USER MANUAL - Tata Swach
Contents
1. Feed water water E Drain water PACK CONTENTS 1 Swach Silver RO Purifier 1 RO Membrane User Manual ww ge Installation accessories e 2Self Tapping Screws e 2 Plastic Anchor Plugs e Flexible Pipe 1 4 OD e Ball Valve e Adaptor to mount Ball Valve ELECTRONIC CIRCUIT DIAGRAM Power Supply Feed Water 2 5 STAGE PURIFICATION Stage 1 Sediment Filter Cartridge Coarse This is the first filtration process which reduces removes impurities from the inlet water These impurities may be particles such as dust and sediments which are above 10micron in size The life of first sediment filter depends upon the inlet water quality If this cartridge chokes the low pressure switch will be activated and the Double i Care indicator will show a fault indication Recommended replacement cycle 6 months Stage 2 Bacteriostatic Granular Activated Carbon GAC with Nano Silver Impregnation technology This GAC Cartridge reduces chlorine bad taste and odor from the inlet water It also reduces volatile organic compounds and pesticides from water The Nano silver impregnation technology used in this cartridge ensures improved bacteriostatic performance for the entire life of the carbon capacity This Special Silver Safety of the bacteriostatic GAC greatly reduces the chance of bio fouling and hence increases the life of carbon cartridge Recommended replacement cycle 6 months 62. The product s plastic body is not covered under Warranty and hence it must be handled with care to guard against breakage during transit and usage The customer will notify TCL customer care promptly about any defects noticed and give the ASP adequate opportunity to inspect test and remedy them for which the customer will deposit the purifier if necessary with the company s service centre along with original invoice in the city where the product was purchased Product so deposited for Warranty examination must be shipped freight prepaid TCL will be entitled to repair replace the defective part and retain the replaced part This Warranty is void if the unit is not installed by ASP and also if not operated under normal municipal well water conditions or is subjected to the temperature above 35 C This warranty is void if any kind of repair or alteration is done by customer or unauthorized service provider or for failures resulting from the lack of proper maintenance or faulty electrical conditions or non usage of Tata Swach genuine spare parts Input water pressure needs be between 5 PSI and 35 PSI In case it is more than 35 PSI you need to use a pressure reducing valve and in case it is less than 5 PSI you need to use a pressure booster pump Incase consumer chooses not to install the required any replacement of damages parts due to fluctuating input pressure shall be on payable basis 14 10 11 12 13 1
3. must to understand normal osmosis Osmosis is a natural process that occurs in all living things For instance osmosis permits water and nutrients absorption through the root system of plants similarly nutrition is assimilated from blood to cells in human bodies So if a semi permeable membrane separates a dilute solution and a concentrated solution pure water will flow from dilute to the concentrated side and will try to balance the concentrations on both sides This phenomenon is called Osmosis The RO membrane is not permeable to dissolved salts and only pure water can move across a RO membrane If pressure is applied to the concentrated solution side the flow of water across a membrane can be reversed This phenomenon of moving pure water across membrane from a high TDS solution is called as Reverse Osmosis Hence in Reverse Osmosis as the water exerts pressure on a semi permeable membrane the purified or permeate part enters through the pores of the membrane while the rejected or concentrate is diverted to the drain When the diameter of the pores is as low as 0 0001 microns pure water and a little quantity of minerals sodium potassium calcium and magnesium etc can pass through while other substances such as dissolved solids bacteria viruses metals pesticides chemical products etc are rejected during the process This gives you clean and safe drinking water for consumption 2 Water g pressure
