Difficult to regulate Any possible leakage must be sealed off A draught regulator or possibly a damper can reduce the chimney draught NB A leakage of only 5 cm2 is enough for 30 of the heated air to sufficiently the combustion and the wood burn up too quickly disappear The smoke buffer is wrongly positioned Control the positioning of the smoke buffer see assembly instructions In case of using oven dried wood this requires less T inicdownithe air sunni o air supply than when using normal wood ppy raug The gaskets around the door are worn and totally flat Cono te gaskets and exchange tierras per he assembly instructions The chimney is too large Contac chimneysw
9. begrenser eller evt spjeld Obs En lekkasje p bare 5 cm er nok til at 30 av den produserte varmluften forsvinner rett i pipa For mye trekk R ykvenderplaten kan sitte galt Kontroller monteringen av r ykvenderplaten se bruksanvisning Hvis du bruker ovnst rket tre krever dette mindre lufttilf rsel enn ved normal brensel Skru ned lufttilf rselen Tetingsb ndene ved d ren er nedslitte og trykket helt flate Kontroller tetningsb ndene Hvis disse er nedslitte skiftes de ut som beskrevet i bruksanvisningen Pipen er for stor Kontakt feier ovnsforhandler for ytterligere veiledning Glassruten sotes til Treet er for v tt Det b r kun brukes t rt tre med en maksimal fuktighet p 20 Luftventilen er lukket for mye Luftventilen pnes s det tilf res mer luft til forbrenningen Hvitt glass D rlig forbrenning for lav temperatur i ovnen F lg instruksjonene for riktig fyring som beskrevet i denne h ndboken Feil fyring fyring med avfallstre malt tre impregnert tre plastlaminat kryssfiner o l S rg for bruke rent og t rt brensel R yk ut i stuen n r d ren pnes Det oppst r en trykkutjevning i brennkammeret Lukk opp lufteventilen ca 1 min f r d ren pnes unng pne d ren raskt D ren pnes n r det er ild i brennkammeret pne d ren kun ved gl ding Hvit r yk Forbrenningstemperaturen er for lav k lufttil
10. claration issued by effect the draught should have a pressure of 14 to Company name Nordpeis AS 25 Pascal If necessary contact a professional for Address Gjellebekkstubben 9 11 Postal N 3420 Lierskogen assistance Country Norway Phone 47 32 24 47 00 Fax 47 32 24 47 11 Web www nordpeis no E mail post nordpeis no Nordpeis This product conforms to EN 13240 annex ZA Identification Nordpeis CASA SINTEF 110 0251 Product type Stove roomheater Stove type Welded and cast iron stove burning solid fuel Fuel type Firewood only follow user manual Flue gas mean temperature 280 C CO content at 13 Oz 0 14 E 75 mg sm Thermal output mean value 5 4 kW space heating output The stove needs to be placed ona plate of non Energy efficiency at 5 4 kW 78 A lt Minimum draughts o Di i combustible material e g concrete steel or afety measurements E Must be used in accordance with user manual 2 ES E E Combustible moter 650 mm side amp 100 mm rear amp 300 mm corner similar Flooring such as carpet cork and similar must be removed from under this plate Country Classification Standard Approved by EUR Intermittent EN 13240 per oe No Class II NS 3059 SINTEF NBL OL y ll stan Varre For your own safety comply with the assembly General Manager Nordpeis AS A a a a Snus instructions All safety distances are minimum SINTEF sinter ner titer bru Tiller N 7465 Trondheim NORWAY distances Installation of
11. den tilf rte luften ikke v re tilstrekkelig til oppn den n dvendige temperaturen og gassene vil forsvinne uforbrent ut gjennom pipen Derfor er det viktig tilf re luft til b let like etter at brenselet er lagt p slik at det er flammer i brennkammeret og gassene dermed forbrennes Bruk kl yvet ved fremfor rund stor ved Dette gir bedre varmeavgivelse og renere forbrenning Peisovner fra Nordpeis er konstruert og godkjent kun for fyring med ved Pipetrekk Pipa er en viktig faktor for f full utnytelse av ildstedet Selv den beste ovnen vil fungere d rlig hvis pipa ikke er riktig dimensjonert og i god stand Anbefalt trekk er fra 14 25 Pascal Advarsel Pass p at produktet ikke blir overopphetet det kan f re til uopprettelig skade p ovnen Slike skader omfattes ikke av garantien Trekkforhold Oppdriften styres hovedsaklig av r ykgasstemperatur utetemperatur lufttilf rsel og pipeh yde Trekken ker n r skorsteinen blir varmere enn utelufta den aktive lengden p skorsteinen ker over ildstedet god lufttilf rsel til forbrenningen Er pipe overdimensjonert i forhold til ildstedet kan det bli vanskelig oppn god trekk fordi pipa ikke blir godt nok oppvarmet Dersom det er mulig b r det settes inn et mindre piper r For kraftig trekk kan ogs avhjelpes med en trekkbegrenser Varmedanning og fordeling Vi skiller mellom str levarme og konveksjonsvarme I dobbeltvegg