4. or its ASP In all such cases regular charges will apply This limited Warranty does not include service to diagnose a claimed malfunction in this unit TCL reserves the right to alter or improve design and specifications of Tata Swach Silver RO at any time without any contingent obligations to prospective buyers or owners of the products previously sold Any disagreements and obligations based upon the purchase of Tata Swach Silver RO products and thereby imposed on TCL or its ASP shall be governed by and construed according to the laws of India and subject to the jurisdiction of Mumbai Courts only In case of product related queries or complaints kindly report the same on our Toll Free no 1800 2 585858 or mail us at tataswach tatachemicals com 15 EY WARRANTY CARD to be filled by service provider Company Copy Customer Copy Product Details Model name Model Serial No Customer Details Name Telephone No Address Email Purchase Details Retailer Name City Invoice No Invoice Date Invoice amount Installation Date Service Providers Details Name Address phone no Customer Signature Service Provider s Stamp Marketed By Tata Chemicals Ltd 16 Product Details Model name Model Serial No Customer Details Name Telephone No Address Email Purchase Details Retailer Name City Invoice No Invoice Date Installation Date Service Providers Details Name Address phone no Customer Signature S
5. through the cartridge The life of 3rd stage sediment filter depends upon the input water quality Standard test conditions have ISO coarse A4 dust in water which is passed through the cartridge for 6000Liters at a pressure of 60psi AUnder standard test conditions of running the system at 10psi input pressure TDS upto 750 PPM turbidity less than 5 NTU and temperature of 25 C Depending upon the inlet hardness and TDS levels the membrane may need to be replaced earlier than 2 years The life of GAC cartridge depends upon the organics chlorine etc present in the input water supply Under standard test conditions the life is measured as 12000 liters with 2 ppm chlorine water passing through the cartridge yf ADVANCED FEATURES OF YOUR TATA SWACH PLATINA SILVER RO WATER PURIFIER Purification rate 12 0 Liters hour Auto Flush Mechanism Automatic Membrane Protection Auto Low pressure cut off Automatic system switch off below 5 psi pressure in input water to avoid dry running of booster pump Inlet water switch off mechanism Blocks inlet water supply when no power is available to the system or system is not purifying Special Silver Safety Nano Silver Impregnation technology which imparts longer life to cartridges Double i Care indicators Provides intelligent information through E Rem Zero Contamination Storage Tank Saves you from the hassle of cleaning C ee Stylish faucet tap To match your modern lifestyle Adva
6. 000Ltr Stage 3 Sediment Filter Cartridge Fine This is the third filtration process which reduces removes finer impurities from the inlet water which may have passed through the earlier two stages These impurities may be particles such as dust and sediments which are above 5 micron in size Recommended replacement cycle 6 months 6000Ltr Stage 4 RO Membrane This is the heart of your Tata Swach Silver RO Water Purifier This National Science Foundation US NSF certified membrane has fine pores as low as 0 0001 micron in size to reduce water contaminants such as dissolved salts pesticides heavy metals and water borne micro organisms such as virus bacteria etc 100 dry membrane that comes with your system maximizes shelf life and is put in your system at the time of installation Recommended replacement cycle 2 years Stage 5 Bacteriostatic Granular Activated Carbon GAC with Nano Silver impregnation technology This Post Carbon GAC cartridge imparts bacteriostatic property to the purified water and enhances the taste of water Recommended replacement cycle 1 year 12000 Ltr If this cartridge chokes sooner than the recommended replacement cycle it is advisable to install a pre filter available separately at a cost The life of GAC cartridge depends upon the organics chlorine etc present in the input water supply Under standard test conditions the life is measured as 6000 liters with 2 ppm chlorine water passing
7. 4 15 TCL or its ASP shall not be held liable for claims exceeding the cost of repair of the defects in workmanship This Warranty Agreement shall not be interpreted to render TCL or its ASP liable for injuries or damages of any kind direct consequential or contingent to persons or property TCL or its ASP shall not be held responsible by representative or buyer for failure to abide by any of the obligations of this Warranty Agreement if such failures are the result of circumstances of Forces Majeure including but not limited to Acts of God like floods earthquakes etc or transportation strikes labour disputes with outside suppliers or any other conditions beyond the control of TCL or its ASP TCL or its ASP cannot and shall not be held liable for any sickness or illness due to the consumption of drinking water from any water purifier supplied by TCL since TCL or its ASP does not have any control over the quality of input water maintenance of purifier and storage and consumption conditions of purified water This Warranty Agreement excludes all products component parts or damage to any part of this water purifier which in the opinion of TCL or its ASP have been subjected to misuse misapplication negligence alteration accident or operation contrary to TCL instructions or incompatibility with accessories not installed by TCL or its ASP or that have been repaired with component parts other than those manufactured by or obtained from TCL
8. TATA PLATINA SILVER RO WATER PURIFIER Contact us Toll Free Number 1800 2 585858 Email tataswach tatachemicals com Visit www tataswach com TATA PLATINA SILVER KO Water Purifier THE RO WATER PURIFIER on a e fie a E nd 00 B E A Q USER MANUAL vs 0 EL cw s 4 e Mure 6 5 De y my g Table of Content Sr No Content PageNo 4 Electronic Circuit Diagram 3 Purification Process Diagram Tata Swach Silver RO purifier 7 7 10 12 14 16 6 8 9 1 Welcome Note Dear Customer Congratulations for bringing home the new Tata Swach Platina Silver RO Being the health minister of your home it is your conscientiousness to safeguard your family from water borne diseases The new Tata Swach Platina water purifier includes the advanced RO technology and Special Silver Safety which acts as a shield of purity Its user friendly features like Double i Care indicators Modern Snap Button fitment and Zero contamination concealed storage tank ease your Mission Swach Jal by consistently providing clean and pure drinking water for your family This user manual will help you know your Tata Swach Platina Silver RO Water Purifier For any assistance we are just a call away 1800 2 585858 Tata Swach Team 2 THE TECHNOLOGY IN YOUR PURIFIER RO To fully understand the technology of Reverse Osmosis it is a
9. d to drain out the stored water if not consumed within two days How can use the rejected water It is not recommended to use reject water for any kind of consumption However you can use it for gardening or cleaning floors What should I do if any part of purifier gets broken Please call the Tata Swach Toll free number 1800 2 585858 Our technician will visit your house and guide you on the repairs required There will be a nominal visiting charge and all replacements shall be on a chargeable basis Can open and service my Tata Swach Platina Silver RO It is not recommended to open and service the purifier yourself Call our customer care if you face any issue which requires servicing or opening the purifier 12 What should do if the output water tastes unusual This might be because of one or more of the following reason Water is stored for too long in the storage tank Please drain the stored water and fill fresh water The filters membrane need to be replaced Call Tata Swach customer care and get replaced or cleaned The input water quality has changed This will lead to a sudden change in the output water taste Please call the Tata Swach customer care to get your system checked What should do if the purification is taking more time This might be because of one or more of the following reason The ball valve may not be open fully Please ensure that ball valve is open completely so that the water flow is not
10. ect sunlight and high humidity environment The optimal room temperature for the unit is 4 C 50 C 11 EY FAQ TROUBLESHOOTING What is the storage capacity of my Tata Swach Platina Silver RO Tata Swach Platina Silver RO has tank volume of 7Itrs The process of filling the tank is fully automatic and when you take water out of the tank the purification process automatically starts and refills the storage tank What is the purification rate of my Tata Swach Platina Silver RO Tata Swach Platina Silver RO can purify water upto 12 Itr hr However time taken to purify water depends upon the life of filters the input water pressure TDS and other impurities present in water Which consumables require periodic replacement Consumables such as the two Sediment Filter cartridges Pre and Post GAC cartridges and RO membrane need periodic replacement depending upon the end of life indication service schedule or fault indication as shown on display panel Please note that the life of the consumables is dependent on the input water quality What should do when there is no purified water in the tank In case there is no purified water in the tank you need to first check for any red indication on the Double i Care indicator Please call Tata Swach Toll free number 1800 2 585858 for change of cartridges or any other assistance required How long is the stored water in the Tata Swach Platina Silver RO safe to drink It is advise