12. ecific for this material and avoid soaking the varnished surfaces The best advice for cleaning the glass is to use a damp cloth or kitchen roll paper and apply some soot from the burn chamber Rub around the soot on the glass and finish off with a piece of clean and damp kitchen roll paper NB Only clean the glass when the stove is cold Depending on how frequently the fireplace is used it is necessary to change the gasket in the door in order to ensure that the stove is airtight and function optimally The glass borders must be unscrewed in order to change the gasket Ashes The ashes should be removed with regular interval how often depends of course on how much the stove is used Be aware that the ashes can contain hot ember even 24 hrs after that the fire has finished Use an inflammable container to remove the ashes It is recommended to leave a layer of ashes in the bottom as this further insulates the burn chamber NB Handle the Thermotte plates with care when emptying the ashes especially when using an ash spade Thermotte Plates insulation plates These heat insulating plates in the burn chamber contribute to a high combustion temperature a better gas exhaustion of the wood and a higher rate of efficiency The plates are not harmful and are exchanged when worn less than half of their original thickness Any fissures in the Thermotte plates will not reduce their insulation efficiency If you need new plat
13. ede ovner skapes en sirkulasjon av varmluft Luftrommet mellom ildstedets ytre og indre vegg varmes opp Denne oppvarmede luften stiger opp og ut gjennom ventiler plassert h yt p ildstedet Samtidig suges kald gulvluft inn i luftrommet gjennom spalter ventiler plassert lavt p ildstedet Str levarme er en direkte str ling fra en enkeltvegget ovn samt varmestr lingen gjennom glasset p alle ovner og peiser Denne varmen er intens og mer stillest ende enn konveksjonsvarmen Produktets overflatetemperatur blir h y og avstandskravet til brennbar vegg ker betraktelig Norsk 5 Sekund rforbrenning Nye ildsteder er konstruert slik at de forurenser lite samtidig som de utnytter veden mer effektivt Dermed trenger du mindre ved for oppn samme varmeeffekt noe som igjen f rer til mindre aske Nordpeis peisovner har sekund rforbrenning Ved sekund rforbrenning skjer forbrenningen i to trinn F rst brenner veden deretter antennes r ykgassene av forvarmet luft Milj messige hensyn V re ovner representerer en ny generasjon ildsteder som gir bedre varmeeffekt er rentbrennende og som ved riktig fyring ikke avgir store mengder sot og partikler I tiden fremover er det ikke bare konomiske krav til energibruk som er overordnet Krav til milj l sninger skjerpes ogs mer og mer Det vil si at vi skal bruke fornybare energikilder som er lite forurensende eller skadelige for milj et Trevirke g r under betegnelse
14. eeper or other professional for more details The glass is The wood is too wet Only use dry wood with a humidity of maximum 20 sooty The air vent control is too closed Open the air vent control to add air to the combustion Bad combustion the temperature is too low Follow the guidelines in this booklet for correct heating White glass Using wrong material for combustion such as painted or impregnated wood plastic laminate plywood etc Ensure to use only dry and clean wood Smoke comes A levelling out of pressure occurs in the burn Open the air vent control for about 1 min before opening the out of the chamber door avoid opening the door too quickly insert when the door is The door is opened when there is a fire in the burn Only open the door when there is hot ember opened chamber The combustion temperature is too low Increase the air supply White smoke The wood is humid and contains water damp Ensure to use only dry and clean wood Black or grey black smoke Insufficient combustion Increase the air supply English 13 Casa mm 228 855 425 14 00 lt FIG 1 gt 930
15. eld trekkventiler eller d rer p ildsteder som ikke er i bruk som st r pne og skaper falsk trekk Steng spjeld d rer og trekkventiler p ildsteder som ikke er i bruk pent hull i skorstenen eller ildsteder som er fjernet og skaper falsk trekk Hull m mures igjen Defekt murverk i skorstenen f eks utetthet rundt r rgjennomf ring og eller delagt skillevegg mellom r ykl p som skaper falsk trekk Tett igjen og puss alle sprekker og utettheter For stort tverrsnitt i skorstenen gir liten eller ingen trekk Skorstenen m rehabiliteres evt montering av r yksuger For lite tverrsnitt klarer ikke transportere all r ykgass ut Bytt til et mindre ildsted eller bygg ny skorsten med st rre tverrsnitt Evt montering av r yksuger For lav skorsten som gir d rlig trekk k skorstensh yden lldstedet ryker inne n r det er vind ute Skorstenen ligger for lavt i forhold til omkringliggende terreng bygninger tr r e l Forleng skorstenen Evt monter skorstenshatt eller monter r yksuger Turbulens rundt skorstenen pga for flatt tak k skorstensh yden og eller monter skorstenshatt lldstedet varmer for d rlig Ildstedet f r for mye surstoff til forbrenningen pga lekkasje i underkant av ildstedet el for stor skorstenstrekk Vanskelig regulere forbrenningen og veden brenner fort opp Eventueller lekkasjer m tettes Skorstens trekken kan reduseres ved hjelp av en trekk
16. ely fill up the burn chamber with wood as this can reduce the lifespan of the Thermotte plates significantly as it can cause fissures in the plates Some technical information on combustion In order to obtain an optimal combustion the temperature needs to reach 600 800 C It is recommended to keep an even fire with a small amount of wood If too many logs are put on the hot ember the air supply will not be sufficient for reaching the require temperature and the gases will go out un burnt For this reason it is important to increase the air supply just after adding the logs in order to have proper flames in the burn chamber so that the gases are burnt Use split wood logs rather than whole round pieces of wood This will give a better heat effect and cleaner combustion The stoves from Nordpeis are intended for and only approved for wood combustion Chimney Draught The chimney is an important factor for getting the most out of the hearth Even the best stove will not work properly if the chimney does not have the right dimensions or is not in good working order Recommended draught is 14 25 Pascal Warning Be careful that the product is not overheated as this can cause irreparable damage which is not covered by the warranty Draught Conditions The draught is mainly controlled by gas temperature outside temperature air supply and the height of the chimney The draught increases when The chimney becomes warme
17. er part Wall vent inner part Hose clamp x 2 Screws and plastic plugs x 4 NO oh O N On the bottom plate at the back of the stove FIG 2 there is a lid that can be removed so that a the fresh air supply tube can be connected The lid is removed be hitting it gently with a hammer See FIG 2 A D for different installation variations The flue outlet collar on the stove has an outer diameter of 64mm A Indirectly through outerwall B Through outerwall C Through floor and basement D Through floor and plate in the ground In order to avoid condensation in hot rooms the air supply tube must me isolated with 30 mm mineral wool that is sealed of with a humidity membrane When installing the air channel it is important that the space between the tube and the wall or floor is proerly sealed off In case the tube is longer than 1m the diameter needs to be increased to 100mm 5 Assembly The following tools are necessary 5mm Umbracco key Caulking gun for the stove cement Ensure that all loose parts are included A Glove and lighter B Assembly instructions Casa is delivered as standard with the flue outlet collar on the top In order to change to a back mounted flue outlet FIG 3 1 8 Remove the entire loose lid on the top Unscrew the collar with a 5 mm Umbraco key Remove the perforated plate in the surround Remove the perforated plate in the heat shield Unscrew the cast iron lid Screw in place the