11. ervice Provider s Stamp Marketed By Tata Chemicals Ltd TATA PLATINA SILVER RO WATER PURIFIER Contact us Tata Chemicals Ltd Leela Business Park Andheri Kurla Road Andheri E Mumbai 400059 Toll Free Number 1800 2 585858 Email tataswach tatachemicals com Visit www tataswach com
12. mes sealed in a pack and not pre fitted with your system to maximize shelf life Unpack and install the RO membrane 9 6 Plug in the power supply and check for any leakages from any of the connectors or pipes If leakage then refit If there is no leakage close the front cover of the purifier 7 Wait for a few minutes for the system to auto flush and start filling the concealed storage tank 8 Drain out first 15 to 20 liters of purified water from the storage tank Your Tata Swach Platina Silver RO is now ready for use Familiarize your family members with operation and maintenance of the system If away from home If the purifier is not going to be used for more than 2 weeks shut off the system and drain the stored water Also turn off the inlet water adapter valve PA SAFETY INSTRUCTIONS Electrical Safety These safety instructions must be read carefully to ensure your safety and prevent property damage 1 Ensure that the local voltage accords with the system voltage to prevent electric shock or fire 2 Do not use a damaged power cord or plug or a loose outlet Do not unplug by pulling the cord or handle the plug with wet hands This may result in electric shock or fire 4 Do not bundle the power cord tightly together as it may cause damage 5 If the cord or plug is wet unplug the unit and let it dry completely before subsequent use 6 Unplug the unit before repair inspection or replacement to preven
13. nced Snap button fitment Screw less front opening of the purifier makes servicing easy as it avoids dismantling the unit Voltage Spike Guard Protects against power fluctuation As per standard test conditions 10psi input pressure and 750ppm TDS at 25degC 539 DOUBLE i CARE INDICATORS Introduces you to advanced new era of modern amp useful indications in an easy to understand way S N Apolicati Conditi LED Indication O ication ondition System Fault 1 stage choked 000000 1 stage choked 000000 choked Flushing System is flushing power on Gf Green Blinking and every 6 hrs Tank Status Tank Full EM TECHNICAL SPECIFICATIONS Product TATASWACH PLATINA SILVERRO Applications Suitable for purification of tap water Purification ON Tank Filling Pump running RO upto 2000ppm TDS and hardness below 500ppm Purification Capacity Upto 12L hr Wall Mounted Dimensions HxWxD in mm 537 x 420 x 168 Inlet water pressure Minimum 5 psi Maximum 35 psi Inlet water temperature 2 C to 49 C Stages Sediment Pre carbon Sediment RO Post carbon Membrane Type TLC Thin Layer Composite Booster Pump voltage 24V DC Mains voltage 160 270V AC As per standard test conditions 10 psi input pressure 750ppm TDS at 25degC I D GENERAL INSTRUCTIONS While our Service Technicians are trained to follow the installation safety guide it is imperative tha
14. nt and water from reject water pipe is never consumed IND INSTALLATION INSTRUCTIONS PLEASE ENSURE THAT YOUR TATA SWACH PLATINA SILVER RO IS INSTALLED BY A TATA SWACH TECHNICIAN ONLY Pre Installation Requisites i 2 3 4 5 220V single phase AC connection not more than 2m away from the point of installation of purifier The wire length supplied with the system is 2m Raw water supply with gt nipple not more than 3m away Drain for rejected water not more than 3m away Space on the wall as per dimensions of the purifier Wall plane surface for mounting two screws and holding the machine Installation Instructions 1 Turn off the main water supply before accessing the nipple for connecting the ball valve and adaptor Connect the adaptor to the nipple and thread in the ball valve to the adaptor Make sure Teflon tape is applied to arrest any leakages from the threads Connect the ball valve with the pipe provided Remove the front cover of the purifier by pushing the snap button on top Take out both the GAC cartridges one by one and use the pipe attached to the ball valve to flush for 30 sec with water After flushing connect it back in to the system Connect the pipe to the inlet marked on the purifier In case you choose to install additional pre filter available at an additional cost connect the pipe to inlet of this pre filter and connect the outlet of pre filter to inlet of the purifier 100 dry RO membrane co