18. es contact your dealer Their original thickness is 25 mm Please note Too long wood logs can cause additional strain and crack the plates due to the tenstion created between the sideplates Cleaning and Inspection The stove should be inspected thoroughly and cleaned at least once per season possibly in combination with the chimney and chimney pipes being swept Ensure that all joints are tight and that the gaskets are rightly positioned Exchange any gaskets that are worn or deformed 8 Warranty The steel stoves from Nordpeis AS benefit of a 5 year warranty Any claim during this period should primarily be made to the dealer who sold the stove The warranty does not include normal wear and tear on items such as Thermotte plates smoke baffle glass and gaskets New parts can be ordered at your dealer The warranty does not include damages that are caused by wrong handling or misuse of the stove see section Advice on lighting a fire The warranty only entails the product There is no compensation for third party damage or damage to other items caused by use of the stove Demounting remounting delays and transport are not covered for any fault that can be noticed before assembly A dated invoice is required for any repair covered by the warranty English 11 The stoves have a plaque with the SINTEF number on the inside of one of the legs Casa Sintef nr 110 0251 Complete product documentation can be downloaded at www
19. es og klargj res for tilf rsel av forbrenningsluft utenfra Ogs i eldre hus kan bruk av uteluft tilf rselssett anbefales da ildstedets forbrenning blir mindre p virket av kj kkenvifter v tromsventilasjon osv Utilstrekkelig tilf rsel av luft utenifra medf rer undertrykk i rommet der ildstedet st r og dermed d rlig fororenning med problemene det medf rer soting p glass d rligere utnyttelse av veden og nedsoting av pipa Skorsteinstrekk Sammenlignet med eldre og ikke milj godkjente ovner stiller dagens moderne ovner betydelig st rre krav til pipen Trekket p virkes fremfor alt av pipens lengde og diameter Anbefalt pipelengde er minst 4 meter over r ykinnf ringen med en diameter p 150 200 mm Ved nominell effekt skal trekket ha et trykk p mellom 14 og 25 Pascal Ved behov ta kontakt med en feier p forh nd Krav til gulvplate Det kreves 30 cm gulvplate p ildstedet dersom brennbart gulv Peisovnen skal plasseres p en plate av ubrennbart materiale f eks betong st l eller lignende Gulvbelegg som teppe kork og lignende under dette materialet m fjernes For egen sikkerhet f lg monteringsanvisningen Alle sikkerhetsavstander er minimumsavstander Installasjon av ildsteder m v re i henhold til det enkelte lands lover og regler Nordpeis AS st r ikke ansvarlig for feilmontering av ildstedet 2 Norsk 2 Teknisk informasjon Ovnen er rentbrennende Med dette menes at den ha
20. este m ten tenne opp et ildsted er ved bruk av opptenningsbriketter Aviser gir mye aske og trykksverten er ikke bra for milj et Reklamer magasiner og melkekartonger mm er ikke egnet for opptenning i ildsteder Advarsel Bruk ALDRI impregnert tre malt tre plastlaminat kryssfiner sponplater avfall melkekartonger trykksaker eller lignende Ved bruk av disse materialene bortfaller garantien da de kan inneholde giftige etsende og farlige damper n r de forbrennes Videre kan de utvikle den giftige gassen dioksin som kan skade ovnen og milj et Det er sv rt viktig av man alltid bruker ren og t rr ved Fuktig ved krever mye luft til forbrenningen siden det m brukes ekstra energi varme til t rke ut det fuktige treet Varmeavgivelsen er derfor minimal Samtidig f rer det til sotdannelse i pipen med fare for beksot og pipebrann Feil fyring For stor lufttilf rsel til forbrenningen gir en ukontrollerbar flamme som sv rt raskt vil varme opp hele peisinnsatsen til en ekstremt h y temperatur gjelder ved fyring med lukket eller nesten lukket d r Fyll aldri opp peisovnen helt opp med ved Levetiden p thermotteplatene reduseres vesentlig ved et overfylt brennkammer da det lettere oppst r sprekker Litt teknisk om fyring For oppn en optimal forbrenning m temperaturen opp til 600 800 C Det er best fyre jevnlig med en liten mengde ved Hvis det legges for mange vedkubber p et gl delag vil
21. f rselen Treet er for fuktig og inneholder vanndamp S rg alltid for bruke ren og t rr brensel Svart eller Ufullstendig forbrenning k lufttilf rselen gr svart r yk Norsk Kontrollskjema Nordpeis SJEKKLISTE OG BEKREFTELSE PA UTF RT KONTROLL AV ILDSTEDSMONTERING Eiendommens adresse Gnr Bnr TIf Eiers navn Adresse Postnummer Sted Montgrens navn Adresse Postnummer Sted lldstedstype og fabrikk Effekt i kW Brenseltype Skorstenstype Eks tegl type elemtskorsten Dimensjon i cm Ant ildsteder pa skorstenen Installasjonen er kontrollert av Adresse Postnummer Sted Kvalifikasjon Folgende ble kontrollert av montor under installasjonen Kontrollpunkt Ja Nei Er ildstedet montert etter monteringsanvisning a 3 Er avstanden til brannmur kontrollert Er avstanden til brennbart materiale kontrollert Er avstanden til tak kontrollert 3 a Er det plate under og foran ildstedet Taler gulvet vekten av ildsted med omramming Er det feiemuligheter for ildsted og r ykr r Er ildstedet sikret nok tilforsel av forbrenningsluft via lufteventiler over vindu O O Er r ykr ret montert i skorstenen etter skorstensprodusentens anvisninger Er skorstenen egnet for tilkobling av det aktuelle ildstedet Har skorstenen passende dimensjon a Finnes produktdokumentasjon med
22. fornybar ressurs biobrensel Norsk R d og tips ved problemer med forbrenningen Feil Forklaring Utbedring Manglende trekk Pipen er tilstoppet Roykroret er tilsotet eller det er sotansamling p r ykvenderplaten R ykvenderplaten kan sitte galt Kontakt feier ovnsforhandler for ytterligere informasjon eller rens r ykr r og brennkammer lldstedet ryker under opptenning og drift Undertrykk i rommet der ildstedet st r For lite trekk huset er for tett Sjekkes ved fyre opp med et pent vindu i rommet Hjelper dette m det installeres flere st rre ventiler Undertrykk i rommet kj kkenvifte og eller sentralt ventilasjonsanlegg trekker for mye luft ut av rommet Sl av reguler kj kkenvifte og eller annen ventilasjon Hjelper dette m det settes inn flere ventiler i rommet R ykr r fra to ildsteder er tilsluttet skorsten i samme h yde Monteres om H ydeforskjell mellom r ykr r b r v re minst 30 cm R ykr ret heller nedover R ykr r m flyttes slik at det er stigende fra ildsted til skorsten min 10 grader Evt montering av r yksuger R ykr ret stikker for langt inn i skorstensl pet R ykr r m monteres om Skal avsluttes 5 mm f r skorstenens innervegg Evt montering av r yksuger Feieluke i kjeller eller loft som st r pen og skaper falsk trekk Feieluker m alltid v re lukket Utette eller defekte feieluker m skiftes Spj
23. irekte gjennom yttervegg l Gjennom yttervegg J Gjennom gulv og krypkjeller K Gjennom gulv og plate p bakken For unng kondens i varme rom m kanalen isoleres med 30 mm mineralull som forsegles med fuktsperre byggeplast I gjennomf ringen er det viktig tette mellom r ret og veggen alt gulvet med tetningsmasse Ved lengre r r enn 1 m skal r rdiameteren kes til 100 mm og tilsvarende st rre veggventil velges Viktig S rg for at det er 40 mm avstand mellom kondensisolering og peisovnens bunn 5 Montering Du trenger f lgende verkt y 5 mm Umbraco n kkel Fugepistol til ovnskitt 1 Se at alle l se deler medf lger A Hanske B Monteringsanvisning Casa leveres med toppmontert r ykstuss som standard For endre til bakmontert stuss FIG 3 1 8 Fjern hele det l se topplokket Skru av r ykstussen med en 5 mm umbraco n kkel Sl ut det perforerte pyntelokket i omrammingen Sl ut det perforerte lokket i varmeskjoldet Skru av st pejernslokket Skru p plass r ykr rstussen p bakuttaket Skru p plass st pejernslokket p topputtaket Legg p plass topplokket Na ONO Q Funksjoner FIG 4 1 5 1 Doren pnes ved trekke handtaket ut og opp 2 Askeskuffen trekkes ut i front 3 Askeristen skyves ut og inn for fjerne aske fra brennkammeret 4 Ventilen for forbrenningsluft justeres ved hjelp av hjulet i front under d ren 5 L
24. ng da det kan skade lakken Dette gjelder bare n r ovnen er ny og lakken fersk Opptenning Legg inn t rr sm ved tenn opp og la flammene f godt tak i veden f r d ren lukkes F r d ren lukkes pnes ventilen for forbrenningsluft FIG 4 4 N r flammene er stabile og pipen er blitt varm justeres lufttilf rselen med denne denne regulatoren N r det er dannet et gl dende kullag kan ny ved legges inn N r du legger inn ny ved husk dra gl rne frem i ovnen slik at den nye veden antennes forfra B let skal brenne med friske livlige flammer bl flammer betyr meget god forbrenning Sv rt lav forbrenningseffekt og fors k p rundfyring er uheldig med ket forurensning og ket fare for pipebrann Optimal regulering av luftventilen krever litt erfaring N r du har fyrt i ovnen en stund vil du finne en naturlig fyringsrytme Advarsel Fyr aldri slik at ovn eller r r blir r dgl dende Steng topptrekksregulatoren hvis dette skjer 7 Vedlikehold Husk at peisovnen alltid m v re kald f r du inspiserer den D r Glasset i d ra er keramisk og m ikke utsettes for rengj ringsmidler som inneholder slipemiddel Bruk glassrens som er beregnet for dette og unng s l av glassrens p lakkerte flater Det beste tipset til rengj ring av glasset er bruke en fuktig klut eller kj kkenpapir og ta p litt sot fra brennkammeret Gni asken rundt p glasset og avslutt med et rent og fuktig kj kkenpa