15. restricted The incoming water line or the ball valve is choked because of debris in the incoming water You can ask your plumber to check if this is the case The temperature of input water might have dipped drastically this will happen rarely The filters may be choked or the membrane needs replacement What should do if the storage tank is not getting filled This might be because of one or more of the following reason Check if the ball valve is kept open Check if the system power is ON Check if any of the indications are blinking RED or solid RED Check for any clogging in the incoming water line A RED indication will be there to show low pressure if this is the case Check for leakages in the purifier and if found call the Tata Swach Toll free number 1800 2 585858 13 ES WARRANTY POLICY Your new Tata Swach Platina Silver RO water purifier is warranted against material defects arising from workmanship for a period of 12 months from the date of invoice by the first end user subject to following conditions 1 During this Warranty period TATA CHEMICALS LTD TCL or its Authorized Service Provider ASP will replace or repair any part ofthe Tata Swach Silver RO water purifier that in the opinion of TCL or its ASP arise due to faulty material or workmanship i e manufacturing defects Consumables like Sediment Filter Carbon Filter and Membrane are input water quality dependent hence not covered under warranty
16. t any damage 7 Do not plug into an outlet or power strip that is being used by several other appliances Use a separate outlet for the unit to prevent fire 8 Shut the main water supply valve and unplug the power cord when not using for a long time 9 Do not attempt to repair the power cord yourself Electric shock or fire may occur as a result 10 10 Remove any dust or water particles on the plug Never use benzene or gasoline to clean the plug Electric shock or fire may occur as a result 11 Do not move the product by pulling the electrical cord 12 Do not clean the system with wet cloth when power is on Use a moist cloth to clean the external surface of the purifier Operation Safety Instructions 1 If water leaks from the product close the ball valve and call the customer service 2 f the unit makes a strange noise or you notice an odd smell unplug immediately and call the customer service 3 Do not place candles cigarettes or any other flammable objects on and around the purifier 4 If you have not consumed water from the Tata Swach Silver RO purifier for more than 2 days drain the water from storage tank and refill for consumption 5 Periodical cartridge replacement is a prerequisite for clean water Use Tata Swach genuine with Tata Swach logo purifier products to maintain expected product lifespan and performance 6 Flushing is necessary after any cartridge replacement Do not expose the unit to dir
17. t you are aware of them 2 MI od 0 g Match the packaging list with the items in the box Always ensure that the Tata Swach Silver RO purifier is installed by a trained technician Tata Swach Silver RO purifier must be wall mounted Do not install the purifier directly above an electric socket Ensure you use the plug provided with the purifier and do not change it unless recommended by Company s service technician The length of the water inlet hose must be shorter than 3 meters to ensure sufficient pressure is available to the machine Always connect only with cold normal water inlet only Do not use with hot water Do not confine water purifier in a cabinet Input water pressure needs to be between 5 PSI and 35 PSI In case it is more than 35 PSI you need to use a pressure reducing valve and in case it is less than 5 PSI you need to use a pressure booster pump Either can be bought from the market or from the Company technician at an additional cost Inlet water TDS should not exceed 2000 ppm Hardness should not exceed 500 ppm Ensure the inlet outlet and drain connections are properly connected and that the drain point is not blocked Avoid sharp bends in the connecting pipes ensuring inlet pipe and reject water pipe has free water flow path 13 14 Avoid direct exposure to sunlight or humidity and ensure sufficient ventilation Ensure waste reject water pipe is connected to a drain poi
Download Pdf Manuals
Related Search