25. ngen Minste avstand til brennbart materiale 650 mm side amp 100 mm bak amp 300 mm hj rne mo cum non OL y Yhaullne Godkjennt av SP Technical Research Institute of Sweden SINTEF NBL Stian Varre Daglig leder Nordpeis AS Testrapport SINTEF NBL 102041 83 SINTEF NBL Tiller bru Tiller SINTEF w Test reports P6 02886 F P 7465 Trondheim NORGE Certificate no 22 03 15 SP Technical Research Institute of Sweden Certification Box 857 SE 501 15 Bor s SVERIGE 1 F r du installerer peisovnen Installasjon og kontroll f r bruk Installasjon av nye ildsteder skal meldes til de lokale bygningsmyndigheter Huseier st r selv ansvarlig for at alle krav til sikkerhet er ivaretatt p en forskriftsmessig m te og er forpliktet til f installasjonen inspisert og sikkerheten bekreftet av en kvalifisert kontroll r Kvalifisert kontroll r kan v re feier murmester varmeforhandler eller andre med tilstrekkelig kompetanse Det er ogs en fordel at du kan dokumentere denne kontrollen skriftlig Lokalt feievesen m informeres dersom installasjonen medf rer endret feiebehov Tilf rsel av luft Uteluft tilf rselssett f s kj pt som tilbeh r og sikrer da at tilf rsel av forbrenningsluften til peisovnen blir mindre p virket av ventilasjonsanlegg kj kkenvifter og andre forhold som kan medf re undertrykk i rommet der ovnen st r alle nybygg anbefaler vi p det sterkeste at det prosjekter
26. of at least 30 cm e a Pe The flue must be moved so that there is an inclination of at The flue is in a declining position from the smoke A E least 10 from smoke dome to chimney Possibly install a dome to the chimney f smoke suction device The fue iS too tar into he chimre The flue must be remounted Should end 5 mm before the Abe insert y chimney inner wall Possibly install a smoke suction device release smoke when Soot hatch in the basement or attic that is open and Soot hatches must always be closed Hatches that are not tight lighting the thus creating a false draught or defected must be changed fire and during Damper top draught vents or doors on fireplaces that Close damper doors and top draught vents on fireplaces that combustion are not in use are not in use are open and create a false draught An open hole in the chimney or a fireplace that has been removed thus creating a false draught Holes must be completely closed Defect masonry in the chimney e g it is not airtight around the flue pipe entry and or broken partition inside the chimney creating a false draught Seal and plaster all cracks and sites that are not tight The cross section in the chimney is too large which results in no or very low draught The chimney must be refitted possibly install a smoke suction device The cross section in the chimney is too small and the chimney cannot carry out all the smoke Change to a sm
27. peisovnen inspiseres grundig og rengj res gjerne i forbindelse med feiing av skorstein og piper r Se til at alle sammenf yninger er tette og at pakninger ligger riktig Pakninger som er slitt eller deformert b r skiftes ut 8 Garanti P peisovnene fra Nordpeis AS gis 5 rs garanti Ved eventuell reklamasjon i garantiperioden skal henvendelsen skje til forhandleren som har solgt ovnen Garantien omfatter ikke thermotteplater 4 Norsk r ykvenderplater glass og pakninger Dersom det ovennevnte g r i stykker eller m skiftes ut p grunn av slitasje kan nye deler bestilles hos din forhandler Garantien omfatter ikke skader som er oppst tt p grunn av feil betjening eller bruk eksempelvis overoppheting av ovnen med bakgrunn i feil luftregulering eller bruk av feil brensel Ved garantireparasjon omfatter garantien kun produktet Det gis ikke st tte til demontering transport og oppmontering av peisovn Det gis ingen erstatning for f lgeskader og skader p ande gjenstander som skyldes bruken av ovnen I forbindelse med garantireparasjoner m det forevises datert faktura Ovnen er utstyrt med Sintef nr 110 0251 Fullstendig produktdokumentasjon kan lastes ned p www nbl sintef no CE merkingen er plassert til venstre innenfor bunnluken 9 Fyringstips Advarsel Bruk ALDRI opptenningsveske som bensin parafin r dsprit eller lignende til opptenning Du kan skade b de deg selv og produktet Den b
28. pir NB Rengj ring av glasset m kun gj res n r ovnen er kald Avhengig av hvor hyppig ildstedet brukes er det n dvendig skifte tetningslistene p d ren for sikre at peisovnen fortsatt er tett og fungerer optimalt Disse f s kj pt som sett med keramisk lim inkludert Glasslistene m skrus ut for skifte d rpakningen Aske Asken b r t mmes med jevne mellomrom hvor ofte avhenger naturligvis av hvor mye du bruker ovnen V r oppmerksom p at asken kan inneholde gl r selv et d gn etter at ilden er opph rt Bruk en beholder av ikke brennbart materiale til fjerne asken Det anbefales imidlertid la det ligge et lag aske i bunnen da dette bidrar til isolere brennkammeret NB V r varsom med thermotteplatene ved t mming av aske spesielt ved bruk av askespade Thermotteplater isolasjonsplater De varmeisolerende platene i brennkammeret bidrar til gi hoy forbrenningstemperatur bedre avgassing av veden og h yere virkningsgrad i ovnen Platene er ikke helseskadelig og byttes etter slitasje under halv tykkelse av opprinnelig Eventuelle sprekker i thermotteplatene forringer ikke isolasjonsevnen For nye plater ta kontakt med din forhandler Opprinnelig tykkelse er ca 25 mm Merk Ved bruk av for lang ved vil det medf re ekstra belastning som kan knekke platene dersom veden blir liggende i spenn mellom sideplatene Rengj ring og inspisering Minst en gang i l pet av fyringssesongen b r
29. r minimalt utslipp av sotpartikler og uforbrente gasser for eksempel CO Fyr utelukkende med ren og tgrr ved Materiale Stopejern platest l Overflatebehandling Lakk Brensel Ved 30 cm Effekt 3 7 kW Trekksystem Ventil for forbrenningsluft Forbrenningssystem Sekundeerforbrenning ren forbrenning Oppvarmingsareal Inntil 100 m2 Roykuttak Topp og bakuttak Roykror 150 mm Mulighet for st lpipe Ja Vekt 112 kg 3 Brannmur FIG 1 Sgrg for at angitte sikkerhetsavstander ikke underskrides Mobleringsavstand foran ildstedet er minimum 1 meter Ved toppmontering til st lpipe henviser vi til respektive fabrikats monteringsanvisning Overhold de sikkerhetsavstandene montering av st lpipen krever 4 Tilforsel av forbrenningsluft Ekstra tilf rsel av forbrenningsluft kan tilf res direkte via en kanal utenifra eller indirekte via en ventil i ytterveggen i det rommet peisovnen er plassert i Deleliste friskluftssett FIG 2 Aluminiumslange Isolering Overgangsstuss fra 65 til 100 mm Veggvetil ytre del Veggventil indre del Slangeklemme x 2 Skrue og plastplugg x 4 O Q O N I fotplaten bak p peisovnen FIG 2 finnes det et brytelokk for gjennomfgring av tilluftsslangen Brytelokket sl s ut med en hammer Se FIG 2 A D for noen installasjonsalternativer Avslutningsstussen p peisovnen har en utvendig diameter p 64 mm H Ind
30. r than the outside air The active length of the chimney increases over the hearth Good air supply to the combustion It can be difficult to obtain the right draught conditions in case the chimney is too large in relationship to the fireplace as the chimney does not heat up well enough If possible stove a smaller chimney pipe Draught that is too strong can also be controlled with a damper Heat Creation and Distribution There are two different types of heat radiation and convection heat The heat created in the space between the stove and surround is what is called convection heat Cold air is sucked in at floor level under the stove The stove then heats up this air which expands and as a result blows out through the vents on top of the surround This heat circulation ensures a good distribution of heat throughout the home The best location for the fireplace is in the middle of the house in the room that requires the most heating The heat released from the front of the stove is what is called radiation heat Secondary Combustion This new type of stoves is constructed so that it pollutes very little and at the same time it uses the energy of the wood efficiently Hence with less wood the same heat effect is achieved and thus less ashes The stoves from Nordpeis have secondary combustion i e the combustion happens in two phases first the wood burns and then the gases from the fumes are lit by the hot air Respect
31. st time 44 check local regulations concerning distance from i stove to combustible flammable materials insulation 7 Maintenance 11 materials requirements between stove and back wall 8 Warranty 44 Size of floor plates in front of stove if required fluepipe i i connection between stove and chimney and insulation 9 Advice on making up a fire 12 requirements if fluepipe goes through flammable wall Combustion complications 12 such as a wood wall Some technical information on combustion 12 Chimney Draught 12 Air Supply Heat Creation and Distribution 12 A set for fresh air supply is available as an accessory Respect for the Environment 12 and will ensure that ventilation systems kitchen fans Some advice in case of combustion problems 13 and other factors that can create a downdraught in the room of the fireplace affect less the air supply to the stove Insufficient air supply can cause downdraught NB COMPLIES WITH NORWEGIAN SAFETY and thereby low combustion efficiency and the REQUIREMENTS problems that this entails soot stains on the glass inefficient use of the wood and a soot deposits in the chimney Chimney Draught The draught is firstly affected by the length and cross section of the chimney Recommended chimney height is at least 4 metres EC CONFORMITY DECLARATION from where the flue pipe is connected to the chimney Date of issue 04 06 2008 with an internal diameter of 150 200 mm At nominal Conformity de
32. the stove must comply with the rules and regulations of the country Test reports P602886 F Certificate no 220315 where installed Nordpeis AS is not responsible Y Certification Bor 857 SE S01 15 Borde SWEDEN for wrongly assembled stoves English 9 2 Technical Information This is a clean burning stove which has a minimal emission of soot particles and un burnt gases e g CO Use exclusively clean and dry wood Stove Casa Material Cast iron sheet steel Surface treatment Varnish door doorframe Fuel Wood logs 30 cm Operating range 3 7 kW Draught system Air vent control Combustion system Secondary combustion clean burning Heating area Until 100 m2 Flue outlet Top and posterior Flue 150 mm Weight of stove 112 kg 3 Distance to combustible material FIG 1 Ensure that the safety distances are respected The distance from the front of the stove to furniture needs to be of at least 1 metre When connecting a steel chimney to the top outlet use the security distances required from the manufacturer 4 Fresh air supply Additional supply of combustion air can be added directly by channeling it directly from the outside or indirectly by a vent in the exterior wall of the room where the stove is situated List of parts for fresh air supply set FIG 2 Aluminium hose Insulation Transition collar from 65 to 100 mm Wall vent out
33. uken under d ren pnes og lukkes med et lett trykk p h yre side av d ren Thermotteplatene Thermotteplatene FIG 5 er i fire deler og kommer ferdig montert i peisovnen Skulle det v re behov for erstatte eller bytte ut enkelte thermotteplater kontakt din forhandler Se avsnitt om vedlikehold A R ykhvelvplaten B Sideplate C Sideplate D Bakplate Evt demontering av thermotteplatene p f lgende m te 1 L ft opp r ykhvelvplaten A med en h nd 2 Plukk ut sideplaten B eller C 3 Senk ned r ykhvelvplaten A og fjern alle biter Norsk Kontroll av funksjoner N r peisovnen er oppstilt kontroller at funksjoner fungerer lett og virker tilfredsstillende Ventil for forbrenningsluft Venstre posisjon Lukket Midtre posisjon Normal pning H yre posisjon Full pning D r H ndtaket vender ned Lukket H ndtaket vender opp pent 6 F rste opptenning N r peisovnen er p plass og alle forskrifter er overholdt kan det tennes opp V r oppmerksom p f lgende Rgykvenderplaten og thermotteplatene kan knekke ved kraftig st t Disse omfattes ikke av garantien og du b r derfor unng kraftige st t n r du legger ved inn i brennkammeret Det er lurt s rge for god utluftning ved f rste fyring da lakken p innsatsen vil avgi r yk og lukt Denne r yken og lukten er ikke farlig og vil forsvinne Advarsel V r varsom med ber ring av ovnen ved innfyri
Download Pdf Manuals
Related Search
Related Contents
View installation guide Zyklonstaubsauger Power Pro Cyclone Vacuum - maxx intext:Betriebsanleitung filetype:pdf MD-11/ MD-14 DW917K2 DW921K2 DW922K2 - Service après vente Service Manual 3155 (Combo 3/6) Combination Snack/Beverage 11.11 PVC Setup Screen Betriebsanleitung Copyright © All rights reserved.
Failed to retrieve file